| Common Name: | DOWSIL PR-1200 RTV PRIME COAT CLEAR |
| Manufacturer: | DOW CHEMICAL |
| SDS Revision Date: | 7/12/2022 |
| SDS Format: | No Format Specified |
| Item Number(s): | 53DC96, 53DC97, 53DC98 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
DOW(R*)
SAFETY DATA SHEET
THE DOW CHEMICAL COMPANY
PRODUCT NAME: DOWSIL(TM) PR-1200 RTV PRIME COAT CLEAR
ISSUE DATE: 07/12/2022
PRINT DATE: 07/13/2022
THE DOW CHEMICAL COMPANY ENCOURAGES AND EXPECTS YOU TO READ AND UNDERSTAND
THE ENTIRE (M)SDS, AS THERE IS IMPORTANT INFORMATION THROUGHOUT THE
DOCUMENT. WE EXPECT YOU TO FOLLOW THE PRECAUTIONS IDENTIFIED IN THIS
DOCUMENT UNLESS YOUR USE CONDITIONS WOULD NECESSITATE OTHER APPROPRIATE
METHODS OR ACTIONS.
| 1. IDENTIFICATION |  |
PRODUCT NAME: DOWSIL(TM) PR-1200 RTV PRIME COAT CLEAR
RECOMMENDED USE OF THE CHEMICAL AND RESTRICTIONS ON USE:
IDENTIFIED USES: ADHESIVE, BINDING AGENTS
COMPANY IDENTIFICATION:
THE DOW CHEMICAL COMPANY
2211 H.H. DOW WAY
MIDLAND, MI 48674
UNITED STATES
CUSTOMER INFORMATION NUMBER: 800-258-2436
SDSQUESTION@DOW.COM
EMERGENCY TELEPHONE NUMBER:
24-HOUR EMERGENCY CONTACT:
CHEMTREC: +1 800-424-9300
LOCAL EMERGENCY CONTACT: 800-424-9300
| 2. HAZARDS IDENTIFICATION | |
HAZARD CLASSIFICATION:
GHS CLASSIFICATION IN ACCORDANCE WITH THE OSHA HAZARD COMMUNICATION
STANDARD (29 CFR 1910.1200)
FLAMMABLE LIQUIDS: CATEGORY 2
SKIN IRRITATION: CATEGORY 2
SERIOUS EYE DAMAGE: CATEGORY 1
SPECIFIC TARGET ORGAN TOXICITY - SINGLE EXPOSURE: CATEGORY 3
SPECIFIC TARGET ORGAN TOXICITY - REPEATED EXPOSURE: CATEGORY 2
ASPIRATION HAZARD: CATEGORY 1
LABEL ELEMENTS:
HAZARD PICTOGRAMS:
FLAME
HEALTH HAZARD
CORROSION
EXCLAMATION MARK
SIGNAL WORD: DANGER!
HAZARDS:
HIGHLY FLAMMABLE LIQUID AND VAPOR.
MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS.
CAUSES SKIN IRRITATION.
CAUSES SERIOUS EYE DAMAGE.
MAY CAUSE DROWSINESS OR DIZZINESS.
MAY CAUSE DAMAGE TO ORGANS (BLOOD) THROUGH PROLONGED OR REPEATED EXPOSURE.
PRECAUTIONARY STATEMENTS:
PREVENTION:
KEEP AWAY FROM HEAT/SPARKS/OPEN FLAMES/HOT SURFACES. NO SMOKING.
KEEP CONTAINER TIGHTLY CLOSED.
GROUND/BOND CONTAINER AND RECEIVING EQUIPMENT.
USE EXPLOSION-PROOF ELECTRICAL/VENTILATING/LIGHTING EQUIPMENT.
USE ONLY NON-SPARKING TOOLS.
TAKE PRECAUTIONARY MEASURES AGAINST STATIC DISCHARGE.
DO NOT BREATHE MIST OR VAPORS.
WASH SKIN THOROUGHLY AFTER HANDLING.
USE ONLY OUTDOORS OR IN A WELL-VENTILATED AREA.
WEAR PROTECTIVE GLOVES/EYE PROTECTION/FACE PROTECTION.
RESPONSE:
IF SWALLOWED: IMMEDIATELY CALL A POISON CENTER/DOCTOR.
IF ON SKIN (OR HAIR):
TAKE OFF IMMEDIATELY ALL CONTAMINATED CLOTHING. RINSE SKIN WITH
WATER/SHOWER.
IF INHALED:
REMOVE PERSON TO FRESH AIR AND KEEP COMFORTABLE FOR BREATHING. CALL A
POISON CENTER/DOCTOR IF YOU FEEL UNWELL.
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES, IF
PRESENT AND EASY TO DO. CONTINUE RINSING. IMMEDIATELY CALL A POISON CENTER
AND/OR DOCTOR.
GET MEDICAL ADVICE/ATTENTION IF YOU FEEL UNWELL.
DO NOT INDUCE VOMITING.
IF SKIN IRRITATION OCCURS: GET MEDICAL ADVICE/ATTENTION.
TAKE OFF CONTAMINATED CLOTHING AND WASH BEFORE REUSE.
IN CASE OF FIRE:
USE WATER SPRAY, ALCOHOL-RESISTANT FOAM, DRY CHEMICAL OR CARBON DIOXIDE TO
EXTINGUISH.
STORAGE:
STORE IN A WELL-VENTILATED PLACE. KEEP CONTAINER TIGHTLY CLOSED.
STORE IN A WELL-VENTILATED PLACE. KEEP COOL.
STORE LOCKED UP.
DISPOSAL:
DISPOSE OF CONTENTS AND/OR CONTAINER TO AN APPROVED WASTE DISPOSAL PLANT.
OTHER HAZARDS: STATIC-ACCUMULATING FLAMMABLE LIQUID.
| 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
CHEMICAL NATURE:
INORGANIC AND ORGANIC COMPOUNDS, MIXTURE THIS PRODUCT IS A MIXTURE.
COMPONENT CASRN CONCENTRATION
DISTILLATES, PETROLEUM, LIGHT DISTILLATE 68410-97-9 >=82.0 - <=88.0%
HYDROTREATING PROCESS, LOW-BOILING
TETRAKIS(2-BUTOXYETHYL) ORTHOSILICATE 18765-38-3 >=4.0 - <=6.0%
TETRA N-BUTYL TITANATE 5593-70-4 >=4.0 - <=6.0%
OCTANE 111-65-9 <=1.4%
| 4. FIRST AID MEASURES | |
DESCRIPTION OF FIRST AID MEASURES:
GENERAL ADVICE:
FIRST AID RESPONDERS SHOULD PAY ATTENTION TO SELF-PROTECTION AND USE THE
RECOMMENDED PROTECTIVE CLOTHING (CHEMICAL RESISTANT GLOVES, SPLASH
PROTECTION). IF POTENTIAL FOR EXPOSURE EXISTS REFER TO SECTION 8 FOR
SPECIFIC PERSONAL PROTECTIVE EQUIPMENT.
INHALATION:
MOVE PERSON TO FRESH AIR AND KEEP COMFORTABLE FOR BREATHING. IF NOT
BREATHING, GIVE ARTIFICIAL RESPIRATION; IF BY MOUTH TO MOUTH USE RESCUER
PROTECTION (POCKET MASK, ETC). IF BREATHING IS DIFFICULT, OXYGEN SHOULD BE
ADMINISTERED BY QUALIFIED PERSONNEL. CALL A PHYSICIAN OR TRANSPORT TO A
MEDICAL FACILITY.
SKIN CONTACT:
WASH OFF WITH PLENTY OF WATER. SUITABLE EMERGENCY SAFETY SHOWER FACILITY
SHOULD BE AVAILABLE IN WORK AREA.
EYE CONTACT:
WASH IMMEDIATELY AND CONTINUOUSLY WITH FLOWING WATER FOR AT LEAST 30
MINUTES. REMOVE CONTACT LENSES AFTER THE FIRST 5 MINUTES AND CONTINUE
WASHING. OBTAIN PROMPT MEDICAL CONSULTATION, PREFERABLY FROM AN
OPHTHALMOLOGIST. SUITABLE EMERGENCY EYE WASH FACILITY SHOULD BE IMMEDIATELY
AVAILABLE.
INGESTION:
DO NOT INDUCE VOMITING. CALL A PHYSICIAN AND/OR TRANSPORT TO EMERGENCY
FACILITY IMMEDIATELY.
MOST IMPORTANT SYMPTOMS AND EFFECTS, BOTH ACUTE AND DELAYED:
MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS. CAUSES SKIN IRRITATION.
