| Common Name: | CABLE CLEAN HIGH VOLTAGE SPLICE CLEANER NO. 02069 (ITEM 1003195) |
| Manufacturer: | CRC INDUSTRIES |
| SDS Revision Date: | 10/10/2017 |
| SDS Format: | GHS-US |
| Item Number(s): | 4YPJ4 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
CRC(R*)
SAFETY DATA SHEET
| 1. IDENTIFICATION |  |
PRODUCT IDENTIFIER: CABLE CLEAN(R*) HIGH VOLTAGE SPLICE CLEANER
OTHER MEANS OF IDENTIFICATION:
PRODUCT CODE: NO. 02069 (ITEM# 1003195)
RECOMMENDED USE: SPLICE AND TERMINATION CLEANER
RECOMMENDED RESTRICTIONS: NONE KNOWN.
MANUFACTURER/IMPORTER/SUPPLIER/DISTRIBUTOR INFORMATION:
MANUFACTURED OR SOLD BY:
COMPANY NAME: CRC INDUSTRIES, INC.
ADDRESS:
885 LOUIS DR.
WARMINSTER, PA 18974
US
TELEPHONE:
GENERAL INFORMATION: 215-674-4300
TECHNICAL ASSISTANCE: 800-521-3168
CUSTOMER SERVICE: 800-272-4620
24-HOUR EMERGENCY (CHEMTREC):
800-424-9300 (US)
703-527-3887 (INTERNATIONAL)
WEBSITE: WWW.CRCINDUSTRIES.COM
| 2. HAZARD(S) IDENTIFICATION | |
PHYSICAL HAZARDS:
FLAMMABLE AEROSOLS: CATEGORY 2
GASES UNDER PRESSURE: COMPRESSED GAS
HEALTH HAZARDS:
ACUTE TOXICITY, ORAL: CATEGORY 4
SKIN CORROSION/IRRITATION: CATEGORY 2
SERIOUS EYE DAMAGE/EYE IRRITATION: CATEGORY 2
SPECIFIC TARGET ORGAN TOXICITY, SINGLE EXPOSURE:
CATEGORY 3 NARCOTIC EFFECTS
ASPIRATION HAZARD: CATEGORY 1
ENVIRONMENTAL HAZARDS: NOT CLASSIFIED.
OSHA DEFINED HAZARDS: NOT CLASSIFIED.
LABEL ELEMENTS:
FLAME
GAS CYLINDER
HEALTH HAZARD
EXCLAMATION MARK
SIGNAL WORD: DANGER
HAZARD STATEMENT:
FLAMMABLE AEROSOL. CONTAINS GAS UNDER PRESSURE; MAY EXPLODE IF HEATED.
HARMFUL IF SWALLOWED. MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS. CAUSES
SKIN IRRITATION. CAUSES SERIOUS EYE IRRITATION. MAY CAUSE DROWSINESS OR
DIZZINESS.
PRECAUTIONARY STATEMENT:
PREVENTION:
KEEP AWAY FROM HEAT/SPARKS/OPEN FLAMES/HOT SURFACES. - NO SMOKING. DO NOT
SPRAY ON AN OPEN FLAME OR OTHER IGNITION SOURCE.
PRESSURIZED CONTAINER:
DO NOT PIERCE OR BURN, EVEN AFTER USE. USE WITH ADEQUATE VENTILATION.
OPEN DOORS AND WINDOWS OR USE OTHER MEANS TO ENSURE A FRESH AIR SUPPLY
DURING USE AND WHILE PRODUCT IS DRYING. IF YOU EXPERIENCE ANY SYMPTOMS
LISTED ON THIS LABEL, INCREASE VENTILATION OR LEAVE THE AREA. AVOID
BREATHING MIST OR VAPOR. WASH THOROUGHLY AFTER HANDLING. DO NOT EAT,
DRINK OR SMOKE WHEN USING THIS PRODUCT. WEAR EYE PROTECTION/FACE
PROTECTION. WEAR PROTECTIVE GLOVES.
RESPONSE:
IF SWALLOWED:
IMMEDIATELY CALL A POISON CENTER/DOCTOR. DO NOT INDUCE VOMITING.
RINSE MOUTH.
IF ON SKIN: WASH WITH PLENTY OF WATER.
IF SKIN IRRITATION OCCURS:
GET MEDICAL ADVICE/ATTENTION. TAKE OFF CONTAMINATED CLOTHING AND WASH
BEFORE REUSE.
IF INHALED:
REMOVE PERSON TO FRESH AIR AND KEEP COMFORTABLE FOR BREATHING. CALL A
POISON CENTER/DOCTOR IF YOU FEEL UNWELL.
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES,
IF PRESENT AND EASY TO DO. CONTINUE RINSING.
IF EYE IRRITATION PERSISTS: GET MEDICAL ADVICE/ATTENTION.
STORAGE:
STORE IN A WELL-VENTILATED PLACE. STORE LOCKED UP. PROTECT FROM SUNLIGHT.
DO NOT EXPOSE TO TEMPERATURES EXCEEDING 50 DEG. C/122 DEG. F. EXPOSURE TO
HIGH TEMPERATURE MAY CAUSE CAN TO BURST.
DISPOSAL:
DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH LOCAL/REGIONAL/NATIONAL
REGULATIONS.
HAZARD(S) NOT OTHERWISE CLASSIFIED (HNOC): NONE KNOWN.
