| Common Name: | RTV SILICONE CLEAR, RTV SILICONE BLACK, RTV SILICONE WHITE |
| Manufacturer: | WHITE LIGHTNING PRODUCTS |
| SDS Revision Date: | 7/2/2015 |
| SDS Format: | GHS-US |
| Item Number(s): | 49LX63 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
SAFETY DATA SHEET
WL099110C
| SECTION 1. IDENTIFICATION |  |
PRODUCT NAME: WHITE LIGHTNING(R*) RTV SILICONE CLEAR
PRODUCT CODE: WL099110C
OTHER MEANS OF IDENTIFICATION: NOT AVAILABLE.
PRODUCT TYPE: LIQUID.
RELEVANT IDENTIFIED USES OF THE SUBSTANCE OR MIXTURE AND USES ADVISED
AGAINST: NOT APPLICABLE.
MANUFACTURER:
WHITE LIGHTNING PRODUCTS
101 WEST PROSPECT AVENUE
CLEVELAND, OHIO 44115
EMERGENCY TELEPHONE NUMBER OF THE COMPANY: (216) 566-2917
PRODUCT INFORMATION TELEPHONE NUMBER: (800) 241-5295
REGULATORY INFORMATION TELEPHONE NUMBER: (216) 566-2902
TRANSPORTATION EMERGENCY TELEPHONE NUMBER: (800) 424-9300
| SECTION 2. HAZARDS IDENTIFICATION | |
OSHA/HCS STATUS:
THIS MATERIAL IS CONSIDERED HAZARDOUS BY THE OSHA HAZARD COMMUNICATION
STANDARD (29 CFR 1910.1200).
CLASSIFICATION OF THE SUBSTANCE OR MIXTURE:
SERIOUS EYE DAMAGE/EYE IRRITATION: CATEGORY 2B
TOXIC TO REPRODUCTION (FERTILITY): CATEGORY 2
SPECIFIC TARGET ORGAN TOXICITY (REPEATED EXPOSURE): CATEGORY 2
ASPIRATION HAZARD: CATEGORY 1
PERCENTAGE OF THE MIXTURE CONSISTING OF INGREDIENT(S) OF UNKNOWN TOXICITY:
56.5%
GHS LABEL ELEMENTS:
HAZARD PICTOGRAMS: HEALTH HAZARD
SIGNAL WORD: DANGER
HAZARD STATEMENTS:
CAUSES EYE IRRITATION.
SUSPECTED OF DAMAGING FERTILITY.
MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS.
MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE.
PRECAUTIONARY STATEMENTS:
GENERAL:
READ LABEL BEFORE USE. KEEP OUT OF REACH OF CHILDREN. IF MEDICAL ADVICE
IS NEEDED, HAVE PRODUCT CONTAINER OR LABEL AT HAND.
PREVENTION:
OBTAIN SPECIAL INSTRUCTIONS BEFORE USE. DO NOT HANDLE UNTIL ALL SAFETY
PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD. USE PERSONAL PROTECTIVE
EQUIPMENT AS REQUIRED. WEAR EYE OR FACE PROTECTION. DO NOT BREATHE VAPOR.
WASH HANDS THOROUGHLY AFTER HANDLING.
RESPONSE: GET MEDICAL ATTENTION IF YOU FEEL UNWELL.
IF EXPOSED OR CONCERNED: GET MEDICAL ATTENTION.
IF SWALLOWED:
IMMEDIATELY CALL A POISON CENTER OR PHYSICIAN. DO NOT INDUCE VOMITING.
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES, IF
PRESENT AND EASY TO DO. CONTINUE RINSING.
IF EYE IRRITATION PERSISTS: GET MEDICAL ATTENTION.
STORAGE: STORE LOCKED UP.
DISPOSAL:
DISPOSE OF CONTENTS AND CONTAINER IN ACCORDANCE WITH ALL LOCAL, REGIONAL,
NATIONAL AND INTERNATIONAL REGULATIONS.
SUPPLEMENTAL LABEL ELEMENTS:
DELAYED EFFECTS FROM LONG TERM OVEREXPOSURE. CONTAINS SOLVENTS WHICH CAN
CAUSE PERMANENT BRAIN AND NERVOUS SYSTEM DAMAGE. INTENTIONAL MISUSE BY
DELIBERATELY CONCENTRATING AND INHALING THE CONTENTS CAN BE HARMFUL OR
FATAL.
PLEASE REFER TO THE SDS FOR ADDITIONAL INFORMATION. DO NOT TRANSFER
CONTENTS TO OTHER CONTAINERS FOR STORAGE.
HAZARDS NOT OTHERWISE CLASSIFIED: NONE KNOWN.
| SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
SUBSTANCE/MIXTURE: MIXTURE
OTHER MEANS OF IDENTIFICATION: NOT AVAILABLE.
CAS NUMBER/OTHER IDENTIFIERS:
INGREDIENT NAME % BY WEIGHT CAS NUMBER
OCTAMETHYLCYCLOTETRASILOXANE 24.6 556-67-2
MIDDLE PETROLEUM DISTILLATES 17.5 64742-46-7
ACETIC ACID 2.9 64-19-7
THERE ARE NO ADDITIONAL INGREDIENTS PRESENT WHICH, WITHIN THE CURRENT
KNOWLEDGE OF THE SUPPLIER AND IN THE CONCENTRATIONS APPLICABLE, ARE
CLASSIFIED AS HAZARDOUS TO HEALTH OR THE ENVIRONMENT AND HENCE REQUIRE
REPORTING IN THIS SECTION.
OCCUPATIONAL EXPOSURE LIMITS, IF AVAILABLE, ARE LISTED IN SECTION 8.
| SECTION 4. FIRST AID MEASURES | |
DESCRIPTION OF NECESSARY FIRST AID MEASURES:
EYE CONTACT:
IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER, OCCASIONALLY LIFTING THE
UPPER AND LOWER EYELIDS. CHECK FOR AND REMOVE ANY CONTACT LENSES. CONTINUE
TO RINSE FOR AT LEAST 10 MINUTES. GET MEDICAL ATTENTION FOLLOWING EXPOSURE
OR IF FEELING UNWELL.
INHALATION:
REMOVE VICTIM TO FRESH AIR AND KEEP AT REST IN A POSITION COMFORTABLE FOR
BREATHING. IF NOT BREATHING, IF BREATHING IS IRREGULAR OR IF RESPIRATORY
ARREST OCCURS, PROVIDE ARTIFICIAL RESPIRATION OR OXYGEN BY TRAINED
PERSONNEL. IT MAY BE DANGEROUS TO THE PERSON PROVIDING AID TO GIVE
MOUTH-TO-MOUTH RESUSCITATION. GET MEDICAL ATTENTION. IF UNCONSCIOUS, PLACE
IN RECOVERY POSITION AND GET MEDICAL ATTENTION IMMEDIATELY. MAINTAIN AN
OPEN AIRWAY. LOOSEN TIGHT CLOTHING SUCH AS A COLLAR, TIE, BELT OR
WAISTBAND.
SKIN CONTACT:
FLUSH CONTAMINATED SKIN WITH PLENTY OF WATER. REMOVE CONTAMINATED CLOTHING
AND SHOES. CONTINUE TO RINSE FOR AT LEAST 10 MINUTES. GET MEDICAL
ATTENTION. WASH CLOTHING BEFORE REUSE. CLEAN SHOES THOROUGHLY BEFORE
REUSE.
INGESTION:
GET MEDICAL ATTENTION IMMEDIATELY. CALL A POISON CENTER OR PHYSICIAN. WASH
OUT MOUTH WITH WATER. REMOVE DENTURES IF ANY. REMOVE VICTIM TO FRESH AIR
AND KEEP AT REST IN A POSITION COMFORTABLE FOR BREATHING. IF MATERIAL HAS
BEEN SWALLOWED AND THE EXPOSED PERSON IS CONSCIOUS, GIVE SMALL QUANTITIES
OF WATER TO DRINK. STOP IF THE EXPOSED PERSON FEELS SICK AS VOMITING MAY
BE DANGEROUS. ASPIRATION HAZARD IF SWALLOWED. CAN ENTER LUNGS AND CAUSE
DAMAGE. DO NOT INDUCE VOMITING. IF VOMITING OCCURS, THE HEAD SHOULD BE KEPT
LOW SO THAT VOMIT DOES NOT ENTER THE LUNGS. NEVER GIVE ANYTHING BY MOUTH TO
AN UNCONSCIOUS PERSON. IF UNCONSCIOUS, PLACE IN RECOVERY POSITION AND GET
MEDICAL ATTENTION IMMEDIATELY. MAINTAIN AN OPEN AIRWAY. LOOSEN TIGHT
CLOTHING SUCH AS A COLLAR, TIE, BELT OR WAISTBAND.
MOST IMPORTANT SYMPTOMS/EFFECTS, ACUTE AND DELAYED:
POTENTIAL ACUTE HEALTH EFFECTS:
EYE CONTACT: CAUSES EYE IRRITATION.
INHALATION: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
SKIN CONTACT: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
INGESTION:
MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS. MAY BE IRRITATING TO MOUTH,
THROAT AND STOMACH.
OVER-EXPOSURE SIGNS/SYMPTOMS:
EYE CONTACT:
ADVERSE SYMPTOMS MAY INCLUDE THE FOLLOWING:
IRRITATION
WATERING
REDNESS
INHALATION:
ADVERSE SYMPTOMS MAY INCLUDE THE FOLLOWING:
REDUCED FETAL WEIGHT
INCREASE IN FETAL DEATHS
SKELETAL MALFORMATIONS
SKIN CONTACT:
ADVERSE SYMPTOMS MAY INCLUDE THE FOLLOWING:
REDUCED FETAL WEIGHT
INCREASE IN FETAL DEATHS
SKELETAL MALFORMATIONS
INGESTION:
ADVERSE SYMPTOMS MAY INCLUDE THE FOLLOWING:
NAUSEA OR VOMITING
REDUCED FETAL WEIGHT
INCREASE IN FETAL DEATHS
SKELETAL MALFORMATIONS
INDICATION OF IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED,
IF NECESSARY:
NOTES TO PHYSICIAN:
TREAT SYMPTOMATICALLY. CONTACT POISON TREATMENT SPECIALIST IMMEDIATELY IF
LARGE QUANTITIES HAVE BEEN INGESTED OR INHALED.
SPECIFIC TREATMENTS: NO SPECIFIC TREATMENT.
PROTECTION OF FIRST-AIDERS:
NO ACTION SHALL BE TAKEN INVOLVING ANY PERSONAL RISK OR WITHOUT SUITABLE
TRAINING. IT MAY BE DANGEROUS TO THE PERSON PROVIDING AID TO GIVE
MOUTH-TO-MOUTH RESUSCITATION.
SEE TOXICOLOGICAL INFORMATION (SECTION 11)
| SECTION 5. FIRE-FIGHTING MEASURES | |
EXTINGUISHING MEDIA:
SUITABLE EXTINGUISHING MEDIA:
USE AN EXTINGUISHING AGENT SUITABLE FOR THE SURROUNDING FIRE.
UNSUITABLE EXTINGUISHING MEDIA: NONE KNOWN.
SPECIFIC HAZARDS ARISING FROM THE CHEMICAL:
IN A FIRE OR IF HEATED, A PRESSURE INCREASE WILL OCCUR AND THE CONTAINER
MAY BURST.
HAZARDOUS THERMAL DECOMPOSITION PRODUCTS:
DECOMPOSITION PRODUCTS MAY INCLUDE THE FOLLOWING MATERIALS:
CARBON DIOXIDE
CARBON MONOXIDE
METAL OXIDE/OXIDES
SPECIAL PROTECTIVE ACTIONS FOR FIRE-FIGHTERS:
PROMPTLY ISOLATE THE SCENE BY REMOVING ALL PERSONS FROM THE VICINITY OF
THE INCIDENT IF THERE IS A FIRE. NO ACTION SHALL BE TAKEN INVOLVING ANY
PERSONAL RISK OR WITHOUT SUITABLE TRAINING.
SPECIAL PROTECTIVE EQUIPMENT FOR FIRE-FIGHTERS:
FIRE-FIGHTERS SHOULD WEAR APPROPRIATE PROTECTIVE EQUIPMENT AND
SELF-CONTAINED BREATHING APPARATUS (SCBA) WITH A FULL FACE-PIECE OPERATED
IN POSITIVE PRESSURE MODE.
| SECTION 6. ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
FOR NON-EMERGENCY PERSONNEL:
NO ACTION SHALL BE TAKEN INVOLVING ANY PERSONAL RISK OR WITHOUT SUITABLE
TRAINING. EVACUATE SURROUNDING AREAS. KEEP UNNECESSARY AND UNPROTECTED
PERSONNEL FROM ENTERING. DO NOT TOUCH OR WALK THROUGH SPILLED MATERIAL.
AVOID BREATHING VAPOR OR MIST. PROVIDE ADEQUATE VENTILATION. WEAR
APPROPRIATE RESPIRATOR WHEN VENTILATION IS INADEQUATE. PUT ON APPROPRIATE
PERSONAL PROTECTIVE EQUIPMENT.
FOR EMERGENCY RESPONDERS:
IF SPECIALISED CLOTHING IS REQUIRED TO DEAL WITH THE SPILLAGE, TAKE NOTE
OF ANY INFORMATION IN SECTION 8 ON SUITABLE AND UNSUITABLE MATERIALS. SEE
ALSO THE INFORMATION IN "FOR NON-EMERGENCY PERSONNEL".
ENVIRONMENTAL PRECAUTIONS:
AVOID DISPERSAL OF SPILLED MATERIAL AND RUNOFF AND CONTACT WITH SOIL,
WATERWAYS, DRAINS AND SEWERS. INFORM THE RELEVANT AUTHORITIES IF THE
PRODUCT HAS CAUSED ENVIRONMENTAL POLLUTION (SEWERS, WATERWAYS, SOIL OR
AIR).
METHODS AND MATERIALS FOR CONTAINMENT AND CLEANING UP:
SMALL SPILL:
STOP LEAK IF WITHOUT RISK. MOVE CONTAINERS FROM SPILL AREA. DILUTE WITH
WATER AND MOP UP IF WATER-SOLUBLE. ALTERNATIVELY, OR IF WATER-INSOLUBLE,
ABSORB WITH AN INERT DRY MATERIAL AND PLACE IN AN APPROPRIATE WASTE
DISPOSAL CONTAINER. DISPOSE OF VIA A LICENSED WASTE DISPOSAL CONTRACTOR.
LARGE SPILL:
STOP LEAK IF WITHOUT RISK. MOVE CONTAINERS FROM SPILL AREA. APPROACH
RELEASE FROM UPWIND. PREVENT ENTRY INTO SEWERS, WATER COURSES, BASEMENTS
OR CONFINED AREAS. WASH SPILLAGES INTO AN EFFLUENT TREATMENT PLANT OR
PROCEED AS FOLLOWS. CONTAIN AND COLLECT SPILLAGE WITH NON-COMBUSTIBLE,
ABSORBENT MATERIAL E.G. SAND, EARTH, VERMICULITE OR DIATOMACEOUS EARTH
AND PLACE IN CONTAINER FOR DISPOSAL ACCORDING TO LOCAL REGULATIONS
(SEE SECTION 13). DISPOSE OF VIA A LICENSED WASTE DISPOSAL CONTRACTOR.
CONTAMINATED ABSORBENT MATERIAL MAY POSE THE SAME HAZARD AS THE SPILLED
PRODUCT.
