| Common Name: | LOCTITE 609 RETAINING COMPOUND KNOWN AS LOCTITE 609 RETAINING COMPOU, 60941 |
| Manufacturer: | HENKEL |
| SDS Revision Date: | 10/6/2022 |
| SDS Format: | No Format Specified |
| Item Number(s): | 4KM31 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
HENKEL
SAFETY DATA SHEET
REVISION NUMBER: 006.2
ISSUE DATE: 10/06/2022
| 1. PRODUCT AND COMPANY IDENTIFICATION |  |
PRODUCT NAME:
LOCTITE 609 RETAINING COMPOUND KNOWN AS LOCTITE(R*) 609(TM) RETAINING
COMPOU
IDH NUMBER: 135513
PRODUCT TYPE/USE: ADHESIVE
ITEM NUMBER: 60941
RESTRICTION OF USE: NONE IDENTIFIED
REGION: UNITED STATES
COMPANY ADDRESS:
HENKEL CORPORATION
ONE HENKEL WAY
ROCKY HILL, CONNECTICUT 06067
CONTACT INFORMATION:
TELEPHONE: +1 (860) 571-5100
MEDICAL EMERGENCY PHONE:
POISON CONTROL CENTER:
1-877-671-4608 (TOLL FREE) OR 1-303-592-1711
TRANSPORT EMERGENCY PHONE:
CHEMTREC: 1-800-424-9300 (TOLL FREE) OR 1-703-527-3887
INTERNET: WWW.HENKELNA.COM
| 2. HAZARDS IDENTIFICATION | |
EMERGENCY OVERVIEW:
WARNING:
CAUSES SKIN IRRITATION.
MAY CAUSE AN ALLERGIC SKIN REACTION.
CAUSES SERIOUS EYE IRRITATION.
MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE.
HAZARD CLASS HAZARD CATEGORY
SKIN IRRITATION 2
EYE IRRITATION 2A
SKIN SENSITIZATION 1
SPECIFIC TARGET ORGAN TOXICITY - REPEATED EXPOSURE 2
PICTOGRAM(S):
HEALTH HAZARD
EXCLAMATION MARK
PRECAUTIONARY STATEMENTS:
PREVENTION:
DO NOT BREATHE VAPORS, MIST, OR SPRAY. WASH AFFECTED AREA THOROUGHLY
AFTER HANDLING. CONTAMINATED WORK CLOTHING SHOULD NOT BE ALLOWED OUT
OF THE WORKPLACE. WEAR PROTECTIVE GLOVES, EYE PROTECTION, AND FACE
PROTECTION.
RESPONSE:
IF ON SKIN: WASH WITH PLENTY OF WATER.
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES,
IF PRESENT AND EASY TO DO. CONTINUE RINSING. GET MEDICAL ATTENTION IF
YOU FEEL UNWELL.
IF SKIN IRRITATION OR RASH OCCURS: GET MEDICAL ATTENTION.
IF EYE IRRITATION PERSISTS:
GET MEDICAL ATTENTION. TAKE OFF CONTAMINATED CLOTHING.
STORAGE: NOT PRESCRIBED
DISPOSAL:
DISPOSE OF CONTENTS AND/OR CONTAINER ACCORDING TO FEDERAL, STATE/PROVINCIAL
AND LOCAL GOVERNMENTAL REGULATIONS.
CLASSIFICATION COMPLIES WITH OSHA HAZARD COMMUNICATION STANDARD
(29 CFR 1910.1200) AND IS CONSISTENT WITH THE PROVISIONS OF THE
UNITED NATIONS GLOBALLY HARMONIZED SYSTEM OF CLASSIFICATION AND
LABELING OF CHEMICALS (GHS).