SUPPLEMENTAL INFORMATION:
WHEN EXPOSED TO EXTREME HEAT OR HOT SURFACES, VAPORS MAY DECOMPOSE TO
HARMFUL OR FATAL CORROSIVE GASES SUCH AS HYDROGEN FLUORIDE, HYDROGEN
CHLORIDE AND POSSIBLY PHOSGENE.
| 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
MIXTURES:
CHEMICAL NAME COMMON NAME AND SYNONYMS CAS NUMBER %
TRANS-1,2-DICHLOROETHYLENE 156-60-5 80 - 90
DECAFLUOROPENTANE HFC 43-10MEE 138495-42-8 10 - 20
CARBON DIOXIDE 124-38-9 3 - 5
ISOPROPYL ALCOHOL 67-63-0 1 - 3
SPECIFIC CHEMICAL IDENTITY AND/OR PERCENTAGE OF COMPOSITION HAS BEEN
WITHHELD AS A TRADE SECRET.
| 4. FIRST-AID MEASURES | |
INHALATION:
REMOVE VICTIM TO FRESH AIR AND KEEP AT REST IN A POSITION COMFORTABLE FOR
BREATHING. CALL A POISON CENTER OR DOCTOR/PHYSICIAN IF YOU FEEL UNWELL.
SKIN CONTACT:
REMOVE CONTAMINATED CLOTHING. WASH WITH PLENTY OF SOAP AND WATER.
IF SKIN IRRITATION OCCURS:
GET MEDICAL ADVICE/ATTENTION. WASH CONTAMINATED CLOTHING BEFORE REUSE.
EYE CONTACT:
IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES.
REMOVE CONTACT LENSES, IF PRESENT AND EASY TO DO. CONTINUE RINSING.
IF EYE IRRITATION PERSISTS: GET MEDICAL ADVICE/ATTENTION.
INGESTION:
CALL A PHYSICIAN OR POISON CONTROL CENTER IMMEDIATELY. RINSE MOUTH. DO NOT
INDUCE VOMITING. IF VOMITING OCCURS, KEEP HEAD LOW SO THAT STOMACH CONTENT
DOESN'T GET INTO THE LUNGS.
MOST IMPORTANT SYMPTOMS/EFFECTS, ACUTE AND DELAYED:
ASPIRATION MAY CAUSE PULMONARY EDEMA AND PNEUMONITIS. MAY CAUSE DROWSINESS
AND DIZZINESS. HEADACHE. NAUSEA, VOMITING. SEVERE EYE IRRITATION. SYMPTOMS
MAY INCLUDE STINGING, TEARING, REDNESS, SWELLING, AND BLURRED VISION. SKIN
IRRITATION. MAY CAUSE REDNESS AND PAIN.
INDICATION OF IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED:
PROVIDE GENERAL SUPPORTIVE MEASURES AND TREAT SYMPTOMATICALLY. KEEP VICTIM
WARM. KEEP VICTIM UNDER OBSERVATION. SYMPTOMS MAY BE DELAYED.
GENERAL INFORMATION:
ENSURE THAT MEDICAL PERSONNEL ARE AWARE OF THE MATERIAL(S) INVOLVED, AND
TAKE PRECAUTIONS TO PROTECT THEMSELVES. SHOW THIS SAFETY DATA SHEET TO THE
DOCTOR IN ATTENDANCE.
| 5. FIRE-FIGHTING MEASURES | |
SUITABLE EXTINGUISHING MEDIA:
WATER FOG. FOAM. DRY CHEMICAL POWDER. CARBON DIOXIDE (CO2).
UNSUITABLE EXTINGUISHING MEDIA:
DO NOT USE WATER JET AS AN EXTINGUISHER, AS THIS WILL SPREAD THE FIRE.
SPECIFIC HAZARDS ARISING FROM THE CHEMICAL:
CONTENTS UNDER PRESSURE. PRESSURIZED CONTAINER MAY RUPTURE WHEN EXPOSED TO
HEAT OR FLAME. DURING FIRE, GASES HAZARDOUS TO HEALTH MAY BE FORMED. WHEN
EXPOSED TO EXTREME HEAT OR HOT SURFACES, VAPORS MAY DECOMPOSE TO HARMFUL
OR FATAL CORROSIVE GASES SUCH AS HYDROGEN FLUORIDE, HYDROGEN CHLORIDE AND
POSSIBLY PHOSGENE.
SPECIAL PROTECTIVE EQUIPMENT AND PRECAUTIONS FOR FIREFIGHTERS:
FIREFIGHTERS MUST USE STANDARD PROTECTIVE EQUIPMENT INCLUDING FLAME
RETARDANT COAT, HELMET WITH FACE SHIELD, GLOVES, RUBBER BOOTS, AND IN
ENCLOSED SPACES, SCBA.
FIRE-FIGHTING EQUIPMENT/INSTRUCTIONS:
IN CASE OF FIRE:
STOP LEAK IF SAFE TO DO SO. MOVE CONTAINERS FROM FIRE AREA IF YOU CAN DO
SO WITHOUT RISK. CONTAINERS SHOULD BE COOLED WITH WATER TO PREVENT VAPOR
PRESSURE BUILD UP.
