| Common Name: | OILFIELD DRY MOLY LUBE - 11 OZ NO. 03284 (ITEM 1003484) |
| Manufacturer: | CRC INDUSTRIES |
| SDS Revision Date: | 3/20/2023 |
| SDS Format: | No Format Specified |
| Item Number(s): | 49XX25 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
CRC(R*)
SAFETY DATA SHEET
| 1. IDENTIFICATION |  |
PRODUCT IDENTIFIER: OILFIELD DRY MOLY LUBE - 11 OZ
OTHER MEANS OF IDENTIFICATION:
PRODUCT CODE: NO. 03284 (ITEM# 1003484)
RECOMMENDED USE: DRY FILM LUBRICANT
RECOMMENDED RESTRICTIONS: NONE KNOWN.
MANUFACTURER/IMPORTER/SUPPLIER/DISTRIBUTOR INFORMATION:
MANUFACTURED OR SOLD BY:
COMPANY NAME: CRC INDUSTRIES, INC.
ADDRESS:
885 LOUIS DR.
WARMINSTER, PA 18974
US
TELEPHONE: 800-556-5074
24-HOUR EMERGENCY (CHEMTREC): 800-424-9300 (US)
WEBSITE: CRCINDUSTRIES.COM
| 2. HAZARD(S) IDENTIFICATION | |
PHYSICAL HAZARDS:
FLAMMABLE AEROSOLS: CATEGORY 1
GASES UNDER PRESSURE: LIQUEFIED GAS
HEALTH HAZARDS:
SKIN CORROSION/IRRITATION: CATEGORY 2
SERIOUS EYE DAMAGE/EYE IRRITATION: CATEGORY 2A
REPRODUCTIVE TOXICITY: CATEGORY 2
SPECIFIC TARGET ORGAN TOXICITY, SINGLE EXPOSURE:
CATEGORY 3 RESPIRATORY TRACT IRRITATION
SPECIFIC TARGET ORGAN TOXICITY, SINGLE EXPOSURE:
CATEGORY 3 NARCOTIC EFFECTS
SPECIFIC TARGET ORGAN TOXICITY, REPEATED EXPOSURE:
CATEGORY 2 (CENTRAL NERVOUS SYSTEM, EYES, KIDNEYS, LIVER, RESPIRATORY
SYSTEM, SKIN)
ASPIRATION HAZARD: CATEGORY 1
ENVIRONMENTAL HAZARDS:
HAZARDOUS TO THE AQUATIC ENVIRONMENT, ACUTE HAZARD: CATEGORY 3
HAZARDOUS TO THE AQUATIC ENVIRONMENT, LONG-TERM HAZARD: CATEGORY 3
OSHA DEFINED HAZARDS: NOT CLASSIFIED.
LABEL ELEMENTS:
FLAME
GAS CYLINDER
HEALTH HAZARD
EXCLAMATION MARK
SIGNAL WORD: DANGER
HAZARD STATEMENT:
EXTREMELY FLAMMABLE AEROSOL. CONTAINS GAS UNDER PRESSURE; MAY EXPLODE
IF HEATED. MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS. CAUSES SKIN
IRRITATION. CAUSES SERIOUS EYE IRRITATION. MAY CAUSE RESPIRATORY
IRRITATION. MAY CAUSE DROWSINESS OR DIZZINESS. SUSPECTED OF DAMAGING
FERTILITY OR THE UNBORN CHILD. MAY CAUSE DAMAGE TO ORGANS (CENTRAL
NERVOUS SYSTEM, EYES, KIDNEYS, LIVER, RESPIRATORY SYSTEM, SKIN) THROUGH
PROLONGED OR REPEATED EXPOSURE.
PRECAUTIONARY STATEMENT:
PREVENTION:
OBTAIN SPECIAL INSTRUCTIONS BEFORE USE. DO NOT HANDLE UNTIL ALL SAFETY
PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD. KEEP AWAY FROM HEAT/SPARKS/OPEN
FLAMES/HOT SURFACES. - NO SMOKING. DO NOT SPRAY ON AN OPEN FLAME OR OTHER
IGNITION SOURCE.
PRESSURIZED CONTAINER:
DO NOT PIERCE OR BURN, EVEN AFTER USE. DO NOT APPLY WHILE EQUIPMENT IS
ENERGIZED. EXTINGUISH ALL FLAMES, PILOT LIGHTS, AND HEATERS. VAPORS WILL
ACCUMULATE READILY AND MAY IGNITE. USE ONLY OUTDOORS OR IN A WELL-
VENTILATED AREA. MAINTAIN VENTILATION DURING USE AND UNTIL ALL VAPORS ARE
GONE. DO NOT BREATHE MIST/VAPORS. OPEN DOORS AND WINDOWS OR USE OTHER MEANS
TO ENSURE A FRESH AIR SUPPLY DURING USE AND WHILE PRODUCT IS DRYING. IF YOU
EXPERIENCE ANY SYMPTOMS LISTED ON THIS LABEL, INCREASE VENTILATION OR LEAVE
THE AREA. WASH THOROUGHLY AFTER HANDLING. WEAR PROTECTIVE GLOVES/PROTECTIVE
CLOTHING/EYE PROTECTION/FACE PROTECTION.
RESPONSE:
IF SWALLOWED:
IMMEDIATELY CALL A POISON CENTER/DOCTOR. DO NOT INDUCE VOMITING.
IF INHALED:
REMOVE PERSON TO FRESH AIR AND KEEP COMFORTABLE FOR BREATHING. CALL A
POISON CENTER/DOCTOR IF YOU FEEL UNWELL.
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES, IF
PRESENT AND EASY TO DO. CONTINUE RINSING.
IF EYE IRRITATION PERSISTS: GET MEDICAL ADVICE/ATTENTION.
IF ON SKIN: WASH WITH PLENTY OF WATER.
IF SKIN IRRITATION OCCURS:
GET MEDICAL ADVICE/ATTENTION. TAKE OFF CONTAMINATED CLOTHING AND WASH
BEFORE REUSE.
