| Common Name: | DYKEM CROSS CHECK TORQUE SEAL - PINK, 83320 |
| Manufacturer: | ITW PRO BRANDS |
| SDS Revision Date: | 6/14/2021 |
| SDS Format: | No Format Specified |
| Item Number(s): | 52GY71 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
ITW PRO BRANDS
SAFETY DATA SHEET
| 1. IDENTIFICATION |  |
PRODUCT IDENTIFIER: DYKEM(R*) CROSS CHECK(TM) TORQUE SEAL(R*) - PINK
OTHER MEANS OF IDENTIFICATION:
PART NUMBER: 83320
RECOMMENDED USE: INSPECTION PAINT
RECOMMENDED RESTRICTIONS: NONE KNOWN.
MANUFACTURER/IMPORTER/SUPPLIER/DISTRIBUTOR INFORMATION:
MANUFACTURER:
COMPANY NAME: ITW PRO BRANDS
ADDRESS:
805 E. OLD 56 HIGHWAY
OLATHE, KS 66061
COUNTRY: (U.S.A.)
TEL: +1 800-443-9536
IN CASE OF EMERGENCY: 1-800-535-5053 (INFOTRAC)
| 2. HAZARD(S) IDENTIFICATION | |
PHYSICAL HAZARDS:
FLAMMABLE LIQUIDS: CATEGORY 3
HEALTH HAZARDS:
SERIOUS EYE DAMAGE/EYE IRRITATION: CATEGORY 1
SENSITIZATION, SKIN: CATEGORY 1
GERM CELL MUTAGENICITY: CATEGORY 1B
CARCINOGENICITY: CATEGORY 2
REPRODUCTIVE TOXICITY: CATEGORY 1B
SPECIFIC TARGET ORGAN TOXICITY, REPEATED EXPOSURE:
CATEGORY 1 (CENTRAL NERVOUS SYSTEM)
ASPIRATION HAZARD: CATEGORY 1
ENVIRONMENTAL HAZARDS: NOT CLASSIFIED.
OSHA DEFINED HAZARDS: NOT CLASSIFIED.
LABEL ELEMENTS:
FLAME
CORROSION
HEALTH HAZARD
EXCLAMATION MARK
SIGNAL WORD: DANGER
HAZARD STATEMENT:
FLAMMABLE LIQUID AND VAPOR. MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS.
MAY CAUSE AN ALLERGIC SKIN REACTION. CAUSES SERIOUS EYE DAMAGE. MAY CAUSE
GENETIC DEFECTS. SUSPECTED OF CAUSING CANCER. MAY DAMAGE FERTILITY OR THE
UNBORN CHILD. CAUSES DAMAGE TO ORGANS (CENTRAL NERVOUS SYSTEM) THROUGH
PROLONGED OR REPEATED EXPOSURE. HARMFUL TO AQUATIC LIFE WITH LONG LASTING
EFFECTS.
PRECAUTIONARY STATEMENT:
PREVENTION:
OBTAIN SPECIAL INSTRUCTIONS BEFORE USE. DO NOT HANDLE UNTIL ALL SAFETY
PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD. KEEP AWAY FROM HEAT/SPARKS/OPEN
FLAMES/HOT SURFACES. - NO SMOKING. KEEP CONTAINER TIGHTLY CLOSED.
GROUND/BOND CONTAINER AND RECEIVING EQUIPMENT. USE EXPLOSION-PROOF
ELECTRICAL/VENTILATING/LIGHTING EQUIPMENT. USE ONLY NON-SPARKING TOOLS.
TAKE PRECAUTIONARY MEASURES AGAINST STATIC DISCHARGE. DO NOT BREATHE MIST
OR VAPOR. WASH THOROUGHLY AFTER HANDLING. DO NOT EAT, DRINK OR SMOKE WHEN
USING THIS PRODUCT. CONTAMINATED WORK CLOTHING MUST NOT BE ALLOWED OUT OF
THE WORKPLACE. WEAR PROTECTIVE GLOVES/PROTECTIVE CLOTHING/EYE
PROTECTION/FACE PROTECTION.
RESPONSE:
IF SWALLOWED:
IMMEDIATELY CALL A POISON CENTER/DOCTOR. DO NOT INDUCE VOMITING.
IF ON SKIN (OR HAIR):
TAKE OFF IMMEDIATELY ALL CONTAMINATED CLOTHING. RINSE SKIN WITH
WATER/SHOWER.
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES, IF
PRESENT AND EASY TO DO. CONTINUE RINSING. IMMEDIATELY CALL A POISON
CENTER/DOCTOR.
IF SKIN IRRITATION OR RASH OCCURS:
GET MEDICAL ADVICE/ATTENTION. WASH CONTAMINATED CLOTHING BEFORE REUSE.
IN CASE OF FIRE: USE APPROPRIATE MEDIA TO EXTINGUISH.
STORAGE: STORE IN A WELL-VENTILATED PLACE. KEEP COOL. STORE LOCKED UP.
DISPOSAL:
DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH
LOCAL/REGIONAL/NATIONAL/INTERNATIONAL REGULATIONS.
HAZARD(S) NOT OTHERWISE CLASSIFIED (HNOC): NONE KNOWN.
