| Common Name: | FLOOR 1-GL 2PK 6000 SILVER GRAY, 6082408 |
| Manufacturer: | RUST-OLEUM |
| SDS Revision Date: | 8/7/2018 |
| SDS Format: | GHS-US |
| Item Number(s): | 5A278 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
DATE PRINTED: 8/7/2018
SAFETY DATA SHEET
RUST-OLEUM CORPORATION
TRUSTED QUALITY SINCE 1921
WWW.RUSTOLEUM.COM
| 1. IDENTIFICATION |  |
PRODUCT NAME: FLOOR 1-GL 2PK 6000 SILVER GRAY
PRODUCT IDENTIFIER: 6082408
RECOMMENDED USE: FLOOR COATING/WATERBASED EPOXY
REVISION DATE: 8/7/2018
SUPERCEDES DATE: 7/27/2018
SUPPLIER:
RUST-OLEUM CORPORATION
11 HAWTHORN PARKWAY
VERNON HILLS, IL 60061
USA
RUST-OLEUM CANADA (ROCA)
200 CONFEDERATION PARKWAY
CONCORD, ON L4K 4T8
CANADA
EMERGENCY PHONE: 800-387-3625
MANUFACTURER:
RUST-OLEUM CORPORATION
11 HAWTHORN PARKWAY
VERNON HILLS, IL 60061
USA
PREPARER: REGULATORY DEPARTMENT
EMERGENCY TELEPHONE:
24 HOUR HOTLINE: 847-367-7700
| 2. HAZARD IDENTIFICATION | |
CLASSIFICATION:
SYMBOL(S) OF PRODUCT:
EXCLAMATION MARK
HEALTH HAZARD
SIGNAL WORD: DANGER
POSSIBLE HAZARDS:
29% OF THE MIXTURE CONSISTS OF INGREDIENT(S) OF UNKNOWN ACUTE TOXICITY.
GHS HAZARD STATEMENTS:
CARCINOGENICITY, CATEGORY 1B:
H350: MAY CAUSE CANCER.
ACUTE TOXICITY, INHALATION, CATEGORY 4:
H332: HARMFUL IF INHALED.
GHS LABEL PRECAUTIONARY STATEMENTS:
P201: OBTAIN SPECIAL INSTRUCTIONS BEFORE USE.
P280:
WEAR PROTECTIVE GLOVES/PROTECTIVE CLOTHING/EYE PROTECTION/FACE PROTECTION.
P308+P313:
IF EXPOSED OR CONCERNED: GET MEDICAL ADVICE/ATTENTION.
P405: STORE LOCKED UP.
P501:
DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH LOCAL, REGIONAL AND
NATIONAL REGULATIONS.
P261: AVOID BREATHING DUST/FUME/GAS/MIST/VAPORS/SPRAY.
P271: USE ONLY OUTDOORS OR IN A WELL-VENTILATED AREA.
P304+P340:
IF INHALED: REMOVE PERSON TO FRESH AIR AND KEEP COMFORTABLE FOR BREATHING.
P312: CALL A POISON CENTER OR DOCTOR/PHYSICIAN IF YOU FEEL UNWELL.
| 3. COMPOSITION / INFORMATION ON INGREDIENTS | |
HAZARDOUS SUBSTANCES:
CHEMICAL NAME CAS-NO. WT.% GHS SYMBOLS GHS STATEMENTS
SURFACTANT PROPRIETARY 29 NOT AVAILABLE NOT AVAILABLE
TITANIUM DIOXIDE 13463-67-7 9.1 NOT AVAILABLE NOT AVAILABLE
ETHYLENE GLYCOL 2807-30-9 5.0 GHS06 H311-319-331
MONOPROPYL ETHER
SOLVENT NAPHTHA, 64742-95-6 1.8 GHS07-GHS08 H304-332
LIGHT AROMATIC
DISTILLATES 64742-65-0 0.3 NOT AVAILABLE NOT AVAILABLE
(PETROLEUM)
SOLVENT-DEWAXED
HEAVY PARAFFINIC
PETROLEUM 64742-56-9 0.1 GHS08 H350
DISTILLATES,
SOLVENT DEWAXED
LIGHT PARAFFINIC
| 4. FIRST-AID MEASURES | |
FIRST AID - EYE CONTACT:
IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES
HOLDING EYELIDS OPEN. GET MEDICAL ATTENTION. DO NOT ALLOW RUBBING OF
EYES OR KEEPING EYES CLOSED.