CAUSES SERIOUS EYE DAMAGE. MAY CAUSE DROWSINESS OR DIZZINESS. MAY CAUSE
DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE.
INDICATION OF ANY IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED:
NOTES TO PHYSICIAN:
MAINTAIN ADEQUATE VENTILATION AND OXYGENATION OF THE PATIENT. MAY CAUSE
ASTHMA-LIKE (REACTIVE AIRWAYS) SYMPTOMS. BRONCHODILATORS, EXPECTORANTS,
ANTITUSSIVES AND CORTICOSTEROIDS MAY BE OF HELP. CHEMICAL EYE BURNS MAY
REQUIRE EXTENDED IRRIGATION. OBTAIN PROMPT CONSULTATION, PREFERABLY FROM AN
OPHTHALMOLOGIST. IF BURN IS PRESENT, TREAT AS ANY THERMAL BURN, AFTER
DECONTAMINATION. IF LAVAGE IS PERFORMED, SUGGEST ENDOTRACHEAL AND/OR
ESOPHAGEAL CONTROL. DANGER FROM LUNG ASPIRATION MUST BE WEIGHED AGAINST
TOXICITY WHEN CONSIDERING EMPTYING THE STOMACH. THE DECISION OF WHETHER TO
INDUCE VOMITING OR NOT SHOULD BE MADE BY A PHYSICIAN. NO SPECIFIC ANTIDOTE.
TREATMENT OF EXPOSURE SHOULD BE DIRECTED AT THE CONTROL OF SYMPTOMS AND THE
CLINICAL CONDITION OF THE PATIENT. REPEATED EXCESSIVE EXPOSURE MAY
AGGRAVATE PREEXISTING LUNG DISEASE. SKIN CONTACT MAY AGGRAVATE PREEXISTING
DERMATITIS.
| 5. FIREFIGHTING MEASURES | |
EXTINGUISHING MEDIA:
SUITABLE EXTINGUISHING MEDIA:
ALCOHOL-RESISTANT FOAM. CARBON DIOXIDE (CO2). DRY CHEMICAL. DRY SAND.
UNSUITABLE EXTINGUISHING MEDIA:
HIGH VOLUME WATER JET. DO NOT USE DIRECT WATER STREAM..
SPECIAL HAZARDS ARISING FROM THE SUBSTANCE OR MIXTURE:
HAZARDOUS COMBUSTION PRODUCTS:
SILICON OXIDES. FORMALDEHYDE. CARBON OXIDES. METAL OXIDES.
UNUSUAL FIRE AND EXPLOSION HAZARDS:
FLASH BACK POSSIBLE OVER CONSIDERABLE DISTANCE.. EXPOSURE TO COMBUSTION
PRODUCTS MAY BE A HAZARD TO HEALTH.. FLAMMABLE CONCENTRATIONS OF VAPOR CAN
ACCUMULATE AT TEMPERATURES ABOVE FLASH POINT; SEE SECTION 9.. FLAMMABLE
MIXTURES MAY EXIST WITHIN THE VAPOR SPACE OF CONTAINERS AT ROOM
TEMPERATURE.. CLOSED CONTAINERS MAY RUPTURE VIA PRESSURE BUILD-UP WHEN
EXPOSED TO FIRE OR EXTREME HEAT.. VAPORS MAY FORM EXPLOSIVE MIXTURES WITH
AIR..
ADVICE FOR FIREFIGHTERS:
FIRE FIGHTING PROCEDURES:
USE WATER SPRAY TO COOL UNOPENED CONTAINERS.. EVACUATE AREA.. COLLECT
CONTAMINATED FIRE EXTINGUISHING WATER SEPARATELY. THIS MUST NOT BE
DISCHARGED INTO DRAINS.. FIRE RESIDUES AND CONTAMINATED FIRE EXTINGUISHING
WATER MUST BE DISPOSED OF IN ACCORDANCE WITH LOCAL REGULATIONS.. CONTAIN
FIRE WATER RUN-OFF IF POSSIBLE. FIRE WATER RUN-OFF, IF NOT CONTAINED, MAY
CAUSE ENVIRONMENTAL DAMAGE.. USE WATER SPRAY TO COOL FIRE EXPOSED
CONTAINERS AND FIRE AFFECTED ZONE UNTIL FIRE IS OUT AND DANGER OF
REIGNITION HAS PASSED.. DO NOT USE A SOLID WATER STREAM AS IT MAY SCATTER
AND SPREAD FIRE..
USE EXTINGUISHING MEASURES THAT ARE APPROPRIATE TO LOCAL CIRCUMSTANCES AND
THE SURROUNDING ENVIRONMENT. REMOVE UNDAMAGED CONTAINERS FROM FIRE AREA IF
IT IS SAFE TO DO SO.
SPECIAL PROTECTIVE EQUIPMENT FOR FIREFIGHTERS:
IN THE EVENT OF FIRE, WEAR SELF-CONTAINED BREATHING APPARATUS.. USE
PERSONAL PROTECTIVE EQUIPMENT..
| 6. ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
REMOVE ALL SOURCES OF IGNITION. VENTILATE THE AREA. USE PERSONAL PROTECTIVE
EQUIPMENT. ELIMINATE ALL SOURCES OF IGNITION IN VICINITY OF SPILL OR
RELEASED VAPOR TO AVOID FIRE OR EXPLOSION. GROUND AND BOND ALL CONTAINERS
AND HANDLING EQUIPMENT. VAPOR EXPLOSION HAZARD. KEEP OUT OF SEWERS. FOLLOW
SAFE HANDLING ADVICE AND PERSONAL PROTECTIVE EQUIPMENT RECOMMENDATIONS.
ENVIRONMENTAL PRECAUTIONS:
DO NOT RELEASE THE PRODUCT TO THE AQUATIC ENVIRONMENT ABOVE DEFINED
REGULATORY LEVELS PREVENT FURTHER LEAKAGE OR SPILLAGE IF SAFE TO DO SO.
PREVENT SPREADING OVER A WIDE AREA (E.G. BY CONTAINMENT OR OIL BARRIERS).
RETAIN AND DISPOSE OF CONTAMINATED WASH WATER. LOCAL AUTHORITIES SHOULD BE
ADVISED IF SIGNIFICANT SPILLAGES CANNOT BE CONTAINED.
METHODS AND MATERIALS FOR CONTAINMENT AND CLEANING UP:
NON-SPARKING TOOLS SHOULD BE USED. SOAK UP WITH INERT ABSORBENT MATERIAL.
SUPPRESS (KNOCK DOWN) GASES/VAPORS/MISTS WITH A WATER SPRAY JET. CLEAN UP
REMAINING MATERIALS FROM SPILL WITH SUITABLE ABSORBANT. LOCAL OR NATIONAL
REGULATIONS MAY APPLY TO RELEASES AND DISPOSAL OF THIS MATERIAL, AS WELL AS
THOSE MATERIALS AND ITEMS EMPLOYED IN THE CLEANUP OF RELEASES. YOU WILL
NEED TO DETERMINE WHICH REGULATIONS ARE APPLICABLE. FOR LARGE SPILLS,
PROVIDE DYKING OR OTHER APPROPRIATE CONTAINMENT TO KEEP MATERIAL FROM
SPREADING. IF DYKED MATERIAL CAN BE PUMPED, STORE RECOVERED MATERIAL IN
APPROPRIATE CONTAINER. SEE SECTIONS: 7, 8, 11, 12 AND 13.
| 7. HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING:
DO NOT GET ON SKIN OR CLOTHING. DO NOT BREATHE VAPORS OR SPRAY MIST. DO
NOT SWALLOW. DO NOT GET IN EYES. KEEP CONTAINER TIGHTLY CLOSED. KEEP AWAY
FROM HEAT AND SOURCES OF IGNITION. TAKE PRECAUTIONARY MEASURES AGAINST
STATIC DISCHARGES. TAKE CARE TO PREVENT SPILLS, WASTE AND MINIMIZE RELEASE
TO THE ENVIRONMENT. NON-SPARKING TOOLS SHOULD BE USED. HANDLE IN ACCORDANCE
WITH GOOD INDUSTRIAL HYGIENE AND SAFETY PRACTICE. CONTAINERS MAY BE
HAZARDOUS WHEN EMPTY. SINCE EMPTIED CONTAINERS RETAIN PRODUCT RESIDUE
FOLLOW ALL (M)SDS AND LABEL WARNINGS EVEN AFTER CONTAINER IS EMPTIED.
