| Common Name: | DRY GRAPHITE LUBE - 10 OZ NO. 03094 (ITEM 1003362) |
| Manufacturer: | CRC INDUSTRIES |
| SDS Revision Date: | 10/6/2022 |
| SDS Format: | No Format Specified |
| Item Number(s): | 4JB39 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
CRC(R*)
SAFETY DATA SHEET
| 1. IDENTIFICATION |  |
PRODUCT IDENTIFIER: DRY GRAPHITE LUBE - 10 OZ
OTHER MEANS OF IDENTIFICATION:
PRODUCT CODE: NO. 03094 (ITEM# 1003362)
RECOMMENDED USE: DRY FILM LUBRICANT
RECOMMENDED RESTRICTIONS: NONE KNOWN.
MANUFACTURER/IMPORTER/SUPPLIER/DISTRIBUTOR INFORMATION:
MANUFACTURED OR SOLD BY:
COMPANY NAME: CRC INDUSTRIES, INC.
ADDRESS:
885 LOUIS DR.
WARMINSTER, PA 18974
US
TELEPHONE:
GENERAL INFORMATION: 215-674-4300
TECHNICAL ASSISTANCE: 800-521-3168
CUSTOMER SERVICE: 800-272-4620
24-HOUR EMERGENCY (CHEMTREC): 800-424-9300 (US)
WEBSITE: WWW.CRCINDUSTRIES.COM
| 2. HAZARD(S) IDENTIFICATION | |
PHYSICAL HAZARDS:
HEALTH HAZARDS:
FLAMMABLE AEROSOLS: CATEGORY 1
GASES UNDER PRESSURE: LIQUEFIED GAS
SERIOUS EYE DAMAGE/EYE IRRITATION: CATEGORY 2A
REPRODUCTIVE TOXICITY: CATEGORY 1B
SPECIFIC TARGET ORGAN TOXICITY, SINGLE EXPOSURE:
CATEGORY 3 NARCOTIC EFFECTS
SPECIFIC TARGET ORGAN TOXICITY, REPEATED EXPOSURE: CATEGORY 2
ENVIRONMENTAL HAZARDS:
HAZARDOUS TO THE AQUATIC ENVIRONMENT, ACUTE HAZARD: CATEGORY 2
OSHA DEFINED HAZARDS: NOT CLASSIFIED.
LABEL ELEMENTS:
FLAME
GAS CYLINDER
HEALTH HAZARD
EXCLAMATION MARK
SIGNAL WORD: DANGER
HAZARD STATEMENT:
EXTREMELY FLAMMABLE AEROSOL. CONTAINS GAS UNDER PRESSURE; MAY EXPLODE IF
HEATED. CAUSES SERIOUS EYE IRRITATION. MAY CAUSE DROWSINESS OR DIZZINESS.
MAY DAMAGE FERTILITY OR THE UNBORN CHILD. MAY CAUSE DAMAGE TO ORGANS
THROUGH PROLONGED OR REPEATED EXPOSURE.
PRECAUTIONARY STATEMENT:
PREVENTION:
OBTAIN SPECIAL INSTRUCTIONS BEFORE USE. DO NOT HANDLE UNTIL ALL SAFETY
PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD. KEEP AWAY FROM HEAT/SPARKS/OPEN
FLAMES/HOT SURFACES. - NO SMOKING. DO NOT SPRAY ON AN OPEN FLAME OR OTHER
IGNITION SOURCE.
PRESSURIZED CONTAINER:
DO NOT PIERCE OR BURN, EVEN AFTER USE. DO NOT APPLY WHILE EQUIPMENT IS
ENERGIZED. EXTINGUISH ALL FLAMES, PILOT LIGHTS, AND HEATERS. VAPORS WILL
ACCUMULATE READILY AND MAY IGNITE. DO NOT BREATHE MIST/VAPORS. USE ONLY
OUTDOORS OR IN A WELL-VENTILATED AREA. MAINTAIN VENTILATION DURING USE AND
UNTIL ALL VAPORS ARE GONE. OPEN DOORS AND WINDOWS OR USE OTHER MEANS TO
ENSURE A FRESH AIR SUPPLY DURING USE AND WHILE PRODUCT IS DRYING. IF YOU
EXPERIENCE ANY SYMPTOMS LISTED ON THIS LABEL, INCREASE VENTILATION OR LEAVE
THE AREA. WASH THOROUGHLY AFTER HANDLING. WEAR PROTECTIVE GLOVES/PROTECTIVE
CLOTHING/EYE PROTECTION/FACE PROTECTION.
RESPONSE:
IF INHALED:
REMOVE PERSON TO FRESH AIR AND KEEP COMFORTABLE FOR BREATHING. CALL A
POISON CENTER/DOCTOR IF YOU FEEL UNWELL.
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES,
IF PRESENT AND EASY TO DO. CONTINUE RINSING.
IF EYE IRRITATION PERSISTS: GET MEDICAL ADVICE/ATTENTION.
IF EXPOSED OR CONCERNED: GET MEDICAL ADVICE/ATTENTION.
STORAGE:
KEEP CONTAINER TIGHTLY CLOSED. STORE LOCKED UP. PROTECT FROM SUNLIGHT.
STORE IN A WELL-VENTILATED PLACE. DO NOT EXPOSE TO TEMPERATURES EXCEEDING
50 DEG. C/122 DEG. F. EXPOSURE TO HIGH TEMPERATURE MAY CAUSE CAN TO BURST.
DISPOSAL:
DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH
LOCAL/REGIONAL/NATIONAL/INTERNATIONAL REGULATIONS.
