| Common Name: | HYDURANCE AW FLUID 46 |
| Manufacturer: | CITGO PETROLEUM |
| SDS Revision Date: | 3/7/2016 |
| SDS Format: | GHS-US |
| Item Number(s): | 52XN96 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
SAFETY DATA SHEET
CITGO HYDURANCE(TM) AW FLUID 46
CITGO(R*)
| SECTION 1. IDENTIFICATION |  |
GHS PRODUCT IDENTIFIER: CITGO HYDURANCE(TM) AW FLUID 46
SYNONYMS: HYDRAULIC FLUID
CODE: 633608001
SUPPLIER'S DETAILS:
CITGO PETROLEUM CORPORATION
P.O. BOX 4689
HOUSTON, TX 77210
SDSVEND@CITGO.COM
EMERGENCY TELEPHONE NUMBER:
TECHNICAL CONTACT: (800) 248-4684
MEDICAL EMERGENCY: (832) 486-4700
CHEMTREC EMERGENCY: (800) 424-9300 (UNITED STATES ONLY)
| SECTION 2. HAZARDS IDENTIFICATION | |
OSHA/HCS STATUS:
WHILE THIS MATERIAL IS NOT CONSIDERED HAZARDOUS BY THE OSHA HAZARD
COMMUNICATION STANDARD (29 CFR 1910.1200), THIS SDS CONTAINS VALUABLE
INFORMATION CRITICAL TO THE SAFE HANDLING AND PROPER USE OF THE PRODUCT.
THIS SDS SHOULD BE RETAINED AND AVAILABLE FOR EMPLOYEES AND OTHER USERS
OF THIS PRODUCT.
CLASSIFICATION OF THE SUBSTANCE OR MIXTURE: NOT CLASSIFIED.
GHS LABEL ELEMENTS:
SIGNAL WORD: WARNING
HAZARD STATEMENTS:
INJECTION UNDER THE SKIN CAN CAUSE SEVERE INJURY.
MOST DAMAGE OCCURS IN THE FIRST FEW HOURS.
INITIAL SYMPTOMS MAY BE MINIMAL.
PRECAUTIONARY STATEMENTS:
GENERAL: AVOID CONTACT WITH EYES, SKIN AND CLOTHING.
IF IN EYES: RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES.
IF SWALLOWED:
DO NOT INDUCE VOMITING. AFTER HANDLING, ALWAYS WASH HANDS THOROUGHLY WITH
SOAP AND WATER. IF YOU FEEL UNWELL, SEEK MEDICAL ATTENTION AND SHOW THE
LABEL WHEN POSSIBLE. KEEP OUT OF REACH OF CHILDREN.
PREVENTION: NOT APPLICABLE.
RESPONSE: NOT APPLICABLE.
STORAGE:
STORE IN A DRY PLACE AND/OR IN CLOSED CONTAINER. STORE IN ACCORDANCE WITH
ALL LOCAL, REGIONAL, NATIONAL AND INTERNATIONAL REGULATIONS.
DISPOSAL:
DISPOSE OF CONTENTS AND CONTAINER IN ACCORDANCE WITH ALL LOCAL, REGIONAL,
NATIONAL AND INTERNATIONAL REGULATIONS.
HAZARDS NOT OTHERWISE CLASSIFIED:
INJECTION OF PETROLEUM HYDROCARBONS REQUIRES IMMEDIATE MEDICAL ATTENTION.
| SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
SUBSTANCE/MIXTURE: MIXTURE
OTHER MEANS OF IDENTIFICATION: HYDRAULIC FLUID
CAS NUMBER/OTHER IDENTIFIERS:
CAS NUMBER: NOT APPLICABLE.
ANY CONCENTRATION SHOWN AS A RANGE IS TO PROTECT CONFIDENTIALITY OR IS DUE
TO PROCESS VARIATION.
THERE ARE NO INGREDIENTS PRESENT WHICH, WITHIN THE CURRENT KNOWLEDGE OF THE
SUPPLIER AND IN THE CONCENTRATIONS APPLICABLE, ARE CLASSIFIED AS HAZARDOUS
TO HEALTH OR THE ENVIRONMENT AND HENCE REQUIRE REPORTING IN THIS SECTION.