IF EXPOSED OR CONCERNED: GET MEDICAL ADVICE/ATTENTION.
STORAGE:
PROTECT FROM SUNLIGHT. STORE IN A WELL-VENTILATED PLACE. KEEP CONTAINER
TIGHTLY CLOSED. STORE LOCKED UP. DO NOT EXPOSE TO TEMPERATURES EXCEEDING
50 DEG. C/122 DEG. F. EXPOSURE TO HIGH TEMPERATURE MAY CAUSE CAN TO BURST.
DISPOSAL:
DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH LOCAL/REGIONAL/NATIONAL/
INTERNATIONAL REGULATIONS.
HAZARD(S) NOT OTHERWISE CLASSIFIED (HNOC): NONE KNOWN.
SUPPLEMENTAL INFORMATION: NONE.
| 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
MIXTURES:
CHEMICAL NAME COMMON NAME AND SYNONYMS CAS NUMBER %
ACETONE 67-64-1 30 - 40
LIQUEFIED PETROLEUM GAS 68476-86-8 20 - 30
TOLUENE 108-88-3 20 - 30
ISOPROPYL ALCOHOL 67-63-0 10 - 20
MOLYBDENUM DISULPHIDE 1317-33-5 0.1 - 1
XYLENE 1330-20-7 0.1 - 1
SPECIFIC CHEMICAL IDENTITY AND/OR PERCENTAGE OF COMPOSITION HAS BEEN
WITHHELD AS A TRADE SECRET.
| 4. FIRST-AID MEASURES | |
INHALATION:
REMOVE VICTIM TO FRESH AIR AND KEEP AT REST IN A POSITION COMFORTABLE FOR
BREATHING. CALL A POISON CENTER OR DOCTOR/PHYSICIAN IF YOU FEEL UNWELL.
SKIN CONTACT:
REMOVE CONTAMINATED CLOTHING IMMEDIATELY AND WASH SKIN WITH SOAP AND WATER.
IN CASE OF ECZEMA OR OTHER SKIN DISORDERS:
SEEK MEDICAL ATTENTION AND TAKE ALONG THESE INSTRUCTIONS. WASH CONTAMINATED
CLOTHING BEFORE REUSE.
EYE CONTACT:
IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES. REMOVE
CONTACT LENSES, IF PRESENT AND EASY TO DO. CONTINUE RINSING. GET MEDICAL
ATTENTION IF IRRITATION DEVELOPS AND PERSISTS.
INGESTION:
CALL A PHYSICIAN OR POISON CONTROL CENTER IMMEDIATELY. RINSE MOUTH. DO NOT
INDUCE VOMITING. IF VOMITING OCCURS, KEEP HEAD LOW SO THAT STOMACH CONTENT
DOESN'T GET INTO THE LUNGS.
MOST IMPORTANT SYMPTOMS/EFFECTS, ACUTE AND DELAYED:
ASPIRATION MAY CAUSE PULMONARY EDEMA AND PNEUMONITIS. MAY CAUSE DROWSINESS
OR DIZZINESS. HEADACHE. NAUSEA, VOMITING. SEVERE EYE IRRITATION. SYMPTOMS
MAY INCLUDE STINGING, TEARING, REDNESS, SWELLING, AND BLURRED VISION. MAY
CAUSE RESPIRATORY IRRITATION. SKIN IRRITATION. MAY CAUSE REDNESS AND PAIN.
MAY CAUSE AN ALLERGIC SKIN REACTION. DERMATITIS. RASH. PROLONGED EXPOSURE
MAY CAUSE CHRONIC EFFECTS.
INDICATION OF IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED:
PROVIDE GENERAL SUPPORTIVE MEASURES AND TREAT SYMPTOMATICALLY. KEEP VICTIM
UNDER OBSERVATION. SYMPTOMS MAY BE DELAYED.
GENERAL INFORMATION:
IF EXPOSED OR CONCERNED:
GET MEDICAL ADVICE/ATTENTION. ENSURE THAT MEDICAL PERSONNEL ARE AWARE OF
THE MATERIAL(S) INVOLVED, AND TAKE PRECAUTIONS TO PROTECT THEMSELVES. SHOW
THIS SAFETY DATA SHEET TO THE DOCTOR IN ATTENDANCE. WASH CONTAMINATED
CLOTHING BEFORE REUSE.
| 5. FIRE-FIGHTING MEASURES | |
SUITABLE EXTINGUISHING MEDIA:
WATER FOG. DRY CHEMICAL POWDER. CARBON DIOXIDE (CO2). COOL CONTAINERS /
TANKS WITH WATER SPRAY.
UNSUITABLE EXTINGUISHING MEDIA:
DO NOT USE WATER JET AS AN EXTINGUISHER, AS THIS WILL SPREAD THE FIRE.
KEEP AWAY FROM SOURCES OF IGNITION - NO SMOKING.
SPECIFIC HAZARDS ARISING FROM THE CHEMICAL:
CONTENTS UNDER PRESSURE. PRESSURIZED CONTAINER MAY RUPTURE WHEN EXPOSED TO
HEAT OR FLAME. DURING FIRE, GASES HAZARDOUS TO HEALTH MAY BE FORMED. STATIC
CHARGES GENERATED BY EMPTYING PACKAGE IN OR NEAR FLAMMABLE VAPOR MAY CAUSE
FLASH FIRE.
SPECIAL PROTECTIVE EQUIPMENT AND PRECAUTIONS FOR FIREFIGHTERS:
IN THE EVENT OF FIRE AND/OR EXPLOSION DO NOT BREATHE FUMES. AS IN ANY
FIRE, WEAR SELF-CONTAINED BREATHING APPARATUS PRESSURE-DEMAND, MSHA/NIOSH
(APPROVED OR EQUIVALENT) AND FULL PROTECTIVE GEAR. FIREFIGHTERS MUST USE
STANDARD PROTECTIVE EQUIPMENT INCLUDING FLAME RETARDANT COAT, HELMET
WITH FACE SHIELD, GLOVES, RUBBER BOOTS, AND IN ENCLOSED SPACES, SCBA.
