| Common Name: | DRY FALL WATERBORNE FLAT BLACK |
| Manufacturer: | KRYLON PRODUCTS |
| SDS Revision Date: | 6/20/2016 |
| SDS Format: | GHS-US |
| Item Number(s): | 52JN62 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
SAFETY DATA SHEET
K000Z5931
| SECTION 1. IDENTIFICATION |  |
PRODUCT NAME: KRYLON(R*) DRY FALL WATERBORNE FLAT BLACK
PRODUCT CODE: K000Z5931
OTHER MEANS OF IDENTIFICATION: NOT AVAILABLE.
PRODUCT TYPE: LIQUID.
RELEVANT IDENTIFIED USES OF THE SUBSTANCE OR MIXTURE AND USES ADVISED
AGAINST: NOT APPLICABLE.
MANUFACTURER:
KRYLON PRODUCTS GROUP
CLEVELAND, OH 44115
EMERGENCY TELEPHONE NUMBER OF THE COMPANY: (216) 566-2917
PRODUCT INFORMATION TELEPHONE NUMBER: (800) 247-3266
REGULATORY INFORMATION TELEPHONE NUMBER: (216) 566-2902
TRANSPORTATION EMERGENCY TELEPHONE NUMBER: (800) 424-9300
| SECTION 2. HAZARDS IDENTIFICATION | |
OSHA/HCS STATUS:
THIS MATERIAL IS CONSIDERED HAZARDOUS BY THE OSHA HAZARD COMMUNICATION
STANDARD (29 CFR 1910.1200).
CLASSIFICATION OF THE SUBSTANCE OR MIXTURE:
CARCINOGENICITY: CATEGORY 1A
SPECIFIC TARGET ORGAN TOXICITY (REPEATED EXPOSURE): CATEGORY 2
PERCENTAGE OF THE MIXTURE CONSISTING OF INGREDIENT(S) OF UNKNOWN TOXICITY:
1%
GHS LABEL ELEMENTS:
HAZARD PICTOGRAMS: HEALTH HAZARD
SIGNAL WORD: DANGER
HAZARD STATEMENTS:
MAY CAUSE CANCER.
MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE.
PRECAUTIONARY STATEMENTS:
PREVENTION:
OBTAIN SPECIAL INSTRUCTIONS BEFORE USE. DO NOT HANDLE UNTIL ALL SAFETY
PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD. WEAR PROTECTIVE GLOVES. WEAR EYE
OR FACE PROTECTION. WEAR PROTECTIVE CLOTHING. DO NOT BREATHE VAPOR.
RESPONSE: GET MEDICAL ATTENTION IF YOU FEEL UNWELL.
IF EXPOSED OR CONCERNED: GET MEDICAL ATTENTION.
STORAGE: STORE LOCKED UP.
DISPOSAL:
DISPOSE OF CONTENTS AND CONTAINER IN ACCORDANCE WITH ALL LOCAL, REGIONAL,
NATIONAL AND INTERNATIONAL REGULATIONS.
SUPPLEMENTAL LABEL ELEMENTS:
WARNING:
THIS PRODUCT CONTAINS CHEMICALS KNOWN TO THE STATE OF CALIFORNIA TO CAUSE
CANCER AND BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM. FOR INDUSTRIAL USE
ONLY. ADEQUATE VENTILATION REQUIRED WHEN SANDING OR ABRADING THE DRIED
FILM. IF ADEQUATE VENTILATION CANNOT BE PROVIDED WEAR AN APPROVED
PARTICULATE RESPIRATOR (NIOSH APPROVED). FOLLOW RESPIRATOR MANUFACTURER'S
DIRECTIONS FOR RESPIRATOR USE. DELAYED EFFECTS FROM LONG TERM OVEREXPOSURE.
ABRADING OR SANDING OF THE DRY FILM MAY RELEASE CRYSTALLINE SILICA WHICH
HAS BEEN SHOWN TO CAUSE LUNG DAMAGE AND CANCER UNDER LONG TERM EXPOSURE.
PLEASE REFER TO THE SDS FOR ADDITIONAL INFORMATION. KEEP OUT OF REACH OF
CHILDREN. DO NOT TRANSFER CONTENTS TO OTHER CONTAINERS FOR STORAGE.
HAZARDS NOT OTHERWISE CLASSIFIED: NONE KNOWN.
| SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
SUBSTANCE/MIXTURE: MIXTURE
OTHER MEANS OF IDENTIFICATION: NOT AVAILABLE.
CAS NUMBER/OTHER IDENTIFIERS:
INGREDIENT NAME % BY WEIGHT CAS NUMBER
CARBON BLACK 2.5 1333-86-4
ETHANOL 1.57 64-17-5
CRYSTALLINE SILICA, RESPIRABLE POWDER 0.14 14808-60-7
ANY CONCENTRATION SHOWN AS A RANGE IS TO PROTECT CONFIDENTIALITY OR IS DUE
TO BATCH VARIATION.
THERE ARE NO ADDITIONAL INGREDIENTS PRESENT WHICH, WITHIN THE CURRENT
KNOWLEDGE OF THE SUPPLIER AND IN THE CONCENTRATIONS APPLICABLE, ARE
CLASSIFIED AS HAZARDOUS TO HEALTH AND HENCE REQUIRE REPORTING IN THIS
SECTION.
