| Common Name: | LOCTITE SF 790 GASKET REMOVER KNOWN AS LOCTITE CHISEL PAINT STRIPPE, 79040 |
| Manufacturer: | HENKEL |
| SDS Revision Date: | 8/28/2019 |
| SDS Format: | GHS-US |
| Item Number(s): | 4KM53 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
HENKEL
SAFETY DATA SHEET
REVISION NUMBER: 008.0
ISSUE DATE: 08/28/2019
| 1. PRODUCT AND COMPANY IDENTIFICATION |  |
PRODUCT NAME:
LOCTITE SF 790 GASKET REMOVER KNOWN AS LOCTITE(R*) CHISEL(R*) PAINT STRIPPE
PRODUCT TYPE/USE: CLEANER
RESTRICTION OF USE: NONE IDENTIFIED
IDH NUMBER: 135544
ITEM NUMBER: 79040
REGION: UNITED STATES
COMPANY ADDRESS:
HENKEL CORPORATION
ONE HENKEL WAY
ROCKY HILL, CONNECTICUT 06067
CONTACT INFORMATION:
TELEPHONE: +1 (860) 571-5100
MEDICAL EMERGENCY PHONE:
POISON CONTROL CENTER: 1-877-671-4608 (TOLL FREE) OR 1-303-592-1711
TRANSPORT EMERGENCY PHONE:
CHEMTREC: 1-800-424-9300 (TOLL FREE) OR 1-703-527-3887
INTERNET: WWW.HENKELNA.COM
THIS PRODUCT IS NOT AND CANNOT BE DISTRIBUTED IN COMMERCE (AS DEFINED IN
TSCA SECTION 3(5)) OR PROCESSED (AS DEFINED IN TSCA SECTION 3(13)) FOR
CONSUMER PAINT OR COATING REMOVAL. PLEASE CONTACT HENKEL PRODUCT
SAFETY & REGULATORY AFFAIRS FOR FURTHER INFORMATION.
| 2. HAZARDS IDENTIFICATION | |
EMERGENCY OVERVIEW:
DANGER:
CONTENTS UNDER PRESSURE.
EXTREMELY FLAMMABLE AEROSOL.
MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS.
CAUSES SKIN IRRITATION.
CAUSES SERIOUS EYE IRRITATION.
MAY CAUSE DROWSINESS OR DIZZINESS.
SUSPECTED OF CAUSING CANCER.
CAUSES DAMAGE TO ORGANS.
MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE.
HAZARD CLASS HAZARD CATEGORY
FLAMMABLE AEROSOL. 1
SKIN IRRITATION 2
EYE IRRITATION 2A
CARCINOGENICITY 2
SPECIFIC TARGET ORGAN TOXICITY - SINGLE EXPOSURE 1
SPECIFIC TARGET ORGAN TOXICITY - SINGLE EXPOSURE 3
SPECIFIC TARGET ORGAN TOXICITY - REPEATED EXPOSURE 2
ASPIRATION HAZARD 1
PICTOGRAM(S):
FLAME
HEALTH HAZARD
EXCLAMATION MARK
PRECAUTIONARY STATEMENTS:
PREVENTION:
OBTAIN SPECIAL INSTRUCTIONS BEFORE USE. DO NOT HANDLE UNTIL ALL SAFETY
PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD. KEEP AWAY FROM HEAT, SPARKS,
OPEN FLAMES, HOT SURFACES - NO SMOKING. DO NOT SPRAY ON AN OPEN FLAME OR
OTHER IGNITION SOURCE. DO NOT PIERCE OR BURN, EVEN AFTER USE. DO NOT
BREATHE MIST OR SPRAY. WASH AFFECTED AREA THOROUGHLY AFTER HANDLING. DO NOT
EAT, DRINK OR SMOKE WHEN USING THIS PRODUCT. USE ONLY OUTDOORS OR IN A
WELL-VENTILATED AREA. WEAR PROTECTIVE GLOVES, CLOTHING, EYE AND FACE
PROTECTION.