FIRST AID - SKIN CONTACT:
WASH SKIN WITH SOAP AND WATER. REMOVE CONTAMINATED CLOTHING. GET MEDICAL
ATTENTION IF IRRITATION DEVELOPS OR PERSISTS.
FIRST AID - INHALATION:
IF YOU EXPERIENCE DIFFICULTY IN BREATHING, LEAVE THE AREA TO OBTAIN FRESH
AIR. IF CONTINUED DIFFICULTY IS EXPERIENCED, GET MEDICAL ASSISTANCE
IMMEDIATELY. REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE ARTIFICIAL
RESPIRATION. IF BREATHING IS DIFFICULT, GIVE OXYGEN. GET IMMEDIATE MEDICAL
ATTENTION. DO NOT USE MOUTH-TO-MOUTH RESUSCITATION.
FIRST AID - INGESTION:
IF SWALLOWED, DO NOT INDUCE VOMITING. IF VICTIM IS CONSCIOUS AND ALERT,
GIVE 2 TO 4 CUPFULS OF WATER OR MILK. CALL A PHYSICIAN OR POISON CONTROL
CENTER IMMEDIATELY. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
TREAT SYMPTOMATICALLY AND SUPPORTIVELY. SWALLOWING LESS THAN AN OUNCE WILL
NOT CAUSE SIGNIFICANT HARM. FOR LARGER AMOUNTS, DO NOT INDUCE VOMITING,
BUT GIVE ONE OR TWO GLASSES OF WATER TO DRINK AND GET MEDICAL ATTENTION.
IF SWALLOWED, RINSE MOUTH WITH WATER. IF FEELING UNWELL, GET MEDICAL
ATTENTION.
| 5. FIRE-FIGHTING MEASURES | |
EXTINGUISHING MEDIA:
ALCOHOL FILM FORMING FOAM, CARBON DIOXIDE, DRY CHEMICAL, WATER FOG
UNUSUAL FIRE AND EXPLOSION HAZARDS:
CLOSED CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT DUE TO BUILDUP
OF STEAM. ISOLATE FROM HEAT, ELECTRICAL EQUIPMENT, SPARKS AND OPEN FLAME.
NO UNUSUAL FIRE OR EXPLOSION HAZARDS NOTED. KEEP CONTAINERS TIGHTLY CLOSED.
FLASH POINT IS TESTED TO BE GREATER THAN 200 DEGREES F.
SPECIAL FIREFIGHTING PROCEDURES:
EVACUATE AREA AND FIGHT FIRE FROM A SAFE DISTANCE. WATER MAY BE USED TO
COOL CLOSED CONTAINERS TO PREVENT BUILDUP OF STEAM. IF WATER IS USED, FOG
NOZZLES ARE PREFERRED.
SPECIAL FIRE AND EXPLOSION HAZARD (COMBUSTIBLE DUST): NO INFORMATION
| 6. ACCIDENTAL RELEASE MEASURES | |
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED:
DISPOSE OF ACCORDING TO LOCAL, STATE (PROVINCIAL) AND FEDERAL REGULATIONS.