OCCUPATIONAL EXPOSURE LIMITS, IF AVAILABLE, ARE LISTED IN SECTION 8.
| SECTION 4. FIRST AID MEASURES | |
DESCRIPTION OF NECESSARY FIRST AID MEASURES:
EYE CONTACT:
IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER, OCCASIONALLY LIFTING THE UPPER
AND LOWER EYELIDS. CHECK FOR AND REMOVE ANY CONTACT LENSES. CONTINUE TO
RINSE FOR AT LEAST 10 MINUTES. GET MEDICAL ATTENTION.
INHALATION:
REMOVE VICTIM TO FRESH AIR AND KEEP AT REST IN A POSITION COMFORTABLE FOR
BREATHING. IF NOT BREATHING, IF BREATHING IS IRREGULAR OR IF RESPIRATORY
ARREST OCCURS, PROVIDE ARTIFICIAL RESPIRATION OR OXYGEN BY TRAINED
PERSONNEL. IT MAY BE DANGEROUS TO THE PERSON PROVIDING AID TO GIVE
MOUTH-TO-MOUTH RESUSCITATION. GET MEDICAL ATTENTION. IF UNCONSCIOUS, PLACE
IN RECOVERY POSITION AND GET MEDICAL ATTENTION IMMEDIATELY. MAINTAIN AN
OPEN AIRWAY. LOOSEN TIGHT CLOTHING SUCH AS A COLLAR, TIE, BELT OR
WAISTBAND.
SKIN CONTACT:
FLUSH CONTAMINATED SKIN WITH PLENTY OF WATER. REMOVE CONTAMINATED CLOTHING
AND SHOES. WASH CONTAMINATED CLOTHING THOROUGHLY WITH WATER BEFORE REMOVING
IT, OR WEAR GLOVES. CONTINUE TO RINSE FOR AT LEAST 10 MINUTES. GET MEDICAL
ATTENTION. WASH CLOTHING BEFORE REUSE. CLEAN SHOES THOROUGHLY BEFORE REUSE.
INGESTION:
WASH OUT MOUTH WITH WATER. REMOVE DENTURES IF ANY. REMOVE VICTIM TO FRESH
AIR AND KEEP AT REST IN A POSITION COMFORTABLE FOR BREATHING. IF MATERIAL
HAS BEEN SWALLOWED AND THE EXPOSED PERSON IS CONSCIOUS, GIVE SMALL
QUANTITIES OF WATER TO DRINK. STOP IF THE EXPOSED PERSON FEELS SICK AS
VOMITING MAY BE DANGEROUS. DO NOT INDUCE VOMITING UNLESS DIRECTED TO DO SO
BY MEDICAL PERSONNEL. IF VOMITING OCCURS, THE HEAD SHOULD BE KEPT LOW SO
THAT VOMIT DOES NOT ENTER THE LUNGS. GET MEDICAL ATTENTION. NEVER GIVE
ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. IF UNCONSCIOUS, PLACE IN
RECOVERY POSITION AND GET MEDICAL ATTENTION IMMEDIATELY. MAINTAIN AN OPEN
AIRWAY. LOOSEN TIGHT CLOTHING SUCH AS A COLLAR, TIE, BELT OR WAISTBAND.
MOST IMPORTANT SYMPTOMS/EFFECTS, ACUTE AND DELAYED:
POTENTIAL ACUTE HEALTH EFFECTS:
EYE CONTACT: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
INHALATION: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
SKIN CONTACT: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
INGESTION: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
OVER-EXPOSURE SIGNS/SYMPTOMS:
EYE CONTACT: NO SPECIFIC DATA.
INHALATION: NO SPECIFIC DATA.
SKIN CONTACT: NO SPECIFIC DATA.
INGESTION: NO SPECIFIC DATA.
INDICATION OF IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED, IF
NECESSARY:
NOTES TO PHYSICIAN:
TREAT SYMPTOMATICALLY. CONTACT POISON TREATMENT SPECIALIST IMMEDIATELY IF
LARGE QUANTITIES HAVE BEEN INGESTED OR INHALED.
SPECIFIC TREATMENTS: NO SPECIFIC TREATMENT.
PROTECTION OF FIRST-AIDERS:
NO ACTION SHALL BE TAKEN INVOLVING ANY PERSONAL RISK OR WITHOUT SUITABLE
TRAINING. IF IT IS SUSPECTED THAT FUMES ARE STILL PRESENT, THE RESCUER
SHOULD WEAR AN APPROPRIATE MASK OR SELF-CONTAINED BREATHING APPARATUS. IT
MAY BE DANGEROUS TO THE PERSON PROVIDING AID TO GIVE MOUTH-TO-MOUTH
RESUSCITATION. WASH CONTAMINATED CLOTHING THOROUGHLY WITH WATER BEFORE
REMOVING IT, OR WEAR GLOVES.
SEE TOXICOLOGICAL INFORMATION (SECTION 11)
| SECTION 5. FIRE-FIGHTING MEASURES | |
EXTINGUISHING MEDIA:
SUITABLE EXTINGUISHING MEDIA:
USE AN EXTINGUISHING AGENT SUITABLE FOR THE SURROUNDING FIRE.
UNSUITABLE EXTINGUISHING MEDIA: NONE KNOWN.
SPECIFIC HAZARDS ARISING FROM THE CHEMICAL:
IN A FIRE OR IF HEATED, A PRESSURE INCREASE WILL OCCUR AND THE CONTAINER
MAY BURST.
