| Common Name: | LPS RED & REDI, 05816 |
| Manufacturer: | ITW PRO BRANDS |
| SDS Revision Date: | 3/31/2017 |
| SDS Format: | GHS-US |
| Item Number(s): | 5YH77 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
LPS(R*)
SAFETY DATA SHEET
| 1. IDENTIFICATION |  |
PRODUCT IDENTIFIER: LPS(R*) RED & REDI
OTHER MEANS OF IDENTIFICATION:
SDS NUMBER: 05816
PART NUMBER: 05816
RECOMMENDED USE:
A RED COLORED, MULTI-PURPOSE GREASE DESIGNED WITH HIGH TEMPERATURE
RESISTANCE WHILE PROVIDING EXCELLENT LUBRICATION.
RECOMMENDED RESTRICTIONS: NONE KNOWN.
MANUFACTURER/IMPORTER/SUPPLIER/DISTRIBUTOR INFORMATION:
MANUFACTURER:
MANUFACTURER:
COMPANY NAME:
ITW PRO BRANDS
ADDRESS 4647
HUGH HOWELL RD.
TUCKER, GA 30084
COUNTRY: (USA.)
TEL: +1 770-243-8800
IN CASE OF EMERGENCY:
1 -800-424-9300 (INSIDE U.S.)
+001 703-527-3887 (OUTSIDE U.S.)
WEBSITE: WWW.LPSLABS.COM
E-MAIL: LPSSDS@ITWPROBRANDS.COM
| 2. HAZARD(S) IDENTIFICATION | |
PHYSICAL HAZARDS:
FLAMMABLE AEROSOLS: CATEGORY 1
GASES UNDER PRESSURE: LIQUEFIED GAS
HEALTH HAZARDS:
SKIN CORROSION/IRRITATION: CATEGORY 2
REPRODUCTIVE TOXICITY: CATEGORY 2
SPECIFIC TARGET ORGAN TOXICITY, SINGLE EXPOSURE:
CATEGORY 3 NARCOTIC EFFECTS
SPECIFIC TARGET ORGAN TOXICITY, REPEATED EXPOSURE (INHALATION):
CATEGORY 2 (NERVOUS SYSTEM)
ENVIRONMENTAL HAZARDS: NOT CLASSIFIED.
OSHA DEFINED HAZARDS: NOT CLASSIFIED.
LABEL ELEMENTS:
FLAME
GAS CYLINDER
HEALTH HAZARD
EXCLAMATION MARK
SIGNAL WORD: DANGER
HAZARD STATEMENT:
EXTREMELY FLAMMABLE AEROSOL. CONTAINS GAS UNDER PRESSURE; MAY EXPLODE IF
HEATED. CAUSES SKIN IRRITATION. SUSPECTED OF DAMAGING FERTILITY OR THE
UNBORN CHILD. MAY CAUSE DROWSINESS OR DIZZINESS. MAY CAUSE DAMAGE TO ORGANS
(NERVOUS SYSTEM) THROUGH PROLONGED OR REPEATED EXPOSURE BY INHALATION.
PRECAUTIONARY STATEMENT:
PREVENTION:
OBTAIN SPECIAL INSTRUCTIONS BEFORE USE. DO NOT HANDLE UNTIL ALL SAFETY
PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD. KEEP AWAY FROM HEAT/SPARKS/OPEN
FLAMES/HOT SURFACES. - NO SMOKING. DO NOT SPRAY ON AN OPEN FLAME OR OTHER
IGNITION SOURCE. PRESSURIZED CONTAINER: DO NOT PIERCE OR BURN, EVEN AFTER
USE. DO NOT BREATHE GAS. WASH THOROUGHLY AFTER HANDLING. USE ONLY OUTDOORS
OR IN A WELL-VENTILATED AREA. WEAR PROTECTIVE GLOVES/PROTECTIVE
CLOTHING/EYE PROTECTION/FACE PROTECTION.
RESPONSE:
IF ON SKIN: WASH WITH PLENTY OF WATER.
IF INHALED:
REMOVE PERSON TO FRESH AIR AND KEEP COMFORTABLE FOR BREATHING.
IF EXPOSED OR CONCERNED:
GET MEDICAL ADVICE/ATTENTION. CALL A POISON CENTER/DOCTOR IF YOU FEEL
UNWELL.
