| Common Name: | LPS MICRO-X NU, 06616 |
| Manufacturer: | ITW PRO BRANDS |
| SDS Revision Date: | 2/13/2018 |
| SDS Format: | GHS-US |
| Item Number(s): | 4XMF1 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
ITW PRO BRANDS
SAFETY DATA SHEET
| 1. IDENTIFICATION |  |
PRODUCT IDENTIFIER: LPS(R*) MICRO-X NU
OTHER MEANS OF IDENTIFICATION:
PART NUMBER: 06616
RECOMMENDED USE:
A SPRAY CLEANER DESIGNED TO REMOVE DIRT, MOISTURE, DUST, FLUX OR OXIDES
FROM THE INTERNAL COMPONENTS OF ELECTRONIC OR PRECISION EQUIPMENT SUCH
AS CIRCUIT BOARDS.
RECOMMENDED RESTRICTIONS: NONE KNOWN.
MANUFACTURER/IMPORTER/SUPPLIER/DISTRIBUTOR INFORMATION:
MANUFACTURER:
COMPANY NAME: ITW PRO BRANDS
ADDRESS:
4647 HUGH HOWELL RD.
TUCKER, GA 30084
COUNTRY: (U.S.A.)
TEL: +1 770-243-8800
IN CASE OF EMERGENCY:
1 -800-424-9300 (INSIDE U.S.)
+001 703-527-3887 (OUTSIDE U.S.)
WEBSITE: WWW.LPSLABS.COM
E-MAIL: LPSSDS@ITWPROBRANDS.COM
| 2. HAZARD(S) IDENTIFICATION | |
PHYSICAL HAZARDS:
FLAMMABLE AEROSOLS: CATEGORY 2
GASES UNDER PRESSURE: LIQUEFIED GAS
HEALTH HAZARDS:
SKIN CORROSION/IRRITATION: CATEGORY 2
REPRODUCTIVE TOXICITY (FERTILITY): CATEGORY 2
SPECIFIC TARGET ORGAN TOXICITY, SINGLE EXPOSURE:
CATEGORY 3 NARCOTIC EFFECTS
SPECIFIC TARGET ORGAN TOXICITY, REPEATED EXPOSURE (INHALATION):
CATEGORY 2 (NERVOUS SYSTEM)
ENVIRONMENTAL HAZARDS: NOT CLASSIFIED.
OSHA DEFINED HAZARDS: NOT CLASSIFIED.
LABEL ELEMENTS:
FLAME
GAS CYLINDER
HEALTH HAZARD
EXCLAMATION MARK
SIGNAL WORD: WARNING
HAZARD STATEMENT:
PRESSURIZED CONTAINER: MAY BURST IF HEATED.
PRESSURIZED CONTAINER: MAY BURST IF HEATED.
PRESSURIZED CONTAINER:
MAY BURST IF HEATED. FLAMMABLE AEROSOL. CONTAINS GAS UNDER PRESSURE; MAY
EXPLODE IF HEATED. CAUSES SKIN IRRITATION. SUSPECTED OF DAMAGING FERTILITY.
MAY CAUSE DROWSINESS OR DIZZINESS. MAY CAUSE DAMAGE TO ORGANS
(NERVOUS SYSTEM) THROUGH PROLONGED OR REPEATED EXPOSURE BY INHALATION.
PRECAUTIONARY STATEMENT:
PREVENTION:
OBTAIN SPECIAL INSTRUCTIONS BEFORE USE. DO NOT HANDLE UNTIL ALL SAFETY
PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD. KEEP AWAY FROM HEAT/SPARKS/OPEN
FLAMES/HOT SURFACES. - NO SMOKING. DO NOT SPRAY ON AN OPEN FLAME OR OTHER
IGNITION SOURCE.
PRESSURIZED CONTAINER:
DO NOT PIERCE OR BURN, EVEN AFTER USE. DO NOT BREATHE GAS. WASH THOROUGHLY
AFTER HANDLING. USE ONLY OUTDOORS OR IN A WELL-VENTILATED AREA. WEAR
PROTECTIVE GLOVES/PROTECTIVE CLOTHING/EYE PROTECTION/FACE PROTECTION.
RESPONSE: SPECIFIC TREATMENT (SEE THIS LABEL).
IF EXPOSED OR CONCERNED: GET MEDICAL ADVICE/ATTENTION.
IF ON SKIN: WASH WITH PLENTY OF WATER.
IF SKIN IRRITATION OCCURS:
GET MEDICAL ADVICE/ATTENTION. TAKE OFF CONTAMINATED CLOTHING AND WASH
BEFORE REUSE.
IF INHALED:
REMOVE PERSON TO FRESH AIR AND KEEP COMFORTABLE FOR BREATHING. CALL A
POISON CENTER/DOCTOR IF YOU FEEL UNWELL.
STORAGE:
STORE IN A WELL-VENTILATED PLACE. KEEP CONTAINER TIGHTLY CLOSED. STORE
LOCKED UP. PROTECT FROM SUNLIGHT. DO NOT EXPOSE TO TEMPERATURES EXCEEDING
50 DEG. C/122 DEG. F.
DISPOSAL:
DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH
LOCAL/REGIONAL/NATIONAL/INTERNATIONAL REGULATIONS.
HAZARD(S) NOT OTHERWISE CLASSIFIED (HNOC): NONE KNOWN.