SEE SECTION 11 FOR ADDITIONAL TOXICOLOGICAL INFORMATION.
| 3. COMPOSITION / INFORMATION ON INGREDIENTS | |
HAZARDOUS COMPONENT(S) CAS NUMBER PERCENTAGE*
2-HYDROXYETHYL METHACRYLATE 868-77-9 10 - 30
POLY (ETHYL METHACRYLATE) 9003-42-3 1 - 5
CUMENE HYDROPEROXIDE 80-15-9 1 - 5
SACCHARIN 81-07-2 1 - 5
METHACRYLIC ACID 79-41-4 0.1 - 1
CUMENE 98-82-8 0.1 - 1
2-PROPENOIC ACID, 2-METHYL-, 2351-43-1 0.1 - 1
2-(2-HYDROXYETHOXY)ETHYL ESTER
* EXACT PERCENTAGES MAY VARY OR ARE TRADE SECRET. CONCENTRATION RANGE
IS PROVIDED TO ASSIST USERS IN PROVIDING APPROPRIATE PROTECTIONS.
| 4. FIRST AID MEASURES | |
INHALATION:
MOVE TO FRESH AIR. IF NOT BREATHING, GIVE ARTIFICIAL RESPIRATION. IF
BREATHING IS DIFFICULT, GIVE OXYGEN. GET MEDICAL ATTENTION.
SKIN CONTACT:
IMMEDIATELY FLUSH SKIN WITH PLENTY OF WATER (USING SOAP, IF AVAILABLE).
REMOVE CONTAMINATED CLOTHING AND FOOTWEAR. WASH CLOTHING BEFORE REUSE.
GET MEDICAL ATTENTION.
EYE CONTACT:
RINSE IMMEDIATELY WITH PLENTY OF WATER, ALSO UNDER THE EYELIDS, FOR AT
LEAST 15 MINUTES. GET MEDICAL ATTENTION.
INGESTION:
DO NOT INDUCE VOMITING. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS
PERSON. GET MEDICAL ATTENTION.
SYMPTOMS: SEE SECTION 11.
| 5. FIRE FIGHTING MEASURES | |
EXTINGUISHING MEDIA:
WATER SPRAY (FOG), FOAM, DRY CHEMICAL OR CARBON DIOXIDE.
SPECIAL FIREFIGHTING PROCEDURES:
WEAR SELF-CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE CLOTHING, SUCH
AS TURN-OUT GEAR.
UNUSUAL FIRE OR EXPLOSION HAZARDS:
UNCONTROLLED POLYMERIZATION MAY OCCUR AT HIGH TEMPERATURES RESULTING IN
EXPLOSIONS OR RUPTURE OF STORAGE CONTAINERS. IN CASE OF FIRE, KEEP
CONTAINERS COOL WITH WATER SPRAY.
HAZARDOUS COMBUSTION PRODUCTS:
OXIDES OF CARBON. OXIDES OF SULFUR. OXIDES OF NITROGEN. IRRITATING ORGANIC
VAPOURS.
| 6. ACCIDENTAL RELEASE MEASURES | |
USE PERSONAL PROTECTION RECOMMENDED IN SECTION 8, ISOLATE THE HAZARD AREA
AND DENY ENTRY TO UNNECESSARY AND UNPROTECTED PERSONNEL.
ENVIRONMENTAL PRECAUTIONS:
DO NOT ALLOW PRODUCT TO ENTER SEWER OR WATERWAYS.
CLEAN-UP METHODS:
REMOVE ALL SOURCES OF IGNITION. EVACUATE AND VENTILATE SPILL AREA; DIKE
SPILL TO PREVENT ENTRY INTO WATER SYSTEM; WEAR FULL PROTECTIVE EQUIPMENT
DURING CLEAN-UP. SOAK UP WITH INERT ABSORBENT MATERIAL (E.G. SAND, SILICA
GEL, ACID BINDER, UNIVERSAL BINDER, SAWDUST). SCRAPE UP AS MUCH MATERIAL
AS POSSIBLE. STORE IN A PARTLY FILLED, CLOSED CONTAINER UNTIL DISPOSAL.