HAZARDOUS THERMAL DECOMPOSITION PRODUCTS:
DECOMPOSITION PRODUCTS MAY INCLUDE THE FOLLOWING MATERIALS:
CARBON DIOXIDE
CARBON MONOXIDE
METAL OXIDE/OXIDES
SPECIAL PROTECTIVE ACTIONS FOR FIRE-FIGHTERS:
PROMPTLY ISOLATE THE SCENE BY REMOVING ALL PERSONS FROM THE VICINITY OF THE
INCIDENT IF THERE IS A FIRE. NO ACTION SHALL BE TAKEN INVOLVING ANY
PERSONAL RISK OR WITHOUT SUITABLE TRAINING.
SPECIAL PROTECTIVE EQUIPMENT FOR FIRE-FIGHTERS:
FIRE-FIGHTERS SHOULD WEAR APPROPRIATE PROTECTIVE EQUIPMENT AND
SELF-CONTAINED BREATHING APPARATUS (SCBA) WITH A FULL FACE-PIECE OPERATED
IN POSITIVE PRESSURE MODE.
| SECTION 6. ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
FOR NON-EMERGENCY PERSONNEL:
NO ACTION SHALL BE TAKEN INVOLVING ANY PERSONAL RISK OR WITHOUT SUITABLE
TRAINING. EVACUATE SURROUNDING AREAS. KEEP UNNECESSARY AND UNPROTECTED
PERSONNEL FROM ENTERING. DO NOT TOUCH OR WALK THROUGH SPILLED MATERIAL.
AVOID BREATHING VAPOR OR MIST. PROVIDE ADEQUATE VENTILATION. WEAR
APPROPRIATE RESPIRATOR WHEN VENTILATION IS INADEQUATE. PUT ON APPROPRIATE
PERSONAL PROTECTIVE EQUIPMENT.
FOR EMERGENCY RESPONDERS:
IF SPECIALIZED CLOTHING IS REQUIRED TO DEAL WITH THE SPILLAGE, TAKE NOTE OF
ANY INFORMATION IN SECTION 8 ON SUITABLE AND UNSUITABLE MATERIALS. SEE ALSO
THE INFORMATION IN "FOR NON-EMERGENCY PERSONNEL".
ENVIRONMENTAL PRECAUTIONS:
AVOID DISPERSAL OF SPILLED MATERIAL AND RUNOFF AND CONTACT WITH SOIL,
WATERWAYS, DRAINS AND SEWERS. INFORM THE RELEVANT AUTHORITIES IF THE
PRODUCT HAS CAUSED ENVIRONMENTAL POLLUTION (SEWERS, WATERWAYS, SOIL OR
AIR).
METHODS AND MATERIALS FOR CONTAINMENT AND CLEANING UP:
SMALL SPILL:
STOP LEAK IF WITHOUT RISK. MOVE CONTAINERS FROM SPILL AREA. DILUTE WITH
WATER AND MOP UP IF WATER-SOLUBLE. ALTERNATIVELY, OR IF WATER-INSOLUBLE,
ABSORB WITH AN INERT DRY MATERIAL AND PLACE IN AN APPROPRIATE WASTE
DISPOSAL CONTAINER. DISPOSE OF VIA A LICENSED WASTE DISPOSAL CONTRACTOR.
LARGE SPILL:
STOP LEAK IF WITHOUT RISK. MOVE CONTAINERS FROM SPILL AREA. APPROACH
RELEASE FROM UPWIND. PREVENT ENTRY INTO SEWERS, WATER COURSES, BASEMENTS OR
CONFINED AREAS. WASH SPILLAGES INTO AN EFFLUENT TREATMENT PLANT OR PROCEED
AS FOLLOWS. CONTAIN AND COLLECT SPILLAGE WITH NON-COMBUSTIBLE, ABSORBENT
MATERIAL E.G. SAND, EARTH, VERMICULITE OR DIATOMACEOUS EARTH AND PLACE IN
CONTAINER FOR DISPOSAL ACCORDING TO LOCAL REGULATIONS (SEE SECTION 13).
DISPOSE OF VIA A LICENSED WASTE DISPOSAL CONTRACTOR. CONTAMINATED ABSORBENT
MATERIAL MAY POSE THE SAME HAZARD AS THE SPILLED PRODUCT.
NOTE:
SEE SECTION 1 FOR EMERGENCY CONTACT INFORMATION AND SECTION 13 FOR WASTE
DISPOSAL.
| SECTION 7. HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING:
PROTECTIVE MEASURES:
PUT ON APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT (SEE SECTION 8). AVOID
EXPOSURE - OBTAIN SPECIAL INSTRUCTIONS BEFORE USE. DO NOT HANDLE UNTIL ALL
SAFETY PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD. DO NOT GET IN EYES OR ON
SKIN OR CLOTHING. DO NOT BREATHE VAPOR OR MIST. DO NOT INGEST. IF DURING
NORMAL USE THE MATERIAL PRESENTS A RESPIRATORY HAZARD, USE ONLY WITH
ADEQUATE VENTILATION OR WEAR APPROPRIATE RESPIRATOR. KEEP IN THE ORIGINAL
CONTAINER OR AN APPROVED ALTERNATIVE MADE FROM A COMPATIBLE MATERIAL, KEPT
TIGHTLY CLOSED WHEN NOT IN USE. EMPTY CONTAINERS RETAIN PRODUCT RESIDUE AND
CAN BE HAZARDOUS. DO NOT REUSE CONTAINER.