SUPPLEMENTAL INFORMATION:
81.79% OF THE MIXTURE CONSISTS OF COMPONENT(S) OF UNKNOWN ACUTE ORAL
TOXICITY.
| 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
MIXTURES:
CHEMICAL NAME COMMON NAME CAS NUMBER %
AND SYNONYMS
2-METHYLPENTANE 107-83-5 30 - 40
ETHANE, 1,1,1,2-TETRAFLUORO- 811-97-2 20 - 30
(HFC-134A)
PENTANE 109-66-0 5 - 10
ISOPROPANOL 67-63-0 1 - 10
N-HEXANE 110-54-3 1 - 3
| 4. FIRST-AID MEASURES | |
INHALATION:
REMOVE VICTIM TO FRESH AIR AND KEEP AT REST IN A POSITION COMFORTABLE FOR
BREATHING. CALL A POISON CENTER OR DOCTOR/PHYSICIAN IF YOU FEEL UNWELL.
SKIN CONTACT:
REMOVE CONTAMINATED CLOTHING. WASH WITH PLENTY OF SOAP AND WATER.
IF SKIN IRRITATION OCCURS:
GET MEDICAL ADVICE/ATTENTION. WASH CONTAMINATED CLOTHING BEFORE REUSE.
EYE CONTACT:
RINSE WITH WATER. GET MEDICAL ATTENTION IF IRRITATION DEVELOPS AND
PERSISTS.
INGESTION:
NOT LIKELY, DUE TO THE FORM OF THE PRODUCT. IN THE UNLIKELY EVENT OF
SWALLOWING CONTACT A PHYSICIAN OR POISON CONTROL CENTER. RINSE MOUTH.
MOST IMPORTANT SYMPTOMS/EFFECTS, ACUTE AND DELAYED:
MAY CAUSE DROWSINESS AND DIZZINESS. NARCOSIS. HEADACHE. NAUSEA, VOMITING.
BEHAVIORAL CHANGES. DECREASE IN MOTOR FUNCTIONS. SKIN IRRITATION. MAY CAUSE
REDNESS AND PAIN. PROLONGED EXPOSURE MAY CAUSE CHRONIC EFFECTS.
INDICATION OF IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED:
PROVIDE GENERAL SUPPORTIVE MEASURES AND TREAT SYMPTOMATICALLY. KEEP VICTIM
UNDER OBSERVATION. SYMPTOMS MAY BE DELAYED.
GENERAL INFORMATION:
IF EXPOSED OR CONCERNED:
GET MEDICAL ADVICE/ATTENTION. IF YOU FEEL UNWELL, SEEK MEDICAL ADVICE
(SHOW THE LABEL WHERE POSSIBLE). ENSURE THAT MEDICAL PERSONNEL ARE AWARE
OF THE MATERIAL(S) INVOLVED, AND TAKE PRECAUTIONS TO PROTECT THEMSELVES.
SHOW THIS SAFETY DATA SHEET TO THE DOCTOR IN ATTENDANCE.
| 5. FIRE-FIGHTING MEASURES | |
SUITABLE EXTINGUISHING MEDIA:
WATER FOG. FOAM. DRY CHEMICAL POWDER. CARBON DIOXIDE (CO2).
UNSUITABLE EXTINGUISHING MEDIA:
DO NOT USE WATER JET AS AN EXTINGUISHER, AS THIS WILL SPREAD THE FIRE.
SPECIFIC HAZARDS ARISING FROM THE CHEMICAL:
CONTENTS UNDER PRESSURE. PRESSURIZED CONTAINER MAY EXPLODE WHEN EXPOSED
TO HEAT OR FLAME. DURING FIRE, GASES HAZARDOUS TO HEALTH MAY BE FORMED.
SPECIAL PROTECTIVE EQUIPMENT AND PRECAUTIONS FOR FIREFIGHTERS:
FIREFIGHTERS MUST USE STANDARD PROTECTIVE EQUIPMENT INCLUDING FLAME
RETARDANT COAT, HELMET WITH FACE SHIELD, GLOVES, RUBBER BOOTS, AND IN
ENCLOSED SPACES, SCBA.
FIRE FIGHTING EQUIPMENT/INSTRUCTIONS:
IN CASE OF FIRE:
STOP LEAK IF SAFE TO DO SO. MOVE CONTAINERS FROM FIRE AREA IF YOU CAN DO
SO WITHOUT RISK. CONTAINERS SHOULD BE COOLED WITH WATER TO PREVENT VAPOR
PRESSURE BUILD UP. FOR MASSIVE FIRE IN CARGO AREA, USE UNMANNED HOSE HOLDER
OR MONITOR NOZZLES, IF POSSIBLE. IF NOT, WITHDRAW AND LET FIRE BURN OUT.
SPECIFIC METHODS:
USE STANDARD FIREFIGHTING PROCEDURES AND CONSIDER THE HAZARDS OF OTHER
INVOLVED MATERIALS. MOVE CONTAINERS FROM FIRE AREA IF YOU CAN DO SO
WITHOUT RISK. COOL CONTAINERS EXPOSED TO FLAMES WITH WATER UNTIL WELL
AFTER THE FIRE IS OUT. IN THE EVENT OF FIRE AND/OR EXPLOSION DO NOT
BREATHE FUMES.
