| Common Name: | VANGUARD |
| Manufacturer: | VANAIR |
| SDS Revision Date: | 5/28/2015 |
| SDS Format: | GHS-US |
| Item Number(s): | 4TZW6 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
VANAIR(R*)
MOBILE POWER SOLUTIONS
SAFETY DATA SHEET
VANGUARD
SDS REVISION DATE: 05/28/2015
| 1. IDENTIFICATION OF THE SUBSTANCE/MIXTURE |  |
AND OF THE COMPANY/UNDERTAKING
1.1. PRODUCT IDENTIFIER:
PRODUCT IDENTITY: VANGUARD
ALTERNATE NAMES:
1.2. RELEVANT IDENTIFIED USES OF THE SUBSTANCE OR MIXTURE AND USES ADVISED
AGAINST:
INTENDED USE: SEE TECHNICAL DATA SHEET.
APPLICATION METHOD: SEE TECHNICAL DATA SHEET.
1.3. DETAILS OF THE SUPPLIER OF THE SAFETY DATA SHEET:
COMPANY NAME:
VANAIR MANUFACTURING, INC.
10896 WEST 300 NORTH
MICHIGAN CITY, IN 46360
USA
EMERGENCY:
CHEMTREC (USA): (800) 424-9300
CUSTOMER SERVICE: VANAIR MANUFACTURING, INC.
PHONE: (219) 879-5100
FAX: (219) 879-5800
| 2. HAZARD IDENTIFICATION OF THE PRODUCT | |
2.1. CLASSIFICATION OF THE SUBSTANCE OR MIXTURE:
NO APPLICABLE GHS CATEGORIES.
2.2. LABEL ELEMENTS:
USING THE TOXICITY DATA LISTED IN SECTION 11 AND 12 THE PRODUCT IS LABELED
AS FOLLOWS.
NO APPLICABLE GHS CATEGORIES.
[PREVENTION]: NO GHS PREVENTION STATEMENTS
[RESPONSE]: NO GHS RESPONSE STATEMENTS
[STORAGE]: NO GHS STORAGE STATEMENTS
[DISPOSAL]: NO GHS DISPOSAL STATEMENTS
| 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
THIS PRODUCT IS CONSIDERED A MIXTURE.
INGREDIENT/CHEMICAL DESIGNATIONS WEIGHT % GHS CLASSIFICATION NOTES
DEC-1-ENE, HOMOPOLYMER, HYDROGENATED 75 - 100 NOT CLASSIFIED
CAS NUMBER: 0068037-01-4
[1] SUBSTANCE CLASSIFIED WITH A HEALTH OR ENVIRONMENTAL HAZARD.
[2] SUBSTANCE WITH A WORKPLACE EXPOSURE LIMIT.
[3] PBT-SUBSTANCE OR VPVB-SUBSTANCE.
*THE FULL TEXTS OF THE PHRASES ARE SHOWN IN SECTION 16.
THIS FORMULATION IS CONSIDERED A TRADE SECRET AND SPECIFIC CHEMICAL
IDENTITY AND EXACT PERCENTAGE (CONCENTRATION) OF COMPOSITION MAY HAVE BEEN
WITHHELD. TRADE SECRETS ARE ALLOWABLE PER PARAGRAPH (I) OF 29 CFR 1910.1200
AS LONG AS SPECIFIC CHEMICAL IDENTITY AND EXACT PERCENTAGE COMPOSITION ARE
AVAILABLE AND WILL BE PROVIDED TO HEALTH PROFESSIONALS, EMPLOYEES, OR
DESIGNATED REPRESENTATIVES IN ACCORDANCE WITH APPLICABLE PROVISIONS OF
PARAGRAPH (I).
| 4. FIRST AID MEASURES | |
4.1. DESCRIPTION OF FIRST AID MEASURES:
GENERAL:
IN ALL CASES OF DOUBT, OR WHEN SYMPTOMS PERSIST, SEEK MEDICAL ATTENTION.
NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
INHALATION:
REMOVE TO FRESH AIR, KEEP PATIENT WARM AND AT REST. IF BREATHING IS
IRREGULAR OR STOPPED, GIVE ARTIFICIAL RESPIRATION. IF UNCONSCIOUS PLACE IN
THE RECOVERY POSITION AND OBTAIN IMMEDIATE MEDICAL ATTENTION. GIVE NOTHING
BY MOUTH.
