| Common Name: | BIO KLEEN DIESEL FUEL BIOCIDE |
| Manufacturer: | POWER SERVICE PRODUCTS |
| SDS Revision Date: | 5/30/2015 |
| SDS Format: | GHS-US |
| Item Number(s): | 49EP34 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
PS(R*)
POWER SERVICE
POWER SERVICE PRODUCTS, INC.
SAFETY DATA SHEET
| SECTION 1 - IDENTIFICATION |  |
PRODUCT NAME: BIO KLEEN DIESEL FUEL BIOCIDE
UNLESS OTHERWISE NOTED, ALL SECTIONS OF THIS SDS APPLY TO EACH OF THE
FOLLOWING PART NUMBERS.
PART NUMBERS: 9016-06, 9080-06, 9128-04, 9055-01
EPA ESTABLISHMENT NUMBER: 69633-TX-001
EPA REGISTERED PESTICIDE NUMBER: 464-659-69633
COMPANY IDENTIFICATION:
POWER SERVICE PRODUCTS, INC.
P.O. BOX 1089
WEATHERFORD, TX 76086
EMAIL: PSP@POWERSERVICE.COM
PHONE: 800/643-9089 OR 817-599-9486
FAX: 817-599-4893
EMERGENCY PHONE NUMBER:
WITHIN USA: 1-800-424-9300.
OUTSIDE USA: 001-703-527-3887 (CALL COLLECT).
RECOMMENDED USES: DIESEL FUEL ADDITIVE
| SECTION 2 - HAZARD(S) IDENTIFICATION | |
CLASSIFICATION UNDER 29 CFR 1910.1200(D):
(NC=PRODUCT DOES NOT MEET CLASSIFICATION CRITERIA):
HEALTH HAZARD CRITERIA CATEGORY
ACUTE TOXICITY, ORAL 4
ACUTE TOXICITY, DERMAL 3
ACUTE TOXICITY, INHALATION, VAPORS 4
SKIN CORROSION/IRRITATION 2
SERIOUS EYE DAMAGE/EYE IRRITATION 1
RESPIRATORY SENSITIZATION NC
SKIN SENSITIZATION 1
GERM CELL MUTAGENICITY NC
CARCINOGENICITY NC
REPRODUCTIVE TOXICITY NC
SPECIFIC TARGET ORGAN TOXICITY, SINGLE EXPOSURE NC
SPECIFIC TARGET ORGAN TOXICITY, REPEATED OR PROLONGED EXPOSURE NC
ASPIRATION HAZARD NC
PHYSICAL PROPERTIES CRITERIA CATEGORY
EXPLOSIVES NC
FLAMMABLE GASES NC
FLAMMABLE AEROSOLS NC
OXIDIZING GASES NC
GASES UNDER PRESSURE NC
FLAMMABLE LIQUIDS NC
FLAMMABLE SOLIDS NC
SELF-REACTIVE CHEMICALS NC
PYROPHORIC LIQUIDS NC
PYROPHORIC SOLIDS NC
SELF-HEATING CHEMICALS NC
CHEMICALS WHICH, IN CONTACT WITH WATER, EMIT FLAMMABLE GASES NC
OXIDIZING LIQUIDS NC
OXIDIZING SOLIDS NC
ORGANIC PEROXIDES NC
CORROSIVE TO METALS NC
LABEL SIGNAL WORD, HAZARD STATEMENTS, SYMBOLS AND PRECAUTIONARY STATEMENTS
UNDER 29 CFR 1910.1200(F):
PLEASE SEE THE NOTE REGARDING PRODUCT LABELING IN SECTION 16.
SIGNAL WORD: DANGER
HAZARD STATEMENT(S):
COMBUSTIBLE LIQUID. HARMFUL IF SWALLOWED OR IF INHALED. TOXIC IN CONTACT
WITH SKIN. CAUSES SKIN IRRITATION. MAY CAUSE AN ALLERGIC SKIN REACTION.
CAUSES SERIOUS EYE DAMAGE.
SYMBOLS: THE FOLLOWING SYMBOLS ARE FOR ALL TREATMENT RATIOS.
SKULLS AND CROSSBONES
CORROSION
EXCLAMATION MARK
PRECAUTIONARY STATEMENT(S):
PREVENTION:
KEEP AWAY FROM HEAT, SPARKS, OPEN FLAMES AND HOT SURFACES. NO SMOKING.
AVOID BREATHING DUST, FUME, GAS, MIST, VAPORS, AND SPRAY. WASH SKIN
THOROUGHLY AFTER HANDLING. DO NOT EAT, DRINK OR SMOKE WHEN USING THIS
PRODUCT. USE ONLY OUTDOORS OR IN A WELL-VENTILATED AREA. CONTAMINATED WORK
CLOTHING SHOULD NOT BE ALLOWED OUT OF THE WORKPLACE. WEAR PROTECTIVE
GLOVES, EYE AND FACE PROTECTION.
RESPONSE:
IF SWALLOWED:
CALL A POISON CENTER OR DOCTOR/PHYSICIAN IF YOU FEEL UNWELL. RINSE MOUTH.
IF ON SKIN:
WASH WITH PLENTY OF SOAP AND WATER. CALL A POISON CENTER OR
DOCTOR/PHYSICIAN IF YOU FEEL UNWELL.
IF SKIN IRRITATION OCCURS:
GET MEDICAL ADVICE/ATTENTION. REMOVE/TAKE OFF IMMEDIATELY ALL CONTAMINATED
CLOTHING.
IF INHALED:
REMOVE VICTIM TO FRESH AIR AND KEEP AT REST IN A POSITION COMFORTABLE FOR
BREATHING. CALL A POISON CENTER OR DOCTOR/PHYSICIAN IF YOU FEEL UNWELL.
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES, IF
PRESENT AND EASY TO DO. CONTINUE RINSING. IMMEDIATELY CALL A POISON CENTER
OR DOCTOR/PHYSICIAN.
IN CASE OF FIRE:
USE DRY SAND, DRY CHEMICAL OR ALCOHOL-RESISTANT FOAM FOR EXTINCTION.