FIRE-FIGHTING EQUIPMENT/INSTRUCTIONS:
IN CASE OF FIRE:
STOP LEAK IF SAFE TO DO SO. MOVE CONTAINERS FROM FIRE AREA IF YOU CAN DO
SO WITHOUT RISK. CONTAINERS SHOULD BE COOLED WITH WATER TO PREVENT VAPOR
PRESSURE BUILD UP.
GENERAL FIRE HAZARDS:
EXTREMELY FLAMMABLE AEROSOL. CONTENTS UNDER PRESSURE. PRESSURIZED CONTAINER
MAY RUPTURE WHEN EXPOSED TO HEAT OR FLAME.
| 6. ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
KEEP UNNECESSARY PERSONNEL AWAY. KEEP PEOPLE AWAY FROM AND UPWIND OF
SPILL/LEAK. KEEP OUT OF LOW AREAS. MANY GASES ARE HEAVIER THAN AIR AND
WILL SPREAD ALONG GROUND AND COLLECT IN LOW OR CONFINED AREAS (SEWERS,
BASEMENTS, TANKS). WEAR APPROPRIATE PROTECTIVE EQUIPMENT AND CLOTHING
DURING CLEAN-UP. DO NOT BREATHE MIST OR VAPOR. EMERGENCY PERSONNEL NEED
SELF-CONTAINED BREATHING EQUIPMENT. DO NOT TOUCH DAMAGED CONTAINERS OR
SPILLED MATERIAL UNLESS WEARING APPROPRIATE PROTECTIVE CLOTHING. VENTILATE
CLOSED SPACES BEFORE ENTERING THEM. LOCAL AUTHORITIES SHOULD BE ADVISED IF
SIGNIFICANT SPILLAGES CANNOT BE CONTAINED. FOR PERSONAL PROTECTION, SEE
SECTION 8 OF THE SDS.
METHODS AND MATERIALS FOR CONTAINMENT AND CLEANING UP:
ELIMINATE ALL IGNITION SOURCES (NO SMOKING, FLARES, SPARKS, OR FLAMES IN
IMMEDIATE AREA). KEEP COMBUSTIBLES (WOOD, PAPER, OIL, ETC.) AWAY FROM
SPILLED MATERIAL. PREVENT PRODUCT FROM ENTERING DRAINS. STOP THE FLOW OF
MATERIAL, IF THIS IS WITHOUT RISK. WIPE UP WITH ABSORBENT MATERIAL (E.G.
CLOTH, FLEECE). CLEAN SURFACE THOROUGHLY TO REMOVE RESIDUAL CONTAMINATION.
FOR WASTE DISPOSAL, SEE SECTION 13 OF THE SDS.
ENVIRONMENTAL PRECAUTIONS:
AVOID RELEASE TO THE ENVIRONMENT. AVOID DISCHARGE INTO DRAINS, WATER
COURSES OR ONTO THE GROUND. PREVENT FURTHER LEAKAGE OR SPILLAGE IF SAFE
TO DO SO. VAPORS MAY ACCUMULATE IN LOW OR CONFINED AREAS OR TRAVEL A
CONSIDERABLE DISTANCE TO A SOURCE OF IGNITION AND FLASH BACK. PREVENT
FURTHER LEAKAGE OR SPILLAGE IF SAFE TO DO SO. INFORM APPROPRIATE MANAGERIAL
OR SUPERVISORY PERSONNEL OF ALL ENVIRONMENTAL RELEASES.
| 7. HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING:
OBTAIN SPECIAL INSTRUCTIONS BEFORE USE. DO NOT HANDLE UNTIL ALL SAFETY
PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD. PRESSURIZED CONTAINER:
DO NOT PIERCE OR BURN, EVEN AFTER USE. DO NOT USE IF SPRAY BUTTON IS
MISSING OR DEFECTIVE. DO NOT SPRAY ON A NAKED FLAME OR ANY OTHER
INCANDESCENT MATERIAL. DO NOT SMOKE WHILE USING OR UNTIL SPRAYED SURFACE
IS THOROUGHLY DRY. DO NOT CUT, WELD, SOLDER, DRILL, GRIND, OR EXPOSE
CONTAINERS TO HEAT, FLAME, SPARKS, OR OTHER SOURCES OF IGNITION. DO NOT
BREATHE MIST OR VAPOR. AVOID CONTACT WITH EYES, SKIN, AND CLOTHING. AVOID
PROLONGED EXPOSURE. PREGNANT OR BREASTFEEDING WOMEN MUST NOT HANDLE THIS
PRODUCT. SHOULD BE HANDLED IN CLOSED SYSTEMS, IF POSSIBLE. USE ONLY IN
WELL-VENTILATED AREAS. WEAR APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT.
WASH HANDS THOROUGHLY AFTER HANDLING. AVOID RELEASE TO THE ENVIRONMENT.
OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES. FOR PRODUCT USAGE INSTRUCTIONS,
SEE THE PRODUCT LABEL.
CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES:
LEVEL 3 AEROSOL.
PRESSURIZED CONTAINER. PROTECT FROM SUNLIGHT AND DO NOT EXPOSE TO
TEMPERATURES EXCEEDING 50 DEG. C/122 DEG. F. DO NOT PUNCTURE, INCINERATE
OR CRUSH. DO NOT HANDLE OR STORE NEAR AN OPEN FLAME, HEAT OR OTHER SOURCES
OF IGNITION. THIS MATERIAL CAN ACCUMULATE STATIC CHARGE WHICH MAY CAUSE
SPARK AND BECOME AN IGNITION SOURCE. STORE IN A WELL-VENTILATED PLACE.