NOTE:
SEE SECTION 1 FOR EMERGENCY CONTACT INFORMATION AND SECTION 13 FOR WASTE
DISPOSAL.
| SECTION 7. HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING:
PROTECTIVE MEASURES:
PUT ON APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT (SEE SECTION 8). AVOID
EXPOSURE - OBTAIN SPECIAL INSTRUCTIONS BEFORE USE. AVOID EXPOSURE DURING
PREGNANCY. DO NOT HANDLE UNTIL ALL SAFETY PRECAUTIONS HAVE BEEN READ AND
UNDERSTOOD. DO NOT GET IN EYES OR ON SKIN OR CLOTHING. DO NOT BREATHE VAPOR
OR MIST. DO NOT SWALLOW. IF DURING NORMAL USE THE MATERIAL PRESENTS A
RESPIRATORY HAZARD, USE ONLY WITH ADEQUATE VENTILATION OR WEAR APPROPRIATE
RESPIRATOR. KEEP IN THE ORIGINAL CONTAINER OR AN APPROVED ALTERNATIVE MADE
FROM A COMPATIBLE MATERIAL, KEPT TIGHTLY CLOSED WHEN NOT IN USE. EMPTY
CONTAINERS RETAIN PRODUCT RESIDUE AND CAN BE HAZARDOUS. DO NOT REUSE
CONTAINER.
ADVICE ON GENERAL OCCUPATIONAL HYGIENE:
EATING, DRINKING AND SMOKING SHOULD BE PROHIBITED IN AREAS WHERE THIS
MATERIAL IS HANDLED, STORED AND PROCESSED. WORKERS SHOULD WASH HANDS AND
FACE BEFORE EATING, DRINKING AND SMOKING. REMOVE CONTAMINATED CLOTHING AND
PROTECTIVE EQUIPMENT BEFORE ENTERING EATING AREAS. SEE ALSO SECTION 8 FOR
ADDITIONAL INFORMATION ON HYGIENE MEASURES.
CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES:
STORE IN ACCORDANCE WITH LOCAL REGULATIONS. STORE IN ORIGINAL CONTAINER
PROTECTED FROM DIRECT SUNLIGHT IN A DRY, COOL AND WELL-VENTILATED AREA,
AWAY FROM INCOMPATIBLE MATERIALS (SEE SECTION 10) AND FOOD AND DRINK.
STORE LOCKED UP. KEEP CONTAINER TIGHTLY CLOSED AND SEALED UNTIL READY FOR
USE. CONTAINERS THAT HAVE BEEN OPENED MUST BE CAREFULLY RESEALED AND KEPT
UPRIGHT TO PREVENT LEAKAGE. DO NOT STORE IN UNLABELED CONTAINERS. USE
APPROPRIATE CONTAINMENT TO AVOID ENVIRONMENTAL CONTAMINATION.
| SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
CONTROL PARAMETERS:
OCCUPATIONAL EXPOSURE LIMITS:
INGREDIENT NAME EXPOSURE LIMITS
ACETIC ACID ACGIH TLV (UNITED STATES, 4/2014).
TWA: 10 PPM 8 HOURS.
TWA: 25 MG/M3 8 HOURS.
STEL: 15 PPM 15 MINUTES.
STEL: 37 MG/M3 15 MINUTES.
NIOSH REL (UNITED STATES, 10/2013).
TWA: 10 PPM 10 HOURS.
TWA: 25 MG/M3 10 HOURS.
STEL: 15 PPM 15 MINUTES.
STEL: 37 MG/M3 15 MINUTES.
OSHA PEL (UNITED STATES, 2/2013).
TWA: 10 PPM 8 HOURS.
TWA: 25 MG/M3 8 HOURS.
APPROPRIATE ENGINEERING CONTROLS:
IF USER OPERATIONS GENERATE DUST, FUMES, GAS, VAPOR OR MIST, USE PROCESS
ENCLOSURES, LOCAL EXHAUST VENTILATION OR OTHER ENGINEERING CONTROLS TO
KEEP WORKER EXPOSURE TO AIRBORNE CONTAMINANTS BELOW ANY RECOMMENDED OR
STATUTORY LIMITS.
ENVIRONMENTAL EXPOSURE CONTROLS:
EMISSIONS FROM VENTILATION OR WORK PROCESS EQUIPMENT SHOULD BE CHECKED
TO ENSURE THEY COMPLY WITH THE REQUIREMENTS OF ENVIRONMENTAL PROTECTION
LEGISLATION. IN SOME CASES, FUME SCRUBBERS, FILTERS OR ENGINEERING
MODIFICATIONS TO THE PROCESS EQUIPMENT WILL BE NECESSARY TO REDUCE
EMISSIONS TO ACCEPTABLE LEVELS.
INDIVIDUAL PROTECTION MEASURES:
HYGIENE MEASURES:
WASH HANDS, FOREARMS AND FACE THOROUGHLY AFTER HANDLING CHEMICAL PRODUCTS,
BEFORE EATING, SMOKING AND USING THE LAVATORY AND AT THE END OF THE WORKING
PERIOD. APPROPRIATE TECHNIQUES SHOULD BE USED TO REMOVE POTENTIALLY
CONTAMINATED CLOTHING. WASH CONTAMINATED CLOTHING BEFORE REUSING. ENSURE
THAT EYEWASH STATIONS AND SAFETY SHOWERS ARE CLOSE TO THE WORKSTATION
LOCATION.
EYE/FACE PROTECTION:
SAFETY EYEWEAR COMPLYING WITH AN APPROVED STANDARD SHOULD BE USED WHEN A
RISK ASSESSMENT INDICATES THIS IS NECESSARY TO AVOID EXPOSURE TO LIQUID
SPLASHES, MISTS, GASES OR DUSTS. IF CONTACT IS POSSIBLE, THE FOLLOWING
PROTECTION SHOULD BE WORN, UNLESS THE ASSESSMENT INDICATES A HIGHER DEGREE
OF PROTECTION: CHEMICAL SPLASH GOGGLES.
SKIN PROTECTION:
HAND PROTECTION:
CHEMICAL-RESISTANT, IMPERVIOUS GLOVES COMPLYING WITH AN APPROVED STANDARD
SHOULD BE WORN AT ALL TIMES WHEN HANDLING CHEMICAL PRODUCTS IF A RISK
ASSESSMENT INDICATES THIS IS NECESSARY. CONSIDERING THE PARAMETERS
SPECIFIED BY THE GLOVE MANUFACTURER, CHECK DURING USE THAT THE GLOVES ARE
STILL RETAINING THEIR PROTECTIVE PROPERTIES. IT SHOULD BE NOTED THAT THE
TIME TO BREAKTHROUGH FOR ANY GLOVE MATERIAL MAY BE DIFFERENT FOR DIFFERENT
GLOVE MANUFACTURERS. IN THE CASE OF MIXTURES, CONSISTING OF SEVERAL
SUBSTANCES, THE PROTECTION TIME OF THE GLOVES CANNOT BE ACCURATELY
ESTIMATED.
BODY PROTECTION:
PERSONAL PROTECTIVE EQUIPMENT FOR THE BODY SHOULD BE SELECTED BASED ON
THE TASK BEING PERFORMED AND THE RISKS INVOLVED AND SHOULD BE APPROVED BY
A SPECIALIST BEFORE HANDLING THIS PRODUCT.
OTHER SKIN PROTECTION:
APPROPRIATE FOOTWEAR AND ANY ADDITIONAL SKIN PROTECTION MEASURES SHOULD
BE SELECTED BASED ON THE TASK BEING PERFORMED AND THE RISKS INVOLVED AND
SHOULD BE APPROVED BY A SPECIALIST BEFORE HANDLING THIS PRODUCT.
RESPIRATORY PROTECTION:
USE A PROPERLY FITTED, AIR-PURIFYING OR AIR-FED RESPIRATOR COMPLYING WITH
AN APPROVED STANDARD IF A RISK ASSESSMENT INDICATES THIS IS NECESSARY.
RESPIRATOR SELECTION MUST BE BASED ON KNOWN OR ANTICIPATED EXPOSURE LEVELS,
THE HAZARDS OF THE PRODUCT AND THE SAFE WORKING LIMITS OF THE SELECTED
RESPIRATOR.
| SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE:
PHYSICAL STATE: LIQUID.
COLOR: NOT AVAILABLE.
ODOR: NOT AVAILABLE.
ODOR THRESHOLD: NOT AVAILABLE.
PH: NOT AVAILABLE.
MELTING POINT: NOT AVAILABLE.
BOILING POINT: 117 DEG. C (242.6 DEG. F)
FLASH POINT:
CLOSED CUP: >93.3 DEG. C (>199.9 DEG. F) [PENSKY-MARTENS CLOSED CUP]
EVAPORATION RATE: 0.97 (BUTYL ACETATE = 1)
FLAMMABILITY (SOLID, GAS): NOT AVAILABLE.
LOWER AND UPPER EXPLOSIVE (FLAMMABLE) LIMITS:
LOWER: 5.4%
UPPER: 19.3%
VAPOR PRESSURE: 0.13 KPA (1 MMHg) [AT 20 DEG. C]
VAPOR DENSITY: 2.07 [AIR = 1]
RELATIVE DENSITY: 1.01
SOLUBILITY: NOT AVAILABLE.
PARTITION COEFFICIENT N-OCTANOL/WATER: NOT AVAILABLE.
AUTO-IGNITION TEMPERATURE: NOT AVAILABLE.
DECOMPOSITION TEMPERATURE: NOT AVAILABLE.
VISCOSITY:
KINEMATIC (ROOM TEMPERATURE): <0.205 CM2/S (<20.5 CST)
KINEMATIC (40 DEG. C (104 DEG. F)): <0.205 CM2/S (<20.5 CST)
AEROSOL PRODUCT:
HEAT OF COMBUSTION: 8.644 KJ/G
| SECTION 10. STABILITY AND REACTIVITY | |
REACTIVITY:
NO SPECIFIC TEST DATA RELATED TO REACTIVITY AVAILABLE FOR THIS PRODUCT OR
ITS INGREDIENTS.
CHEMICAL STABILITY: THE PRODUCT IS STABLE.
POSSIBILITY OF HAZARDOUS REACTIONS:
UNDER NORMAL CONDITIONS OF STORAGE AND USE, HAZARDOUS REACTIONS WILL NOT
OCCUR.
CONDITIONS TO AVOID: NO SPECIFIC DATA.
INCOMPATIBLE MATERIALS: NO SPECIFIC DATA.
HAZARDOUS DECOMPOSITION PRODUCTS:
UNDER NORMAL CONDITIONS OF STORAGE AND USE, HAZARDOUS DECOMPOSITION
PRODUCTS SHOULD NOT BE PRODUCED.
| SECTION 11. TOXICOLOGICAL INFORMATION | |
INFORMATION ON TOXICOLOGICAL EFFECTS:
ACUTE TOXICITY:
PRODUCT/INGREDIENT RESULT SPECIES DOSE EXPOSURE
NAME
OCTAMETHYLCYCLO- LC50 INHALATION VAPOR RAT 36 G/M3 4 HOURS
TETRASILOXANE LD50 DERMAL RAT 1770 MG/KG
LD50 ORAL RAT 1540 MG/KG
ACETIC ACID LC50 INHALATION VAPOR RAT 11000 MG/M3 4 HOURS
LD50 DERMAL RABBIT 1060 MG/KG
LD50 ORAL RAT 3310 MG/KG
IRRITATION/CORROSION:
PRODUCT/ RESULT SPECIES SCORE EXPOSURE OBSERVATION
INGREDIENT
NAME
OCTAMETHYL- EYES: RABBIT 24 HOURS
CYCLOTETRA- MILD IRRITANT 500 MILLIGRAMS
SILOXANE
SKIN: RABBIT 24 HOURS
MILD IRRITANT 500 MILLIGRAMS
ACETIC ACID EYES: RABBIT 0.5 MINUTES
MILD IRRITANT 5 MILLIGRAMS
SKIN: HUMAN 24 HOURS
MILD IRRITANT 50 MILLIGRAMS
SKIN: RABBIT 24 HOURS
MILD IRRITANT 50 MILLIGRAMS
SKIN: RABBIT 525 MILLIGRAMS
SEVERE IRRITANT
SENSITIZATION: NOT AVAILABLE.
MUTAGENICITY: NOT AVAILABLE.
CARCINOGENICITY: NOT AVAILABLE.
REPRODUCTIVE TOXICITY: NOT AVAILABLE.
TERATOGENICITY: NOT AVAILABLE.
SPECIFIC TARGET ORGAN TOXICITY (SINGLE EXPOSURE):
NAME CATEGORY ROUTE OF EXPOSURE TARGET ORGANS
MIDDLE PETROLEUM CATEGORY 3 NOT APPLICABLE. RESPIRATORY TRACT
DISTILLATES IRRITATION AND
NARCOTIC EFFECTS
SPECIFIC TARGET ORGAN TOXICITY (REPEATED EXPOSURE):
NAME CATEGORY ROUTE OF EXPOSURE TARGET ORGANS
MIDDLE PETROLEUM CATEGORY 2 NOT DETERMINED NOT DETERMINED
DISTILLATES
ASPIRATION HAZARD:
NAME RESULT
MIDDLE PETROLEUM DISTILLATES ASPIRATION HAZARD - CATEGORY 1
INFORMATION ON THE LIKELY ROUTES OF EXPOSURE: NOT AVAILABLE.
POTENTIAL ACUTE HEALTH EFFECTS:
EYE CONTACT: CAUSES EYE IRRITATION.
INHALATION: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
SKIN CONTACT: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
INGESTION:
MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS. MAY BE IRRITATING TO MOUTH,
THROAT AND STOMACH.
SYMPTOMS RELATED TO THE PHYSICAL, CHEMICAL AND TOXICOLOGICAL
CHARACTERISTICS:
EYE CONTACT:
ADVERSE SYMPTOMS MAY INCLUDE THE FOLLOWING:
IRRITATION
WATERING
REDNESS
INHALATION:
ADVERSE SYMPTOMS MAY INCLUDE THE FOLLOWING:
REDUCED FETAL WEIGHT
INCREASE IN FETAL DEATHS
SKELETAL MALFORMATIONS
SKIN CONTACT:
ADVERSE SYMPTOMS MAY INCLUDE THE FOLLOWING:
REDUCED FETAL WEIGHT
INCREASE IN FETAL DEATHS
SKELETAL MALFORMATIONS
INGESTION:
ADVERSE SYMPTOMS MAY INCLUDE THE FOLLOWING:
NAUSEA OR VOMITING
REDUCED FETAL WEIGHT
INCREASE IN FETAL DEATHS
SKELETAL MALFORMATIONS
DELAYED AND IMMEDIATE EFFECTS AND ALSO CHRONIC EFFECTS FROM SHORT AND
LONG TERM EXPOSURE:
SHORT TERM EXPOSURE:
POTENTIAL IMMEDIATE EFFECTS: NOT AVAILABLE.
POTENTIAL DELAYED EFFECTS: NOT AVAILABLE.
LONG TERM EXPOSURE:
POTENTIAL IMMEDIATE EFFECTS: NOT AVAILABLE.
POTENTIAL DELAYED EFFECTS: NOT AVAILABLE.
POTENTIAL CHRONIC HEALTH EFFECTS: NOT AVAILABLE.
GENERAL: MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE.
CARCINOGENICITY: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
MUTAGENICITY: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
TERATOGENICITY: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
DEVELOPMENTAL EFFECTS: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
FERTILITY EFFECTS: SUSPECTED OF DAMAGING FERTILITY.