IF SKIN IRRITATION OCCURS:
GET MEDICAL ADVICE/ATTENTION. TAKE OFF CONTAMINATED CLOTHING AND WASH
BEFORE REUSE.
STORAGE:
STORE IN A WELL-VENTILATED PLACE. KEEP CONTAINER TIGHTLY CLOSED. STORE
LOCKED UP. PROTECT FROM SUNLIGHT. DO NOT EXPOSE TO TEMPERATURES EXCEEDING
50 DEG. C/122 DEG. F.
DISPOSAL:
DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH
LOCAL/REGIONAL/NATIONAL/INTERNATIONAL REGULATIONS.
HAZARD(S) NOT OTHERWISE CLASSIFIED (HNOC): NONE KNOWN.
SUPPLEMENTAL INFORMATION: NONE KNOWN.
| 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
MIXTURES:
CHEMICAL NAME COMMON NAME AND SYNONYMS CAS NUMBER %
PETROLEUM OIL 64742-52-5 30 - 40
PETROLEUM GASES, 68476-86-8 20 - 30
LIQUEFIED, SWEETENED
2-METHYLPENTANE 107-83-5 10 - 20
2,3-DIMETHYLBUTANE 79-29-8 1 - 10
3-METHYLPENTANE 96-14-0 1 - 10
2,2-DIMETHYLBUTANE 75-83-2 1 - 5
DISTILLATES PETROLEUM 64742-47-8 1 - 5
HYDROTREATED LIGHT
N-HEXANE 110-54-3 1 - 5
| 4. FIRST-AID MEASURES | |
INHALATION:
REMOVE VICTIM TO FRESH AIR AND KEEP AT REST IN A POSITION COMFORTABLE FOR
BREATHING. CALL A POISON CENTER OR DOCTOR/PHYSICIAN IF YOU FEEL UNWELL.
SKIN CONTACT:
REMOVE CONTAMINATED CLOTHING. WASH WITH PLENTY OF SOAP AND WATER.
IF SKIN IRRITATION OCCURS:
GET MEDICAL ADVICE/ATTENTION. WASH CONTAMINATED CLOTHING BEFORE REUSE.
EYE CONTACT:
RINSE WITH WATER. GET MEDICAL ATTENTION IF IRRITATION DEVELOPS AND
PERSISTS.
INGESTION:
NOT LIKELY, DUE TO THE FORM OF THE PRODUCT. IN THE UNLIKELY EVENT OF
SWALLOWING CONTACT A PHYSICIAN OR POISON CONTROL CENTER. RINSE MOUTH.
MOST IMPORTANT SYMPTOMS/EFFECTS, ACUTE AND DELAYED:
MAY CAUSE DROWSINESS AND DIZZINESS. NARCOSIS. HEADACHE. NAUSEA, VOMITING.
BEHAVIORAL CHANGES. DECREASE IN MOTOR FUNCTIONS. SKIN IRRITATION. MAY CAUSE
REDNESS AND PAIN. PROLONGED EXPOSURE MAY CAUSE CHRONIC EFFECTS.
INDICATION OF IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED:
PROVIDE GENERAL SUPPORTIVE MEASURES AND TREAT SYMPTOMATICALLY. KEEP VICTIM
UNDER OBSERVATION. SYMPTOMS MAY BE DELAYED.
GENERAL INFORMATION:
IF EXPOSED OR CONCERNED:
GET MEDICAL ADVICE/ATTENTION. IF YOU FEEL UNWELL, SEEK MEDICAL ADVICE
(SHOW THE LABEL WHERE POSSIBLE). ENSURE THAT MEDICAL PERSONNEL ARE AWARE
OF THE MATERIAL(S) INVOLVED, AND TAKE PRECAUTIONS TO PROTECT THEMSELVES.
SHOW THIS SAFETY DATA SHEET TO THE DOCTOR IN ATTENDANCE.
| 5. FIRE-FIGHTING MEASURES | |
SUITABLE EXTINGUISHING MEDIA:
WATER FOG. FOAM. DRY CHEMICAL POWDER. CARBON DIOXIDE (CO2).
UNSUITABLE EXTINGUISHING MEDIA:
DO NOT USE WATER JET AS AN EXTINGUISHER, AS THIS WILL SPREAD THE FIRE.