DO NOT INCINERATE CLOSED CONTAINERS. IF SPILLED, CONTAIN SPILLED MATERIAL
AND REMOVE WITH INERT ABSORBENT. DISPOSE OF CONTAMINATED ABSORBENT,
CONTAINER, AND UNUSED CONTENTS IN ACCORDANCE WITH LOCAL, STATE, AND
FEDERAL REGULATIONS. DO NOT INCINERATE CLOSED CONTAINERS
| 7. HANDLING AND STORAGE | |
HANDLING:
WASH THOROUGHLY AFTER HANDLING. WASH HANDS BEFORE EATING. REMOVE
CONTAMINATED CLOTHING AND LAUNDER BEFORE REUSE. USE ONLY IN A
WELL-VENTILATED AREA. USE ONLY WITH ADEQUATE VENTILATION. AVOID PROLONGED
OR REPEATED CONTACT WITH SKIN. FOLLOW ALL SDS AND LABEL PRECAUTIONS EVEN
AFTER CONTAINER IS EMPTIED BECAUSE IT MAY RETAIN PRODUCT RESIDUES. AVOID
BREATHING FUMES, VAPORS, OR MIST. AVOID CONTACT WITH EYES, SKIN AND
CLOTHING.
STORAGE:
KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE FROM HEAT, ELECTRICAL EQUIPMENT,
SPARKS AND OPEN FLAME. KEEP CONTAINER CLOSED WHEN NOT IN USE. STORE IN A
DRY, WELL VENTILATED PLACE. KEEP CONTAINER TIGHTLY CLOSED WHEN NOT IN USE.
ADVICE ON SAFE HANDLING OF COMBUSTIBLE DUST: NO INFORMATION
| 8. EXPOSURE CONTROLS / PERSONAL PROTECTION | |
CHEMICAL NAME CAS-NO. WEIGHT % LESS THAN
SURFACTANT PROPRIETARY 30.0
TITANIUM DIOXIDE 13463-67-7 10.0
ETHYLENE GLYCOL MONOPROPYL ETHER 2807-30-9 5.0
SOLVENT NAPHTHA, LIGHT AROMATIC 64742-95-6 5.0
DISTILLATES (PETROLEUM) 64742-65-0 1.0
SOLVENT-DEWAXED HEAVY PARAFFINIC
PETROLEUM DISTILLATES, 64742-56-9 1.0
SOLVENT DEWAXED LIGHT PARAFFINIC
CHEMICAL NAME ACGIH ACGIH OSHA OSHA
TLV-TWA TLV-STEL PEL-TWA PEL-CEILING
SURFACTANT N.E. N.E. N.E. N.E.
TITANIUM DIOXIDE 10 MG/M3 N.E. 15 MG/M3 N.E.
ETHYLENE GLYCOL N.E. N.E. N.E. N.E.
MONOPROPYL ETHER
SOLVENT NAPHTHA, N.E. N.E. N.E. N.E.
LIGHT AROMATIC
DISTILLATES (PETROLEUM) N.E. N.E. N.E. N.E.
SOLVENT-DEWAXED HEAVY
PARAFFINIC
PETROLEUM DISTILLATES, N.E. N.E. N.E. N.E.
SOLVENT DEWAXED LIGHT
PARAFFINIC
PERSONAL PROTECTION:
ENGINEERING CONTROLS:
USE PROCESS ENCLOSURES, LOCAL EXHAUST VENTILATION, OR OTHER ENGINEERING
CONTROLS TO CONTROL AIRBORNE LEVELS BELOW RECOMMENDED EXPOSURE LIMITS.
PREVENT BUILD-UP OF VAPORS BY OPENING ALL DOORS AND WINDOWS TO ACHIEVE
CROSS-VENTILATION.
RESPIRATORY PROTECTION:
A NIOSH/MSHA APPROVED AIR PURIFYING RESPIRATOR WITH AN ORGANIC VAPOR
CARTRIDGE OR CANISTER MAY BE PERMISSIBLE UNDER CERTAIN CIRCUMSTANCES
WHERE AIRBORNE CONCENTRATIONS ARE EXPECTED TO EXCEED EXPOSURE LIMITS.
PROTECTION PROVIDED BY AIR PURIFYING RESPIRATORS IS LIMITED. USE A
POSITIVE PRESSURE AIR SUPPLIED RESPIRATOR IF THERE IS ANY POTENTIAL FOR
AN UNCONTROLLED RELEASE, EXPOSURE LEVELS ARE NOT KNOWN, OR IN ANY OTHER
CIRCUMSTANCES WHERE AIR PURIFYING RESPIRATORS MAY NOT PROVIDE ADEQUATE
PROTECTION. A RESPIRATORY PROTECTION PROGRAM THAT MEETS OSHA 1910.134
AND ANSI Z88.2 REQUIREMENTS MUST BE FOLLOWED WHENEVER WORKPLACE CONDITIONS
WARRANT A RESPIRATOR'S USE.
