| Common Name: | LOCTITE LB 8150 SV A/S KNOWN AS SILVER GRADE ANTI-SEIZE LUBRIC, 76732 |
| Manufacturer: | HENKEL |
| SDS Revision Date: | 6/14/2019 |
| SDS Format: | GHS-US |
| Item Number(s): | 4KM46 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
HENKEL
SAFETY DATA SHEET
REVISION NUMBER: 006.0
ISSUE DATE: 06/14/2019
| 1. PRODUCT AND COMPANY IDENTIFICATION |  |
PRODUCT NAME:
LOCTITE LB 8150 SV A/S KNOWN AS SILVER GRADE ANTI-SEIZE LUBRIC
PRODUCT TYPE/USE: LUBRICANT
RESTRICTION OF USE: NONE IDENTIFIED
IDH NUMBER: 199012
ITEM NUMBER: 76732
REGION: UNITED STATES
COMPANY ADDRESS:
HENKEL CORPORATION
ONE HENKEL WAY
ROCKY HILL, CONNECTICUT 06067
CONTACT INFORMATION:
TELEPHONE: +1 (860) 571-5100
MEDICAL EMERGENCY PHONE:
POISON CONTROL CENTER: 1-877-671-4608 (TOLL FREE) OR 1-303-592-1711
TRANSPORT EMERGENCY PHONE:
CHEMTREC: 1-800-424-9300 (TOLL FREE) OR 1-703-527-3887
INTERNET: WWW.HENKELNA.COM
| 2. HAZARDS IDENTIFICATION | |
EMERGENCY OVERVIEW:
DANGER:
CAUSES SKIN IRRITATION.
CAUSES SERIOUS EYE DAMAGE.
HAZARD CLASS HAZARD CATEGORY
SKIN IRRITATION 2
SERIOUS EYE DAMAGE 1
PICTOGRAM(S): CORROSION
PRECAUTIONARY STATEMENTS:
PREVENTION:
WASH AFFECTED AREA THOROUGHLY AFTER HANDLING. WEAR PROTECTIVE GLOVES, EYE
PROTECTION, AND FACE PROTECTION.
RESPONSE:
IF ON SKIN: WASH WITH PLENTY OF WATER.
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES, IF
PRESENT AND EASY TO DO. CONTINUE RINSING.
IF SKIN IRRITATION OCCURS:
GET MEDICAL ATTENTION. TAKE OFF CONTAMINATED CLOTHING.
STORAGE: NOT PRESCRIBED
DISPOSAL: NOT PRESCRIBED
1% OF THE MIXTURE CONSISTS OF INGREDIENT(S) OF UNKNOWN ACUTE TOXICITY.
CLASSIFICATION COMPLIES WITH OSHA HAZARD COMMUNICATION STANDARD (29 CFR
1910.1200) AND IS CONSISTENT WITH THE PROVISIONS OF THE UNITED NATIONS
GLOBALLY HARMONIZED SYSTEM OF CLASSIFICATION AND LABELING OF CHEMICALS
(GHS).
SEE SECTION 11 FOR ADDITIONAL TOXICOLOGICAL INFORMATION.
| 3. COMPOSITION / INFORMATION ON INGREDIENTS | |
HAZARDOUS COMPONENT(S) CAS NUMBER PERCENTAGE*
DISTILLATES (PETROLEUM), HYDROTREATED 64742-52-5 30 - 60
HEAVY NAPHTHENIC
GRAPHITE 7782-42-5 10 - 30
CALCIUM OXIDE 1305-78-8 10 - 30
PETROLEUM DISTILLATES, HYDROTREATED, 64742-53-6 10 - 30
LIGHT NAPHTHENIC
ALUMINUM NOT POWDER, DUST OR FUME 7429-90-5 5 - 10
WHITE MINERAL OIL (PETROLEUM) 8042-47-5 1 - 5
QUARTZ (SiO2) RESPIRABLE PARTICULATES 14808-60-7 0.1 - 1
(RCS) >=10%
* EXACT PERCENTAGES MAY VARY OR ARE TRADE SECRET. CONCENTRATION RANGE
IS PROVIDED TO ASSIST USERS IN PROVIDING APPROPRIATE PROTECTIONS.
| 4. FIRST AID MEASURES | |
INHALATION:
MOVE TO FRESH AIR. IF NOT BREATHING, GIVE ARTIFICIAL RESPIRATION. IF
BREATHING IS DIFFICULT, GIVE OXYGEN. GET MEDICAL ATTENTION.