GENERAL FIRE HAZARDS:
FLAMMABLE AEROSOL. CONTENTS UNDER PRESSURE. PRESSURIZED CONTAINER MAY
EXPLODE WHEN EXPOSED TO HEAT OR FLAME.
| 6. ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
KEEP UNNECESSARY PERSONNEL AWAY. KEEP PEOPLE AWAY FROM AND UPWIND OF
SPILL/LEAK. KEEP OUT OF LOW AREAS. MANY GASES ARE HEAVIER THAN AIR AND
WILL SPREAD ALONG GROUND AND COLLECT IN LOW OR CONFINED AREAS (SEWERS,
BASEMENTS, TANKS). WEAR APPROPRIATE PROTECTIVE EQUIPMENT AND CLOTHING
DURING CLEAN-UP. DO NOT BREATHE GAS. EMERGENCY PERSONNEL NEED
SELF-CONTAINED BREATHING EQUIPMENT. DO NOT TOUCH DAMAGED CONTAINERS OR
SPILLED MATERIAL UNLESS WEARING APPROPRIATE PROTECTIVE CLOTHING. VENTILATE
CLOSED SPACES BEFORE ENTERING THEM. LOCAL AUTHORITIES SHOULD BE ADVISED IF
SIGNIFICANT SPILLAGES CANNOT BE CONTAINED.
METHODS AND MATERIALS FOR CONTAINMENT AND CLEANING UP:
REFER TO ATTACHED SAFETY DATA SHEETS AND/OR INSTRUCTIONS FOR USE. STOP
LEAK IF YOU CAN DO SO WITHOUT RISK. MOVE THE CYLINDER TO A SAFE AND OPEN
AREA IF THE LEAK IS IRREPARABLE. ISOLATE AREA UNTIL GAS HAS DISPERSED.
ELIMINATE ALL IGNITION SOURCES (NO SMOKING, FLARES, SPARKS, OR FLAMES IN
IMMEDIATE AREA). KEEP COMBUSTIBLES (WOOD, PAPER, OIL, ETC.) AWAY FROM
SPILLED MATERIAL. THIS PRODUCT IS MISCIBLE IN WATER. PREVENT ENTRY INTO
WATERWAYS, SEWER, BASEMENTS OR CONFINED AREAS. ABSORB IN VERMICULITE, DRY
SAND OR EARTH AND PLACE INTO CONTAINERS. FOLLOWING PRODUCT RECOVERY, FLUSH
AREA WITH WATER.
SMALL SPILLS:
WIPE UP WITH ABSORBENT MATERIAL (E.G. CLOTH, FLEECE). CLEAN SURFACE
THOROUGHLY TO REMOVE RESIDUAL CONTAMINATION.
ENVIRONMENTAL PRECAUTIONS:
AVOID DISCHARGE INTO DRAINS, WATER COURSES OR ONTO THE GROUND.
| 7. HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING:
OBTAIN SPECIAL INSTRUCTIONS BEFORE USE. DO NOT HANDLE UNTIL ALL SAFETY
PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD.
PRESSURIZED CONTAINER:
DO NOT PIERCE OR BURN, EVEN AFTER USE. DO NOT USE IF SPRAY BUTTON IS
MISSING OR DEFECTIVE. DO NOT SPRAY ON A NAKED FLAME OR ANY OTHER
INCANDESCENT MATERIAL. DO NOT SMOKE WHILE USING OR UNTIL SPRAYED SURFACE
IS THOROUGHLY DRY. DO NOT CUT, WELD, SOLDER, DRILL, GRIND, OR EXPOSE
CONTAINERS TO HEAT, FLAME, SPARKS, OR OTHER SOURCES OF IGNITION. ALL
EQUIPMENT USED WHEN HANDLING THE PRODUCT MUST BE GROUNDED. DO NOT RE-USE
EMPTY CONTAINERS. DO NOT BREATHE GAS. AVOID CONTACT WITH EYES, SKIN, AND
CLOTHING. AVOID PROLONGED EXPOSURE. PREGNANT OR BREASTFEEDING WOMEN MUST
NOT HANDLE THIS PRODUCT. SHOULD BE HANDLED IN CLOSED SYSTEMS, IF POSSIBLE.
USE ONLY IN WELL-VENTILATED AREAS. WEAR APPROPRIATE PERSONAL PROTECTIVE
EQUIPMENT. OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES.
CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES:
LEVEL 3 AEROSOL.
STORE LOCKED UP. PRESSURIZED CONTAINER. PROTECT FROM SUNLIGHT AND DO NOT
EXPOSE TO TEMPERATURES EXCEEDING 50 DEG. C/122 DEG. F. DO NOT PUNCTURE,
INCINERATE OR CRUSH. DO NOT HANDLE OR STORE NEAR AN OPEN FLAME, HEAT OR
OTHER SOURCES OF IGNITION. THIS MATERIAL CAN ACCUMULATE STATIC CHARGE WHICH
MAY CAUSE SPARK AND BECOME AN IGNITION SOURCE. STORE IN A WELL-VENTILATED
PLACE. CYLINDERS SHOULD BE STORED UPRIGHT, WITH VALVE PROTECTION CAP IN
PLACE, AND FIRMLY SECURED TO PREVENT FALLING OR BEING KNOCKED OVER. STORED
CONTAINERS SHOULD BE PERIODICALLY CHECKED FOR GENERAL CONDITION AND
LEAKAGE.
| 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
OCCUPATIONAL EXPOSURE LIMITS:
THE FOLLOWING CONSTITUENTS ARE THE ONLY CONSTITUENTS OF THE PRODUCT WHICH
HAVE A PEL, TLV OR OTHER RECOMMENDED EXPOSURE LIMIT. AT THIS TIME, THE
OTHER CONSTITUENTS HAVE NO KNOWN EXPOSURE LIMITS.