STORAGE: STORE IN A WELL-VENTILATED PLACE. KEEP COOL. STORE LOCKED UP.
DISPOSAL:
DISPOSE OF CONTENTS/CONTAINER TO AN APPROVED WASTE DISPOSAL PLANT.
HAZARDS NOT OTHERWISE CLASSIFIED: NONE
| SECTION 3 - COMPOSITION / INFORMATION ON INGREDIENTS | |
SYNONYMS: 4-(2-NITROBUTYL) MORPHOLINE.
CHEMICAL NAME CAS NUMBER CONCENTRATION (%)
4-(2-NITROBUTYL) MORPHOLINE 2224-44-4 81.0
METHYLENE DIMORPHOLINE 5625-90-1 5.7
4,4'-(2-ETHYL-2-NITROPROPANE-1,3-DIYL) 1854-23-5 5.0
BISMORPHOLINE
MORPHOLINE 110-91-8 5.0
1-NITROPROPANE 108-03-2 3.3
| SECTION 4 - FIRST AID MEASURES | |
DESCRIPTION OF FIRST AID MEASURES:
EMERGENCY PERSONNEL PROTECTION:
FIRST AID RESPONDERS SHOULD PAY ATTENTION TO SELF-PROTECTION AND USE THE
RECOMMENDED PROTECTIVE CLOTHING (CHEMICAL RESISTANT GLOVES, SPLASH
PROTECTION). IF POTENTIAL FOR EXPOSURE EXISTS REFER TO SECTION 8 FOR
SPECIFIC PERSONAL PROTECTIVE EQUIPMENT.
EYE CONTACT:
WASH IMMEDIATELY AND CONTINUOUSLY WITH FLOWING WATER FOR AT LEAST
30 MINUTES. REMOVE CONTACT LENSES AFTER FIRST 5 MINUTES AND CONTINUE
WASHING. OBTAIN PROMPT MEDICAL CONSULTATION, PREFERABLY FROM AN
OPHTHALMOLOGIST. SUITABLE EMERGENCY EYE WASH FACILITY SHOULD BE IMMEDIATELY
AVAILABLE.
SKIN CONTACT:
TAKE OFF CONTAMINATED CLOTHING. WASH SKIN WITH SOAP AND PLENTY OF WATER
FOR 15-20 MINUTES. CALL A POISON CONTROL CENTER OR DOCTOR FOR TREATMENT
ADVICE. WASH CLOTHING BEFORE REUSE. SHOES AND OTHER LEATHER ITEMS WHICH
CANNOT BE DECONTAMINATED SHOULD BE DISPOSED OF PROPERLY. SUITABLE EMERGENCY
SAFETY SHOWER FACILITY SHOULD BE IMMEDIATELY AVAILABLE.
INHALATION:
MOVE PERSON TO FRESH AIR. IF PERSON IS NOT BREATHING, CALL AN EMERGENCY
RESPONDER OR AMBULANCE, THEN GIVE ARTIFICIAL RESPIRATION; IF BY MOUTH TO
MOUTH USE RESCUER PROTECTION (POCKET MASK ETC.). CALL A POISON CONTROL
CENTER OR DOCTOR FOR TREATMENT ADVICE.
INGESTION:
CALL A POISON CONTROL CENTER OR DOCTOR IMMEDIATELY FOR TREATMENT ADVICE.
HAVE PERSON SIP A GLASS OF WATER IF ABLE TO SWALLOW. DO NOT INDUCE VOMITING
UNLESS TOLD TO DO SO BY THE POISON CONTROL CENTER OR DOCTOR. NEVER GIVE
ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
MOST IMPORTANT SYMPTOMS AND EFFECTS, BOTH ACUTE AND DELAYED:
ASIDE FROM THE INFORMATION FOUND UNDER DESCRIPTION OF FIRST AID MEASURES
(ABOVE) AND INDICATION OF IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT
(BELOW), ANY ADDITIONAL IMPORTANT SYMPTOMS AND EFFECTS ARE DESCRIBED IN
SECTION 11: TOXICOLOGY INFORMATION.
INDICATION OF IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED:
NOTES TO PHYSICIAN:
CHEMICAL EYE BURNS MAY REQUIRE EXTENDED IRRIGATION. OBTAIN PROMPT
CONSULTATION, PREFERABLY FROM AN OPHTHALMOLOGIST. PROBABLE MUCOSAL DAMAGE
MAY CONTRAINDICATE THE USE OF GASTRIC LAVAGE. IF BURN IS PRESENT, TREAT AS
ANY THERMAL BURN, AFTER DECONTAMINATION. DUE TO IRRITANT PROPERTIES,
SWALLOWING MAY RESULT IN BURNS/ULCERATION OF MOUTH, STOMACH AND LOWER
GASTROINTESTINAL TRACT WITH SUBSEQUENT STRICTURE. ASPIRATION OF VOMITUS
MAY CAUSE LUNG INJURY. SUGGEST ENDOTRACHEAL/ESOPHAGEAL CONTROL IF LAVAGE
IS DONE. NO SPECIFIC ANTIDOTE. TREATMENT OF EXPOSURE SHOULD BE DIRECTED AT
THE CONTROL OF SYMPTOMS AND THE CLINICAL CONDITION OF THE PATIENT. HAVE THE
SAFETY DATA SHEET, AND IF AVAILABLE, THE PRODUCT CONTAINER OR LABEL WITH
YOU WHEN CALLING A POISON CONTROL CENTER OR DOCTOR, OR GOING FOR TREATMENT.
| SECTION 5 - FIRE FIGHTING MEASURES | |
SUITABLE EXTINGUISHING MEDIA:
WATER FOG OR FINE SPRAY. DRY CHEMICAL FIRE EXTINGUISHERS. CARBON DIOXIDE
FIRE EXTINGUISHERS. FOAM. ALCOHOL RESISTANT FOAMS (ATC TYPE) ARE PREFERRED.