HAZARD(S) NOT OTHERWISE CLASSIFIED (HNOC): NONE KNOWN.
SUPPLEMENTAL INFORMATION: NONE.
| 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
MIXTURES:
CHEMICAL NAME COMMON NAME AND SYNONYMS CAS NUMBER %
ACETONE 67-64-1 40 - 50
BUTANE 106-97-8 10 - 20
ISOPROPYL ALCOHOL 67-63-0 10 - 20
PROPANE 74-98-6 10 - 20
GRAPHITE 7782-42-5 1 - 5
TOLUENE 108-88-3 1 - 5
SPECIFIC CHEMICAL IDENTITY AND/OR PERCENTAGE OF COMPOSITION HAS BEEN
WITHHELD AS A TRADE SECRET.
| 4. FIRST-AID MEASURES | |
INHALATION:
REMOVE VICTIM TO FRESH AIR AND KEEP AT REST IN A POSITION COMFORTABLE FOR
BREATHING. CALL A POISON CENTER OR DOCTOR/PHYSICIAN IF YOU FEEL UNWELL.
SKIN CONTACT:
WASH OFF WITH SOAP AND WATER. GET MEDICAL ATTENTION IF IRRITATION DEVELOPS
AND PERSISTS.
EYE CONTACT:
IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES.
REMOVE CONTACT LENSES, IF PRESENT AND EASY TO DO. CONTINUE RINSING.
IF EYE IRRITATION PERSISTS: GET MEDICAL ADVICE/ATTENTION.
INGESTION:
IN THE UNLIKELY EVENT OF SWALLOWING CONTACT A PHYSICIAN OR POISON CONTROL
CENTER. RINSE MOUTH.
MOST IMPORTANT SYMPTOMS/EFFECTS, ACUTE AND DELAYED:
MAY CAUSE DROWSINESS OR DIZZINESS. HEADACHE. NAUSEA, VOMITING. SEVERE EYE
IRRITATION. SYMPTOMS MAY INCLUDE STINGING, TEARING, REDNESS, SWELLING, AND
BLURRED VISION. PROLONGED EXPOSURE MAY CAUSE CHRONIC EFFECTS.
INDICATION OF IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED:
PROVIDE GENERAL SUPPORTIVE MEASURES AND TREAT SYMPTOMATICALLY. KEEP VICTIM
UNDER OBSERVATION. SYMPTOMS MAY BE DELAYED.
GENERAL INFORMATION:
IF EXPOSED OR CONCERNED:
GET MEDICAL ADVICE/ATTENTION. ENSURE THAT MEDICAL PERSONNEL ARE AWARE OF
THE MATERIAL(S) INVOLVED, AND TAKE PRECAUTIONS TO PROTECT THEMSELVES. SHOW
THIS SAFETY DATA SHEET TO THE DOCTOR IN ATTENDANCE.
| 5. FIRE-FIGHTING MEASURES | |
SUITABLE EXTINGUISHING MEDIA:
DRY CHEMICAL POWDER. WATER SPRAY. CARBON DIOXIDE (CO2).
UNSUITABLE EXTINGUISHING MEDIA:
DO NOT USE WATER JET AS AN EXTINGUISHER, AS THIS WILL SPREAD THE FIRE.
SPECIFIC HAZARDS ARISING FROM THE CHEMICAL:
CONTENTS UNDER PRESSURE. PRESSURIZED CONTAINER MAY RUPTURE WHEN EXPOSED
TO HEAT OR FLAME. DURING FIRE, GASES HAZARDOUS TO HEALTH MAY BE FORMED.
SPECIAL PROTECTIVE EQUIPMENT AND PRECAUTIONS FOR FIREFIGHTERS:
FIREFIGHTERS MUST USE STANDARD PROTECTIVE EQUIPMENT INCLUDING FLAME
RETARDANT COAT, HELMET WITH FACE SHIELD, GLOVES, RUBBER BOOTS, AND IN
ENCLOSED SPACES, SCBA.
FIRE-FIGHTING EQUIPMENT/INSTRUCTIONS:
IN CASE OF FIRE:
STOP LEAK IF SAFE TO DO SO. MOVE CONTAINERS FROM FIRE AREA IF YOU CAN DO
SO WITHOUT RISK. CONTAINERS SHOULD BE COOLED WITH WATER TO PREVENT VAPOR
PRESSURE BUILD UP. USE STANDARD FIREFIGHTING PROCEDURES AND CONSIDER THE
HAZARDS OF OTHER INVOLVED MATERIALS. IN THE EVENT OF FIRE AND/OR EXPLOSION
DO NOT BREATHE FUMES.
