| Common Name: | WHEEL CLEANER |
| Manufacturer: | SUPERCLEAN BRANDS |
| SDS Revision Date: | 3/9/2016 |
| SDS Format: | GHS-US |
| Item Number(s): | 55RZ85, 6YHJ8 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
SDS - SUPERCLEAN WHEEL CLEANER
PREPARATION DATE: MARCH 9, 2016
SUPER CLEAN
SAFETY DATA SHEET
| SECTION 1 - IDENTIFICATION |  |
PRODUCT IDENTIFIER: SUPERCLEAN BRANDS, WHEEL CLEANER
OTHER MEANS OF IDENTIFICATION: ORGANIC ACIDIC BASED CLEANER
NAME AND ADDRESS OF RESPONSIBLE PARTIES:
SUPERCLEAN BRANDS, LLC
1380 CORPORATE CENTER CURVE, SUITE 107
EAGAN, MN 55121
INFORMATION TELEPHONE #: 1-651-365-7500
24 HR. EMERGENCY TELEPHONE NUMBER: 1-800-424-9300
CONTRACT NUMBER: CCN644158
| SECTION 2 - HAZARDS IDENTIFICATION | |
CLASSIFICATION OF THE CHEMICAL:
CLEAR LIGHT TO YELLOW LIQUID. SLIGHT ACID ODOR.
THIS MATERIAL IS CLASSIFIED AS HAZARDOUS UNDER OSHA REGULATIONS (29 CFR
1910.1200) (HAZCOM 2012).
HAZARDOUS CLASSIFICATION:
CORROSIVE TO METALS: CATEGORY 1
SKIN IRRITATION: CATEGORY 2
EYE DAMAGE: CATEGORY 2A
LABEL ELEMENTS:
SIGNAL WORD: WARNING
HAZARD STATEMENTS:
MAY BE CORROSIVE LIQUID.
MAY CAUSE SKIN IRRITATION.
MAY CAUSE SEVERE EYE IRRITATION.
PRECAUTIONARY STATEMENTS:
READ INSTRUCTIONS BEFORE USE.
KEEP ONLY IN ORIGINAL CONTAINER.
STORE IN CORROSIVE RESISTANT CONTAINER WITH INNER LINER.
ABSORB SPILLAGE TO PREVENT MATERIAL DAMAGE.
DO NOT HANDLE UNTIL ALL SAFETY INSTRUCTIONS HAVE BEEN READ AND UNDERSTOOD.
KEEP CONTAINER TIGHTLY CLOSED.
WASH HANDS THOROUGHLY AFTER HANDLING.
WEAR PROTECTIVE GLOVES.
IF ON SKIN:
WASH WITH PLENTY OF SOAP AND WATER.
IF SKIN IRRITATION OCCURS GET MEDICAL ADVICE/ATTENTION.
TAKE OFF CONTAMINATED CLOTHING AND WASH BEFORE REUSE.
DO NOT EAT, DRINK OR SMOKE WHILE USING THIS PRODUCT.
USE ONLY IN A WELL VENTILATED AREA.
WEAR EYE PROTECTION SUCH AS GOGGLES OR SAFETY GLASSES WITH SIDE SHIELDS.
IF IN EYES: RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES.
REMOVE CONTACT LENSES, IF PRESENT AND EASY TO DO. CONTINUE RINSING.
IF EYE IRRITATION PERSISTS GET MEDICAL ADVICE/ATTENTION.
HAZARD PICTOGRAM(S): CORROSION
OTHER HAZARDS NOT OTHERWISE CLASSIFIED:
THIS PRODUCT CONTAINS 8.74% INGREDIENTS OF AN UNKNOWN ACUTE TOXICITY. SEE
SECTION 11 FOR MORE INFORMATION.