ADVICE ON GENERAL OCCUPATIONAL HYGIENE:
EATING, DRINKING AND SMOKING SHOULD BE PROHIBITED IN AREAS WHERE THIS
MATERIAL IS HANDLED, STORED AND PROCESSED. WORKERS SHOULD WASH HANDS AND
FACE BEFORE EATING, DRINKING AND SMOKING. REMOVE CONTAMINATED CLOTHING AND
PROTECTIVE EQUIPMENT BEFORE ENTERING EATING AREAS. SEE ALSO SECTION 8 FOR
ADDITIONAL INFORMATION ON HYGIENE MEASURES.
CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES:
STORE IN ACCORDANCE WITH LOCAL REGULATIONS. STORE IN ORIGINAL CONTAINER
PROTECTED FROM DIRECT SUNLIGHT IN A DRY, COOL AND WELL-VENTILATED AREA,
AWAY FROM INCOMPATIBLE MATERIALS (SEE SECTION 10) AND FOOD AND DRINK. STORE
LOCKED UP. KEEP CONTAINER TIGHTLY CLOSED AND SEALED UNTIL READY FOR USE.
CONTAINERS THAT HAVE BEEN OPENED MUST BE CAREFULLY RESEALED AND KEPT
UPRIGHT TO PREVENT LEAKAGE. DO NOT STORE IN UNLABELED CONTAINERS. USE
APPROPRIATE CONTAINMENT TO AVOID ENVIRONMENTAL CONTAMINATION.
| SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
CONTROL PARAMETERS:
OCCUPATIONAL EXPOSURE LIMITS (OSHA UNITED STATES):
INGREDIENT NAME EXPOSURE LIMITS
CARBON BLACK NIOSH REL (UNITED STATES, 10/2013).
TWA: 3.5 MG/M3 10 HOURS.
TWA: 0.1 MG OF PAHS/CM3 10 HOURS.
OSHA PEL (UNITED STATES, 2/2013).
TWA: 3.5 MG/M3 8 HOURS.
ACGIH TLV (UNITED STATES, 3/2015).
TWA: 3 MG/M3 8 HOURS.
FORM: INHALABLE FRACTION
ETHANOL ACGIH TLV (UNITED STATES, 3/2015).
STEL: 1000 PPM 15 MINUTES.
NIOSH REL (UNITED STATES, 10/2013).
TWA: 1000 PPM 10 HOURS.
TWA: 1900 MG/M3 10 HOURS.
OSHA PEL (UNITED STATES, 2/2013).
TWA: 1000 PPM 8 HOURS.
TWA: 1900 MG/M3 8 HOURS.
CRYSTALLINE SILICA, RESPIRABLE OSHA PEL Z3 (UNITED STATES, 2/2013).
POWDER TWA: 250 MPPCF / (%SiO2+5) 8 HOURS.
FORM: RESPIRABLE
TWA: 10 MG/M3 / (%SiO2+2) 8 HOURS.
FORM: RESPIRABLE
ACGIH TLV (UNITED STATES, 3/2015).
TWA: 0.025 MG/M3 8 HOURS.
FORM: RESPIRABLE FRACTION
NIOSH REL (UNITED STATES, 10/2013).
TWA: 0.05 MG/M3 10 HOURS.
FORM: RESPIRABLE DUST
OCCUPATIONAL EXPOSURE LIMITS (CANADA):
INGREDIENT NAME EXPOSURE LIMITS
NONE.
APPROPRIATE ENGINEERING CONTROLS:
IF USER OPERATIONS GENERATE DUST, FUMES, GAS, VAPOR OR MIST, USE PROCESS
ENCLOSURES, LOCAL EXHAUST VENTILATION OR OTHER ENGINEERING CONTROLS TO KEEP
WORKER EXPOSURE TO AIRBORNE CONTAMINANTS BELOW ANY RECOMMENDED OR STATUTORY
LIMITS.
ENVIRONMENTAL EXPOSURE CONTROLS:
EMISSIONS FROM VENTILATION OR WORK PROCESS EQUIPMENT SHOULD BE CHECKED TO
ENSURE THEY COMPLY WITH THE REQUIREMENTS OF ENVIRONMENTAL PROTECTION
LEGISLATION. IN SOME CASES, FUME SCRUBBERS, FILTERS OR ENGINEERING
MODIFICATIONS TO THE PROCESS EQUIPMENT WILL BE NECESSARY TO REDUCE
EMISSIONS TO ACCEPTABLE LEVELS.
INDIVIDUAL PROTECTION MEASURES:
HYGIENE MEASURES:
WASH HANDS, FOREARMS AND FACE THOROUGHLY AFTER HANDLING CHEMICAL PRODUCTS,
BEFORE EATING, SMOKING AND USING THE LAVATORY AND AT THE END OF THE WORKING
PERIOD. APPROPRIATE TECHNIQUES SHOULD BE USED TO REMOVE POTENTIALLY
CONTAMINATED CLOTHING. WASH CONTAMINATED CLOTHING BEFORE REUSING. ENSURE
THAT EYEWASH STATIONS AND SAFETY SHOWERS ARE CLOSE TO THE WORKSTATION
LOCATION.