SKIN PROTECTION:
USE IMPERVIOUS GLOVES TO PREVENT SKIN CONTACT AND ABSORPTION OF THIS
MATERIAL THROUGH THE SKIN. NITRILE OR NEOPRENE GLOVES MAY AFFORD ADEQUATE
SKIN PROTECTION. USE GLOVES TO PREVENT PROLONGED SKIN CONTACT.
EYE PROTECTION:
USE SAFETY EYEWEAR DESIGNED TO PROTECT AGAINST SPLASH OF LIQUIDS.
OTHER PROTECTIVE EQUIPMENT:
REFER TO SAFETY SUPERVISOR OR INDUSTRIAL HYGIENIST FOR FURTHER GUIDANCE
REGARDING TYPES OF PERSONAL PROTECTIVE EQUIPMENT AND THEIR APPLICATIONS.
HYGIENIC PRACTICES:
WASH THOROUGHLY WITH SOAP AND WATER BEFORE EATING, DRINKING OR SMOKING.
REMOVE CONTAMINATED CLOTHING IMMEDIATELY AND LAUNDER BEFORE REUSE.
ENGINEERING MEASURES FOR COMBUSTIBLE DUST: NO INFORMATION
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE: LIQUID
PHYSICAL STATE: LIQUID
ODOR: SOLVENT LIKE
ODOR THRESHOLD: N.E.
RELATIVE DENSITY: 1.127
PH: N.D.
FREEZE POINT, DEG. C: N.D.
VISCOSITY: N.D.
SOLUBILITY IN WATER: MISCIBLE
PARTITION COEFFICIENT, N-OCTANOL/WATER: N.D.
DECOMPOSITION TEMP., DEG. C: N.D.
BOILING RANGE, DEG. C: 100 - 537
EXPLOSIVE LIMITS, VOL%: 1.0 - 7.0
FLAMMABILITY: DOES NOT SUPPORT COMBUSTION
FLASH POINT, DEG. C: 94
EVAPORATION RATE: SLOWER THAN ETHER
AUTO-IGNITION TEMP., DEG. C: N.D.
VAPOR DENSITY: HEAVIER THAN AIR
VAPOR PRESSURE: N.D.
(SEE "OTHER INFORMATION" SECTION FOR ABBREVIATION LEGEND)
| 10. STABILITY AND REACTIVITY | |
CONDITIONS TO AVOID: AVOID CONTACT WITH STRONG ACID AND STRONG BASES.
INCOMPATIBILITY:
INCOMPATIBLE WITH STRONG OXIDIZING AGENTS, STRONG ACIDS AND STRONG
ALKALIES.
HAZARDOUS DECOMPOSITION:
BY OPEN FLAME, CARBON MONOXIDE AND CARBON DIOXIDE. WHEN HEATED TO
DECOMPOSITION, IT EMITS ACRID SMOKE AND IRRITATING FUMES.
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR UNDER NORMAL CONDITIONS.
STABILITY: THIS PRODUCT IS STABLE UNDER NORMAL STORAGE CONDITIONS.
| 11. TOXICOLOGICAL INFORMATION | |
EFFECTS OF OVEREXPOSURE - EYE CONTACT:
CAUSES EYE IRRITATION. IRRITATING, AND MAY INJURE EYE TISSUE IF NOT
REMOVED PROMPTLY.
EFFECTS OF OVEREXPOSURE - SKIN CONTACT:
CAUSES SKIN IRRITATION. ALLERGIC REACTIONS ARE POSSIBLE. MAY CAUSE SKIN
SENSITIZATION, AN ALLERGIC REACTION, WHICH BECOMES EVIDENT UPON RE-EXPOSURE
TO THIS MATERIAL. LOW HAZARD FOR USUAL INDUSTRIAL HANDLING OR COMMERCIAL
HANDLING BY TRAINED PERSONNEL.