| SECTION 3 - COMPOSITION/INFORMATION ON INGREDIENTS | |
EXPOSURE LIMITS:
CHEMICAL NAME, COMMON NAME CAS # CONCENTRATION WT/WT(*)
ALKYL POLYGYLCOSIDES 68515-73-1 1-5
UREA, MONOHYDROCHLORIDE 506-89-8 0.5-1.5
OXALIC ACID 144-62-7 0.1-1.0
POLYETHYLENE GLYCOL DECYL ETHER 26183-52-8 0.5-1.5
ORGANIC ACID SALT TRADE SECRET 1-5
* NOTE:
THE EXACT CONCENTRATIONS OF THE CHEMICAL(S) ABOVE ARE BEING WITHHELD AS A
TRADE SECRET.
| SECTION 4 - FIRST-AID MEASURES | |
DESCRIPTION OF FIRST AID MEASURES:
INHALATION:
IF INHALED REMOVE VICTIM TO FRESH AIR AND KEEP AT REST. CALL A POISON
CENTER OR PHYSICIAN IF YOU FEEL UNWELL.
SKIN CONTACT:
WASH WITH PLENTY OF SOAP AND WATER. TAKE OFF CONTAMINATED CLOTHING AND WASH
BEFORE REUSE.
EYE CONTACT:
RINSE CAUTIOUSLY WITH WATER FOR 15 MINUTES. REMOVE CONTACT LENSES, IF
PRESENT AND EASY TO DO. CONTINUE RINSING. IF EYE IRRITATION PERSISTS SEEK
MEDICAL ADVICE/ATTENTION.
INGESTION:
DO NOT INDUCE VOMITING UNLESS INSTRUCTED BY MEDICAL PERSONAL. NEVER GIVE
ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. CALL A POISON CENTER OR
PHYSICIAN IF YOU FEEL UNWELL.
MOST IMPORTANT SYMPTOMS AND EFFECTS, BOTH ACUTE AND DELAYED:
MAY CAUSE SKIN IRRITATION.
MAY CAUSE SEVERE EYE IRRITATION.
INGESTION MAY CAUSE GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING AND
DIARRHEA.
INDICATION OF ANY IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED:
TREAT SYMPTOMATICALLY.
| SECTION 5 - FIRE-FIGHTING MEASURES | |
EXTINGUISHING MEDIA:
SUITABLE EXTINGUISHING MEDIA:
WATER FOG, CARBON DIOXIDE, DRY CHEMICAL, FOAM.
UNSUITABLE EXTINGUISHING MEDIA: NOT AVAILABLE.
SPECIAL HAZARDS ARISING FROM THE SUBSTANCE OR MIXTURE: NONE KNOWN.
FLAMMABILITY CLASSIFICATION: NOT FLAMMABLE BY OSHA/WHMIS CRITERIA.
HAZARDOUS COMBUSTION PRODUCTS: CARBON OXIDES.
SPECIAL PROTECTIVE EQUIPMENT AND PRECAUTIONS FOR FIREFIGHTERS:
PROTECTIVE EQUIPMENT FOR FIRE-FIGHTERS:
FIREFIGHTERS SHOULD WEAR PROPER PROTECTIVE EQUIPMENT (BUNKER GEAR) AND
SELF-CONTAINED BREATHING APPARATUS WITH FULL FACE OPERATED IN POSITIVE
PRESSURE MODE.
| SECTION 6 - ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
ALL PERSONS DEALING WITH THE CLEAN-UP SHOULD WEAR THE APPROPRIATE
CHEMICALLY PROTECTIVE EQUIPMENT. KEEP PEOPLE AWAY FROM AND UPWIND OF
SPILL/LEAK. RESTRICT ACCESS TO AREA UNTIL COMPLETION OF CLEAN-UP.
METHODS AND MATERIALS FOR CONTAINMENT AND CLEAN UP:
IF POSSIBLE, DO NOT ALLOW MATERIAL TO CONTAMINATE GROUND WATER SYSTEM. IF
NECESSARY, DIKE WELL AHEAD OF THE SPILL TO PREVENT RUN-OFF INTO DRAINS,
SEWERS, OR ANY NATURAL WATERWAY OR DRINKING SUPPLY. VENTILATE THE AREA.