SKIN CONTACT:
REMOVE CONTAMINATED CLOTHING AND FOOTWEAR. IMMEDIATELY FLUSH SKIN WITH
PLENTY OF WATER (USING SOAP, IF AVAILABLE). GET MEDICAL ATTENTION. WASH
CLOTHING BEFORE REUSE.
EYE CONTACT:
IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES. GET
MEDICAL ATTENTION.
INGESTION:
DO NOT INDUCE VOMITING. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS
PERSON. GET IMMEDIATE MEDICAL ATTENTION.
SYMPTOMS: SEE SECTION 11.
| 5. FIRE FIGHTING MEASURES | |
EXTINGUISHING MEDIA: FOAM, DRY CHEMICAL OR CARBON DIOXIDE.
SPECIAL FIREFIGHTING PROCEDURES:
WEAR SELF-CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE CLOTHING, SUCH
AS TURN-OUT GEAR. IN CASE OF FIRE, KEEP CONTAINERS COOL WITH WATER SPRAY.
UNUSUAL FIRE OR EXPLOSION HAZARDS: NONE
HAZARDOUS COMBUSTION PRODUCTS:
OXIDES OF CARBON. TOXIC AND IRRITATING VAPORS.
| 6. ACCIDENTAL RELEASE MEASURES | |
USE PERSONAL PROTECTION RECOMMENDED IN SECTION 8, ISOLATE THE HAZARD AREA
AND DENY ENTRY TO UNNECESSARY AND UNPROTECTED PERSONNEL.
ENVIRONMENTAL PRECAUTIONS:
DO NOT ALLOW PRODUCT TO ENTER SEWER OR WATERWAYS.
CLEAN-UP METHODS:
REFER TO SECTION 8 "EXPOSURE CONTROLS / PERSONAL PROTECTION" PRIOR TO CLEAN
UP. FOR SMALL SPILLS WIPE UP WITH PAPER TOWEL AND PLACE IN CONTAINER FOR
DISPOSAL. FOR LARGE SPILLS ABSORB ONTO INERT ABSORBENT MATERIAL AND PLACE
IN SEALED CONTAINER FOR DISPOSAL.
| 7. HANDLING AND STORAGE | |
HANDLING:
USE ONLY WITH ADEQUATE VENTILATION. PREVENT CONTACT WITH EYES, SKIN AND
CLOTHING. DO NOT BREATHE VAPOR AND MIST. WASH THOROUGHLY AFTER HANDLING.
KEEP CONTAINER CLOSED.
STORAGE: KEEP IN A COOL, WELL VENTILATED AREA.
| 8. EXPOSURE CONTROLS / PERSONAL PROTECTION | |
EMPLOYERS SHOULD COMPLETE AN ASSESSMENT OF ALL WORKPLACES TO DETERMINE THE
NEED FOR, AND SELECTION OF, PROPER EXPOSURE CONTROLS AND PROTECTIVE
EQUIPMENT FOR EACH TASK PERFORMED.
HAZARDOUS COMPONENT(S) ACGIH TLV OSHA PEL AIHA WEEL OTHER
DISTILLATES (PETROLEUM), 5 MG/M3 TWA 500 PPM (2,000 NONE NONE
HYDROTREATED HEAVY INHALABLE MG/M3) PEL
NAPHTHENIC FRACTION. 5 MG/M3 PEL MIST.
GRAPHITE 2 MG/M3 TWA 5 MG/M3 PEL NONE NONE
RESPIRABLE RESPIRABLE
FRACTION. FRACTION.
15 MG/M3 PEL
TOTAL DUST.
15 MPPCF TWA
CALCIUM OXIDE 2 MG/M3 TWA 5 MG/M3 PEL NONE NONE
PETROLEUM DISTILLATES, 5 MG/M3 TWA 500 PPM (2,000 NONE NONE
HYDROTREATED, LIGHT INHALABLE MG/M3) PEL
NAPHTHENIC FRACTION. 5 MG/M3 PEL
MIST.