NUMERICAL MEASURES OF TOXICITY:
ACUTE TOXICITY ESTIMATES:
ROUTE ATE VALUE
ORAL 2376.2 MG/KG
DERMAL 2615.1 MG/KG
INHALATION (VAPORS) 165 MG/L
| SECTION 12. ECOLOGICAL INFORMATION | |
TOXICITY:
PRODUCT/INGREDIENT RESULT SPECIES EXPOSURE
NAME
OCTAMETHYLCYCLO- CHRONIC NOEC: DAPHNIA - DAPHNIA 21 DAYS
TETRASILOXANE 1.7 TO 15 (MICRO)G/L MAGNA
FRESH WATER
CHRONIC NOEC: FISH - ONCORHYNCHUS 93 DAYS
4.4 (MICRO)G/L MYKISS - EGG
FRESH WATER
ACETIC ACID ACUTE EC50: ALGAE - NAVICULA 96 HOURS
73400 (MICRO)G/L SEMINULUM
FRESH WATER
ACUTE EC50: DAPHNIA - DAPHNIA 48 HOURS
65000 (MICRO)G/L MAGNA - NEONATE
FRESH WATER
ACUTE LC50: CRUSTACEANS - ARTEMIA 48 HOURS
50.1 UL/L SP.
MARINE WATER
ACUTE LC50: FISH - LEPOMIS 96 HOURS
75000 (MICRO)G/L MACROCHIRUS
FRESH WATER
PERSISTENCE AND DEGRADABILITY: NOT AVAILABLE.
BIOACCUMULATIVE POTENTIAL:
PRODUCT/INGREDIENT NAME LOGPOW BCF POTENTIAL
OCTAMETHYLCYCLOTETRASILOXANE 13400 HIGH
ACETIC ACID 3.16 LOW
MOBILITY IN SOIL:
SOIL/WATER PARTITION COEFFICIENT (KOC): NOT AVAILABLE.
OTHER ADVERSE EFFECTS: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
| SECTION 13. DISPOSAL CONSIDERATIONS | |
DISPOSAL METHODS:
THE GENERATION OF WASTE SHOULD BE AVOIDED OR MINIMIZED WHEREVER POSSIBLE.
DISPOSAL OF THIS PRODUCT, SOLUTIONS AND ANY BY-PRODUCTS SHOULD AT ALL TIMES
COMPLY WITH THE REQUIREMENTS OF ENVIRONMENTAL PROTECTION AND WASTE DISPOSAL
LEGISLATION AND ANY REGIONAL LOCAL AUTHORITY REQUIREMENTS. DISPOSE OF
SURPLUS AND NON-RECYCLABLE PRODUCTS VIA A LICENSED WASTE DISPOSAL
CONTRACTOR. WASTE SHOULD NOT BE DISPOSED OF UNTREATED TO THE SEWER UNLESS
FULLY COMPLIANT WITH THE REQUIREMENTS OF ALL AUTHORITIES WITH JURISDICTION.
WASTE PACKAGING SHOULD BE RECYCLED. INCINERATION OR LANDFILL SHOULD ONLY
BE CONSIDERED WHEN RECYCLING IS NOT FEASIBLE. THIS MATERIAL AND ITS
CONTAINER MUST BE DISPOSED OF IN A SAFE WAY. CARE SHOULD BE TAKEN WHEN
HANDLING EMPTIED CONTAINERS THAT HAVE NOT BEEN CLEANED OR RINSED OUT. EMPTY
CONTAINERS OR LINERS MAY RETAIN SOME PRODUCT RESIDUES. AVOID DISPERSAL OF
SPILLED MATERIAL AND RUNOFF AND CONTACT WITH SOIL, WATERWAYS, DRAINS AND
SEWERS.
| SECTION 14. TRANSPORT INFORMATION | |
DOT TDG MEXICO
CLASSIFICATION CLASSIFICATION CLASSIFICATION
UN NUMBER NOT REGULATED. NOT REGULATED. NOT REGULATED.
UN PROPER SHIPPING NAME
TRANSPORT HAZARD
CLASS(ES)
PACKING GROUP
ENVIRONMENTAL HAZARDS NO. NO. NO.
ADDITIONAL INFORMATION SPECIAL SPECIAL SPECIAL
PROVISIONS: PROVISIONS: PROVISIONS:
NOT APPLICABLE NOT APPLICABLE NOT APPLICABLE
IATA IMDG
UN NUMBER NOT REGULATED. NOT REGULATED.
UN PROPER SHIPPING NAME
TRANSPORT HAZARD CLASS(ES)
PACKING GROUP
ENVIRONMENTAL HAZARDS NO. NO.
ADDITIONAL INFORMATION SPECIAL PROVISIONS: EMERGENCY SCHEDULES
NOT APPLICABLE (EMS): NOT APPLICABLE
SPECIAL PRECAUTIONS FOR USER:
MULTI-MODAL SHIPPING DESCRIPTIONS ARE PROVIDED FOR INFORMATIONAL PURPOSES
AND DO NOT CONSIDER CONTAINER SIZES. THE PRESENCE OF A SHIPPING DESCRIPTION
FOR A PARTICULAR MODE OF TRANSPORT (SEA, AIR, ETC.), DOES NOT INDICATE THAT
THE PRODUCT IS PACKAGED SUITABLY FOR THAT MODE OF TRANSPORT. ALL PACKAGING
MUST BE REVIEWED FOR SUITABILITY PRIOR TO SHIPMENT, AND COMPLIANCE WITH THE
APPLICABLE REGULATIONS IS THE SOLE RESPONSIBILITY OF THE PERSON OFFERING
THE PRODUCT FOR TRANSPORT. PEOPLE LOADING AND UNLOADING DANGEROUS GOODS
MUST BE TRAINED ON ALL OF THE RISKS DERIVING FROM THE SUBSTANCES AND ON
ALL ACTIONS IN CASE OF EMERGENCY SITUATIONS.
TRANSPORT IN BULK ACCORDING TO ANNEX II OF MARPOL 73/78 AND THE IBC CODE:
NOT AVAILABLE.
| SECTION 15. REGULATORY INFORMATION | |
U.S. FEDERAL REGULATIONS:
STATE REGULATIONS:
| SECTION 16. OTHER INFORMATION | |
HAZARDOUS MATERIAL INFORMATION SYSTEM (U.S.A.):
HEALTH 3
FLAMMABILITY 0
PHYSICAL HAZARDS 0
CAUTION:
HMIS(R*) RATINGS ARE BASED ON A 0-4 RATING SCALE, WITH 0 REPRESENTING
MINIMAL HAZARDS OR RISKS, AND 4 REPRESENTING SIGNIFICANT HAZARDS OR RISKS
ALTHOUGH HMIS(R*) RATINGS ARE NOT REQUIRED ON SDSS UNDER 29 CFR 1910.1200,
THE PREPARER MAY CHOOSE TO PROVIDE THEM. HMIS(R*) RATINGS ARE TO BE USED
WITH A FULLY IMPLEMENTED HMIS(R*) PROGRAM. HMIS(R*) IS A REGISTERED MARK
OF THE NATIONAL PAINT & COATINGS ASSOCIATION (NPCA). HMIS(R*) MATERIALS
MAY BE PURCHASED EXCLUSIVELY FROM J. J. KELLER (800) 327-6868.
THE CUSTOMER IS RESPONSIBLE FOR DETERMINING THE PPE CODE FOR THIS MATERIAL.
NOTICE TO READER:
IT IS RECOMMENDED THAT EACH CUSTOMER OR RECIPIENT OF THIS SAFETY DATA
SHEET (SDS) STUDY IT CAREFULLY AND CONSULT RESOURCES, AS NECESSARY OR
APPROPRIATE, TO BECOME AWARE OF AND UNDERSTAND THE DATA CONTAINED IN THIS
SDS AND ANY HAZARDS ASSOCIATED WITH THE PRODUCT. THIS INFORMATION IS
PROVIDED IN GOOD FAITH AND BELIEVED TO BE ACCURATE AS OF THE EFFECTIVE
DATE HEREIN. HOWEVER, NO WARRANTY, EXPRESS OR IMPLIED, IS GIVEN. THE
INFORMATION PRESENTED HERE APPLIES ONLY TO THE PRODUCT AS SHIPPED. THE
ADDITION OF ANY MATERIAL CAN CHANGE THE COMPOSITION, HAZARDS AND RISKS OF
THE PRODUCT. REGULATORY REQUIREMENTS ARE SUBJECT TO CHANGE AND MAY DIFFER
BETWEEN VARIOUS LOCATIONS AND JURISDICTIONS. THE CUSTOMER/BUYER/USER IS
RESPONSIBLE TO ENSURE THAT HIS ACTIVITIES COMPLY WITH ALL COUNTRY, FEDERAL,
STATE, PROVINCIAL OR LOCAL LAWS. THE CONDITIONS FOR USE OF THE PRODUCT ARE
NOT UNDER THE CONTROL OF THE MANUFACTURER; THE CUSTOMER/BUYER/USER IS
RESPONSIBLE TO DETERMINE THE CONDITIONS NECESSARY FOR THE SAFE USE OF THIS
PRODUCT. THE CUSTOMER/BUYER/USER SHOULD NOT USE THE PRODUCT FOR ANY PURPOSE
OTHER THAN THE PURPOSE SHOWN IN THE APPLICABLE SECTION OF THIS SDS WITHOUT
FIRST REFERRING TO THE SUPPLIER AND OBTAINING WRITTEN HANDLING
INSTRUCTIONS. DUE TO THE PROLIFERATION OF SOURCES FOR INFORMATION SUCH AS
MANUFACTURER-SPECIFIC SDS, THE MANUFACTURER CANNOT BE RESPONSIBLE FOR SDSS
OBTAINED FROM ANY OTHER SOURCE.
DATE OF ISSUE/DATE OF REVISION: 7/2/2015.
DATE OF PREVIOUS ISSUE: 6/11/2015.
VERSION: 1.01
SAFETY DATA SHEET
WL099111B
| SECTION 1. IDENTIFICATION | |
PRODUCT NAME: WHITE LIGHTNING(R*) RTV SILICONE BLACK
PRODUCT CODE: WL099111B
OTHER MEANS OF IDENTIFICATION: NOT AVAILABLE.
PRODUCT TYPE: LIQUID.
RELEVANT IDENTIFIED USES OF THE SUBSTANCE OR MIXTURE AND USES ADVISED
AGAINST: NOT APPLICABLE.
MANUFACTURER:
WHITE LIGHTNING PRODUCTS
101 WEST PROSPECT AVENUE
CLEVELAND, OHIO 44115
EMERGENCY TELEPHONE NUMBER OF THE COMPANY: (216) 566-2917
PRODUCT INFORMATION TELEPHONE NUMBER: (800) 241-5295
REGULATORY INFORMATION TELEPHONE NUMBER: (216) 566-2902
TRANSPORTATION EMERGENCY TELEPHONE NUMBER: (800) 424-9300
| SECTION 2. HAZARDS IDENTIFICATION | |
OSHA/HCS STATUS:
THIS MATERIAL IS CONSIDERED HAZARDOUS BY THE OSHA HAZARD COMMUNICATION
STANDARD (29 CFR 1910.1200).
CLASSIFICATION OF THE SUBSTANCE OR MIXTURE:
SERIOUS EYE DAMAGE/EYE IRRITATION: CATEGORY 2B
TOXIC TO REPRODUCTION (FERTILITY): CATEGORY 2
SPECIFIC TARGET ORGAN TOXICITY (REPEATED EXPOSURE): CATEGORY 2
ASPIRATION HAZARD: CATEGORY 1
PERCENTAGE OF THE MIXTURE CONSISTING OF INGREDIENT(S) OF UNKNOWN TOXICITY:
56.5%
GHS LABEL ELEMENTS:
HAZARD PICTOGRAMS: HEALTH HAZARD
SIGNAL WORD: DANGER
HAZARD STATEMENTS:
CAUSES EYE IRRITATION.
SUSPECTED OF DAMAGING FERTILITY.
MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS.
MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE.
PRECAUTIONARY STATEMENTS:
GENERAL:
READ LABEL BEFORE USE. KEEP OUT OF REACH OF CHILDREN. IF MEDICAL ADVICE
IS NEEDED, HAVE PRODUCT CONTAINER OR LABEL AT HAND.
PREVENTION:
OBTAIN SPECIAL INSTRUCTIONS BEFORE USE. DO NOT HANDLE UNTIL ALL SAFETY
PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD. USE PERSONAL PROTECTIVE
EQUIPMENT AS REQUIRED. WEAR EYE OR FACE PROTECTION. DO NOT BREATHE VAPOR.
WASH HANDS THOROUGHLY AFTER HANDLING.
RESPONSE: GET MEDICAL ATTENTION IF YOU FEEL UNWELL.
IF EXPOSED OR CONCERNED: GET MEDICAL ATTENTION.
IF SWALLOWED:
IMMEDIATELY CALL A POISON CENTER OR PHYSICIAN. DO NOT INDUCE VOMITING.
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES, IF
PRESENT AND EASY TO DO. CONTINUE RINSING.
IF EYE IRRITATION PERSISTS: GET MEDICAL ATTENTION.
STORAGE: STORE LOCKED UP.
DISPOSAL:
DISPOSE OF CONTENTS AND CONTAINER IN ACCORDANCE WITH ALL LOCAL, REGIONAL,
NATIONAL AND INTERNATIONAL REGULATIONS.
SUPPLEMENTAL LABEL ELEMENTS:
DELAYED EFFECTS FROM LONG TERM OVEREXPOSURE. CONTAINS SOLVENTS WHICH
CAN CAUSE PERMANENT BRAIN AND NERVOUS SYSTEM DAMAGE. INTENTIONAL MISUSE BY
DELIBERATELY CONCENTRATING AND INHALING THE CONTENTS CAN BE HARMFUL OR
FATAL.
PLEASE REFER TO THE SDS FOR ADDITIONAL INFORMATION. DO NOT TRANSFER
CONTENTS TO OTHER CONTAINERS FOR STORAGE.
HAZARDS NOT OTHERWISE CLASSIFIED: NONE KNOWN.
| SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
SUBSTANCE/MIXTURE: MIXTURE
OTHER MEANS OF IDENTIFICATION: NOT AVAILABLE.
CAS NUMBER/OTHER IDENTIFIERS:
INGREDIENT NAME % BY WEIGHT CAS NUMBER
OCTAMETHYLCYCLOTETRASILOXANE 24.6 556-67-2
MIDDLE PETROLEUM DISTILLATES 17.5 64742-46-7
ACETIC ACID 2.9 64-19-7
THERE ARE NO ADDITIONAL INGREDIENTS PRESENT WHICH, WITHIN THE CURRENT
KNOWLEDGE OF THE SUPPLIER AND IN THE CONCENTRATIONS APPLICABLE, ARE
CLASSIFIED AS HAZARDOUS TO HEALTH OR THE ENVIRONMENT AND HENCE REQUIRE
REPORTING IN THIS SECTION.
OCCUPATIONAL EXPOSURE LIMITS, IF AVAILABLE, ARE LISTED IN SECTION 8.
| SECTION 4. FIRST AID MEASURES | |
DESCRIPTION OF NECESSARY FIRST AID MEASURES:
EYE CONTACT:
IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER, OCCASIONALLY LIFTING THE
UPPER AND LOWER EYELIDS. CHECK FOR AND REMOVE ANY CONTACT LENSES. CONTINUE
TO RINSE FOR AT LEAST 10 MINUTES. GET MEDICAL ATTENTION FOLLOWING EXPOSURE
OR IF FEELING UNWELL.
INHALATION:
REMOVE VICTIM TO FRESH AIR AND KEEP AT REST IN A POSITION COMFORTABLE FOR
BREATHING. IF NOT BREATHING, IF BREATHING IS IRREGULAR OR IF RESPIRATORY
ARREST OCCURS, PROVIDE ARTIFICIAL RESPIRATION OR OXYGEN BY TRAINED
PERSONNEL. IT MAY BE DANGEROUS TO THE PERSON PROVIDING AID TO GIVE
MOUTH-TO-MOUTH RESUSCITATION. GET MEDICAL ATTENTION. IF UNCONSCIOUS, PLACE
IN RECOVERY POSITION AND GET MEDICAL ATTENTION IMMEDIATELY. MAINTAIN AN
OPEN AIRWAY. LOOSEN TIGHT CLOTHING SUCH AS A COLLAR, TIE, BELT OR
WAISTBAND.