RESPONSE:
IF SWALLOWED: IMMEDIATELY CALL A PHYSICIAN OR POISON CONTROL CENTER.
IF ON SKIN:
WASH WITH PLENTY OF WATER. IF INHALED: REMOVE VICTIM TO FRESH AIR AND KEEP
AT REST IN A POSITION COMFORTABLE FOR BREATHING. CALL A POISON CENTER OR
PHYSICIAN IF YOU FEEL UNWELL.
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES,
IF PRESENT AND EASY TO DO. CONTINUE RINSING.
IF EXPOSED: CALL A POISON CENTER OR PHYSICIAN. DO NOT INDUCE VOMITING.
IF SKIN IRRITATION OCCURS: GET MEDICAL ATTENTION.
IF EYE IRRITATION PERSISTS:
GET MEDICAL ATTENTION. TAKE OFF CONTAMINATED CLOTHING.
STORAGE:
STORE IN A WELL-VENTILATED PLACE. KEEP CONTAINER TIGHTLY CLOSED. STORE
LOCKED UP. PROTECT FROM SUNLIGHT. DO NOT EXPOSE TO TEMPERATURES EXCEEDING
50 DEG. C/122 DEG. F.
DISPOSAL:
DISPOSE OF CONTENTS AND/OR CONTAINER ACCORDING TO FEDERAL, STATE/PROVINCIAL
AND LOCAL GOVERNMENTAL REGULATIONS.
2% OF THE MIXTURE CONSISTS OF INGREDIENT(S) OF UNKNOWN ACUTE TOXICITY.
CLASSIFICATION COMPLIES WITH OSHA HAZARD COMMUNICATION STANDARD
(29 CFR 1910.1200) AND IS CONSISTENT WITH THE PROVISIONS OF THE UNITED
NATIONS GLOBALLY HARMONIZED SYSTEM OF CLASSIFICATION AND LABELING OF
CHEMICALS (GHS).
SEE SECTION 11 FOR ADDITIONAL TOXICOLOGICAL INFORMATION.
| 3. COMPOSITION / INFORMATION ON INGREDIENTS | |
HAZARDOUS COMPONENT(S) CAS NUMBER PERCENTAGE*
METHYLENE CHLORIDE 75-09-2 60 - 80
PROPANE/ISOBUTANE 68476-86-8 10 - 30
METHANOL 67-56-1 5 - 10
* EXACT PERCENTAGES MAY VARY OR ARE TRADE SECRET. CONCENTRATION RANGE IS
PROVIDED TO ASSIST USERS IN PROVIDING APPROPRIATE PROTECTIONS.
| 4. FIRST AID MEASURES | |
INHALATION:
MOVE TO FRESH AIR. IF NOT BREATHING, GIVE ARTIFICIAL RESPIRATION. IF
BREATHING IS DIFFICULT, GIVE OXYGEN. IF SYMPTOMS DEVELOP AND PERSIST,
GET MEDICAL ATTENTION.
SKIN CONTACT:
IMMEDIATELY FLUSH SKIN WITH PLENTY OF WATER (USING SOAP, IF AVAILABLE).
IF SYMPTOMS DEVELOP AND PERSIST, GET MEDICAL ATTENTION.
EYE CONTACT:
IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES. SEEK
MEDICAL ADVICE.
INGESTION:
DO NOT INDUCE VOMITING. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS
PERSON. IF VOMITING OCCURS, PREVENT ASPIRATION BY KEEPING THE PATIENT'S
HEAD BELOW THE KNEES. CALL A PHYSICIAN IMMEDIATELY.
SYMPTOMS: SEE SECTION 11.
| 5. FIRE FIGHTING MEASURES | |
EXTINGUISHING MEDIA: FOAM, DRY CHEMICAL OR CARBON DIOXIDE.
SPECIAL FIREFIGHTING PROCEDURES:
FIREFIGHTERS SHOULD WEAR SELF-CONTAINED BREATHING APPARATUS. WATER MAY BE
INEFFECTIVE, BUT MAY BE USED TO COOL EXPOSED CONTAINERS TO PREVENT PRESSURE
BUILD-UP AND POSSIBLE AUTO-IGNITION OR EXPLOSION WHEN EXPOSED TO EXTREME
HEAT. IF WATER IS USED, FOG NOZZLES ARE PREFERABLE.