SUPPLEMENTAL INFORMATION:
CONTAINS METHYL ETHYL KETOXIME. MAY PRODUCE AN ALLERGIC REACTION.
| 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
MIXTURES:
CHEMICAL NAME COMMON NAME AND SYNONYMS CAS NUMBER %
LIGHT MINERAL SPIRITS 64742-88-7 30 - 40
DIACETONE ALCOHOL 123-42-2 1 - 5
METHYL ETHYL KETOXIME 96-29-7 1 - 5
PROPYLENE GLYCOL 108-65-6 1 - 5
MONOMETHYL ETHER
ACETATE
ETHYLBENZENE 100-41-4 0.1 - 1
METHYL BENZIMIDAZOLE- 10605-21-7 0.1 - 1
2-YI CARBAMATE
*DESIGNATES THAT A SPECIFIC CHEMICAL IDENTITY AND/OR PERCENTAGE OF
COMPOSITION HAS BEEN WITHHELD AS A TRADE SECRET.
| 4. FIRST-AID MEASURES | |
INHALATION:
MOVE TO FRESH AIR. CALL A PHYSICIAN IF SYMPTOMS DEVELOP OR PERSIST.
SKIN CONTACT:
REMOVE CONTAMINATED CLOTHING IMMEDIATELY AND WASH SKIN WITH SOAP AND
WATER. IN CASE OF ECZEMA OR OTHER SKIN DISORDERS: SEEK MEDICAL ATTENTION
AND TAKE ALONG THESE INSTRUCTIONS.
EYE CONTACT:
IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES.
REMOVE CONTACT LENSES, IF PRESENT AND EASY TO DO. CONTINUE RINSING.
GET MEDICAL ATTENTION IMMEDIATELY.
INGESTION:
CALL A PHYSICIAN OR POISON CONTROL CENTER IMMEDIATELY. RINSE MOUTH.
DO NOT INDUCE VOMITING. IF VOMITING OCCURS, KEEP HEAD LOW SO THAT
STOMACH CONTENT DOESN'T GET INTO THE LUNGS.
MOST IMPORTANT SYMPTOMS/EFFECTS, ACUTE AND DELAYED:
ASPIRATION MAY CAUSE PULMONARY EDEMA AND PNEUMONITIS. NARCOSIS. BEHAVIORAL
CHANGES. DECREASE IN MOTOR FUNCTIONS. SEVERE EYE IRRITATION. SYMPTOMS MAY
INCLUDE STINGING, TEARING, REDNESS, SWELLING, AND BLURRED VISION.
PERMANENT EYE DAMAGE INCLUDING BLINDNESS COULD RESULT. MAY CAUSE AN
ALLERGIC SKIN REACTION. DERMATITIS. RASH. PROLONGED EXPOSURE MAY CAUSE
CHRONIC EFFECTS.
INDICATION OF IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED:
PROVIDE GENERAL SUPPORTIVE MEASURES AND TREAT SYMPTOMATICALLY.
THERMAL BURNS:
FLUSH WITH WATER IMMEDIATELY. WHILE FLUSHING, REMOVE CLOTHES WHICH DO NOT
ADHERE TO AFFECTED AREA. CALL AN AMBULANCE. CONTINUE FLUSHING DURING
TRANSPORT TO HOSPITAL. KEEP VICTIM UNDER OBSERVATION. SYMPTOMS MAY BE
DELAYED.
GENERAL INFORMATION:
TAKE OFF ALL CONTAMINATED CLOTHING IMMEDIATELY.
IF EXPOSED OR CONCERNED:
GET MEDICAL ADVICE/ATTENTION. IF YOU FEEL UNWELL, SEEK MEDICAL ADVICE
(SHOW THE LABEL WHERE POSSIBLE). ENSURE THAT MEDICAL PERSONNEL ARE AWARE
OF THE MATERIAL(S) INVOLVED, AND TAKE PRECAUTIONS TO PROTECT THEMSELVES.
SHOW THIS SAFETY DATA SHEET TO THE DOCTOR IN ATTENDANCE. WASH CONTAMINATED
CLOTHING BEFORE REUSE.
| 5. FIRE-FIGHTING MEASURES | |
SUITABLE EXTINGUISHING MEDIA:
WATER FOG. ALCOHOL RESISTANT FOAM. DRY CHEMICAL POWDER. CARBON DIOXIDE
(CO2).
UNSUITABLE EXTINGUISHING MEDIA:
DO NOT USE WATER JET AS AN EXTINGUISHER, AS THIS WILL SPREAD THE FIRE.
SPECIFIC HAZARDS ARISING FROM THE CHEMICAL:
VAPORS MAY FORM EXPLOSIVE MIXTURES WITH AIR. VAPORS MAY TRAVEL
CONSIDERABLE DISTANCE TO A SOURCE OF IGNITION AND FLASH BACK. DURING
FIRE, GASES HAZARDOUS TO HEALTH MAY BE FORMED.
SPECIAL PROTECTIVE EQUIPMENT AND PRECAUTIONS FOR FIREFIGHTERS:
SELF-CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE CLOTHING MUST BE
WORN IN CASE OF FIRE.
FIRE FIGHTING EQUIPMENT/INSTRUCTIONS:
IN CASE OF FIRE AND/OR EXPLOSION DO NOT BREATHE FUMES. MOVE CONTAINERS
FROM FIRE AREA IF YOU CAN DO SO WITHOUT RISK.
SPECIFIC METHODS:
USE STANDARD FIREFIGHTING PROCEDURES AND CONSIDER THE HAZARDS OF OTHER
INVOLVED MATERIALS.
GENERAL FIRE HAZARDS: FLAMMABLE LIQUID AND VAPOR.
| 6. ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
KEEP UNNECESSARY PERSONNEL AWAY. KEEP PEOPLE AWAY FROM AND UPWIND OF
SPILL/LEAK. ELIMINATE ALL IGNITION SOURCES (NO SMOKING, FLARES, SPARKS,
OR FLAMES IN IMMEDIATE AREA). WEAR APPROPRIATE PROTECTIVE EQUIPMENT AND
CLOTHING DURING CLEAN-UP. DO NOT BREATHE MIST OR VAPOR. DO NOT TOUCH
DAMAGED CONTAINERS OR SPILLED MATERIAL UNLESS WEARING APPROPRIATE
PROTECTIVE CLOTHING. VENTILATE CLOSED SPACES BEFORE ENTERING THEM.