USE WITH LOCAL EXHAUST VENTILATION. USE ONLY IN AN AREA EQUIPPED WITH
EXPLOSION PROOF EXHAUST VENTILATION. ENSURE ALL EQUIPMENT IS ELECTRICALLY
GROUNDED BEFORE BEGINNING TRANSFER OPERATIONS. THIS MATERIAL CAN ACCUMULATE
STATIC CHARGE DUE TO ITS INHERENT PHYSICAL PROPERTIES AND CAN THEREFORE
CAUSE AN ELECTRICAL IGNITION SOURCE TO VAPORS. IN ORDER TO PREVENT A FIRE
HAZARD, AS BONDING AND GROUNDING MAY BE INSUFFICIENT TO REMOVE STATIC
ELECTRICITY, IT IS NECESSARY TO PROVIDE AN INERT GAS PURGE BEFORE BEGINNING
TRANSFER OPERATIONS. RESTRICT FLOW VELOCITY IN ORDER TO REDUCE THE
ACCUMULATION OF STATIC ELECTRICITY. GROUND AND BOND CONTAINER AND RECEIVING
EQUIPMENT.
CONDITIONS FOR SAFE STORAGE:
KEEP IN PROPERLY LABELED CONTAINERS. STORE LOCKED UP. KEEP TIGHTLY CLOSED.
KEEP IN A COOL, WELL-VENTILATED PLACE. STORE IN ACCORDANCE WITH THE
PARTICULAR NATIONAL REGULATIONS. KEEP AWAY FROM HEAT AND SOURCES OF
IGNITION.
DO NOT STORE WITH THE FOLLOWING PRODUCT TYPES:
STRONG OXIDIZING AGENTS. ORGANIC PEROXIDES. FLAMMABLE SOLIDS. PYROPHORIC
LIQUIDS. PYROPHORIC SOLIDS. SELF-HEATING SUBSTANCES AND MIXTURES.
SUBSTANCES AND MIXTURES, WHICH IN CONTACT WITH WATER, EMIT FLAMMABLE GASES.
EXPLOSIVES. GASES.
UNSUITABLE MATERIALS FOR CONTAINERS: NONE KNOWN.
| 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
CONTROL PARAMETERS:
IF EXPOSURE LIMITS EXIST, THEY ARE LISTED BELOW. IF NO EXPOSURE LIMITS ARE
DISPLAYED, THEN NO VALUES ARE APPLICABLE.
COMPONENT REGULATION TYPE OF LISTING VALUE
DISTILLATES, OSHA Z-1 TWA 2,000 MG/M3
PETROLEUM, LIGHT 500 PPM
DISTILLATE
HYDROTREATING
PROCESS, LOW-
BOILING
OCTANE OSHA Z-1 TWA 2,350 MG/M3
500 PPM
ACGIH TWA 300 PPM
ETHYLENE GLYCOL ACGIH TWA 20 PPM
MONOBUTYL ETHER
FURTHER INFORMATION:
A3: CONFIRMED ANIMAL CARCINOGEN WITH UNKNOWN RELEVANCE TO
HUMANS
OSHA Z-1 TWA 240 MG/M3
50 PPM
FURTHER INFORMATION:
X: SKIN DESIGNATION
BUTANOL ACGIH TWA 20 PPM
OSHA Z-1 TWA 300 MG/M3
100 PPM
PROPYL ALCOHOL ACGIH TWA 100 PPM
FURTHER INFORMATION:
A4: NOT CLASSIFIABLE AS A HUMAN CARCINOGEN
OSHA Z-1 TWA 500 MG/M3
200 PPM
THE FOLLOWING SUBSTANCE(S), WHICH HAVE OCCUPATIONAL EXPOSURE LIMIT(S)
(OEL), MAY BE FORMED DURING HANDLING OR PROCESSING:, ETHYLENE GLYCOL
MONOBUTYL ETHER, PROPYL ALCOHOL, BUTANOL
BIOLOGICAL OCCUPATIONAL EXPOSURE LIMITS:
COMPONENTS CAS-NO. CONTROL BIOLOGICAL SAMPLING
PARAMETERS SPECIMEN TIME
ETHYLENE 111-76-2 BUTOXYACETIC URINE END OF
GLYCOL ACID (BAA) SHIFT (AS
MONOBUTYL SOON AS
ETHER POSSIBLE
AFTER
EXPOSURE
CEASES)
COMPONENTS PERMISSIBLE CONCENTRATION BASIS
ETHYLENE GLYCOL 200 MG/G ACGIH BEI
MONOBUTYL ETHER CREATININE
EXPOSURE CONTROLS:
ENGINEERING CONTROLS:
USE ENGINEERING CONTROLS TO MAINTAIN AIRBORNE LEVEL BELOW EXPOSURE LIMIT
REQUIREMENTS OR GUIDELINES. IF THERE ARE NO APPLICABLE EXPOSURE LIMIT
REQUIREMENTS OR GUIDELINES, USE ONLY WITH ADEQUATE VENTILATION. LOCAL
EXHAUST VENTILATION MAY BE NECESSARY FOR SOME OPERATIONS.
INDIVIDUAL PROTECTION MEASURES:
EYE/FACE PROTECTION: USE CHEMICAL GOGGLES.
SKIN PROTECTION:
HAND PROTECTION:
USE GLOVES CHEMICALLY RESISTANT TO THIS MATERIAL. EXAMPLES OF PREFERRED
GLOVE BARRIER MATERIALS INCLUDE: CHLORINATED POLYETHYLENE. NEOPRENE.
NITRILE/BUTADIENE RUBBER ("NITRILE" OR "NBR"). POLYETHYLENE. ETHYL VINYL
ALCOHOL LAMINATE ("EVAL"). POLYVINYL CHLORIDE ("PVC" OR "VINYL"). VITON.
POLYVINYL ALCOHOL ("PVA"). EXAMPLES OF ACCEPTABLE GLOVE BARRIER MATERIALS
INCLUDE: BUTYL RUBBER.
NOTICE:
THE SELECTION OF A SPECIFIC GLOVE FOR A PARTICULAR APPLICATION AND DURATION
OF USE IN A WORKPLACE SHOULD ALSO TAKE INTO ACCOUNT ALL RELEVANT WORKPLACE
FACTORS SUCH AS, BUT NOT LIMITED TO: OTHER CHEMICALS WHICH MAY BE HANDLED,
PHYSICAL REQUIREMENTS (CUT/PUNCTURE PROTECTION, DEXTERITY, THERMAL
PROTECTION), POTENTIAL BODY REACTIONS TO GLOVE MATERIALS, AS WELL AS THE
INSTRUCTIONS/SPECIFICATIONS PROVIDED BY THE GLOVE SUPPLIER.
OTHER PROTECTION:
USE PROTECTIVE CLOTHING CHEMICALLY RESISTANT TO THIS MATERIAL. SELECTION OF
SPECIFIC ITEMS SUCH AS FACE SHIELD, BOOTS, APRON, OR FULL BODY SUIT WILL
DEPEND ON THE TASK.
RESPIRATORY PROTECTION:
RESPIRATORY PROTECTION SHOULD BE WORN WHEN THERE IS A POTENTIAL TO EXCEED
THE EXPOSURE LIMIT REQUIREMENTS OR GUIDELINES. IF THERE ARE NO APPLICABLE
EXPOSURE LIMIT REQUIREMENTS OR GUIDELINES, WEAR RESPIRATORY PROTECTION WHEN
ADVERSE EFFECTS, SUCH AS RESPIRATORY IRRITATION OR DISCOMFORT HAVE BEEN
EXPERIENCED, OR WHERE INDICATED BY YOUR RISK ASSESSMENT PROCESS. IN MISTY
ATMOSPHERES, USE AN APPROVED PARTICULATE RESPIRATOR.
| THE FOLLOWING SHOULD BE EFFECTIVE TYPES OF AIR-PURIFYING RESPIRATORS:
| ORGANIC VAPOR CARTRIDGE WITH A PARTICULATE PRE-FILTER.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE:
PHYSICAL STATE: LIQUID
COLOR: COLORLESS TO PALE YELLOW
ODOR: SOLVENT-LIKE
ODOR THRESHOLD: NO DATA AVAILABLE
PH: NOT APPLICABLE, SUBSTANCE/MIXTURE IS NON-SOLUBLE (IN WATER)
MELTING POINT/RANGE: NO DATA AVAILABLE
FREEZING POINT: NO DATA AVAILABLE
BOILING POINT (760 MMHg): >80 DEG. C (>176 DEG. F)
FLASH POINT: TAG CLOSED CUP 13 DEG. C (55 DEG. F)
EVAPORATION RATE (BUTYL ACETATE = 1): NO DATA AVAILABLE
FLAMMABILITY (SOLID, GAS): NOT APPLICABLE
LOWER EXPLOSION LIMIT: NO DATA AVAILABLE
UPPER EXPLOSION LIMIT: NO DATA AVAILABLE
VAPOR PRESSURE: NO DATA AVAILABLE
RELATIVE VAPOR DENSITY (AIR = 1): NO DATA AVAILABLE
RELATIVE DENSITY (WATER = 1): 0.76
WATER SOLUBILITY: INSOLUBLE
PARTITION COEFFICIENT N-OCTANOL/WATER: NO DATA AVAILABLE
AUTO-IGNITION TEMPERATURE: NO DATA AVAILABLE
DECOMPOSITION TEMPERATURE: NO DATA AVAILABLE
KINEMATIC VISCOSITY: 1 MM2/S AT 25 DEG. C (77 DEG. F)
EXPLOSIVE PROPERTIES: NOT EXPLOSIVE
OXIDIZING PROPERTIES:
THE SUBSTANCE OR MIXTURE IS NOT CLASSIFIED AS OXIDIZING.