OCCUPATIONAL EXPOSURE LIMITS, IF AVAILABLE, ARE LISTED IN SECTION 8.
| SECTION 4. FIRST AID MEASURES | |
DESCRIPTION OF NECESSARY FIRST AID MEASURES:
EYE CONTACT:
IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER, OCCASIONALLY LIFTING THE UPPER
AND LOWER EYELIDS. CHECK FOR AND REMOVE ANY CONTACT LENSES. GET MEDICAL
ATTENTION IF IRRITATION OCCURS.
INHALATION:
REMOVE VICTIM TO FRESH AIR AND KEEP AT REST IN A POSITION COMFORTABLE FOR
BREATHING. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR.
SKIN CONTACT:
FLUSH CONTAMINATED SKIN WITH PLENTY OF WATER. REMOVE CONTAMINATED CLOTHING
AND SHOES. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR.
INGESTION:
WASH OUT MOUTH WITH WATER. REMOVE VICTIM TO FRESH AIR AND KEEP AT REST IN A
POSITION COMFORTABLE FOR BREATHING. DO NOT INDUCE VOMITING UNLESS DIRECTED
TO DO SO BY MEDICAL PERSONNEL. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR.
MOST IMPORTANT SYMPTOMS/EFFECTS, ACUTE:
POTENTIAL ACUTE HEALTH EFFECTS:
EYE CONTACT: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
INHALATION: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
SKIN CONTACT:
INJECTION OF PRESSURIZED HYDROCARBONS CAN CAUSE SEVERE PERMANENT TISSUE
DAMAGE. INITIAL SYMPTOMS MAY BE MINOR.
INGESTION: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
OVER-EXPOSURE SIGNS/SYMPTOMS:
EYE CONTACT: NO SPECIFIC DATA.
INHALATION: NO SPECIFIC DATA.
SKIN CONTACT: NO SPECIFIC DATA.
INGESTION: NO SPECIFIC DATA.
INDICATION OF IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED, IF
NECESSARY:
NOTES TO PHYSICIAN:
TREAT SYMPTOMATICALLY. CONTACT POISON TREATMENT SPECIALIST IMMEDIATELY IF
LARGE QUANTITIES HAVE BEEN INGESTED OR INHALED.
SPECIFIC TREATMENTS: TREAT SYMPTOMATICALLY AND SUPPORTIVELY.
PROTECTION OF FIRST-AIDERS:
NO ACTION SHALL BE TAKEN INVOLVING ANY PERSONAL RISK OR WITHOUT SUITABLE
TRAINING.
SEE TOXICOLOGICAL INFORMATION (SECTION 11)
| SECTION 5. FIRE-FIGHTING MEASURES | |
SPECIFIC HAZARDS ARISING FROM THE CHEMICAL:
IN A FIRE OR IF HEATED, A PRESSURE INCREASE WILL OCCUR AND THE CONTAINER
MAY BURST.
EXTINGUISHING MEDIA:
SUITABLE EXTINGUISHING MEDIA:
USE AN EXTINGUISHING AGENT SUITABLE FOR THE SURROUNDING FIRE.
UNSUITABLE EXTINGUISHING MEDIA: NONE KNOWN.
HAZARDOUS THERMAL DECOMPOSITION PRODUCTS:
DECOMPOSITION PRODUCTS MAY INCLUDE THE FOLLOWING MATERIALS:
CARBON DIOXIDE
CARBON MONOXIDE
SPECIAL PROTECTIVE ACTIONS FOR FIRE-FIGHTERS:
PROMPTLY ISOLATE THE SCENE BY REMOVING ALL PERSONS FROM THE VICINITY OF THE
INCIDENT IF THERE IS A FIRE. NO ACTION SHALL BE TAKEN INVOLVING ANY PERSONAL
RISK OR WITHOUT SUITABLE TRAINING.
SPECIAL PROTECTIVE EQUIPMENT FOR FIRE-FIGHTERS:
FIRE-FIGHTERS SHOULD WEAR APPROPRIATE PROTECTIVE EQUIPMENT AND
SELF-CONTAINED
BREATHING APPARATUS (SCBA) WITH A FULL FACE-PIECE OPERATED IN POSITIVE
PRESSURE MODE.
| SECTION 6. ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
FOR NON-EMERGENCY PERSONNEL:
NO ACTION SHALL BE TAKEN INVOLVING ANY PERSONAL RISK OR WITHOUT SUITABLE
TRAINING. EVACUATE SURROUNDING AREAS. KEEP UNNECESSARY AND UNPROTECTED
PERSONNEL FROM ENTERING. DO NOT TOUCH OR WALK THROUGH SPILLED MATERIAL.