GENERAL FIRE HAZARDS:
FLAMMABLE AEROSOL. CONTENTS UNDER PRESSURE. PRESSURIZED CONTAINER MAY
RUPTURE WHEN EXPOSED TO HEAT OR FLAME.
| 6. ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
KEEP UNNECESSARY PERSONNEL AWAY. KEEP PEOPLE AWAY FROM AND UPWIND OF
SPILL/LEAK. KEEP OUT OF LOW AREAS. MANY GASES ARE HEAVIER THAN AIR AND
WILL SPREAD ALONG GROUND AND COLLECT IN LOW OR CONFINED AREAS (SEWERS,
BASEMENTS, TANKS). WEAR APPROPRIATE PROTECTIVE EQUIPMENT AND CLOTHING
DURING CLEAN-UP. AVOID BREATHING MIST OR VAPOR. EMERGENCY PERSONNEL NEED
SELF-CONTAINED BREATHING EQUIPMENT. DO NOT TOUCH DAMAGED CONTAINERS OR
SPILLED MATERIAL UNLESS WEARING APPROPRIATE PROTECTIVE CLOTHING. VENTILATE
CLOSED SPACES BEFORE ENTERING THEM. LOCAL AUTHORITIES SHOULD BE ADVISED IF
SIGNIFICANT SPILLAGES CANNOT BE CONTAINED. FOR PERSONAL PROTECTION, SEE
SECTION 8 OF THE SDS.
METHODS AND MATERIALS FOR CONTAINMENT AND CLEANING UP:
ELIMINATE ALL IGNITION SOURCES (NO SMOKING, FLARES, SPARKS, OR FLAMES IN
IMMEDIATE AREA). KEEP COMBUSTIBLES (WOOD, PAPER, OIL, ETC.) AWAY FROM
SPILLED MATERIAL. COLLECT SPILLAGE. THIS PRODUCT IS MISCIBLE IN WATER.
PREVENT ENTRY INTO WATERWAYS, SEWER, BASEMENTS OR CONFINED AREAS. STOP
THE FLOW OF MATERIAL, IF THIS IS WITHOUT RISK. WIPE UP WITH ABSORBENT
MATERIAL (E.G. CLOTH, FLEECE). CLEAN SURFACE THOROUGHLY TO REMOVE RESIDUAL
CONTAMINATION. FOR WASTE DISPOSAL, SEE SECTION 13 OF THE SDS.
ENVIRONMENTAL PRECAUTIONS:
AVOID RELEASE TO THE ENVIRONMENT. CONTACT LOCAL AUTHORITIES IN CASE OF
SPILLAGE TO DRAIN/AQUATIC ENVIRONMENT. PREVENT FURTHER LEAKAGE OR SPILLAGE
IF SAFE TO DO SO. DO NOT CONTAMINATE WATER. AVOID DISCHARGE INTO DRAINS,
WATER COURSES OR ONTO THE GROUND.
| 7. HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING:
PRESSURIZED CONTAINER:
DO NOT PIERCE OR BURN, EVEN AFTER USE. DO NOT USE IF SPRAY BUTTON IS
MISSING OR DEFECTIVE. DO NOT SPRAY ON A NAKED FLAME OR ANY OTHER
INCANDESCENT MATERIAL. DO NOT SMOKE WHILE USING OR UNTIL SPRAYED SURFACE
IS THOROUGHLY DRY. DO NOT CUT, WELD, SOLDER, DRILL, GRIND, OR EXPOSE
CONTAINERS TO HEAT, FLAME, SPARKS, OR OTHER SOURCES OF IGNITION. USE
CAUTION AROUND ENERGIZED EQUIPMENT. THE METAL CONTAINER WILL CONDUCT
ELECTRICITY IF IT CONTACTS A LIVE SOURCE. THIS MAY RESULT IN INJURY TO
THE USER FROM ELECTRICAL SHOCK AND/OR FLASH FIRE. DO NOT TASTE OR SWALLOW.
AVOID BREATHING MIST OR VAPOR. AVOID CONTACT WITH EYES, SKIN, AND CLOTHING.
AVOID PROLONGED EXPOSURE. WHEN USING, DO NOT EAT, DRINK OR SMOKE. USE ONLY
IN WELL-VENTILATED AREAS. WEAR APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT.
WASH HANDS THOROUGHLY AFTER HANDLING. AVOID RELEASE TO THE ENVIRONMENT.
DO NOT EMPTY INTO DRAINS. OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES.
FOR PRODUCT USAGE INSTRUCTIONS, SEE THE PRODUCT LABEL.
CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES:
LEVEL 1 AEROSOL.
PRESSURIZED CONTAINER. PROTECT FROM SUNLIGHT AND DO NOT EXPOSE TO
TEMPERATURES EXCEEDING 50 DEG. C/122 DEG. F. DO NOT PUNCTURE, INCINERATE
OR CRUSH. DO NOT HANDLE OR STORE NEAR AN OPEN FLAME, HEAT OR OTHER SOURCES
OF IGNITION. THIS MATERIAL CAN ACCUMULATE STATIC CHARGE WHICH MAY CAUSE
SPARK AND BECOME AN IGNITION SOURCE. STORE IN A WELL-VENTILATED PLACE.
STORE AWAY FROM INCOMPATIBLE MATERIALS (SEE SECTION 10 OF THE SDS).
| 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
OCCUPATIONAL EXPOSURE LIMITS:
THE FOLLOWING CONSTITUENTS ARE THE ONLY CONSTITUENTS OF THE PRODUCT WHICH
HAVE A PEL, TLV OR OTHER RECOMMENDED EXPOSURE LIMIT. AT THIS TIME, THE
OTHER CONSTITUENTS HAVE NO KNOWN EXPOSURE LIMITS.