EYES:
IRRIGATE COPIOUSLY WITH CLEAN WATER FOR AT LEAST 15 MINUTES, HOLDING THE
EYELIDS APART AND SEEK MEDICAL ATTENTION.
SKIN:
REMOVE CONTAMINATED CLOTHING. WASH SKIN THOROUGHLY WITH SOAP AND WATER OR
USE A RECOGNIZED SKIN CLEANSER.
INGESTION:
IF SWALLOWED OBTAIN IMMEDIATE MEDICAL ATTENTION. KEEP AT REST. DO NOT
INDUCE VOMITING.
4.2. MOST IMPORTANT SYMPTOMS AND EFFECTS, BOTH ACUTE AND DELAYED:
OVERVIEW: SEE SECTION 2 FOR FURTHER DETAILS.
| 5. FIRE-FIGHTING MEASURES | |
5.1. EXTINGUISHING MEDIA:
DRY CHEMICAL, FOAM, CARBON DIOXIDE OR WATER SPRAY.
5.2. SPECIAL HAZARDS ARISING FROM THE SUBSTANCE OR MIXTURE:
HAZARDOUS DECOMPOSITION: NONE UNDER NORMAL USE.
AVOID BREATHING DUST / FUME / GAS / MIST / VAPORS / SPRAY.
5.3. ADVICE FOR FIRE-FIGHTERS:
IN THE EVENT OF FIRE, WEAR FULL PROTECTIVE CLOTHING AND NIOSH APPROVED
SELF-CONTAINED BREATHING APPARATUS WITH FULL FACE PIECE OPERATED IN THE
PRESSURE DEMAND OR OTHER POSITIVE PRESSURE MODE. MOVE CONTAINER FROM FIRE
AREA IF IT CAN BE DONE WITHOUT RISK. USE WATER TO KEEP FIRE EXPOSED
CONTAINERS COOL AND DISPERSE VAPORS.
ERG GUIDE NO.:
| 6. ACCIDENTAL RELEASE MEASURES | |
6.1. PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
EVACUATE PERSONNEL TO SAFE AREAS. USE PERSONAL PROTECTIVE EQUIPMENT.
6.2. ENVIRONMENTAL PRECAUTIONS:
DO NOT ALLOW SPILLS TO ENTER DRAINS OR WATERWAYS.
USE GOOD PERSONAL HYGIENE PRACTICES. WASH HANDS BEFORE EATING, DRINKING,
SMOKING OR USING TOILET. PROMPTLY REMOVE SOILED CLOTHING AND WASH
THOROUGHLY BEFORE REUSE.
6.3. METHODS AND MATERIAL FOR CONTAINMENT AND CLEANING UP:
USE A NON-COMBUSTIBLE MATERIAL LIKE VERMICULITE, SAND OR EARTH TO SOAK UP
PRODUCT AND PLACE IN A CONTAINER FOR LATER DISPOSAL.
DIKE FOR DISPOSAL AND COVER WITH WET SAND OR EARTH.
| 7. HANDLING AND STORAGE | |
7.1. PRECAUTIONS FOR SAFE HANDLING: SEE SECTION 2 FOR FURTHER DETAILS.
7.2. CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES:
HANDLE CONTAINERS CAREFULLY TO PREVENT DAMAGE AND SPILLAGE.
STORE IN A COOL DRY PLACE.
KEEP CONTAINERS TIGHTLY CLOSED.
INCOMPATIBLE MATERIALS: INCOMPATIBLE WITH STRONG OXIDIZING AGENTS
SEE SECTION 2 FOR FURTHER DETAILS.
7.3. SPECIFIC END USE(S): NO DATA AVAILABLE.
| 8. EXPOSURE CONTROLS AND PERSONAL PROTECTION | |
8.1. CONTROL PARAMETERS:
EXPOSURE:
CAS NO. INGREDIENT SOURCE VALUE
0068037-01-4 DEC-1-ENE, OSHA NO ESTABLISHED LIMIT
HOMOPOLYMER, ACGIH NO ESTABLISHED LIMIT
HYDROGENATED NIOSH NO ESTABLISHED LIMIT
SUPPLIER NO ESTABLISHED LIMIT
CARCINOGEN DATA:
CAS NO. INGREDIENT SOURCE VALUE
0068037-01-4 DEC-1-ENE, OSHA SELECT CARCINOGEN: NO
HOMOPOLYMER,
HYDROGENATED NTP KNOWN: NO;
SUSPECTED: NO
IARC GROUP 1: NO
GROUP 2A: NO
GROUP 2B: NO
GROUP 3: NO
GROUP 4: NO
8.2. EXPOSURE CONTROLS:
RESPIRATORY:
IF WORKERS ARE EXPOSED TO CONCENTRATIONS ABOVE THE EXPOSURE LIMIT THEY MUST
USE THE APPROPRIATE, CERTIFIED RESPIRATORS.