PUT ON APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT.
FOR EMERGENCY RESPONDERS:
IF SPECIALIZED CLOTHING IS REQUIRED TO DEAL WITH THE SPILLAGE, TAKE NOTE OF
ANY INFORMATION IN SECTION 8 ON SUITABLE AND UNSUITABLE MATERIALS. SEE ALSO
THE INFORMATION IN "FOR NON-EMERGENCY PERSONNEL".
ENVIRONMENTAL PRECAUTIONS:
AVOID DISPERSAL OF SPILLED MATERIAL AND RUNOFF AND CONTACT WITH SOIL,
WATERWAYS, DRAINS AND SEWERS. INFORM THE RELEVANT AUTHORITIES IF THE
PRODUCT HAS CAUSED ENVIRONMENTAL POLLUTION (SEWERS, WATERWAYS, SOIL OR AIR).
METHODS AND MATERIALS FOR CONTAINMENT AND CLEANING UP:
SMALL SPILL:
STOP LEAK IF WITHOUT RISK. MOVE CONTAINERS FROM SPILL AREA. ABSORB WITH AN
INERT MATERIAL AND PLACE IN AN APPROPRIATE WASTE DISPOSAL CONTAINER. DISPOSE
OF VIA A LICENSED WASTE DISPOSAL CONTRACTOR.
LARGE SPILL:
STOP LEAK IF WITHOUT RISK. MOVE CONTAINERS FROM SPILL AREA. PREVENT ENTRY
INTO SEWERS, WATER COURSES, BASEMENTS OR CONFINED AREAS. WASH SPILLAGES INTO
AN EFFLUENT TREATMENT PLANT OR PROCEED AS FOLLOWS. CONTAIN AND COLLECT
SPILLAGE WITH NON-COMBUSTIBLE, ABSORBENT MATERIAL E.G. SAND, EARTH,
VERMICULITE OR DIATOMACEOUS EARTH AND PLACE IN CONTAINER FOR DISPOSAL
ACCORDING TO LOCAL REGULATIONS (SEE SECTION 13). DISPOSE OF VIA A LICENSED
WASTE DISPOSAL CONTRACTOR.
NOTE:
SEE SECTION 1 FOR EMERGENCY CONTACT INFORMATION AND SECTION 13 FOR WASTE
DISPOSAL.
| SECTION 7. HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING:
PROTECTIVE MEASURES:
PUT ON APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT (SEE SECTION 8).
ADVICE ON GENERAL OCCUPATIONAL HYGIENE:
EATING, DRINKING AND SMOKING SHOULD BE PROHIBITED IN AREAS WHERE THIS
MATERIAL IS HANDLED, STORED AND PROCESSED. WORKERS SHOULD WASH HANDS AND
FACE BEFORE EATING, DRINKING AND SMOKING. REMOVE CONTAMINATED CLOTHING AND
PROTECTIVE EQUIPMENT BEFORE ENTERING EATING AREAS. SEE ALSO SECTION 8 FOR
ADDITIONAL INFORMATION ON HYGIENE MEASURES.
CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES:
STORE IN ACCORDANCE WITH LOCAL REGULATIONS. STORE IN ORIGINAL CONTAINER
PROTECTED FROM DIRECT SUNLIGHT IN A DRY, COOL AND WELL-VENTILATED AREA, AWAY
FROM INCOMPATIBLE MATERIALS (SEE SECTION 10) AND FOOD AND DRINK. KEEP
CONTAINER TIGHTLY CLOSED AND SEALED UNTIL READY FOR USE. CONTAINERS THAT
HAVE BEEN OPENED MUST BE CAREFULLY RESEALED AND KEPT UPRIGHT TO PREVENT
LEAKAGE. DO NOT STORE IN UNLABELED CONTAINERS. USE APPROPRIATE CONTAINMENT
TO AVOID ENVIRONMENTAL CONTAMINATION.