REFER TO SECTION 8 "EXPOSURE CONTROLS / PERSONAL PROTECTION" PRIOR TO
CLEAN UP.
| 7. HANDLING AND STORAGE | |
HANDLING:
USE ONLY WITH ADEQUATE VENTILATION. PREVENT CONTACT WITH EYES, SKIN AND
CLOTHING. DO NOT BREATHE VAPOR AND MIST. WASH THOROUGHLY AFTER HANDLING.
REFER TO SECTION 8.
STORAGE:
FOR SAFE STORAGE, STORE AT OR BELOW 38 DEG. C (100.4 DEG. F)
KEEP IN A COOL, WELL VENTILATED AREA AWAY FROM HEAT, SPARKS AND OPEN FLAME.
KEEP CONTAINER TIGHTLY CLOSED UNTIL READY FOR USE.
| 8. EXPOSURE CONTROLS / PERSONAL PROTECTION | |
EMPLOYERS SHOULD COMPLETE AN ASSESSMENT OF ALL WORKPLACES TO DETERMINE
THE NEED FOR, AND SELECTION OF, PROPER EXPOSURE CONTROLS AND PROTECTIVE
EQUIPMENT FOR EACH TASK PERFORMED.
HAZARDOUS COMPONENT(S) ACGIH TLV OSHA PEL AIHA WEEL OTHER
2-HYDROXYETHYL METHACRYLATE NONE NONE NONE NONE
POLY (ETHYL METHACRYLATE) NONE NONE NONE NONE
CUMENE HYDROPEROXIDE NONE NONE 1 PPM NONE
(6 MG/M3)
TWA (SKIN)
SACCHARIN NONE NONE NONE NONE
METHACRYLIC ACID 20 PPM TWA NONE NONE NONE
CUMENE 5 PPM TWA 50 PPM NONE NONE
(245 MG/M3)
PEL (SKIN)
2-PROPENOIC ACID, NONE NONE NONE NONE
2-METHYL-, 2-(2-HYDROX-
YETHOXY)ETHYL ESTER
ENGINEERING CONTROLS:
PROVIDE ADEQUATE LOCAL EXHAUST VENTILATION TO MAINTAIN WORKER EXPOSURE
BELOW EXPOSURE LIMITS.
RESPIRATORY PROTECTION:
USE NIOSH APPROVED RESPIRATOR IF THERE IS POTENTIAL TO EXCEED EXPOSURE
LIMIT(S).
EYE/FACE PROTECTION:
SAFETY GOGGLES OR SAFETY GLASSES WITH SIDE SHIELDS. FULL FACE PROTECTION
SHOULD BE USED IF THE POTENTIAL FOR SPLASHING OR SPRAYING OF PRODUCT
EXISTS. SAFETY SHOWERS AND EYE WASH STATIONS SHOULD BE AVAILABLE.
SKIN PROTECTION:
USE CHEMICAL RESISTANT, IMPERMEABLE CLOTHING INCLUDING GLOVES AND EITHER
AN APRON OR BODY SUIT TO PREVENT SKIN CONTACT. NEOPRENE GLOVES. BUTYL
RUBBER GLOVES. NATURAL RUBBER GLOVES. GLOVE RECOMMENDATIONS ARE BASED
UPON PERMEATION STUDY RESULTS FOR SIMILAR PRODUCTS.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
PHYSICAL STATE: LIQUID
COLOR: GREEN
ODOR: MILD
ODOR THRESHOLD: NOT AVAILABLE.
PH: NOT APPLICABLE
VAPOR PRESSURE: <5 MM Hg (27 DEG. C (80.6 DEG. F))
BOILING POINT/RANGE: >149 DEG. C (>300.2 DEG. F)
MELTING POINT/ RANGE: NOT AVAILABLE.
SPECIFIC GRAVITY: 1.1
VAPOR DENSITY: NOT AVAILABLE.
FLASH POINT: >93.3 DEG. C (>199.94 DEG. F) TAGLIABUE CLOSED CUP
FLAMMABLE/EXPLOSIVE LIMITS - LOWER: NOT AVAILABLE.