GENERAL PURPOSE SYNTHETIC FOAMS (INCLUDING AFFF) OR PROTEIN FOAMS MAY
FUNCTION, BUT WILL BE LESS EFFECTIVE. WATER FOG, APPLIED GENTLY MAY BE
USED AS A BLANKET FOR FIRE EXTINGUISHMENT.
UNSUITABLE EXTINGUISHING MEDIA: NO DATA AVAILABLE.
SPECIAL HAZARDS ARISING FROM THE SUBSTANCE OR MIXTURE:
HAZARDOUS COMBUSTION PRODUCTS:
DURING A FIRE, SMOKE MAY CONTAIN THE ORIGINAL MATERIAL IN ADDITION TO
COMBUSTION PRODUCTS OF VARYING COMPOSITION WHICH MAY BE TOXIC AND/OR
IRRITATING.
COMBUSTION PRODUCTS MAY INCLUDE AND ARE NOT LIMITED TO:
NITROGEN OXIDES. CARBON MONOXIDE. CARBON DIOXIDE.
UNUSUAL FIRE AND EXPLOSION HAZARDS:
CONTAINER MAY RUPTURE FROM GAS GENERATION IN A FIRE SITUATION. VIOLENT
STEAM GENERATION OR ERUPTION MAY OCCUR UPON APPLICATION OF DIRECT WATER
STREAM TO HOT LIQUIDS.
ADVICE FOR FIREFIGHTERS:
FIRE FIGHTING PROCEDURES:
KEEP PEOPLE AWAY. ISOLATE FIRE AND DENY UNNECESSARY ENTRY. USE WATER SPRAY
TO COOL FIRE EXPOSED CONTAINERS AND FIRE AFFECTED ZONE UNTIL FIRE IS OUT
AND DANGER OF REIGNITION HAS PASSED. FIGHT FIRE FROM PROTECTED LOCATION OR
SAFE DISTANCE. CONSIDER THE USE OF UNMANNED HOSE HOLDERS OR MONITOR
NOZZLES. IMMEDIATELY WITHDRAW ALL PERSONNEL FROM THE AREA IN CASE OF RISING
SOUND FROM VENTING SAFETY DEVICE OR DISCOLORATION OF THE CONTAINER. DO NOT
USE DIRECT WATER STREAM. MAY SPREAD FIRE. MOVE CONTAINER FROM FIRE AREA IF
THIS IS POSSIBLE WITHOUT HAZARD. BURNING LIQUIDS MAY BE MOVED BY FLUSHING
WITH WATER TO PROTECT PERSONNEL AND MINIMIZE PROPERTY DAMAGE. WATER FOG,
APPLIED GENTLY MAY BE USED AS A BLANKET FOR FIRE EXTINGUISHMENT. CONTAIN
FIRE WATER RUN-OFF IF POSSIBLE. FIRE WATER RUN-OFF, IF NOT CONTAINED, MAY
CAUSE ENVIRONMENTAL DAMAGE. REVIEW THE "ACCIDENTAL RELEASE MEASURES" AND
THE "ECOLOGICAL INFORMATION" SECTIONS OF THIS (M)SDS.
SPECIAL PROTECTIVE EQUIPMENT FOR FIREFIGHTERS:
WEAR POSITIVE-PRESSURE SELF-CONTAINED BREATHING APPARATUS (SCBA) AND
PROTECTIVE FIREFIGHTING CLOTHING (INCLUDES FIREFIGHTING HELMET, COAT,
TROUSERS, BOOTS, AND GLOVES). AVOID CONTACT WITH THIS MATERIAL DURING
FIREFIGHTING OPERATIONS. IF CONTACT IS LIKELY, CHANGE TO FULL CHEMICAL
RESISTANT FIREFIGHTING CLOTHING WITH SELF-CONTAINED BREATHING APPARATUS.
IF THIS IS NOT AVAILABLE, WEAR FULL CHEMICAL RESISTANT CLOTHING WITH
SELF-CONTAINED BREATHING APPARATUS AND FIGHT FIRE FROM A REMOTE LOCATION.
FOR PROTECTIVE EQUIPMENT IN POST-FIRE OR NON-FIRE CLEAN-UP SITUATIONS,
REFER TO THE RELEVANT SECTIONS.
| SECTION 6 - ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT, AND EMERGENCY PROCEDURES:
EVACUATE AREA. REFER TO SECTION 7, HANDLING AND STORAGE, FOR ADDITIONAL
PRECAUTIONARY MEASURES. ONLY TRAINED AND PROPERLY PROTECTED PERSONNEL MUST
BE INVOLVED IN CLEAN-UP OPERATIONS. KEEP UPWIND OF SPILL. VENTILATE AREA OF
LEAK OR SPILL. NO SMOKING IN AREA. USE APPROPRIATE SAFETY EQUIPMENT. FOR
ADDITIONAL INFORMATION, REFER TO SECTION 8, EXPOSURE CONTROLS / PERSONAL
PROTECTION.
ENVIRONMENTAL PRECAUTIONS:
PREVENT FROM ENTERING INTO SOIL, DITCHES, SEWERS, WATERWAYS AND/OR
GROUNDWATER. SEE SECTION 12, ECOLOGICAL INFORMATION. SPILLS OR DISCHARGE
TO NATURAL WATERWAYS IS LIKELY TO KILL AQUATIC ORGANISMS.
METHODS AND MATERIALS FOR CONTAINMENT AND CLEANING UP:
CONTAIN SPILLED MATERIAL IF POSSIBLE. COLLECT IN SUITABLE AND PROPERLY
LABELED CONTAINERS. SEE SECTION 13, DISPOSAL CONSIDERATIONS, FOR ADDITIONAL
INFORMATION.
| SECTION 7 - HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING:
KEEP OUT OF REACH OF CHILDREN. KEEP AWAY FROM HEAT, SPARKS AND FLAME. DO
NOT GET IN EYES. AVOID BREATHING VAPOR. AVOID CONTACT WITH SKIN AND
CLOTHING. AVOID PROLONGED OR REPEATED CONTACT WITH SKIN. DO NOT SWALLOW.