US. OSHA TABLE Z-1 LIMITS FOR AIR CONTAMINANTS (29 CFR 1910.1000):
COMPONENTS TYPE VALUE
CARBON DIOXIDE PEL 9000 MG/M3
(CAS 124-38-9) 5000 PPM
ISOPROPYL ALCOHOL PEL 980 MG/M3
(CAS 67-63-0) 400 PPM
TRANS-1,2-DICHLOROETHYLENE PEL 790 MG/M3
(CAS 156-60-5) 200 PPM
US. ACGIH THRESHOLD LIMIT VALUES:
COMPONENTS TYPE VALUE
CARBON DIOXIDE STEL 30000 PPM
(CAS 124-38-9) TWA 5000 PPM
ISOPROPYL ALCOHOL STEL 400 PPM
(CAS 67-63-0) TWA 200 PPM
TRANS-1,2-DICHLOROETHYLENE TWA 200 PPM
(CAS 156-60-5)
US. NIOSH: POCKET GUIDE TO CHEMICAL HAZARDS
COMPONENTS TYPE VALUE
CARBON DIOXIDE STEL 54000 MG/M3
(CAS 124-38-9) 30000 PPM
TWA 9000 MG/M3
5000 PPM
ISOPROPYL ALCOHOL STEL 1225 MG/M3
(CAS 67-63-0) 500 PPM
TWA 980 MG/M3
400 PPM
TRANS-1,2-DICHLOROETHYLENE TWA 790 MG/M3
(CAS 156-60-5) 200 PPM
BIOLOGICAL LIMIT VALUES:
ACGIH BIOLOGICAL EXPOSURE INDICES:
COMPONENTS VALUE DETERMINANT SPECIMEN SAMPLING TIME
ISOPROPYL ALCOHOL 40 MG/L ACETONE URINE *
(CAS 67-63-0)
* - FOR SAMPLING DETAILS, PLEASE SEE THE SOURCE DOCUMENT.
APPROPRIATE ENGINEERING CONTROLS:
GOOD GENERAL VENTILATION (TYPICALLY 10 AIR CHANGES PER HOUR) SHOULD BE
USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS. IF APPLICABLE,
USE PROCESS ENCLOSURES, LOCAL EXHAUST VENTILATION, OR OTHER ENGINEERING
CONTROLS TO MAINTAIN AIRBORNE LEVELS BELOW RECOMMENDED EXPOSURE LIMITS.
IF EXPOSURE LIMITS HAVE NOT BEEN ESTABLISHED, MAINTAIN AIRBORNE LEVELS TO
AN ACCEPTABLE LEVEL. PROVIDE EYEWASH STATION. EYE WASH FOUNTAIN AND
EMERGENCY SHOWERS ARE RECOMMENDED.
INDIVIDUAL PROTECTION MEASURES, SUCH AS PERSONAL PROTECTIVE EQUIPMENT:
EYE/FACE PROTECTION: WEAR SAFETY GLASSES WITH SIDE SHIELDS (OR GOGGLES).
SKIN PROTECTION:
HAND PROTECTION:
WEAR PROTECTIVE GLOVES SUCH AS:
NITRILE. POLYVINYL ALCOHOL (PVA). VITON/BUTYL.
OTHER: WEAR APPROPRIATE CHEMICAL RESISTANT CLOTHING.
RESPIRATORY PROTECTION:
IF ENGINEERING CONTROLS ARE NOT FEASIBLE OR IF EXPOSURE EXCEEDS THE
APPLICABLE EXPOSURE LIMITS, USE A NIOSH-APPROVED CARTRIDGE RESPIRATOR WITH
AN ORGANIC VAPOR CARTRIDGE. USE A SELF-CONTAINED BREATHING APPARATUS IN
CONFINED SPACES AND FOR EMERGENCIES. AIR MONITORING IS NEEDED TO DETERMINE
ACTUAL EMPLOYEE EXPOSURE LEVELS.
THERMAL HAZARDS:
WEAR APPROPRIATE THERMAL PROTECTIVE CLOTHING, WHEN NECESSARY.
GENERAL HYGIENE CONSIDERATIONS:
WHEN USING, DO NOT EAT, DRINK OR SMOKE. ALWAYS OBSERVE GOOD PERSONAL
HYGIENE MEASURES, SUCH AS WASHING AFTER HANDLING THE MATERIAL AND BEFORE
EATING, DRINKING, AND/OR SMOKING. ROUTINELY WASH WORK CLOTHING AND
PROTECTIVE EQUIPMENT TO REMOVE CONTAMINANTS.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE:
PHYSICAL STATE: LIQUID.
FORM: AEROSOL.
COLOR: COLORLESS.
ODOR: SLIGHT ETHEREAL.
ODOR THRESHOLD: NOT AVAILABLE.
PH: NOT AVAILABLE.
MELTING POINT/FREEZING POINT: -119.2 DEG. F (-84 DEG. C) ESTIMATED
INITIAL BOILING POINT AND BOILING RANGE:
119.7 DEG. F (48.7 DEG. C) ESTIMATED
FLASH POINT: NONE (TAG CLOSED CUP)
EVAPORATION RATE: FAST.
FLAMMABILITY (SOLID, GAS): NOT AVAILABLE.