BULK STORAGE CONDITIONS:
MAINTAIN ALL STORAGE TANKS IN ACCORDANCE WITH APPLICABLE REGULATIONS. USE
NECESSARY CONTROLS TO MONITOR TANK INVENTORIES. INSPECT ALL STORAGE TANKS ON
A PERIODIC BASIS. TEST TANKS AND ASSOCIATED PIPING FOR TIGHTNESS. MAINTAIN
THE AUTOMATIC LEAK DETECTION DEVICES TO ASSURE PROPER WORKING CONDITION.
| SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
CONTROL PARAMETERS:
OCCUPATIONAL EXPOSURE LIMITS: NONE IDENTIFIED.
APPROPRIATE ENGINEERING CONTROLS:
GOOD GENERAL VENTILATION SHOULD BE SUFFICIENT TO CONTROL WORKER EXPOSURE TO
AIRBORNE CONTAMINANTS.
ENVIRONMENTAL EXPOSURE CONTROLS:
EMISSIONS FROM VENTILATION OR WORK PROCESS EQUIPMENT SHOULD BE CHECKED TO
ENSURE THEY COMPLY WITH THE REQUIREMENTS OF ENVIRONMENTAL PROTECTION
LEGISLATION. IN SOME CASES, VAPOR CONTROLS, FILTERS OR ENGINEERING
MODIFICATIONS TO THE PROCESS EQUIPMENT WILL BE NECESSARY TO REDUCE EMISSIONS
TO ACCEPTABLE LEVELS.
INDIVIDUAL PROTECTION MEASURES:
HYGIENE MEASURES:
WASH HANDS, FOREARMS AND FACE THOROUGHLY AFTER HANDLING CHEMICAL PRODUCTS,
BEFORE EATING, SMOKING AND USING THE LAVATORY AND AT THE END OF THE WORKING
PERIOD. APPROPRIATE TECHNIQUES SHOULD BE USED TO REMOVE POTENTIALLY
CONTAMINATED CLOTHING. WASH CONTAMINATED CLOTHING BEFORE REUSING. ENSURE
THAT EYEWASH STATIONS AND SAFETY SHOWERS ARE CLOSE TO THE WORKSTATION
LOCATION.
EYE/FACE PROTECTION:
SAFETY GLASSES EQUIPPED WITH SIDE SHIELDS ARE RECOMMENDED AS MINIMUM
PROTECTION IN INDUSTRIAL SETTINGS. IF CONTACT IS POSSIBLE, THE FOLLOWING
PROTECTION SHOULD BE WORN, UNLESS THE ASSESSMENT INDICATES A HIGHER DEGREE
OF PROTECTION: CHEMICAL SPLASH GOGGLES. SAFETY EYEWEAR COMPLYING WITH AN
APPROVED STANDARD SHOULD BE USED WHEN A RISK ASSESSMENT INDICATES THIS IS
NECESSARY TO AVOID EXPOSURE TO LIQUID SPLASHES, MISTS, GASES OR DUSTS. IF
INHALATION HAZARDS EXIST, A FULL-FACE RESPIRATOR MAY BE REQUIRED INSTEAD.
SKIN PROTECTION:
HAND PROTECTION:
CHEMICAL-RESISTANT GLOVES COMPLYING WITH AN APPROVED STANDARD SHOULD BE WORN
AT ALL TIMES WHEN HANDLING CHEMICAL PRODUCTS IF A RISK ASSESSMENT INDICATES
THIS IS NECESSARY.
BODY PROTECTION:
PERSONAL PROTECTIVE EQUIPMENT FOR THE BODY SHOULD BE SELECTED BASED ON THE
TASK BEING PERFORMED AND THE RISKS INVOLVED AND SHOULD BE APPROVED BY A
SPECIALIST BEFORE HANDLING THIS PRODUCT.
OTHER SKIN PROTECTION:
AVOID SKIN CONTACT WITH LIQUID. APPROPRIATE FOOTWEAR AND ANY ADDITIONAL SKIN
PROTECTION MEASURES SHOULD BE SELECTED BASED ON THE TASK BEING PERFORMED AND
THE RISKS INVOLVED AND SHOULD BE APPROVED BY A SPECIALIST BEFORE HANDLING
THIS PRODUCT. LEATHER BOOTS ARE NOT PROTECTIVE FOR LIQUID CONTACT.