LOCAL AUTHORITIES SHOULD BE ADVISED IF SIGNIFICANT SPILLAGES CANNOT BE
CONTAINED. FOR PERSONAL PROTECTION, SEE SECTION 8 OF THE SDS.
METHODS AND MATERIALS FOR CONTAINMENT AND CLEANING UP:
USE WATER SPRAY TO REDUCE VAPORS OR DIVERT VAPOR CLOUD DRIFT. ELIMINATE
ALL IGNITION SOURCES (NO SMOKING, FLARES, SPARKS, OR FLAMES IN IMMEDIATE
AREA). KEEP COMBUSTIBLES (WOOD, PAPER, OIL, ETC.) AWAY FROM SPILLED
MATERIAL. TAKE PRECAUTIONARY MEASURES AGAINST STATIC DISCHARGE. USE ONLY
NON-SPARKING TOOLS.
LARGE SPILLS:
STOP THE FLOW OF MATERIAL, IF THIS IS WITHOUT RISK. DIKE THE SPILLED
MATERIAL, WHERE THIS IS POSSIBLE. USE A NON-COMBUSTIBLE MATERIAL LIKE
VERMICULITE, SAND OR EARTH TO SOAK UP THE PRODUCT AND PLACE INTO A
CONTAINER FOR LATER DISPOSAL. FOLLOWING PRODUCT RECOVERY, FLUSH AREA
WITH WATER.
SMALL SPILLS:
ABSORB WITH EARTH, SAND OR OTHER NON-COMBUSTIBLE MATERIAL AND TRANSFER
TO CONTAINERS FOR LATER DISPOSAL. WIPE UP WITH ABSORBENT MATERIAL
(E.G. CLOTH, FLEECE). CLEAN SURFACE THOROUGHLY TO REMOVE RESIDUAL
CONTAMINATION.
NEVER RETURN SPILLS TO ORIGINAL CONTAINERS FOR RE-USE. PUT MATERIAL IN
SUITABLE, COVERED, LABELED CONTAINERS. FOR WASTE DISPOSAL, SEE SECTION
13 OF THE SDS.
ENVIRONMENTAL PRECAUTIONS:
AVOID DISCHARGE INTO DRAINS, WATER COURSES OR ONTO THE GROUND.
| 7. HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING:
OBTAIN SPECIAL INSTRUCTIONS BEFORE USE. DO NOT HANDLE UNTIL ALL SAFETY
PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD. DO NOT HANDLE, STORE OR OPEN
NEAR AN OPEN FLAME, SOURCES OF HEAT OR SOURCES OF IGNITION. PROTECT
MATERIAL FROM DIRECT SUNLIGHT. EXPLOSION-PROOF GENERAL AND LOCAL EXHAUST
VENTILATION. TAKE PRECAUTIONARY MEASURES AGAINST STATIC DISCHARGES. ALL
EQUIPMENT USED WHEN HANDLING THE PRODUCT MUST BE GROUNDED. USE
NON-SPARKING TOOLS AND EXPLOSION-PROOF EQUIPMENT. DO NOT BREATHE MIST OR
VAPOR. DO NOT GET THIS MATERIAL IN CONTACT WITH EYES. AVOID CONTACT WITH
EYES, SKIN, AND CLOTHING. AVOID PROLONGED EXPOSURE. WHEN USING, DO NOT
EAT, DRINK OR SMOKE. PREGNANT OR BREASTFEEDING WOMEN MUST NOT HANDLE THIS
PRODUCT. SHOULD BE HANDLED IN CLOSED SYSTEMS, IF POSSIBLE. WEAR
APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT. WASH HANDS THOROUGHLY AFTER
HANDLING. OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES.
CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES:
STORE LOCKED UP. KEEP AWAY FROM HEAT, SPARKS AND OPEN FLAME. PREVENT
ELECTROSTATIC CHARGE BUILD-UP BY USING COMMON BONDING AND GROUNDING
TECHNIQUES. STORE IN A COOL, DRY PLACE OUT OF DIRECT SUNLIGHT. STORE
IN ORIGINAL TIGHTLY CLOSED CONTAINER. STORE IN A WELL-VENTILATED PLACE.
KEEP IN AN AREA EQUIPPED WITH SPRINKLERS. STORE AWAY FROM INCOMPATIBLE
MATERIALS (SEE SECTION 10 OF THE SDS).
| 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
OCCUPATIONAL EXPOSURE LIMITS:
THE FOLLOWING CONSTITUENTS ARE THE ONLY CONSTITUENTS OF THE PRODUCT WHICH
HAVE A PEL, TLV OR OTHER RECOMMENDED EXPOSURE LIMIT.
AT THIS TIME, THE OTHER CONSTITUENTS HAVE NO KNOWN EXPOSURE LIMITS.
US. OSHA TABLE Z-1 LIMITS FOR AIR CONTAMINANTS (29 CFR 1910.1000):
COMPONENTS TYPE VALUE FORM
DIACETONE ALCOHOL (CAS 123-42-2) PEL 240 MG/M3
50 PPM
ETHYLBENZENE (CAS 100-41-4) PEL 435 MG/M3
100 PPM
TITANIUM DIOXIDE (CAS 13463-67-7) PEL 15 MG/M3 TOTAL DUST.