GENERAL FIRE HAZARDS:
EXTREMELY FLAMMABLE AEROSOL. CONTENTS UNDER PRESSURE. PRESSURIZED CONTAINER
MAY RUPTURE WHEN EXPOSED TO HEAT OR FLAME.
| 6. ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
KEEP UNNECESSARY PERSONNEL AWAY. KEEP PEOPLE AWAY FROM AND UPWIND OF
SPILL/LEAK. KEEP OUT OF LOW AREAS. MANY GASES ARE HEAVIER THAN AIR AND
WILL SPREAD ALONG GROUND AND COLLECT IN LOW OR CONFINED AREAS (SEWERS,
BASEMENTS, TANKS). WEAR APPROPRIATE PROTECTIVE EQUIPMENT AND CLOTHING
DURING CLEAN-UP. DO NOT BREATHE MIST/VAPORS. EMERGENCY PERSONNEL NEED
SELF-CONTAINED BREATHING EQUIPMENT. DO NOT TOUCH DAMAGED CONTAINERS OR
SPILLED MATERIAL UNLESS WEARING APPROPRIATE PROTECTIVE CLOTHING. VENTILATE
CLOSED SPACES BEFORE ENTERING THEM. LOCAL AUTHORITIES SHOULD BE ADVISED IF
SIGNIFICANT SPILLAGES CANNOT BE CONTAINED. FOR PERSONAL PROTECTION, SEE
SECTION 8 OF THE SDS.
METHODS AND MATERIALS FOR CONTAINMENT AND CLEANING UP:
ELIMINATE ALL IGNITION SOURCES (NO SMOKING, FLARES, SPARKS, OR FLAMES IN
IMMEDIATE AREA). KEEP COMBUSTIBLES (WOOD, PAPER, OIL, ETC.) AWAY FROM
SPILLED MATERIAL. PREVENT PRODUCT FROM ENTERING DRAINS. STOP THE FLOW OF
MATERIAL, IF THIS IS WITHOUT RISK. WIPE UP WITH ABSORBENT MATERIAL
(E.G. CLOTH, FLEECE). CLEAN SURFACE THOROUGHLY TO REMOVE RESIDUAL
CONTAMINATION. FOR WASTE DISPOSAL, SEE SECTION 13 OF THE SDS.
ENVIRONMENTAL PRECAUTIONS:
AVOID RELEASE TO THE ENVIRONMENT. INFORM APPROPRIATE MANAGERIAL OR
SUPERVISORY PERSONNEL OF ALL ENVIRONMENTAL RELEASES. PREVENT FURTHER
LEAKAGE OR SPILLAGE IF SAFE TO DO SO. AVOID DISCHARGE INTO DRAINS, WATER
COURSES OR ONTO THE GROUND.
| 7. HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING:
OBTAIN SPECIAL INSTRUCTIONS BEFORE USE. DO NOT HANDLE UNTIL ALL SAFETY
PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD.
PRESSURIZED CONTAINER:
DO NOT PIERCE OR BURN, EVEN AFTER USE. DO NOT USE IF SPRAY BUTTON IS
MISSING OR DEFECTIVE. DO NOT SPRAY ON A NAKED FLAME OR ANY OTHER
INCANDESCENT MATERIAL. DO NOT SMOKE WHILE USING OR UNTIL SPRAYED SURFACE
IS THOROUGHLY DRY. DO NOT CUT, WELD, SOLDER, DRILL, GRIND, OR EXPOSE
CONTAINERS TO HEAT, FLAME, SPARKS, OR OTHER SOURCES OF IGNITION. USE
CAUTION AROUND ENERGIZED EQUIPMENT. THE METAL CONTAINER WILL CONDUCT
ELECTRICITY IF IT CONTACTS A LIVE SOURCE. THIS MAY RESULT IN INJURY TO THE
USER FROM ELECTRICAL SHOCK AND/OR FLASH FIRE. DO NOT BREATHE MIST/VAPORS.
AVOID CONTACT WITH EYES. AVOID PROLONGED EXPOSURE. PREGNANT OR
BREASTFEEDING WOMEN MUST NOT HANDLE THIS PRODUCT. SHOULD BE HANDLED IN
CLOSED SYSTEMS, IF POSSIBLE. USE ONLY IN WELL-VENTILATED AREAS. WEAR
APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT. AVOID RELEASE TO THE
ENVIRONMENT. OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES. FOR PRODUCT USAGE
INSTRUCTIONS, SEE THE PRODUCT LABEL.
CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES:
LEVEL 3 AEROSOL.
PRESSURIZED CONTAINER. PROTECT FROM SUNLIGHT AND DO NOT EXPOSE TO
TEMPERATURES EXCEEDING 50 DEG. C/122 DEG. F. DO NOT PUNCTURE, INCINERATE
OR CRUSH. DO NOT HANDLE OR STORE NEAR AN OPEN FLAME, HEAT OR OTHER SOURCES
OF IGNITION. STORE IN TIGHTLY CLOSED CONTAINER. STORE IN A WELL-VENTILATED
PLACE. STORED CONTAINERS SHOULD BE PERIODICALLY CHECKED FOR GENERAL
CONDITION AND LEAKAGE. STORE AWAY FROM INCOMPATIBLE MATERIALS
(SEE SECTION 10 OF THE SDS).
| 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
OCCUPATIONAL EXPOSURE LIMITS:
THE FOLLOWING CONSTITUENTS ARE THE ONLY CONSTITUENTS OF THE PRODUCT WHICH
HAVE A PEL, TLV OR OTHER RECOMMENDED EXPOSURE LIMIT. AT THIS TIME, THE
OTHER CONSTITUENTS HAVE NO KNOWN EXPOSURE LIMITS.
US. OSHA TABLE Z-1 LIMITS FOR AIR CONTAMINANTS (29 CFR 1910.1000):
COMPONENTS TYPE VALUE FORM
ACETONE PEL 2400 MG/M3
(CAS 67-64-1) 1000 PPM
GRAPHITE PEL 5 MG/M3 RESPIRABLE FRACTION.