FLAMMABLE/EXPLOSIVE LIMITS - UPPER: NOT AVAILABLE.
AUTOIGNITION TEMPERATURE: NOT AVAILABLE.
FLAMMABILITY: NOT APPLICABLE
EVAPORATION RATE: NOT AVAILABLE.
SOLUBILITY IN WATER: SLIGHT
PARTITION COEFFICIENT (N-OCTANOL/WATER): NOT AVAILABLE.
VOC CONTENT: 2.83 %
VISCOSITY: NOT AVAILABLE.
DECOMPOSITION TEMPERATURE: NOT AVAILABLE.
| 10. STABILITY AND REACTIVITY | |
STABILITY:
STABLE UNDER NORMAL CONDITIONS OF STORAGE AND USE.
HAZARDOUS REACTIONS:
NONE UNDER NORMAL PROCESSING. POLYMERIZATION MAY OCCUR AT ELEVATED
TEMPERATURE OR IN THE PRESENCE OF INCOMPATIBLE MATERIALS.
HAZARDOUS DECOMPOSITION PRODUCTS:
OXIDES OF CARBON. OXIDES OF SULFUR. OXIDES OF NITROGEN. IRRITATING ORGANIC
VAPOURS.
INCOMPATIBLE MATERIALS: STRONG OXIDIZING AGENTS.
REACTIVITY: NOT AVAILABLE.
CONDITIONS TO AVOID:
ELEVATED TEMPERATURES. HEAT, FLAMES, SPARKS AND OTHER SOURCES OF IGNITION.
STORE AWAY FROM INCOMPATIBLE MATERIALS.
| 11. TOXICOLOGICAL INFORMATION | |
RELEVANT ROUTES OF EXPOSURE: SKIN, INHALATION, EYES, INGESTION
POTENTIAL HEALTH EFFECTS/SYMPTOMS:
INHALATION:
INHALATION OF VAPORS OR MISTS OF THE PRODUCT MAY BE IRRITATING TO THE
RESPIRATORY SYSTEM.
SKIN CONTACT:
CAUSES SKIN IRRITATION. MAY CAUSE ALLERGIC SKIN REACTION.
EYE CONTACT: CAUSES SERIOUS EYE IRRITATION.
INGESTION: MAY CAUSE GASTROINTESTINAL TRACT IRRITATION IF SWALLOWED.
HAZARDOUS COMPONENT(S) LD50S AND LC50S IMMEDIATE AND DELAYED
HEALTH EFFECTS
2-HYDROXYETHYL ORAL LD50 (RAT): IRRITANT, ALLERGEN
METHACRYLATE 11.2 G/KG
ORAL LD50 (RAT):
5,050 MG/KG
POLY (ETHYL METHACRYLATE) NONE IRRITANT
CUMENE HYDROPEROXIDE NONE ALLERGEN, CENTRAL
NERVOUS SYSTEM,
CORROSIVE, IRRITANT,
MUTAGEN
SACCHARIN ORAL LD50 (MOUSE): NO TARGET ORGANS
17 G/KG
METHACRYLIC ACID ORAL LD50 (MOUSE): CORROSIVE, IRRITANT,
1,332 MG/KG ALLERGEN
ORAL LD50 (MOUSE):
1,600 MG/KG
ORAL LD50 (MOUSE):
1,250 MG/KG
ORAL LD50 (RABBIT):
1,200 MG/KG
ORAL LD50 (RAT):
1,060 MG/KG
ORAL LD50 (RAT):
2,224 MG/KG
DERMAL LD50 (RABBIT):
500 MG/KG
CUMENE ORAL LD50 (RAT): CENTRAL NERVOUS
2.91 G/KG SYSTEM, IRRITANT,
LUNG
ORAL LD50 (RAT):
1,400 MG/KG
2-PROPENOIC ACID, NONE ALLERGEN, IRRITANT
2-METHYL-, 2-(2-HYDROX-
YETHOXY)ETHYL ESTER
HAZARDOUS COMPONENT(S) NTP IARC OSHA CARCINOGEN
CARCINOGEN CARCINOGEN (SPECIFICALLY
REGULATED)
2-HYDROXYETHYL NO NO NO
METHACRYLATE
POLY NO NO NO
(ETHYL METHACRYLATE)
CUMENE HYDROPEROXIDE NO NO NO
SACCHARIN NO NO NO
METHACRYLIC ACID NO NO NO
CUMENE REASONABLY GROUP 2B NO
ANTICIPATED
TO BE A
HUMAN
CARCINOGEN.
