| Common Name: | STRUST SSPR 6PK LEAK SEAL BLACK, 265494 |
| Manufacturer: | RUST-OLEUM |
| SDS Revision Date: | 5/8/2019 |
| SDS Format: | GHS-US |
| Item Number(s): | 55CN34 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
DATE PRINTED: 5/8/2019
SAFETY DATA SHEET
RUST-OLEUM CORPORATION
TRUSTED QUALITY SINCE 1921
WWW.RUSTOLEUM.COM
| 1. IDENTIFICATION |  |
PRODUCT NAME: STRUST SSPR 6PK LEAK SEAL BLACK
PRODUCT IDENTIFIER: 265494
SUPERCEDES DATE: 4/9/2019
REVISION DATE: 5/8/2019
RECOMMENDED USE: NO INFORMATION
SUPPLIER:
RUST-OLEUM CORPORATION
11 HAWTHORN PARKWAY
VERNON HILLS, IL 60061
USA
MANUFACTURER:
RUST-OLEUM CORPORATION
11 HAWTHORN PARKWAY
VERNON HILLS, IL 60061
USA
PREPARER: REGULATORY DEPARTMENT
EMERGENCY TELEPHONE:
24 HOUR HOTLINE: 847-367-7700
| 2. HAZARD IDENTIFICATION | |
CLASSIFICATION:
SYMBOL(S) OF PRODUCT:
FLAME
EXCLAMATION MARK
HEALTH HAZARD
GAS CYLINDER
SIGNAL WORD: DANGER
POSSIBLE HAZARDS:
64% OF THE MIXTURE CONSISTS OF INGREDIENT(S) OF UNKNOWN ACUTE TOXICITY.
GHS HAZARD STATEMENTS:
CARCINOGENICITY, CATEGORY 1A:
H350: MAY CAUSE CANCER.
COMPRESSED GAS:
H280: CONTAINS GAS UNDER PRESSURE; MAY EXPLODE IF HEATED.
EYE IRRITATION, CATEGORY 2A:
H319: CAUSES SERIOUS EYE IRRITATION.
FLAMMABLE AEROSOL, CATEGORY 1:
H222: EXTREMELY FLAMMABLE AEROSOL.
GERM CELL MUTAGENICITY, CATEGORY 1A:
H340: MAY CAUSE GENETIC DEFECTS.
STOT, REPEATED EXPOSURE, CATEGORY 2:
H373: MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE.
SKIN SENSITIZER, CATEGORY 1:
H317: MAY CAUSE AN ALLERGIC SKIN REACTION.
GHS LABEL PRECAUTIONARY STATEMENTS:
P201: OBTAIN SPECIAL INSTRUCTIONS BEFORE USE.
P210:
KEEP AWAY FROM HEAT, HOT SURFACES, SPARKS, OPEN FLAMES AND OTHER IGNITION
SOURCES. NO SMOKING.
P211: DO NOT SPRAY ON AN OPEN FLAME OR OTHER IGNITION SOURCE.
P251: DO NOT PIERCE OR BURN, EVEN AFTER USE.
P260: DO NOT BREATHE DUST/FUME/GAS/MIST/VAPORS/SPRAY.
P264: WASH HANDS THOROUGHLY AFTER HANDLING.
P272:
CONTAMINATED WORK CLOTHING SHOULD NOT BE ALLOWED OUT OF THE WORKPLACE.
P280:
WEAR PROTECTIVE GLOVES/PROTECTIVE CLOTHING/EYE PROTECTION/FACE PROTECTION.
P302+P352:
IF ON SKIN: WASH WITH PLENTY OF SOAP AND WATER.
P305+P351+P338:
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES, IF
PRESENT AND EASY TO DO. CONTINUE RINSING.
P308+P313:
IF EXPOSED OR CONCERNED: GET MEDICAL ADVICE/ATTENTION.
P314: GET MEDICAL ADVICE/ATTENTION IF YOU FEEL UNWELL.
P321: FOR SPECIFIC TREATMENT SEE LABEL
P333+P313:
IF SKIN IRRITATION OR RASH OCCURS: GET MEDICAL ADVICE/ATTENTION.
P337+P313:
IF EYE IRRITATION PERSISTS: GET MEDICAL ADVICE/ATTENTION.