SOAK UP SPILL WITH AN INERT ABSORBENT SUCH AS VERMICULITE AND SCOOP INTO
SUITABLE CONTAINER(S). DISPOSE OF ACCORDING TO LOCAL, STATE AND FEDERAL
REGULATIONS.
| SECTION 7 - HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING:
OBTAIN SPECIAL INSTRUCTIONS BEFORE USE. DO NOT HANDLE UNTIL ALL SAFETY
PRECAUTIONS HAVE BEEN READ AND UNDERSTAND. WEAR PROTECTIVE GLOVES AND
EYE/FACE PROTECTION. DO NOT BREATHE VAPORS OR SPRAY MIST. AVOID CONTACT
WITH SKIN, EYES AND CLOTHING. KEEP AWAY FROM HEAT. KEEP CONTAINER TIGHTLY
CLOSED.
CONDITIONS FOR SAFE STORAGE:
STORE IN COOL/WELL VENTILATED PLACE. CONTAINERS SHOULD BE CLEARLY
IDENTIFIED, CLEAR OF OBSTRUCTIONS AND ACCESSIBLE ONLY TO AUTHORIZED
PERSONNEL. PROTECT FROM SUNLIGHT. HAVE APPROPRIATE FIRE EXTINGUISHERS
AND SPILL CLEAN-UP EQUIPMENT IN OR NEAR STORAGE AREA.
INCOMPATIBLE MATERIALS: STRONG OXIDIZERS, STRONG BASES.
| SECTION 8 - EXPOSURE CONTROLS/PERSONAL PROTECTION | |
EXPOSURE LIMITS:
CHEMICAL NAME ACGIH-TLV OSHA-PEL
OXALIC ACID 1 MG/M3 1 MG/M3
POLYETHYLENE GLYCOL DECYL ETHER NOT AVAILABLE NOT AVAILABLE
EXPOSURE CONTROLS:
VENTILATION AND ENGINEERING MEASURES:
USE IN WELL VENTILATED AREA. APPLY TECHNICAL MEASURES TO COMPLY WITH
OCCUPATIONAL EXPOSURE LIMITS IF NEEDED.
RESPIRATORY MEASURES:
IF AIRBORNE CONCENTRATIONS ABOVE THE PERMISSIBLE EXPOSURE LIMIT USE NIOSH
APPROVED RESPIRATORS.
SKIN PROTECTION:
WEAR PROTECTIVE GLOVES. WHERE EXTENSIVE EXPOSURE TO THE PRODUCT IS
POSSIBLE, USE RESISTANT APRON AND BOOTS.
EYE PROTECTION: GOGGLES OR SAFETY GLASSES WITH SIDE SHIELDS.
OTHER PROTECTIVE EQUIPMENT:
ENSURE THAT EYEWASH STATIONS AND A SAFETY SHOWER ARE CLOSE THE
WORKSTATION(S).
GENERAL HYGIENE CONSIDERATIONS:
DO NOT BREATHE VAPORS OR SPRAY MIST. AVOID CONTACT WITH EYES, SKIN AND
CLOTHING. DO NOT EAT OR DRINK WHEN USING THIS PRODUCT. WASH HANDS AFTER
HANDLING. REMOVE AND WASH ALL CONTAMINATED CLOTHING BEFORE RE-USE. HANDLE
IN ACCORDANCE WITH GOOD INDUSTRIAL HYGIENE AND SAFETY PRACTICE.
| SECTION 9 - PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE: CLEAR/LIGHT YELLOW.
ODOR: SLIGHT ODOR.
ODOR THRESHOLD: NOT AVAILABLE.
PH: 0.5 - 1
MELTING/FREEZING POINTING: NOT AVAILABLE.
BOILING POINT AND BOILING RANGE: >100C (212F)
FLASH POINT: >93.3C (199.4F)
EVAPORATION POINT (BUTYL ACETATE=1): NOT AVAILABLE
FLAMMABILITY (METHOD DETERMINATION): CLOSED CUP.
LOWER FLAMMABILITY LIMIT (% BY VOL.): NOT AVAILABLE.
UPPER FLAMMABILITY LIMIT (% BY VOL.): NOT AVAILABLE.
VAPOR PRESSURE: NOT AVAILABLE.
VAPOR DENSITY: NOT AVAILABLE.