SKIN CONTACT:
FLUSH CONTAMINATED SKIN WITH PLENTY OF WATER. REMOVE CONTAMINATED CLOTHING
AND SHOES. CONTINUE TO RINSE FOR AT LEAST 10 MINUTES. GET MEDICAL
ATTENTION. WASH CLOTHING BEFORE REUSE. CLEAN SHOES THOROUGHLY BEFORE REUSE.
INGESTION:
GET MEDICAL ATTENTION IMMEDIATELY. CALL A POISON CENTER OR PHYSICIAN. WASH
OUT MOUTH WITH WATER. REMOVE DENTURES IF ANY. REMOVE VICTIM TO FRESH AIR
AND KEEP AT REST IN A POSITION COMFORTABLE FOR BREATHING. IF MATERIAL HAS
BEEN SWALLOWED AND THE EXPOSED PERSON IS CONSCIOUS, GIVE SMALL QUANTITIES
OF WATER TO DRINK. STOP IF THE EXPOSED PERSON FEELS SICK AS VOMITING MAY
BE DANGEROUS. ASPIRATION HAZARD IF SWALLOWED. CAN ENTER LUNGS AND CAUSE
DAMAGE. DO NOT INDUCE VOMITING. IF VOMITING OCCURS, THE HEAD SHOULD BE KEPT
LOW SO THAT VOMIT DOES NOT ENTER THE LUNGS. NEVER GIVE ANYTHING BY MOUTH
TO AN UNCONSCIOUS PERSON. IF UNCONSCIOUS, PLACE IN RECOVERY POSITION AND
GET MEDICAL ATTENTION IMMEDIATELY. MAINTAIN AN OPEN AIRWAY. LOOSEN TIGHT
CLOTHING SUCH AS A COLLAR, TIE, BELT OR WAISTBAND.
MOST IMPORTANT SYMPTOMS/EFFECTS, ACUTE AND DELAYED:
POTENTIAL ACUTE HEALTH EFFECTS:
EYE CONTACT: CAUSES EYE IRRITATION.
INHALATION: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
SKIN CONTACT: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
INGESTION:
MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS. MAY BE IRRITATING TO MOUTH,
THROAT AND STOMACH.
OVER-EXPOSURE SIGNS/SYMPTOMS:
EYE CONTACT:
ADVERSE SYMPTOMS MAY INCLUDE THE FOLLOWING:
IRRITATION
WATERING
REDNESS
INHALATION:
ADVERSE SYMPTOMS MAY INCLUDE THE FOLLOWING:
REDUCED FETAL WEIGHT
INCREASE IN FETAL DEATHS
SKELETAL MALFORMATIONS
SKIN CONTACT:
ADVERSE SYMPTOMS MAY INCLUDE THE FOLLOWING:
REDUCED FETAL WEIGHT
INCREASE IN FETAL DEATHS
SKELETAL MALFORMATIONS
INGESTION:
ADVERSE SYMPTOMS MAY INCLUDE THE FOLLOWING:
NAUSEA OR VOMITING
REDUCED FETAL WEIGHT
INCREASE IN FETAL DEATHS
SKELETAL MALFORMATIONS
INDICATION OF IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED,
IF NECESSARY:
NOTES TO PHYSICIAN:
TREAT SYMPTOMATICALLY. CONTACT POISON TREATMENT SPECIALIST IMMEDIATELY
IF LARGE QUANTITIES HAVE BEEN INGESTED OR INHALED.
SPECIFIC TREATMENTS: NO SPECIFIC TREATMENT.
PROTECTION OF FIRST-AIDERS:
NO ACTION SHALL BE TAKEN INVOLVING ANY PERSONAL RISK OR WITHOUT SUITABLE
TRAINING. IT MAY BE DANGEROUS TO THE PERSON PROVIDING AID TO GIVE
MOUTH-TO-MOUTH RESUSCITATION.
SEE TOXICOLOGICAL INFORMATION (SECTION 11)
| SECTION 5. FIRE-FIGHTING MEASURES | |
EXTINGUISHING MEDIA:
SUITABLE EXTINGUISHING MEDIA:
USE AN EXTINGUISHING AGENT SUITABLE FOR THE SURROUNDING FIRE.
UNSUITABLE EXTINGUISHING MEDIA: NONE KNOWN.
SPECIFIC HAZARDS ARISING FROM THE CHEMICAL:
IN A FIRE OR IF HEATED, A PRESSURE INCREASE WILL OCCUR AND THE CONTAINER
MAY BURST.
HAZARDOUS THERMAL DECOMPOSITION PRODUCTS:
DECOMPOSITION PRODUCTS MAY INCLUDE THE FOLLOWING MATERIALS:
CARBON DIOXIDE
CARBON MONOXIDE
METAL OXIDE/OXIDES
SPECIAL PROTECTIVE ACTIONS FOR FIRE-FIGHTERS:
PROMPTLY ISOLATE THE SCENE BY REMOVING ALL PERSONS FROM THE VICINITY OF
THE INCIDENT IF THERE IS A FIRE. NO ACTION SHALL BE TAKEN INVOLVING ANY
PERSONAL RISK OR WITHOUT SUITABLE TRAINING.
SPECIAL PROTECTIVE EQUIPMENT FOR FIRE-FIGHTERS:
FIRE-FIGHTERS SHOULD WEAR APPROPRIATE PROTECTIVE EQUIPMENT AND
SELF-CONTAINED BREATHING APPARATUS (SCBA) WITH A FULL FACE-PIECE OPERATED
IN POSITIVE PRESSURE MODE.
| SECTION 6. ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
FOR NON-EMERGENCY PERSONNEL:
NO ACTION SHALL BE TAKEN INVOLVING ANY PERSONAL RISK OR WITHOUT SUITABLE
TRAINING. EVACUATE SURROUNDING AREAS. KEEP UNNECESSARY AND UNPROTECTED
PERSONNEL FROM ENTERING. DO NOT TOUCH OR WALK THROUGH SPILLED MATERIAL.
AVOID BREATHING VAPOR OR MIST. PROVIDE ADEQUATE VENTILATION. WEAR
APPROPRIATE RESPIRATOR WHEN VENTILATION IS INADEQUATE. PUT ON APPROPRIATE
PERSONAL PROTECTIVE EQUIPMENT.
FOR EMERGENCY RESPONDERS:
IF SPECIALISED CLOTHING IS REQUIRED TO DEAL WITH THE SPILLAGE, TAKE NOTE
OF ANY INFORMATION IN SECTION 8 ON SUITABLE AND UNSUITABLE MATERIALS. SEE
ALSO THE INFORMATION IN "FOR NON-EMERGENCY PERSONNEL".
ENVIRONMENTAL PRECAUTIONS:
AVOID DISPERSAL OF SPILLED MATERIAL AND RUNOFF AND CONTACT WITH SOIL,
WATERWAYS, DRAINS AND SEWERS. INFORM THE RELEVANT AUTHORITIES IF THE
PRODUCT HAS CAUSED ENVIRONMENTAL POLLUTION (SEWERS, WATERWAYS, SOIL OR
AIR).
METHODS AND MATERIALS FOR CONTAINMENT AND CLEANING UP:
SMALL SPILL:
STOP LEAK IF WITHOUT RISK. MOVE CONTAINERS FROM SPILL AREA. DILUTE WITH
WATER AND MOP UP IF WATER-SOLUBLE. ALTERNATIVELY, OR IF WATER-INSOLUBLE,
ABSORB WITH AN INERT DRY MATERIAL AND PLACE IN AN APPROPRIATE WASTE
DISPOSAL CONTAINER. DISPOSE OF VIA A LICENSED WASTE DISPOSAL CONTRACTOR.
LARGE SPILL:
STOP LEAK IF WITHOUT RISK. MOVE CONTAINERS FROM SPILL AREA. APPROACH
RELEASE FROM UPWIND. PREVENT ENTRY INTO SEWERS, WATER COURSES, BASEMENTS
OR CONFINED AREAS. WASH SPILLAGES INTO AN EFFLUENT TREATMENT PLANT OR
PROCEED AS FOLLOWS. CONTAIN AND COLLECT SPILLAGE WITH NON-COMBUSTIBLE,
ABSORBENT MATERIAL E.G. SAND, EARTH, VERMICULITE OR DIATOMACEOUS EARTH
AND PLACE IN CONTAINER FOR DISPOSAL ACCORDING TO LOCAL REGULATIONS
(SEE SECTION 13). DISPOSE OF VIA A LICENSED WASTE DISPOSAL CONTRACTOR.
CONTAMINATED ABSORBENT MATERIAL MAY POSE THE SAME HAZARD AS THE SPILLED
PRODUCT.
NOTE:
SEE SECTION 1 FOR EMERGENCY CONTACT INFORMATION AND SECTION 13 FOR WASTE
DISPOSAL.
| SECTION 7. HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING:
PROTECTIVE MEASURES:
PUT ON APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT (SEE SECTION 8). AVOID
EXPOSURE - OBTAIN SPECIAL INSTRUCTIONS BEFORE USE. AVOID EXPOSURE DURING
PREGNANCY. DO NOT HANDLE UNTIL ALL SAFETY PRECAUTIONS HAVE BEEN READ AND
UNDERSTOOD. DO NOT GET IN EYES OR ON SKIN OR CLOTHING. DO NOT BREATHE
VAPOR OR MIST. DO NOT SWALLOW. IF DURING NORMAL USE THE MATERIAL PRESENTS A
RESPIRATORY HAZARD, USE ONLY WITH ADEQUATE VENTILATION OR WEAR APPROPRIATE
RESPIRATOR. KEEP IN THE ORIGINAL CONTAINER OR AN APPROVED ALTERNATIVE MADE
FROM A COMPATIBLE MATERIAL, KEPT TIGHTLY CLOSED WHEN NOT IN USE. EMPTY
CONTAINERS RETAIN PRODUCT RESIDUE AND CAN BE HAZARDOUS. DO NOT REUSE
CONTAINER.
ADVICE ON GENERAL OCCUPATIONAL HYGIENE:
EATING, DRINKING AND SMOKING SHOULD BE PROHIBITED IN AREAS WHERE THIS
MATERIAL IS HANDLED, STORED AND PROCESSED. WORKERS SHOULD WASH HANDS AND
FACE BEFORE EATING, DRINKING AND SMOKING. REMOVE CONTAMINATED CLOTHING AND
PROTECTIVE EQUIPMENT BEFORE ENTERING EATING AREAS. SEE ALSO SECTION 8 FOR
ADDITIONAL INFORMATION ON HYGIENE MEASURES.
CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES:
STORE IN ACCORDANCE WITH LOCAL REGULATIONS. STORE IN ORIGINAL CONTAINER
PROTECTED FROM DIRECT SUNLIGHT IN A DRY, COOL AND WELL-VENTILATED AREA,
AWAY FROM INCOMPATIBLE MATERIALS (SEE SECTION 10) AND FOOD AND DRINK.
STORE LOCKED UP. KEEP CONTAINER TIGHTLY CLOSED AND SEALED UNTIL READY FOR
USE. CONTAINERS THAT HAVE BEEN OPENED MUST BE CAREFULLY RESEALED AND KEPT
UPRIGHT TO PREVENT LEAKAGE. DO NOT STORE IN UNLABELED CONTAINERS. USE
APPROPRIATE CONTAINMENT TO AVOID ENVIRONMENTAL CONTAMINATION.
| SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
CONTROL PARAMETERS:
OCCUPATIONAL EXPOSURE LIMITS:
INGREDIENT NAME EXPOSURE LIMITS
ACETIC ACID ACGIH TLV (UNITED STATES, 4/2014).
TWA: 10 PPM 8 HOURS.
TWA: 25 MG/M3 8 HOURS.
STEL: 15 PPM 15 MINUTES.
STEL: 37 MG/M3 15 MINUTES.
NIOSH REL (UNITED STATES, 10/2013).
TWA: 10 PPM 10 HOURS.
TWA: 25 MG/M3 10 HOURS.
STEL: 15 PPM 15 MINUTES.
STEL: 37 MG/M3 15 MINUTES.
OSHA PEL (UNITED STATES, 2/2013).
TWA: 10 PPM 8 HOURS.
TWA: 25 MG/M3 8 HOURS.
APPROPRIATE ENGINEERING CONTROLS:
IF USER OPERATIONS GENERATE DUST, FUMES, GAS, VAPOR OR MIST, USE PROCESS
ENCLOSURES, LOCAL EXHAUST VENTILATION OR OTHER ENGINEERING CONTROLS TO
KEEP WORKER EXPOSURE TO AIRBORNE CONTAMINANTS BELOW ANY RECOMMENDED OR
STATUTORY LIMITS.
ENVIRONMENTAL EXPOSURE CONTROLS:
EMISSIONS FROM VENTILATION OR WORK PROCESS EQUIPMENT SHOULD BE CHECKED TO
ENSURE THEY COMPLY WITH THE REQUIREMENTS OF ENVIRONMENTAL PROTECTION
LEGISLATION. IN SOME CASES, FUME SCRUBBERS, FILTERS OR ENGINEERING
MODIFICATIONS TO THE PROCESS EQUIPMENT WILL BE NECESSARY TO REDUCE
EMISSIONS TO ACCEPTABLE LEVELS.
INDIVIDUAL PROTECTION MEASURES:
HYGIENE MEASURES:
WASH HANDS, FOREARMS AND FACE THOROUGHLY AFTER HANDLING CHEMICAL PRODUCTS,
BEFORE EATING, SMOKING AND USING THE LAVATORY AND AT THE END OF THE WORKING
PERIOD. APPROPRIATE TECHNIQUES SHOULD BE USED TO REMOVE POTENTIALLY
CONTAMINATED CLOTHING. WASH CONTAMINATED CLOTHING BEFORE REUSING. ENSURE
THAT EYEWASH STATIONS AND SAFETY SHOWERS ARE CLOSE TO THE WORKSTATION
LOCATION.
EYE/FACE PROTECTION:
SAFETY EYEWEAR COMPLYING WITH AN APPROVED STANDARD SHOULD BE USED WHEN A
RISK ASSESSMENT INDICATES THIS IS NECESSARY TO AVOID EXPOSURE TO LIQUID
SPLASHES, MISTS, GASES OR DUSTS. IF CONTACT IS POSSIBLE, THE FOLLOWING
PROTECTION SHOULD BE WORN, UNLESS THE ASSESSMENT INDICATES A HIGHER DEGREE
OF PROTECTION: CHEMICAL SPLASH GOGGLES.
SKIN PROTECTION:
HAND PROTECTION:
CHEMICAL-RESISTANT, IMPERVIOUS GLOVES COMPLYING WITH AN APPROVED STANDARD
SHOULD BE WORN AT ALL TIMES WHEN HANDLING CHEMICAL PRODUCTS IF A RISK
ASSESSMENT INDICATES THIS IS NECESSARY. CONSIDERING THE PARAMETERS
SPECIFIED BY THE GLOVE MANUFACTURER, CHECK DURING USE THAT THE GLOVES ARE
STILL RETAINING THEIR PROTECTIVE PROPERTIES. IT SHOULD BE NOTED THAT THE
TIME TO BREAKTHROUGH FOR ANY GLOVE MATERIAL MAY BE DIFFERENT FOR DIFFERENT
GLOVE MANUFACTURERS. IN THE CASE OF MIXTURES, CONSISTING OF SEVERAL
SUBSTANCES, THE PROTECTION TIME OF THE GLOVES CANNOT BE ACCURATELY
ESTIMATED.