ALUMINUM NOT POWDER, 1 MG/M3 TWA 5 MG/M3 PEL (AS NONE NONE
DUST OR FUME RESPIRABLE Al) RESPIRABLE
FRACTION. FRACTION.
15 MPPCF TWA
RESPIRABLE
FRACTION.
5 MG/M3 TWA
RESPIRABLE
FRACTION.
WHITE MINERAL OIL 5 MG/M3 TWA 5 MG/M3 PEL MIST. NONE NONE
(PETROLEUM) INHALABLE
FRACTION.
QUARTZ (SiO2) RESPIRABLE 0.025 MG/M3 2.4 MPPCF TWA NONE NONE
PARTICULATES (RCS) TWA RESPIRABLE.
>=10% RESPIRABLE 0.1 MG/M3 TWA
FRACTION. RESPIRABLE.
0.05 MG/M3 TWA
(RESPIRABLE
DUST.)
(RESPIRABLE
DUST.)
0.025 MG/M3
OSHA_ACT
(RESPIRABLE
DUST.)
0.05 MG/M3 PEL
RESPIRABLE DUST.
ENGINEERING CONTROLS:
PROVIDE ADEQUATE LOCAL EXHAUST VENTILATION TO MAINTAIN WORKER EXPOSURE
BELOW EXPOSURE LIMITS.
RESPIRATORY PROTECTION:
USE NIOSH APPROVED RESPIRATOR IF THERE IS POTENTIAL TO EXCEED EXPOSURE
LIMIT(S).
EYE/FACE PROTECTION:
SAFETY GOGGLES OR SAFETY GLASSES WITH SIDE SHIELDS. FULL FACE PROTECTION
SHOULD BE USED IF THE POTENTIAL FOR SPLASHING OR SPRAYING OF PRODUCT
EXISTS. SAFETY SHOWERS AND EYE WASH STATIONS SHOULD BE AVAILABLE.
SKIN PROTECTION:
USE IMPERMEABLE GLOVES AND PROTECTIVE CLOTHING AS NECESSARY TO PREVENT SKIN
CONTACT.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
PHYSICAL STATE: PASTE
COLOR: SILVER
ODOR: HYDROCARBON-LIKE
ODOR THRESHOLD: NOT AVAILABLE.
PH: NOT APPLICABLE
VAPOR PRESSURE: <5 MM Hg
BOILING POINT/RANGE: NOT AVAILABLE.
MELTING POINT/RANGE: NOT AVAILABLE.
SPECIFIC GRAVITY: 1.25
VAPOR DENSITY: NOT AVAILABLE.
FLASH POINT: >93 DEG. C (>199.4 DEG. F)
FLAMMABLE/EXPLOSIVE LIMITS - LOWER: NOT AVAILABLE.
FLAMMABLE/EXPLOSIVE LIMITS - UPPER: NOT AVAILABLE.
AUTOIGNITION TEMPERATURE: NOT DETERMINED
FLAMMABILITY: NOT APPLICABLE
EVAPORATION RATE: NOT AVAILABLE.
SOLUBILITY IN WATER: INSOLUBLE
PARTITION COEFFICIENT (N-OCTANOL/WATER): NOT AVAILABLE.
VOC CONTENT: <3%
VISCOSITY: NOT AVAILABLE.
DECOMPOSITION TEMPERATURE: NOT AVAILABLE.
| 10. STABILITY AND REACTIVITY | |
STABILITY: STABLE UNDER NORMAL CONDITIONS OF STORAGE AND USE.
HAZARDOUS REACTIONS: NONE UNDER NORMAL PROCESSING.
HAZARDOUS DECOMPOSITION PRODUCTS:
OXIDES OF CARBON. IRRITATING ORGANIC VAPOURS.
INCOMPATIBLE MATERIALS: STRONG OXIDIZING AGENTS. ACIDS. WATER. ALKALIS.
REACTIVITY: NOT AVAILABLE.