RELATIVE DENSITY: 1.00 - 1.05
SOLUBILITY IN WATER: COMPLETE.
PARTITION COEFFICIENT (N-OCTANOL/WATER): NOT AVAILABLE.
AUTO IGNITION TEMPERATURE: NOT AVAILABLE.
DECOMPOSITION TEMPERATURE: NOT AVAILABLE.
VISCOSITY: NOT AVAILABLE.
VOLATILES (% BY WT): O
VOLATILE ORGANIC COMPOUNDS: NOT AVAILABLE.
OTHER PHYSICAL/CHEMICAL COMMENTS: NO ADDITION INFORMATION.
| SECTION 10 - STABILITY AND REACTIVITY | |
REACTIVITY: NOT NORMALLY REACTIVE.
CHEMICAL STABILITY: STABLE UNDER NORMAL CONDITIONS.
POSSIBILITY OF HAZARDOUS REACTIONS:
HAZARDOUS POLYMERIZATION DOES NOT OCCUR.
CONDITIONS TO AVOID: HEAT.
INCOMPATIBLE MATERIALS: STRONG OXIDIZERS, STRONG BASES.
HAZARDOUS DECOMPOSITION PRODUCTS: HYDROGEN CHLORIDE, CARBON DIOXIDE
| SECTION 11 - EXPOSURE CONTROLS/PERSONAL PROTECTION | |
INFORMATION ON ROUTES OF EXPOSURE:
ROUTES OF ENTRY-INHALATION: YES
ROUTES OF ENTRY-SKIN & EYE: YES
ROUTES OF ENTRY-INGESTION: YES
ROUTES OF ENTRY-SKIN ABSORPTION: YES
POTENTIAL HEALTH EFFECTS:
SIGNS AND SYMPTOMS OF SHORT TERM EXPOSURE:
SIGNS AND SYMPTOMS: INHALATION
MAY CAUSE RESPIRATORY IRRITATION. MAY CAUSE HEADACHE, NAUSEA, DIZZINESS AND
OTHER SYMPTOMS OF CENTRAL NERVOUS SYSTEM DEPRESSION.
SIGNS AND SYMPTOMS: INGESTION
INGESTION MAY CAUSE GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING AND
DIARRHEA. LAGER AMOUNTS MAY CAUSE BURNS TO THE THROAT AND ESOPHAGUS.
SIGNS AND SYMPTOMS: SKIN
MAY CAUSE BURNS OR IRRITATION.
SIGNS AND SYMPTOMS: EYES
MAY CAUSE SEVERE IRRITATION.
POTENTIAL CHRONIC HEALTH EFFECTS: NONE KNOWN.
MUTAGENICITY: NOT EXPECTED TO BE MUTAGENIC IN HUMANS.
CARCINOGENICITY:
NO COMPONENTS ARE LISTED AS CARCINOGENS BY ACGIH, IARC, OSHA OR NTP.
REPRODUCTIVE EFFECTS: NOT HAZARDOUS BY OSHA/WHMIS CRITERIA.
SENSITIZATION TO MATERIAL:
NO DATA AVAILABLE TO INDICATE PRODUCT MAY BE A SENSITIZER.
SPECIFIC TARGET ORGAN EFFECTS: NOT AVAILABLE.
MEDICAL CONDITIONS AGGRAVATED BY OVEREXPOSURE:
PRE-EXISTING SKIN AND EYE CONDITIONS.
TOXICOLOGICAL DATA:
THE CALCULATED ATE VALUE FOR THIS MIXTURE IS WELL ABOVE CLASSIFICATION
PARAMETERS.
CHEMICAL NAME LD (ORAL) DERMAL
OXALIC ACID 7500 MG/KG (RAT) N/AV
ALKYL POLYGLYCOSIDES N/AV N/AV
UREA, MONOHYDROCHLORIDE N/AV N/AV
POLYETHYLENE GLYCOL DECYL ETHER N/AV N/AV
ORGANIC ACID SALT N/AV N/AV
| SECTION 12 - ECOLOGICAL INFORMATION | |
MOBILITY IS SOIL: THIS PRODUCT ITSELF HAS NOT BEEN TESTED.