WASH THOROUGHLY AFTER HANDLING. KEEP CONTAINER CLOSED. USE WITH ADEQUATE
VENTILATION. SEE SECTION 8, EXPOSURE CONTROLS / PERSONAL PROTECTION.
CONTAINERS, EVEN THOSE THAT HAVE BEEN EMPTIED, CAN CONTAIN VAPORS. DO NOT
CUT, DRILL, GRIND, WELD, OR PERFORM SIMILAR OPERATIONS ON OR NEAR EMPTY
CONTAINERS.
CONDITIONS FOR SAFE STORAGE:
AVOID TEMPERATURES ABOVE 100 DEG. C (212 DEG. F).
STORE AWAY FROM INCOMPATIBLE MATERIALS. SEE STABILITY AND REACTIVITY
SECTION.
STORAGE STABILITY:
SHELF LIFE: USE WITHIN 12 MONTHS.
| SECTION 8 - EXPOSURE CONTROLS / PERSONAL PROTECTION | |
CONTROL PARAMETERS: EXPOSURE LIMITS ARE LISTED BELOW, IF THEY EXIST.
COMPONENT REGULATION TYPE OF LISTING VALUE/NOTATION
MORPHOLINE ACGIH TWA 20 PPM
(ABSORBED VIA SKIN)
OSHA TABLE Z-1 TWA 70 MG/M3 20 PPM
(ABSORBED VIA SKIN)
1-NITROPROPANE ACGIH TWA 25 PPM
OSHA TABLE Z-1 TWA 90 MG/M3 25 PPM
EXPOSURE CONTROLS:
ENGINEERING CONTROLS:
USE LOCAL EXHAUST VENTILATION, OR OTHER ENGINEERING CONTROLS TO MAINTAIN
AIRBORNE LEVELS BELOW EXPOSURE LIMIT REQUIREMENTS OR GUIDELINES. IF THERE
ARE NO APPLICABLE EXPOSURE LIMIT REQUIREMENTS OR GUIDELINES, GENERAL
VENTILATION SHOULD BE SUFFICIENT FOR MOST OPERATIONS. LOCAL EXHAUST
VENTILATION MAY BE NECESSARY FOR SOME OPERATIONS.
INDIVIDUAL PROTECTION MEASURES:
EYES / FACE PROTECTION: USE CHEMICAL GOGGLES.
SKIN PROTECTION:
HAND PROTECTION: USE GLOVES CHEMICALLY RESISTANT TO THIS MATERIAL.
EXAMPLES OF PREFERRED GLOVE BARRIER MATERIALS INCLUDE:
CHLORINATED POLYETHYLENE. POLYETHYLENE. ETHYL VINYL ALCOHOL LAMINATE
("EVAL").
EXAMPLES OF ACCEPTABLE GLOVE BARRIER MATERIALS INCLUDE:
BUTYL RUBBER. NATURAL RUBBER ("LATEX"). NEOPRENE. NITRILE/BUTADIENE RUBBER
("NITRILE" OR "NBR"). POLYVINYL ALCOHOL ("PVA"). POLYVINYL CHLORIDE
("PVC" OR "VINYL"). VITON.
NOTICE:
THE SELECTION OF A SPECIFIC GLOVE FOR A PARTICULAR APPLICATION AND DURATION
OF USE IN A WORKPLACE SHOULD ALSO TAKE INTO ACCOUNT ALL RELEVANT WORKPLACE
FACTORS SUCH AS, BUT NOT LIMITED TO:
OTHER CHEMICALS WHICH MAY BE HANDLED, PHYSICAL REQUIREMENTS (CUT/PUNCTURE
PROTECTION, DEXTERITY, THERMAL PROTECTION), POTENTIAL BODY REACTIONS TO
GLOVE MATERIALS, AS WELL AS THE INSTRUCTIONS/SPECIFICATIONS PROVIDED BY THE
GLOVE SUPPLIER.
OTHER PROTECTION:
USE PROTECTIVE CLOTHING CHEMICALLY RESISTANT TO THIS MATERIAL. SELECTION
OF SPECIFIC ITEMS SUCH AS FACE SHIELD, BOOTS, APRON, OR FULL BODY SUIT
WILL DEPEND ON THE TASK.
RESPIRATORY PROTECTION:
RESPIRATORY PROTECTION SHOULD BE WORN WHEN THERE IS A POTENTIAL TO EXCEED
THE EXPOSURE LIMIT REQUIREMENTS OR GUIDELINES. IF THERE ARE NO APPLICABLE
EXPOSURE LIMIT REQUIREMENTS OR GUIDELINES, WEAR RESPIRATORY PROTECTION WHEN
ADVERSE EFFECTS, SUCH AS RESPIRATORY IRRITATION OR DISCOMFORT HAVE BEEN
EXPERIENCED, OR WHERE INDICATED BY YOUR RISK ASSESSMENT PROCESS. FOR MOST
CONDITIONS, NO RESPIRATORY PROTECTION SHOULD BE NEEDED; HOWEVER, IF
MATERIAL IS HEATED OR SPRAYED, USE AN APPROVED AIR-PURIFYING RESPIRATOR.
THE FOLLOWING SHOULD BE EFFECTIVE TYPES OF AIR-PURIFYING RESPIRATORS:
ORGANIC VAPOR CARTRIDGE WITH A PARTICULATE PRE-FILTER.