US. ACGIH THRESHOLD LIMIT VALUES:
COMPONENTS TYPE VALUE FORM
DIACETONE ALCOHOL (CAS 123-42-2) TWA 50 PPM
ETHYLBENZENE (CAS 100-41-4) TWA 20 PPM
KAOLIN (CAS 1332-58-7) TWA 2 MG/M3 RESPIRABLE
FRACTION.
TITANIUM DIOXIDE (CAS 13463-67-7) TWA 10 MG/M3
US. NIOSH:
POCKET GUIDE TO CHEMICAL HAZARDS:
COMPONENTS TYPE VALUE FORM
DIACETONE ALCOHOL (CAS 123-42-2) TWA 240 MG/M3
50 PPM
ETHYLBENZENE (CAS 100-41-4) STEL 545 MG/M3
125 PPM
TWA 435 MG/M3
100 PPM
KAOLIN (CAS 1332-58-7) TWA 5 MG/M3 RESPIRABLE.
10 MG/M3 TOTAL
SILICA, AMORPHOUS (CAS 7631-86-9) TWA 6 MG/M3
US. WORKPLACE ENVIRONMENTAL EXPOSURE LEVEL (WEEL) GUIDES:
COMPONENTS TYPE VALUE
METHYL ETHYL KETOXIME (CAS 96-29-7) TWA 36 MG/M3
10 PPM
PROPYLENE GLYCOL MONOMETHYL ETHER ACETATE (CAS 108-65-6) TWA 50 PPM
BIOLOGICAL LIMIT VALUES:
ACGIH BIOLOGICAL EXPOSURE INDICES:
COMPONENTS VALUE DETERMINANT SPECIMEN SAMPLING TIME
ETHYLBENZENE 0.15 G/G SUM OF MANDELIC ACID CREATININE *
(CAS 100-41-4) AND PHENYLGLYOXYLIC IN URINE
ACID
* - FOR SAMPLING DETAILS, PLEASE SEE THE SOURCE DOCUMENT.
EXPOSURE GUIDELINES:
US - CALIFORNIA OELS:
SKIN DESIGNATION:
PROPYLENE GLYCOL MONOMETHYL ETHER ACETATE (CAS 108-65-6):
CAN BE ABSORBED THROUGH THE SKIN.
APPROPRIATE ENGINEERING CONTROLS:
EXPLOSION-PROOF GENERAL AND LOCAL EXHAUST VENTILATION. GOOD GENERAL
VENTILATION (TYPICALLY 10 AIR CHANGES PER HOUR) SHOULD BE USED.
VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS. IF APPLICABLE,
USE PROCESS ENCLOSURES, LOCAL EXHAUST VENTILATION, OR OTHER ENGINEERING
CONTROLS TO MAINTAIN AIRBORNE LEVELS BELOW RECOMMENDED EXPOSURE LIMITS.
IF EXPOSURE LIMITS HAVE NOT BEEN ESTABLISHED, MAINTAIN AIRBORNE LEVELS
TO AN ACCEPTABLE LEVEL. PROVIDE EYEWASH STATION.
INDIVIDUAL PROTECTION MEASURES, SUCH AS PERSONAL PROTECTIVE EQUIPMENT:
EYE/FACE PROTECTION: WEAR SAFETY GLASSES WITH SIDE SHIELDS (OR GOGGLES).
SKIN PROTECTION:
HAND PROTECTION: WEAR APPROPRIATE CHEMICAL RESISTANT GLOVES.
OTHER:
WEAR APPROPRIATE CHEMICAL RESISTANT CLOTHING. USE OF AN IMPERVIOUS APRON
IS RECOMMENDED.
RESPIRATORY PROTECTION:
USE A POSITIVE-PRESSURE AIR-SUPPLIED RESPIRATOR IF THERE IS ANY POTENTIAL
FOR AN UNCONTROLLED RELEASE, EXPOSURE LEVELS ARE NOT KNOWN, OR ANY OTHER
CIRCUMSTANCES WHERE AIR-PURIFYING RESPIRATORS MAY NOT PROVIDE ADEQUATE
PROTECTION.
THERMAL HAZARDS:
WEAR APPROPRIATE THERMAL PROTECTIVE CLOTHING, WHEN NECESSARY.
GENERAL HYGIENE CONSIDERATIONS:
OBSERVE ANY MEDICAL SURVEILLANCE REQUIREMENTS. WHEN USING DO NOT SMOKE.
ALWAYS OBSERVE GOOD PERSONAL HYGIENE MEASURES, SUCH AS WASHING AFTER
HANDLING THE MATERIAL AND BEFORE EATING, DRINKING, AND/OR SMOKING.
ROUTINELY WASH WORK CLOTHING AND PROTECTIVE EQUIPMENT TO REMOVE
CONTAMINANTS. CONTAMINATED WORK CLOTHING SHOULD NOT BE ALLOWED OUT
OF THE WORKPLACE.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE:
PHYSICAL STATE: LIQUID.
FORM: LIQUID.
COLOR: PINK.
ODOR: MILD.
ODOR THRESHOLD: NOT AVAILABLE.
PH: NOT AVAILABLE.
MELTING POINT/FREEZING POINT: NOT AVAILABLE.
INITIAL BOILING POINT AND BOILING RANGE:
277 - 485 DEG. F (136.11 - 251.67 DEG. C)
FLASH POINT: 40.6 - 105.0 DEG. F (4.8 - 40.6 DEG. C)
EVAPORATION RATE: <1 (BUAC=1)
FLAMMABILITY (SOLID, GAS): NOT APPLICABLE.