EYE/FACE PROTECTION:
SAFETY EYEWEAR COMPLYING WITH AN APPROVED STANDARD SHOULD BE USED WHEN A
RISK ASSESSMENT INDICATES THIS IS NECESSARY TO AVOID EXPOSURE TO LIQUID
SPLASHES, MISTS, GASES OR DUSTS. IF CONTACT IS POSSIBLE, THE FOLLOWING
PROTECTION SHOULD BE WORN, UNLESS THE ASSESSMENT INDICATES A HIGHER DEGREE
OF PROTECTION: SAFETY GLASSES WITH SIDE-SHIELDS.
SKIN PROTECTION:
HAND PROTECTION:
CHEMICAL-RESISTANT, IMPERVIOUS GLOVES COMPLYING WITH AN APPROVED STANDARD
SHOULD BE WORN AT ALL TIMES WHEN HANDLING CHEMICAL PRODUCTS IF A RISK
ASSESSMENT INDICATES THIS IS NECESSARY. CONSIDERING THE PARAMETERS
SPECIFIED BY THE GLOVE MANUFACTURER, CHECK DURING USE THAT THE GLOVES ARE
STILL RETAINING THEIR PROTECTIVE PROPERTIES. IT SHOULD BE NOTED THAT THE
TIME TO BREAKTHROUGH FOR ANY GLOVE MATERIAL MAY BE DIFFERENT FOR DIFFERENT
GLOVE MANUFACTURERS. IN THE CASE OF MIXTURES, CONSISTING OF SEVERAL
SUBSTANCES, THE PROTECTION TIME OF THE GLOVES CANNOT BE ACCURATELY
ESTIMATED.
BODY PROTECTION:
PERSONAL PROTECTIVE EQUIPMENT FOR THE BODY SHOULD BE SELECTED BASED ON THE
TASK BEING PERFORMED AND THE RISKS INVOLVED AND SHOULD BE APPROVED BY A
SPECIALIST BEFORE HANDLING THIS PRODUCT.
OTHER SKIN PROTECTION:
APPROPRIATE FOOTWEAR AND ANY ADDITIONAL SKIN PROTECTION MEASURES SHOULD BE
SELECTED BASED ON THE TASK BEING PERFORMED AND THE RISKS INVOLVED AND
SHOULD BE APPROVED BY A SPECIALIST BEFORE HANDLING THIS PRODUCT.
RESPIRATORY PROTECTION:
BASED ON THE HAZARD AND POTENTIAL FOR EXPOSURE, SELECT A RESPIRATOR THAT
MEETS THE APPROPRIATE STANDARD OR CERTIFICATION. RESPIRATORS MUST BE USED
ACCORDING TO A RESPIRATORY PROTECTION PROGRAM TO ENSURE PROPER FITTING,
TRAINING, AND OTHER IMPORTANT ASPECTS OF USE.
| SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE:
PHYSICAL STATE: LIQUID.
COLOR: BLACK.
ODOR: NOT AVAILABLE.
ODOR THRESHOLD: NOT AVAILABLE.
PH: 9.5
MELTING POINT: NOT AVAILABLE.
BOILING POINT: 77 DEG. C (170.6 DEG. F)
FLASH POINT:
CLOSED CUP: >93.3 DEG. C (>199.9 DEG. F)
EVAPORATION RATE: 1.6 (BUTYL ACETATE = 1)
FLAMMABILITY (SOLID, GAS): NOT AVAILABLE.
LOWER AND UPPER EXPLOSIVE (FLAMMABLE) LIMITS:
LOWER: 3.3%
UPPER: 19%
VAPOR PRESSURE: 0.78 KPA (5.866 MMHg) [AT 20 DEG. C]
VAPOR DENSITY: 1 [AIR = 1]
RELATIVE DENSITY: 1.44
SOLUBILITY: NOT AVAILABLE.
PARTITION COEFFICIENT N-OCTANOL/WATER: NOT AVAILABLE.
AUTO-IGNITION TEMPERATURE: NOT AVAILABLE.
DECOMPOSITION TEMPERATURE: NOT AVAILABLE.
VISCOSITY:
KINEMATIC (ROOM TEMPERATURE): >0.205 CM2/S (>20.5 CST)
KINEMATIC (40 DEG. C (104 DEG. F)): >0.205 CM2/S (>20.5 CST)
MOLECULAR WEIGHT: NOT APPLICABLE.
AEROSOL PRODUCT:
HEAT OF COMBUSTION: 1.176 KJ/G
| SECTION 10. STABILITY AND REACTIVITY | |
REACTIVITY:
NO SPECIFIC TEST DATA RELATED TO REACTIVITY AVAILABLE FOR THIS PRODUCT OR
ITS INGREDIENTS.
CHEMICAL STABILITY: THE PRODUCT IS STABLE.
POSSIBILITY OF HAZARDOUS REACTIONS:
UNDER NORMAL CONDITIONS OF STORAGE AND USE, HAZARDOUS REACTIONS WILL NOT
OCCUR.
CONDITIONS TO AVOID: NO SPECIFIC DATA.
INCOMPATIBLE MATERIALS: NO SPECIFIC DATA.