UNUSUAL FIRE OR EXPLOSION HAZARDS:
VAPOURS MAY ACCUMULATE IN LOW OR CONFINED AREAS, TRAVEL CONSIDERABLE
DISTANCE TO SOURCE OF IGNITION, AND FLASH BACK. CLOSED CONTAINERS MAY
RUPTURE (DUE TO BUILD UP OF PRESSURE) WHEN EXPOSED TO EXTREME HEAT.
HAZARDOUS COMBUSTION PRODUCTS:
IRRITATING ORGANIC VAPOURS. PHOSGENE. HYDROGEN CHLORIDE. OXIDES OF CARBON.
| 6. ACCIDENTAL RELEASE MEASURES | |
USE PERSONAL PROTECTION RECOMMENDED IN SECTION 8, ISOLATE THE HAZARD AREA
AND DENY ENTRY TO UNNECESSARY AND UNPROTECTED PERSONNEL.
ENVIRONMENTAL PRECAUTIONS: DO NOT ALLOW TO ENTER THE GROUND / SOIL.
CLEAN-UP METHODS:
REMOVE ALL SOURCES OF IGNITION. SPILLED LIQUID IS COMBUSTIBLE AND CAN BE
IGNITED BY HEAT, FLAMES, SPARKS, OR OTHER SOURCES OF IGNITION. STORE IN A
CLOSED CONTAINER UNTIL READY FOR DISPOSAL. SOAK UP WITH INERT ABSORBENT.
SCRAPE UP SPILLED MATERIAL AND PLACE IN A CLOSED CONTAINER FOR DISPOSAL.
FOR SMALL SPILLS WIPE UP WITH PAPER TOWEL AND PLACE IN CONTAINER FOR
DISPOSAL.
| 7. HANDLING AND STORAGE | |
HANDLING:
USE ONLY WITH ADEQUATE VENTILATION. PREVENT CONTACT WITH EYES, SKIN AND
CLOTHING. DO NOT BREATHE VAPOR AND MIST. WASH THOROUGHLY AFTER HANDLING.
AVOID BREATHING MISTS OR AEROSOLS OF THIS PRODUCT.
STORAGE:
FOR SAFE STORAGE, STORE BETWEEN 0 DEG. C (32 DEG. F) AND 32 DEG. C
(89.6 DEG. F)
STORE IN A COOL, DRY, WELL-VENTILATED AREA. STORE IN ORIGINAL CONTAINER
UNTIL READY TO USE.
| 8. EXPOSURE CONTROLS / PERSONAL PROTECTION | |
EMPLOYERS SHOULD COMPLETE AN ASSESSMENT OF ALL WORKPLACES TO DETERMINE THE
NEED FOR, AND SELECTION OF, PROPER EXPOSURE CONTROLS AND PROTECTIVE
EQUIPMENT FOR EACH TASK PERFORMED.
HAZARDOUS COMPONENT(S) ACGIH TLV OSHA PEL AIHA WEEL OTHER
METHYLENE CHLORIDE 50 PPM TWA 12.5 PPM OSHA_ACT NONE NONE
25 PPM TWA
125 PPM STEL
PROPANE/ISOBUTANE NONE NONE NONE NONE
METHANOL 200 PPM TWA 200 PPM NONE NONE
(SKIN) (260 MG/M3) PEL
250 PPM STEL
ENGINEERING CONTROLS:
PROVIDE ADEQUATE LOCAL EXHAUST VENTILATION TO MAINTAIN WORKER EXPOSURE
BELOW EXPOSURE LIMITS.
RESPIRATORY PROTECTION:
USE NIOSH APPROVED RESPIRATOR IF THERE IS POTENTIAL TO EXCEED EXPOSURE
LIMIT(S). USE ONLY IN WELL-VENTILATED AREAS.