UPPER/LOWER FLAMMABILITY OR EXPLOSIVE LIMITS:
FLAMMABILITY LIMIT - LOWER (%): 2 % ESTIMATED
FLAMMABILITY LIMIT - UPPER (%): 18 % ESTIMATED
VAPOR PRESSURE: 2682.3 HPA ESTIMATED
VAPOR DENSITY: NOT AVAILABLE.
RELATIVE DENSITY: 1.28 ESTIMATED
SOLUBILITY (WATER): NOT AVAILABLE.
PARTITION COEFFICIENT (N-OCTANOL/WATER): NOT AVAILABLE.
AUTO-IGNITION TEMPERATURE: 860 DEG. F (460 DEG. C) ESTIMATED
DECOMPOSITION TEMPERATURE: NOT AVAILABLE.
VISCOSITY (KINEMATIC): NOT AVAILABLE.
PERCENT VOLATILE: 96 % ESTIMATED
| 10. STABILITY AND REACTIVITY | |
REACTIVITY:
THE PRODUCT IS STABLE AND NON-REACTIVE UNDER NORMAL CONDITIONS OF USE,
STORAGE AND TRANSPORT.
CHEMICAL STABILITY: MATERIAL IS STABLE UNDER NORMAL CONDITIONS.
POSSIBILITY OF HAZARDOUS REACTIONS:
NO DANGEROUS REACTION KNOWN UNDER CONDITIONS OF NORMAL USE.
CONDITIONS TO AVOID:
HEAT, FLAMES AND SPARKS. CONTACT WITH INCOMPATIBLE MATERIALS. WHEN EXPOSED
TO EXTREME HEAT OR HOT SURFACES, VAPORS MAY DECOMPOSE TO HARMFUL OR FATAL
CORROSIVE GASES SUCH AS HYDROGEN FLUORIDE, HYDROGEN CHLORIDE AND POSSIBLY
PHOSGENE.
INCOMPATIBLE MATERIALS:
STRONG OXIDIZING AGENTS. STRONG ACIDS. STRONG BASES. ALKALI METALS.
ALKALINE EARTH METALS. POWDERED METAL.
HAZARDOUS DECOMPOSITION PRODUCTS:
CARBON OXIDES. HYDROGEN CHLORIDE. PHOSGENE. HYDROGEN FLUORIDE.
| 11. TOXICOLOGICAL INFORMATION | |
INFORMATION ON LIKELY ROUTES OF EXPOSURE:
INHALATION:
PROLONGED INHALATION MAY BE HARMFUL. MAY CAUSE DROWSINESS AND DIZZINESS.
HEADACHE. NAUSEA, VOMITING.
SKIN CONTACT: CAUSES SKIN IRRITATION.
EYE CONTACT: CAUSES SERIOUS EYE IRRITATION.
INGESTION:
MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS. HARMFUL IF SWALLOWED.
DROPLETS OF THE PRODUCT ASPIRATED INTO THE LUNGS THROUGH INGESTION OR
VOMITING MAY CAUSE A SERIOUS CHEMICAL PNEUMONIA.
SYMPTOMS RELATED TO THE PHYSICAL, CHEMICAL AND TOXICOLOGICAL
CHARACTERISTICS:
ASPIRATION MAY CAUSE PULMONARY EDEMA AND PNEUMONITIS. MAY CAUSE DROWSINESS
AND DIZZINESS. HEADACHE. NAUSEA, VOMITING. SEVERE EYE IRRITATION. SYMPTOMS
MAY INCLUDE STINGING, TEARING, REDNESS, SWELLING, AND BLURRED VISION. SKIN
IRRITATION. MAY CAUSE REDNESS AND PAIN.
INFORMATION ON TOXICOLOGICAL EFFECTS:
ACUTE TOXICITY:
IN HIGH CONCENTRATIONS, VAPORS ARE ANESTHETIC AND MAY CAUSE HEADACHE,
FATIGUE, DIZZINESS AND CENTRAL NERVOUS SYSTEM EFFECTS. MAY BE FATAL IF
SWALLOWED AND ENTERS AIRWAYS. NARCOTIC EFFECTS.
PRODUCT SPECIES TEST RESULTS
CABLE CLEAN(R*) HIGH VOLTAGE SPLICE CLEANER:
ACUTE:
DERMAL:
LD50 RABBIT 5033.2 MG/KG CALCULATED
INHALATION:
LC50 RAT 96.6 MG/L,
4 HOURS CALCULATED
ORAL:
LD50 RAT 1465.7 MG/KG CALCULATED
COMPONENTS SPECIES TEST RESULTS
DECAFLUOROPENTANE (CAS 138495-42-8):
ACUTE:
DERMAL:
LD50 RABBIT >5000 MG/KG
INHALATION:
LC50 RAT 11058 MG/KG,
4 HOURS CALCULATED
ORAL:
LD50 RAT >5000 MG/KG
ISOPROPYL ALCOHOL (CAS 67-63-0):
ACUTE:
DERMAL:
LD50 RABBIT 13900 MG/KG
INHALATION:
LC50 RAT 16000 PPM, 4 HOURS
ORAL:
LD50 RAT 4700 MG/KG
TRANS-1,2-DICHLOROETHYLENE (CAS 156-60-5):
ACUTE:
ORAL:
LD50 RAT 1235 MG/KG
* ESTIMATES FOR PRODUCT MAY BE BASED ON ADDITIONAL COMPONENT DATA
NOT SHOWN.