P405: STORE LOCKED UP.
P410+P403: PROTECT FROM SUNLIGHT. STORE IN A WELL-VENTILATED PLACE.
P410+P412:
PROTECT FROM SUNLIGHT. DO NOT EXPOSE TO TEMPERATURES EXCEEDING 50 DEG. C /
122 DEG. F.
P501:
DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH LOCAL, REGIONAL AND
NATIONAL REGULATIONS.
GHS SDS PRECAUTIONARY STATEMENTS:
P363: WASH CONTAMINATED CLOTHING BEFORE REUSE.
| 3. COMPOSITION / INFORMATION ON INGREDIENTS | |
HAZARDOUS SUBSTANCES:
CHEMICAL NAME CAS-NO. WT.% GHS SYMBOLS GHS
RANGE STATEMENTS
NAPHTHA, PETROLEUM, 64742-49-0 10-25 GHS08 H304
HYDROTREATED LIGHT
PROPANE 74-98-6 10-25 GHS04 H280
DIMETHYL CARBONATE 616-38-6 10-25 GHS02 H225
N-BUTANE 106-97-8 2.5-10 GHS04 H280
HYDROUS MAGNESIUM 14807-96-6 2.5-10 NOT AVAILABLE NOT
SILICATE AVAILABLE
XYLENES (O-, M-, P- 1330-20-7 2.5-10 GHS02-GHS07 H226-315-
ISOMERS) 319-332
ETHYL ACETATE 141-78-6 2.5-10 GHS02-GHS07 H225-319-
332-336
N-BUTYL ACETATE 123-86-4 1.0-2.5 GHS02-GHS07 H226-336
METHYL ISOBUTYL KETONE 108-10-1 1.0-2.5 GHS02-GHS06 H225-319-
331-335
ETHYLBENZENE 100-41-4 1.0-2.5 GHS02-GHS07- H225-304-
GHS08 332-351-
373
N-HEPTANE 142-82-5 1.0-2.5 GHS02-GHS07- H225-304-
GHS08 315-336
OCTANE 111-65-9 1.0-2.5 GHS02-GHS07- H225-304-
GHS08 315-336
MEDIUM OIL ALKYD PROPRIETARY 1.0-2.5 NOT AVAILABLE NOT
AVAILABLE
CARBON BLACK 1333-86-4 0.1-1.0 NOT AVAILABLE NOT
AVAILABLE
METHANOL 67-56-1 0.1-1.0 GHS02-GHS06- H225-331-
GHS08 370
STODDARD SOLVENT 8052-41-3 0.1-1.0 GHS08 H304-372
BIS(1,2,2,6,6-PENTAMETHYL- 41556-26-7 0.1-1.0 GHS07 H317
4-PIPERIDINYL) SEBACATE
| 4. FIRST-AID MEASURES | |
FIRST AID - EYE CONTACT:
IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES HOLDING
EYELIDS OPEN. GET MEDICAL ATTENTION. DO NOT ALLOW RUBBING OF EYES OR
KEEPING EYES CLOSED.
FIRST AID - SKIN CONTACT:
WASH SKIN WITH SOAP AND WATER. REMOVE CONTAMINATED CLOTHING. GET MEDICAL
ATTENTION IF IRRITATION DEVELOPS OR PERSISTS.
FIRST AID - INHALATION:
REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE ARTIFICIAL RESPIRATION. IF
BREATHING IS DIFFICULT, GIVE OXYGEN. GET IMMEDIATE MEDICAL ATTENTION. DO
NOT USE MOUTH-TO-MOUTH RESUSCITATION. IF YOU EXPERIENCE DIFFICULTY IN
BREATHING, LEAVE THE AREA TO OBTAIN FRESH AIR. IF CONTINUED DIFFICULTY IS
EXPERIENCED, GET MEDICAL ASSISTANCE IMMEDIATELY.