EYE/FACE PROTECTION:
SAFETY GOGGLES OR SAFETY GLASSES WITH SIDE SHIELDS. FULL FACE PROTECTION
SHOULD BE USED IF THE POTENTIAL FOR SPLASHING OR SPRAYING OF PRODUCT
EXISTS. SAFETY SHOWERS AND EYE WASH STATIONS SHOULD BE AVAILABLE.
SKIN PROTECTION:
USE CHEMICAL RESISTANT, IMPERMEABLE CLOTHING INCLUDING GLOVES AND EITHER
AN APRON OR BODY SUIT TO PREVENT SKIN CONTACT. SILVER SHIELD GLOVES. VITON
GLOVES. POLYVINYL ALCOHOL GLOVES. 4H GLOVES. EVAL-LAMINATE GLOVES.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
PHYSICAL STATE: AEROSOL, LIQUID
COLOR: GRAY, TO, OFF WHITE
ODOR: SHARP, SOLVENT
ODOR THRESHOLD: NOT AVAILABLE.
PH: NOT AVAILABLE.
VAPOR PRESSURE: NOT AVAILABLE.
BOILING POINT/RANGE: NOT AVAILABLE.
MELTING POINT/RANGE: NOT AVAILABLE.
SPECIFIC GRAVITY: 0.789
VAPOR DENSITY: NOT AVAILABLE.
FLASH POINT: <5 DEG. C (<41 DEG. F)
FLAMMABLE/EXPLOSIVE LIMITS - LOWER: NOT AVAILABLE.
FLAMMABLE/EXPLOSIVE LIMITS - UPPER: NOT AVAILABLE.
AUTOIGNITION TEMPERATURE: NOT AVAILABLE.
FLAMMABILITY: EXTREMELY FLAMMABLE AEROSOL.
EVAPORATION RATE: NOT AVAILABLE.
SOLUBILITY IN WATER: SLIGHTLY SOLUBLE
PARTITION COEFFICIENT (N-OCTANOL/WATER): NOT AVAILABLE.
VOC CONTENT: 30%; 237 G/L
VISCOSITY: NOT AVAILABLE.
DECOMPOSITION TEMPERATURE: NOT AVAILABLE.
| 10. STABILITY AND REACTIVITY | |
STABILITY: STABLE UNDER NORMAL CONDITIONS OF STORAGE AND USE.
HAZARDOUS REACTIONS: WILL NOT OCCUR.
HAZARDOUS DECOMPOSITION PRODUCTS:
HYDROGEN CHLORIDE. OXIDES OF CARBON. IRRITATING ORGANIC VAPOURS. PHOSGENE.
INCOMPATIBLE MATERIALS:
ACIDS AND BASES. OXIDIZING AGENTS. SODIUM. POTASSIUM.
REACTIVITY: NOT AVAILABLE.
CONDITIONS TO AVOID: KEEP AWAY FROM HEAT, SPARK AND FLAME.
| 11. TOXICOLOGICAL INFORMATION | |
RELEVANT ROUTES OF EXPOSURE: SKIN, INHALATION, EYES, INGESTION
POTENTIAL HEALTH EFFECTS/SYMPTOMS:
INHALATION:
INHALATION OF VAPOR OR AEROSOL MAY CAUSE SEVERE IRRITATION TO NOSE,
THROAT AND LUNGS. EXCESSIVE INHALATION OF THIS MATERIAL CAUSES HEADACHE,
DIZZINESS, NAUSEA AND INCOORDINATION.
SKIN CONTACT:
CAUSES SKIN IRRITATION. MAY CAUSE IRRITATION DUE TO DEFATTING OF THE SKIN.
EYE CONTACT: CAUSES SERIOUS EYE IRRITATION.
INGESTION:
ASPIRATED MATERIAL CAN ENTER LUNGS AND CAUSE DAMAGE. MAY CAUSE DIZZINESS,
INCOORDINATION, HEADACHE, NAUSEA, AND VOMITING.