2-PROPENOIC ACID, NO NO NO
2-METHYL-, 2-(2-HYDRO-
XYETHOXY)ETHYL ESTER
| 12. ECOLOGICAL INFORMATION | |
ECOLOGICAL INFORMATION: NOT AVAILABLE.
| 13. DISPOSAL CONSIDERATIONS | |
INFORMATION PROVIDED IS FOR UNUSED PRODUCT ONLY.
RECOMMENDED METHOD OF DISPOSAL:
FOLLOW ALL LOCAL, STATE, FEDERAL AND PROVINCIAL REGULATIONS FOR DISPOSAL.
| 14. TRANSPORT INFORMATION | |
THE TRANSPORT INFORMATION PROVIDED IN THIS SECTION ONLY APPLIES TO THE
MATERIAL/FORMULATION ITSELF, AND IS NOT SPECIFIC TO ANY PACKAGE/
CONFIGURATION.
U.S. DEPARTMENT OF TRANSPORTATION GROUND (49 CFR):
PROPER SHIPPING NAME:
RQ, ENVIRONMENTALLY HAZARDOUS SUBSTANCE, LIQUID, N.O.S.
HAZARD CLASS OR DIVISION: 9
IDENTIFICATION NUMBER: UN 3082
PACKING GROUP: III
DOT HAZARDOUS SUBSTANCE(S): ALPHA,ALPHA-DIMETHYLBENZYLHYDROPEROXIDE
INTERNATIONAL AIR TRANSPORTATION (ICAO/IATA):
PROPER SHIPPING NAME:
RQ, ENVIRONMENTALLY HAZARDOUS SUBSTANCE, LIQUID, N.O.S.
HAZARD CLASS OR DIVISION: 9
IDENTIFICATION NUMBER: UN 3082
PACKING GROUP: III
WATER TRANSPORTATION (IMO/IMDG):
PROPER SHIPPING NAME:
RQ, ENVIRONMENTALLY HAZARDOUS SUBSTANCE, LIQUID, N.O.S.
HAZARD CLASS OR DIVISION: 9
IDENTIFICATION NUMBER: UN 3082
PACKING GROUP: III
| 15. REGULATORY INFORMATION | |
UNITED STATES REGULATORY INFORMATION:
TSCA 8 (B) INVENTORY STATUS:
ALL COMPONENTS ARE LISTED AS ACTIVE OR ARE EXEMPT FROM LISTING ON THE
TOXIC SUBSTANCES CONTROL ACT (TSCA) INVENTORY.
TSCA 12 (B) EXPORT NOTIFICATION: NONE ABOVE REPORTING DE MINIMIS
CERCLA/SARA SECTION 302 EHS: NONE ABOVE REPORTING DE MINIMIS.
CERCLA/SARA SECTION 311/312: IMMEDIATE HEALTH, DELAYED HEALTH
CERCLA/SARA SECTION 313:
THIS PRODUCT CONTAINS THE FOLLOWING TOXIC CHEMICALS SUBJECT TO THE
REPORTING REQUIREMENTS OF SECTION 313 OF THE EMERGENCY PLANNING AND
COMMUNITY RIGHT-TO-KNOW ACT OF 1986 (40 CFR 372). CUMENE HYDROPEROXIDE
(CAS# 80-15-9). SACCHARIN (CAS# 81-07-2). CUMENE (CAS# 98-82-8).