FIRST AID - INGESTION:
ASPIRATION HAZARD:
DO NOT INDUCE VOMITING OR GIVE ANYTHING BY MOUTH BECAUSE THIS MATERIAL
CAN ENTER THE LUNGS AND CAUSE SEVERE LUNG DAMAGE. GET IMMEDIATE MEDICAL
ATTENTION. IF SWALLOWED, GET MEDICAL ATTENTION.
| 5. FIRE-FIGHTING MEASURES | |
EXTINGUISHING MEDIA:
ALCOHOL FILM FORMING FOAM, CARBON DIOXIDE, DRY CHEMICAL, DRY SAND, WATER
FOG
UNUSUAL FIRE AND EXPLOSION HAZARDS:
FLASH POINT IS LESS THAN 20 DEG. F. EXTREMELY FLAMMABLE LIQUID AND VAPOR!
WATER SPRAY MAY BE INEFFECTIVE. CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT DUE TO BUILDUP OF STEAM. CLOSED CONTAINERS MAY
EXPLODE WHEN EXPOSED TO EXTREME HEAT. VAPORS MAY FORM EXPLOSIVE MIXTURES
WITH AIR. VAPORS CAN TRAVEL TO A SOURCE OF IGNITION AND FLASH BACK. KEEP
CONTAINERS TIGHTLY CLOSED. ISOLATE FROM HEAT, ELECTRICAL EQUIPMENT, SPARKS
AND OPEN FLAME. PERFORATION OF THE PRESSURIZED CONTAINER MAY CAUSE BURSTING
OF THE CAN. NO UNUSUAL FIRE OR EXPLOSION HAZARDS NOTED.
SPECIAL FIREFIGHTING PROCEDURES:
WATER MAY BE USED TO COOL CLOSED CONTAINERS TO PREVENT PRESSURE BUILDUP AND
POSSIBLE AUTOIGNITION OR EXPLOSION. FULL PROTECTIVE EQUIPMENT INCLUDING
SELF-CONTAINED BREATHING APPARATUS SHOULD BE USED. EVACUATE AREA AND FIGHT
FIRE FROM A SAFE DISTANCE. USE WATER SPRAY TO KEEP FIRE-EXPOSED CONTAINERS
COOL. CONTAINERS MAY EXPLODE WHEN HEATED. SPECIAL FIRE AND EXPLOSION HAZARD
(COMBUSTIBLE DUST): NO INFORMATION
| 6. ACCIDENTAL RELEASE MEASURES | |
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED:
CONTAIN SPILLED LIQUID WITH SAND OR EARTH. DO NOT USE COMBUSTIBLE MATERIALS
SUCH AS SAWDUST. ISOLATE THE HAZARD AREA AND DENY ENTRY TO UNNECESSARY AND
UNPROTECTED PERSONNEL. REMOVE ALL SOURCES OF IGNITION, VENTILATE AREA AND
REMOVE WITH INERT ABSORBENT AND NON-SPARKING TOOLS. DISPOSE OF ACCORDING TO
LOCAL, STATE (PROVINCIAL) AND FEDERAL REGULATIONS. DO NOT INCINERATE CLOSED
CONTAINERS. VENTILATE AREA, ISOLATE SPILLED MATERIAL, AND REMOVE WITH INERT
ABSORBENT. DISPOSE OF CONTAMINATED ABSORBENT, CONTAINER, AND UNUSED
CONTENTS IN ACCORDANCE WITH LOCAL, STATE, AND FEDERAL REGULATIONS.
| 7. HANDLING AND STORAGE | |
HANDLING:
WASH THOROUGHLY AFTER HANDLING. WASH HANDS BEFORE EATING. REMOVE
CONTAMINATED CLOTHING AND LAUNDER BEFORE REUSE. USE ONLY WITH ADEQUATE
VENTILATION. FOLLOW ALL SDS AND LABEL PRECAUTIONS EVEN AFTER CONTAINER
IS EMPTIED BECAUSE IT MAY RETAIN PRODUCT RESIDUES. AVOID BREATHING FUMES,
VAPORS, OR MIST. AVOID CONTACT WITH EYES, SKIN AND CLOTHING.