(CAS 7782-42-5) 15 MG/M3 TOTAL DUST.
ISOPROPYL ALCOHOL PEL 980 MG/M3
(CAS 67-63-0) 400 PPM
PROPANE PEL 1800 MG/M3
(CAS 74-98-6) 1000 PPM
US. OSHA TABLE Z-2 (29 CFR 1910.1000):
COMPONENTS TYPE VALUE
TOLUENE CEILING 300 PPM
(CAS 108-88-3)
TWA 200 PPM
US. OSHA TABLE Z-3 (29 CFR 1910.1000):
COMPONENTS TYPE VALUE
GRAPHITE TWA 15 MPPCF
(CAS 7782-42-5)
US. ACGIH THRESHOLD LIMIT VALUES:
COMPONENTS TYPE VALUE FORM
ACETONE STEL 500 PPM
(CAS 67-64-1)
TWA 250 PPM
BUTANE STEL 1000 PPM
(CAS 106-97-8)
GRAPHITE TWA 2 MG/M3 RESPIRABLE FRACTION.
(CAS 7782-42-5)
ISOPROPYL ALCOHOL STEL 400 PPM
(CAS 67-63-0)
TWA 200 PPM
TOLUENE TWA 20 PPM
(CAS 108-88-3)
US. NIOSH: POCKET GUIDE TO CHEMICAL HAZARDS
COMPONENTS TYPE VALUE FORM
ACETONE TWA 590 MG/M3
(CAS 67-64-1) 250 PPM
BUTANE TWA 1900 MG/M3
(CAS 106-97-8) 800 PPM
GRAPHITE TWA 2.5 MG/M3 RESPIRABLE.
(CAS 7782-42-5)
ISOPROPYL ALCOHOL STEL 1225 MG/M3
(CAS 67-63-0) 500 PPM
TWA 980 MG/M3
400 PPM
PROPANE TWA 1800 MG/M3
(CAS 74-98-6) 1000 PPM
TOLUENE STEL 560 MG/M3
(CAS 108-88-3) 150 PPM
TWA 375 MG/M3
100 PPM
BIOLOGICAL LIMIT VALUES:
ACGIH BIOLOGICAL EXPOSURE INDICES:
COMPONENTS VALUE DETERMINANT SPECIMEN SAMPLING TIME
ACETONE 25 MG/L ACETONE URINE *
(CAS 67-64-1)
ISOPROPYL ALCOHOL 40 MG/L ACETONE URINE *
(CAS 67-63-0)
TOLUENE 0.3 MG/G O-CRESOL, WITH CREATININE *
(CAS 108-88-3) HYDROLYSIS IN URINE
0.03 MG/L TOLUENE URINE *
0.02 MG/L TOLUENE BLOOD *
* - FOR SAMPLING DETAILS, PLEASE SEE THE SOURCE DOCUMENT.
EXPOSURE GUIDELINES:
US - CALIFORNIA OELS SKIN DESIGNATION
TOLUENE (CAS 108-88-3) CAN BE ABSORBED THROUGH THE SKIN.
US - MINNESOTA HAZ SUBS SKIN DESIGNATION APPLIES
TOLUENE (CAS 108-88-3) SKIN DESIGNATION APPLIES.
APPROPRIATE ENGINEERING CONTROLS:
GOOD GENERAL VENTILATION SHOULD BE USED. VENTILATION RATES SHOULD BE
MATCHED TO CONDITIONS. IF APPLICABLE, USE PROCESS ENCLOSURES, LOCAL EXHAUST
VENTILATION, OR OTHER ENGINEERING CONTROLS TO MAINTAIN AIRBORNE LEVELS
BELOW RECOMMENDED EXPOSURE LIMITS. IF EXPOSURE LIMITS HAVE NOT BEEN
ESTABLISHED, MAINTAIN AIRBORNE LEVELS TO AN ACCEPTABLE LEVEL. PROVIDE
EYEWASH STATION.
INDIVIDUAL PROTECTION MEASURES, SUCH AS PERSONAL PROTECTIVE EQUIPMENT:
EYE/FACE PROTECTION: WEAR SAFETY GLASSES WITH SIDE SHIELDS (OR GOGGLES).
SKIN PROTECTION:
HAND PROTECTION:
WEAR PROTECTIVE GLOVES SUCH AS: NITRILE.
OTHER: WEAR SUITABLE PROTECTIVE CLOTHING.
RESPIRATORY PROTECTION:
IF ENGINEERING CONTROLS ARE NOT FEASIBLE OR IF EXPOSURE EXCEEDS THE
APPLICABLE EXPOSURE LIMITS, USE A NIOSH-APPROVED CARTRIDGE RESPIRATOR WITH
AN ORGANIC VAPOR CARTRIDGE. USE A SELF-CONTAINED BREATHING APPARATUS IN
CONFINED SPACES AND FOR EMERGENCIES. AIR MONITORING IS NEEDED TO DETERMINE
ACTUAL EMPLOYEE EXPOSURE LEVELS.
THERMAL HAZARDS:
WEAR APPROPRIATE THERMAL PROTECTIVE CLOTHING, WHEN NECESSARY.
GENERAL HYGIENE CONSIDERATIONS:
WHEN USING DO NOT SMOKE. ALWAYS OBSERVE GOOD PERSONAL HYGIENE MEASURES,
SUCH AS WASHING AFTER HANDLING THE MATERIAL AND BEFORE EATING, DRINKING,
AND/OR SMOKING. ROUTINELY WASH WORK CLOTHING AND PROTECTIVE EQUIPMENT TO
REMOVE CONTAMINANTS.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE:
PHYSICAL STATE: LIQUID.