MOLECULAR WEIGHT: NO DATA AVAILABLE
PARTICLE SIZE: NOT APPLICABLE
NOTE:
THE PHYSICAL DATA PRESENTED ABOVE ARE TYPICAL VALUES AND SHOULD NOT BE
CONSTRUED AS A SPECIFICATION.
| 10. STABILITY AND REACTIVITY | |
REACTIVITY: NOT CLASSIFIED AS A REACTIVITY HAZARD.
CHEMICAL STABILITY: STABLE UNDER NORMAL CONDITIONS.
POSSIBILITY OF HAZARDOUS REACTIONS:
CAN REACT WITH STRONG OXIDIZING AGENTS. VAPORS MAY FORM EXPLOSIVE MIXTURE
WITH AIR. HIGHLY FLAMMABLE LIQUID AND VAPOUR.
CONDITIONS TO AVOID: AVOID STATIC DISCHARGE. HEAT, FLAMES AND SPARKS.
INCOMPATIBLE MATERIALS: AVOID CONTACT WITH OXIDIZING MATERIALS.
HAZARDOUS DECOMPOSITION PRODUCTS:
DECOMPOSITION PRODUCTS CAN INCLUDE AND ARE NOT LIMITED TO: ETHYLENE GLYCOL
MONOBUTYL ETHER. PROPYL ALCOHOL. BUTANOL.
| 11. TOXICOLOGICAL INFORMATION | |
TOXICOLOGICAL INFORMATION APPEARS IN THIS SECTION WHEN SUCH DATA IS
AVAILABLE.
INFORMATION ON LIKELY ROUTES OF EXPOSURE:
INHALATION, EYE CONTACT, SKIN CONTACT, INGESTION.
ACUTE TOXICITY (REPRESENTS SHORT TERM EXPOSURES WITH IMMEDIATE EFFECTS - NO
CHRONIC/DELAYED EFFECTS KNOWN UNLESS OTHERWISE NOTED):
ACUTE TOXICITY ENDPOINTS: NOT CLASSIFIED BASED ON AVAILABLE INFORMATION.
ACUTE ORAL TOXICITY:
INFORMATION FOR THE PRODUCT:
VERY LOW TOXICITY IF SWALLOWED. HARMFUL EFFECTS NOT ANTICIPATED FROM
SWALLOWING SMALL AMOUNTS.
AS PRODUCT: SINGLE DOSE ORAL LD50 HAS NOT BEEN DETERMINED.
BASED ON INFORMATION FOR COMPONENT(S): LD50, RAT, >5,000 MG/KG ESTIMATED.
INFORMATION FOR COMPONENTS:
DISTILLATES, PETROLEUM, LIGHT DISTILLATE HYDROTREATING PROCESS,
LOW-BOILING:
FOR SIMILAR MATERIAL(S):
LD50, RAT, MALE AND FEMALE, >5,000 MG/KG OECD 401 OR EQUIVALENT NO DEATHS
OCCURRED AT THIS CONCENTRATION.
TETRAKIS(2-BUTOXYETHYL) ORTHOSILICATE:
LD50, RAT,: >2,000 MG/KG
TETRA N-BUTYL TITANATE:
LD50, RAT, MALE,: 4,220 MG/KG
OCTANE:
FOR SIMILAR MATERIAL(S):
LD50, RAT, MALE AND FEMALE, >5,000 MG/KG OECD 401 OR EQUIVALENT
ACUTE DERMAL TOXICITY:
INFORMATION FOR THE PRODUCT:
PROLONGED SKIN CONTACT IS UNLIKELY TO RESULT IN ABSORPTION OF HARMFUL
AMOUNTS.
AS PRODUCT: THE DERMAL LD50 HAS NOT BEEN DETERMINED.
BASED ON INFORMATION FOR COMPONENT(S): LD50, >2,000 MG/KG ESTIMATED.
INFORMATION FOR COMPONENTS:
DISTILLATES, PETROLEUM, LIGHT DISTILLATE HYDROTREATING PROCESS,
LOW-BOILING:
FOR SIMILAR MATERIAL(S):
LD50, RABBIT, MALE AND FEMALE, >2,000 MG/KG OECD 402 OR EQUIVALENT NO
DEATHS OCCURRED AT THIS CONCENTRATION.
TETRAKIS(2-BUTOXYETHYL) ORTHOSILICATE:
INFORMATION TAKEN FROM REFERENCE WORKS AND THE LITERATURE. LD50, RAT,
>2,000 MG/KG
TETRA N-BUTYL TITANATE: LD50, RABBIT, 5,300 MG/KG
OCTANE:
FOR SIMILAR MATERIAL(S):
LD50, RABBIT, MALE AND FEMALE, >2,000 MG/KG OECD 402 OR EQUIVALENT NO
DEATHS OCCURRED AT THIS CONCENTRATION.
ACUTE INHALATION TOXICITY:
INFORMATION FOR THE PRODUCT:
BRIEF EXPOSURE (MINUTES) IS NOT LIKELY TO CAUSE ADVERSE EFFECTS. EXCESSIVE
EXPOSURE MAY CAUSE:
LUNG EFFECTS CENTRAL NERVOUS SYSTEM DEPRESSION MIST MAY CAUSE IRRITATION OF
UPPER RESPIRATORY TRACT (NOSE AND THROAT) AND LUNGS.
AS PRODUCT: THE LC50 HAS NOT BEEN DETERMINED.
INFORMATION FOR COMPONENTS:
DISTILLATES, PETROLEUM, LIGHT DISTILLATE HYDROTREATING PROCESS,
LOW-BOILING:
BRIEF EXPOSURE (MINUTES) IS NOT LIKELY TO CAUSE ADVERSE EFFECTS. EXCESSIVE
EXPOSURE MAY CAUSE: LUNG EFFECTS CENTRAL NERVOUS SYSTEM DEPRESSION
FOR SIMILAR MATERIAL(S): LC50, RAT, 4 HOUR, VAPOR, >5.61 MG/L
TETRAKIS(2-BUTOXYETHYL) ORTHOSILICATE:
BRIEF EXPOSURE (MINUTES) IS NOT LIKELY TO CAUSE ADVERSE EFFECTS.
TETRA N-BUTYL TITANATE: LC50, RAT, 4 HOUR, DUST/MIST, 11 MG/L
OCTANE:
LC50, RAT, MALE AND FEMALE, 4 HOUR, VAPOR, >24.88 MG/L OECD TEST GUIDELINE
403 NO DEATHS OCCURRED AT THIS CONCENTRATION.
SKIN CORROSION/IRRITATION: CAUSES SKIN IRRITATION.
INFORMATION FOR THE PRODUCT:
BASED ON INFORMATION FOR COMPONENT(S):
BRIEF CONTACT MAY CAUSE MODERATE SKIN IRRITATION WITH LOCAL REDNESS.
REPEATED CONTACT MAY CAUSE SKIN BURNS. SYMPTOMS MAY INCLUDE PAIN, SEVERE
LOCAL REDNESS, SWELLING, AND TISSUE DAMAGE.
MAY CAUSE PAIN.
MAY CAUSE DRYING AND FLAKING OF THE SKIN.
INFORMATION FOR COMPONENTS:
DISTILLATES, PETROLEUM, LIGHT DISTILLATE HYDROTREATING PROCESS,
LOW-BOILING:
FOR SIMILAR MATERIAL(S):
BRIEF CONTACT MAY CAUSE SEVERE SKIN IRRITATION WITH PAIN AND LOCAL REDNESS.
TETRAKIS(2-BUTOXYETHYL) ORTHOSILICATE:
BRIEF CONTACT MAY CAUSE MODERATE SKIN IRRITATION WITH LOCAL REDNESS.