CONDITIONS TO AVOID:
KEEP AWAY FROM HEAT, IGNITION SOURCES AND INCOMPATIBLE MATERIALS.
| 11. TOXICOLOGICAL INFORMATION | |
RELEVANT ROUTES OF EXPOSURE: SKIN, INHALATION, EYES, INGESTION
POTENTIAL HEALTH EFFECTS/SYMPTOMS:
INHALATION:
MAY CAUSE RESPIRATORY TRACT IRRITATION. ABRASION OF CURED MATERIAL SUCH AS
BY SANDING OR GRINDING COULD RELEASE RESPIRABLE PARTICLES OF SILICA QUARTZ,
A CANCER HAZARD BY INHALATION. NORMAL USE OF THIS PRODUCT CAUSES NO SUCH
RELEASE.
SKIN CONTACT: CAUSES SKIN IRRITATION.
EYE CONTACT: CAUSES SERIOUS EYE DAMAGE.
INGESTION:
NOT EXPECTED UNDER NORMAL CONDITIONS OF USE. MAY CAUSE GASTROINTESTINAL
TRACT IRRITATION IF SWALLOWED.
HAZARDOUS COMPONENT(S) LD50S AND LC50S IMMEDIATE AND DELAYED HEALTH
EFFECTS
DISTILLATES (PETROLEUM), NONE IRRITANT
HYDROTREATED HEAVY
NAPHTHENIC
GRAPHITE NONE LUNG
CALCIUM OXIDE NONE IRRITANT, CORROSIVE, EYES
PETROLEUM DISTILLATES, NONE IRRITANT
HYDROTREATED, LIGHT
NAPHTHENIC
ALUMINUM NOT POWDER, NONE CENTRAL NERVOUS SYSTEM,
DUST OR FUME IRRITANT, LUNG
WHITE MINERAL OIL NONE NO DATA
(PETROLEUM)
QUARTZ (SiO2) RESPIRABLE NONE NO DATA
PARTICULATES (RCS)
>=10%
HAZARDOUS COMPONENT(S) NTP CARCINOGEN IARC CARCINOGEN OSHA CARCINOGEN
(SPECIFICALLY
REGULATED)
DISTILLATES (PETROLEUM), NO NO NO
HYDROTREATED HEAVY
NAPHTHENIC
GRAPHITE NO NO NO
CALCIUM OXIDE NO NO NO
PETROLEUM DISTILLATES, NO NO NO
HYDROTREATED, LIGHT
NAPHTHENIC
ALUMINUM NOT POWDER, NO NO NO
DUST OR FUME
WHITE MINERAL OIL NO NO NO
(PETROLEUM)
QUARTZ (SiO2) RESPIRABLE KNOWN TO BE GROUP 1 YES
PARTICULATES (RCS) HUMAN
>=10% CARCINOGEN.
| 12. ECOLOGICAL INFORMATION | |
ECOLOGICAL INFORMATION: NOT AVAILABLE.
| 13. DISPOSAL CONSIDERATIONS | |
INFORMATION PROVIDED IS FOR UNUSED PRODUCT ONLY.
RECOMMENDED METHOD OF DISPOSAL:
FOLLOW ALL LOCAL, STATE, FEDERAL AND PROVINCIAL REGULATIONS FOR DISPOSAL.
HAZARDOUS WASTE NUMBER: NOT A RCRA HAZARDOUS WASTE.
| 14. TRANSPORT INFORMATION | |
THE TRANSPORT INFORMATION PROVIDED IN THIS SECTION ONLY APPLIES TO THE
MATERIAL/FORMULATION ITSELF, AND IS NOT SPECIFIC TO ANY
PACKAGE/CONFIGURATION.
U.S. DEPARTMENT OF TRANSPORTATION GROUND (49 CFR):
PROPER SHIPPING NAME: NOT REGULATED
HAZARD CLASS OR DIVISION: NONE
IDENTIFICATION NUMBER: NONE
PACKING GROUP: NONE
INTERNATIONAL AIR TRANSPORTATION (ICAO/IATA):
PROPER SHIPPING NAME: NOT REGULATED
HAZARD CLASS OR DIVISION: NONE
IDENTIFICATION NUMBER: NONE
PACKING GROUP: NONE
WATER TRANSPORTATION (IMO/IMDG):
PROPER SHIPPING NAME: NOT REGULATED
HAZARD CLASS OR DIVISION: NONE
IDENTIFICATION NUMBER: NONE
PACKING GROUP: NONE
| 15. REGULATORY INFORMATION | |
UNITED STATES REGULATORY INFORMATION:
TSCA 8 (B) INVENTORY STATUS:
ALL COMPONENTS ARE LISTED OR ARE EXEMPT FROM LISTING ON THE TOXIC
SUBSTANCES CONTROL ACT INVENTORY.