STORAGE:
STORE IN A DRY, WELL VENTILATED PLACE. KEEP CONTAINER TIGHTLY CLOSED WHEN
NOT IN USE. KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE FROM HEAT, ELECTRICAL
EQUIPMENT, SPARKS AND OPEN FLAME. CONTENTS UNDER PRESSURE. DO NOT STORE
ABOVE 120 DEG. F. STORE LARGE QUANTITIES IN BUILDINGS DESIGNED AND
PROTECTED FOR STORAGE OF FLAMMABLE AEROSOLS. KEEP AWAY FROM HEAT, SPARKS,
FLAME AND SOURCES OF IGNITION. AVOID EXCESS HEAT. PRODUCT SHOULD BE STORED
IN TIGHTLY SEALED CONTAINERS AND PROTECTED FROM HEAT, MOISTURE, AND FOREIGN
MATERIALS.
ADVICE ON SAFE HANDLING OF COMBUSTIBLE DUST: NO INFORMATION
| 8. EXPOSURE CONTROLS / PERSONAL PROTECTION | |
CHEMICAL NAME CAS-NO. WEIGHT % LESS THAN
NAPHTHA, PETROLEUM, HYDROTREATED 64742-49-0 25.0
LIGHT
PROPANE 74-98-6 20.0
DIMETHYL CARBONATE 616-38-6 15.0
N-BUTANE 106-97-8 10.0
HYDROUS MAGNESIUM SILICATE 14807-96-6 10.0
XYLENES (O-, M-, P- ISOMERS) 1330-20-7 10.0
ETHYL ACETATE 141-78-6 5.0
N-BUTYL ACETATE 123-86-4 5.0
METHYL ISOBUTYL KETONE 108-10-1 5.0
ETHYLBENZENE 100-41-4 5.0
OCTANE 111-65-9 5.0
N-HEPTANE 142-82-5 5.0
MEDIUM OIL ALKYD PROPRIETARY 5.0
CARBON BLACK 1333-86-4 1.0
METHANOL 67-56-1 1.0
STODDARD SOLVENT 8052-41-3 1.0
BIS(1,2,2,6,6-PENTAMETHYL-4- 41556-26-7 1.0
PIPERIDINYL) SEBACATE
CHEMICAL NAME ACGIH ACGIH TLV-STEL OSHA PEL-TWA OSHA PEL-
TLV-TWA CEILING
NAPHTHA, PETROLEUM, N.E. N.E. N.E. N.E.
HYDROTREATED LIGHT
PROPANE N.E. N.E. 1000 PPM N.E.
DIMETHYL CARBONATE N.E. N.E. N.E. N.E.
N-BUTANE N.E. 1000 PPM N.E. N.E.
HYDROUS MAGNESIUM 2 MG/M3 N.E. N.E. N.E.
SILICATE
XYLENES (O-, M-, 100 PPM 150 PPM 100 PPM N.E.
P- ISOMERS)
ETHYL ACETATE 400 PPM N.E. 400 PPM N.E.
N-BUTYL ACETATE 50 PPM 150 PPM 150 PPM N.E.
METHYL ISOBUTYL 20 PPM 75 PPM 100 PPM N.E.
KETONE
ETHYLBENZENE 20 PPM N.E. 100 PPM N.E.
OCTANE 300 PPM N.E. 500 PPM N.E.
N-HEPTANE 400 PPM 500 PPM 500 PPM N.E.
MEDIUM OIL ALKYD N.E. N.E. N.E. N.E.
CARBON BLACK 3 MG/M3 N.E. 3.5 MG/M3 N.E.
METHANOL 200 PPM 250 PPM 200 PPM N.E.
STODDARD SOLVENT 100 PPM N.E. 500 PPM N.E.
BIS(1,2,2,6,6- N.E. N.E. N.E. N.E.
PENTAMETHYL-4-
PIPERIDINYL)
SEBACATE
PERSONAL PROTECTION:
ENGINEERING CONTROLS:
USE PROCESS ENCLOSURES, LOCAL EXHAUST VENTILATION, OR OTHER ENGINEERING
CONTROLS TO CONTROL AIRBORNE LEVELS BELOW RECOMMENDED EXPOSURE LIMITS. USE
EXPLOSION-PROOF VENTILATION EQUIPMENT. PROVIDE GENERAL DILUTION OF LOCAL
EXHAUST VENTILATION IN VOLUME AND PATTERN TO KEEP TLV OF HAZARDOUS
INGREDIENTS BELOW ACCEPTABLE LIMITS. PREVENT BUILD-UP OF VAPORS BY OPENING
ALL DOORS AND WINDOWS TO ACHIEVE CROSS-VENTILATION.