SPECIFIC HAZARDS ARISING FROM THE CHEMICAL:
CONTENTS UNDER PRESSURE. PRESSURIZED CONTAINER MAY EXPLODE WHEN EXPOSED
TO HEAT OR FLAME. DURING FIRE, GASES HAZARDOUS TO HEALTH MAY BE FORMED.
SPECIAL PROTECTIVE EQUIPMENT AND PRECAUTIONS FOR FIREFIGHTERS:
FIREFIGHTERS MUST USE STANDARD PROTECTIVE EQUIPMENT INCLUDING FLAME
RETARDANT COAT, HELMET WITH FACE SHIELD, GLOVES, RUBBER BOOTS, AND IN
ENCLOSED SPACES, SCBA.
FIRE FIGHTING EQUIPMENT/INSTRUCTIONS:
IN CASE OF FIRE:
STOP LEAK IF SAFE TO DO SO. DO NOT MOVE CARGO OR VEHICLE IF CARGO HAS BEEN
EXPOSED TO HEAT. MOVE CONTAINERS FROM FIRE AREA IF YOU CAN DO SO WITHOUT
RISK. CONTAINERS SHOULD BE COOLED WITH WATER TO PREVENT VAPOR PRESSURE
BUILD UP. FOR MASSIVE FIRE IN CARGO AREA, USE UNMANNED HOSE HOLDER OR
MONITOR NOZZLES, IF POSSIBLE. IF NOT, WITHDRAW AND LET FIRE BURN OUT.
SPECIFIC METHODS:
USE STANDARD FIREFIGHTING PROCEDURES AND CONSIDER THE HAZARDS OF OTHER
INVOLVED MATERIALS. MOVE CONTAINERS FROM FIRE AREA IF YOU CAN DO SO
WITHOUT RISK. COOL CONTAINERS EXPOSED TO FLAMES WITH WATER UNTIL WELL
AFTER THE FIRE IS OUT. IN THE EVENT OF FIRE AND/OR EXPLOSION DO NOT
BREATHE FUMES.
GENERAL FIRE HAZARDS:
EXTREMELY FLAMMABLE AEROSOL. CONTENTS UNDER PRESSURE. PRESSURIZED CONTAINER
MAY EXPLODE WHEN EXPOSED TO HEAT OR FLAME.
| 6. ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
KEEP UNNECESSARY PERSONNEL AWAY. KEEP PEOPLE AWAY FROM AND UPWIND OF
SPILL/LEAK. KEEP OUT OF LOW AREAS. MANY GASES ARE HEAVIER THAN AIR AND
WILL SPREAD ALONG GROUND AND COLLECT IN LOW OR CONFINED AREAS (SEWERS,
BASEMENTS, TANKS). WEAR APPROPRIATE PROTECTIVE EQUIPMENT AND CLOTHING
DURING CLEAN-UP. DO NOT BREATHE GAS. EMERGENCY PERSONNEL NEED
SELF-CONTAINED BREATHING EQUIPMENT. DO NOT TOUCH DAMAGED CONTAINERS OR
SPILLED MATERIAL UNLESS WEARING APPROPRIATE PROTECTIVE CLOTHING. VENTILATE
CLOSED SPACES BEFORE ENTERING THEM. LOCAL AUTHORITIES SHOULD BE ADVISED IF
SIGNIFICANT SPILLAGES CANNOT BE CONTAINED. USE PERSONAL PROTECTION
RECOMMENDED IN SECTION 8 OF THE SDS.
METHODS AND MATERIALS FOR CONTAINMENT AND CLEANING UP:
REFER TO ATTACHED SAFETY DATA SHEETS AND/OR INSTRUCTIONS FOR USE. STOP LEAK
IF YOU CAN DO SO WITHOUT RISK. ISOLATE AREA UNTIL GAS HAS DISPERSED.
ELIMINATE ALL IGNITION SOURCES (NO SMOKING, FLARES, SPARKS, OR FLAMES IN
IMMEDIATE AREA). KEEP COMBUSTIBLES (WOOD, PAPER, OIL, ETC.) AWAY FROM
SPILLED MATERIAL. PREVENT ENTRY INTO WATERWAYS, SEWER, BASEMENTS OR
CONFINED AREAS. ABSORB IN VERMICULITE, DRY SAND OR EARTH AND PLACE INTO
CONTAINERS. FOLLOWING PRODUCT RECOVERY, FLUSH AREA WITH WATER.