HAZARDOUS COMPONENT(S) LD50S AND LC50S IMMEDIATE AND DELAYED
HEALTH EFFECTS
METHYLENE CHLORIDE ORAL LD50 (RAT): BLOOD, CARDIAC, CENTRAL
1,600 MG/KG NERVOUS SYSTEM, CORROSIVE,
IRRITANT, KIDNEY, LIVER,
SOME EVIDENCE OF
CARCINOGENICITY
PROPANE/ISOBUTANE NONE NO RECORDS
METHANOL ORAL LD50 (RAT): EYES, IRRITANT, METABOLIC,
5,628 MG/KG NERVOUS SYSTEM
ORAL LD50 (MOUSE):
7,300 MG/KG
ORAL LD50 (RABBIT):
14.4 G/KG
DERMAL LD50 (RABBIT):
15,800 MG/KG
HAZARDOUS COMPONENT(S) NTP CARCINOGEN IARC CARCINOGEN OSHA CARCINOGEN
(SPECIFICALLY
REGULATED)
METHYLENE CHLORIDE REASONABLY GROUP 2A YES
ANTICIPATED
TO BE A HUMAN
CARCINOGEN.
PROPANE/ISOBUTANE NO NO NO
METHANOL NO NO NO
| 12. ECOLOGICAL INFORMATION | |
ECOLOGICAL INFORMATION: NOT AVAILABLE.
| 13. DISPOSAL CONSIDERATIONS | |
INFORMATION PROVIDED IS FOR UNUSED PRODUCT ONLY.
RECOMMENDED METHOD OF DISPOSAL:
FOLLOW ALL LOCAL, STATE, FEDERAL AND PROVINCIAL REGULATIONS FOR DISPOSAL.
HAZARDOUS WASTE NUMBER:
D001: IGNITABLE.
| 14. TRANSPORT INFORMATION | |
THE TRANSPORT INFORMATION PROVIDED IN THIS SECTION ONLY APPLIES TO THE
MATERIAL/FORMULATION ITSELF, AND IS NOT SPECIFIC TO ANY
PACKAGE/CONFIGURATION.
U.S. DEPARTMENT OF TRANSPORTATION GROUND (49 CFR):
PROPER SHIPPING NAME: AEROSOLS
HAZARD CLASS OR DIVISION: 2.1
IDENTIFICATION NUMBER: UN 1950
PACKING GROUP: NONE
INTERNATIONAL AIR TRANSPORTATION (ICAO/IATA):
PROPER SHIPPING NAME:
AEROSOLS, FLAMMABLE, CONTAINING SUBSTANCES IN DIVISION 6.1, PACKING
GROUP III
HAZARD CLASS OR DIVISION: 2.1 (6.1)
IDENTIFICATION NUMBER: UN 1950
PACKING GROUP: NONE
WATER TRANSPORTATION (IMO/IMDG):
PROPER SHIPPING NAME: AEROSOLS (METHYLENE CHLORIDE)
HAZARD CLASS OR DIVISION: 2.1 (6.1)
IDENTIFICATION NUMBER: UN 1950
PACKING GROUP: NONE
| 15. REGULATORY INFORMATION | |
UNITED STATES REGULATORY INFORMATION:
TSCA 8(B) INVENTORY STATUS:
ALL COMPONENTS ARE LISTED OR ARE EXEMPT FROM LISTING ON THE TOXIC
SUBSTANCES CONTROL ACT INVENTORY.
TSCA 6 RISK MANAGEMENT RULES:
THIS PRODUCT IS NOT AND CANNOT BE DISTRIBUTED IN COMMERCE (AS DEFINED IN
TSCA SECTION 3(5)) OR PROCESSED (AS DEFINED IN TSCA SECTION 3(13)) FOR
CONSUMER PAINT OR COATING REMOVAL. PLEASE CONTACT HENKEL PRODUCT
SAFETY & REGULATORY AFFAIRS FOR FURTHER INFORMATION.
TSCA 12(B) EXPORT NOTIFICATION: METHYLENE CHLORIDE (CAS# 75-09-2).
CERCLA/SARA SECTION 302 EHS: NONE ABOVE REPORTING DE MINIMIS.