RESPIRATORY PROTECTION:
A RESPIRATORY PROTECTION PROGRAM THAT MEETS OSHA 1910.134 AND ANSI Z88.2
REQUIREMENTS MUST BE FOLLOWED WHENEVER WORKPLACE CONDITIONS WARRANT A
RESPIRATOR'S USE. A NIOSH/MSHA APPROVED AIR PURIFYING RESPIRATOR WITH
ORGANIC VAPOR CARTRIDGE OR CANISTER MAY BE PERMISSIBLE UNDER CERTAIN
CIRCUMSTANCES WHERE AIRBORNE CONCENTRATIONS ARE EXPECTED TO EXCEED
EXPOSURE LIMITS.
SKIN PROTECTION:
USE GLOVES TO PREVENT PROLONGED SKIN CONTACT. NITRILE OR NEOPRENE GLOVES
MAY AFFORD ADEQUATE SKIN PROTECTION.
EYE PROTECTION:
USE SAFETY EYEWEAR DESIGNED TO PROTECT AGAINST SPLASH OF LIQUIDS.
OTHER PROTECTIVE EQUIPMENT:
REFER TO SAFETY SUPERVISOR OR INDUSTRIAL HYGIENIST FOR FURTHER GUIDANCE
REGARDING TYPES OF PERSONAL PROTECTIVE EQUIPMENT AND THEIR APPLICATIONS.
HYGIENIC PRACTICES:
WASH THOROUGHLY WITH SOAP AND WATER BEFORE EATING, DRINKING OR SMOKING.
REMOVE CONTAMINATED CLOTHING IMMEDIATELY AND LAUNDER BEFORE REUSE.
ENGINEERING MEASURES FOR COMBUSTIBLE DUST: NO INFORMATION
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE: AEROSOLIZED MIST
PHYSICAL STATE: LIQUID
ODOR: SOLVENT LIKE
ODOR THRESHOLD: N.E.
SPECIFIC GRAVITY: 0.783
PH: N.A.
FREEZE POINT, DEG. C: N.D.
VISCOSITY: N.D.
SOLUBILITY IN WATER: SLIGHT
PARTITION COEFFICIENT, N-OCTANOL/WATER: N.D.
DECOMPOSITION TEMP., DEG. C: N.D.
BOILING RANGE, DEG. C: -37 - 537
EXPLOSIVE LIMITS, VOL%: 0.9 - 10.7
FLAMMABILITY: SUPPORTS COMBUSTION
FLASH POINT, DEG. C: -96
EVAPORATION RATE: FASTER THAN ETHER
AUTO-IGNITION TEMP., DEG. C: N.D.
VAPOR DENSITY: HEAVIER THAN AIR
VAPOR PRESSURE: N.D.
(SEE "OTHER INFORMATION" SECTION FOR ABBREVIATION LEGEND)
| 10. STABILITY AND REACTIVITY | |
CONDITIONS TO AVOID:
AVOID TEMPERATURES ABOVE 120 DEG. F (49 DEG. C). AVOID ALL POSSIBLE SOURCES
OF IGNITION.
INCOMPATIBILITY:
INCOMPATIBLE WITH STRONG OXIDIZING AGENTS, STRONG ACIDS AND STRONG ALKALIS.
HAZARDOUS DECOMPOSITION:
BY OPEN FLAME, CARBON MONOXIDE AND CARBON DIOXIDE. WHEN HEATED TO
DECOMPOSITION, IT EMITS ACRID SMOKE AND IRRITATING FUMES. CONTAINS
SOLVENTS WHICH MAY FORM CARBON MONOXIDE, CARBON DIOXIDE, AND FORMALDEHYDE.
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR UNDER NORMAL CONDITIONS.
STABILITY:
THIS PRODUCT IS STABLE UNDER NORMAL STORAGE CONDITIONS. MAY FORM PEROXIDES
OF UNKNOWN STABILITY.
| 11. TOXICOLOGICAL INFORMATION | |
EFFECTS OF OVEREXPOSURE - EYE CONTACT: CAUSES SERIOUS EYE IRRITATION
EFFECTS OF OVEREXPOSURE - SKIN CONTACT:
MAY CAUSE SKIN IRRITATION. ALLERGIC REACTIONS ARE POSSIBLE. MAY CAUSE SKIN
SENSITIZATION, AN ALLERGIC REACTION, WHICH BECOMES EVIDENT UPON RE-EXPOSURE
TO THIS MATERIAL.