RESPIRATORY PROTECTION:
AVOID INHALATION OF GASES, VAPORS, MISTS OR DUSTS. USE A PROPERLY FITTED,
AIR-PURIFYING OR SUPPLIED-AIR RESPIRATOR COMPLYING WITH AN APPROVED STANDARD
IF A RISK ASSESSMENT INDICATES THIS IS NECESSARY. RESPIRATOR SELECTION MUST
BE BASED ON KNOWN OR ANTICIPATED EXPOSURE LEVELS, THE HAZARDS OF THE PRODUCT
AND THE SAFE WORKING LIMITS OF THE SELECTED RESPIRATOR.
| SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES | |
PHYSICAL STATE: LIQUID.
COLOR: LIGHT AMBER [LIGHT]
ODOR: MILD PETROLEUM ODOR [SLIGHT]
PH: NOT APPLICABLE.
BOILING POINT/BOILING RANGE: NOT AVAILABLE.
FLASH POINT:
OPEN CUP: 230 DEG. C (446 DEG. F) [CLEVELAND.]
LOWER AND UPPER EXPLOSIVE (FLAMMABLE) LIMITS: NOT AVAILABLE.
VAPOR PRESSURE: NOT AVAILABLE.
VAPOR DENSITY: NOT AVAILABLE.
RELATIVE DENSITY: NOT AVAILABLE.
DENSITY LBS/GAL: 7.2 LBS/GAL
GRAVITY, API: 32.3
VISCOSITY:
DYNAMIC (ROOM TEMPERATURE): NOT APPLICABLE.
KINEMATIC (ROOM TEMPERATURE): NOT APPLICABLE.
KINEMATIC (40 DEG. C (104 DEG. F)): 0.48 CM2/S (48 CST)
VISCOSITY SUS: 240 SUS @100 F
| SECTION 10. STABILITY AND REACTIVITY | |
REACTIVITY:
NOT EXPECTED TO BE EXPLOSIVE, SELF-REACTIVE, SELF-HEATING, OR AN ORGANIC
PEROXIDE UNDER US GHS DEFINITION(S).
CHEMICAL STABILITY: THE PRODUCT IS STABLE.
POSSIBILITY OF HAZARDOUS REACTIONS:
UNDER NORMAL CONDITIONS OF STORAGE AND USE, HAZARDOUS REACTIONS WILL NOT
OCCUR.
CONDITIONS TO AVOID: NO SPECIFIC DATA.
INCOMPATIBLE MATERIALS: NO SPECIFIC DATA.
HAZARDOUS DECOMPOSITION PRODUCTS:
UNDER NORMAL CONDITIONS OF STORAGE AND USE, HAZARDOUS DECOMPOSITION PRODUCTS
SHOULD NOT BE PRODUCED.
| SECTION 11. TOXICOLOGICAL INFORMATION | |
INFORMATION ON TOXICOLOGICAL EFFECTS:
ACUTE TOXICITY:
CONCLUSION/SUMMARY:
DISTILLATES (PETROLEUM), HYDROTREATED HEAVY PARAFFINIC:
MINERAL OIL MISTS DERIVED FROM HIGHLY REFINED OILS ARE REPORTED TO HAVE LOW
ACUTE AND SUB-ACUTE TOXICITIES IN ANIMALS. EFFECTS FROM SINGLE AND
SHORT-TERM REPEATED EXPOSURES TO HIGH CONCENTRATIONS OF MINERAL OIL MISTS
WELL ABOVE APPLICABLE WORKPLACE EXPOSURE LEVELS INCLUDE LUNG INFLAMMATORY
REACTION, LIPOID GRANULOMA FORMATION AND LIPOID PNEUMONIA. IN ACUTE AND
SUB-ACUTE STUDIES INVOLVING EXPOSURES TO LOWER CONCENTRATIONS OF MINERAL OIL
MISTS AT OR NEAR CURRENT WORK PLACE EXPOSURE LEVELS PRODUCED NO SIGNIFICANT
TOXICOLOGICAL EFFECTS.
IRRITATION/CORROSION:
SKIN: NO ADDITIONAL INFORMATION.
EYES: NO ADDITIONAL INFORMATION.
RESPIRATORY: NO ADDITIONAL INFORMATION.
SENSITIZATION:
SKIN: NO ADDITIONAL INFORMATION.
RESPIRATORY: NO ADDITIONAL INFORMATION.
MUTAGENICITY:
CONCLUSION/SUMMARY: NO ADDITIONAL INFORMATION.
CARCINOGENICITY:
CONCLUSION/SUMMARY: NO ADDITIONAL INFORMATION.