TETRA N-BUTYL TITANATE:
PROLONGED CONTACT MAY CAUSE MODERATE SKIN IRRITATION WITH LOCAL REDNESS.
OCTANE:
PROLONGED CONTACT MAY CAUSE SKIN IRRITATION WITH LOCAL REDNESS.
REPEATED CONTACT MAY CAUSE SKIN BURNS. SYMPTOMS MAY INCLUDE PAIN, SEVERE
LOCAL REDNESS, SWELLING, AND TISSUE DAMAGE.
MAY CAUSE PAIN.
MAY CAUSE DRYING AND FLAKING OF THE SKIN.
SERIOUS EYE DAMAGE/EYE IRRITATION: CAUSES SERIOUS EYE DAMAGE.
INFORMATION FOR THE PRODUCT:
BASED ON INFORMATION FOR COMPONENT(S):
MAY CAUSE MODERATE EYE IRRITATION.
MAY CAUSE SEVERE CORNEAL INJURY.
MAY CAUSE PERMANENT IMPAIRMENT OF VISION.
INFORMATION FOR COMPONENTS:
DISTILLATES, PETROLEUM, LIGHT DISTILLATE HYDROTREATING PROCESS,
LOW-BOILING:
FOR SIMILAR MATERIAL(S):
MAY CAUSE SLIGHT TEMPORARY EYE IRRITATION.
CORNEAL INJURY IS UNLIKELY.
TETRAKIS(2-BUTOXYETHYL) ORTHOSILICATE: ESSENTIALLY NONIRRITATING TO EYES.
TETRA N-BUTYL TITANATE:
MAY CAUSE MODERATE EYE IRRITATION.
MAY CAUSE SEVERE CORNEAL INJURY.
MAY CAUSE PERMANENT IMPAIRMENT OF VISION.
OCTANE:
MAY CAUSE PAIN DISPROPORTIONATE TO THE LEVEL OF IRRITATION TO EYE TISSUES.
MAY CAUSE SLIGHT TEMPORARY EYE IRRITATION.
MAY CAUSE SLIGHT TEMPORARY CORNEAL INJURY.
SENSITIZATION:
FOR SKIN SENSITIZATION: NOT CLASSIFIED BASED ON AVAILABLE INFORMATION.
FOR RESPIRATORY SENSITIZATION:
NOT CLASSIFIED BASED ON AVAILABLE INFORMATION.
INFORMATION FOR THE PRODUCT:
FOR SKIN SENSITIZATION:
CONTAINS COMPONENT(S) WHICH DID NOT CAUSE ALLERGIC SKIN SENSITIZATION IN
GUINEA PIGS.
FOR RESPIRATORY SENSITIZATION: NO RELEVANT DATA FOUND.
INFORMATION FOR COMPONENTS:
DISTILLATES, PETROLEUM, LIGHT DISTILLATE HYDROTREATING PROCESS,
LOW-BOILING:
FOR SKIN SENSITIZATION:
FOR SIMILAR MATERIAL(S):
DID NOT CAUSE ALLERGIC SKIN REACTIONS WHEN TESTED IN GUINEA PIGS.
FOR RESPIRATORY SENSITIZATION: NO RELEVANT DATA FOUND.
TETRAKIS(2-BUTOXYETHYL) ORTHOSILICATE:
FOR SKIN SENSITIZATION:
DID NOT CAUSE ALLERGIC SKIN REACTIONS WHEN TESTED IN GUINEA PIGS.
NO RELEVANT DATA FOUND.
TETRA N-BUTYL TITANATE:
DID NOT DEMONSTRATE THE POTENTIAL FOR CONTACT ALLERGY IN MICE.
FOR RESPIRATORY SENSITIZATION: NO RELEVANT DATA FOUND.
OCTANE:
FOR SIMILAR MATERIAL(S):
DID NOT CAUSE ALLERGIC SKIN REACTIONS WHEN TESTED IN GUINEA PIGS.
FOR RESPIRATORY SENSITIZATION: NO RELEVANT DATA FOUND.
SPECIFIC TARGET ORGAN SYSTEMIC TOXICITY (SINGLE EXPOSURE):
MAY CAUSE DROWSINESS OR DIZZINESS.
INFORMATION FOR THE PRODUCT: PRODUCT TEST DATA NOT AVAILABLE.
INFORMATION FOR COMPONENTS:
DISTILLATES, PETROLEUM, LIGHT DISTILLATE HYDROTREATING PROCESS,
LOW-BOILING: MAY CAUSE DROWSINESS OR DIZZINESS.
ROUTE OF EXPOSURE: INHALATION
TARGET ORGANS: CENTRAL NERVOUS SYSTEM
TETRAKIS(2-BUTOXYETHYL) ORTHOSILICATE:
EVALUATION OF AVAILABLE DATA SUGGESTS THAT THIS MATERIAL IS NOT AN STOT-SE
TOXICANT.
TETRA N-BUTYL TITANATE:
MAY CAUSE RESPIRATORY IRRITATION.
ROUTE OF EXPOSURE: INHALATION
TARGET ORGANS: RESPIRATORY TRACT
MAY CAUSE DROWSINESS OR DIZZINESS.
ROUTE OF EXPOSURE: INHALATION
TARGET ORGANS: NERVOUS SYSTEM
OCTANE:
MAY CAUSE DROWSINESS OR DIZZINESS.
ROUTE OF EXPOSURE: INHALATION
TARGET ORGANS: CENTRAL NERVOUS SYSTEM
ASPIRATION HAZARD: MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS.
INFORMATION FOR THE PRODUCT:
ASPIRATION INTO THE LUNGS MAY OCCUR DURING INGESTION OR VOMITING, CAUSING
LUNG DAMAGE OR EVEN DEATH DUE TO CHEMICAL PNEUMONIA.
INFORMATION FOR COMPONENTS:
DISTILLATES, PETROLEUM, LIGHT DISTILLATE HYDROTREATING PROCESS,
LOW-BOILING: MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS.
TETRAKIS(2-BUTOXYETHYL) ORTHOSILICATE:
BASED ON PHYSICAL PROPERTIES, NOT LIKELY TO BE AN ASPIRATION HAZARD.
TETRA N-BUTYL TITANATE:
BASED ON AVAILABLE INFORMATION, ASPIRATION HAZARD COULD NOT BE DETERMINED.
OCTANE: MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS.
CHRONIC TOXICITY (REPRESENTS LONGER TERM EXPOSURES WITH REPEATED DOSE
RESULTING IN CHRONIC/DELAYED EFFECTS - NO IMMEDIATE EFFECTS KNOWN UNLESS
OTHERWISE NOTED):
SPECIFIC TARGET ORGAN SYSTEMIC TOXICITY (REPEATED EXPOSURE):
MAY CAUSE DAMAGE TO ORGANS (BLOOD) THROUGH PROLONGED OR REPEATED EXPOSURE.
INFORMATION FOR THE PRODUCT: PRODUCT TEST DATA NOT AVAILABLE.
INFORMATION FOR COMPONENTS:
DISTILLATES, PETROLEUM, LIGHT DISTILLATE HYDROTREATING PROCESS,
LOW-BOILING:
FOR SIMILAR MATERIAL(S):
KIDNEY EFFECTS HAVE BEEN OBSERVED IN MALE RATS. THESE EFFECTS ARE BELIEVED
TO BE SPECIES SPECIFIC AND UNLIKELY TO OCCUR IN HUMANS.
TETRAKIS(2-BUTOXYETHYL) ORTHOSILICATE:
| IN ANIMALS, EFFECTS HAVE BEEN REPORTED ON THE FOLLOWING ORGANS: BLOOD.
TETRA N-BUTYL TITANATE: NO RELEVANT DATA FOUND.
OCTANE: NO RELEVANT DATA FOUND.
CARCINOGENICITY: NOT CLASSIFIED BASED ON AVAILABLE INFORMATION.
INFORMATION FOR THE PRODUCT: PRODUCT TEST DATA NOT AVAILABLE.
INFORMATION FOR COMPONENTS:
DISTILLATES, PETROLEUM, LIGHT DISTILLATE HYDROTREATING PROCESS,
LOW-BOILING:
KIDNEY EFFECTS AND/OR TUMORS HAVE BEEN OBSERVED IN MALE RATS. THESE EFFECTS
ARE BELIEVED TO BE SPECIES SPECIFIC AND UNLIKELY TO OCCUR IN HUMANS.
TETRAKIS(2-BUTOXYETHYL) ORTHOSILICATE: NO RELEVANT DATA FOUND.
TETRA N-BUTYL TITANATE: NO RELEVANT DATA FOUND.
OCTANE: NO RELEVANT DATA FOUND.