HAZARDOUS DECOMPOSITION PRODUCTS:
UNDER NORMAL CONDITIONS OF STORAGE AND USE, HAZARDOUS DECOMPOSITION
PRODUCTS SHOULD NOT BE PRODUCED.
| SECTION 11. TOXICOLOGICAL INFORMATION | |
INFORMATION ON TOXICOLOGICAL EFFECTS:
ACUTE TOXICITY:
PRODUCT/INGREDIENT RESULT SPECIES DOSE EXPOSURE
NAME
CARBON BLACK LD50 ORAL RAT >15400 MG/KG
ETHANOL LC50 INHALATION VAPOR RAT 124700 MG/M3 4 HOURS
LD50 ORAL RAT 7 G/KG
IRRITATION/CORROSION:
PRODUCT/ RESULT SPECIES SCORE EXPOSURE OBSERVATION
INGREDIENT
NAME
ETHANOL EYES: RABBIT 24 HOURS
MILD IRRITANT 500 MILLIGRAMS
EYES: RABBIT 0.066666667
MODERATE MINUTES
IRRITANT 100 MILLIGRAMS
EYES: RABBIT 100 MICROLITERS
MODERATE
IRRITANT
EYES: RABBIT 500 MILLIGRAMS
SEVERE
IRRITANT
SKIN: RABBIT 400 MILLIGRAMS
MILD IRRITANT
SKIN: RABBIT 24 HOURS
MODERATE 20 MILLIGRAMS
IRRITANT
SENSITIZATION: NOT AVAILABLE.
MUTAGENICITY: NOT AVAILABLE.
CARCINOGENICITY: NOT AVAILABLE.
CLASSIFICATION:
PRODUCT/INGREDIENT NAME OSHA IARC NTP
CARBON BLACK 2B
ETHANOL 1
CRYSTALLINE SILICA, 1 KNOWN TO BE A HUMAN CARCINOGEN.
RESPIRABLE POWDER
REPRODUCTIVE TOXICITY: NOT AVAILABLE.
TERATOGENICITY: NOT AVAILABLE.
SPECIFIC TARGET ORGAN TOXICITY (SINGLE EXPOSURE):
NAME CATEGORY ROUTE OF TARGET ORGANS
EXPOSURE
ETHANOL CATEGORY 3 NOT APPLICABLE. RESPIRATORY TRACT
IRRITATION AND
NARCOTIC EFFECTS
SPECIFIC TARGET ORGAN TOXICITY (REPEATED EXPOSURE):
NAME CATEGORY ROUTE OF TARGET ORGANS
EXPOSURE
ETHANOL CATEGORY 2 NOT DETERMINED NOT DETERMINED
CRYSTALLINE SILICA, CATEGORY 1 INHALATION NOT DETERMINED
RESPIRABLE POWDER
ASPIRATION HAZARD: NOT AVAILABLE.
INFORMATION ON THE LIKELY ROUTES OF EXPOSURE: NOT AVAILABLE.
POTENTIAL ACUTE HEALTH EFFECTS:
EYE CONTACT: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
INHALATION: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
SKIN CONTACT: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
INGESTION: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
SYMPTOMS RELATED TO THE PHYSICAL, CHEMICAL AND TOXICOLOGICAL
CHARACTERISTICS:
EYE CONTACT: NO SPECIFIC DATA.
INHALATION: NO SPECIFIC DATA.
SKIN CONTACT: NO SPECIFIC DATA.
INGESTION: NO SPECIFIC DATA.
DELAYED AND IMMEDIATE EFFECTS AND ALSO CHRONIC EFFECTS FROM SHORT AND LONG
TERM EXPOSURE:
SHORT TERM EXPOSURE:
POTENTIAL IMMEDIATE EFFECTS: NOT AVAILABLE.
POTENTIAL DELAYED EFFECTS: NOT AVAILABLE.
LONG TERM EXPOSURE:
POTENTIAL IMMEDIATE EFFECTS: NOT AVAILABLE.
POTENTIAL DELAYED EFFECTS: NOT AVAILABLE.
POTENTIAL CHRONIC HEALTH EFFECTS: NOT AVAILABLE.
GENERAL: MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE.
CARCINOGENICITY:
MAY CAUSE CANCER. RISK OF CANCER DEPENDS ON DURATION AND LEVEL OF EXPOSURE.
MUTAGENICITY: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
TERATOGENICITY: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
DEVELOPMENTAL EFFECTS: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
FERTILITY EFFECTS: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
NUMERICAL MEASURES OF TOXICITY:
ACUTE TOXICITY ESTIMATES: NOT AVAILABLE.
| SECTION 12. ECOLOGICAL INFORMATION | |
TOXICITY:
PRODUCT/INGREDIENT RESULT SPECIES EXPOSURE
NAME
ETHANOL ACUTE EC50: ALGAE - ULVA PERTUSA 96 HOURS
17.921 MG/L
MARINE WATER
ACUTE EC50: DAPHNIA - DAPHNIA MAGNA 48 HOURS
2000 (MICRO)G/L
FRESH WATER
ACUTE LC50: CRUSTACEANS - ARTEMIA 48 HOURS
25500 (MICRO)G/L FRANCISCANA - LARVAE
MARINE WATER
ACUTE LC50: FISH - ONCORHYNCHUS 4 DAYS
42000 (MICRO)G/L MYKISS
FRESH WATER
CHRONIC NOEC: ALGAE - ULVA PERTUSA 96 HOURS
4.995 MG/L
MARINE WATER
CHRONIC NOEC: DAPHNIA - DAPHNIA 21 DAYS
100 UL/L MAGNA - NEONATE
FRESH WATER
CHRONIC NOEC: FISH - GAMBUSIA 12 WEEKS
0.375 UL/L HOLBROOKI - LARVAE
FRESH WATER
PERSISTENCE AND DEGRADABILITY:
PRODUCT/INGREDIENT NAME AQUATIC HALF-LIFE PHOTOLYSIS BIODEGRADABILITY
ETHANOL READILY
BIOACCUMULATIVE POTENTIAL: NOT AVAILABLE.