| SECTION 9 - PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE: LIQUID, YELLOW TO BROWN COLOR
ODOR: AMINE
ODOR THRESHOLD: NOT AVAILABLE
PH: 9.5 - 10.0 (ASTEM E70)
MELTING POINT: NOT AVAILABLE
FREEZING POINT: 50.9 DEG. F (10.5 DEG. C) LITERATURE
BOILING POINT (760 MMHg): 346.8 DEG. F (174.9 DEG. C) ASTM D1120
FLASH POINT: 160 DEG. F (>/-71 DEG. C) PENSKY-MARTENS CLOSED CUP ASTM D93
EVAPORATION RATE: NOT AVAILABLE
FLAMMABILITY (SOLID, GAS): NOT AVAILABLE
UPPER. LOWER FLAMMABILITY OR EXPLOSIVE LIMITS: NOT AVAILABLE
VAPOR PRESSURE: 1.04 HPA AT 77 DEG. F (25 DEG. C) EC METHOD A4
VAPOR DENSITY (AIR = 1): NOT AVAILABLE
RELATIVE DENSITY (WATER = 1): 1.1 AT 77 DEG. F (25 DEG. C) ASTM D891
WATER SOLUBILITY: 3.1% AT 77 DEG. F (25 DEG. C) EC METHOD A6
PARTITION COEFFICIENT; N-OCTANOL / WATER: NOT AVAILABLE
AUTO-IGNITION TEMPERATURE: 500 DEG. F (260 DEG. C) EC METHOD A15
DECOMPOSITION TEMPERATURE: NOT AVAILABLE
DYNAMIC VISCOSITY:
18.2 MPA.S AT 68 DEG. F (20 DEG. C) OECD 114 (BROOKFIELD VISCOSITY-@
100 RPM, #0 SPINDLE) 7.7 MPA.S AT 104 DEG. F (40 DEG. C) OECD
114 (BROOKFIELD VISCOCITY - @ 100 RPM, #0 SPINDLE)
KINEMATIC VISCOSITY:
16.55 CST AT 68 DEG. F (20 DEG. C) CALCULATED. 7.0 CST AT 104 DEG. F
(40 DEG. C) CALCULATED
EXPLOSIVE PROPERTIES: NOT EXPLOSIVE
OXIDIZING PROPERTIES: NO
MOLECULAR WEIGHT: 188.2 G/MOL CALCULATED
NOTE:
THE PHYSICAL DATA PRESENTED ABOVE ARE TYPICAL VALUES AND SHOULD NOT BE
CONSTRUED AS A SPECIFICATION.
| SECTION 10 - STABILITY AND REACTIVITY | |
REACTIVITY: NO DANGEROUS REACTION KNOWN UNDER CONDITIONS OF NORMAL USE.
CHEMICAL STABILITY:
STABLE UNDER RECOMMENDED STORAGE CONDITIONS. SEE STORAGE, SECTION 7.
UNSTABLE AT ELEVATED TEMPERATURES.
POSSIBILITY OF HAZARDOUS REACTIONS: POLYMERIZATION WILL NOT OCCUR.
CONDITIONS TO AVOID:
CAN CRYSTALLIZE. DISSOLVE CRYSTALS BEFORE USE BY WARMING AND MIXING. AVOID
TEMPERATURES ABOVE 95 DEG. F (35 DEG. C.) AND BELOW 50 DEG. F (10 DEG. C.).
POTENTIALLY VIOLENT DECOMPOSITION CAN OCCUR ABOVE 212 DEG. F.
(100 DEG. C.). GENERATION OF GAS DURING DECOMPOSITION CAN CAUSE PRESSURE
IN CLOSED SYSTEMS. PRESSURE BUILD-UP CAN BE RAPID.
INCOMPATIBLE MATERIALS: AVOID CONTACT WITH OXIDIZING MATERIALS.
AVOID CONTACT WITH:
ACIDIC PH. ACIDS. REACTION WITH ACID CAN GENERATE FLAMMABLE FORMALDEHYDE
GAS.
HAZARDOUS DECOMPOSITION PRODUCTS:
DECOMPOSITION PRODUCTS DEPEND UPON TEMPERATURE, AIR SUPPLY AND THE
PRESENCE OF OTHER MATERIALS. TOXIC FLAMMABLE GASES CAN BE RELEASED DURING
DECOMPOSITION.
| SECTION 11 - TOXICOLOGICAL INFORMATION | |
TOXICOLOGICAL INFORMATION ON THIS PRODUCT OR ITS COMPONENTS APPEAR IN THIS
SECTION WHEN SUCH DATA ARE AVAILABLE.
ACUTE TOXICITY:
ACUTE ORAL TOXICITY:
LOW TOXICITY IF SWALLOWED. SMALL AMOUNTS SWALLOWED INCIDENTALLY AS A RESULT
OF NORMAL HANDLING OPERATIONS ARE NOT LIKELY TO CAUSE INJURY; HOWEVER,
SWALLOWING LARGER AMOUNTS MAY CAUSE INJURY.
LD50, RAT: 620 MG/KG
ACUTE DERMAL TOXICITY:
PROLONGED OR WIDESPREAD SKIN CONTACT MAY RESULT IN ABSORPTION OF HARMFUL
AMOUNTS.
LD50, RABBIT: 420 MG/KG
ACUTE INHALATION TOXICITY:
VAPOR FROM HEATED MATERIAL OR MIST MAY CAUSE RESPIRATORY IRRITATION.
FOR NARCOTIC EFFECTS: NO SPECIFIC, RELEVANT DATA AVAILABLE FOR ASSESSMENT.
MAXIMUM ACHIEVABLE CONCENTRATION. LC50, 4 H, AEROSOL, RAT: >2.33 MG/L
SKIN CORROSION/IRRITATION:
BRIEF CONTACT MAY CAUSE SEVERE SKIN IRRITATION WITH PAIN AND LOCAL REDNESS.
REPEATED CONTACT MAY CAUSE SKIN BURNS. SYMPTOMS MAY INCLUDE PAIN, SEVERE
LOCAL REDNESS, SWELLING, AND TISSUE DAMAGE.
SERIOUS EYE DAMAGE/EYE IRRITATION:
MAY CAUSE SEVERE IRRITATION WITH CORNEAL INJURY WHICH MAY RESULT IN
PERMANENT IMPAIRMENT OF VISION, EVEN BLINDNESS. CHEMICAL BURNS MAY OCCUR.
MIST MAY CAUSE SEVERE EYE IRRITATION AND CORNEAL INJURY.
SENSITIZATION:
SKIN: SKIN CONTACT MAY CAUSE AN ALLERGIC SKIN REACTION.
RESPIRATORY: NO RELEVANT DATA FOUND.