CERCLA/SARA SECTION 311/312:
FIRE, PRESSURE, IMMEDIATE HEALTH, DELAYED HEALTH
CERCLA/SARA SECTION 313:
THIS PRODUCT CONTAINS THE FOLLOWING TOXIC CHEMICALS SUBJECT TO THE
REPORTING REQUIREMENTS OF SECTION 313 OF THE EMERGENCY PLANNING AND
COMMUNITY RIGHT-TO-KNOW ACT OF 1986 (40 CFR 372).
METHANOL (CAS# 67-56-1).
METHYLENE CHLORIDE (CAS# 75-09-2).
CERCLA REPORTABLE QUANTITY:
METHYLENE CHLORIDE (CAS# 75-09-2) 1,000 LBS. (454 KG)
CALIFORNIA PROPOSITION 65:
THIS PRODUCT CONTAINS A CHEMICAL KNOWN IN THE STATE OF CALIFORNIA TO CAUSE
CANCER. THIS PRODUCT CONTAINS A CHEMICAL KNOWN TO THE STATE OF CALIFORNIA
TO CAUSE BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM.
CANADA REGULATORY INFORMATION:
CEPA DSL/NDSL STATUS:
ALL COMPONENTS ARE LISTED ON OR ARE EXEMPT FROM LISTING ON THE CANADIAN
DOMESTIC SUBSTANCES LIST.
| 16. OTHER INFORMATION | |
THIS SAFETY DATA SHEET CONTAINS CHANGES FROM THE PREVIOUS VERSION IN
SECTIONS: 1, 15
PREPARED BY: PRODUCT SAFETY AND REGULATORY AFFAIRS
ISSUE DATE: 08/28/2019
DISCLAIMER:
THE DATA CONTAINED HEREIN ARE FURNISHED FOR INFORMATION ONLY AND ARE
BELIEVED TO BE RELIABLE. HOWEVER, HENKEL CORPORATION AND ITS AFFILIATES
('HENKEL') DOES NOT ASSUME RESPONSIBILITY FOR ANY RESULTS OBTAINED BY
PERSONS OVER WHOSE METHODS HENKEL HAS NO CONTROL. IT IS THE USER'S
RESPONSIBILITY TO DETERMINE THE SUITABILITY OF HENKEL'S PRODUCTS OR ANY
PRODUCTION METHODS MENTIONED HEREIN FOR A PARTICULAR PURPOSE, AND TO ADOPT
SUCH PRECAUTIONS AS MAY BE ADVISABLE FOR THE PROTECTION OF PROPERTY AND
PERSONS AGAINST ANY HAZARDS THAT MAY BE INVOLVED IN THE HANDLING AND USE OF
ANY HENKEL'S PRODUCTS. IN LIGHT OF THE FOREGOING, HENKEL SPECIFICALLY
DISCLAIMS ALL WARRANTIES, EXPRESS OR IMPLIED, INCLUDING WARRANTIES OF
MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE, ARISING FROM SALE OR
USE OF HENKEL'S PRODUCTS. HENKEL FURTHER DISCLAIMS ANY LIABILITY FOR
CONSEQUENTIAL OR INCIDENTAL DAMAGES OF ANY KIND, INCLUDING LOST PROFITS.
THIS SAFETY DATA SHEET HAS BEEN GENERATED BASED ON OSHA HAZARD
COMMUNICATION STANDARD (29 CFR 1910.1200) AND PROVIDES INFORMATION IN
ACCORDANCE WITH U.S. FEDERAL LAW ONLY. NO WARRANTY OR REPRESENTATION OF
ANY KIND IS GIVEN WITH RESPECT TO THE SUBSTANTIVE OR EXPORT LAWS OF ANY
OTHER JURISDICTION OR COUNTRY. PLEASE CONFIRM THAT THE INFORMATION PROVIDED
HEREIN CONFORMS TO THE SUBSTANTIVE EXPORT OR OTHER LAW OF ANY OTHER
JURISDICTION PRIOR TO EXPORT. PLEASE CONTACT HENKEL PRODUCT SAFETY AND
REGULATORY AFFAIRS FOR ADDITIONAL ASSISTANCE.