REPRODUCTIVE TOXICITY:
CONCLUSION/SUMMARY: NO ADDITIONAL INFORMATION.
TERATOGENICITY:
CONCLUSION/SUMMARY: NO ADDITIONAL INFORMATION.
SPECIFIC TARGET ORGAN TOXICITY (SINGLE EXPOSURE): NOT AVAILABLE.
SPECIFIC TARGET ORGAN TOXICITY (REPEATED EXPOSURE): NOT AVAILABLE.
ASPIRATION HAZARD: NOT AVAILABLE.
INFORMATION ON THE LIKELY ROUTES OF EXPOSURE: NOT AVAILABLE.
POTENTIAL ACUTE HEALTH EFFECTS:
EYE CONTACT: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
INHALATION: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
SKIN CONTACT:
INJECTION OF PRESSURIZED HYDROCARBONS CAN CAUSE SEVERE PERMANENT TISSUE
DAMAGE. INITIAL SYMPTOMS MAY BE MINOR.
INGESTION: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
SYMPTOMS RELATED TO THE PHYSICAL, CHEMICAL AND TOXICOLOGICAL
CHARACTERISTICS:
EYE CONTACT: NO SPECIFIC DATA.
INHALATION: NO SPECIFIC DATA.
SKIN CONTACT: NO SPECIFIC DATA.
INGESTION: NO SPECIFIC DATA.
POTENTIAL CHRONIC HEALTH EFFECTS:
GENERAL: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
CARCINOGENICITY: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
MUTAGENICITY: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
TERATOGENICITY: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
DEVELOPMENTAL EFFECTS: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
FERTILITY EFFECTS: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
| SECTION 12. ECOLOGICAL INFORMATION | |
TOXICITY:
CONCLUSION/SUMMARY: NOT AVAILABLE.
PERSISTENCE AND DEGRADABILITY:
CONCLUSION/SUMMARY: NOT AVAILABLE.
BIOACCUMULATIVE POTENTIAL: NOT AVAILABLE.
MOBILITY IN SOIL:
SOIL/WATER PARTITION COEFFICIENT (KOC): NOT AVAILABLE.
OTHER ADVERSE EFFECTS: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
| SECTION 13. DISPOSAL CONSIDERATIONS | |
DISPOSAL METHODS:
THE GENERATION OF WASTE SHOULD BE AVOIDED OR MINIMIZED WHEREVER POSSIBLE.
DISPOSAL OF THIS PRODUCT, SOLUTIONS AND ANY BY-PRODUCTS SHOULD AT ALL TIMES
COMPLY WITH THE REQUIREMENTS OF ENVIRONMENTAL PROTECTION AND WASTE DISPOSAL
LEGISLATION AND ANY REGIONAL LOCAL AUTHORITY REQUIREMENTS. DISPOSE OF
SURPLUS AND NON-RECYCLABLE PRODUCTS VIA A LICENSED WASTE DISPOSAL
CONTRACTOR. WASTE SHOULD NOT BE DISPOSED OF UNTREATED TO THE SEWER UNLESS
FULLY COMPLIANT WITH THE REQUIREMENTS OF ALL AUTHORITIES WITH JURISDICTION.
WASTE PACKAGING SHOULD BE RECYCLED. THIS MATERIAL AND ITS CONTAINER MUST BE
DISPOSED OF IN A SAFE WAY. EMPTY CONTAINERS OR LINERS MAY RETAIN SOME
PRODUCT RESIDUES. AVOID DISPERSAL OF SPILLED MATERIAL AND RUNOFF AND CONTACT
WITH SOIL, WATERWAYS, DRAINS AND SEWERS.
| SECTION 14. TRANSPORT INFORMATION | |
DOT CLASSIFICATION IMDG IATA
UN NUMBER NOT REGULATED. NOT REGULATED. NOT REGULATED.
UN PROPER
SHIPPING NAME
TRANSPORT
HAZARD CLASS(ES)
PACKING GROUP
ENVIRONMENTAL NO. NO. NO.
HAZARDS
ADDITIONAL
INFORMATION
SPECIAL PRECAUTIONS FOR USER:
TRANSPORT WITHIN USER'S PREMISES:
ALWAYS TRANSPORT IN CLOSED CONTAINERS THAT ARE UPRIGHT AND SECURE. ENSURE
THAT PERSONS TRANSPORTING THE PRODUCT KNOW WHAT TO DO IN THE EVENT OF AN
ACCIDENT OR SPILLAGE.
| SECTION 15. REGULATORY INFORMATION | |
U.S. FEDERAL REGULATIONS:
UNITED STATES INVENTORY (TSCA 8B): ALL COMPONENTS ARE LISTED OR EXEMPTED.