STORED CONTAINERS SHOULD BE PERIODICALLY CHECKED FOR GENERAL CONDITION
AND LEAKAGE. STORE AWAY FROM INCOMPATIBLE MATERIALS (SEE SECTION 10 OF THE
SDS).
| 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
OCCUPATIONAL EXPOSURE LIMITS:
THE FOLLOWING CONSTITUENTS ARE THE ONLY CONSTITUENTS OF THE PRODUCT WHICH
HAVE A PEL, TLV OR OTHER RECOMMENDED EXPOSURE LIMIT. AT THIS TIME, THE
OTHER CONSTITUENTS HAVE NO KNOWN EXPOSURE LIMITS.
US. OSHA TABLE Z-1 LIMITS FOR AIR CONTAMINANTS (29 CFR 1910.1000):
COMPONENTS TYPE VALUE
ACETONE (CAS 67-64-1) PEL 2400 MG/M3
1000 PPM
ISOPROPYL ALCOHOL (CAS 67-63-0) PEL 980 MG/M3
400 PPM
XYLENE (CAS 1330-20-7) PEL 435 MG/M3
100 PPM
US. OSHA TABLE Z-2 (29 CFR 1910.1000):
COMPONENTS TYPE VALUE
TOLUENE (CAS 108-88-3) CEILING 300 PPM
TWA 200 PPM
US. ACGIH THRESHOLD LIMIT VALUES:
COMPONENTS TYPE VALUE
ACETONE (CAS 67-64-1) STEL 500 PPM
TWA 250 PPM
ISOPROPYL ALCOHOL (CAS 67-63-0) STEL 400 PPM
TWA 200 PPM
TOLUENE (CAS 108-88-3) TWA 20 PPM
XYLENE (CAS 1330-20-7) STEL 150 PPM
TWA 100 PPM
US. NIOSH: POCKET GUIDE TO CHEMICAL HAZARDS
COMPONENTS TYPE VALUE
ACETONE (CAS 67-64-1) TWA 590 MG/M3
250 PPM
ISOPROPYL ALCOHOL (CAS 67-63-0) STEL 1225 MG/M3
500 PPM
TWA 980 MG/M3
400 PPM
TOLUENE (CAS 108-88-3) STEL 560 MG/M3
150 PPM
TWA 375 MG/M3
100 PPM
XYLENE (CAS 1330-20-7) STEL 655 MG/M3
150 PPM
TWA 435 MG/M3
100 PPM
BIOLOGICAL LIMIT VALUES:
ACGIH BIOLOGICAL EXPOSURE INDICES:
COMPONENTS VALUE DETERMINANT SPECIMEN SAMPLING TIME
ACETONE 25 MG/L ACETONE URINE *
(CAS 67-64-1)
ISOPROPYL ALCOHOL 40 MG/L ACETONE URINE *
(CAS 67-63-0)
TOLUENE 0.3 MG/G O-CRESOL, WITH CREATININE *
(CAS 108-88-3) HYDROLYSIS IN URINE
0.03 MG/L TOLUENE URINE *
0.02 MG/L TOLUENE BLOOD *
XYLENE 1.5 G/G METHYLHIPPURIC CREATININE *
(CAS 1330-20-7) ACIDS IN URINE
* - FOR SAMPLING DETAILS, PLEASE SEE THE SOURCE DOCUMENT.
EXPOSURE GUIDELINES:
US - CALIFORNIA OELS SKIN DESIGNATION
TOLUENE (CAS 108-88-3) CAN BE ABSORBED THROUGH THE SKIN.
US - MINNESOTA HAZ SUBS SKIN DESIGNATION APPLIES
TOLUENE (CAS 108-88-3) SKIN DESIGNATION APPLIES.
APPROPRIATE ENGINEERING CONTROLS:
GOOD GENERAL VENTILATION SHOULD BE USED. VENTILATION RATES SHOULD BE
MATCHED TO CONDITIONS. IF APPLICABLE, USE PROCESS ENCLOSURES, LOCAL EXHAUST
VENTILATION, OR OTHER ENGINEERING CONTROLS TO MAINTAIN AIRBORNE LEVELS
BELOW RECOMMENDED EXPOSURE LIMITS. IF EXPOSURE LIMITS HAVE NOT BEEN
ESTABLISHED, MAINTAIN AIRBORNE LEVELS TO AN ACCEPTABLE LEVEL. PROVIDE
EYEWASH STATION AND SAFETY SHOWER.
INDIVIDUAL PROTECTION MEASURES, SUCH AS PERSONAL PROTECTIVE EQUIPMENT:
EYE/FACE PROTECTION: WEAR SAFETY GLASSES WITH SIDE SHIELDS (OR GOGGLES).
SKIN PROTECTION:
HAND PROTECTION:
WEAR PROTECTIVE GLOVES SUCH AS: NITRILE. NEOPRENE.
OTHER: WEAR APPROPRIATE CHEMICAL RESISTANT CLOTHING.
RESPIRATORY PROTECTION:
IF ENGINEERING CONTROLS ARE NOT FEASIBLE OR IF EXPOSURE EXCEEDS THE
APPLICABLE EXPOSURE LIMITS, USE A NIOSH-APPROVED CARTRIDGE RESPIRATOR
WITH AN ORGANIC VAPOR CARTRIDGE. USE A SELF-CONTAINED BREATHING APPARATUS
IN CONFINED SPACES AND FOR EMERGENCIES. AIR MONITORING IS NEEDED TO
DETERMINE ACTUAL EMPLOYEE EXPOSURE LEVELS.
THERMAL HAZARDS:
WEAR APPROPRIATE THERMAL PROTECTIVE CLOTHING, WHEN NECESSARY.
GENERAL HYGIENE CONSIDERATIONS:
OBSERVE ANY MEDICAL SURVEILLANCE REQUIREMENTS. WHEN USING DO NOT SMOKE.
ALWAYS OBSERVE GOOD PERSONAL HYGIENE MEASURES, SUCH AS WASHING AFTER
HANDLING THE MATERIAL AND BEFORE EATING, DRINKING, AND/OR SMOKING.