UPPER/LOWER FLAMMABILITY OR EXPLOSIVE LIMITS:
FLAMMABILITY LIMIT - LOWER (%): 1.1 %
FLAMMABILITY LIMIT - UPPER (%): 7 %
EXPLOSIVE LIMIT - LOWER (%): NOT AVAILABLE.
EXPLOSIVE LIMIT - UPPER (%): NOT AVAILABLE.
VAPOR PRESSURE: NOT AVAILABLE.
VAPOR DENSITY: >1 (AIR=1)
RELATIVE DENSITY: >1 @ 70 DEG. C
SOLUBILITY(IES):
SOLUBILITY (WATER): NEGLIGIBLE
PARTITION COEFFICIENT (N-OCTANOL/WATER): NOT AVAILABLE.
AUTO-IGNITION TEMPERATURE: NOT AVAILABLE.
DECOMPOSITION TEMPERATURE: NOT AVAILABLE.
VISCOSITY: NOT AVAILABLE.
OTHER INFORMATION:
EXPLOSIVE PROPERTIES: NOT EXPLOSIVE.
OXIDIZING PROPERTIES: NOT OXIDIZING.
VOC: 30.83 %
| 10. STABILITY AND REACTIVITY | |
REACTIVITY:
THE PRODUCT IS STABLE AND NON-REACTIVE UNDER NORMAL CONDITIONS
OF USE, STORAGE AND TRANSPORT.
CHEMICAL STABILITY: MATERIAL IS STABLE UNDER NORMAL CONDITIONS.
POSSIBILITY OF HAZARDOUS REACTIONS:
HAZARDOUS POLYMERIZATION DOES NOT OCCUR.
CONDITIONS TO AVOID:
AVOID HEAT, SPARKS, OPEN FLAMES AND OTHER IGNITION SOURCES. AVOID
TEMPERATURES EXCEEDING THE FLASH POINT. CONTACT WITH INCOMPATIBLE
MATERIALS.
INCOMPATIBLE MATERIALS: STRONG OXIDIZING AGENTS.
HAZARDOUS DECOMPOSITION PRODUCTS: CARBON OXIDES.
| 11. TOXICOLOGICAL INFORMATION | |
INFORMATION ON LIKELY ROUTES OF EXPOSURE:
INHALATION:
MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE BY
INHALATION.
SKIN CONTACT: MAY CAUSE AN ALLERGIC SKIN REACTION.
EYE CONTACT: CAUSES SERIOUS EYE DAMAGE.
INGESTION:
DROPLETS OF THE PRODUCT ASPIRATED INTO THE LUNGS THROUGH INGESTION OR
VOMITING MAY CAUSE A SERIOUS CHEMICAL PNEUMONIA.
SYMPTOMS RELATED TO THE PHYSICAL, CHEMICAL AND TOXICOLOGICAL
CHARACTERISTICS:
ASPIRATION MAY CAUSE PULMONARY EDEMA AND PNEUMONITIS. NARCOSIS.
BEHAVIORAL CHANGES. DECREASE IN MOTOR FUNCTIONS. SEVERE EYE IRRITATION.
SYMPTOMS MAY INCLUDE STINGING, TEARING, REDNESS, SWELLING, AND BLURRED
VISION. PERMANENT EYE DAMAGE INCLUDING BLINDNESS COULD RESULT.
MAY CAUSE AN ALLERGIC SKIN REACTION. DERMATITIS. RASH.
INFORMATION ON TOXICOLOGICAL EFFECTS:
ACUTE TOXICITY: MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS.
COMPONENTS SPECIES TEST RESULTS
DIACETONE ALCOHOL (CAS 123-42-2):
ACUTE:
DERMAL:
LD50 RAT >1900 MG/KG, 24 HOURS
ORAL:
LD50 RAT 3000 MG/KG
ETHYLBENZENE (CAS 100-41-4):
ACUTE:
ORAL:
LD50 RAT 3500 MG/KG
KAOLIN (CAS 1332-58-7):
ACUTE:
DERMAL:
LD50 RAT >5000 MG/KG
ORAL:
LD50 RAT >5000 MG/KG
LIGHT MINERAL SPIRITS (CAS 64742-88-7):
ACUTE:
DERMAL:
LD50 RABBIT >2000 MG/KG, 24 HOURS
INHALATION:
VAPOR:
LC50 RAT >4.5 MG/L, 4 HOURS
>0.1 MG/L, 8 HOURS
ORAL:
LD50 RAT >5000 MG/KG
METHYL BENZIMIDAZOLE-2-YI CARBAMATE (CAS 10605-21-7):
ACUTE:
DERMAL:
LD50 RAT 2000 MG/KG
ORAL:
LD50 RAT >5000 MG/KG
METHYL ETHYL KETOXIME (CAS 96-29-7):
ACUTE:
DERMAL:
LD50 RABBIT >1000 MG/KG, 24 HOURS
INHALATION:
VAPOR:
LC50 RAT >4.8 MG/L, 4 HOURS
ORAL:
LD50 RAT >900 MG/KG
PROPYLENE GLYCOL MONOMETHYL ETHER ACETATE (CAS 108-65-6):
ACUTE:
DERMAL:
LD50 RAT >2000 MG/KG, 24 HOURS
ORAL:
LD50 RAT >5000 MG/KG
SILICA, AMORPHOUS (CAS 7631-86-9):
ACUTE:
DERMAL:
LD50 RABBIT >2000 MG/KG, 24 HOURS
INHALATION:
DUST:
LC50 RAT >0.14 MG/L, 4 HOURS
ORAL:
LD50 RAT >3300 MG/KG
TITANIUM DIOXIDE (CAS 13463-67-7):
ACUTE:
INHALATION:
LC50 RAT >2.3 MG/L, 4 HOURS
ORAL:
LD50 RAT >2000 MG/KG
SKIN CORROSION/IRRITATION:
PROLONGED SKIN CONTACT MAY CAUSE TEMPORARY IRRITATION.