PERSISTENCE AND DEGRADABILITY: THIS PRODUCT ITSELF HAS NOT BEEN TESTED.
BIOACCUMULATION POTENTIAL: THIS PRODUCT ITSELF HAS NOT BEEN TESTED.
OTHER ADVERSE ENVIRONMENTAL EFFECTS: NONE KNOWN.
| SECTION 13 - DISPOSAL INFORMATION | |
HANDLING FOR DISPOSAL:
HANDLE IN ACCORDANCE WITH GOOD INDUSTRIAL HYGIENE AND SAFETY PRACTICE.
REFER TO PROTECTIVE MEASURES LISTED IN SECTIONS 7 AND 8.
METHODS OF DISPOSAL:
DISPOSE IN ACCORDANCE WITH ALL APPLICABLE FEDERAL, STATE, PROVINCIAL
AND LOCAL REGULATION. CONTACT YOUR FEDERAL, STATE, PROVINCIAL AND LOCAL
AUTHORITIES FOR SPECIFIC RULES.
| SECTION 14 - TRANSPORTATION INFORMATION | |
US 49 CFR/DOT.:
UN NO.: UN1760
UN PROPER SHIPPING NAME: CORROSIVE LIQUID, N.O.S., (ACID SALTS)
TRANSPORT HAZARD CLASS: 3
PACKING GROUP: III
SPECIAL TRANSPORTATION NOTES:
MAY BE SHIPPED AS LIMITED QUANTITY BY GROUND WHEN CONTAINERS ARE <5.0
LITERS; IN PACKAGES NOT EXCEEDING 30KG GROSS MASS PER CFR 49 173.154(B).
| SECTION 15 - REGULATORY INFORMATION | |
US FEDERAL INFORMATION:
TSCA: ALL LISTED INGREDIENTS APPEAR ON THE TOXIC SUBSTANCES CONTROL ACT.
SARA TITLE III: SEC. 302, EXTREMELY HAZARDOUS SUBSTANCES, 40 CFR 355
NO EXTREMELY HAZARDOUS SUBSTANCES ARE PRESENT IN THIS MATERIAL.
SARA TITLE III: SEC. 311 AND 312, MSDS REQUIREMENTS, 40 CFR 370 HAZARD
CLASSES
REACTIVE HAZARD, ACUTE HEALTH HAZARD, CHRONIC HEALTH HAZARD. UNDER SARA
SECTION 311 AND 312, THE EPA HAS ESTABLISHED THRESHOLD QUANTITIES FOR THE
REPORTING OF HAZARDOUS CHEMICALS. THE CURRENT THRESHOLDS ARE 500 POUNDS FOR
THE THRESHOLD PLANNING QUANTITY (TPQ), WHICHEVER IS LOWER, FOR EXTREMELY
HAZARDOUS SUBSTANCES AND 10,000 POUNDS FOR ALL OTHER HAZARDOUS CHEMICALS.
SARA TITLE III: SEC. 313, TOXIC CHEMICALS NOTIFICATION, 40 CFR 372
NO COMPONENTS ARE PRESENT IN THIS MATERIAL.
STATE REGULATIONS:
CALIFORNIA PROPOSITION 65:
THIS PRODUCT DOES NOT CONTAIN A CHEMICAL KNOWN TO THE STATE OF CALIFORNIA
TO CAUSE, BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM.
INTERNATIONAL INFORMATION:
CANADIAN ENVIRONMENTAL PROTECTION ACT (CEPA) INFORMATION:
ALL INGREDIENTS LISTED APPEAR ON THE DOMESTIC SUBSTANCES LIST (DSL).