SKIN CORROSION/IRRITATION: CAUSES SKIN IRRITATION.
SERIOUS EYE DAMAGE/EYE IRRITATION: CAUSES SERIOUS EYE IRRITATION.
RESPIRATORY SENSITIZATION: NOT A RESPIRATORY SENSITIZER.
SKIN SENSITIZATION:
THIS PRODUCT IS NOT EXPECTED TO CAUSE SKIN SENSITIZATION.
GERM CELL MUTAGENICITY:
NO DATA AVAILABLE TO INDICATE PRODUCT OR ANY COMPONENTS PRESENT AT GREATER
THAN 0.1% ARE MUTAGENIC OR GENOTOXIC.
CARCINOGENICITY:
THIS PRODUCT IS NOT CONSIDERED TO BE A CARCINOGEN BY IARC, ACGIH, NTP, OR
OSHA.
IARC MONOGRAPHS. OVERALL EVALUATION OF CARCINOGENICITY: NOT LISTED.
OSHA SPECIFICALLY REGULATED SUBSTANCES (29 CFR 1910.1001-1050):
NOT REGULATED.
US. NATIONAL TOXICOLOGY PROGRAM (NTP) REPORT ON CARCINOGENS: NOT LISTED.
REPRODUCTIVE TOXICITY:
THIS PRODUCT IS NOT EXPECTED TO CAUSE REPRODUCTIVE OR DEVELOPMENTAL
EFFECTS.
SPECIFIC TARGET ORGAN TOXICITY - SINGLE EXPOSURE:
MAY CAUSE DROWSINESS AND DIZZINESS.
SPECIFIC TARGET ORGAN TOXICITY - REPEATED EXPOSURE: NOT CLASSIFIED.
ASPIRATION HAZARD:
MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS. IF ASPIRATED INTO LUNGS
DURING SWALLOWING OR VOMITING, MAY CAUSE CHEMICAL PNEUMONIA, PULMONARY
INJURY OR DEATH.
CHRONIC EFFECTS: PROLONGED INHALATION MAY BE HARMFUL.
| 12. ECOLOGICAL INFORMATION | |
ECOTOXICITY:
THE PRODUCT IS NOT CLASSIFIED AS ENVIRONMENTALLY HAZARDOUS. HOWEVER,
THIS DOES NOT EXCLUDE THE POSSIBILITY THAT LARGE OR FREQUENT SPILLS
CAN HAVE A HARMFUL OR DAMAGING EFFECT ON THE ENVIRONMENT.
COMPONENTS SPECIES TEST RESULTS
DECAFLUOROPENTANE (CAS 138495-42-8):
AQUATIC:
ACUTE:
CRUSTACEA EC50 WATER FLEA (DAPHNIA MAGNA) 11.7 MG/L, 48 HOURS
FISH LC50 ZEBRA DANIO (DANIO RERIO) 13 MG/L, 96 HOURS
ISOPROPYL ALCOHOL (CAS 67-63-0):
AQUATIC:
ACUTE:
CRUSTACEA EC50 WATER FLEA (DAPHNIA MAGNA) 7550 - 13299 MG/L,
48 HOURS
FISH LC50 FATHEAD MINNOW (PIMEPHALES 9640 MG/L, 96 HOURS
PROMELAS)
TRANS-1,2-DICHLOROETHYLENE (CAS 156-60-5):
AQUATIC:
FISH LC50 BLUEGILL (LEPOMIS 120 - 160 MG/L, 96 HOURS
MACROCHIRUS)
ACUTE:
CRUSTACEA EC50 WATER FLEA (DAPHNIA MAGNA) 220 MG/L, 48 HOURS
* ESTIMATES FOR PRODUCT MAY BE BASED ON ADDITIONAL COMPONENT DATA
NOT SHOWN.
PERSISTENCE AND DEGRADABILITY:
BIOACCUMULATIVE POTENTIAL:
PARTITION COEFFICIENT N-OCTANOL / WATER (LOG KOW):
DECAFLUOROPENTANE: 2.7, POW AT 20 DEG. C
ISOPROPYL ALCOHOL: 0.05
TRANS-1,2-DICHLOROETHYLENE: 2.06
BIOCONCENTRATION FACTOR (BCF):
ISOPROPYL ALCOHOL: 3.16
MOBILITY IN SOIL: NO DATA AVAILABLE.
OTHER ADVERSE EFFECTS:
NO OTHER ADVERSE ENVIRONMENTAL EFFECTS (E.G. OZONE DEPLETION,
PHOTOCHEMICAL OZONE CREATION POTENTIAL, ENDOCRINE DISRUPTION, GLOBAL
WARMING POTENTIAL) ARE EXPECTED FROM THIS COMPONENT.
| 13. DISPOSAL CONSIDERATIONS | |
DISPOSAL OF WASTE FROM RESIDUES / UNUSED PRODUCTS:
THE DISPENSED LIQUID PRODUCT IS NOT A RCRA HAZARDOUS WASTE (SEE 40 CFR PART
261.20 - 261.33). EMPTY CONTAINER CAN BE RECYCLED. COLLECT AND RECLAIM OR
DISPOSE IN SEALED CONTAINERS AT LICENSED WASTE DISPOSAL SITE. CONTENTS
UNDER PRESSURE. DO NOT PUNCTURE, INCINERATE OR CRUSH. DISPOSE IN ACCORDANCE
WITH ALL APPLICABLE REGULATIONS.