EFFECTS OF OVEREXPOSURE - INHALATION:
HARMFUL IF INHALED. HIGH GAS, VAPOR, MIST OR DUST CONCENTRATIONS MAY BE
HARMFUL IF INHALED. AVOID BREATHING FUMES, SPRAY, VAPORS, OR MIST. HIGH
VAPOR CONCENTRATIONS ARE IRRITATING TO THE EYES, NOSE, THROAT AND LUNGS.
PROLONGED OR EXCESSIVE INHALATION MAY CAUSE RESPIRATORY TRACT IRRITATION.
EFFECTS OF OVEREXPOSURE - INGESTION:
HARMFUL IF SWALLOWED. POISON, MAY BE FATAL OR CAUSE BLINDNESS IF SWALLOWED.
EFFECTS OF OVEREXPOSURE - CHRONIC HAZARDS:
MAY CAUSE CENTRAL NERVOUS SYSTEM DISORDER (E.G., NARCOSIS INVOLVING A LOSS
OF COORDINATION, WEAKNESS, FATIGUE, MENTAL CONFUSION, AND BLURRED VISION)
AND/OR DAMAGE. HIGH CONCENTRATIONS MAY LEAD TO CENTRAL NERVOUS SYSTEM
EFFECTS (DROWSINESS, DIZZINESS, NAUSEA, HEADACHES, PARALYSIS, AND BLURRED
VISION) AND/OR DAMAGE. REPORTS HAVE ASSOCIATED REPEATED AND PROLONGED
OCCUPATIONAL OVEREXPOSURE TO SOLVENTS WITH PERMANENT BRAIN AND NERVOUS
SYSTEM DAMAGE. OVEREXPOSURE TO XYLENE IN LABORATORY ANIMALS HAS BEEN
ASSOCIATED WITH LIVER ABNORMALITIES, KIDNEY, LUNG, SPLEEN, EYE AND BLOOD
DAMAGE AS WELL AS REPRODUCTIVE DISORDERS. EFFECTS IN HUMANS, DUE TO CHRONIC
OVEREXPOSURE, HAVE INCLUDED LIVER, CARDIAC ABNORMALITIES AND NERVOUS SYSTEM
DAMAGE. CONTAINS CARBON BLACK. CHRONIC INFLAMMATION, LUNG FIBROSIS, AND
LUNG TUMORS HAVE BEEN OBSERVED IN SOME RATS EXPERIMENTALLY EXPOSED FOR LONG
PERIODS OF TIME TO EXCESSIVE CONCENTRATIONS OF CARBON BLACK AND SEVERAL
INSOLUBLE FINE DUST PARTICLES. TUMORS HAVE NOT BEEN OBSERVED IN OTHER
ANIMAL SPECIES (I.E., MOUSE AND HAMSTER) UNDER SIMILAR CIRCUMSTANCES AND
STUDY CONDITIONS. EPIDEMIOLOGICAL STUDIES OF NORTH AMERICAN WORKERS SHOW
NO EVIDENCE OF CLINICALLY SIGNIFICANT ADVERSE HEALTH EFFECTS DUE TO
OCCUPATIONAL EXPOSURE TO CARBON BLACK.
CARBON BLACK IS LISTED AS A GROUP 2B-"POSSIBLY CARCINOGENIC TO HUMANS"
BY IARC AND IS PROPOSED TO BE LISTED AS A4- "NOT CLASSIFIED AS A HUMAN
CARCINOGEN" BY THE AMERICAN CONFERENCE OF GOVERNMENTAL INDUSTRIAL
HYGIENISTS. SIGNIFICANT EXPOSURE IS NOT ANTICIPATED DURING BRUSH
APPLICATION OR DRYING. RISK OF OVEREXPOSURE DEPENDS ON DURATION AND LEVEL
OF EXPOSURE TO DUST FROM REPEATED SANDING OF SURFACES OR SPRAY MIST AND THE
ACTUAL CONCENTRATION OF CARBON BLACK IN THE FORMULA. IARC LISTS
ETHYLBENZENE AS A POSSIBLE HUMAN CARCINOGEN (GROUP 2B).