SPECIFIC TARGET ORGAN SYSTEMIC TOXICITY (SINGLE EXPOSURE):
EVALUATION OF AVAILABLE DATA SUGGESTS THAT THIS MATERIAL IS NOT AN STOT-SE
TOXICANT.
SPECIFIC TARGET ORGAN SYSTEMIC TOXICITY (REPEATED EXPOSURE):
REPEATED EXPOSURE DID NOT PRODUCE SYSTEMIC TOXICITY WHEN APPLIED TO THE
SKIN OF RABBITS. REPEATED EXPOSURE DID NOT PRODUCE SYSTEMIC TOXICITY WHEN
APPLIED TO THE SKIN OF RATS. BASED ON AVAILABLE DATA, REPEATED EXPOSURES
ARE NOT ANTICIPATED TO CAUSE SIGNIFICANT ADVERSE EFFECTS.
CARCINOGENICITY: NO RELEVANT DATA FOUND.
TERATOGENICITY:
HAS BEEN TOXIC TO THE FETUS IN LABORATORY ANIMALS AT DOSES TOXIC TO THE
MOTHER. DID NOT CAUSE BIRTH DEFECTS IN LABORATORY ANIMALS.
REPRODUCTIVE TOXICITY:
IN ANIMAL STUDIES, DID NOT INTERFERE WITH REPRODUCTION. IN ANIMAL STUDIES,
DID NOT INTERFERE WITH FERTILITY.
MUTAGENICITY:
IN VITRO GENETIC TOXICITY STUDIES WERE NEGATIVE IN SOME CASES AND POSITIVE
IN OTHER CASES. ANIMAL GENETIC TOXICITY STUDIES WERE NEGATIVE.
ASPIRATION HAZARD: MAY BE HARMFUL IF SWALLOWED AND ENTERS AIRWAYS.
| SECTION 12 - ECOLOGICAL INFORMATION | |
ECOTOXICOLOGICAL INFORMATION ON THIS PRODUCT OR ITS COMPONENTS APPEAR IN
THIS SECTION WHEN SUCH DATA ARE AVAILABLE.
TOXICITY:
ACUTE TOXICITY TO FISH:
MATERIAL IS HIGHLY TOXIC TO AQUATIC ORGANISMS ON AN ACUTE BASIS
(LC50 / EC50 BETWEEN 0.1 AND 1 MG/L IN MOST SENSITIVE SPECIES TESTED).
LC50, ONCORHYNCHUS MYKISS (RAINBOW TROUT), FLOW-THROUGH, 96 H:
2.3 MG/L, OECD TEST GUIDELINE 203 OR EQUIVALENT
LC50, LEPOMIS MACROCHIRUS (BLUEGILL SUNFISH), SEMI-STATIC TEST, 96 H:
1.3 MG/L, OECD TEST GUIDELINE 203 OR EQUIVALENT
LC50, ONCORHYNCHUS MYKISS (RAINBOW TROUT), SEMI-STATIC TEST, 96 H:
1.1 MG/L, OECD TEST GUIDELINE 203 OR EQUIVALENT
ACUTE TOXICITY TO AQUATIC INVERTEBRATES:
EC50, DAPHNIA MAGNA (WATER FLEA), FLOW-THROUGH TEST, 48 H:
3.23 MG/L, OECD TEST GUIDELINE 202 OR EQUIVALENT
NOEC, DAHNIA MAGNA (WATER FLEA), FLOW-THROUGH TEST, 48 H:
1.77 MG/L, OECD TEST GUIDELINE 202 OR EQUIVALENT
EC50, DAPHNIA MAGNA (WATER FLEA), STATIC TEST, 48 H:
1.9 MG/L, OECD TEST GUIDELINE 202 OR EQUIVALENT
LC50, PINK SHRIMP (PENAEUS DUORARUM), SEMI-STATIC TEST, 96 H: 2.2 MG/L
ACUTE TOXICITY TO ALGAE/AQUATIC PLANTS:
EC50, PSEUDOKIRCHNERIELLA SUBCAPITATA (GREEN ALGA), BIOMASS GROWTH
INHIBITION, 96 H: 0.844 MG/L, OECD TEST GUIDELINE 201 OR EQUIVALENT
TOXICITY TO ABOVE GROUND ORGANISMS:
MATERIAL IS PRACTICALLY NON-TOXIC TO BIRDS ON AN ACUTE BASIS
(LD50 >2000 MG/KG).
MATERIAL IS PRACTICALLY NON-TOXIC TO BIRDS ON A DIETARY BASIS
(LC50 >5000 PPM).
ORAL LD50, ANAS PLATYRHYNCHOS (MALLARD DUCK): 2,695 MG/KG
DIETARY LC50, COLINUS VIRGINIANUS (BOBWHITE QUAIL): >5,620 PPM
DIETARY LC50, ANAS PLATYRHYNCHOS (MALLARD DUCK): >5,620 PPM
PERSISTENCE AND DEGRADABILITY:
ABIOTIC DEGRADATION: THE MATERIAL IS RAPIDLY DEGRADABLE BY ABIOTIC MEANS.
OECD BIODEGRADATION TESTS:
BIODEGRADATION EXPOSURE TIME METHOD 10 DAY WINDOW
11.9-27.2% 28 D OCED 301B TEST OR EQUIVALENT FAIL
BIOACCUMULATIVE POTENTIAL: NO DATA AVAILABLE FOR THIS PRODUCT.
BASED ON INFORMATION FOR COMPONENT(S):
BIOCONCENTRATION POTENTIAL IS LOW (BCF <100 OR LOG POW <3).
MOBILITY IN SOIL:
BASED ON INFORMATION FOR COMPONENT(S):
POTENTIAL FOR MOBILITY IN SOIL IS HIGH (KOC BETWEEN 50 AND 150).