EYES: SAFETY GLASSES WITH SIDE SHIELDS
SKIN:
OVERALLS WHICH COVER THE BODY, ARMS AND LEGS SHOULD BE WORN. SKIN SHOULD
NOT BE EXPOSED. ALL PARTS OF THE BODY SHOULD BE WASHED AFTER CONTACT.
ENGINEERING CONTROLS:
PROVIDE ADEQUATE VENTILATION. WHERE REASONABLY PRACTICABLE THIS SHOULD BE
ACHIEVED BY THE USE OF LOCAL EXHAUST VENTILATION AND GOOD GENERAL
EXTRACTION. IF THESE ARE NOT SUFFICIENT TO MAINTAIN CONCENTRATIONS OF
PARTICULATES AND ANY VAPOR BELOW OCCUPATIONAL EXPOSURE LIMITS SUITABLE
RESPIRATORY PROTECTION MUST BE WORN.
OTHER WORK PRACTICES:
USE GOOD PERSONAL HYGIENE PRACTICES. WASH HANDS BEFORE EATING, DRINKING,
SMOKING OR USING TOILET. PROMPTLY REMOVE SOILED CLOTHING AND WASH
THOROUGHLY BEFORE REUSE.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE: CLEAR AND BRIGHT
ODOR: MILD
ODOR THRESHOLD: NOT MEASURED
PH: NOT MEASURED
MELTING POINT / FREEZING POINT: POUR POINT -51 C
INITIAL BOILING POINT AND BOILING RANGE: NOT MEASURED
FLASH POINT: 251 C
EVAPORATION RATE (ETHER = 1): NOT MEASURED
FLAMMABILITY (SOLID, GAS): NOT APPLICABLE
UPPER/LOWER FLAMMABILITY OR EXPLOSIVE LIMITS:
LOWER EXPLOSIVE LIMIT: NOT MEASURED
UPPER EXPLOSIVE LIMIT: NOT MEASURED
VAPOR PRESSURE (PA): NOT MEASURED
VAPOR DENSITY: NOT MEASURED
SPECIFIC GRAVITY: 0.86
SOLUBILITY IN WATER: NOT MEASURED
PARTITION COEFFICIENT N-OCTANOL/WATER (LOG KOW): NOT MEASURED
AUTO-IGNITION TEMPERATURE: NOT MEASURED
DECOMPOSITION TEMPERATURE: NOT MEASURED
VISCOSITY (CST): 38.0 CST @ 40 C
9.2. OTHER INFORMATION: NONE
| 10. STABILITY AND REACTIVITY | |
10.1. REACTIVITY: HAZARDOUS POLYMERIZATION WILL NOT OCCUR.
10.2. CHEMICAL STABILITY: STABLE UNDER NORMAL CIRCUMSTANCES.
10.3. POSSIBILITY OF HAZARDOUS REACTIONS: NO DATA AVAILABLE.
10.4. CONDITIONS TO AVOID: NONE KNOWN
10.5. INCOMPATIBLE MATERIALS: INCOMPATIBLE WITH STRONG OXIDIZING AGENTS
10.6. HAZARDOUS DECOMPOSITION PRODUCTS: NONE UNDER NORMAL USE.
| 11. TOXICOLOGICAL INFORMATION | |
ACUTE TOXICITY:
PRODUCT IS SAFE FOR INTENDED USE BASED ON THE FORMULATION, TESTING RESULTS
AND THE LONG HISTORY OF SAFE CONSUMER USE.