TSCA 12 (B) EXPORT NOTIFICATION: NONE ABOVE REPORTING DE MINIMIS
CERCLA/SARA SECTION 302 EHS: NONE ABOVE REPORTING DE MINIMIS.
CERCLA/SARA SECTION 311/312: IMMEDIATE HEALTH, DELAYED HEALTH
CERCLA/SARA SECTION 313: NONE ABOVE REPORTING DE MINIMIS.
CALIFORNIA PROPOSITION 65:
THIS PRODUCT CONTAINS A CHEMICAL KNOWN IN THE STATE OF CALIFORNIA TO CAUSE
CANCER.
CANADA REGULATORY INFORMATION:
CEPA DSL/NDSL STATUS:
ALL COMPONENTS ARE LISTED ON OR ARE EXEMPT FROM LISTING ON THE CANADIAN
DOMESTIC SUBSTANCES LIST.
| 16. OTHER INFORMATION | |
THIS SAFETY DATA SHEET CONTAINS CHANGES FROM THE PREVIOUS VERSION IN
SECTIONS: 2, 11, 14
PREPARED BY: PRODUCT SAFETY AND REGULATORY AFFAIRS
ISSUE DATE: 06/14/2019
DISCLAIMER:
THE DATA CONTAINED HEREIN ARE FURNISHED FOR INFORMATION ONLY AND ARE
BELIEVED TO BE RELIABLE. HOWEVER, HENKEL CORPORATION AND ITS AFFILIATES
("HENKEL") DOES NOT ASSUME RESPONSIBILITY FOR ANY RESULTS OBTAINED BY
PERSONS OVER WHOSE METHODS HENKEL HAS NO CONTROL. IT IS THE USER'S
RESPONSIBILITY TO DETERMINE THE SUITABILITY OF HENKEL'S PRODUCTS OR ANY
PRODUCTION METHODS MENTIONED HEREIN FOR A PARTICULAR PURPOSE, AND TO ADOPT
SUCH PRECAUTIONS AS MAY BE ADVISABLE FOR THE PROTECTION OF PROPERTY AND
PERSONS AGAINST ANY HAZARDS THAT MAY BE INVOLVED IN THE HANDLING AND USE
OF ANY HENKEL'S PRODUCTS. IN LIGHT OF THE FOREGOING, HENKEL SPECIFICALLY
DISCLAIMS ALL WARRANTIES, EXPRESS OR IMPLIED, INCLUDING WARRANTIES OF
MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE, ARISING FROM SALE
OR USE OF HENKEL'S PRODUCTS. HENKEL FURTHER DISCLAIMS ANY LIABILITY FOR
CONSEQUENTIAL OR INCIDENTAL DAMAGES OF ANY KIND, INCLUDING LOST PROFITS.
THIS SAFETY DATA SHEET HAS BEEN GENERATED BASED ON OSHA HAZARD
COMMUNICATION STANDARD (29 CFR 1910.1200) AND PROVIDES INFORMATION IN
ACCORDANCE WITH U.S. FEDERAL LAW ONLY. NO WARRANTY OR REPRESENTATION
OF ANY KIND IS GIVEN WITH RESPECT TO THE SUBSTANTIVE OR EXPORT LAWS
OF ANY OTHER JURISDICTION OR COUNTRY. PLEASE CONFIRM THAT THE INFORMATION
PROVIDED HEREIN CONFORMS TO THE SUBSTANTIVE EXPORT OR OTHER LAW OF ANY
OTHER JURISDICTION PRIOR TO EXPORT. PLEASE CONTACT HENKEL PRODUCT SAFETY
AND REGULATORY AFFAIRS FOR ADDITIONAL ASSISTANCE.