| SECTION 16 - OTHER INFORMATION | |
HMIS - HAZARDOUS MATERIALS IDENTIFICATION SYSTEM:
HEALTH 2
FLAMMABILITY 1
PHYSICAL HAZARD 1
PPE B
NFPA - NATIONAL FIRE PROTECTION ASSOCIATION:
HEALTH 2
FLAMMABILITY 1
REACTIVITY 1
ABBREVIATIONS LEGEND:
ACGIH: AMERICAN CONFERENCE OF GOVERNMENTAL INDUSTRIAL HYGIENIST
ATE: ACUTE TOXICITY ESTIMATE
CAS: CHEMICAL ABSTRACT SERVICES
CERCLA:
COMPREHENSIVE ENVIRONMENTAL RESPONSE, COMPENSATION, AND LIABILITY ACT OF
1980
CFR: CODE OF FEDERAL REGULATIONS
CSA: CANADIAN STANDARDS ASSOCIATION
DOT: DEPARTMENT OF TRANSPORTATION
ECOTOX: U.S. EPA ECOTOXICOLOGY DATABASE
EINECS: EUROPEAN INVENTORY OF EXISTING COMMERCIAL CHEMICAL SUBSTANCES
EPA: ENVIRONMENTAL PROTECTION AGENCY
HSDB: HAZARDOUS SUBSTANCES DATABASE
IARC: INTERNATIONAL AGENCY FOR RESEARCH ON CANCER
IBC: INTERMEDIATE BULK CONTAINER
IUCLID: INTERNATIONAL UNIFORM CHEMICAL INFORMATION DATABASE
LC: LETHAL CONCENTRATION
LD: LETHAL DOSE
NIOSH: NATIONAL INSTITUTE OF OCCUPATIONAL SAFETY AND HEALTH
NTP: NATIONAL TOXICOLOGY PROGRAM
OECD: ORGANIZATION FOR ECONOMIC COOPERATION AND DEVELOPMENT
PEL: PERMISSIBLE EXPOSURE LIMIT
RCRA: RESOURCE CONSERVATION AND RECOVERY ACT
RTECS: REGISTRY OF TOXIC EFFECTS OF CHEMICAL SUBSTANCES
SARA: SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT
SDS: SAFETY DATA SHEET
STEL: SHORT TERM EXPOSURE LIMIT
TDG: CANADIAN TRANSPORTATION OF DANGEROUS GOODS ACT & REGULATIONS
TLV: THRESHOLD LIMIT VALUES
TWA: TIME WEIGHTED AVERAGE
WHMIS: WORKPLACE HAZARDOUS MATERIALS IDENTIFICATION SYSTEM
DISCLAIMER:
THE INFORMATION CONTINUED HEREIN IS BASED ON THE MANUFACTURES' OWN STUDY
AND THE WORK OF OTHERS, IMPLIED, AS TO THE ACCURACY, COMPLETENESS OR
ADEQUACY OF THE INFORMATION CONTAINED HEREIN, AND NEITHER THE PROVIDER NOR
THE MANUFACTURER (NOR THE AGENTS, DIRECTORS, OFFICERS, CONTRACTORS OR
EMPLOYEES OF EITHER) ARE LIABLE TO ANY PARTY FOR ANY DAMAGES OF ANY NATURE,
INCLUDING DIRECT, SPECIAL OR CONSEQUENTIAL DAMAGES ARISING OUT OF OR IN
CONNECTION WITH THE ACCURACY, COMPLETENESS, ADEQUACY OR FURNISHING OF ANY
INFORMATION IN THIS SDS, OR IN ANY OTHER WAY RELATED (DIRECTLY OR
INDIRECTLY) TO THIS SDS. THE INFORMATION PROVIDED ON THIS SDS IS CORRECT TO
THE BEST OF OUR KNOWLEDGE, INFORMATION AND BELIEF AT THE DATE OF ITS
PUBLICATION. THE INFORMATION GIVEN IS DESIGNED ONLY AS A GUIDE FOR THE SAFE
HANDLING, USE, PROCESSING, STORAGE, TRANSPORTATION, DISPOSAL AND RELEASE
AND IS NOT TO BE CONSIDERED AS A WARRANTY OR QUALITY SPECIFICATION. THE
INFORMATION RELATES ONLY TO THE SPECIFIC MATERIAL DESIGNATED AND MAY NOT BE
VALID FOR SUCH MATERIAL USED IN COMBINATION WITH ANY OTHER MATERIAL OR IN
ANY OTHER PROCESS.