INGREDIENT ORAL LD50, SKIN LD50, INHALATION VAPOR
MG/KG MG/KG LD50, MG/L/4HR
DEC-1-ENE, HOMOPOLYMER, >5,000.00, RAT NO DATA NO DATA
HYDROGENATED - (68037-01-4) - CATEGORY: NA AVAILABLE AVAILABLE
INGREDIENT INHALATION DUST/MIST INHALATION
LD50, MG/L/4HR GAS LD50, PPM
DEC-1-ENE, HOMOPOLYMER, 4,800.00, RAT - NO DATA AVAILABLE
HYDROGENATED - (68037-01-4) CATEGORY: NA
NOTE:
WHEN NO ROUTE SPECIFIC LD50 DATA IS AVAILABLE FOR AN ACUTE TOXIN, THE
CONVERTED ACUTE TOXICITY POINT ESTIMATE WAS USED IN THE CALCULATION OF
THE PRODUCT'S ATE (ACUTE TOXICITY ESTIMATE).
CLASSIFICATION CATEGORY HAZARD DESCRIPTION
ACUTE TOXICITY (ORAL) NOT APPLICABLE
ACUTE TOXICITY (DERMAL) NOT APPLICABLE
ACUTE TOXICITY (INHALATION) NOT APPLICABLE
SKIN CORROSION/IRRITATION NOT APPLICABLE
SERIOUS EYE DAMAGE/IRRITATION NOT APPLICABLE
RESPIRATORY SENSITIZATION NOT APPLICABLE
SKIN SENSITIZATION NOT APPLICABLE
GERM CELL MUTAGENICITY NOT APPLICABLE
CARCINOGENICITY NOT APPLICABLE
REPRODUCTIVE TOXICITY NOT APPLICABLE
STOT-SINGLE EXPOSURE NOT APPLICABLE
STOT-REPEATED EXPOSURE NOT APPLICABLE
ASPIRATION HAZARD NOT APPLICABLE
| 12. ECOLOGICAL INFORMATION | |
12.1. TOXICITY:
AQUATIC ECOTOXICITY:
INGREDIENT 96 HR LC50 48 HR EC50 ERC50 ALGAE, MG/L
FISH, MG/L CRUSTACEA, MG/L
DEC-1-ENE, HOMOPOLYMER, NOT AVAILABLE NOT AVAILABLE NOT AVAILABLE
HYDROGENATED -
(68037-01-4)
12.2. PERSISTENCE AND DEGRADABILITY:
THERE IS NO DATA AVAILABLE ON THE PREPARATION ITSELF.
12.3. BIOACCUMULATIVE POTENTIAL: NOT MEASURED
12.4. MOBILITY IN SOIL: NO DATA AVAILABLE.
12.5. RESULTS OF PBT AND VPVB ASSESSMENT:
THIS PRODUCT CONTAINS NO PBT/VPVB CHEMICALS.
12.6. OTHER ADVERSE EFFECTS: NO DATA AVAILABLE.
| 13. DISPOSAL CONSIDERATIONS | |
13.1. WASTE TREATMENT METHODS:
OBSERVE ALL FEDERAL, STATE AND LOCAL REGULATIONS WHEN DISPOSING OF THIS
SUBSTANCE.
| 14. TRANSPORT INFORMATION | |
DOT (DOMESTIC SURFACE IMO / IMDG (OCEAN ICAO/IATA
TRANSPORTATION) TRANSPORTATION)
14.1. UN NOT APPLICABLE NOT REGULATED NOT REGULATED
NUMBER
14.2. UN PROPER NOT REGULATED NOT REGULATED NOT REGULATED
SHIPPING NAME
14.3. TRANSPORT DOT HAZARD CLASS: IMDG: AIR CLASS:
HAZARD CLASS(ES) NOT APPLICABLE NOT APPLICABLE NOT APPLICABLE
DOT LABEL: SUB CLASS:
NOT APPLICABLE
14.4. PACKING NOT APPLICABLE NOT APPLICABLE NOT APPLICABLE
GROUP
14.5. ENVIRONMENTAL HAZARDS:
IMDG:
MARINE POLLUTANT: NO
14.6. SPECIAL PRECAUTIONS FOR USER: NO FURTHER INFORMATION
| 15. REGULATORY INFORMATION | |
REGULATORY OVERVIEW:
THE REGULATORY DATA IN SECTION 15 IS NOT INTENDED TO BE ALL-INCLUSIVE, ONLY
SELECTED REGULATIONS ARE REPRESENTED.
TOXIC SUBSTANCE CONTROL ACT (TSCA):
ALL COMPONENTS OF THIS MATERIAL ARE EITHER LISTED OR EXEMPT FROM LISTING ON
THE TSCA INVENTORY.