SERIOUS EYE DAMAGE/EYE IRRITATION: CAUSES SERIOUS EYE DAMAGE.
RESPIRATORY OR SKIN SENSITIZATION:
RESPIRATORY SENSITIZATION: NOT A RESPIRATORY SENSITIZER.
SKIN SENSITIZATION: MAY CAUSE AN ALLERGIC SKIN REACTION.
GERM CELL MUTAGENICITY: MAY CAUSE GENETIC DEFECTS.
CARCINOGENICITY: SUSPECTED OF CAUSING CANCER.
ACGIH CARCINOGENS:
ETHYLBENZENE (CAS 100-41-4):
A3 CONFIRMED ANIMAL CARCINOGEN WITH UNKNOWN RELEVANCE TO HUMANS.
KAOLIN (CAS 1332-58-7): A4 NOT CLASSIFIABLE AS A HUMAN CARCINOGEN.
TITANIUM DIOXIDE (CAS 13463-67-7):
A4 NOT CLASSIFIABLE AS A HUMAN CARCINOGEN.
IARC MONOGRAPHS. OVERALL EVALUATION OF CARCINOGENICITY:
ETHYLBENZENE (CAS 100-41-4): 2B POSSIBLY CARCINOGENIC TO HUMANS.
SILICA, AMORPHOUS (CAS 7631-86-9):
3 NOT CLASSIFIABLE AS TO CARCINOGENICITY TO HUMANS.
TITANIUM DIOXIDE (CAS 13463-67-7): 2B POSSIBLY CARCINOGENIC TO HUMANS.
OSHA SPECIFICALLY REGULATED SUBSTANCES (29 CFR 1910.1001-1053):
NOT LISTED.
US. NATIONAL TOXICOLOGY PROGRAM (NTP) REPORT ON CARCINOGENS: NOT LISTED.
REPRODUCTIVE TOXICITY: MAY DAMAGE FERTILITY OR THE UNBORN CHILD.
SPECIFIC TARGET ORGAN TOXICITY - SINGLE EXPOSURE: NOT CLASSIFIED.
SPECIFIC TARGET ORGAN TOXICITY - REPEATED EXPOSURE:
CAUSES DAMAGE TO ORGANS (CENTRAL NERVOUS SYSTEM) THROUGH PROLONGED OR
REPEATED EXPOSURE.
ASPIRATION HAZARD: MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS.
CHRONIC EFFECTS:
CAUSES DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE.
PROLONGED INHALATION MAY BE HARMFUL. PROLONGED EXPOSURE MAY CAUSE
CHRONIC EFFECTS.
FURTHER INFORMATION: SYMPTOMS MAY BE DELAYED.
| 12. ECOLOGICAL INFORMATION | |
ECOTOXICITY:
THE PRODUCT IS NOT CLASSIFIED AS ENVIRONMENTALLY HAZARDOUS. HOWEVER,
THIS DOES NOT EXCLUDE THE POSSIBILITY THAT LARGE OR FREQUENT SPILLS
CAN HAVE A HARMFUL OR DAMAGING EFFECT ON THE ENVIRONMENT.
COMPONENTS SPECIES TEST RESULTS
DIACETONE ALCOHOL (CAS 123-42-2):
AQUATIC:
ACUTE:
FISH LC50 BLUEGILL 420 MG/L, 96 HOURS
(LEPOMIS MACROCHIRUS)
ETHYLBENZENE (CAS 100-41-4):
AQUATIC:
ACUTE:
CRUSTACEA EC50 WATER FLEA 1.37 - 4.4 MG/L,
(DAPHNIA MAGNA) 48 HOURS
FISH LC50 ATLANTIC SILVERSIDE 4.4 - 5.7 MG/L,
(MENIDIA MENIDIA) 96 HOURS
METHYL BENZIMIDAZOLE-2-YI CARBAMATE (CAS 10605-21-7):
AQUATIC:
ACUTE:
FISH LC50 CHANNEL CATFISH 0.008 - 0.013 MG/L,
(ICTALURUS PUNCTATUS) 96 HOURS
METHYL ETHYL KETOXIME (CAS 96-29-7):
AQUATIC:
ACUTE:
FISH LC50 FATHEAD MINNOW 777 - 914 MG/L,
(PIMEPHALES PROMELAS) 96 HOURS
TITANIUM DIOXIDE (CAS 13463-67-7):
AQUATIC:
ACUTE:
CRUSTACEA EC50 WATER FLEA >1000 MG/L,
(DAPHNIA MAGNA) 48 HOURS
FISH LC50 MUMMICHOG >1000 MG/L,
(FUNDULUS HETEROCLITUS) 96 HOURS
PERSISTENCE AND DEGRADABILITY:
NO DATA IS AVAILABLE ON THE DEGRADABILITY OF ANY INGREDIENTS IN THE
MIXTURE.
BIOACCUMULATIVE POTENTIAL:
PARTITION COEFFICIENT N-OCTANOL / WATER (LOG KOW):
DIACETONE ALCOHOL -0.098
ETHYLBENZENE 3.15
METHYL BENZIMIDAZOLE-2-YI CARBAMATE 1.52
MOBILITY IN SOIL: NOT ESTABLISHED.