BODY PROTECTION:
PERSONAL PROTECTIVE EQUIPMENT FOR THE BODY SHOULD BE SELECTED BASED ON THE
TASK BEING PERFORMED AND THE RISKS INVOLVED AND SHOULD BE APPROVED BY A
SPECIALIST BEFORE HANDLING THIS PRODUCT.
OTHER SKIN PROTECTION:
APPROPRIATE FOOTWEAR AND ANY ADDITIONAL SKIN PROTECTION MEASURES SHOULD
BE SELECTED BASED ON THE TASK BEING PERFORMED AND THE RISKS INVOLVED AND
SHOULD BE APPROVED BY A SPECIALIST BEFORE HANDLING THIS PRODUCT.
RESPIRATORY PROTECTION:
USE A PROPERLY FITTED, AIR-PURIFYING OR AIR-FED RESPIRATOR COMPLYING WITH
AN APPROVED STANDARD IF A RISK ASSESSMENT INDICATES THIS IS NECESSARY.
RESPIRATOR SELECTION MUST BE BASED ON KNOWN OR ANTICIPATED EXPOSURE LEVELS,
THE HAZARDS OF THE PRODUCT AND THE SAFE WORKING LIMITS OF THE SELECTED
RESPIRATOR.
| SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE:
PHYSICAL STATE: LIQUID.
COLOR: NOT AVAILABLE.
ODOR: NOT AVAILABLE.
ODOR THRESHOLD: NOT AVAILABLE.
PH: NOT AVAILABLE.
MELTING POINT: NOT AVAILABLE.
BOILING POINT: 117 DEG. C (242.6 DEG. F)
FLASH POINT:
CLOSED CUP: >93.3 DEG. C (>199.9 DEG. F) [PENSKY-MARTENS CLOSED CUP]
EVAPORATION RATE: 0.97 (BUTYL ACETATE = 1)
FLAMMABILITY (SOLID, GAS): NOT AVAILABLE.
LOWER AND UPPER EXPLOSIVE (FLAMMABLE) LIMITS:
LOWER: 5.4%
UPPER: 19.3%
VAPOR PRESSURE: 0.13 KPA (1 MMHg) [AT 20 DEG. C]
VAPOR DENSITY: 2.07 [AIR = 1]
RELATIVE DENSITY: 1.01
SOLUBILITY: NOT AVAILABLE.
PARTITION COEFFICIENT N-OCTANOL/WATER: NOT AVAILABLE.
AUTO-IGNITION TEMPERATURE: NOT AVAILABLE.
DECOMPOSITION TEMPERATURE: NOT AVAILABLE.
VISCOSITY:
KINEMATIC (ROOM TEMPERATURE): <0.205 CM2/S (<20.5 CST)
KINEMATIC (40 DEG. C (104 DEG. F)): <0.205 CM2/S (<20.5 CST)
AEROSOL PRODUCT:
HEAT OF COMBUSTION: 8.644 KJ/G
| SECTION 10. STABILITY AND REACTIVITY | |
REACTIVITY:
NO SPECIFIC TEST DATA RELATED TO REACTIVITY AVAILABLE FOR THIS PRODUCT OR
ITS INGREDIENTS.
CHEMICAL STABILITY: THE PRODUCT IS STABLE.
POSSIBILITY OF HAZARDOUS REACTIONS:
UNDER NORMAL CONDITIONS OF STORAGE AND USE, HAZARDOUS REACTIONS WILL NOT
OCCUR.
CONDITIONS TO AVOID: NO SPECIFIC DATA.
INCOMPATIBLE MATERIALS: NO SPECIFIC DATA.
HAZARDOUS DECOMPOSITION PRODUCTS:
UNDER NORMAL CONDITIONS OF STORAGE AND USE, HAZARDOUS DECOMPOSITION
PRODUCTS SHOULD NOT BE PRODUCED.
| SECTION 11. TOXICOLOGICAL INFORMATION | |
INFORMATION ON TOXICOLOGICAL EFFECTS:
ACUTE TOXICITY:
PRODUCT/INGREDIENT RESULT SPECIES DOSE EXPOSURE
NAME
OCTAMETHYLCYCLO- LC50 INHALATION VAPOR RAT 36 G/M3 4 HOURS
TETRASILOXANE LD50 DERMAL RAT 1770 MG/KG
LD50 ORAL RAT 1540 MG/KG
ACETIC ACID LC50 INHALATION VAPOR RAT 11000 MG/M3 4 HOURS
LD50 DERMAL RABBIT 1060 MG/KG
LD50 ORAL RAT 3310 MG/KG
IRRITATION/CORROSION:
PRODUCT/ RESULT SPECIES SCORE EXPOSURE OBSERVATION
INGREDIENT
NAME
OCTAMETHYL- EYES: RABBIT 24 HOURS
CYCLOTETRA- MILD IRRITANT 500 MILLIGRAMS
SILOXANE
SKIN: RABBIT 24 HOURS
MILD IRRITANT 500 MILLIGRAMS
ACETIC ACID EYES: RABBIT 0.5 MINUTES
MILD IRRITANT 5 MILLIGRAMS
SKIN: HUMAN 24 HOURS
MILD IRRITANT 50 MILLIGRAMS
SKIN: RABBIT 24 HOURS
MILD IRRITANT 50 MILLIGRAMS
SKIN: RABBIT 525 MILLIGRAMS
SEVERE IRRITANT
SENSITIZATION: NOT AVAILABLE.
MUTAGENICITY: NOT AVAILABLE.
CARCINOGENICITY: NOT AVAILABLE.
REPRODUCTIVE TOXICITY: NOT AVAILABLE.
TERATOGENICITY: NOT AVAILABLE.
SPECIFIC TARGET ORGAN TOXICITY (SINGLE EXPOSURE):
NAME CATEGORY ROUTE OF EXPOSURE TARGET ORGANS
MIDDLE PETROLEUM CATEGORY 3 NOT APPLICABLE. RESPIRATORY TRACT
DISTILLATES IRRITATION AND
NARCOTIC EFFECTS
SPECIFIC TARGET ORGAN TOXICITY (REPEATED EXPOSURE):
NAME CATEGORY ROUTE OF EXPOSURE TARGET ORGANS
MIDDLE PETROLEUM CATEGORY 2 NOT DETERMINED NOT DETERMINED
DISTILLATES
ASPIRATION HAZARD:
NAME RESULT
MIDDLE PETROLEUM DISTILLATES ASPIRATION HAZARD - CATEGORY 1
INFORMATION ON THE LIKELY ROUTES OF EXPOSURE: NOT AVAILABLE.
POTENTIAL ACUTE HEALTH EFFECTS:
EYE CONTACT: CAUSES EYE IRRITATION.
INHALATION: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
SKIN CONTACT: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
INGESTION:
MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS. MAY BE IRRITATING TO MOUTH,
THROAT AND STOMACH.
SYMPTOMS RELATED TO THE PHYSICAL, CHEMICAL AND TOXICOLOGICAL
CHARACTERISTICS:
EYE CONTACT:
ADVERSE SYMPTOMS MAY INCLUDE THE FOLLOWING:
IRRITATION
WATERING
REDNESS
INHALATION:
ADVERSE SYMPTOMS MAY INCLUDE THE FOLLOWING:
REDUCED FETAL WEIGHT
INCREASE IN FETAL DEATHS
SKELETAL MALFORMATIONS
SKIN CONTACT:
ADVERSE SYMPTOMS MAY INCLUDE THE FOLLOWING:
REDUCED FETAL WEIGHT
INCREASE IN FETAL DEATHS
SKELETAL MALFORMATIONS
INGESTION:
ADVERSE SYMPTOMS MAY INCLUDE THE FOLLOWING:
NAUSEA OR VOMITING
REDUCED FETAL WEIGHT
INCREASE IN FETAL DEATHS
SKELETAL MALFORMATIONS
DELAYED AND IMMEDIATE EFFECTS AND ALSO CHRONIC EFFECTS FROM SHORT AND
LONG TERM EXPOSURE:
SHORT TERM EXPOSURE:
POTENTIAL IMMEDIATE EFFECTS: NOT AVAILABLE.
POTENTIAL DELAYED EFFECTS: NOT AVAILABLE.
LONG TERM EXPOSURE:
POTENTIAL IMMEDIATE EFFECTS: NOT AVAILABLE.
POTENTIAL DELAYED EFFECTS: NOT AVAILABLE.
POTENTIAL CHRONIC HEALTH EFFECTS: NOT AVAILABLE.
GENERAL: MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE.
CARCINOGENICITY: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
MUTAGENICITY: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
TERATOGENICITY: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
DEVELOPMENTAL EFFECTS: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
FERTILITY EFFECTS: SUSPECTED OF DAMAGING FERTILITY.
NUMERICAL MEASURES OF TOXICITY:
ACUTE TOXICITY ESTIMATES:
ROUTE ATE VALUE
ORAL 2376.2 MG/KG
DERMAL 2615.1 MG/KG
INHALATION (VAPORS) 165 MG/L
| SECTION 12. ECOLOGICAL INFORMATION | |
TOXICITY:
PRODUCT/INGREDIENT RESULT SPECIES EXPOSURE
NAME
OCTAMETHYLCYCLO- CHRONIC NOEC: DAPHNIA - DAPHNIA 21 DAYS
TETRASILOXANE 1.7 TO 15 (MICRO)G/L MAGNA
FRESH WATER
CHRONIC NOEC: FISH - ONCORHYNCHUS 93 DAYS
4.4 (MICRO)G/L MYKISS - EGG
FRESH WATER
ACETIC ACID ACUTE EC50: ALGAE - NAVICULA 96 HOURS
73400 (MICRO)G/L SEMINULUM
FRESH WATER
ACUTE EC50: DAPHNIA - DAPHNIA 48 HOURS
65000 (MICRO)G/L MAGNA - NEONATE
FRESH WATER
ACUTE LC50: CRUSTACEANS - ARTEMIA 48 HOURS
50.1 UL/L SP.
MARINE WATER
ACUTE LC50: FISH - LEPOMIS 96 HOURS
75000 (MICRO)G/L MACROCHIRUS
FRESH WATER
PERSISTENCE AND DEGRADABILITY: NOT AVAILABLE.
BIOACCUMULATIVE POTENTIAL:
PRODUCT/INGREDIENT NAME LOGPOW BCF POTENTIAL
OCTAMETHYLCYCLOTETRASILOXANE 13400 HIGH
ACETIC ACID 3.16 LOW
MOBILITY IN SOIL:
SOIL/WATER PARTITION COEFFICIENT (KOC): NOT AVAILABLE.
OTHER ADVERSE EFFECTS: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
| SECTION 13. DISPOSAL CONSIDERATIONS | |
DISPOSAL METHODS:
THE GENERATION OF WASTE SHOULD BE AVOIDED OR MINIMIZED WHEREVER POSSIBLE.
DISPOSAL OF THIS PRODUCT, SOLUTIONS AND ANY BY-PRODUCTS SHOULD AT ALL TIMES
COMPLY WITH THE REQUIREMENTS OF ENVIRONMENTAL PROTECTION AND WASTE DISPOSAL
LEGISLATION AND ANY REGIONAL LOCAL AUTHORITY REQUIREMENTS. DISPOSE OF
SURPLUS AND NON-RECYCLABLE PRODUCTS VIA A LICENSED WASTE DISPOSAL
CONTRACTOR. WASTE SHOULD NOT BE DISPOSED OF UNTREATED TO THE SEWER UNLESS
FULLY COMPLIANT WITH THE REQUIREMENTS OF ALL AUTHORITIES WITH JURISDICTION.
WASTE PACKAGING SHOULD BE RECYCLED. INCINERATION OR LANDFILL SHOULD ONLY
BE CONSIDERED WHEN RECYCLING IS NOT FEASIBLE. THIS MATERIAL AND ITS
CONTAINER MUST BE DISPOSED OF IN A SAFE WAY. CARE SHOULD BE TAKEN WHEN
HANDLING EMPTIED CONTAINERS THAT HAVE NOT BEEN CLEANED OR RINSED OUT. EMPTY
CONTAINERS OR LINERS MAY RETAIN SOME PRODUCT RESIDUES. AVOID DISPERSAL OF
SPILLED MATERIAL AND RUNOFF AND CONTACT WITH SOIL, WATERWAYS, DRAINS AND
SEWERS.
| SECTION 14. TRANSPORT INFORMATION | |
DOT TDG MEXICO
CLASSIFICATION CLASSIFICATION CLASSIFICATION
UN NUMBER NOT REGULATED. NOT REGULATED. NOT REGULATED.
UN PROPER SHIPPING NAME
TRANSPORT HAZARD
CLASS(ES)
PACKING GROUP
ENVIRONMENTAL HAZARDS NO. NO. NO.
ADDITIONAL INFORMATION SPECIAL SPECIAL SPECIAL
PROVISIONS: PROVISIONS: PROVISIONS:
NOT APPLICABLE NOT APPLICABLE NOT APPLICABLE
IATA IMDG
UN NUMBER NOT REGULATED. NOT REGULATED.
UN PROPER SHIPPING NAME
TRANSPORT HAZARD CLASS(ES)
PACKING GROUP
ENVIRONMENTAL HAZARDS NO. NO.
ADDITIONAL INFORMATION SPECIAL PROVISIONS: EMERGENCY SCHEDULES
NOT APPLICABLE (EMS): NOT APPLICABLE
SPECIAL PRECAUTIONS FOR USER:
MULTI-MODAL SHIPPING DESCRIPTIONS ARE PROVIDED FOR INFORMATIONAL PURPOSES
AND DO NOT CONSIDER CONTAINER SIZES. THE PRESENCE OF A SHIPPING DESCRIPTION
FOR A PARTICULAR MODE OF TRANSPORT (SEA, AIR, ETC.), DOES NOT INDICATE THAT
THE PRODUCT IS PACKAGED SUITABLY FOR THAT MODE OF TRANSPORT. ALL PACKAGING
MUST BE REVIEWED FOR SUITABILITY PRIOR TO SHIPMENT, AND COMPLIANCE WITH THE
APPLICABLE REGULATIONS IS THE SOLE RESPONSIBILITY OF THE PERSON OFFERING
THE PRODUCT FOR TRANSPORT. PEOPLE LOADING AND UNLOADING DANGEROUS GOODS
MUST BE TRAINED ON ALL OF THE RISKS DERIVING FROM THE SUBSTANCES AND ON
ALL ACTIONS IN CASE OF EMERGENCY SITUATIONS.
TRANSPORT IN BULK ACCORDING TO ANNEX II OF MARPOL 73/78 AND THE IBC CODE:
NOT AVAILABLE.
| SECTION 15. REGULATORY INFORMATION | |
U.S. FEDERAL REGULATIONS:
STATE REGULATIONS:
| SECTION 16. OTHER INFORMATION | |
HAZARDOUS MATERIAL INFORMATION SYSTEM (U.S.A.):
HEALTH 3
FLAMMABILITY 0
PHYSICAL HAZARDS 0
CAUTION:
HMIS(R*) RATINGS ARE BASED ON A 0-4 RATING SCALE, WITH 0 REPRESENTING
MINIMAL HAZARDS OR RISKS, AND 4 REPRESENTING SIGNIFICANT HAZARDS OR RISKS
ALTHOUGH HMIS(R*) RATINGS ARE NOT REQUIRED ON SDSS UNDER 29 CFR 1910.1200,
THE PREPARER MAY CHOOSE TO PROVIDE THEM. HMIS(R*) RATINGS ARE TO BE USED
WITH A FULLY IMPLEMENTED HMIS(R*) PROGRAM. HMIS(R*) IS A REGISTERED MARK
OF THE NATIONAL PAINT & COATINGS ASSOCIATION (NPCA). HMIS(R*) MATERIALS
MAY BE PURCHASED EXCLUSIVELY FROM J. J. KELLER (800) 327-6868.