FORM: AEROSOL.
COLOR: BLACK.
ODOR: AROMATIC.
ODOR THRESHOLD: NOT AVAILABLE.
PH: NOT AVAILABLE.
MELTING POINT/FREEZING POINT: -138.8 DEG. F (-94.9 DEG. C) ESTIMATED
INITIAL BOILING POINT AND BOILING RANGE: 95 DEG. F (35 DEG. C) ESTIMATED
FLASH POINT: -4.0 DEG. F (-20.0 DEG. C)
EVAPORATION RATE: NOT AVAILABLE.
FLAMMABILITY (SOLID, GAS): NOT AVAILABLE.
UPPER/LOWER FLAMMABILITY OR EXPLOSIVE LIMITS:
EXPLOSIVE LIMIT - LOWER (%): 1.5%
EXPLOSIVE LIMIT - UPPER (%): 12%
VAPOR PRESSURE: 2750 HPA
VAPOR DENSITY: NOT AVAILABLE.
RELATIVE DENSITY: 0.8
SOLUBILITY(IES):
SOLUBILITY (WATER): NOT AVAILABLE.
PARTITION COEFFICIENT (N-OCTANOL/WATER): NOT AVAILABLE.
AUTO-IGNITION TEMPERATURE: 750.2 DEG. F (399 DEG. C) ESTIMATED
DECOMPOSITION TEMPERATURE: NOT AVAILABLE.
PERCENT VOLATILE: NOT AVAILABLE.
| 10. STABILITY AND REACTIVITY | |
REACTIVITY:
THE PRODUCT IS STABLE AND NON-REACTIVE UNDER NORMAL CONDITIONS OF USE,
STORAGE AND TRANSPORT.
CHEMICAL STABILITY: MATERIAL IS STABLE UNDER NORMAL CONDITIONS.
POSSIBILITY OF HAZARDOUS REACTIONS:
NO DANGEROUS REACTION KNOWN UNDER CONDITIONS OF NORMAL USE.
CONDITIONS TO AVOID:
HEAT, FLAMES AND SPARKS. CONTACT WITH INCOMPATIBLE MATERIALS. AVOID
OVERHEATING OR FREEZING.
INCOMPATIBLE MATERIALS: STRONG OXIDIZING AGENTS.
HAZARDOUS DECOMPOSITION PRODUCTS: CARBON OXIDES.
| 11. TOXICOLOGICAL INFORMATION | |
INFORMATION ON LIKELY ROUTES OF EXPOSURE:
INHALATION:
MAY CAUSE DROWSINESS OR DIZZINESS. HEADACHE. NAUSEA, VOMITING. PROLONGED
INHALATION MAY BE HARMFUL.
SKIN CONTACT:
BASED ON AVAILABLE DATA, THE CLASSIFICATION CRITERIA ARE NOT MET.
EYE CONTACT: CAUSES SERIOUS EYE IRRITATION.
INGESTION:
BASED ON AVAILABLE DATA, THE CLASSIFICATION CRITERIA ARE NOT MET.
SYMPTOMS RELATED TO THE PHYSICAL, CHEMICAL AND TOXICOLOGICAL
CHARACTERISTICS:
MAY CAUSE DROWSINESS OR DIZZINESS. HEADACHE. NAUSEA, VOMITING. SEVERE EYE
IRRITATION. SYMPTOMS MAY INCLUDE STINGING, TEARING, REDNESS, SWELLING, AND
BLURRED VISION.
INFORMATION ON TOXICOLOGICAL EFFECTS:
ACUTE TOXICITY: NOT KNOWN.
SKIN CORROSION/IRRITATION:
PROLONGED SKIN CONTACT MAY CAUSE TEMPORARY IRRITATION.
SERIOUS EYE DAMAGE/EYE IRRITATION: CAUSES SERIOUS EYE IRRITATION.
RESPIRATORY OR SKIN SENSITIZATION:
RESPIRATORY SENSITIZATION: NOT A RESPIRATORY SENSITIZER.
SKIN SENSITIZATION:
THIS PRODUCT IS NOT EXPECTED TO CAUSE SKIN SENSITIZATION.
GERM CELL MUTAGENICITY:
NO DATA AVAILABLE TO INDICATE PRODUCT OR ANY COMPONENTS PRESENT AT GREATER
THAN 0.1% ARE MUTAGENIC OR GENOTOXIC.
CARCINOGENICITY: NOT CLASSIFIABLE AS TO CARCINOGENICITY TO HUMANS.
IARC MONOGRAPHS. OVERALL EVALUATION OF CARCINOGENICITY:
TOLUENE (CAS 108-88-3): 3 NOT CLASSIFIABLE AS TO CARCINOGENICITY TO HUMANS.
OSHA SPECIFICALLY REGULATED SUBSTANCES (29 CFR 1910.1001-1053): NOT LISTED.
US. NATIONAL TOXICOLOGY PROGRAM (NTP) REPORT ON CARCINOGENS: NOT LISTED.
REPRODUCTIVE TOXICITY: MAY DAMAGE FERTILITY OR THE UNBORN CHILD.
SPECIFIC TARGET ORGAN TOXICITY - SINGLE EXPOSURE:
MAY CAUSE DROWSINESS OR DIZZINESS.