ROUTINELY WASH WORK CLOTHING AND PROTECTIVE EQUIPMENT TO REMOVE
CONTAMINANTS. CONTAMINATED WORK CLOTHING SHOULD NOT BE ALLOWED OUT OF
THE WORKPLACE.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE:
PHYSICAL STATE: LIQUID.
FORM: AEROSOL.
COLOR: BLACK
ODOR: SOLVENT.
ODOR THRESHOLD: NOT AVAILABLE.
PH: NOT AVAILABLE.
MELTING POINT/FREEZING POINT: -138.8 DEG. F (-94.9 DEG. C) ESTIMATED
INITIAL BOILING POINT AND BOILING RANGE:
132.9 DEG. F (56.1 DEG. C) ESTIMATED
FLASH POINT: -4.0 DEG. F (-20.0 DEG. C) ESTIMATED
EVAPORATION RATE: FAST.
FLAMMABILITY (SOLID, GAS): NOT AVAILABLE.
UPPER/LOWER FLAMMABILITY OR EXPLOSIVE LIMITS:
EXPLOSIVE LIMIT - LOWER (%): 1.27 % ESTIMATED
EXPLOSIVE LIMIT - UPPER (%): 12.8 % ESTIMATED
VAPOR PRESSURE: 1302.7 HPA ESTIMATED
VAPOR DENSITY: >1 (AIR = 1)
RELATIVE DENSITY: 0.77 ESTIMATED
SOLUBILITY(IES):
SOLUBILITY (WATER): NOT AVAILABLE.
PARTITION COEFFICIENT (N-OCTANOL/WATER): NOT AVAILABLE.
AUTO-IGNITION TEMPERATURE: 750.2 DEG. F (399 DEG. C) ESTIMATED
DECOMPOSITION TEMPERATURE: NOT AVAILABLE.
VISCOSITY: NOT AVAILABLE.
PERCENT VOLATILE: NOT AVAILABLE.
OTHER INFORMATION:
VOC: 81.4 % ESTIMATED
| 10. STABILITY AND REACTIVITY | |
REACTIVITY:
THE PRODUCT IS STABLE AND NON-REACTIVE UNDER NORMAL CONDITIONS OF USE,
STORAGE AND TRANSPORT.
CHEMICAL STABILITY: MATERIAL IS STABLE UNDER NORMAL CONDITIONS.
POSSIBILITY OF HAZARDOUS REACTIONS:
NO DANGEROUS REACTION KNOWN UNDER CONDITIONS OF NORMAL USE.
CONDITIONS TO AVOID:
HEAT, FLAMES AND SPARKS. CONTACT WITH INCOMPATIBLE MATERIALS.
INCOMPATIBLE MATERIALS: STRONG ACIDS. ALKALIS. STRONG OXIDIZING AGENTS.
HAZARDOUS DECOMPOSITION PRODUCTS: CARBON OXIDES. HYDROCARBONS. FUMES.
| 11. TOXICOLOGICAL INFORMATION | |
INFORMATION ON LIKELY ROUTES OF EXPOSURE:
INHALATION:
MAY CAUSE DROWSINESS OR DIZZINESS. HEADACHE. NAUSEA, VOMITING. MAY CAUSE
IRRITATION TO THE RESPIRATORY SYSTEM. PROLONGED INHALATION MAY BE HARMFUL.
SKIN CONTACT: CAUSES SKIN IRRITATION.
EYE CONTACT: CAUSES SERIOUS EYE IRRITATION.
INGESTION:
DROPLETS OF THE PRODUCT ASPIRATED INTO THE LUNGS THROUGH INGESTION OR
VOMITING MAY CAUSE A SERIOUS CHEMICAL PNEUMONIA.
SYMPTOMS RELATED TO THE PHYSICAL, CHEMICAL AND TOXICOLOGICAL
CHARACTERISTICS:
ASPIRATION MAY CAUSE PULMONARY EDEMA AND PNEUMONITIS. MAY CAUSE DROWSINESS
OR DIZZINESS. NARCOSIS. HEADACHE. NAUSEA, VOMITING. BEHAVIORAL CHANGES.
DECREASE IN MOTOR FUNCTIONS. SEVERE EYE IRRITATION. SYMPTOMS MAY INCLUDE
STINGING, TEARING, REDNESS, SWELLING, AND BLURRED VISION. MAY CAUSE
RESPIRATORY IRRITATION. SKIN IRRITATION. MAY CAUSE REDNESS AND PAIN. RASH.
DEFATTING OF THE SKIN. JAUNDICE.
INFORMATION ON TOXICOLOGICAL EFFECTS:
ACUTE TOXICITY: MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS.
PRODUCT SPECIES TEST RESULTS
OILFIELD DRY MOLY LUBE - 11 OZ
ACUTE:
DERMAL:
ATE 8726 MG/KG
INHALATION:
GAS:
ATE 87069 MG/L
VAPOR:
ATE 637 MG/L
DUST AND MIST.:
ATE 68.2 MG/L
ORAL:
ATE 24161 MG/KG
SKIN CORROSION/IRRITATION: CAUSES SKIN IRRITATION.
SERIOUS EYE DAMAGE/EYE IRRITATION: CAUSES SERIOUS EYE IRRITATION.
RESPIRATORY OR SKIN SENSITIZATION:
RESPIRATORY SENSITIZATION: NOT A RESPIRATORY SENSITIZER.
SKIN SENSITIZATION:
THIS PRODUCT IS NOT EXPECTED TO CAUSE SKIN SENSITIZATION.
GERM CELL MUTAGENICITY:
NO DATA AVAILABLE TO INDICATE PRODUCT OR ANY COMPONENTS PRESENT AT GREATER
THAN 0.1% ARE MUTAGENIC OR GENOTOXIC.
CARCINOGENICITY: NOT CLASSIFIABLE AS TO CARCINOGENICITY TO HUMANS.
IARC MONOGRAPHS. OVERALL EVALUATION OF CARCINOGENICITY:
TOLUENE (CAS 108-88-3) 3 NOT CLASSIFIABLE AS TO CARCINOGENICITY TO HUMANS.