THE CUSTOMER IS RESPONSIBLE FOR DETERMINING THE PPE CODE FOR THIS MATERIAL.
NOTICE TO READER:
IT IS RECOMMENDED THAT EACH CUSTOMER OR RECIPIENT OF THIS SAFETY DATA
SHEET (SDS) STUDY IT CAREFULLY AND CONSULT RESOURCES, AS NECESSARY OR
APPROPRIATE, TO BECOME AWARE OF AND UNDERSTAND THE DATA CONTAINED IN THIS
SDS AND ANY HAZARDS ASSOCIATED WITH THE PRODUCT. THIS INFORMATION IS
PROVIDED IN GOOD FAITH AND BELIEVED TO BE ACCURATE AS OF THE EFFECTIVE
DATE HEREIN. HOWEVER, NO WARRANTY, EXPRESS OR IMPLIED, IS GIVEN. THE
INFORMATION PRESENTED HERE APPLIES ONLY TO THE PRODUCT AS SHIPPED. THE
ADDITION OF ANY MATERIAL CAN CHANGE THE COMPOSITION, HAZARDS AND RISKS OF
THE PRODUCT. REGULATORY REQUIREMENTS ARE SUBJECT TO CHANGE AND MAY DIFFER
BETWEEN VARIOUS LOCATIONS AND JURISDICTIONS. THE CUSTOMER/BUYER/USER IS
RESPONSIBLE TO ENSURE THAT HIS ACTIVITIES COMPLY WITH ALL COUNTRY, FEDERAL,
STATE, PROVINCIAL OR LOCAL LAWS. THE CONDITIONS FOR USE OF THE PRODUCT ARE
NOT UNDER THE CONTROL OF THE MANUFACTURER; THE CUSTOMER/BUYER/USER IS
RESPONSIBLE TO DETERMINE THE CONDITIONS NECESSARY FOR THE SAFE USE OF THIS
PRODUCT. THE CUSTOMER/BUYER/USER SHOULD NOT USE THE PRODUCT FOR ANY PURPOSE
OTHER THAN THE PURPOSE SHOWN IN THE APPLICABLE SECTION OF THIS SDS WITHOUT
FIRST REFERRING TO THE SUPPLIER AND OBTAINING WRITTEN HANDLING
INSTRUCTIONS. DUE TO THE PROLIFERATION OF SOURCES FOR INFORMATION SUCH
AS MANUFACTURER-SPECIFIC SDS, THE MANUFACTURER CANNOT BE RESPONSIBLE FOR
SDSS OBTAINED FROM ANY OTHER SOURCE.
DATE OF ISSUE/DATE OF REVISION: 7/2/2015.
DATE OF PREVIOUS ISSUE: 6/11/2015.
VERSION: 1.01
SAFETY DATA SHEET
WL099112W
| SECTION 1. IDENTIFICATION | |
PRODUCT NAME: WHITE LIGHTNING(R*) RTV SILICONE WHITE
PRODUCT CODE: WL099112W
OTHER MEANS OF IDENTIFICATION: NOT AVAILABLE.
PRODUCT TYPE: LIQUID.
RELEVANT IDENTIFIED USES OF THE SUBSTANCE OR MIXTURE AND USES ADVISED
AGAINST: NOT APPLICABLE.
MANUFACTURER:
WHITE LIGHTNING PRODUCTS
101 WEST PROSPECT AVENUE
CLEVELAND, OHIO 44115
EMERGENCY TELEPHONE NUMBER OF THE COMPANY: (216) 566-2917
PRODUCT INFORMATION TELEPHONE NUMBER: (800) 241-5295
REGULATORY INFORMATION TELEPHONE NUMBER: (216) 566-2902
TRANSPORTATION EMERGENCY TELEPHONE NUMBER: (800) 424-9300
| SECTION 2. HAZARDS IDENTIFICATION | |
OSHA/HCS STATUS:
THIS MATERIAL IS CONSIDERED HAZARDOUS BY THE OSHA HAZARD COMMUNICATION
STANDARD (29 CFR 1910.1200).
CLASSIFICATION OF THE SUBSTANCE OR MIXTURE:
SERIOUS EYE DAMAGE/EYE IRRITATION: CATEGORY 2A
CARCINOGENICITY: CATEGORY 2
TOXIC TO REPRODUCTION (FERTILITY): CATEGORY 2
SPECIFIC TARGET ORGAN TOXICITY (REPEATED EXPOSURE): CATEGORY 2
ASPIRATION HAZARD: CATEGORY 1
PERCENTAGE OF THE MIXTURE CONSISTING OF INGREDIENT(S) OF UNKNOWN TOXICITY:
14.1%
GHS LABEL ELEMENTS:
HAZARD PICTOGRAMS:
HEALTH HAZARD
EXCLAMATION MARK
SIGNAL WORD: DANGER
HAZARD STATEMENTS:
CAUSES SERIOUS EYE IRRITATION.
SUSPECTED OF DAMAGING FERTILITY.
SUSPECTED OF CAUSING CANCER.
MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS.
MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE.
PRECAUTIONARY STATEMENTS:
GENERAL:
READ LABEL BEFORE USE. KEEP OUT OF REACH OF CHILDREN. IF MEDICAL ADVICE
IS NEEDED, HAVE PRODUCT CONTAINER OR LABEL AT HAND.
PREVENTION:
OBTAIN SPECIAL INSTRUCTIONS BEFORE USE. DO NOT HANDLE UNTIL ALL SAFETY
PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD. WEAR PROTECTIVE GLOVES. WEAR
EYE OR FACE PROTECTION. WEAR PROTECTIVE CLOTHING. DO NOT BREATHE VAPOR.
WASH HANDS THOROUGHLY AFTER HANDLING.
RESPONSE: GET MEDICAL ATTENTION IF YOU FEEL UNWELL.
IF EXPOSED OR CONCERNED: GET MEDICAL ATTENTION.
IF SWALLOWED:
IMMEDIATELY CALL A POISON CENTER OR PHYSICIAN. DO NOT INDUCE VOMITING.
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES, IF
PRESENT AND EASY TO DO. CONTINUE RINSING.
IF EYE IRRITATION PERSISTS: GET MEDICAL ATTENTION.
STORAGE: STORE LOCKED UP.
DISPOSAL:
DISPOSE OF CONTENTS AND CONTAINER IN ACCORDANCE WITH ALL LOCAL, REGIONAL,
NATIONAL AND INTERNATIONAL REGULATIONS.
SUPPLEMENTAL LABEL ELEMENTS:
DELAYED EFFECTS FROM LONG TERM OVEREXPOSURE. CONTAINS SOLVENTS WHICH
CAN CAUSE PERMANENT BRAIN AND NERVOUS SYSTEM DAMAGE. INTENTIONAL MISUSE
BY DELIBERATELY CONCENTRATING AND INHALING THE CONTENTS CAN BE HARMFUL OR
FATAL.
WARNING:
THIS PRODUCT CONTAINS CHEMICALS KNOWN TO THE STATE OF CALIFORNIA TO CAUSE
CANCER.
PLEASE REFER TO THE SDS FOR ADDITIONAL INFORMATION. DO NOT TRANSFER
CONTENTS TO OTHER CONTAINERS FOR STORAGE.
HAZARDS NOT OTHERWISE CLASSIFIED: NONE KNOWN.
| SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
SUBSTANCE/MIXTURE: MIXTURE
OTHER MEANS OF IDENTIFICATION: NOT AVAILABLE.
CAS NUMBER/OTHER IDENTIFIERS:
INGREDIENT NAME % BY WEIGHT CAS NUMBER
OCTAMETHYLCYCLOTETRASILOXANE 24.5 556-67-2
MIDDLE PETROLEUM DISTILLATES 9.1 64742-46-7
HYDROTREATED HEAVY PETROLEUM NAPHTHA 9.0 64742-48-9
POLY(DIMETHYLSILOXANE) 2.0 63148-62-9
ACETIC ACID 1.0 64-19-7
TITANIUM DIOXIDE 0.5 13463-67-7
CARBON BLACK 0.5 1333-86-4
THERE ARE NO ADDITIONAL INGREDIENTS PRESENT WHICH, WITHIN THE CURRENT
KNOWLEDGE OF THE SUPPLIER AND IN THE CONCENTRATIONS APPLICABLE, ARE
CLASSIFIED AS HAZARDOUS TO HEALTH OR THE ENVIRONMENT AND HENCE REQUIRE
REPORTING IN THIS SECTION.
OCCUPATIONAL EXPOSURE LIMITS, IF AVAILABLE, ARE LISTED IN SECTION 8.
| SECTION 4. FIRST AID MEASURES | |
DESCRIPTION OF NECESSARY FIRST AID MEASURES:
EYE CONTACT:
IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER, OCCASIONALLY LIFTING THE
UPPER AND LOWER EYELIDS. CHECK FOR AND REMOVE ANY CONTACT LENSES. CONTINUE
TO RINSE FOR AT LEAST 10 MINUTES. GET MEDICAL ATTENTION.
INHALATION:
REMOVE VICTIM TO FRESH AIR AND KEEP AT REST IN A POSITION COMFORTABLE FOR
BREATHING. IF NOT BREATHING, IF BREATHING IS IRREGULAR OR IF RESPIRATORY
ARREST OCCURS, PROVIDE ARTIFICIAL RESPIRATION OR OXYGEN BY TRAINED
PERSONNEL. IT MAY BE DANGEROUS TO THE PERSON PROVIDING AID TO GIVE
MOUTH-TO-MOUTH RESUSCITATION. GET MEDICAL ATTENTION. IF UNCONSCIOUS, PLACE
IN RECOVERY POSITION AND GET MEDICAL ATTENTION IMMEDIATELY. MAINTAIN AN
OPEN AIRWAY. LOOSEN TIGHT CLOTHING SUCH AS A COLLAR, TIE, BELT OR
WAISTBAND.
SKIN CONTACT:
FLUSH CONTAMINATED SKIN WITH PLENTY OF WATER. REMOVE CONTAMINATED CLOTHING
AND SHOES. CONTINUE TO RINSE FOR AT LEAST 10 MINUTES. GET MEDICAL
ATTENTION. WASH CLOTHING BEFORE REUSE. CLEAN SHOES THOROUGHLY BEFORE
REUSE.
INGESTION:
GET MEDICAL ATTENTION IMMEDIATELY. CALL A POISON CENTER OR PHYSICIAN. WASH
OUT MOUTH WITH WATER. REMOVE DENTURES IF ANY. REMOVE VICTIM TO FRESH AIR
AND KEEP AT REST IN A POSITION COMFORTABLE FOR BREATHING. IF MATERIAL HAS
BEEN SWALLOWED AND THE EXPOSED PERSON IS CONSCIOUS, GIVE SMALL QUANTITIES
OF WATER TO DRINK. STOP IF THE EXPOSED PERSON FEELS SICK AS VOMITING MAY
BE DANGEROUS. ASPIRATION HAZARD IF SWALLOWED. CAN ENTER LUNGS AND CAUSE
DAMAGE. DO NOT INDUCE VOMITING. IF VOMITING OCCURS, THE HEAD SHOULD BE KEPT
LOW SO THAT VOMIT DOES NOT ENTER THE LUNGS. NEVER GIVE ANYTHING BY MOUTH
TO AN UNCONSCIOUS PERSON. IF UNCONSCIOUS, PLACE IN RECOVERY POSITION AND
GET MEDICAL ATTENTION IMMEDIATELY. MAINTAIN AN OPEN AIRWAY. LOOSEN TIGHT
CLOTHING SUCH AS A COLLAR, TIE, BELT OR WAISTBAND.
MOST IMPORTANT SYMPTOMS/EFFECTS, ACUTE AND DELAYED:
POTENTIAL ACUTE HEALTH EFFECTS:
EYE CONTACT: CAUSES SERIOUS EYE IRRITATION.
INHALATION: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
SKIN CONTACT: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
INGESTION: MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS.
OVER-EXPOSURE SIGNS/SYMPTOMS:
EYE CONTACT:
ADVERSE SYMPTOMS MAY INCLUDE THE FOLLOWING:
PAIN OR IRRITATION
WATERING
REDNESS
INHALATION:
ADVERSE SYMPTOMS MAY INCLUDE THE FOLLOWING:
REDUCED FETAL WEIGHT
INCREASE IN FETAL DEATHS
SKELETAL MALFORMATIONS
SKIN CONTACT:
ADVERSE SYMPTOMS MAY INCLUDE THE FOLLOWING:
REDUCED FETAL WEIGHT
INCREASE IN FETAL DEATHS
SKELETAL MALFORMATIONS
INGESTION:
ADVERSE SYMPTOMS MAY INCLUDE THE FOLLOWING:
NAUSEA OR VOMITING
REDUCED FETAL WEIGHT
INCREASE IN FETAL DEATHS
SKELETAL MALFORMATIONS
INDICATION OF IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED,
IF NECESSARY:
NOTES TO PHYSICIAN:
TREAT SYMPTOMATICALLY. CONTACT POISON TREATMENT SPECIALIST IMMEDIATELY
IF LARGE QUANTITIES HAVE BEEN INGESTED OR INHALED.
SPECIFIC TREATMENTS: NO SPECIFIC TREATMENT.
PROTECTION OF FIRST-AIDERS:
NO ACTION SHALL BE TAKEN INVOLVING ANY PERSONAL RISK OR WITHOUT SUITABLE
TRAINING. IT MAY BE DANGEROUS TO THE PERSON PROVIDING AID TO GIVE
MOUTH-TO-MOUTH RESUSCITATION.
SEE TOXICOLOGICAL INFORMATION (SECTION 11)
| SECTION 5. FIRE-FIGHTING MEASURES | |
EXTINGUISHING MEDIA:
SUITABLE EXTINGUISHING MEDIA:
USE AN EXTINGUISHING AGENT SUITABLE FOR THE SURROUNDING FIRE.
UNSUITABLE EXTINGUISHING MEDIA: NONE KNOWN.
SPECIFIC HAZARDS ARISING FROM THE CHEMICAL:
IN A FIRE OR IF HEATED, A PRESSURE INCREASE WILL OCCUR AND THE CONTAINER
MAY BURST.
HAZARDOUS THERMAL DECOMPOSITION PRODUCTS:
DECOMPOSITION PRODUCTS MAY INCLUDE THE FOLLOWING MATERIALS:
CARBON DIOXIDE
CARBON MONOXIDE
METAL OXIDE/OXIDES
SPECIAL PROTECTIVE ACTIONS FOR FIRE-FIGHTERS:
PROMPTLY ISOLATE THE SCENE BY REMOVING ALL PERSONS FROM THE VICINITY OF
THE INCIDENT IF THERE IS A FIRE. NO ACTION SHALL BE TAKEN INVOLVING ANY
PERSONAL RISK OR WITHOUT SUITABLE TRAINING.
SPECIAL PROTECTIVE EQUIPMENT FOR FIRE-FIGHTERS:
FIRE-FIGHTERS SHOULD WEAR APPROPRIATE PROTECTIVE EQUIPMENT AND
SELF-CONTAINED BREATHING APPARATUS (SCBA) WITH A FULL FACE-PIECE OPERATED
IN POSITIVE PRESSURE MODE.
| SECTION 6. ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
FOR NON-EMERGENCY PERSONNEL:
NO ACTION SHALL BE TAKEN INVOLVING ANY PERSONAL RISK OR WITHOUT SUITABLE
TRAINING. EVACUATE SURROUNDING AREAS. KEEP UNNECESSARY AND UNPROTECTED
PERSONNEL FROM ENTERING. DO NOT TOUCH OR WALK THROUGH SPILLED MATERIAL.