CLEAN WATER ACT (CWA) 307: ZINC AND ZINC COMPOUNDS; TOLUENE; PHENOL
CLEAN WATER ACT (CWA) 311: TOLUENE; PHENOL
THIS MATERIAL IS CLASSIFIED AS AN OIL UNDER SECTION 311 OF THE CLEAN WATER
ACT (CWA) AND THE OIL POLLUTION ACT OF 1990 (OPA). DISCHARGES OR SPILLS
WHICH PRODUCE A VISIBLE SHEEN ON WATERS OF THE UNITED STATES, THEIR
ADJOINING SHORELINES, OR INTO CONDUITS LEADING TO SURFACE WATERS MUST BE
REPORTED TO THE EPA'S NATIONAL RESPONSE CENTER AT (800) 424-8802.
SARA 302/304:
COMPOSITION/INFORMATION ON INGREDIENTS:
NAME % EHS SARA 302 TPQ SARA 304 RQ
(LBS) (GALLONS) (LBS) (GALLONS)
PHENOL <0.01 YES. 500 / 10000 1000
SARA 304 RQ: 99900099.9 LBS / 45354645.4 KG [13931895 GAL / 52737959.7 L]
SARA 311/312:
CLASSIFICATION: NOT APPLICABLE.
COMPOSITION/INFORMATION ON INGREDIENTS:
STATE REGULATIONS:
MASSACHUSETTS: NONE OF THE COMPONENTS ARE LISTED.
NEW YORK: NONE OF THE COMPONENTS ARE LISTED.
NEW JERSEY: NONE OF THE COMPONENTS ARE LISTED.
PENNSYLVANIA: NONE OF THE COMPONENTS ARE LISTED.
CALIFORNIA PROP. 65:
WARNING:
THIS PRODUCT CONTAINS LESS THAN 0.1% OF A CHEMICAL KNOWN TO THE STATE OF
CALIFORNIA TO CAUSE CANCER.
WARNING:
THIS PRODUCT CONTAINS LESS THAN 1% OF A CHEMICAL KNOWN TO THE STATE OF
CALIFORNIA TO CAUSE BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM.
INGREDIENT NAME % CANCER REPRODUCTIVE NO MAXIMUM
SIGNIFICANT ACCEPTABLE
RISK LEVEL DOSAGE LEVEL
TOLUENE <0.01 NO. YES. NO. 7000
(MICRO)G/DAY
(INGESTION)
ETHYL ACRYLATE <0.0001 YES. NO. NO. NO.
INTERNATIONAL REGULATIONS:
INTERNATIONAL LISTS:
AUSTRALIA INVENTORY (AICS): ALL COMPONENTS ARE LISTED OR EXEMPTED.
CHINA INVENTORY (IECSC): ALL COMPONENTS ARE LISTED OR EXEMPTED.
JAPAN INVENTORY: ALL COMPONENTS ARE LISTED OR EXEMPTED.
KOREA INVENTORY: ALL COMPONENTS ARE LISTED OR EXEMPTED.
MALAYSIA INVENTORY (EHS REGISTER): NOT DETERMINED.
NEW ZEALAND INVENTORY OF CHEMICALS (NZIOC):
ALL COMPONENTS ARE LISTED OR EXEMPTED.
PHILIPPINES INVENTORY (PICCS): ALL COMPONENTS ARE LISTED OR EXEMPTED.
TAIWAN INVENTORY (CSNN): NOT DETERMINED.
CANADA INVENTORY: ALL COMPONENTS ARE LISTED OR EXEMPTED.
EU INVENTORY: ALL COMPONENTS ARE LISTED OR EXEMPTED.