US. OSHA TABLE Z-1 LIMITS FOR AIR CONTAMINANTS (29 CFR 1910.1000):
COMPONENTS TYPE VALUE
ISOPROPANOL PEL 980 MG/M3
(CAS 67-63-0) 400 PPM
N-HEXANE PEL 1800 MG/M3
(CAS 110-54-3) 500 PPM
PENTANE PEL 2950 MG/M3
(CAS 109-66-0) 1000 PPM
US. ACGIH THRESHOLD LIMIT VALUES:
COMPONENTS TYPE VALUE
2-METHYLPENTANE STEL 1000 PPM
(CAS 107-83-5)
TWA 500 PPM
ISOPROPANOL STEL 400 PPM
(CAS 67-63-0)
TWA 200 PPM
N-HEXANE TWA 50 PPM
(CAS 110-54-3)
PENTANE TWA 1000 PPM
(CAS 109-66-0)
US. NIOSH: POCKET GUIDE TO CHEMICAL HAZARDS
COMPONENTS TYPE VALUE
ISOPROPANOL STEL 1225 MG/M3
(CAS 67-63-0) 500 PPM
TWA 980 MG/M3
400 PPM
N-HEXANE TWA 180 MG/M3
(CAS 110-54-3) 50 PPM
PENTANE CEILING 1800 MG/M3
(CAS 109-66-0) 610 PPM
TWA 350 MG/M3
120 PPM
US. WORKPLACE ENVIRONMENTAL EXPOSURE LEVEL (WEEL) GUIDES:
COMPONENTS TYPE VALUE FORM
ETHANE,1,1,1,2-TETRAFLUORO-(HFC-134A) TWA 1000 PPM 8 HOUR
(CAS 811-97-2)
BIOLOGICAL LIMIT VALUES:
ACGIH BIOLOGICAL EXPOSURE INDICES:
COMPONENTS VALUE DETERMINANT SPECIMEN SAMPLING TIME
ISOPROPANOL 40 MG/L ACETONE URINE *
(CAS 67-63-0)
N-HEXANE 0.4 MG/L 2,5-HEXANEDIONE, URINE *
(CAS 110-54-3) WITHOUT
HYDROLYSIS
* - FOR SAMPLING DETAILS, PLEASE SEE THE SOURCE DOCUMENT.
EXPOSURE GUIDELINES:
US - CALIFORNIA OELS SKIN DESIGNATION
N-HEXANE (CAS 110-54-3) CAN BE ABSORBED THROUGH THE SKIN.
US ACGIH THRESHOLD LIMIT VALUES SKIN DESIGNATION
N-HEXANE (CAS 110-54-3) CAN BE ABSORBED THROUGH THE SKIN.
APPROPRIATE ENGINEERING CONTROLS:
GOOD GENERAL VENTILATION (TYPICALLY 10 AIR CHANGES PER HOUR) SHOULD BE
USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS. IF APPLICABLE,
USE PROCESS ENCLOSURES, LOCAL EXHAUST VENTILATION, OR OTHER ENGINEERING
CONTROLS TO MAINTAIN AIRBORNE LEVELS BELOW RECOMMENDED EXPOSURE LIMITS.
IF EXPOSURE LIMITS HAVE NOT BEEN ESTABLISHED, MAINTAIN AIRBORNE LEVELS
TO AN ACCEPTABLE LEVEL. EYE WASH FACILITIES AND EMERGENCY SHOWER MUST
BE AVAILABLE WHEN HANDLING THIS PRODUCT.
INDIVIDUAL PROTECTION MEASURES, SUCH AS PERSONAL PROTECTIVE EQUIPMENT:
EYE/FACE PROTECTION: WEAR SAFETY GLASSES WITH SIDE SHIELDS (OR GOGGLES).
SKIN PROTECTION:
HAND PROTECTION: WEAR APPROPRIATE CHEMICAL RESISTANT GLOVES.
OTHER:
WEAR APPROPRIATE CHEMICAL RESISTANT CLOTHING. USE OF AN IMPERVIOUS APRON
IS RECOMMENDED.
RESPIRATORY PROTECTION:
IF PERMISSIBLE LEVELS ARE EXCEEDED USE NIOSH MECHANICAL FILTER / ORGANIC
VAPOR CARTRIDGE OR AN AIR-SUPPLIED RESPIRATOR.
THERMAL HAZARDS:
WEAR APPROPRIATE THERMAL PROTECTIVE CLOTHING, WHEN NECESSARY.
GENERAL HYGIENE CONSIDERATIONS:
OBSERVE ANY MEDICAL SURVEILLANCE REQUIREMENTS. WHEN USING DO NOT SMOKE.