SPECIFIC TARGET ORGAN TOXICITY - REPEATED EXPOSURE:
MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE.
ASPIRATION HAZARD: NOT AN ASPIRATION HAZARD.
CHRONIC EFFECTS:
PROLONGED INHALATION MAY BE HARMFUL. MAY CAUSE DAMAGE TO ORGANS THROUGH
PROLONGED OR REPEATED EXPOSURE.
| 12. ECOLOGICAL INFORMATION | |
ECOTOXICITY: TOXIC TO AQUATIC LIFE.
COMPONENTS SPECIES TEST RESULTS
TOLUENE (CAS 108-88-3):
ACUTE:
OTHER EC50 PSEUDOKIRCHNERELLA SUBCAPITATA 433 MG/L, 96 HOURS
433 MG/L, 96 HOURS
12.5 MG/L, 72 HOURS
12.5 MG/L, 72 HOURS
AQUATIC:
ACUTE:
FISH LC50 COHO SALMON, SILVER SALMON 5.5 MG/L, 96 HOURS
(ONCORHYNCHUS KISUTCH) 5.5 MG/L, 96 HOURS
PERSISTENCE AND DEGRADABILITY:
NO DATA IS AVAILABLE ON THE DEGRADABILITY OF ANY INGREDIENTS IN THE
MIXTURE.
BIOACCUMULATIVE POTENTIAL:
PARTITION COEFFICIENT N-OCTANOL / WATER (LOG KOW):
ACETONE: -0.24
BUTANE: 2.89
ISOPROPYL ALCOHOL: 0.05
PROPANE: 2.36
TOLUENE: 2.73
BIOCONCENTRATION FACTOR (BCF):
TOLUENE: 90
MOBILITY IN SOIL: NO DATA AVAILABLE.
OTHER ADVERSE EFFECTS:
THE PRODUCT CONTAINS VOLATILE ORGANIC COMPOUNDS WHICH HAVE A PHOTOCHEMICAL
OZONE CREATION POTENTIAL.
| 13. DISPOSAL CONSIDERATIONS | |
DISPOSAL INSTRUCTIONS:
THE DISPENSED LIQUID PRODUCT IS A RCRA HAZARDOUS WASTE FOR THE
CHARACTERISTIC OF IGNITABILITY WITH A WASTE CODE OF D001 (SEE 40 CFR PART
261.20 - 261.33). EMPTY CONTAINER CAN BE RECYCLED. FULL OR PARTIALLY-FULL
AEROSOL CANS CAN BE TREATED AS UNIVERSAL WASTE. CONTENTS UNDER PRESSURE.
INCINERATE THE MATERIAL UNDER CONTROLLED CONDITIONS IN AN APPROVED
INCINERATOR. DO NOT INCINERATE SEALED CONTAINERS. DO NOT ALLOW THIS
MATERIAL TO DRAIN INTO SEWERS/WATER SUPPLIES. DO NOT CONTAMINATE PONDS,
WATERWAYS OR DITCHES WITH CHEMICAL OR USED CONTAINER. DISPOSE IN ACCORDANCE
WITH ALL APPLICABLE REGULATIONS.
HAZARDOUS WASTE CODE:
POSSIBLE RCRA WASTE CODE INCLUDES:
D001: WASTE FLAMMABLE MATERIAL WITH A FLASH POINT <140 F
F003: WASTE NON-HALOGENATED SOLVENT - SPENT NON-HALOGENATED SOLVENT
HOWEVER, IT IS THE GENERATOR'S RESPONSIBILITY TO DETERMINE THE PROPER
CLASSIFICATION AND DISPOSAL METHOD AT THE TIME OF DISPOSAL.
CONTAMINATED PACKAGING:
SINCE EMPTIED CONTAINERS MAY RETAIN PRODUCT RESIDUE, FOLLOW LABEL WARNINGS
EVEN AFTER CONTAINER IS EMPTIED. EMPTY CONTAINERS SHOULD BE TAKEN TO AN
APPROVED WASTE HANDLING SITE FOR RECYCLING OR DISPOSAL.
| 14. TRANSPORT INFORMATION | |
DOT:
UN NUMBER: UN1950
UN PROPER SHIPPING NAME: AEROSOLS, FLAMMABLE, LIMITED QUANTITY
TRANSPORT HAZARD CLASS(ES):
CLASS: 2.1
SUBSIDIARY RISK:
LABEL(S): 2.1
PACKING GROUP: NOT ASSIGNED.
ENVIRONMENTAL HAZARDS:
MARINE POLLUTANT: NO.
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
SPECIAL PROVISIONS: N82
PACKAGING EXCEPTIONS: 306
PACKAGING NON BULK: NONE
PACKAGING BULK: NONE
IATA:
UN NUMBER: UN1950
UN PROPER SHIPPING NAME: AEROSOLS, FLAMMABLE, LIMITED QUANTITY
TRANSPORT HAZARD CLASS(ES):
CLASS: 2.1
SUBSIDIARY RISK:
PACKING GROUP: NOT ASSIGNED.
ERG CODE: 10L
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
OTHER INFORMATION:
PASSENGER AND CARGO AIRCRAFT: ALLOWED WITH RESTRICTIONS.
CARGO AIRCRAFT ONLY: ALLOWED WITH RESTRICTIONS.