HAZARDOUS WASTE CODE: NOT REGULATED.
CONTAMINATED PACKAGING:
SINCE EMPTIED CONTAINERS MAY RETAIN PRODUCT RESIDUE, FOLLOW LABEL WARNINGS
EVEN AFTER CONTAINER IS EMPTIED. EMPTY CONTAINERS SHOULD BE TAKEN TO AN
APPROVED WASTE HANDLING SITE FOR RECYCLING OR DISPOSAL.
| 14. TRANSPORT INFORMATION | |
DOT:
UN NUMBER: UN1950
UN PROPER SHIPPING NAME: AEROSOLS, FLAMMABLE, LIMITED QUANTITY
TRANSPORT HAZARD CLASS(ES):
CLASS: 2.1
SUBSIDIARY RISK:
LABEL(S): 2.1
PACKING GROUP: NOT APPLICABLE.
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
SPECIAL PROVISIONS: N82
PACKAGING EXCEPTIONS: 306
PACKAGING NON BULK: NONE
PACKAGING BULK: NONE
IATA:
UN NUMBER: UN1950
UN PROPER SHIPPING NAME: AEROSOLS, FLAMMABLE, LIMITED QUANTITY
TRANSPORT HAZARD CLASS(ES):
CLASS: 2.1
SUBSIDIARY RISK:
PACKING GROUP: NOT APPLICABLE.
ERG CODE: 10L
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
OTHER INFORMATION:
PASSENGER AND CARGO AIRCRAFT: ALLOWED WITH RESTRICTIONS.
CARGO AIRCRAFT ONLY: ALLOWED WITH RESTRICTIONS.
IMDG:
UN NUMBER: UN1950
UN PROPER SHIPPING NAME: AEROSOLS, LIMITED QUANTITY
TRANSPORT HAZARD CLASS(ES):
CLASS: 2
SUBSIDIARY RISK:
PACKING GROUP: NOT APPLICABLE.
ENVIRONMENTAL HAZARDS:
MARINE POLLUTANT: NO.
EMS: NOT AVAILABLE.
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
| 15. REGULATORY INFORMATION | |
US FEDERAL REGULATIONS:
THIS PRODUCT IS A "HAZARDOUS CHEMICAL" AS DEFINED BY THE OSHA HAZARD
COMMUNICATION STANDARD, 29 CFR 1910.1200.
TSCA SECTION 12(B) EXPORT NOTIFICATION (40 CFR 707, SUBPT. D):
DECAFLUOROPENTANE (CAS 138495-42-8):
1.0 % ONE-TIME EXPORT NOTIFICATION ONLY.
SARA 304 EMERGENCY RELEASE NOTIFICATION: NOT REGULATED.
OSHA SPECIFICALLY REGULATED SUBSTANCES (29 CFR 1910.1001-1050):
NOT REGULATED.
US EPCRA (SARA TITLE III) SECTION 313 - TOXIC CHEMICAL LISTED SUBSTANCE
NOT LISTED.
CERCLA HAZARDOUS SUBSTANCE LIST (40 CFR 302.4):
TRANS-1,2-DICHLOROETHYLENE (CAS 156-60-5): LISTED.
CERCLA HAZARDOUS SUBSTANCES REPORTABLE QUANTITY
TRANS-1,2-DICHLOROETHYLENE 1000 LBS
(CAS 156-60-5)
SPILLS OR RELEASES RESULTING IN THE LOSS OF ANY INGREDIENT AT OR ABOVE ITS
RQ REQUIRE IMMEDIATE NOTIFICATION TO THE NATIONAL RESPONSE CENTER
(800-424-8802) AND TO YOUR LOCAL EMERGENCY PLANNING COMMITTEE.
CLEAN AIR ACT (CAA) SECTION 112 HAZARDOUS AIR POLLUTANTS (HAPS) LIST:
NOT REGULATED.
CLEAN AIR ACT (CAA) SECTION 112(R) ACCIDENTAL RELEASE PREVENTION (40 CFR
68.130): NOT REGULATED.
SAFE DRINKING WATER ACT (SDWA): NOT REGULATED.
FEMA PRIORITY SUBSTANCES RESPIRATORY HEALTH AND SAFETY IN THE FLAVOR
MANUFACTURING WORKPLACE:
ISOPROPYL ALCOHOL (CAS 67-63-0): LOW PRIORITY
FOOD AND DRUG ADMINISTRATION (FDA): NOT REGULATED.
SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 (SARA):
SECTION 311/312 HAZARD CATEGORIES:
IMMEDIATE HAZARD: YES
DELAYED HAZARD: NO
FIRE HAZARD: YES
PRESSURE HAZARD: YES
REACTIVITY HAZARD: NO
SARA 302 EXTREMELY HAZARDOUS SUBSTANCE: NO
US STATE REGULATIONS:
US. CALIFORNIA. CANDIDATE CHEMICALS LIST. SAFER CONSUMER PRODUCTS
REGULATIONS (CAL. CODE REGS, TIT. 22, 69502.3, SUBD. (A)):
ISOPROPYL ALCOHOL (CAS 67-63-0)
TRANS-1,2-DICHLOROETHYLENE (CAS 156-60-5)
US. NEW JERSEY WORKER AND COMMUNITY RIGHT-TO-KNOW ACT:
CARBON DIOXIDE (CAS 124-38-9)
ISOPROPYL ALCOHOL (CAS 67-63-0)
TRANS-1,2-DICHLOROETHYLENE (CAS 156-60-5)
US. MASSACHUSETTS RTK - SUBSTANCE LIST:
CARBON DIOXIDE (CAS 124-38-9)
ISOPROPYL ALCOHOL (CAS 67-63-0)
TRANS-1,2-DICHLOROETHYLENE (CAS 156-60-5)
US. PENNSYLVANIA WORKER AND COMMUNITY RIGHT-TO-KNOW LAW:
CARBON DIOXIDE (CAS 124-38-9)
ISOPROPYL ALCOHOL (CAS 67-63-0)
TRANS-1,2-DICHLOROETHYLENE (CAS 156-60-5)
US. RHODE ISLAND RTK:
CARBON DIOXIDE (CAS 124-38-9)
TRANS-1,2-DICHLOROETHYLENE (CAS 156-60-5)
US. CALIFORNIA PROPOSITION 65:
CALIFORNIA SAFE DRINKING WATER AND TOXIC ENFORCEMENT ACT OF 1986
(PROPOSITION 65):
THIS MATERIAL IS NOT KNOWN TO CONTAIN ANY CHEMICALS CURRENTLY LISTED AS
CARCINOGENS OR REPRODUCTIVE TOXINS.
VOLATILE ORGANIC COMPOUNDS (VOC) REGULATIONS:
EPA:
VOC CONTENT (40 CFR 51.100(S)): 81.7 %
CONSUMER PRODUCTS (40 CFR 59, SUBPT. C): NOT REGULATED
STATE:
CONSUMER PRODUCTS: NOT REGULATED
VOC CONTENT (CA): 96.1 %
VOC CONTENT (OTC): 81.7 %
INTERNATIONAL INVENTORIES:
COUNTRY(S) OR INVENTORY NAME ON INVENTORY
REGION (YES/NO)*
AUSTRALIA AUSTRALIAN INVENTORY OF CHEMICAL SUBSTANCES YES
(AICS)
CANADA DOMESTIC SUBSTANCES LIST (DSL) NO
CANADA NON-DOMESTIC SUBSTANCES LIST (NDSL) YES
CHINA INVENTORY OF EXISTING CHEMICAL SUBSTANCES IN YES
CHINA (IECSC)
EUROPE EUROPEAN INVENTORY OF EXISTING COMMERCIAL NO
CHEMICAL SUBSTANCES (EINECS)
EUROPE EUROPEAN LIST OF NOTIFIED CHEMICAL SUBSTANCES NO
(ELINCS)
JAPAN INVENTORY OF EXISTING AND NEW CHEMICAL YES
SUBSTANCES (ENCS)
KOREA EXISTING CHEMICALS LIST (ECL) YES
NEW ZEALAND NEW ZEALAND INVENTORY YES
PHILIPPINES PHILIPPINE INVENTORY OF CHEMICALS AND CHEMICAL YES
SUBSTANCES (PICCS)
UNITED STATES TOXIC SUBSTANCES CONTROL ACT (TSCA) INVENTORY YES
& PUERTO RICO
*A "YES" INDICATES THAT ALL COMPONENTS OF THIS PRODUCT COMPLY WITH THE
INVENTORY REQUIREMENTS ADMINISTERED BY THE GOVERNING COUNTRY(S)
A "NO" INDICATES THAT ONE OR MORE COMPONENTS OF THE PRODUCT ARE NOT LISTED
OR EXEMPT FROM LISTING ON THE INVENTORY ADMINISTERED BY THE GOVERNING
COUNTRY(S).
| 16. OTHER INFORMATION, INCLUDING DATE OF PREPARATION | |
OR LAST REVISION
ISSUE DATE: 06-24-2014
REVISION DATE: 10-10-2017
PREPARED BY: ALLISON YOON
VERSION #: 03
FURTHER INFORMATION: CRC # 697/1002744
HMIS(R*) RATINGS:
HEALTH 2
FLAMMABILITY 2
PHYSICAL HAZARD 0
PERSONAL PROTECTION B
NFPA RATINGS:
HEALTH 2
FLAMMABILITY 2
INSTABILITY 0
NFPA RATINGS:
2
2
0
DISCLAIMER:
THE INFORMATION CONTAINED IN THIS DOCUMENT APPLIES TO THIS SPECIFIC
MATERIAL AS SUPPLIED. IT MAY NOT BE VALID FOR THIS MATERIAL IF IT IS USED
IN COMBINATION WITH ANY OTHER MATERIALS. THIS INFORMATION IS ACCURATE TO
THE BEST OF CRC'S KNOWLEDGE OR OBTAINED FROM SOURCES BELIEVED BY CRC TO BE
ACCURATE. BEFORE USING ANY PRODUCT, READ ALL WARNINGS AND DIRECTIONS ON THE
LABEL. FOR FURTHER CLARIFICATION OF ANY INFORMATION CONTAINED ON THIS
(M)SDS CONSULT YOUR SUPERVISOR, A HEALTH & SAFETY PROFESSIONAL, OR CRC
INDUSTRIES, INC..
REVISION INFORMATION:
THIS DOCUMENT HAS UNDERGONE SIGNIFICANT CHANGES AND SHOULD BE REVIEWED IN
ITS ENTIRETY.
MATERIAL NAME: CABLE CLEAN(R*) HIGH VOLTAGE SPLICE CLEANER
SDS US