CARCINOGENICITY:
COMPONENT LIST CLASSIFICATION
DISTILLATES, PETROLEUM, LIGHT IARC GROUP 2B: POSSIBLY CARCINOGENIC
DISTILLATE HYDROTREATING TO HUMANS
PROCESS, LOW-BOILING
TERATOGENICITY: NOT CLASSIFIED BASED ON AVAILABLE INFORMATION.
INFORMATION FOR THE PRODUCT: PRODUCT TEST DATA NOT AVAILABLE.
INFORMATION FOR COMPONENTS:
DISTILLATES, PETROLEUM, LIGHT DISTILLATE HYDROTREATING PROCESS,
LOW-BOILING:
FOR SIMILAR MATERIAL(S):
DID NOT CAUSE BIRTH DEFECTS OR ANY OTHER FETAL EFFECTS IN LABORATORY
ANIMALS.
| TETRAKIS(2-BUTOXYETHYL) ORTHOSILICATE:
| DID NOT CAUSE BIRTH DEFECTS IN LABORATORY ANIMALS.
TETRA N-BUTYL TITANATE: NO RELEVANT DATA FOUND.
OCTANE:
FOR SIMILAR MATERIAL(S): DID NOT CAUSE BIRTH DEFECTS IN LABORATORY ANIMALS.
REPRODUCTIVE TOXICITY: NOT CLASSIFIED BASED ON AVAILABLE INFORMATION.
INFORMATION FOR THE PRODUCT: PRODUCT TEST DATA NOT AVAILABLE.
INFORMATION FOR COMPONENTS:
DISTILLATES, PETROLEUM, LIGHT DISTILLATE HYDROTREATING PROCESS,
LOW-BOILING:
FOR SIMILAR MATERIAL(S):
IN ANIMAL STUDIES, DID NOT INTERFERE WITH REPRODUCTION.
TETRAKIS(2-BUTOXYETHYL) ORTHOSILICATE:
| IN LABORATORY ANIMALS, EXCESSIVE DOSES TOXIC TO THE PARENT ANIMALS CAUSED
| DECREASED WEIGHT AND SURVIVAL OF OFFSPRING.
TETRA N-BUTYL TITANATE: NO RELEVANT DATA FOUND.
OCTANE:
FOR SIMILAR MATERIAL(S):
IN ANIMAL STUDIES, DID NOT INTERFERE WITH REPRODUCTION.
MUTAGENICITY: NOT CLASSIFIED BASED ON AVAILABLE INFORMATION.
INFORMATION FOR THE PRODUCT: PRODUCT TEST DATA NOT AVAILABLE.
INFORMATION FOR COMPONENTS:
DISTILLATES, PETROLEUM, LIGHT DISTILLATE HYDROTREATING PROCESS,
LOW-BOILING:
FOR SIMILAR MATERIAL(S):
IN VITRO GENETIC TOXICITY STUDIES WERE NEGATIVE. ANIMAL GENETIC TOXICITY
STUDIES WERE NEGATIVE.
TETRAKIS(2-BUTOXYETHYL) ORTHOSILICATE: NO RELEVANT DATA FOUND.
TETRA N-BUTYL TITANATE: NO RELEVANT DATA FOUND.
OCTANE:
FOR SIMILAR MATERIAL(S): IN VITRO GENETIC TOXICITY STUDIES WERE NEGATIVE.
| 12. ECOLOGICAL INFORMATION | |
ECOTOXICOLOGICAL INFORMATION APPEARS IN THIS SECTION WHEN SUCH DATA IS
AVAILABLE.
TOXICITY:
DISTILLATES, PETROLEUM, LIGHT DISTILLATE HYDROTREATING PROCESS,
LOW-BOILING:
ACUTE TOXICITY TO FISH:
MATERIAL IS MODERATELY TOXIC TO AQUATIC ORGANISMS ON AN ACUTE BASIS
(LC50/EC50 BETWEEN 1 AND 10 MG/L IN THE MOST SENSITIVE SPECIES TESTED).
LL50, ONCORHYNCHUS MYKISS (RAINBOW TROUT), SEMI-STATIC TEST, 96 HOUR, 10
MG/L, OECD TEST GUIDELINE 203 OR EQUIVALENT
ACUTE TOXICITY TO AQUATIC INVERTEBRATES:
EL50, DAPHNIA MAGNA (WATER FLEA), STATIC TEST, 48 HOUR, 4.5 MG/L, OECD TEST
GUIDELINE 202 OR EQUIVALENT
ACUTE TOXICITY TO ALGAE/AQUATIC PLANTS:
FOR SIMILAR MATERIAL(S):
EC50, PSEUDOKIRCHNERIELLA SUBCAPITATA (GREEN ALGAE), 72 HOUR, GROWTH RATE,
3.1 MG/L, OECD TEST GUIDELINE 201
FOR SIMILAR MATERIAL(S):
NOELR, PSEUDOKIRCHNERIELLA SUBCAPITATA (GREEN ALGAE), 72 HOUR, GROWTH RATE,
0.5 MG/L, OECD TEST GUIDELINE 201
CHRONIC TOXICITY TO FISH:
FOR SIMILAR MATERIAL(S):
NOELR, PIMEPHALES PROMELAS (FATHEAD MINNOW), SEMI-STATIC TEST, 14 D,
MORTALITY, 2.6 MG/L
CHRONIC TOXICITY TO AQUATIC INVERTEBRATES:
BASED ON DATA FROM SIMILAR MATERIALS NOELR, DAPHNIA MAGNA (WATER FLEA),
SEMI-STATIC TEST, 21 D, NUMBER OF OFFSPRING, 2.6 MG/L
TETRAKIS(2-BUTOXYETHYL) ORTHOSILICATE:
ACUTE TOXICITY TO FISH:
MATERIAL IS PRACTICALLY NON-TOXIC TO FISH ON AN ACUTE BASIS (LC50 >100
MG/L).
LC50, DANIO RERIO (ZEBRA FISH), 96 HOUR, >201 MG/L, OECD TEST GUIDELINE 203
ACUTE TOXICITY TO AQUATIC INVERTEBRATES:
NO TOXICITY AT THE LIMIT OF SOLUBILITY
EC50, DAPHNIA SP. (WATER FLEA), 48 HOUR, >90 MG/L, EG 84/449
ACUTE TOXICITY TO ALGAE/AQUATIC PLANTS:
ERC50, SCENEDESMUS SUBSPICATUS, 72 HOUR, >161 MG/L, 88/302/EC
TETRA N-BUTYL TITANATE:
ACUTE TOXICITY TO FISH: NO RELEVANT DATA FOUND.
OCTANE:
ACUTE TOXICITY TO FISH:
MATERIAL IS HIGHLY TOXIC TO AQUATIC ORGANISMS ON AN ACUTE BASIS (LC50/EC50
BETWEEN 0.1 AND 1 MG/L IN THE MOST SENSITIVE SPECIES TESTED).
LC50, ORYZIAS LATIPES (ORANGE-RED KILLIFISH), 96 HOUR, 0.42 MG/L
ACUTE TOXICITY TO AQUATIC INVERTEBRATES:
EC50, DAPHNIA MAGNA (WATER FLEA), 48 HOUR, 0.3 MG/L, METHOD NOT SPECIFIED.
ACUTE TOXICITY TO ALGAE/AQUATIC PLANTS:
PSEUDOKIRCHNERIELLA SUBCAPITA, 72 HOUR, GROWTH RATE, >1.1 MG/L
CHRONIC TOXICITY TO AQUATIC INVERTEBRATES:
BASED ON DATA FROM SIMILAR MATERIALS
NOEC, DAPHNIA MAGNA (WATER FLEA), 21 D, 0.17 MG/L
PERSISTENCE AND DEGRADABILITY:
DISTILLATES, PETROLEUM, LIGHT DISTILLATE HYDROTREATING PROCESS,
LOW-BOILING:
BIODEGRADABILITY: NO RELEVANT DATA FOUND.
TETRAKIS(2-BUTOXYETHYL) ORTHOSILICATE:
BIODEGRADABILITY:
MATERIAL IS READILY BIODEGRADABLE. PASSES OECD TEST(S) FOR READY
BIODEGRADABILITY.
10-DAY WINDOW: PASS
BIODEGRADATION: 83%
METHOD: OECD TEST GUIDELINE 301B
TETRA N-BUTYL TITANATE:
BIODEGRADABILITY: NO RELEVANT DATA FOUND.
OCTANE:
BIODEGRADABILITY: MATERIAL IS EXPECTED TO BE READILY BIODEGRADABLE.