XYLENE (CAS 1330-20-7) 3 NOT CLASSIFIABLE AS TO CARCINOGENICITY TO HUMANS.
OSHA SPECIFICALLY REGULATED SUBSTANCES (29 CFR 1910.1001-1053): NOT LISTED.
US. NATIONAL TOXICOLOGY PROGRAM (NTP) REPORT ON CARCINOGENS: NOT LISTED.
REPRODUCTIVE TOXICITY:
COMPONENTS IN THIS PRODUCT HAVE BEEN SHOWN TO CAUSE BIRTH DEFECTS AND
REPRODUCTIVE DISORDERS IN LABORATORY ANIMALS. SUSPECTED OF DAMAGING
FERTILITY OR THE UNBORN CHILD.
SPECIFIC TARGET ORGAN TOXICITY - SINGLE EXPOSURE:
MAY CAUSE RESPIRATORY IRRITATION. MAY CAUSE DROWSINESS OR DIZZINESS.
SPECIFIC TARGET ORGAN TOXICITY - REPEATED EXPOSURE:
MAY CAUSE DAMAGE TO ORGANS (CENTRAL NERVOUS SYSTEM, EYES, KIDNEYS, LIVER,
RESPIRATORY SYSTEM, SKIN) THROUGH PROLONGED OR REPEATED EXPOSURE.
ASPIRATION HAZARD: MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS.
CHRONIC EFFECTS:
PROLONGED INHALATION MAY BE HARMFUL. MAY CAUSE DAMAGE TO ORGANS THROUGH
PROLONGED OR REPEATED EXPOSURE.
| 12. ECOLOGICAL INFORMATION | |
ECOTOXICITY: HARMFUL TO AQUATIC LIFE WITH LONG LASTING EFFECTS.
PERSISTENCE AND DEGRADABILITY:
NO DATA IS AVAILABLE ON THE DEGRADABILITY OF ANY INGREDIENTS IN THE
MIXTURE.
BIOACCUMULATIVE POTENTIAL:
PARTITION COEFFICIENT N-OCTANOL / WATER (LOG KOW):
ACETONE -0.24
ISOPROPYL ALCOHOL 0.05
TOLUENE 2.73
BIOCONCENTRATION FACTOR (BCF):
TOLUENE 90
XYLENE 23.99
MOBILITY IN SOIL: NO DATA AVAILABLE.
OTHER ADVERSE EFFECTS:
NO OTHER ADVERSE ENVIRONMENTAL EFFECTS (E.G. OZONE DEPLETION, PHOTOCHEMICAL
OZONE CREATION POTENTIAL, ENDOCRINE DISRUPTION, GLOBAL WARMING POTENTIAL)
ARE EXPECTED FROM THIS COMPONENT.
| 13. DISPOSAL CONSIDERATIONS | |
DISPOSAL INSTRUCTIONS:
THIS MATERIAL AND ITS CONTAINER MUST BE DISPOSED OF AS HAZARDOUS WASTE.
FULL OR PARTIALLY-FULL AEROSOL CANS CAN BE TREATED AS UNIVERSAL WASTE.
EMPTY CONTAINER CAN BE RECYCLED. CONTENTS UNDER PRESSURE. INCINERATE THE
MATERIAL UNDER CONTROLLED CONDITIONS IN AN APPROVED INCINERATOR. DO NOT
INCINERATE SEALED CONTAINERS. DO NOT ALLOW THIS MATERIAL TO DRAIN INTO
SEWERS/WATER SUPPLIES. DO NOT CONTAMINATE PONDS, WATERWAYS OR DITCHES WITH
CHEMICAL OR USED CONTAINER. DISPOSE IN ACCORDANCE WITH ALL APPLICABLE
REGULATIONS.
HAZARDOUS WASTE CODE:
POSSIBLE RCRA WASTE CODE INCLUDES:
D001: WASTE FLAMMABLE MATERIAL WITH A FLASH POINT <140 F
F003: WASTE NON-HALOGENATED SOLVENT - SPENT NON-HALOGENATED SOLVENT
F005: WASTE NON-HALOGENATED SOLVENT - SPENT NON-HALOGENATED SOLVENT
HOWEVER, IT IS THE GENERATOR'S RESPONSIBILITY TO DETERMINE THE PROPER
CLASSIFICATION AND DISPOSAL METHOD AT THE TIME OF DISPOSAL.
CONTAMINATED PACKAGING:
SINCE EMPTIED CONTAINERS MAY RETAIN PRODUCT RESIDUE, FOLLOW LABEL WARNINGS
EVEN AFTER CONTAINER IS EMPTIED. EMPTY CONTAINERS SHOULD BE TAKEN TO AN
APPROVED WASTE HANDLING SITE FOR RECYCLING OR DISPOSAL.
| 14. TRANSPORT INFORMATION | |
DOT:
UN NUMBER: UN1950
UN PROPER SHIPPING NAME: AEROSOLS, FLAMMABLE, LIMITED QUANTITY
TRANSPORT HAZARD CLASS(ES):
CLASS: 2.1
SUBSIDIARY RISK:
LABEL(S): 2.1
PACKING GROUP: NOT ASSIGNED.
ENVIRONMENTAL HAZARDS:
MARINE POLLUTANT: NO.
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
SPECIAL PROVISIONS: N82
PACKAGING EXCEPTIONS: 306
PACKAGING NON BULK: NONE
PACKAGING BULK: NONE
IATA:
UN NUMBER: UN1950
UN PROPER SHIPPING NAME: AEROSOLS, FLAMMABLE, LIMITED QUANTITY
TRANSPORT HAZARD CLASS(ES):
CLASS: 2.1
SUBSIDIARY RISK:
PACKING GROUP: NOT ASSIGNED.
ERG CODE: 10L
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
OTHER INFORMATION:
PASSENGER AND CARGO AIRCRAFT: ALLOWED WITH RESTRICTIONS.
CARGO AIRCRAFT ONLY: ALLOWED WITH RESTRICTIONS.