OTHER ADVERSE EFFECTS:
THE PRODUCT CONTAINS VOLATILE ORGANIC COMPOUNDS WHICH HAVE A PHOTOCHEMICAL
OZONE CREATION POTENTIAL.
| 13. DISPOSAL CONSIDERATIONS | |
DISPOSAL INSTRUCTIONS:
COLLECT AND RECLAIM OR DISPOSE IN SEALED CONTAINERS AT LICENSED WASTE
DISPOSAL SITE. DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH
LOCAL/REGIONAL/NATIONAL/INTERNATIONAL REGULATIONS.
LOCAL DISPOSAL REGULATIONS:
DISPOSE IN ACCORDANCE WITH ALL APPLICABLE REGULATIONS.
HAZARDOUS WASTE CODE:
THE WASTE CODE SHOULD BE ASSIGNED IN DISCUSSION BETWEEN THE USER,
THE PRODUCER AND THE WASTE DISPOSAL COMPANY.
WASTE FROM RESIDUES / UNUSED PRODUCTS:
DISPOSE OF IN ACCORDANCE WITH LOCAL REGULATIONS. EMPTY CONTAINERS OR
LINERS MAY RETAIN SOME PRODUCT RESIDUES. THIS MATERIAL AND ITS CONTAINER
MUST BE DISPOSED OF IN A SAFE MANNER (SEE: DISPOSAL INSTRUCTIONS).
CONTAMINATED PACKAGING:
SINCE EMPTIED CONTAINERS MAY RETAIN PRODUCT RESIDUE, FOLLOW LABEL WARNINGS
EVEN AFTER CONTAINER IS EMPTIED. EMPTY CONTAINERS SHOULD BE TAKEN TO AN
APPROVED WASTE HANDLING SITE FOR RECYCLING OR DISPOSAL.
| 14. TRANSPORT INFORMATION | |
DOT:
UN NUMBER: UN1263
UN PROPER SHIPPING NAME: PAINT
TRANSPORT HAZARD CLASS(ES):
CLASS: 3
SUBSIDIARY RISK:
LABEL(S): 3
PACKING GROUP: III
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
SPECIAL PROVISIONS: B1, B52, IB3, T2, TP1, TP29
PACKAGING EXCEPTIONS: 150
PACKAGING NON BULK: 173
PACKAGING BULK: 242
IATA:
UN NUMBER: UN1263
UN PROPER SHIPPING NAME: PAINT
TRANSPORT HAZARD CLASS(ES):
CLASS: 3
SUBSIDIARY RISK:
PACKING GROUP: III
ENVIRONMENTAL HAZARDS: NO.
ERG CODE: 3L
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
OTHER INFORMATION:
PASSENGER AND CARGO AIRCRAFT: ALLOWED WITH RESTRICTIONS.
CARGO AIRCRAFT ONLY: ALLOWED WITH RESTRICTIONS.
IMDG:
UN NUMBER: UN1263
UN PROPER SHIPPING NAME: PAINT
TRANSPORT HAZARD CLASS(ES):
CLASS: 3
SUBSIDIARY RISK:
PACKING GROUP: III
ENVIRONMENTAL HAZARDS:
MARINE POLLUTANT: NO.
EMS: F-E, S-E
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
TRANSPORT IN BULK ACCORDING TO ANNEX II OF MARPOL 73/78 AND THE IBC CODE:
NOT APPLICABLE.
DOT: FLAMMABLE LIQUID, CLASS/DIVISION 3.1, 3.2, 3.3
IATA; IMDG: CLASS 3, FLAMMABLE LIQUIDS
| 15. REGULATORY INFORMATION | |
US FEDERAL REGULATIONS:
THIS PRODUCT IS A "HAZARDOUS CHEMICAL" AS DEFINED BY THE OSHA HAZARD
COMMUNICATION STANDARD, 29 CFR 1910.1200.
TOXIC SUBSTANCES CONTROL ACT (TSCA):
TSCA SECTION 12(B) EXPORT NOTIFICATION (40 CFR 707, SUBPT. D):
NOT REGULATED.
CERCLA HAZARDOUS SUBSTANCE LIST (40 CFR 302.4):
ETHYLBENZENE (CAS 100-41-4) LISTED.
METHYL BENZIMIDAZOLE-2-YI CARBAMATE (CAS 10605-21-7) LISTED.
SARA 304 EMERGENCY RELEASE NOTIFICATION: NOT REGULATED.
OSHA SPECIFICALLY REGULATED SUBSTANCES (29 CFR 1910.1001-1053):
NOT LISTED.
SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 (SARA):
SARA 302 EXTREMELY HAZARDOUS SUBSTANCE: NOT LISTED.
SARA 311/312 HAZARDOUS CHEMICAL: YES
CLASSIFIED HAZARD CATEGORIES:
FLAMMABLE (GASES, AEROSOLS, LIQUIDS, OR SOLIDS)
SERIOUS EYE DAMAGE OR EYE IRRITATION
RESPIRATORY OR SKIN SENSITIZATION
GERM CELL MUTAGENICITY
CARCINOGENICITY
REPRODUCTIVE TOXICITY
SPECIFIC TARGET ORGAN TOXICITY (SINGLE OR REPEATED EXPOSURE)
ASPIRATION HAZARD
SARA 313 (TRI REPORTING):
CHEMICAL NAME CAS NUMBER % BY WT.
ETHYLBENZENE 100-41-4 0.1 - 1
OTHER FEDERAL REGULATIONS:
CLEAN AIR ACT (CAA) SECTION 112 HAZARDOUS AIR POLLUTANTS (HAPS) LIST:
ETHYLBENZENE (CAS 100-41-4)
CLEAN AIR ACT (CAA) SECTION 112(R) ACCIDENTAL RELEASE PREVENTION
(40 CFR 68.130): NOT REGULATED.