WHMIS (CANADA): NOT CONTROLLED UNDER WHMIS (CANADA).
| SECTION 16. OTHER INFORMATION | |
NATIONAL FIRE PROTECTION ASSOCIATION (U.S.A.):
HEALTH 0
FLAMMABILITY 1
INSTABILITY/REACTIVITY 0
SPECIAL
REPRINTED WITH PERMISSION FROM NFPA 704-2001, IDENTIFICATION OF THE HAZARDS
OF MATERIALS FOR EMERGENCY RESPONSE COPYRIGHT (C)1997, NATIONAL FIRE
PROTECTION ASSOCIATION, QUINCY, MA 02269. THIS REPRINTED MATERIAL IS NOT THE
COMPLETE AND OFFICIAL POSITION OF THE NATIONAL FIRE PROTECTION ASSOCIATION,
ON THE REFERENCED SUBJECT WHICH IS REPRESENTED ONLY BY THE STANDARD IN ITS
ENTIRETY.
COPYRIGHT (C)2001, NATIONAL FIRE PROTECTION ASSOCIATION, QUINCY, MA 02269.
THIS WARNING SYSTEM IS INTENDED TO BE INTERPRETED AND APPLIED ONLY BY
PROPERLY TRAINED INDIVIDUALS TO IDENTIFY FIRE, HEALTH AND REACTIVITY HAZARDS
OF CHEMICALS. THE USER IS REFERRED TO CERTAIN LIMITED NUMBER OF CHEMICALS
WITH RECOMMENDED CLASSIFICATIONS IN NFPA 49 AND NFPA 325, WHICH WOULD BE
USED AS A GUIDELINE ONLY. WHETHER THE CHEMICALS ARE CLASSIFIED BY NFPA OR
NOT, ANYONE USING THE 704 SYSTEMS TO CLASSIFY CHEMICALS DOES SO AT THEIR OWN
RISK.
HISTORY:
DATE OF ISSUE/DATE OF REVISION: 3/7/2016
KEY TO ABBREVIATIONS:
ATE: ACUTE TOXICITY ESTIMATE
BCF: BIOCONCENTRATION FACTOR
GHS: GLOBALLY HARMONIZED SYSTEM OF CLASSIFICATION AND LABELING OF CHEMICALS
IATA: INTERNATIONAL AIR TRANSPORT ASSOCIATION
IBC: INTERMEDIATE BULK CONTAINER
IMDG: INTERNATIONAL MARITIME DANGEROUS GOODS
LOGPOW: LOGARITHM OF THE OCTANOL/WATER PARTITION COEFFICIENT
MARPOL 73/78:
INTERNATIONAL CONVENTION FOR THE PREVENTION OF POLLUTION FROM SHIPS, 1973 AS
MODIFIED BY THE PROTOCOL OF 1978. ("MARPOL" = MARINE POLLUTION)
UN: UNITED NATIONS
NOTICE TO READER:
THE INFORMATION IN THIS SAFETY DATA SHEET (SDS) WAS OBTAINED FROM SOURCES
WHICH WE BELIEVE ARE RELIABLE. HOWEVER, THE INFORMATION IS PROVIDED WITHOUT
ANY WARRANTY, EXPRESSED OR IMPLIED REGARDING ITS CORRECTNESS OR ACCURACY.
SOME INFORMATION PRESENTED AND CONCLUSIONS DRAWN HEREIN ARE FROM SOURCES
OTHER THAN DIRECT TEST DATA ON THE SUBSTANCE ITSELF. THIS SDS WAS PREPARED
AND IS TO BE USED ONLY FOR THIS PRODUCT. IF THE PRODUCT IS USED AS A
COMPONENT IN ANOTHER PRODUCT, THIS SDS INFORMATION MAY NOT BE APPLICABLE.
USERS SHOULD MAKE THEIR OWN INVESTIGATIONS TO DETERMINE THE SUITABILITY OF
THE INFORMATION OR PRODUCTS FOR THEIR PARTICULAR PURPOSE OR APPLICATION.
THE CONDITIONS OR METHODS OF HANDLING, STORAGE, USE, AND/OR DISPOSAL OF THE
PRODUCT ARE BEYOND OUR CONTROL AND MAY BE BEYOND OUR KNOWLEDGE. FOR THIS AND
OTHER REASONS, WE DO NOT ASSUME RESPONSIBILITY AND EXPRESSLY DISCLAIM
LIABILITY FOR ANY LOSS, DAMAGE OR EXPENSE ARISING OUT OF OR IN ANY WAY
CONNECTED WITH HANDLING, STORAGE, USE OR DISPOSAL OF THE PRODUCT.
CITGO IS A REGISTERED TRADEMARK OF CITGO PETROLEUM CORPORATION