IMDG:
UN NUMBER: UN1950
UN PROPER SHIPPING NAME: AEROSOLS, LIMITED QUANTITY
TRANSPORT HAZARD CLASS(ES):
CLASS: 2.1
SUBSIDIARY RISK:
PACKING GROUP: NOT ASSIGNED.
ENVIRONMENTAL HAZARDS:
MARINE POLLUTANT: NO.
EMS: F-D, S-U
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
DOT; IMDG: LIMITED QUANTITY FOR PACKAGES NOT PREPARED FOR AIR TRANSPORT
IATA: LIMITED QUANTITY MARKING FOR PACKAGES PREPARED FOR AIR TRANSPORT
| 15. REGULATORY INFORMATION | |
US FEDERAL REGULATIONS:
THIS PRODUCT IS A "HAZARDOUS CHEMICAL" AS DEFINED BY THE OSHA HAZARD
COMMUNICATION STANDARD, 29 CFR 1910.1200.
SARA 304 EMERGENCY RELEASE NOTIFICATION: NOT REGULATED.
OSHA SPECIFICALLY REGULATED SUBSTANCES (29 CFR 1910.1001-1053): NOT LISTED.
CERCLA HAZARDOUS SUBSTANCE LIST (40 CFR 302.4):
ACETONE (CAS 67-64-1)
TOLUENE (CAS 108-88-3)
XYLENE (CAS 1330-20-7)
CERCLA HAZARDOUS SUBSTANCES REPORTABLE QUANTITY
ACETONE (CAS 67-64-1) 5000 LBS
TOLUENE (CAS 108-88-3) 1000 LBS
XYLENE (CAS 1330-20-7) 100 LBS
SPILLS OR RELEASES RESULTING IN THE LOSS OF ANY INGREDIENT AT OR ABOVE
ITS RQ REQUIRE IMMEDIATE NOTIFICATION TO THE NATIONAL RESPONSE CENTER
(800-424-8802) AND TO YOUR LOCAL EMERGENCY PLANNING COMMITTEE.
TOXIC SUBSTANCES CONTROL ACT (TSCA):
TSCA SECTION 12(B) EXPORT NOTIFICATION (40 CFR 707, SUBPT. D):
NOT REGULATED.
OTHER FEDERAL REGULATIONS:
CLEAN AIR ACT (CAA) SECTION 112 HAZARDOUS AIR POLLUTANTS (HAPS) LIST:
TOLUENE (CAS 108-88-3)
XYLENE (CAS 1330-20-7)
CLEAN AIR ACT (CAA) SECTION 112(R) ACCIDENTAL RELEASE PREVENTION
(40 CFR 68.130): NOT REGULATED.
SAFE DRINKING WATER ACT (SDWA):
CONTAINS COMPONENT(S) REGULATED UNDER THE SAFE DRINKING WATER ACT.
DRUG ENFORCEMENT ADMINISTRATION (DEA). LIST 2, ESSENTIAL CHEMICALS
(21 CFR 1310.02(B) AND 1310.04(F)(2) AND CHEMICAL CODE NUMBER:
ACETONE (CAS 67-64-1) 6532
TOLUENE (CAS 108-88-3) 6594
DRUG ENFORCEMENT ADMINISTRATION (DEA). LIST 1 & 2 EXEMPT CHEMICAL MIXTURES
(21 CFR 1310.12(C)):
ACETONE (CAS 67-64-1) 35 %WV
TOLUENE (CAS 108-88-3) 35 %WV
DEA EXEMPT CHEMICAL MIXTURES CODE NUMBER:
ACETONE (CAS 67-64-1) 6532
TOLUENE (CAS 108-88-3) 594
FEMA PRIORITY SUBSTANCES RESPIRATORY HEALTH AND SAFETY IN THE FLAVOR
MANUFACTURING WORKPLACE:
ACETONE (CAS 67-64-1) LOW PRIORITY
ISOPROPYL ALCOHOL (CAS 67-63-0) LOW PRIORITY
FOOD AND DRUG ADMINISTRATION (FDA): NOT REGULATED.
SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 (SARA):
CLASSIFIED HAZARD CATEGORIES:
FLAMMABLE (GASES, AEROSOLS, LIQUIDS, OR SOLIDS)
GAS UNDER PRESSURE
SKIN CORROSION OR IRRITATION
SERIOUS EYE DAMAGE OR EYE IRRITATION
REPRODUCTIVE TOXICITY
SPECIFIC TARGET ORGAN TOXICITY (SINGLE OR REPEATED EXPOSURE)
ASPIRATION HAZARD
SARA 302 EXTREMELY HAZARDOUS SUBSTANCE: NOT LISTED.
SARA 311/312 HAZARDOUS CHEMICAL: YES
SARA 313 (TRI REPORTING):
CHEMICAL NAME CAS NUMBER % BY WT.