WHMIS CLASSIFICATION: NOT REGULATED
US EPA TIER II HAZARDS:
FIRE: NO
REACTIVE: NO
SUDDEN RELEASE OF PRESSURE: NO
IMMEDIATE (ACUTE): YES
DELAYED (CHRONIC): NO
EPCRA 311/312 CHEMICALS AND RQS:
TO THE BEST OF OUR KNOWLEDGE, THERE ARE NO CHEMICALS AT LEVELS WHICH
REQUIRE REPORTING UNDER THIS STATUTE.
EPCRA 302 EXTREMELY HAZARDOUS:
TO THE BEST OF OUR KNOWLEDGE, THERE ARE NO CHEMICALS AT LEVELS WHICH
REQUIRE REPORTING UNDER THIS STATUTE.
EPCRA 313 TOXIC CHEMICALS:
TO THE BEST OF OUR KNOWLEDGE, THERE ARE NO CHEMICALS AT LEVELS WHICH
REQUIRE REPORTING UNDER THIS STATUTE.
PROPOSITION 65 - CARCINOGENS (>0.0%):
TO THE BEST OF OUR KNOWLEDGE, THERE ARE NO CHEMICALS AT LEVELS WHICH
REQUIRE REPORTING UNDER THIS STATUTE.
PROPOSITION 65 - DEVELOPMENTAL TOXINS (>0.0%): DI-ISODECYL PHTHALATE (DIDP)
PROPOSITION 65 - FEMALE REPRO TOXINS (>0.0%):
TO THE BEST OF OUR KNOWLEDGE, THERE ARE NO CHEMICALS AT LEVELS WHICH
REQUIRE REPORTING UNDER THIS STATUTE.
PROPOSITION 65 - MALE REPRO TOXINS (>0.0%):
TO THE BEST OF OUR KNOWLEDGE, THERE ARE NO CHEMICALS AT LEVELS WHICH
REQUIRE REPORTING UNDER THIS STATUTE.
N.J. RTK SUBSTANCES (>1%):
TO THE BEST OF OUR KNOWLEDGE, THERE ARE NO CHEMICALS AT LEVELS WHICH
REQUIRE REPORTING UNDER THIS STATUTE.
PENN RTK SUBSTANCES (>1%):
TO THE BEST OF OUR KNOWLEDGE, THERE ARE NO CHEMICALS AT LEVELS WHICH
REQUIRE REPORTING UNDER THIS STATUTE.
| 16. OTHER INFORMATION | |
THE INFORMATION AND RECOMMENDATIONS CONTAINED HEREIN ARE BASED UPON DATA
BELIEVED TO BE CORRECT. HOWEVER, NO GUARANTEE OR WARRANTY OF ANY KIND,
EXPRESSED OR IMPLIED, IS MADE WITH RESPECT TO THE INFORMATION CONTAINED
HEREIN. WE ACCEPT NO RESPONSIBILITY AND DISCLAIM ALL LIABILITY FOR ANY
HARMFUL EFFECTS WHICH MAY BE CAUSED BY EXPOSURE TO OUR PRODUCTS.
CUSTOMERS/USERS OF THIS PRODUCT MUST COMPLY WITH ALL APPLICABLE HEALTH
AND SAFETY LAWS, REGULATIONS, AND ORDERS.
THE FULL TEXT OF THE PHRASES APPEARING IN SECTION 3 IS: NOT APPLICABLE.
THIS IS THE FIRST VERSION IN THE GHS SDS FORMAT. LISTINGS OF CHANGES FROM
PREVIOUS VERSIONS IN OTHER FORMATS ARE NOT APPLICABLE.
THE INFORMATION PROVIDED ON THE SDS IS A CORRECT TO THE BEST OF OUR
KNOWLEDGE, INFORMATION AND BELIEF AT THE DATE OF ITS PUBLICATION. THE
INFORMATION GIVEN IS DESIGNED ONLY AS A GUIDE FOR SAFE HANDLING, USE,
PROCESSING, STORAGE, TRANSPORTATION, DISPOSAL AND RELEASE AND IS NOT TO BE
CONSIDERED AS A WARRANTY OR QUALITY SPECIFICATION. THE INFORMATION RELATES
ONLY TO THE SPECIFIC MATERIAL DESIGNATED AND MAY NOT BE VALID FOR SUCH
MATERIAL USED IN COMBINATION WITH ANY OTHER MATERIAL OR IN ANY PROCESS,
UNLESS SPECIFIED IN THE TEXT.