BIODEGRADATION: >60%
EXPOSURE TIME: 20 D
METHOD: OTHER GUIDELINES
BIOACCUMULATIVE POTENTIAL:
DISTILLATES, PETROLEUM, LIGHT DISTILLATE HYDROTREATING PROCESS,
LOW-BOILING:
BIOACCUMULATION:
BIOCONCENTRATION POTENTIAL IS HIGH (BCF >3000 OR LOG POW BETWEEN 5 AND 7).
TETRAKIS(2-BUTOXYETHYL) ORTHOSILICATE:
BIOACCUMULATION: NO RELEVANT DATA FOUND.
TETRA N-BUTYL TITANATE:
BIOACCUMULATION:
BIOCONCENTRATION POTENTIAL IS LOW (BCF <100 OR LOG POW <3).
PARTITION COEFFICIENT N-OCTANOL/WATER(LOG POW): 0.88 ESTIMATED.
OCTANE:
BIOACCUMULATION:
BIOCONCENTRATION POTENTIAL IS MODERATE (BCF BETWEEN 100 AND 3000 OR LOG POW
BETWEEN 3 AND 5).
PARTITION COEFFICIENT N-OCTANOL/WATER(LOG POW): 5.15 LITERATURE
BIOCONCENTRATION FACTOR (BCF):
198.7 MYTILUS EDULI (SALTWATER MUSSELS) 105 MIN
MOBILITY IN SOIL:
DISTILLATES, PETROLEUM, LIGHT DISTILLATE HYDROTREATING PROCESS,
LOW-BOILING: NO RELEVANT DATA FOUND.
TETRAKIS(2-BUTOXYETHYL) ORTHOSILICATE: NO RELEVANT DATA FOUND.
TETRA N-BUTYL TITANATE: NO RELEVANT DATA FOUND.
OCTANE: POTENTIAL FOR MOBILITY IN SOIL IS MEDIUM (KOC BETWEEN 150 AND 500).
PARTITION COEFFICIENT (KOC): 436.8 ESTIMATED.
| 13. DISPOSAL CONSIDERATIONS | |
DISPOSAL METHODS:
DO NOT DUMP INTO ANY SEWERS, ON THE GROUND, OR INTO ANY BODY OF WATER. ALL
DISPOSAL PRACTICES MUST BE IN COMPLIANCE WITH ALL FEDERAL, STATE/PROVINCIAL
AND LOCAL LAWS AND REGULATIONS. REGULATIONS MAY VARY IN DIFFERENT
LOCATIONS. WASTE CHARACTERIZATIONS AND COMPLIANCE WITH APPLICABLE LAWS ARE
THE RESPONSIBILITY SOLELY OF THE WASTE GENERATOR. AS YOUR SUPPLIER, WE HAVE
NO CONTROL OVER THE MANAGEMENT PRACTICES OR MANUFACTURING PROCESSES OF
PARTIES HANDLING OR USING THIS MATERIAL. THE INFORMATION PRESENTED HERE
PERTAINS ONLY TO THE PRODUCT AS SHIPPED IN ITS INTENDED CONDITION AS
DESCRIBED IN MSDS SECTION: COMPOSITION INFORMATION. FOR UNUSED &
UNCONTAMINATED PRODUCT, THE PREFERRED OPTIONS INCLUDE SENDING TO A
LICENSED, PERMITTED: INCINERATOR OR OTHER THERMAL DESTRUCTION DEVICE. FOR
ADDITIONAL INFORMATION, REFER TO: HANDLING & STORAGE INFORMATION, MSDS
SECTION 7 STABILITY & REACTIVITY INFORMATION, MSDS SECTION 10 REGULATORY
INFORMATION, MSDS SECTION 15
TREATMENT AND DISPOSAL METHODS OF USED PACKAGING:
EMPTY CONTAINERS SHOULD BE RECYCLED OR OTHERWISE DISPOSED OF BY AN APPROVED
WASTE MANAGEMENT FACILITY. WASTE CHARACTERIZATIONS AND COMPLIANCE WITH
APPLICABLE LAWS ARE THE RESPONSIBILITY SOLELY OF THE WASTE GENERATOR. DO
NOT RE-USE CONTAINERS FOR ANY PURPOSE.
| 14. TRANSPORT INFORMATION | |
DOT:
PROPER SHIPPING NAME: ADHESIVES
UN NUMBER: UN 1133
CLASS: 3
PACKING GROUP: II
CLASSIFICATION FOR SEA TRANSPORT (IMO-IMDG):
PROPER SHIPPING NAME: ADHESIVES
UN NUMBER: UN 1133
CLASS: 3
PACKING GROUP: II
MARINE POLLUTANT:
DISTILLATES, PETROLEUM, LIGHT DISTILLATE HYDROTREATING PROCESS,
LOW-BOILING
TRANSPORT IN BULK ACCORDING TO ANNEX I OR II OF MARPOL 73/78 AND THE IBC OR
IGC CODE: CONSULT IMO REGULATIONS BEFORE TRANSPORTING OCEAN BULK
CLASSIFICATION FOR AIR TRANSPORT (IATA/ICAO):
PROPER SHIPPING NAME: ADHESIVES
UN NUMBER: UN 1133
CLASS: 3
PACKING GROUP: II
THIS INFORMATION IS NOT INTENDED TO CONVEY ALL SPECIFIC REGULATORY OR
OPERATIONAL REQUIREMENTS/INFORMATION RELATING TO THIS PRODUCT.
TRANSPORTATION CLASSIFICATIONS MAY VARY BY CONTAINER VOLUME AND MAY BE
INFLUENCED BY REGIONAL OR COUNTRY VARIATIONS IN REGULATIONS. ADDITIONAL
TRANSPORTATION SYSTEM INFORMATION CAN BE OBTAINED THROUGH AN AUTHORIZED
SALES OR CUSTOMER SERVICE REPRESENTATIVE. IT IS THE RESPONSIBILITY OF THE
TRANSPORTING ORGANIZATION TO FOLLOW ALL APPLICABLE LAWS, REGULATIONS AND
RULES RELATING TO THE TRANSPORTATION OF THE MATERIAL.
| 15. REGULATORY INFORMATION | |
SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 TITLE III (EMERGENCY
PLANNING AND COMMUNITY RIGHT-TO-KNOW ACT OF 1986) SECTIONS 311 AND 312:
FLAMMABLE (GASES, AEROSOLS, LIQUIDS, OR SOLIDS)
HAZARD NOT OTHERWISE CLASSIFIED (PHYSICAL HAZARDS)
ASPIRATION HAZARD
SKIN CORROSION OR IRRITATION
SERIOUS EYE DAMAGE OR EYE IRRITATION
SPECIFIC TARGET ORGAN TOXICITY (SINGLE OR REPEATED EXPOSURE)
SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 TITLE III (EMERGENCY
PLANNING AND COMMUNITY RIGHT-TO-KNOW ACT OF 1986) SECTION 313:
THIS MATERIAL DOES NOT CONTAIN ANY CHEMICAL COMPONENTS WITH KNOWN CAS
NUMBERS THAT EXCEED THE THRESHOLD (DE MINIMIS) REPORTING LEVELS ESTABLISHED
BY SARA TITLE III, SECTION 313.
PENNSYLVANIA RIGHT TO KNOW:
THE FOLLOWING CHEMICALS ARE LISTED BECAUSE OF THE ADDITIONAL REQUIREMENTS
OF PENNSYLVANIA LAW:
COMPONENTS CASRN
DISTILLATES, PETROLEUM, LIGHT DISTILLATE 68410-97-9
HYDROTREATING PROCESS, LOW-BOILING
TETRA N-BUTYL TITANATE 5593-70-4
TETRAPROPYL ORTHOSILICATE 682-01-9
TETRAKIS(2-BUTOXYETHYL) ORTHOSILICATE 18765-38-3
OCTANE 111-65-9
CALIFORNIA PROP. 65:
WARNING:
THIS PRODUCT CAN EXPOSE YOU TO CHEMICALS INCLUDING ETHYLBENZENE, BENZENE,
WHICH IS/ARE KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER, AND TOLUENE,
BENZENE, WHICH IS/ARE KNOWN TO THE STATE OF CALIFORNIA TO CAUSE BIRTH
DEFECTS OR OTHER REPRODUCTIVE HARM. FOR MORE INFORMATION GO TO
WWW.P65WARNINGS.CA.GOV.