ALWAYS OBSERVE GOOD PERSONAL HYGIENE MEASURES, SUCH AS WASHING AFTER
HANDLING THE MATERIAL AND BEFORE EATING, DRINKING, AND/OR SMOKING.
ROUTINELY WASH WORK CLOTHING AND PROTECTIVE EQUIPMENT TO REMOVE
CONTAMINANTS.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE:
PHYSICAL STATE: GAS.
FORM: AEROSOL.
COLOR: CLEAR COLORLESS OR NEARLY COLORLESS.
ODOR: MILD.
ODOR THRESHOLD: NOT ESTABLISHED
PH: NOT AVAILABLE.
MELTING POINT/FREEZING POINT: -198.4 DEG. F (-128 DEG. C) ESTIMATED
INITIAL BOILING POINT AND BOILING RANGE:
140.9 DEG. F (60.5 DEG. C) DISPENSED LIQUID
FLASH POINT: <1.4 DEG. F (<-17.0 DEG. C) TAG CLOSED CUP DISPENSED LIQUID
EVAPORATION RATE: <1 BUAC (ETHYL ETHER= 1)
FLAMMABILITY (SOLID, GAS): FLAMMABLE GAS.
UPPER/LOWER FLAMMABILITY OR EXPLOSIVE LIMITS:
FLAMMABILITY LIMIT - LOWER (%): 0.6%
FLAMMABILITY LIMIT - UPPER (%): 7%
EXPLOSIVE LIMIT - LOWER (%): NOT AVAILABLE.
EXPLOSIVE LIMIT - UPPER (%): NOT AVAILABLE.
VAPOR PRESSURE: 352.53 MMHg @ 38 DEG. C
VAPOR DENSITY: >1 (AIR = 1)
RELATIVE DENSITY: NOT AVAILABLE.
SOLUBILITY(IES):
SOLUBILITY (WATER): <10 % BY WEIGHT
PARTITION COEFFICIENT (N-OCTANOL/WATER): NOT ESTABLISHED
AUTO-IGNITION TEMPERATURE: 582.8 DEG. F (306 DEG. C)
DECOMPOSITION TEMPERATURE: NOT ESTABLISHED
VISCOSITY: <3 CST @ 25 DEG. C
OTHER INFORMATION:
EXPLOSIVE PROPERTIES: NOT EXPLOSIVE.
HEAT OF COMBUSTION: >30 KJ/G
OXIDIZING PROPERTIES: NOT OXIDIZING.
PERCENT VOLATILE: 100%
SPECIFIC GRAVITY: 0.8 - 0.82 @ 20 DEG. C
VOC:
74% PER STATE & FEDERAL CONSUMER PRODUCT REGULATIONS; 600 G/L PER SCAQMD
RULE 102
| 10. STABILITY AND REACTIVITY | |
REACTIVITY:
THE PRODUCT IS STABLE AND NON-REACTIVE UNDER NORMAL CONDITIONS OF USE,
STORAGE AND TRANSPORT.
CHEMICAL STABILITY: MATERIAL IS STABLE UNDER NORMAL CONDITIONS.
POSSIBILITY OF HAZARDOUS REACTIONS:
HAZARDOUS POLYMERIZATION DOES NOT OCCUR.
CONDITIONS TO AVOID:
HEAT. AVOID TEMPERATURES EXCEEDING THE FLASH POINT. CONTACT WITH
INCOMPATIBLE MATERIALS.
INCOMPATIBLE MATERIALS:
ACIDS. STRONG OXIDIZING AGENTS. ISOCYANATES. CHLORINE.
HAZARDOUS DECOMPOSITION PRODUCTS: CARBON OXIDES.
| 11. TOXICOLOGICAL INFORMATION | |
INFORMATION ON LIKELY ROUTES OF EXPOSURE:
INHALATION:
MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE BY
INHALATION. MAY CAUSE DROWSINESS AND DIZZINESS. HEADACHE. NAUSEA, VOMITING.
SKIN CONTACT: CAUSES SKIN IRRITATION.
EYE CONTACT: DIRECT CONTACT WITH EYES MAY CAUSE TEMPORARY IRRITATION.
INGESTION: EXPECTED TO BE A LOW INGESTION HAZARD.
SYMPTOMS RELATED TO THE PHYSICAL, CHEMICAL AND TOXICOLOGICAL
CHARACTERISTICS:
MAY CAUSE DROWSINESS AND DIZZINESS. NARCOSIS. HEADACHE. NAUSEA, VOMITING.
BEHAVIORAL CHANGES. DECREASE IN MOTOR FUNCTIONS. SKIN IRRITATION. MAY
CAUSE REDNESS AND PAIN.
INFORMATION ON TOXICOLOGICAL EFFECTS:
ACUTE TOXICITY: NARCOTIC EFFECTS.
COMPONENTS SPECIES TEST RESULTS
ISOPROPANOL (CAS 67-63-0):
ACUTE:
ORAL:
LD50 RAT 4.7 G/KG
N-HEXANE (CAS 110-54-3):
ACUTE:
DERMAL:
LD50 RABBIT >2000 MG/KG, 4 HOURS
PENTANE (CAS 109-66-0):
ACUTE:
ORAL:
LD50 RAT >2000 MG/KG
SKIN CORROSION/IRRITATION: CAUSES SKIN IRRITATION.