MOBILITY IN SOIL:
SOIL/WATER PARTITION COEFFICIENT (KOC): NOT AVAILABLE.
OTHER ADVERSE EFFECTS: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
| SECTION 13. DISPOSAL CONSIDERATIONS | |
DISPOSAL METHODS:
THE GENERATION OF WASTE SHOULD BE AVOIDED OR MINIMIZED WHEREVER POSSIBLE.
DISPOSAL OF THIS PRODUCT, SOLUTIONS AND ANY BY-PRODUCTS SHOULD AT ALL TIMES
COMPLY WITH THE REQUIREMENTS OF ENVIRONMENTAL PROTECTION AND WASTE DISPOSAL
LEGISLATION AND ANY REGIONAL LOCAL AUTHORITY REQUIREMENTS. DISPOSE OF
SURPLUS AND NON-RECYCLABLE PRODUCTS VIA A LICENSED WASTE DISPOSAL
CONTRACTOR. WASTE SHOULD NOT BE DISPOSED OF UNTREATED TO THE SEWER UNLESS
FULLY COMPLIANT WITH THE REQUIREMENTS OF ALL AUTHORITIES WITH JURISDICTION.
WASTE PACKAGING SHOULD BE RECYCLED. INCINERATION OR LANDFILL SHOULD ONLY BE
CONSIDERED WHEN RECYCLING IS NOT FEASIBLE. THIS MATERIAL AND ITS CONTAINER
MUST BE DISPOSED OF IN A SAFE WAY. CARE SHOULD BE TAKEN WHEN HANDLING
EMPTIED CONTAINERS THAT HAVE NOT BEEN CLEANED OR RINSED OUT. EMPTY
CONTAINERS OR LINERS MAY RETAIN SOME PRODUCT RESIDUES. AVOID DISPERSAL OF
SPILLED MATERIAL AND RUNOFF AND CONTACT WITH SOIL, WATERWAYS, DRAINS AND
SEWERS.
| SECTION 14. TRANSPORT INFORMATION | |
DOT TDG MEXICO
CLASSIFICATION CLASSIFICATION CLASSIFICATION
UN NUMBER NOT REGULATED. NOT REGULATED. NOT REGULATED.
UN PROPER SHIPPING NAME
TRANSPORT HAZARD
CLASS(ES)
PACKING GROUP
ENVIRONMENTAL HAZARDS NO. NO. NO.
ADDITIONAL INFORMATION
IATA IMDG
UN NUMBER NOT REGULATED. NOT REGULATED.
UN PROPER SHIPPING NAME
TRANSPORT HAZARD CLASS(ES)
PACKING GROUP
ENVIRONMENTAL HAZARDS NO. NO.
ADDITIONAL INFORMATION
SPECIAL PRECAUTIONS FOR USER:
MULTI-MODAL SHIPPING DESCRIPTIONS ARE PROVIDED FOR INFORMATIONAL PURPOSES
AND DO NOT CONSIDER CONTAINER SIZES. THE PRESENCE OF A SHIPPING DESCRIPTION
FOR A PARTICULAR MODE OF TRANSPORT (SEA, AIR, ETC.), DOES NOT INDICATE THAT
THE PRODUCT IS PACKAGED SUITABLY FOR THAT MODE OF TRANSPORT. ALL PACKAGING
MUST BE REVIEWED FOR SUITABILITY PRIOR TO SHIPMENT, AND COMPLIANCE WITH THE
APPLICABLE REGULATIONS IS THE SOLE RESPONSIBILITY OF THE PERSON OFFERING
THE PRODUCT FOR TRANSPORT. PEOPLE LOADING AND UNLOADING DANGEROUS GOODS
MUST BE TRAINED ON ALL OF THE RISKS DERIVING FROM THE SUBSTANCES AND ON ALL
ACTIONS IN CASE OF EMERGENCY SITUATIONS.
TRANSPORT IN BULK ACCORDING TO ANNEX II OF MARPOL AND THE IBC CODE:
NOT AVAILABLE.
PROPER SHIPPING NAME: NOT AVAILABLE.
SHIP TYPE: NOT AVAILABLE.
POLLUTION CATEGORY: NOT AVAILABLE.
| SECTION 15. REGULATORY INFORMATION | |
SARA 313:
SARA 313 (40 CFR 372.45) SUPPLIER NOTIFICATION CAN BE FOUND ON THE
ENVIRONMENTAL DATA SHEET.
CALIFORNIA PROP. 65:
WARNING:
THIS PRODUCT CONTAINS CHEMICALS KNOWN TO THE STATE OF CALIFORNIA TO CAUSE
CANCER AND BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM.
| SECTION 16. OTHER INFORMATION | |
HAZARDOUS MATERIAL INFORMATION SYSTEM (U.S.A.):
HEALTH 2*
FLAMMABILITY 0
PHYSICAL HAZARDS 0
THE CUSTOMER IS RESPONSIBLE FOR DETERMINING THE PPE CODE FOR THIS MATERIAL.