EFFECTS OF OVEREXPOSURE - INHALATION:
HIGH GAS, VAPOR, MIST OR DUST CONCENTRATIONS MAY BE HARMFUL IF INHALED.
PROLONGED OR EXCESSIVE INHALATION MAY CAUSE RESPIRATORY TRACT IRRITATION.
AVOID BREATHING FUMES, SPRAY, VAPORS, OR MIST.
EFFECTS OF OVEREXPOSURE - INGESTION: SUBSTANCE MAY BE HARMFUL IF SWALLOWED.
EFFECTS OF OVEREXPOSURE - CHRONIC HAZARDS:
CONTAINS TITANIUM DIOXIDE. TITANIUM DIOXIDE IS LISTED AS A GROUP
2B-"POSSIBLY CARCINOGENIC TO HUMANS" BY IARC. NO SIGNIFICANT EXPOSURE TO
TITANIUM DIOXIDE IS THOUGHT TO OCCUR DURING THE USE OF PRODUCTS IN WHICH
TITANIUM DIOXIDE IS BOUND TO OTHER MATERIALS, SUCH AS IN PAINTS DURING
BRUSH APPLICATION OR DRYING. RISK OF OVEREXPOSURE DEPENDS ON DURATION AND
LEVEL OF EXPOSURE TO DUST FROM REPEATED SANDING OF SURFACES OR SPRAY MIST
AND THE ACTUAL CONCENTRATION OF TITANIUM DIOXIDE IN THE FORMULA.
(REF: IARC MONOGRAPH, VOL. 93, 2010)
PRIMARY ROUTE(S) OF ENTRY:
EYE CONTACT, INGESTION, INHALATION, SKIN ABSORPTION, SKIN CONTACT
ACUTE TOXICITY VALUES:
THE ACUTE EFFECTS OF THIS PRODUCT HAVE NOT BEEN TESTED. DATA ON INDIVIDUAL
COMPONENTS ARE TABULATED BELOW:
CAS-NO. CHEMICAL NAME ORAL LD50 DERMAL LD50 VAPOR LC50
13463-67-7 TITANIUM DIOXIDE >10000 MG/KG 2500 MG/KG N.E.
RAT
2807-30-9 ETHYLENE GLYCOL 3089 MG/KG 870 MG/KG N.E.
MONOPROPYL ETHER RAT RABBIT
64742-95-6 SOLVENT NAPHTHA, 8400 MG/KG >2000 MG/KG N.E.
LIGHT AROMATIC RAT RABBIT
64742-65-0 DISTILLATES >15000 MG/KG >5000 MG/KG 21 MG/L
(PETROLEUM) RAT RABBIT
SOLVENT-DEWAXED
HEAVY PARAFFINIC
64742-56-9 PETROLEUM >5000 MG/KG >5000 MG/KG N.E.
DISTILLATES, RAT RABBIT
SOLVENT DEWAXED
LIGHT PARAFFINIC
N.E. - NOT ESTABLISHED
| 12. ECOLOGICAL INFORMATION | |
ECOLOGICAL INFORMATION: PRODUCT IS A MIXTURE OF LISTED COMPONENTS.
| 13. DISPOSAL INFORMATION | |
DISPOSAL INFORMATION:
DISPOSE OF MATERIAL IN ACCORDANCE TO LOCAL, STATE, AND FEDERAL REGULATIONS
AND ORDINANCES. DO NOT ALLOW TO ENTER WATERWAYS, WASTEWATER, SOIL, STORM
DRAINS OR SEWER SYSTEMS.
| 14. TRANSPORT INFORMATION | |
DOMESTIC INTERNATIONAL AIR (IATA) TDG (CANADA)
(USDOT) (IMDG)
UN NUMBER N.A. N.A. N.A. N.A.
PROPER NOT REGULATED NOT REGULATED NOT REGULATED NOT REGULATED
SHIPPING NAME
HAZARD CLASS N.A. N.A. N.A. N.A.