AVOID BREATHING VAPOR OR MIST. PROVIDE ADEQUATE VENTILATION. WEAR
APPROPRIATE RESPIRATOR WHEN VENTILATION IS INADEQUATE. PUT ON APPROPRIATE
PERSONAL PROTECTIVE EQUIPMENT.
FOR EMERGENCY RESPONDERS:
IF SPECIALISED CLOTHING IS REQUIRED TO DEAL WITH THE SPILLAGE, TAKE NOTE
OF ANY INFORMATION IN SECTION 8 ON SUITABLE AND UNSUITABLE MATERIALS. SEE
ALSO THE INFORMATION IN "FOR NON-EMERGENCY PERSONNEL".
ENVIRONMENTAL PRECAUTIONS:
AVOID DISPERSAL OF SPILLED MATERIAL AND RUNOFF AND CONTACT WITH SOIL,
WATERWAYS, DRAINS AND SEWERS. INFORM THE RELEVANT AUTHORITIES IF THE
PRODUCT HAS CAUSED ENVIRONMENTAL POLLUTION (SEWERS, WATERWAYS, SOIL OR
AIR).
METHODS AND MATERIALS FOR CONTAINMENT AND CLEANING UP:
SMALL SPILL:
STOP LEAK IF WITHOUT RISK. MOVE CONTAINERS FROM SPILL AREA. DILUTE WITH
WATER AND MOP UP IF WATER-SOLUBLE. ALTERNATIVELY, OR IF WATER-INSOLUBLE,
ABSORB WITH AN INERT DRY MATERIAL AND PLACE IN AN APPROPRIATE WASTE
DISPOSAL CONTAINER. DISPOSE OF VIA A LICENSED WASTE DISPOSAL CONTRACTOR.
LARGE SPILL:
STOP LEAK IF WITHOUT RISK. MOVE CONTAINERS FROM SPILL AREA. APPROACH
RELEASE FROM UPWIND. PREVENT ENTRY INTO SEWERS, WATER COURSES, BASEMENTS
OR CONFINED AREAS. WASH SPILLAGES INTO AN EFFLUENT TREATMENT PLANT OR
PROCEED AS FOLLOWS. CONTAIN AND COLLECT SPILLAGE WITH NON-COMBUSTIBLE,
ABSORBENT MATERIAL E.G. SAND, EARTH, VERMICULITE OR DIATOMACEOUS EARTH
AND PLACE IN CONTAINER FOR DISPOSAL ACCORDING TO LOCAL REGULATIONS
(SEE SECTION 13). DISPOSE OF VIA A LICENSED WASTE DISPOSAL CONTRACTOR.
CONTAMINATED ABSORBENT MATERIAL MAY POSE THE SAME HAZARD AS THE SPILLED
PRODUCT.
NOTE:
SEE SECTION 1 FOR EMERGENCY CONTACT INFORMATION AND SECTION 13 FOR WASTE
DISPOSAL.
| SECTION 7. HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING:
PROTECTIVE MEASURES:
PUT ON APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT (SEE SECTION 8). AVOID
EXPOSURE - OBTAIN SPECIAL INSTRUCTIONS BEFORE USE. AVOID EXPOSURE DURING
PREGNANCY. DO NOT HANDLE UNTIL ALL SAFETY PRECAUTIONS HAVE BEEN READ AND
UNDERSTOOD. DO NOT GET IN EYES OR ON SKIN OR CLOTHING. DO NOT BREATHE VAPOR
OR MIST. DO NOT SWALLOW. IF DURING NORMAL USE THE MATERIAL PRESENTS A
RESPIRATORY HAZARD, USE ONLY WITH ADEQUATE VENTILATION OR WEAR APPROPRIATE
RESPIRATOR. KEEP IN THE ORIGINAL CONTAINER OR AN APPROVED ALTERNATIVE MADE
FROM A COMPATIBLE MATERIAL, KEPT TIGHTLY CLOSED WHEN NOT IN USE. EMPTY
CONTAINERS RETAIN PRODUCT RESIDUE AND CAN BE HAZARDOUS. DO NOT REUSE
CONTAINER.
ADVICE ON GENERAL OCCUPATIONAL HYGIENE:
EATING, DRINKING AND SMOKING SHOULD BE PROHIBITED IN AREAS WHERE THIS
MATERIAL IS HANDLED, STORED AND PROCESSED. WORKERS SHOULD WASH HANDS AND
FACE BEFORE EATING, DRINKING AND SMOKING. REMOVE CONTAMINATED CLOTHING AND
PROTECTIVE EQUIPMENT BEFORE ENTERING EATING AREAS. SEE ALSO SECTION 8 FOR
ADDITIONAL INFORMATION ON HYGIENE MEASURES.
CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES:
STORE IN ACCORDANCE WITH LOCAL REGULATIONS. STORE IN ORIGINAL CONTAINER
PROTECTED FROM DIRECT SUNLIGHT IN A DRY, COOL AND WELL-VENTILATED AREA,
AWAY FROM INCOMPATIBLE MATERIALS (SEE SECTION 10) AND FOOD AND DRINK.
STORE LOCKED UP. KEEP CONTAINER TIGHTLY CLOSED AND SEALED UNTIL READY FOR
USE. CONTAINERS THAT HAVE BEEN OPENED MUST BE CAREFULLY RESEALED AND KEPT
UPRIGHT TO PREVENT LEAKAGE. DO NOT STORE IN UNLABELED CONTAINERS. USE
APPROPRIATE CONTAINMENT TO AVOID ENVIRONMENTAL CONTAMINATION.
| SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
CONTROL PARAMETERS:
OCCUPATIONAL EXPOSURE LIMITS:
INGREDIENT NAME EXPOSURE LIMITS
ACETIC ACID ACGIH TLV (UNITED STATES, 3/2015).
TWA: 10 PPM 8 HOURS.
TWA: 25 MG/M3 8 HOURS.
STEL: 15 PPM 15 MINUTES.
STEL: 37 MG/M3 15 MINUTES.
NIOSH REL (UNITED STATES, 10/2013).
TWA: 10 PPM 10 HOURS.
TWA: 25 MG/M3 10 HOURS.
STEL: 15 PPM 15 MINUTES.
STEL: 37 MG/M3 15 MINUTES.
OSHA PEL (UNITED STATES, 2/2013).
TWA: 10 PPM 8 HOURS.
TWA: 25 MG/M3 8 HOURS.
TITANIUM DIOXIDE ACGIH TLV (UNITED STATES, 3/2015).
TWA: 10 MG/M3 8 HOURS.
OSHA PEL (UNITED STATES, 2/2013).
TWA: 15 MG/M3 8 HOURS.
FORM: TOTAL DUST
CARBON BLACK NIOSH REL (UNITED STATES, 10/2013).
TWA: 3.5 MG/M3 10 HOURS.
TWA: 0.1 MG OF PAHS/CM3 10 HOURS.
OSHA PEL (UNITED STATES, 2/2013).
TWA: 3.5 MG/M3 8 HOURS.
ACGIH TLV (UNITED STATES, 3/2015).
TWA: 3 MG/M3 8 HOURS.
FORM: INHALABLE FRACTION
APPROPRIATE ENGINEERING CONTROLS:
IF USER OPERATIONS GENERATE DUST, FUMES, GAS, VAPOR OR MIST, USE PROCESS
ENCLOSURES, LOCAL EXHAUST VENTILATION OR OTHER ENGINEERING CONTROLS TO
KEEP WORKER EXPOSURE TO AIRBORNE CONTAMINANTS BELOW ANY RECOMMENDED OR
STATUTORY LIMITS.
ENVIRONMENTAL EXPOSURE CONTROLS:
EMISSIONS FROM VENTILATION OR WORK PROCESS EQUIPMENT SHOULD BE CHECKED
TO ENSURE THEY COMPLY WITH THE REQUIREMENTS OF ENVIRONMENTAL PROTECTION
LEGISLATION. IN SOME CASES, FUME SCRUBBERS, FILTERS OR ENGINEERING
MODIFICATIONS TO THE PROCESS EQUIPMENT WILL BE NECESSARY TO REDUCE
EMISSIONS TO ACCEPTABLE LEVELS.
INDIVIDUAL PROTECTION MEASURES:
HYGIENE MEASURES:
WASH HANDS, FOREARMS AND FACE THOROUGHLY AFTER HANDLING CHEMICAL PRODUCTS,
BEFORE EATING, SMOKING AND USING THE LAVATORY AND AT THE END OF THE WORKING
PERIOD. APPROPRIATE TECHNIQUES SHOULD BE USED TO REMOVE POTENTIALLY
CONTAMINATED CLOTHING. WASH CONTAMINATED CLOTHING BEFORE REUSING. ENSURE
THAT EYEWASH STATIONS AND SAFETY SHOWERS ARE CLOSE TO THE WORKSTATION
LOCATION.
EYE/FACE PROTECTION:
SAFETY EYEWEAR COMPLYING WITH AN APPROVED STANDARD SHOULD BE USED WHEN A
RISK ASSESSMENT INDICATES THIS IS NECESSARY TO AVOID EXPOSURE TO LIQUID
SPLASHES, MISTS, GASES OR DUSTS. IF CONTACT IS POSSIBLE, THE FOLLOWING
PROTECTION SHOULD BE WORN, UNLESS THE ASSESSMENT INDICATES A HIGHER DEGREE
OF PROTECTION: CHEMICAL SPLASH GOGGLES.
SKIN PROTECTION:
HAND PROTECTION:
CHEMICAL-RESISTANT, IMPERVIOUS GLOVES COMPLYING WITH AN APPROVED STANDARD
SHOULD BE WORN AT ALL TIMES WHEN HANDLING CHEMICAL PRODUCTS IF A RISK
ASSESSMENT INDICATES THIS IS NECESSARY. CONSIDERING THE PARAMETERS
SPECIFIED BY THE GLOVE MANUFACTURER, CHECK DURING USE THAT THE GLOVES ARE
STILL RETAINING THEIR PROTECTIVE PROPERTIES. IT SHOULD BE NOTED THAT THE
TIME TO BREAKTHROUGH FOR ANY GLOVE MATERIAL MAY BE DIFFERENT FOR DIFFERENT
GLOVE MANUFACTURERS. IN THE CASE OF MIXTURES, CONSISTING OF SEVERAL
SUBSTANCES, THE PROTECTION TIME OF THE GLOVES CANNOT BE ACCURATELY
ESTIMATED.
BODY PROTECTION:
PERSONAL PROTECTIVE EQUIPMENT FOR THE BODY SHOULD BE SELECTED BASED ON
THE TASK BEING PERFORMED AND THE RISKS INVOLVED AND SHOULD BE APPROVED BY
A SPECIALIST BEFORE HANDLING THIS PRODUCT.
OTHER SKIN PROTECTION:
APPROPRIATE FOOTWEAR AND ANY ADDITIONAL SKIN PROTECTION MEASURES SHOULD
BE SELECTED BASED ON THE TASK BEING PERFORMED AND THE RISKS INVOLVED AND
SHOULD BE APPROVED BY A SPECIALIST BEFORE HANDLING THIS PRODUCT.
RESPIRATORY PROTECTION:
USE A PROPERLY FITTED, AIR-PURIFYING OR AIR-FED RESPIRATOR COMPLYING WITH
AN APPROVED STANDARD IF A RISK ASSESSMENT INDICATES THIS IS NECESSARY.
RESPIRATOR SELECTION MUST BE BASED ON KNOWN OR ANTICIPATED EXPOSURE LEVELS,
THE HAZARDS OF THE PRODUCT AND THE SAFE WORKING LIMITS OF THE SELECTED
RESPIRATOR.
| SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE:
PHYSICAL STATE: LIQUID.
COLOR: NOT AVAILABLE.
ODOR: NOT AVAILABLE.
ODOR THRESHOLD: NOT AVAILABLE.
PH: NOT AVAILABLE.
MELTING POINT: NOT AVAILABLE.
BOILING POINT: 117 DEG. C (242.6 DEG. F)
FLASH POINT:
CLOSED CUP: >93.3 DEG. C (>199.9 DEG. F) [PENSKY-MARTENS CLOSED CUP]
EVAPORATION RATE: 0.97 (BUTYL ACETATE = 1)
FLAMMABILITY (SOLID, GAS): NOT AVAILABLE.
LOWER AND UPPER EXPLOSIVE (FLAMMABLE) LIMITS:
LOWER: 1.3%
UPPER: 19.3%
VAPOR PRESSURE: 0.13 KPA (1 MMHg) [AT 20 DEG. C]
VAPOR DENSITY: 2.07 [AIR = 1]
RELATIVE DENSITY: 1
SOLUBILITY: NOT AVAILABLE.
PARTITION COEFFICIENT N-OCTANOL/WATER: NOT AVAILABLE.
AUTO-IGNITION TEMPERATURE: NOT AVAILABLE.
DECOMPOSITION TEMPERATURE: NOT AVAILABLE.
VISCOSITY:
KINEMATIC (ROOM TEMPERATURE): <0.205 CM2/S (<20.5 CST)
KINEMATIC (40 DEG. C (104 DEG. F)): <0.205 CM2/S (<20.5 CST)
MOLECULAR WEIGHT: NOT APPLICABLE.
AEROSOL PRODUCT:
HEAT OF COMBUSTION: 9.925 KJ/G
| SECTION 10. STABILITY AND REACTIVITY | |
REACTIVITY:
NO SPECIFIC TEST DATA RELATED TO REACTIVITY AVAILABLE FOR THIS PRODUCT OR
ITS INGREDIENTS.
CHEMICAL STABILITY: THE PRODUCT IS STABLE.
POSSIBILITY OF HAZARDOUS REACTIONS:
UNDER NORMAL CONDITIONS OF STORAGE AND USE, HAZARDOUS REACTIONS WILL NOT
OCCUR.
CONDITIONS TO AVOID: NO SPECIFIC DATA.
INCOMPATIBLE MATERIALS: NO SPECIFIC DATA.
HAZARDOUS DECOMPOSITION PRODUCTS:
UNDER NORMAL CONDITIONS OF STORAGE AND USE, HAZARDOUS DECOMPOSITION
PRODUCTS SHOULD NOT BE PRODUCED.
| SECTION 11. TOXICOLOGICAL INFORMATION | |
INFORMATION ON TOXICOLOGICAL EFFECTS:
ACUTE TOXICITY:
PRODUCT/INGREDIENT RESULT SPECIES DOSE EXPOSURE
NAME
OCTAMETHYLCYCLO- LC50 INHALATION VAPOR RAT 36 G/M3 4 HOURS
TETRASILOXANE LD50 DERMAL RAT 1770 MG/KG
LD50 ORAL RAT 1540 MG/KG
HYDROTREATED HEAVY LC50 INHALATION VAPOR RAT 8500 MG/M3 4 HOURS
PETROLEUM NAPHTHA LD50 ORAL RAT >6 G/KG
ACETIC ACID LC50 INHALATION VAPOR RAT 11000 MG/M3 4 HOURS
LD50 DERMAL RABBIT 1060 MG/KG
LD50 ORAL RAT 3310 MG/KG
CARBON BLACK LD50 ORAL RAT >15400 MG/KG
IRRITATION/CORROSION:
PRODUCT/ RESULT SPECIES SCORE EXPOSURE OBSERVATION
INGREDIENT
NAME
OCTAMETHYL- EYES: RABBIT 24 HOURS
CYCLOTETRA- MILD IRRITANT 500 MILLIGRAMS
SILOXANE
SKIN: RABBIT 24 HOURS
MILD IRRITANT 500 MILLIGRAMS
POLY EYES: RABBIT 1 HOURS
(DIMETHYL- MILD IRRITANT 100 MILLIGRAMS
SILOXANE)
EYES: RABBIT 24 HOURS
MILD IRRITANT 100 MICROLITERS
EYES: RABBIT 24 HOURS
MODERATE 100 MICROLITERS
IRRITANT
SKIN: RABBIT 24 HOURS
MILD IRRITANT 500 MICROLITERS
ACETIC ACID EYES: RABBIT 0.5 MINUTES
MILD IRRITANT 5 MILLIGRAMS
SKIN: HUMAN 24 HOURS
MILD IRRITANT 50 MILLIGRAMS
SKIN: RABBIT 24 HOURS
MILD IRRITANT 50 MILLIGRAMS
SKIN: RABBIT 525 MILLIGRAMS
SEVERE IRRITANT
TITANIUM SKIN: HUMAN 72 HOURS
DIOXIDE MILD IRRITANT 300 MICROGRAMS
INTERMITTENT
SENSITIZATION: NOT AVAILABLE.