IMDG:
UN NUMBER: UN1950
UN PROPER SHIPPING NAME: AEROSOLS, LIMITED QUANTITY
TRANSPORT HAZARD CLASS(ES):
CLASS: 2.1
SUBSIDIARY RISK:
PACKING GROUP: NOT ASSIGNED.
ENVIRONMENTAL HAZARDS:
MARINE POLLUTANT: NO.
EMS: F-D, S-U
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
DOT; IMDG: LIMITED QUANTITY FOR PACKAGES NOT PREPARED FOR AIR TRANSPORT
IATA: LIMITED QUANTITY MARKING FOR PACKAGES PREPARED FOR AIR TRANSPORT
| 15. REGULATORY INFORMATION | |
US FEDERAL REGULATIONS:
THIS PRODUCT IS A "HAZARDOUS CHEMICAL" AS DEFINED BY THE OSHA HAZARD
COMMUNICATION STANDARD, 29 CFR 1910.1200.
TSCA SECTION 12(B) EXPORT NOTIFICATION (40 CFR 707, SUBPT. D):
NOT REGULATED.
SARA 304 EMERGENCY RELEASE NOTIFICATION: NOT REGULATED.
OSHA SPECIFICALLY REGULATED SUBSTANCES (29 CFR 1910.1001-1053): NOT LISTED.
CERCLA HAZARDOUS SUBSTANCE LIST (40 CFR 302.4):
ACETONE (CAS 67-64-1)
TOLUENE (CAS 108-88-3)
CERCLA HAZARDOUS SUBSTANCES REPORTABLE QUANTITY
ACETONE (CAS 67-64-1) 5000 LBS
TOLUENE (CAS 108-88-3) 1000 LBS
SPILLS OR RELEASES RESULTING IN THE LOSS OF ANY INGREDIENT AT OR ABOVE
ITS RQ REQUIRE IMMEDIATE NOTIFICATION TO THE NATIONAL RESPONSE CENTER
(800-424-8802) AND TO YOUR LOCAL EMERGENCY PLANNING COMMITTEE.
OTHER FEDERAL REGULATIONS:
CLEAN AIR ACT (CAA) SECTION 112 HAZARDOUS AIR POLLUTANTS (HAPS) LIST:
TOLUENE (CAS 108-88-3)
CLEAN AIR ACT (CAA) SECTION 112(R) ACCIDENTAL RELEASE PREVENTION
(40 CFR 68.130):
BUTANE (CAS 106-97-8)
PROPANE (CAS 74-98-6)
SAFE DRINKING WATER ACT (SDWA):
CONTAINS COMPONENT(S) REGULATED UNDER THE SAFE DRINKING WATER ACT.
DRUG ENFORCEMENT ADMINISTRATION (DEA). LIST 2, ESSENTIAL CHEMICALS
(21 CFR 1310.02(B) AND 1310.04(F)(2) AND CHEMICAL CODE NUMBER:
ACETONE (CAS 67-64-1): 6532
TOLUENE (CAS 108-88-3): 6594
DRUG ENFORCEMENT ADMINISTRATION (DEA). LIST 1 & 2 EXEMPT CHEMICAL MIXTURES
(21 CFR 1310.12(C)):
ACETONE (CAS 67-64-1): 35 %WV
TOLUENE (CAS 108-88-3): 35 %WV
DEA EXEMPT CHEMICAL MIXTURES CODE NUMBER:
ACETONE (CAS 67-64-1): 6532
TOLUENE (CAS 108-88-3): 594
FEMA PRIORITY SUBSTANCES RESPIRATORY HEALTH AND SAFETY IN THE FLAVOR
MANUFACTURING WORKPLACE:
ACETONE (CAS 67-64-1): LOW PRIORITY
ISOPROPYL ALCOHOL (CAS 67-63-0): LOW PRIORITY
FOOD AND DRUG ADMINISTRATION (FDA): NOT REGULATED.
SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 (SARA):
CLASSIFIED HAZARD CATEGORIES:
FLAMMABLE (GASES, AEROSOLS, LIQUIDS, OR SOLIDS)
GAS UNDER PRESSURE
SERIOUS EYE DAMAGE OR EYE IRRITATION
REPRODUCTIVE TOXICITY
SPECIFIC TARGET ORGAN TOXICITY (SINGLE OR REPEATED EXPOSURE)
SARA 302 EXTREMELY HAZARDOUS SUBSTANCE: NOT LISTED.
SARA 311/312 HAZARDOUS CHEMICAL: YES
SARA 313 (TRI REPORTING):
CHEMICAL NAME CAS NUMBER % BY WT.