CAUTION:
HMIS(R*) RATINGS ARE BASED ON A 0-4 RATING SCALE, WITH 0 REPRESENTING
MINIMAL HAZARDS OR RISKS, AND 4 REPRESENTING SIGNIFICANT HAZARDS OR RISKS
ALTHOUGH HMIS(R*) RATINGS ARE NOT REQUIRED ON SDSS UNDER 29 CFR 1910.1200,
THE PREPARER MAY CHOOSE TO PROVIDE THEM. HMIS(R*) RATINGS ARE TO BE USED
WITH A FULLY IMPLEMENTED HMIS(R*) PROGRAM. HMIS(R*) IS A REGISTERED MARK OF
THE NATIONAL PAINT & COATINGS ASSOCIATION (NPCA). HMIS(R*) MATERIALS MAY BE
PURCHASED EXCLUSIVELY FROM J. J. KELLER (800) 327-6868.
PROCEDURE USED TO DERIVE THE CLASSIFICATION:
CLASSIFICATION JUSTIFICATION
CARCINOGENICITY - CATEGORY 1A CALCULATION METHOD
SPECIFIC TARGET ORGAN TOXICITY (REPEATED CALCULATION METHOD
EXPOSURE) - CATEGORY 2
HISTORY:
DATE OF PRINTING: 6/20/2016
DATE OF ISSUE/DATE OF REVISION: 6/20/2016
DATE OF PREVIOUS ISSUE: 6/4/2016
VERSION: 3.01
KEY TO ABBREVIATIONS:
ATE: ACUTE TOXICITY ESTIMATE
BCF: BIOCONCENTRATION FACTOR
GHS:
GLOBALLY HARMONIZED SYSTEM OF CLASSIFICATION AND LABELLING OF CHEMICALS
IATA: INTERNATIONAL AIR TRANSPORT ASSOCIATION
IBC: INTERMEDIATE BULK CONTAINER
IMDG: INTERNATIONAL MARITIME DANGEROUS GOODS
LOGPOW: LOGARITHM OF THE OCTANOL/WATER PARTITION COEFFICIENT
MARPOL:
INTERNATIONAL CONVENTION FOR THE PREVENTION OF POLLUTION FROM SHIPS, 1973
AS MODIFIED BY THE PROTOCOL OF 1978. ("MARPOL" = MARINE POLLUTION)
UN: UNITED NATIONS
NOTICE TO READER:
IT IS RECOMMENDED THAT EACH CUSTOMER OR RECIPIENT OF THIS SAFETY DATA SHEET
(SDS) STUDY IT CAREFULLY AND CONSULT RESOURCES, AS NECESSARY OR
APPROPRIATE, TO BECOME AWARE OF AND UNDERSTAND THE DATA CONTAINED IN THIS
SDS AND ANY HAZARDS ASSOCIATED WITH THE PRODUCT. THIS INFORMATION IS
PROVIDED IN GOOD FAITH AND BELIEVED TO BE ACCURATE AS OF THE EFFECTIVE DATE
HEREIN. HOWEVER, NO WARRANTY, EXPRESS OR IMPLIED, IS GIVEN. THE INFORMATION
PRESENTED HERE APPLIES ONLY TO THE PRODUCT AS SHIPPED. THE ADDITION OF ANY
MATERIAL CAN CHANGE THE COMPOSITION, HAZARDS AND RISKS OF THE PRODUCT.
PRODUCTS SHALL NOT BE REPACKAGED, MODIFIED, OR TINTED EXCEPT AS
SPECIFICALLY INSTRUCTED BY SHERWIN-WILLIAMS, INCLUDING BUT NOT LIMITED TO
THE INCORPORATION OF NON SHERWIN-WILLIAMS PRODUCTS OR THE USE OR ADDITION
OF PRODUCTS IN PROPORTIONS NOT SPECIFIED BY SHERWIN-WILLIAMS. REGULATORY
REQUIREMENTS ARE SUBJECT TO CHANGE AND MAY DIFFER BETWEEN VARIOUS LOCATIONS
AND JURISDICTIONS. THE CUSTOMER/BUYER/USER IS RESPONSIBLE TO ENSURE THAT
HIS ACTIVITIES COMPLY WITH ALL COUNTRY, FEDERAL, STATE, PROVINCIAL OR LOCAL
LAWS. THE CONDITIONS FOR USE OF THE PRODUCT ARE NOT UNDER THE CONTROL OF
THE MANUFACTURER; THE CUSTOMER/BUYER/USER IS RESPONSIBLE TO DETERMINE THE
CONDITIONS NECESSARY FOR THE SAFE USE OF THIS PRODUCT. THE
CUSTOMER/BUYER/USER SHOULD NOT USE THE PRODUCT FOR ANY PURPOSE OTHER THAN
THE PURPOSE SHOWN IN THE APPLICABLE SECTION OF THIS SDS WITHOUT FIRST
REFERRING TO THE SUPPLIER AND OBTAINING WRITTEN HANDLING INSTRUCTIONS. DUE
TO THE PROLIFERATION OF SOURCES FOR INFORMATION SUCH AS
MANUFACTURER-SPECIFIC SDS, THE MANUFACTURER CANNOT BE RESPONSIBLE FOR SDSS
OBTAINED FROM ANY OTHER SOURCE.