PRIMARY ROUTE(S) OF ENTRY:
EYE CONTACT, INGESTION, INHALATION, SKIN ABSORPTION, SKIN CONTACT
ACUTE TOXICITY VALUES:
THE ACUTE EFFECTS OF THIS PRODUCT HAVE NOT BEEN TESTED. DATA ON INDIVIDUAL
COMPONENTS ARE TABULATED BELOW:
CAS-NO. CHEMICAL NAME ORAL LD50 DERMAL LD50 VAPOR LC50
64742-49-0 NAPHTHA, PETROLEUM, >5000 MG/KG >3160 MG/KG >4951 MG/L RAT
HYDROTREATED LIGHT RAT RABBIT
616-38-6 DIMETHYL CARBONATE 13000 MG/KG >5000 MG/KG 140 MG/L RAT
RAT RABBIT
106-97-8 N-BUTANE N.E. N.E. 658 MG/L RAT
14807-96-6 HYDROUS MAGNESIUM 6000 N.E. 30
SILICATE
1330-20-7 XYLENES (O-, M-, 3500 MG/KG >4350 MG/KG 29.08 MG/L RAT
P- ISOMERS) RAT RABBIT
141-78-6 ETHYL ACETATE 5620 MG/KG >18000 MG/KG N.E.
RAT RABBIT
123-86-4 N-BUTYL ACETATE 10768 MG/KG >17600 MG/KG >21 MG/L RAT
RAT RABBIT
108-10-1 METHYL ISOBUTYL 2080 MG/KG 3000 MG/KG 8.2 MG/L RAT
KETONE RAT RABBIT
100-41-4 ETHYLBENZENE 3500 MG/KG 15400 MG/KG 17.4 MG/L RAT
RAT RABBIT
142-82-5 N-HEPTANE N.E. 3000 MG/KG 103 MG/L RAT
RABBIT
111-65-9 OCTANE N.E. N.E. >23.36 MG/L
RAT
PROPRIETARY MEDIUM OIL ALKYD 27,054.00 13,463.00 33.50 MG/L
MG/KG MG/KG
1333-86-4 CARBON BLACK >15400 N.E. N.E.
MG/KG RAT
67-56-1 METHANOL 6200 MG/KG 15840 MG/KG N.E.
RAT RABBIT
41556-26-7 BIS(1,2,2,6,6- 2615 MG/KG N.E. N.E.
PENTAMETHYL-4- RAT
PIPERIDINYL)
SEBACATE
N.E. - NOT ESTABLISHED
| 12. ECOLOGICAL INFORMATION | |
ECOLOGICAL INFORMATION: PRODUCT IS A MIXTURE OF LISTED COMPONENTS.
| 13. DISPOSAL INFORMATION | |
DISPOSAL INFORMATION:
DO NOT INCINERATE CLOSED CONTAINERS. THIS PRODUCT AS SUPPLIED IS A USEPA
DEFINED IGNITABLE HAZARDOUS WASTE. DISPOSE OF UNUSABLE PRODUCT AS A
HAZARDOUS WASTE (D001) IN ACCORDANCE WITH LOCAL, STATE, AND FEDERAL
REGULATION.
| 14. TRANSPORT INFORMATION | |
DOMESTIC (USDOT) INTERNATIONAL AIR (IATA) TDG (CANADA)
(IMDG)
UN NUMBER N.A. 1950 1950 N.A.
PROPER PAINT AND RELATED AEROSOLS AEROSOLS, AEROSOLS
SHIPPING NAME SPRAY PRODUCTS IN FLAMMABLE
LTD QTY
HAZARD CLASS N.A. 2 2.1 N.A.
PACKING GROUP N.A. N.A. N.A. N.A.