SAFE DRINKING WATER ACT (SDWA):
CONTAINS COMPONENT(S) REGULATED UNDER THE SAFE DRINKING WATER ACT.
US STATE REGULATIONS:
US. NEW JERSEY WORKER AND COMMUNITY RIGHT-TO-KNOW ACT:
DIACETONE ALCOHOL (CAS 123-42-2)
ETHYLBENZENE (CAS 100-41-4)
KAOLIN (CAS 1332-58-7)
METHYL BENZIMIDAZOLE-2-YI CARBAMATE (CAS 10605-21-7)
TITANIUM DIOXIDE (CAS 13463-67-7)
CALIFORNIA PROPOSITION 65:
WARNING:
WARNING:
THIS PRODUCT CONTAINS A CHEMICAL KNOWN TO THE STATE OF CALIFORNIA TO CAUSE
CANCER. FOR MORE INFORMATION GO TO WWW.P65WARNINGS.CA.GOV.
CALIFORNIA PROPOSITION 65 - CRT LISTED DATE/CARCINOGENIC SUBSTANCE
ETHYLBENZENE (CAS 100-41-4) LISTED: JUNE 11, 2004
US. CALIFORNIA. CANDIDATE CHEMICALS LIST. SAFER CONSUMER PRODUCTS
REGULATIONS (CAL. CODE REGS, TIT. 22, 69502.3, SUBD. (A)):
ETHYLBENZENE (CAS 100-41-4)
TITANIUM DIOXIDE (CAS 13463-67-7)
INTERNATIONAL INVENTORIES:
COUNTRY(S) OR REGION INVENTORY NAME ON INVENTORY
(YES/NO)*
AUSTRALIA AUSTRALIAN INVENTORY YES
OF INDUSTRIAL CHEMICALS (AICIS)
CANADA DOMESTIC SUBSTANCES LIST (DSL) YES
CANADA NON-DOMESTIC SUBSTANCES LIST NO
(NDSL)
CHINA INVENTORY OF EXISTING CHEMICAL YES
SUBSTANCES IN CHINA (IECSC)
EUROPE EUROPEAN INVENTORY OF EXISTING NO
COMMERCIAL CHEMICAL SUBSTANCES
(EINECS)
EUROPE EUROPEAN LIST OF NOTIFIED NO
CHEMICAL SUBSTANCES (ELINCS)
JAPAN INVENTORY OF EXISTING AND NEW NO
CHEMICAL SUBSTANCES (ENCS)
KOREA EXISTING CHEMICALS LIST (ECL) YES
NEW ZEALAND NEW ZEALAND INVENTORY YES
PHILIPPINES PHILIPPINE INVENTORY OF YES
CHEMICALS AND CHEMICAL
SUBSTANCES (PICCS)
TAIWAN TAIWAN CHEMICAL SUBSTANCE YES
INVENTORY (TCSI)
UNITED STATES & TOXIC SUBSTANCES CONTROL YES
PUERTO RICO ACT (TSCA) INVENTORY
*A "YES" INDICATES THAT ALL COMPONENTS OF THIS PRODUCT COMPLY WITH
THE INVENTORY REQUIREMENTS ADMINISTERED BY THE GOVERNING COUNTRY(S)
A "NO" INDICATES THAT ONE OR MORE COMPONENTS OF THE PRODUCT ARE NOT
LISTED OR EXEMPT FROM LISTING ON THE INVENTORY ADMINISTERED BY THE
GOVERNING COUNTRY(S).
| 16. OTHER INFORMATION, INCLUDING DATE OF PREPARATION | |
OR LAST REVISION
ISSUE DATE: 12-30-2020
REVISION DATE: 06-14-2021
VERSION #: 04
DISCLAIMER:
ITW PRO BRANDS CANNOT ANTICIPATE ALL CONDITIONS UNDER WHICH THIS
INFORMATION AND ITS PRODUCT, OR THE PRODUCTS OF OTHER MANUFACTURERS
IN COMBINATION WITH ITS PRODUCT, MAY BE USED. IT IS THE USER'S
RESPONSIBILITY TO ENSURE SAFE CONDITIONS FOR HANDLING, STORAGE AND
DISPOSAL OF THE PRODUCT, AND TO ASSUME LIABILITY FOR LOSS, INJURY,
DAMAGE OR EXPENSE DUE TO IMPROPER USE. THE INFORMATION PROVIDED IN THIS
SAFETY DATA SHEET IS CORRECT TO THE BEST OF OUR KNOWLEDGE, INFORMATION
AND BELIEF AT THE DATE OF ITS PUBLICATION. THE INFORMATION GIVEN IS
DESIGNED ONLY AS A GUIDANCE FOR SAFE HANDLING, USE, PROCESSING, STORAGE,
TRANSPORTATION, DISPOSAL AND RELEASE AND IS NOT TO BE CONSIDERED A
WARRANTY OR QUALITY SPECIFICATION. THE INFORMATION RELATES ONLY TO THE
SPECIFIC MATERIAL DESIGNATED AND MAY NOT BE VALID FOR SUCH MATERIAL USED
IN COMBINATION WITH ANY OTHER MATERIALS OR IN ANY PROCESS, UNLESS
SPECIFIED IN THE TEXT.
REVISION INFORMATION:
TRANSPORT INFORMATION: PROPER SHIPPING NAME/PACKING GROUP
MATERIAL NAME: DYKEM(R*) CROSS CHECK(TM) TORQUE SEAL(R*) - PINK
SDS US