PARTITION COEFFICIENT, SOIL ORGANIC CARBON/WATER (KOC): 50 ESTIMATED.
| SECTION 13 - DISPOSAL CONSIDERATIONS | |
DO NOT DUMP INTO ANY SEWERS, ON THE GROUND, OR INTO ANY BODY OF WATER. ALL
DISPOSAL PRACTICES MUST BE IN COMPLIANCE WITH ALL FEDERAL, STATE/PROVINCIAL
AND LOCAL LAWS AND REGULATIONS. REGULATIONS MAY VARY IN DIFFERENT
LOCATIONS. WASTE CHARACTERIZATIONS AND COMPLIANCE WITH APPLICABLE LAWS ARE
THE RESPONSIBILITY SOLELY OF THE WASTE GENERATOR. POWER SERVICE PRODUCTS
HAS NO CONTROL OVER THE MANAGEMENT PRACTICES OF THE PARTIES HANDLING OR
USING THIS MATERIAL. THE INFORMATION PRESENTED HERE PERTAINS ONLY TO THE
PRODUCT AS SHIPPED IN ITS INTENDED CONDITION AS DESCRIBED IN SDS SECTION
COMPOSITION INFORMATION. FOR UNUSED & UNCOMTAMINATED PRODUCTS, THE
PREFERRED OPTION IS TO CONTACT YOUR STATE PESTICIDE OR ENVIRONMENTAL
CONTROL AGENCY, OR THE HAZARDOUS WASTE REPRESENTATIVE AT THE NEAREST EPA
REGIONAL OFFICE FOR GUIDANCE. THE PREFERRED OPTION IN OTHER JURISDICTIONS
IS TO CONTACT THE REGULATORY AUTHORITY FOR THIS PRODUCT FOR GUIDANCE.
INCINERATOR OR OTHER THERMAL DESTRUCTION DEVICE.
STATE OR LOCAL LAWS MAY IMPOSE ADDITIONAL REGULATORY REQUIREMENTS REGARDING
DISPOSAL.
EMPTY CONTAINER WARNING:
EMPTY CONTAINERS MAY CONTAIN RESIDUE AND CAN BE DANGEROUS. SEE SECTION 5
FOR FIRE FIGHTING MEASURES.
| SECTION 14 - TRANSPORTATION INFORMATION | |
THE FOLLOWING PART NUMBERS ARE CONSUMER COMMODITIES AND ARE NOT REGULATED
BY DOT: 9016-06, 9080-06, 9128-04
THE FOLLOWING PART NUMBER IS REGULATED BY DOT: 9055-01
PROPER SHIPPING NAME:
DISINFECTANT, LIQUID, TOXIC, N.O.S., (4-(2-NITROBUTYL)MORPHOLINE)
HAZARD CLASS: 6.1
I.D. NUMBER: UN 3142
PACKING GROUP: III
PLACARDING: TOXIC
MARINE POLLUTANT:
THIS INFORMATION IS NOT INTENDED TO CONVEY ALL SPECIFIC REGULATORY OR
OPERATIONAL REQUIREMENTS/INFORMATION RELATING TO THIS PRODUCT. IT IS THE
RESPONSIBILITY OF THE TRANSPORTING ORGANIZATION TO FOLLOW ALL APPLICABLE
LAWS, REGULATIONS AND RULES RELATING TO THE TRANSPORTATION OF THE MATERIAL.
| SECTION 15 - REGULATORY INFORMATION | |
THIS PRODUCT IS A "HAZARDOUS CHEMICAL" AS DEFINED BY THE OSHA HAZARD
COMMUNICATION STANDARD, 29 CFR 1910.1200.
TSCA STATUS:
THIS PRODUCT CONTAINS CHEMICAL SUBSTANCE(S) EXEMPT FROM U.S. EPA TSCA
INVENTORY REQUIREMENTS. IT IS REGULATED AS A PESTICIDE SUBJECT TO THE
FEDERAL INSECTICIDE, FUNGICIDE, AND RODENTICIDE ACT (FIFRA) REQUIREMENTS.
EPA SARA TITLE III CHEMICAL LISTINGS:
SECTION 302 EXTREMELY HAZARDOUS SUBSTANCES:
TO THE BEST OF OUR KNOWLEDGE, THIS PRODUCT DOES NOT CONTAIN CHEMICALS AT
LEVELS WHICH REQUIRE REPORTING UNDER THIS STATUTE.
SECTIONS 311/312 HAZARD CLASS:
IMMEDIATE (ACUTE) HEALTH HAZARD: YES
DELAYED (CHRONIC) HEALTH HAZARD: NO
FIRE HAZARD: YES
REACTIVE HAZARD: NO
SUDDEN RELEASE OF PRESSURE HAZARD: NO
SECTION 313:
THIS MATERIAL DOES NOT CONTAIN ANY CHEMICAL COMPONENTS WITH KNOWN CAS
NUMBERS THAT EXCEED THE THRESHOLD (DE MINIMIS) REPORTING LEVELS ESTABLISHED
BY SARA TITLE III, SECTION 313.
EPA CERCLA:
SECTION 103:
TO THE BEST OF OUR KNOWLEDGE, THIS PRODUCT DOES NOT CONTAIN CHEMICALS
AT LEVELS WHICH REQUIRE REPORTING UNDER THIS STATUTE.
PENNSYLVANIA (WORKER AND COMMUNITY RIGHT-TO-KNOW ACT):
THE FOLLOWING CHEMICAL ARE LISTED BECAUSE OF THE ADDITIONAL REQUIREMENTS
OF PENNSYLVANIA LAW
COMPONENT CAS#
1-NITROPROPANE 108-03-2
MORPHOLINE 110-91-8
CALIFORNIA PROPOSITION 65 (SAFE DRINKING WATER AND TOXIC ENFORCEMENT ACT
OF 1986):
THIS PRODUCT CONTAINS NO LISTED SUBSTANCES KNOWN TO THE STATE OF CALIFORNIA
TO CAUSE CANCER, BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM, AT LEVELS WHICH
WOULD REQUIRE A WARNING UNDER THE STATUTE.