LIMITED YES YES YES YES
QUANTITY
| 15. REGULATORY INFORMATION | |
U.S. FEDERAL REGULATIONS:
CERCLA - SARA HAZARD CATEGORY:
THIS PRODUCT HAS BEEN REVIEWED ACCORDING TO THE EPA 'HAZARD CATEGORIES'
PROMULGATED UNDER SECTIONS 311 AND 312 OF THE SUPERFUND AMENDMENT AND
REAUTHORIZATION ACT OF 1986 (SARA TITLE III) AND IS CONSIDERED, UNDER
APPLICABLE DEFINITIONS, TO MEET THE FOLLOWING CATEGORIES:
GAS UNDER PRESSURE, CARCINOGENICITY, RESPIRATORY OR SKIN SENSITIZATION,
SERIOUS EYE DAMAGE OR EYE IRRITATION, SPECIFIC TARGET ORGAN TOXICITY
(SINGLE OR REPEATED EXPOSURE), GERM CELL MUTAGENICITY
SARA SECTION 313:
THIS PRODUCT CONTAINS THE FOLLOWING SUBSTANCES SUBJECT TO THE REPORTING
REQUIREMENTS OF SECTION 313 OF TITLE III OF THE SUPERFUND AMENDMENT AND
REAUTHORIZATION ACT OF 1986 AND 40 CFR PART 372:
CHEMICAL NAME CAS-NO.
XYLENES (O-, M-, P- ISOMERS) 1330-20-7
METHYL ISOBUTYL KETONE 108-10-1
ETHYLBENZENE 100-41-4
METHANOL 67-56-1
TOXIC SUBSTANCES CONTROL ACT:
THIS PRODUCT CONTAINS THE FOLLOWING CHEMICAL SUBSTANCES SUBJECT TO THE
REPORTING REQUIREMENTS OF TSCA 12(B) IF EXPORTED FROM THE UNITED STATES:
NO TSCA 12(B) COMPONENTS EXIST IN THIS PRODUCT.
U.S. STATE REGULATIONS:
CALIFORNIA PROPOSITION 65:
WARNING: CANCER AND REPRODUCTIVE HARM - WWW.P65WARNINGS.CA.GOV.
| 16. OTHER INFORMATION | |
HMIS RATINGS:
HEALTH 2*
FLAMMABILITY 4
PHYSICAL HAZARD 0
PERSONAL PROTECTION X
NFPA RATINGS:
HEALTH 2
FLAMMABILITY 4
INSTABILITY 0
MAXIMUM INCREMENTAL REACTIVITY 1.15
SDS REVISION DATE: 5/8/2019
REASON FOR REVISION:
SUBSTANCE AND/OR PRODUCT PROPERTIES CHANGED IN SECTION(S):
01 - IDENTIFICATION
11 - TOXICOLOGICAL INFORMATION
LEGEND:
N.A. - NOT APPLICABLE
N.E. - NOT ESTABLISHED
N.D. - NOT DETERMINED
RUST-OLEUM CORPORATION BELIEVES, TO THE BEST OF ITS KNOWLEDGE, INFORMATION
AND BELIEF, THE INFORMATION CONTAINED HEREIN TO BE ACCURATE AND RELIABLE AS
OF THE DATE OF THIS SAFETY DATA SHEET. HOWEVER, BECAUSE THE CONDITIONS OF
HANDLING, USE, AND STORAGE OF THESE MATERIALS ARE BEYOND OUR CONTROL, WE
ASSUME NO RESPONSIBILITY OR LIABILITY FOR PERSONAL INJURY OR PROPERTY
DAMAGE INCURRED BY THE USE OF THESE MATERIALS. RUST-OLEUM CORPORATION MAKES
NO WARRANTY, EXPRESSED OR IMPLIED, REGARDING THE ACCURACY OR RELIABILITY OF
THE DATA OR RESULTS OBTAINED FROM THEIR USE. ALL MATERIALS MAY PRESENT
UNKNOWN HAZARDS AND SHOULD BE USED WITH CAUTION. THE INFORMATION AND
RECOMMENDATIONS IN THIS MATERIAL SAFETY DATA SHEET ARE OFFERED FOR THE
USERS' CONSIDERATION AND EXAMINATION. IT IS THE RESPONSIBILITY OF THE USER
TO DETERMINE THE FINAL SUITABILITY OF THIS INFORMATION AND TO COMPLY WITH
ALL APPLICABLE INTERNATIONAL, FEDERAL, STATE, AND LOCAL LAWS AND
REGULATIONS.