CERCLA REPORTABLE QUANTITY:
CUMENE HYDROPEROXIDE (CAS# 80-15-9) 10 LBS. (4.54 KG)
CALIFORNIA PROPOSITION 65:
THIS PRODUCT CONTAINS A CHEMICAL KNOWN IN THE STATE OF CALIFORNIA TO CAUSE
CANCER. THIS PRODUCT CONTAINS A CHEMICAL KNOWN TO THE STATE OF CALIFORNIA
TO CAUSE BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM.
CANADA REGULATORY INFORMATION:
CEPA DSL/NDSL STATUS:
CONTAINS ONE OR MORE COMPONENTS LISTED ON THE NON-DOMESTIC SUBSTANCES
LIST. ALL OTHER COMPONENTS ARE LISTED ON OR ARE EXEMPT FROM LISTING ON
THE DOMESTIC SUBSTANCES LIST. COMPONENTS LISTED ON THE NDSL MUST BE
TRACKED BY ALL CANADIAN IMPORTERS OF RECORD AS REQUIRED BY ENVIRONMENT
CANADA. THEY MAY BE IMPORTED INTO CANADA IN LIMITED QUANTITIES. PLEASE
CONTACT REGULATORY AFFAIRS FOR ADDITIONAL DETAILS.
| 16. OTHER INFORMATION | |
THIS SAFETY DATA SHEET CONTAINS CHANGES FROM THE PREVIOUS VERSION IN
SECTIONS: 9
PREPARED BY: PRODUCT SAFETY AND REGULATORY AFFAIRS
ISSUE DATE: 10/06/2022
DISCLAIMER:
THE DATA CONTAINED HEREIN ARE FURNISHED FOR INFORMATION ONLY AND ARE
BELIEVED TO BE RELIABLE. HOWEVER, HENKEL CORPORATION AND ITS AFFILIATES
("HENKEL") DOES NOT ASSUME RESPONSIBILITY FOR ANY RESULTS OBTAINED BY
PERSONS OVER WHOSE METHODS HENKEL HAS NO CONTROL. IT IS THE USER'S
RESPONSIBILITY TO DETERMINE THE SUITABILITY OF HENKEL'S PRODUCTS OR
ANY PRODUCTION METHODS MENTIONED HEREIN FOR A PARTICULAR PURPOSE, AND
TO ADOPT SUCH PRECAUTIONS AS MAY BE ADVISABLE FOR THE PROTECTION OF
PROPERTY AND PERSONS AGAINST ANY HAZARDS THAT MAY BE INVOLVED IN THE
HANDLING AND USE OF ANY HENKEL'S PRODUCTS. IN LIGHT OF THE FOREGOING,
HENKEL SPECIFICALLY DISCLAIMS ALL WARRANTIES, EXPRESS OR IMPLIED,
INCLUDING WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR
PURPOSE, ARISING FROM SALE OR USE OF HENKEL'S PRODUCTS. HENKEL FURTHER
DISCLAIMS ANY LIABILITY FOR CONSEQUENTIAL OR INCIDENTAL DAMAGES OF ANY
KIND, INCLUDING LOST PROFITS.
THIS SAFETY DATA SHEET HAS BEEN GENERATED BASED ON OSHA HAZARD
COMMUNICATION STANDARD (29 CFR 1910.1200) AND PROVIDES INFORMATION
IN ACCORDANCE WITH U.S. FEDERAL LAW ONLY. NO WARRANTY OR REPRESENTATION
OF ANY KIND IS GIVEN WITH RESPECT TO THE SUBSTANTIVE OR EXPORT LAWS OF
ANY OTHER JURISDICTION OR COUNTRY. PLEASE CONFIRM THAT THE INFORMATION
PROVIDED HEREIN CONFORMS TO THE SUBSTANTIVE EXPORT OR OTHER LAW OF ANY
OTHER JURISDICTION PRIOR TO EXPORT. PLEASE CONTACT HENKEL PRODUCT SAFETY
AND REGULATORY AFFAIRS FOR ADDITIONAL ASSISTANCE.