FEDERAL INSECTICIDE, FUNGICIDE AND RODENTICIDE ACT (FIFRA):
EPA REGISTRATION NUMBER: 464-659
THIS CHEMICAL IS A PESTICIDE PRODUCT REGISTERED BY THE ENVIRONMENTAL
PROTECTION AGENCY AND IS SUBJECT TO CERTAIN LABELING REQUIREMENTS UNDER
FEDERAL PESTICIDE LAW. THESE REQUIREMENTS DIFFER FROM THE CLASSIFICATION
CRITERIA AND HAZARD INFORMATION REQUIRED FOR SAFETY DATA SHEETS, AND FOR
WORKPLACE LABELS OF NON-PESTICIDE CHEMICALS.
FOLLOWING IS THE HAZARD INFORMATION AS REQUIRED ON THE PESTICIDE LABEL:
DANGER
CORROSIVE
CAUSES IRREVERSIBLE EYE DAMAGE
HARMFUL IF SWALLOWED
HARMFUL IF ABSORBED THROUGH SKIN
PROLONGED OR FREQUENTLY REPEATED SKIN CONTACT MAY CAUSE ALLERGIC REACTIONS
IN SOME INDIVIDUALS.
THIS PESTICIDE IS TOXIC TO FISH AND AQUATIC ORGANISMS.
| SECTION 16 - OTHER INFORMATION | |
DATE OF PREPARATION / REVISION: MAY 30, 2015.
NOTE REGARDING PRODUCT LABELING:
THE OSHA HAZARD COMMUNICATION STANDARD APPLIES TO HAZARDOUS CHEMICALS KNOWN
TO BE PRESENT IN THE WORKPLACE. HOWEVER, THE LABELING REQUIREMENTS DO NOT
APPLY TO PRODUCT REGULATED BY THE FEDERAL INSECTICIDE, FUNGICIDE, AND
RODENTICIDE ACT (FIFRA), SUCH AS BIOKLEEN PRODUCED BY POWER SERVICE
PRODUCTS. THE LABEL FOR THE BIOKLEEN PRODUCTS REQUIRED UNDER FEDERAL
PESTICIDE LAW DIFFERS FROM THE CLASSIFICATION CRITERIA AND HAZARD
INFORMATION REQUIRED BY OSHA. PLEASE SEE SECTION 15.
THE INFORMATION CONTAINED HEREIN IS OFFERED IN GOOD FAITH AND IS BELIEVED
TO BE ACCURATE BASED ON THE DATA AVAILABLE TO US AS OF THE DATE OF SDS
PREPARATION. THE INFORMATION IN THIS DOCUMENT APPLIES TO THIS SPECIFIC
PRODUCT AS SUPPLIED. IT MAY NOT BE APPROPRIATE FOR THIS PRODUCT IF THE
PRODUCT IS USED IN COMBINATION WITH OTHER MATERIALS. THE INFORMATION IN
THIS DOCUMENT IS NOT INTENDED TO CONSTITUTE PRODUCT PERFORMANCE
INFORMATION. SOME OF THE INFORMATION PRESENTED AND CONCLUSIONS DRAWN HEREIN
ARE FROM SOURCES OTHER THAN DIRECT TEST DATA ON THE PRODUCT. NO STATEMENT
SHALL BE CONSTRUED AS AN ENDORSEMENT OF ANY PRODUCT OR PROCESS. THE
RECOMMENDED INDUSTRIAL HYGIENE AND SAFE HANDLING PROCEDURES ARE BELIEVED
TO BE VALID IN THE CONTEXT OF THE INTENDED USE AS DESCRIBED IN PRODUCT
LABELING. HOWEVER, EACH USER SHOULD REVIEW THESE RECOMMENDATIONS IN THE
SPECIFIC CONTEXT OF THE INTENDED USE AND DETERMINE WHETHER THEY ARE
APPROPRIATE. YOU ARE URGED TO OBTAIN MATERIAL SAFETY DATA SHEETS FOR ALL
PRODUCTS YOU BUY, PROCESS, USE OR DISTRIBUTE, AND ARE ENCOURAGED TO ADVISE
THOSE WHO MAY COME IN CONTACT WITH SUCH PRODUCTS OF THE INFORMATION
CONTAINED THEREIN. REGULATORY REQUIREMENTS ARE SUBJECT TO CHANGE AND MAY
DIFFER BETWEEN LOCATIONS. IT IS THE BUYER'S/USER'S RESPONSIBILITY TO
ENSURE THAT HIS ACTIVITIES COMPLY WITH ALL FEDERAL, STATE, PROVINCIAL OR
LOCAL LAWS. NO WARRANTY OR GUARANTEE IS EXPRESSED OR IMPLIED WITH RESPECT
TO THIS PRODUCT, THE ACCURACY AND SUFFICIENCY OF THE DATA OR
RECOMMENDATIONS HEREIN, OR THE RESULTS TO BE OBTAINED FROM THE USE OF THIS
PRODUCT. IN NO EVENT SHALL POWER SERVICE PRODUCTS, INC. BE LIABLE FOR ANY
LOSS, CLAIM, DAMAGE OR LIABILITY OF ANY KIND, WHICH MAY ARISE FROM OR IN
CONNECTION WITH THE INFORMATION CONTAINED IN THIS DOCUMENT OR FROM THE USE,
HANDLING OR STORAGE OF THE PRODUCT BY THE BUYER/USER, WHETHER DIRECT,
INDIRECT, OR CONSEQUENTIAL, OR FOR ANY CLAIM BY ANY THIRD PARTY, BEYOND THE
PURCHASE PRICE OR REPLACEMENT OF THE PRODUCT IN CONNECTION WITH WHICH SUCH
LOSS, CLAIM, DAMAGE OR LIABILITY AROSE.
THE FOREGOING LIMITATIONS APPLY REGARDLESS OF THE CAUSES OR CIRCUMSTANCES
GIVING RISE TO SUCH LOSS, CLAIM, DAMAGE OR LIABILITY, EVEN IF SUCH LOSS,
CLAIM, DAMAGE, OR LIABILITY IS BASED ON NEGLIGENCE OR OTHER TORTS OR BREACH
OF CONTRACT.
REVISED: MAY 30, 2015
SUPERSEDES: FEBRUARY 24, 2015
POWER SERVICE BIO KLEEN DIESEL FUEL BIOCIDE