UNITED STATES TSCA INVENTORY (TSCA):
ALL COMPONENTS OF THIS PRODUCT ARE IN COMPLIANCE WITH THE INVENTORY LISTING
REQUIREMENTS OF THE U.S. TOXIC SUBSTANCES CONTROL ACT (TSCA) CHEMICAL
SUBSTANCE INVENTORY.
| 16. OTHER INFORMATION | |
HAZARD RATING SYSTEM:
NFPA:
HEALTH 3
FLAMMABILITY 3
INSTABILITY 0
HMIS:
HEALTH 3*
FLAMMABILITY 3
PHYSICAL HAZARD 0
* = CHRONIC EFFECTS (SEE HAZARDS IDENTIFICATION)
REVISION:
IDENTIFICATION NUMBER: 6022263 / A001
ISSUE DATE: 07/12/2022
VERSION: 13.0
MOST RECENT REVISION(S) ARE NOTED BY THE BOLD, DOUBLE BARS IN LEFT-HAND
MARGIN THROUGHOUT THIS DOCUMENT.
LEGEND:
ACGIH: USA. ACGIH THRESHOLD LIMIT VALUES (TLV)
ACGIH BEI: ACGIH - BIOLOGICAL EXPOSURE INDICES (BEI)
OSHA Z-1:
USA. OCCUPATIONAL EXPOSURE LIMITS (OSHA) - TABLE Z-1 LIMITS FOR AIR
CONTAMINANTS
TWA: 8-HOUR, TIME-WEIGHTED AVERAGE
FULL TEXT OF OTHER ABBREVIATIONS:
AIIC: AUSTRALIAN INVENTORY OF INDUSTRIAL CHEMICALS
ASTM: AMERICAN SOCIETY FOR THE TESTING OF MATERIALS
BW: BODY WEIGHT
CERCLA:
COMPREHENSIVE ENVIRONMENTAL RESPONSE, COMPENSATION, AND LIABILITY ACT
CMR: CARCINOGEN, MUTAGEN OR REPRODUCTIVE TOXICANT
DIN: STANDARD OF THE GERMAN INSTITUTE FOR STANDARDIZATION
DOT: DEPARTMENT OF TRANSPORTATION
DSL: DOMESTIC SUBSTANCES LIST (CANADA)
ECX: CONCENTRATION ASSOCIATED WITH X% RESPONSE
EHS: EXTREMELY HAZARDOUS SUBSTANCE
ELX: LOADING RATE ASSOCIATED WITH X% RESPONSE
EMS: EMERGENCY SCHEDULE
ENCS: EXISTING AND NEW CHEMICAL SUBSTANCES (JAPAN)
ERCX: CONCENTRATION ASSOCIATED WITH X% GROWTH RATE RESPONSE
ERG: EMERGENCY RESPONSE GUIDE
GHS: GLOBALLY HARMONIZED SYSTEM
GLP: GOOD LABORATORY PRACTICE
HMIS: HAZARDOUS MATERIALS IDENTIFICATION SYSTEM
IARC: INTERNATIONAL AGENCY FOR RESEARCH ON CANCER
IATA: INTERNATIONAL AIR TRANSPORT ASSOCIATION
IBC:
INTERNATIONAL CODE FOR THE CONSTRUCTION AND EQUIPMENT OF SHIPS CARRYING
DANGEROUS CHEMICALS IN BULK
IC50: HALF MAXIMAL INHIBITORY CONCENTRATION
ICAO: INTERNATIONAL CIVIL AVIATION ORGANIZATION
IECSC: INVENTORY OF EXISTING CHEMICAL SUBSTANCES IN CHINA
IMDG: INTERNATIONAL MARITIME DANGEROUS GOODS
IMO: INTERNATIONAL MARITIME ORGANIZATION
ISHL: INDUSTRIAL SAFETY AND HEALTH LAW (JAPAN)
ISO: INTERNATIONAL ORGANIZATION FOR STANDARDIZATION
KECI: KOREA EXISTING CHEMICALS INVENTORY
LC50: LETHAL CONCENTRATION TO 50% OF A TEST POPULATION
LD50: LETHAL DOSE TO 50% OF A TEST POPULATION (MEDIAN LETHAL DOSE)
MARPOL: INTERNATIONAL CONVENTION FOR THE PREVENTION OF POLLUTION FROM SHIPS
MSHA: MINE SAFETY AND HEALTH ADMINISTRATION
N.O.S.: NOT OTHERWISE SPECIFIED
NFPA: NATIONAL FIRE PROTECTION ASSOCIATION
NO(A)EC: NO OBSERVED (ADVERSE) EFFECT CONCENTRATION
NO(A)EL: NO OBSERVED (ADVERSE) EFFECT LEVEL
NOELR: NO OBSERVABLE EFFECT LOADING RATE
NTP: NATIONAL TOXICOLOGY PROGRAM
NZIOC: NEW ZEALAND INVENTORY OF CHEMICALS
OECD: ORGANIZATION FOR ECONOMIC CO-OPERATION AND DEVELOPMENT
OPPTS: OFFICE OF CHEMICAL SAFETY AND POLLUTION PREVENTION
PBT: PERSISTENT, BIOACCUMULATIVE AND TOXIC SUBSTANCE
PICCS: PHILIPPINES INVENTORY OF CHEMICALS AND CHEMICAL SUBSTANCES
(Q)SAR: (QUANTITATIVE) STRUCTURE ACTIVITY RELATIONSHIP
RCRA: RESOURCE CONSERVATION AND RECOVERY ACT
REACH:
REGULATION (EC) NO 1907/2006 OF THE EUROPEAN PARLIAMENT AND OF THE COUNCIL
CONCERNING THE REGISTRATION, EVALUATION, AUTHORIZATION AND RESTRICTION OF
CHEMICALS
RQ: REPORTABLE QUANTITY
SADT: SELF-ACCELERATING DECOMPOSITION TEMPERATURE
SARA: SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT
SDS: SAFETY DATA SHEET
TCSI: TAIWAN CHEMICAL SUBSTANCE INVENTORY
TECI: THAILAND EXISTING CHEMICALS INVENTORY
TSCA: TOXIC SUBSTANCES CONTROL ACT (UNITED STATES)
UN: UNITED NATIONS
UNRTDG: UNITED NATIONS RECOMMENDATIONS ON THE TRANSPORT OF DANGEROUS GOODS
VPVB: VERY PERSISTENT AND VERY BIOACCUMULATIVE
INFORMATION SOURCE AND REFERENCES:
THIS SDS IS PREPARED BY PRODUCT REGULATORY SERVICES AND HAZARD
COMMUNICATIONS GROUPS FROM INFORMATION SUPPLIED BY INTERNAL REFERENCES
WITHIN OUR COMPANY.
THE DOW CHEMICAL COMPANY URGES EACH CUSTOMER OR RECIPIENT OF THIS (M)SDS TO
STUDY IT CAREFULLY AND CONSULT APPROPRIATE EXPERTISE, AS NECESSARY OR
APPROPRIATE, TO BECOME AWARE OF AND UNDERSTAND THE DATA CONTAINED IN THIS
(M)SDS AND ANY HAZARDS ASSOCIATED WITH THE PRODUCT. THE INFORMATION HEREIN
IS PROVIDED IN GOOD FAITH AND BELIEVED TO BE ACCURATE AS OF THE EFFECTIVE
DATE SHOWN ABOVE. HOWEVER, NO WARRANTY, EXPRESS OR IMPLIED, IS GIVEN.
REGULATORY REQUIREMENTS ARE SUBJECT TO CHANGE AND MAY DIFFER BETWEEN
VARIOUS LOCATIONS. IT IS THE BUYER'S/USER'S RESPONSIBILITY TO ENSURE THAT
HIS ACTIVITIES COMPLY WITH ALL FEDERAL, STATE, PROVINCIAL OR LOCAL LAWS.
THE INFORMATION PRESENTED HERE PERTAINS ONLY TO THE PRODUCT AS SHIPPED.
SINCE CONDITIONS FOR USE OF THE PRODUCT ARE NOT UNDER THE CONTROL OF THE
MANUFACTURER, IT IS THE BUYER'S/USER'S DUTY TO DETERMINE THE CONDITIONS
NECESSARY FOR THE SAFE USE OF THIS PRODUCT. DUE TO THE PROLIFERATION OF
SOURCES FOR INFORMATION SUCH AS MANUFACTURER-SPECIFIC (M)SDSS, WE ARE NOT
AND CANNOT BE RESPONSIBLE FOR (M)SDSS OBTAINED FROM ANY SOURCE OTHER THAN
OURSELVES. IF YOU HAVE OBTAINED AN (M)SDS FROM ANOTHER SOURCE OR IF YOU ARE
NOT SURE THAT THE (M)SDS YOU HAVE IS CURRENT, PLEASE CONTACT US FOR THE
MOST CURRENT VERSION.
US
(R*) (TM) TRADEMARK OF THE DOW CHEMICAL COMPANY ("DOW") OR AN AFFILIATED
COMPANY OF DOW
GENERAL BUSINESS