SERIOUS EYE DAMAGE/EYE IRRITATION:
DIRECT CONTACT WITH EYES MAY CAUSE TEMPORARY IRRITATION.
RESPIRATORY OR SKIN SENSITIZATION:
RESPIRATORY SENSITIZATION: NOT A RESPIRATORY SENSITIZER.
SKIN SENSITIZATION:
THIS PRODUCT IS NOT EXPECTED TO CAUSE SKIN SENSITIZATION.
GERM CELL MUTAGENICITY:
NO DATA AVAILABLE TO INDICATE PRODUCT OR ANY COMPONENTS PRESENT AT GREATER
THAN 0.1% ARE MUTAGENIC OR GENOTOXIC.
CARCINOGENICITY:
THIS PRODUCT IS NOT CONSIDERED TO BE A CARCINOGEN BY IARC, ACGIH, NTP, OR
OSHA.
ACGIH CARCINOGENS:
ISOPROPANOL (CAS 67-63-0): A4 NOT CLASSIFIABLE AS A HUMAN CARCINOGEN.
IARC MONOGRAPHS. OVERALL EVALUATION OF CARCINOGENICITY: NOT LISTED.
OSHA SPECIFICALLY REGULATED SUBSTANCES (29 CFR 1910.1001-1052):
NOT REGULATED.
US. NATIONAL TOXICOLOGY PROGRAM (NTP) REPORT ON CARCINOGENS: NOT LISTED.
REPRODUCTIVE TOXICITY: SUSPECTED OF DAMAGING FERTILITY OR THE UNBORN CHILD.
SPECIFIC TARGET ORGAN TOXICITY - SINGLE EXPOSURE:
MAY CAUSE DROWSINESS AND DIZZINESS.
SPECIFIC TARGET ORGAN TOXICITY - REPEATED EXPOSURE:
MAY CAUSE DAMAGE TO ORGANS (NERVOUS SYSTEM) THROUGH PROLONGED OR REPEATED
EXPOSURE BY INHALATION.
ASPIRATION HAZARD: NOT LIKELY, DUE TO THE FORM OF THE PRODUCT.
CHRONIC EFFECTS:
MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE.
PROLONGED INHALATION MAY BE HARMFUL.
FURTHER INFORMATION: SYMPTOMS MAY BE DELAYED.
| 12. ECOLOGICAL INFORMATION | |
ECOTOXICITY:
THE PRODUCT IS NOT CLASSIFIED AS ENVIRONMENTALLY HAZARDOUS. HOWEVER, THIS
DOES NOT EXCLUDE THE POSSIBILITY THAT LARGE OR FREQUENT SPILLS CAN HAVE A
HARMFUL OR DAMAGING EFFECT ON THE ENVIRONMENT.
COMPONENTS SPECIES TEST RESULTS
ISOPROPANOL (CAS 67-63-0):
AQUATIC:
FISH LC50 BLUEGILL >1400 MG/L, 96 HOURS
(LEPOMIS MACROCHIRUS)
N-HEXANE (CAS 110-54-3):
AQUATIC:
FISH LC50 FATHEAD MINNOW 2.101 - 2.981 MG/L,
(PIMEPHALES PROMELAS) 96 HOURS
PERSISTENCE AND DEGRADABILITY:
NO DATA IS AVAILABLE ON THE DEGRADABILITY OF THIS PRODUCT.
BIOACCUMULATIVE POTENTIAL:
PARTITION COEFFICIENT N-OCTANOL / WATER (LOG KOW):
2-METHYLPENTANE: 3.74
ETHANE, 1,1,1,2-TETRAFLUORO-(HFC-134A): 1.06
ISOPROPANOL: 0.05
N-HEXANE: 3.9
PENTANE: 3.39
MOBILITY IN SOIL: NO DATA AVAILABLE.
OTHER ADVERSE EFFECTS:
THE PRODUCT CONTAINS VOLATILE ORGANIC COMPOUNDS WHICH HAVE A PHOTOCHEMICAL
OZONE CREATION POTENTIAL.
| 13. DISPOSAL CONSIDERATIONS | |
DISPOSAL INSTRUCTIONS:
COLLECT AND RECLAIM OR DISPOSE IN SEALED CONTAINERS AT LICENSED WASTE
DISPOSAL SITE. CONTENTS UNDER PRESSURE. DO NOT PUNCTURE, INCINERATE OR
CRUSH. DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH
LOCAL/REGIONAL/NATIONAL/INTERNATIONAL REGULATIONS.
LOCAL DISPOSAL REGULATIONS:
DISPOSE IN ACCORDANCE WITH ALL APPLICABLE REGULATIONS.
HAZARDOUS WASTE CODE:
THE WASTE CODE SHOULD BE ASSIGNED IN DISCUSSION BETWEEN THE USER, THE
PRODUCER AND THE WASTE DISPOSAL COMPANY.
D001: WASTE FLAMMABLE MATERIAL WITH A FLASH POINT <140 F
D003: WASTE REACTIVE MATERIAL
WASTE FROM RESIDUES / UNUSED PRODUCTS:
DISPOSE OF IN ACCORDANCE WITH LOCAL REGULATIONS. EMPTY CONTAINERS OR LINERS
MAY RETAIN SOME PRODUCT RESIDUES. THIS MATERIAL AND ITS CONTAINER MUST BE
DISPOSED OF IN A SAFE MANNER (SEE: DISPOSAL INSTRUCTIONS).