MUTAGENICITY: NOT AVAILABLE.
CARCINOGENICITY: NOT AVAILABLE.
CLASSIFICATION:
PRODUCT/INGREDIENT NAME OSHA IARC NTP
CARBON BLACK 2B
TITANIUM DIOXIDE 2B
REPRODUCTIVE TOXICITY: NOT AVAILABLE.
TERATOGENICITY: NOT AVAILABLE.
SPECIFIC TARGET ORGAN TOXICITY (SINGLE EXPOSURE):
NAME CATEGORY ROUTE OF EXPOSURE TARGET ORGANS
MIDDLE PETROLEUM CATEGORY 3 NOT APPLICABLE. RESPIRATORY TRACT
DISTILLATES IRRITATION AND
NARCOTIC EFFECTS
HYDROTREATED HEAVY CATEGORY 3 NOT APPLICABLE. RESPIRATORY TRACT
PETROLEUM NAPHTHA IRRITATION AND
NARCOTIC EFFECTS
SPECIFIC TARGET ORGAN TOXICITY (REPEATED EXPOSURE):
NAME CATEGORY ROUTE OF EXPOSURE TARGET ORGANS
MIDDLE PETROLEUM CATEGORY 2 NOT DETERMINED NOT DETERMINED
DISTILLATES
HYDROTREATED HEAVY CATEGORY 2 NOT DETERMINED NOT DETERMINED
PETROLEUM NAPHTHA
ASPIRATION HAZARD:
NAME RESULT
MIDDLE PETROLEUM DISTILLATES ASPIRATION HAZARD - CATEGORY 1
HYDROTREATED HEAVY PETROLEUM NAPHTHA ASPIRATION HAZARD - CATEGORY 1
INFORMATION ON THE LIKELY ROUTES OF EXPOSURE: NOT AVAILABLE.
POTENTIAL ACUTE HEALTH EFFECTS:
EYE CONTACT: CAUSES SERIOUS EYE IRRITATION.
INHALATION: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
SKIN CONTACT: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
INGESTION: MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS.
SYMPTOMS RELATED TO THE PHYSICAL, CHEMICAL AND TOXICOLOGICAL
CHARACTERISTICS:
EYE CONTACT:
ADVERSE SYMPTOMS MAY INCLUDE THE FOLLOWING:
PAIN OR IRRITATION
WATERING
REDNESS
INHALATION:
ADVERSE SYMPTOMS MAY INCLUDE THE FOLLOWING:
REDUCED FETAL WEIGHT
INCREASE IN FETAL DEATHS
SKELETAL MALFORMATIONS
SKIN CONTACT:
ADVERSE SYMPTOMS MAY INCLUDE THE FOLLOWING:
REDUCED FETAL WEIGHT
INCREASE IN FETAL DEATHS
SKELETAL MALFORMATIONS
INGESTION:
ADVERSE SYMPTOMS MAY INCLUDE THE FOLLOWING:
NAUSEA OR VOMITING
REDUCED FETAL WEIGHT
INCREASE IN FETAL DEATHS
SKELETAL MALFORMATIONS
DELAYED AND IMMEDIATE EFFECTS AND ALSO CHRONIC EFFECTS FROM SHORT AND
LONG TERM EXPOSURE:
SHORT TERM EXPOSURE:
POTENTIAL IMMEDIATE EFFECTS: NOT AVAILABLE.
POTENTIAL DELAYED EFFECTS: NOT AVAILABLE.
LONG TERM EXPOSURE:
POTENTIAL IMMEDIATE EFFECTS: NOT AVAILABLE.
POTENTIAL DELAYED EFFECTS: NOT AVAILABLE.
POTENTIAL CHRONIC HEALTH EFFECTS: NOT AVAILABLE.
GENERAL: MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE.
CARCINOGENICITY:
SUSPECTED OF CAUSING CANCER. RISK OF CANCER DEPENDS ON DURATION AND LEVEL
OF EXPOSURE.
MUTAGENICITY: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
TERATOGENICITY: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
DEVELOPMENTAL EFFECTS: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
FERTILITY EFFECTS: SUSPECTED OF DAMAGING FERTILITY.
NUMERICAL MEASURES OF TOXICITY:
ACUTE TOXICITY ESTIMATES:
ROUTE ATE VALUE
ORAL 4862 MG/KG
DERMAL 5809.9 MG/KG
INHALATION (VAPORS) 74.71 MG/L
| SECTION 12. ECOLOGICAL INFORMATION | |
TOXICITY:
PRODUCT/INGREDIENT RESULT SPECIES EXPOSURE
NAME
OCTAMETHYLCYCLO- CHRONIC NOEC: DAPHNIA - DAPHNIA 21 DAYS
TETRASILOXANE 1.7 TO 15 (MICRO)G/L MAGNA
FRESH WATER
CHRONIC NOEC: FISH - ONCORHYNCHUS 93 DAYS
4.4 (MICRO)G/L MYKISS - EGG
FRESH WATER
POLY ACUTE LC50: DAPHNIA - DAPHNIA 48 HOURS
(DIMETHYLSILOXANE) 44.5 PPM MAGNA - INSTAR
FRESH WATER
ACUTE LC50: FISH - ICTALURUS 96 HOURS
3160 (MICRO)G/L PUNCTATUS
FRESH WATER
ACETIC ACID ACUTE EC50: ALGAE - NAVICULA 96 HOURS
73400 (MICRO)G/L SEMINULUM
FRESH WATER
ACUTE EC50: DAPHNIA - DAPHNIA 48 HOURS
65000 (MICRO)G/L MAGNA - NEONATE
FRESH WATER
ACUTE LC50: CRUSTACEANS - ARTEMIA 48 HOURS
50.1 UL/L SP.
MARINE WATER
ACUTE LC50: FISH - LEPOMIS 96 HOURS
75000 (MICRO)G/L MACROCHIRUS
FRESH WATER
TITANIUM DIOXIDE ACUTE LC50: FISH - FUNDULUS 96 HOURS
>1000000 (MICRO)G/L HETEROCLITUS
MARINE WATER
PERSISTENCE AND DEGRADABILITY: NOT AVAILABLE.
BIOACCUMULATIVE POTENTIAL:
PRODUCT/INGREDIENT NAME LOGPOW BCF POTENTIAL
OCTAMETHYLCYCLOTETRASILOXANE 13400 HIGH
HYDROTREATED HEAVY PETROLEUM NAPHTHA 10 TO 2500 HIGH
ACETIC ACID 3.16 LOW
TITANIUM DIOXIDE 352 LOW
MOBILITY IN SOIL:
SOIL/WATER PARTITION COEFFICIENT (KOC): NOT AVAILABLE.
OTHER ADVERSE EFFECTS: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
| SECTION 13. DISPOSAL CONSIDERATIONS | |
DISPOSAL METHODS:
THE GENERATION OF WASTE SHOULD BE AVOIDED OR MINIMIZED WHEREVER POSSIBLE.
DISPOSAL OF THIS PRODUCT, SOLUTIONS AND ANY BY-PRODUCTS SHOULD AT ALL TIMES
COMPLY WITH THE REQUIREMENTS OF ENVIRONMENTAL PROTECTION AND WASTE DISPOSAL
LEGISLATION AND ANY REGIONAL LOCAL AUTHORITY REQUIREMENTS. DISPOSE OF
SURPLUS AND NON-RECYCLABLE PRODUCTS VIA A LICENSED WASTE DISPOSAL
CONTRACTOR. WASTE SHOULD NOT BE DISPOSED OF UNTREATED TO THE SEWER UNLESS
FULLY COMPLIANT WITH THE REQUIREMENTS OF ALL AUTHORITIES WITH JURISDICTION.
WASTE PACKAGING SHOULD BE RECYCLED. INCINERATION OR LANDFILL SHOULD ONLY
BE CONSIDERED WHEN RECYCLING IS NOT FEASIBLE. THIS MATERIAL AND ITS
CONTAINER MUST BE DISPOSED OF IN A SAFE WAY. CARE SHOULD BE TAKEN WHEN
HANDLING EMPTIED CONTAINERS THAT HAVE NOT BEEN CLEANED OR RINSED OUT. EMPTY
CONTAINERS OR LINERS MAY RETAIN SOME PRODUCT RESIDUES. AVOID DISPERSAL OF
SPILLED MATERIAL AND RUNOFF AND CONTACT WITH SOIL, WATERWAYS, DRAINS AND
SEWERS.
| SECTION 14. TRANSPORT INFORMATION | |
DOT TDG MEXICO
CLASSIFICATION CLASSIFICATION CLASSIFICATION
UN NUMBER NOT REGULATED. NOT REGULATED. NOT REGULATED.
UN PROPER SHIPPING NAME
TRANSPORT HAZARD
CLASS(ES)
PACKING GROUP
ENVIRONMENTAL HAZARDS NO. NO. NO.
ADDITIONAL INFORMATION SPECIAL SPECIAL SPECIAL
PROVISIONS: PROVISIONS: PROVISIONS:
NOT APPLICABLE NOT APPLICABLE NOT APPLICABLE
IATA IMDG
UN NUMBER NOT REGULATED. NOT REGULATED.
UN PROPER SHIPPING NAME
TRANSPORT HAZARD CLASS(ES)
PACKING GROUP
ENVIRONMENTAL HAZARDS NO. NO.
ADDITIONAL INFORMATION SPECIAL PROVISIONS: EMERGENCY SCHEDULES
NOT APPLICABLE (EMS): NOT APPLICABLE
SPECIAL PRECAUTIONS FOR USER:
MULTI-MODAL SHIPPING DESCRIPTIONS ARE PROVIDED FOR INFORMATIONAL PURPOSES
AND DO NOT CONSIDER CONTAINER SIZES. THE PRESENCE OF A SHIPPING DESCRIPTION
FOR A PARTICULAR MODE OF TRANSPORT (SEA, AIR, ETC.), DOES NOT INDICATE THAT
THE PRODUCT IS PACKAGED SUITABLY FOR THAT MODE OF TRANSPORT. ALL PACKAGING
MUST BE REVIEWED FOR SUITABILITY PRIOR TO SHIPMENT, AND COMPLIANCE WITH THE
APPLICABLE REGULATIONS IS THE SOLE RESPONSIBILITY OF THE PERSON OFFERING
THE PRODUCT FOR TRANSPORT. PEOPLE LOADING AND UNLOADING DANGEROUS GOODS
MUST BE TRAINED ON ALL OF THE RISKS DERIVING FROM THE SUBSTANCES AND ON
ALL ACTIONS IN CASE OF EMERGENCY SITUATIONS.
TRANSPORT IN BULK ACCORDING TO ANNEX II OF MARPOL 73/78 AND THE IBC CODE:
NOT AVAILABLE.
PROPER SHIPPING NAME: NOT AVAILABLE.
SHIP TYPE: NOT AVAILABLE.
POLLUTION CATEGORY: NOT AVAILABLE.
| SECTION 15. REGULATORY INFORMATION | |
U.S. FEDERAL REGULATIONS:
STATE REGULATIONS:
CALIFORNIA PROP. 65:
WARNING:
THIS PRODUCT CONTAINS CHEMICALS KNOWN TO THE STATE OF CALIFORNIA TO CAUSE
CANCER.
| SECTION 16. OTHER INFORMATION | |
HAZARDOUS MATERIAL INFORMATION SYSTEM (U.S.A.):
HEALTH 3*
FLAMMABILITY 0
PHYSICAL HAZARDS 0
CAUTION:
HMIS(R*) RATINGS ARE BASED ON A 0-4 RATING SCALE, WITH 0 REPRESENTING
MINIMAL HAZARDS OR RISKS, AND 4 REPRESENTING SIGNIFICANT HAZARDS OR RISKS
ALTHOUGH HMIS(R*) RATINGS ARE NOT REQUIRED ON SDSS UNDER 29 CFR 1910.1200,
THE PREPARER MAY CHOOSE TO PROVIDE THEM. HMIS(R*) RATINGS ARE TO BE USED
WITH A FULLY IMPLEMENTED HMIS(R*) PROGRAM. HMIS(R*) IS A REGISTERED MARK
OF THE NATIONAL PAINT & COATINGS ASSOCIATION (NPCA). HMIS(R*) MATERIALS
MAY BE PURCHASED EXCLUSIVELY FROM J. J. KELLER (800) 327-6868.
THE CUSTOMER IS RESPONSIBLE FOR DETERMINING THE PPE CODE FOR THIS MATERIAL.
NOTICE TO READER:
IT IS RECOMMENDED THAT EACH CUSTOMER OR RECIPIENT OF THIS SAFETY DATA
SHEET (SDS) STUDY IT CAREFULLY AND CONSULT RESOURCES, AS NECESSARY OR
APPROPRIATE, TO BECOME AWARE OF AND UNDERSTAND THE DATA CONTAINED IN THIS
SDS AND ANY HAZARDS ASSOCIATED WITH THE PRODUCT. THIS INFORMATION IS
PROVIDED IN GOOD FAITH AND BELIEVED TO BE ACCURATE AS OF THE EFFECTIVE
DATE HEREIN. HOWEVER, NO WARRANTY, EXPRESS OR IMPLIED, IS GIVEN. THE
INFORMATION PRESENTED HERE APPLIES ONLY TO THE PRODUCT AS SHIPPED. THE
ADDITION OF ANY MATERIAL CAN CHANGE THE COMPOSITION, HAZARDS AND RISKS OF
THE PRODUCT. REGULATORY REQUIREMENTS ARE SUBJECT TO CHANGE AND MAY DIFFER
BETWEEN VARIOUS LOCATIONS AND JURISDICTIONS. THE CUSTOMER/BUYER/USER IS
RESPONSIBLE TO ENSURE THAT HIS ACTIVITIES COMPLY WITH ALL COUNTRY, FEDERAL,
STATE, PROVINCIAL OR LOCAL LAWS. THE CONDITIONS FOR USE OF THE PRODUCT ARE
NOT UNDER THE CONTROL OF THE MANUFACTURER; THE CUSTOMER/BUYER/USER IS
RESPONSIBLE TO DETERMINE THE CONDITIONS NECESSARY FOR THE SAFE USE OF
THIS PRODUCT. THE CUSTOMER/BUYER/USER SHOULD NOT USE THE PRODUCT FOR ANY
PURPOSE OTHER THAN THE PURPOSE SHOWN IN THE APPLICABLE SECTION OF THIS
SDS WITHOUT FIRST REFERRING TO THE SUPPLIER AND OBTAINING WRITTEN HANDLING
INSTRUCTIONS. DUE TO THE PROLIFERATION OF SOURCES FOR INFORMATION SUCH AS
MANUFACTURER-SPECIFIC SDS, THE MANUFACTURER CANNOT BE RESPONSIBLE FOR SDSS
OBTAINED FROM ANY OTHER SOURCE.
DATE OF ISSUE/DATE OF REVISION: 10/1/2015
DATE OF PREVIOUS ISSUE: NO PREVIOUS VALIDATION
VERSION: 1