TOLUENE 108-88-3 1 - 5
US STATE REGULATIONS:
US. CALIFORNIA. CANDIDATE CHEMICALS LIST. SAFER CONSUMER PRODUCTS
REGULATIONS (CAL. CODE REGS, TIT. 22, 69502.3, SUBD. (A)):
ACETONE (CAS 67-64-1)
BUTANE (CAS 106-97-8)
ISOPROPYL ALCOHOL (CAS 67-63-0)
TOLUENE (CAS 108-88-3)
US. NEW JERSEY WORKER AND COMMUNITY RIGHT-TO-KNOW ACT:
ACETONE (CAS 67-64-1)
BUTANE (CAS 106-97-8)
GRAPHITE (CAS 7782-42-5)
ISOPROPYL ALCOHOL (CAS 67-63-0)
PROPANE (CAS 74-98-6)
TOLUENE (CAS 108-88-3)
US. MASSACHUSETTS RTK - SUBSTANCE LIST:
ACETONE (CAS 67-64-1)
BUTANE (CAS 106-97-8)
GRAPHITE (CAS 7782-42-5)
ISOPROPYL ALCOHOL (CAS 67-63-0)
PROPANE (CAS 74-98-6)
TOLUENE (CAS 108-88-3)
US. PENNSYLVANIA WORKER AND COMMUNITY RIGHT-TO-KNOW LAW:
ACETONE (CAS 67-64-1)
BUTANE (CAS 106-97-8)
GRAPHITE (CAS 7782-42-5)
ISOPROPYL ALCOHOL (CAS 67-63-0)
PROPANE (CAS 74-98-6)
TOLUENE (CAS 108-88-3)
US. RHODE ISLAND RTK:
ACETONE (CAS 67-64-1)
BUTANE (CAS 106-97-8)
GRAPHITE (CAS 7782-42-5)
ISOPROPYL ALCOHOL (CAS 67-63-0)
PROPANE (CAS 74-98-6)
TOLUENE (CAS 108-88-3)
CALIFORNIA PROPOSITION 65:
WARNING: REPRODUCTIVE HARM - WWW.P65WARNINGS.CA.GOV
CALIFORNIA PROPOSITION 65 - CRT LISTED DATE/DEVELOPMENTAL TOXIN
TOLUENE (CAS 108-88-3) LISTED: JANUARY 1, 1991
VOLATILE ORGANIC COMPOUNDS (VOC) REGULATIONS:
EPA:
VOC CONTENT (40 CFR 51.100(S)): 48.6%
CONSUMER PRODUCTS (40 CFR 59, SUBPT. C): NOT REGULATED
STATE:
CONSUMER PRODUCTS:
THIS PRODUCT IS REGULATED AS A DRY LUBRICANT. THIS PRODUCT IS COMPLIANT
FOR USE IN ALL 50 STATES.
VOC CONTENT (CA): 48.6%
VOC CONTENT (OTC): 48.6%
INTERNATIONAL INVENTORIES:
COUNTRY(S) OR REGION INVENTORY NAME ON INVENTORY
(YES/NO)*
AUSTRALIA AUSTRALIAN INVENTORY OF INDUSTRIAL YES
CHEMICALS (AICIS)
CANADA DOMESTIC SUBSTANCES LIST (DSL) YES
CANADA NON-DOMESTIC SUBSTANCES LIST (NDSL) NO
CHINA INVENTORY OF EXISTING CHEMICAL YES
SUBSTANCES IN CHINA (IECSC)
EUROPE EUROPEAN INVENTORY OF EXISTING YES
COMMERCIAL CHEMICAL SUBSTANCES
(EINECS)
EUROPE EUROPEAN LIST OF NOTIFIED CHEMICAL NO
SUBSTANCES (ELINCS)
JAPAN INVENTORY OF EXISTING AND NEW NO
CHEMICAL SUBSTANCES (ENCS)
KOREA EXISTING CHEMICALS LIST (ECL) YES
NEW ZEALAND NEW ZEALAND INVENTORY YES
PHILIPPINES PHILIPPINE INVENTORY OF CHEMICALS YES
AND CHEMICAL SUBSTANCES (PICCS)
TAIWAN TAIWAN CHEMICAL SUBSTANCE YES
INVENTORY (TCSI)
UNITED STATES & TOXIC SUBSTANCES CONTROL ACT (TSCA) YES
PUERTO RICO INVENTORY
*A "YES" INDICATES THAT ALL COMPONENTS OF THIS PRODUCT COMPLY WITH
THE INVENTORY REQUIREMENTS ADMINISTERED BY THE GOVERNING COUNTRY(S)
A "NO" INDICATES THAT ONE OR MORE COMPONENTS OF THE PRODUCT ARE NOT LISTED
OR EXEMPT FROM LISTING ON THE INVENTORY ADMINISTERED BY THE GOVERNING
COUNTRY(S).
| 16. OTHER INFORMATION, INCLUDING DATE OF PREPARATION | |
OR LAST REVISION
ISSUE DATE: 10-28-2020
REVISION DATE: 10-06-2022
PREPARED BY: ALLISON YOON
VERSION #: 02
DISCLAIMER:
THE INFORMATION CONTAINED IN THIS DOCUMENT APPLIES TO THIS SPECIFIC
MATERIAL AS SUPPLIED. IT MAY NOT BE VALID FOR THIS MATERIAL IF IT IS USED
IN COMBINATION WITH ANY OTHER MATERIALS. THIS INFORMATION IS ACCURATE TO
THE BEST OF CRC'S KNOWLEDGE OR OBTAINED FROM SOURCES BELIEVED BY CRC TO BE
ACCURATE. BEFORE USING ANY PRODUCT, READ ALL WARNINGS AND DIRECTIONS ON
THE LABEL. FOR FURTHER CLARIFICATION OF ANY INFORMATION CONTAINED ON THIS
(M)SDS CONSULT YOUR SUPERVISOR, A HEALTH & SAFETY PROFESSIONAL, OR CRC
INDUSTRIES, INC..
REVISION INFORMATION:
THIS DOCUMENT HAS UNDERGONE SIGNIFICANT CHANGES AND SHOULD BE REVIEWED IN
ITS ENTIRETY.
MATERIAL NAME: DRY GRAPHITE LUBE - 10 OZ
SDS US