PACKING GROUP N.A. N.A. N.A. N.A.
LIMITED NO NO NO NO
QUANTITY
| 15. REGULATORY INFORMATION | |
U.S. FEDERAL REGULATIONS:
CERCLA - SARA HAZARD CATEGORY:
THIS PRODUCT HAS BEEN REVIEWED ACCORDING TO THE EPA 'HAZARD CATEGORIES'
PROMULGATED UNDER SECTIONS 311 AND 312 OF THE SUPERFUND AMENDMENT AND
REAUTHORIZATION ACT OF 1986 (SARA TITLE III) AND IS CONSIDERED, UNDER
APPLICABLE DEFINITIONS, TO MEET THE FOLLOWING CATEGORIES:
CARCINOGENICITY, ACUTE TOXICITY (ANY ROUTE OF EXPOSURE)
SARA SECTION 313:
THIS PRODUCT CONTAINS THE FOLLOWING SUBSTANCES SUBJECT TO THE REPORTING
REQUIREMENTS OF SECTION 313 OF TITLE III OF THE SUPERFUND AMENDMENT AND
REAUTHORIZATION ACT OF 1986 AND 40 CFR PART 372:
CHEMICAL NAME CAS-NO.
ETHYLENE GLYCOL MONOPROPYL ETHER 2807-30-9
TOXIC SUBSTANCES CONTROL ACT:
THIS PRODUCT CONTAINS THE FOLLOWING CHEMICAL SUBSTANCES SUBJECT TO THE
REPORTING REQUIREMENTS OF TSCA 12(B) IF EXPORTED FROM THE UNITED STATES:
NO TSCA 12(B) COMPONENTS EXIST IN THIS PRODUCT.
| 16. OTHER INFORMATION | |
HMIS RATINGS:
HEALTH 2*
FLAMMABILITY 1
PHYSICAL HAZARD 0
PERSONAL PROTECTION X
NFPA RATINGS:
HEALTH 2
FLAMMABILITY 1
INSTABILITY 0
VOLATILE ORGANIC COMPOUNDS: 203 G/L
SDS REVISION DATE: 8/7/2018
REASON FOR REVISION:
SUBSTANCE AND/OR PRODUCT PROPERTIES CHANGED IN SECTION(S):
03 - COMPOSITION/INFORMATION ON INGREDIENTS
LEGEND:
N.A. - NOT APPLICABLE
N.E. - NOT ESTABLISHED
N.D. - NOT DETERMINED
THE MANUFACTURER BELIEVES, TO THE BEST OF ITS KNOWLEDGE, INFORMATION AND
BELIEF, THE INFORMATION CONTAINED HEREIN TO BE ACCURATE AND RELIABLE AS
OF THE DATE OF THIS SAFETY DATA SHEET. HOWEVER, BECAUSE THE CONDITIONS OF
HANDLING, USE, AND STORAGE OF THESE MATERIALS ARE BEYOND OUR CONTROL, WE
ASSUME NO RESPONSIBILITY OR LIABILITY FOR PERSONAL INJURY OR PROPERTY
DAMAGE INCURRED BY THE USE OF THESE MATERIALS. THE MANUFACTURER MAKES NO
WARRANTY, EXPRESSED OR IMPLIED, REGARDING THE ACCURACY OR RELIABILITY OF
THE DATA OR RESULTS OBTAINED FROM THEIR USE. ALL MATERIALS MAY PRESENT
UNKNOWN HAZARDS AND SHOULD BE USED WITH CAUTION. THE INFORMATION AND
RECOMMENDATIONS IN THIS MATERIAL SAFETY DATA SHEET ARE OFFERED FOR THE
USERS' CONSIDERATION AND EXAMINATION. IT IS THE RESPONSIBILITY OF THE USER
TO DETERMINE THE FINAL SUITABILITY OF THIS INFORMATION AND TO COMPLY WITH
ALL APPLICABLE INTERNATIONAL, FEDERAL, STATE, AND LOCAL LAWS AND
REGULATIONS.