CONTAMINATED PACKAGING:
SINCE EMPTIED CONTAINERS MAY RETAIN PRODUCT RESIDUE, FOLLOW LABEL WARNINGS
EVEN AFTER CONTAINER IS EMPTIED. EMPTY CONTAINERS SHOULD BE TAKEN TO AN
APPROVED WASTE HANDLING SITE FOR RECYCLING OR DISPOSAL. DO NOT RE-USE EMPTY
CONTAINERS.
| 14. TRANSPORT INFORMATION | |
DOT:
UN NUMBER: UN1950
UN PROPER SHIPPING NAME: AEROSOLS, FLAMMABLE
TRANSPORT HAZARD CLASS(ES):
CLASS: 2.1
SUBSIDIARY RISK:
LABEL(S): 2.1
PACKING GROUP: NOT AVAILABLE.
ENVIRONMENTAL HAZARDS:
MARINE POLLUTANT: NO
SPECIAL PRECAUTIONS FOR USER: NOT AVAILABLE.
PACKAGING EXCEPTIONS: 306
PACKAGING NON BULK: NONE
PACKAGING BULK: NONE
IATA:
UN NUMBER: UN1950
UN PROPER SHIPPING NAME: AEROSOLS, FLAMMABLE
TRANSPORT HAZARD CLASS(ES):
CLASS: 2.1
SUBSIDIARY RISK:
PACKING GROUP: NOT AVAILABLE.
ENVIRONMENTAL HAZARDS: NO.
ERG CODE: 2X
SPECIAL PRECAUTIONS FOR USER: NOT AVAILABLE.
OTHER INFORMATION:
PASSENGER AND CARGO AIRCRAFT: ALLOWED WITH RESTRICTIONS.
CARGO AIRCRAFT ONLY: ALLOWED WITH RESTRICTIONS.
IMDG:
UN NUMBER: UN1950
UN PROPER SHIPPING NAME: AEROSOLS, FLAMMABLE (HEXANES), MARINE POLLUTANT
TRANSPORT HAZARD CLASS(ES):
CLASS: 2.1
SUBSIDIARY RISK:
LABEL(S): 2.1
PACKING GROUP: NOT AVAILABLE.
ENVIRONMENTAL HAZARDS:
MARINE POLLUTANT: YES
EMS: F-D, S-U
SPECIAL PRECAUTIONS FOR USER: NOT AVAILABLE.
TRANSPORT IN BULK ACCORDING TO ANNEX II OF MARPOL 73/78 AND THE IBC CODE:
NOT APPLICABLE.
DOT: FLAMMABLE GAS, CLASS/DIVISION 2.1
IATA; IMDG: CLASS 2.1, FLAMMABLE GASES
MARINE POLLUTANT: ENVIRONMENT
GENERAL INFORMATION:
IMDG REGULATED MARINE POLLUTANT. AVOID TRANSPORT ON VEHICLES WHERE THE
LOAD SPACE IS NOT SEPARATED FROM THE DRIVER'S COMPARTMENT. ENSURE VEHICLE
DRIVER IS AWARE OF THE POTENTIAL HAZARDS OF THE LOAD AND KNOWS WHAT TO DO
IN THE EVENT OF AN ACCIDENT OR AN EMERGENCY. BEFORE TRANSPORTING PRODUCT
CONTAINERS: ENSURE THAT CONTAINERS ARE FIRMLY SECURED. ENSURE CYLINDER
VALVE IS CLOSED AND NOT LEAKING. ENSURE VALVE OUTLET CAP NUT OR PLUG
(WHERE PROVIDED) IS CORRECTLY FITTED. ENSURE VALVE PROTECTION DEVICE
(WHERE PROVIDED) IS CORRECTLY FITTED. ENSURE ADEQUATE VENTILATION. ENSURE
COMPLIANCE WITH APPLICABLE REGULATIONS.
| 15. REGULATORY INFORMATION | |
US FEDERAL REGULATIONS:
THIS PRODUCT IS A "HAZARDOUS CHEMICAL" AS DEFINED BY THE OSHA HAZARD
COMMUNICATION STANDARD, 29 CFR 1910.1200.
TSCA SECTION 12(B) EXPORT NOTIFICATION (40 CFR 707, SUBPT. D):
NOT REGULATED.
CERCLA HAZARDOUS SUBSTANCE LIST (40 CFR 302.4):
N-HEXANE (CAS 110-54-3): LISTED.
SARA 304 EMERGENCY RELEASE NOTIFICATION: NOT REGULATED.
OSHA SPECIFICALLY REGULATED SUBSTANCES (29 CFR 1910.1001-1052):
NOT REGULATED.
SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 (SARA):
SARA 302 EXTREMELY HAZARDOUS SUBSTANCE: NOT LISTED.
SARA 311/312 HAZARDOUS CHEMICAL: YES
SARA 313 (TRI REPORTING): NOT REGULATED.
OTHER FEDERAL REGULATIONS:
CLEAN AIR ACT (CAA) SECTION 112 HAZARDOUS AIR POLLUTANTS (HAPS) LIST:
N-HEXANE (CAS 110-54-3)
CLEAN AIR ACT (CAA) SECTION 112(R) ACCIDENTAL RELEASE PREVENTION
(40 CFR 68.130): PENTANE (CAS 109-66-0)
SAFE DRINKING WATER ACT (SDWA): NOT REGULATED.