TOLUENE 108-88-3 20 - 30
XYLENE 1330-20-7 0.1 - 1
US STATE REGULATIONS:
US. CALIFORNIA. CANDIDATE CHEMICALS LIST. SAFER CONSUMER PRODUCTS
REGULATIONS (CAL. CODE REGS, TIT. 22, 69502.3, SUBD. (A)):
ACETONE (CAS 67-64-1)
ISOPROPYL ALCOHOL (CAS 67-63-0)
LIQUEFIED PETROLEUM GAS (CAS 68476-86-8)
TOLUENE (CAS 108-88-3)
XYLENE (CAS 1330-20-7)
US. NEW JERSEY WORKER AND COMMUNITY RIGHT-TO-KNOW ACT:
ACETONE (CAS 67-64-1)
ISOPROPYL ALCOHOL (CAS 67-63-0)
TOLUENE (CAS 108-88-3)
XYLENE (CAS 1330-20-7)
US. MASSACHUSETTS RTK - SUBSTANCE LIST:
ACETONE (CAS 67-64-1)
ISOPROPYL ALCOHOL (CAS 67-63-0)
MOLYBDENUM DISULPHIDE (CAS 1317-33-5)
TOLUENE (CAS 108-88-3)
XYLENE (CAS 1330-20-7)
US. PENNSYLVANIA WORKER AND COMMUNITY RIGHT-TO-KNOW LAW:
ACETONE (CAS 67-64-1)
ISOPROPYL ALCOHOL (CAS 67-63-0)
TOLUENE (CAS 108-88-3)
XYLENE (CAS 1330-20-7)
US. RHODE ISLAND RTK:
ACETONE (CAS 67-64-1)
ISOPROPYL ALCOHOL (CAS 67-63-0)
TOLUENE (CAS 108-88-3)
XYLENE (CAS 1330-20-7)
CALIFORNIA PROPOSITION 65:
WARNING:
THIS PRODUCT CAN EXPOSE YOU TO CHEMICALS INCLUDING NAPHTHALENE, WHICH IS
KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER, AND TOLUENE, WHICH IS
KNOWN TO THE STATE OF CALIFORNIA TO CAUSE BIRTH DEFECTS OR OTHER
REPRODUCTIVE HARM. FOR MORE INFORMATION GO TO WWW.P65WARNINGS.CA.GOV.
CALIFORNIA PROPOSITION 65 - CRT LISTED DATE/CARCINOGENIC SUBSTANCE
BENZENE (CAS 71-43-2) LISTED: FEBRUARY 27, 1987
ETHYLBENZENE (CAS 100-41-4) LISTED: JUNE 11, 2004
NAPHTHALENE (CAS 91-20-3) LISTED: APRIL 19, 2002
CALIFORNIA PROPOSITION 65 - CRT LISTED DATE/DEVELOPMENTAL TOXIN
BENZENE (CAS 71-43-2) LISTED: DECEMBER 26, 1997
TOLUENE (CAS 108-88-3) LISTED: JANUARY 1, 1991
CALIFORNIA PROPOSITION 65 - CRT LISTED DATE/MALE REPRODUCTIVE TOXIN
BENZENE (CAS 71-43-2) LISTED: DECEMBER 26, 1997
VOLATILE ORGANIC COMPOUNDS (VOC) REGULATIONS:
EPA:
VOC CONTENT (40 CFR 51.100(S)): 65.2 %
CONSUMER PRODUCTS (40 CFR 59, SUBPT. C): NOT REGULATED
STATE:
CONSUMER PRODUCTS:
THIS PRODUCT IS REGULATED AS A DRY LUBRICANT. THIS PRODUCT IS COMPLIANT
FOR USE IN ALL 50 STATES.
VOC CONTENT (CA): 65.2 %
VOC CONTENT (OTC): 65.2 %
INTERNATIONAL INVENTORIES:
COUNTRY(S) INVENTORY NAME ON INVENTORY
OR REGION (YES/NO)*
AUSTRALIA AUSTRALIAN INVENTORY OF INDUSTRIAL YES
CHEMICALS (AICIS)
CANADA DOMESTIC SUBSTANCES LIST (DSL) YES
CANADA NON-DOMESTIC SUBSTANCES LIST (NDSL) NO
CHINA INVENTORY OF EXISTING CHEMICAL SUBSTANCES YES
IN CHINA (IECSC)
EUROPE EUROPEAN INVENTORY OF EXISTING COMMERCIAL YES
CHEMICAL SUBSTANCES (EINECS)
EUROPE EUROPEAN LIST OF NOTIFIED CHEMICAL NO
SUBSTANCES (ELINCS)
JAPAN INVENTORY OF EXISTING AND NEW CHEMICAL NO
SUBSTANCES (ENCS)
KOREA EXISTING CHEMICALS LIST (ECL) YES
NEW ZEALAND NEW ZEALAND INVENTORY YES
PHILIPPINES PHILIPPINE INVENTORY OF CHEMICALS YES
AND CHEMICAL SUBSTANCES (PICCS)
TAIWAN TAIWAN CHEMICAL SUBSTANCE INVENTORY YES
(TCSI)
UNITED STATES & TOXIC SUBSTANCES CONTROL ACT (TSCA) YES
PUERTO RICO INVENTORY
*A "YES" INDICATES THAT ALL COMPONENTS OF THIS PRODUCT COMPLY WITH THE
INVENTORY REQUIREMENTS ADMINISTERED BY THE GOVERNING COUNTRY(S)
A "NO" INDICATES THAT ONE OR MORE COMPONENTS OF THE PRODUCT ARE NOT LISTED
OR EXEMPT FROM LISTING ON THE INVENTORY ADMINISTERED BY THE GOVERNING
COUNTRY(S).
| 16. OTHER INFORMATION, INCLUDING DATE OF PREPARATION | |
OR LAST REVISION
ISSUE DATE: 03-20-2023
PREPARED BY: JOSHUA WEIR
VERSION #: 01
DISCLAIMER:
THE INFORMATION CONTAINED IN THIS DOCUMENT APPLIES TO THIS SPECIFIC
MATERIAL AS SUPPLIED. IT MAY NOT BE VALID FOR THIS MATERIAL IF IT IS
USED IN COMBINATION WITH ANY OTHER MATERIALS. THIS INFORMATION IS
ACCURATE TO THE BEST OF CRC'S KNOWLEDGE OR OBTAINED FROM SOURCES
BELIEVED BY CRC TO BE ACCURATE. BEFORE USING ANY PRODUCT, READ ALL
WARNINGS AND DIRECTIONS ON THE LABEL. FOR FURTHER CLARIFICATION OF ANY
INFORMATION CONTAINED ON THIS (M)SDS CONSULT YOUR SUPERVISOR, A HEALTH &
SAFETY PROFESSIONAL, OR CRC INDUSTRIES, INC..
REVISION INFORMATION:
THIS DOCUMENT HAS UNDERGONE SIGNIFICANT CHANGES AND SHOULD BE REVIEWED IN
ITS ENTIRETY.
MATERIAL NAME: OILFIELD DRY MOLY LUBE - 11 OZ
SDS US