FEMA PRIORITY SUBSTANCES RESPIRATORY HEALTH AND SAFETY IN THE FLAVOR
MANUFACTURING WORKPLACE:
ISOPROPANOL (CAS 67-63-0): LOW PRIORITY
US STATE REGULATIONS:
CALIFORNIA SAFE DRINKING WATER AND TOXIC ENFORCEMENT ACT OF 1986
(PROPOSITION 65):
THIS MATERIAL IS NOT KNOWN TO CONTAIN ANY CHEMICALS CURRENTLY LISTED AS
CARCINOGENS OR REPRODUCTIVE TOXINS.
US. NEW JERSEY WORKER AND COMMUNITY RIGHT-TO-KNOW ACT:
2-METHYLPENTANE (CAS 107-83-5)
ISOPROPANOL (CAS 67-63-0)
N-HEXANE (CAS 110-54-3)
PENTANE (CAS 109-66-0)
CALIFORNIA PROPOSITION 65:
US. CALIFORNIA. CANDIDATE CHEMICALS LIST. SAFER CONSUMER PRODUCTS
REGULATIONS (CAL. CODE REGS, TIT. 22, 69502.3, SUBD. (A)):
ISOPROPANOL (CAS 67-63-0)
N-HEXANE (CAS 110-54-3)
INTERNATIONAL INVENTORIES:
COUNTRY(S) OR REGION INVENTORY NAME ON INVENTORY
(YES/NO)*
AUSTRALIA AUSTRALIAN INVENTORY OF CHEMICAL YES
SUBSTANCES (AICS)
CANADA DOMESTIC SUBSTANCES LIST (DSL) YES
CANADA NON-DOMESTIC SUBSTANCES LIST (NDSL) NO
CHINA INVENTORY OF EXISTING CHEMICAL YES
SUBSTANCES IN CHINA (IECSC)
EUROPE EUROPEAN INVENTORY OF EXISTING YES
COMMERCIAL CHEMICAL SUBSTANCES
(EINECS)
EUROPE EUROPEAN LIST OF NOTIFIED CHEMICAL NO
SUBSTANCES (ELINCS)
JAPAN INVENTORY OF EXISTING AND NEW YES
CHEMICAL SUBSTANCES (ENCS)
KOREA EXISTING CHEMICALS LIST (ECL) YES
NEW ZEALAND NEW ZEALAND INVENTORY YES
PHILIPPINES PHILIPPINE INVENTORY OF CHEMICALS YES
AND CHEMICAL SUBSTANCES (PICCS)
TAIWAN TAIWAN TOXIC CHEMICAL SUBSTANCES YES
(TCS)
UNITED STATES & TOXIC SUBSTANCES CONTROL ACT (TSCA) YES
PUERTO RICO INVENTORY
*A "YES" INDICATES THAT ALL COMPONENTS OF THIS PRODUCT COMPLY WITH
THE INVENTORY REQUIREMENTS ADMINISTERED BY THE GOVERNING COUNTRY(S)
A "NO" INDICATES THAT ONE OR MORE COMPONENTS OF THE PRODUCT ARE NOT
LISTED OR EXEMPT FROM LISTING ON THE INVENTORY ADMINISTERED BY THE
GOVERNING COUNTRY(S).
| 16. OTHER INFORMATION, INCLUDING DATE OF PREPARATION | |
OR LAST REVISION
ISSUE DATE: 02-13-2018
VERSION #: 01
DISCLAIMER:
ITW PRO BRANDS CANNOT ANTICIPATE ALL CONDITIONS UNDER WHICH THIS
INFORMATION AND ITS PRODUCT, OR THE PRODUCTS OF OTHER MANUFACTURERS IN
COMBINATION WITH ITS PRODUCT, MAY BE USED. IT IS THE USER'S RESPONSIBILITY
TO ENSURE SAFE CONDITIONS FOR HANDLING, STORAGE AND DISPOSAL OF THE
PRODUCT, AND TO ASSUME LIABILITY FOR LOSS, INJURY, DAMAGE OR EXPENSE DUE
TO IMPROPER USE. THE INFORMATION PROVIDED IN THIS SAFETY DATA SHEET IS
CORRECT TO THE BEST OF OUR KNOWLEDGE, INFORMATION AND BELIEF AT THE DATE
OF ITS PUBLICATION. THE INFORMATION GIVEN IS DESIGNED ONLY AS A GUIDANCE
FOR SAFE HANDLING, USE, PROCESSING, STORAGE, TRANSPORTATION, DISPOSAL AND
RELEASE AND IS NOT TO BE CONSIDERED A WARRANTY OR QUALITY SPECIFICATION.
THE INFORMATION RELATES ONLY TO THE SPECIFIC MATERIAL DESIGNATED AND MAY
NOT BE VALID FOR SUCH MATERIAL USED IN COMBINATION WITH ANY OTHER
MATERIALS OR IN ANY PROCESS, UNLESS SPECIFIED IN THE TEXT.
REVISION INFORMATION:
COMPOSITION / INFORMATION ON INGREDIENTS: DISCLOSURE OVERRIDES
MATERIAL NAME: LPS(R*) MICRO-X NU
SDS US