SMALL SPILLS:
WIPE UP WITH ABSORBENT MATERIAL (E.G. CLOTH, FLEECE). CLEAN SURFACE
THOROUGHLY TO REMOVE RESIDUAL CONTAMINATION. FOR WASTE DISPOSAL, SEE
SECTION 13 OF THE SDS.
ENVIRONMENTAL PRECAUTIONS:
AVOID DISCHARGE INTO DRAINS, WATER COURSES OR ONTO THE GROUND.
| 7. HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING:
OBTAIN SPECIAL INSTRUCTIONS BEFORE USE. DO NOT HANDLE UNTIL ALL SAFETY
PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD.
PRESSURIZED CONTAINER:
DO NOT PIERCE OR BURN, EVEN AFTER USE. DO NOT USE IF SPRAY BUTTON IS
MISSING OR DEFECTIVE. DO NOT SPRAY ON A NAKED FLAME OR ANY OTHER
INCANDESCENT MATERIAL. DO NOT SMOKE WHILE USING OR UNTIL SPRAYED SURFACE
IS THOROUGHLY DRY. DO NOT CUT, WELD, SOLDER, DRILL, GRIND, OR EXPOSE
CONTAINERS TO HEAT, FLAME, SPARKS, OR OTHER SOURCES OF IGNITION. ALL
EQUIPMENT USED WHEN HANDLING THE PRODUCT MUST BE GROUNDED. DO NOT RE-USE
EMPTY CONTAINERS. DO NOT BREATHE GAS. AVOID CONTACT WITH EYES, SKIN, AND
CLOTHING. AVOID PROLONGED EXPOSURE. PREGNANT OR BREASTFEEDING WOMEN MUST
NOT HANDLE THIS PRODUCT. SHOULD BE HANDLED IN CLOSED SYSTEMS, IF POSSIBLE.
USE ONLY IN WELL-VENTILATED AREAS. WEAR APPROPRIATE PERSONAL PROTECTIVE
EQUIPMENT. OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES.
CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES:
LEVEL 3 AEROSOL.
STORE LOCKED UP. PRESSURIZED CONTAINER. PROTECT FROM SUNLIGHT AND DO NOT
EXPOSE TO TEMPERATURES EXCEEDING 50 DEG. C/122 DEG. F. DO NOT PUNCTURE,
INCINERATE OR CRUSH. DO NOT HANDLE OR STORE NEAR AN OPEN FLAME, HEAT OR
OTHER SOURCES OF IGNITION. THIS MATERIAL CAN ACCUMULATE STATIC CHARGE WHICH
MAY CAUSE SPARK AND BECOME AN IGNITION SOURCE. STORE IN A WELL-VENTILATED
PLACE. STORED CONTAINERS SHOULD BE PERIODICALLY CHECKED FOR GENERAL
CONDITION AND LEAKAGE. STORE AWAY FROM INCOMPATIBLE MATERIALS (SEE
SECTION 10 OF THE SDS).
| 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
OCCUPATIONAL EXPOSURE LIMITS:
THE FOLLOWING CONSTITUENTS ARE THE ONLY CONSTITUENTS OF THE PRODUCT WHICH
HAVE A PEL, TLV OR OTHER RECOMMENDED EXPOSURE LIMIT. AT THIS TIME, THE
OTHER CONSTITUENTS HAVE NO KNOWN EXPOSURE LIMITS.
U.S. - OSHA:
COMPONENTS TYPE VALUE FORM
PETROLEUM OIL PEL 5 MG/M3 OIL MIST
(CAS 64742-52-5)
US. OSHA TABLE Z-1 LIMITS FOR AIR CONTAMINANTS (29 CFR 1910.1000):
COMPONENTS TYPE VALUE
N-HEXANE PEL 1800 MG/M3
(CAS 110-54-3) 500 PPM
ACGIH:
COMPONENTS TYPE VALUE FORM
PETROLEUM OIL TWA 5 MG/M3 OIL MIST
(CAS 64742-52-5)
US. ACGIH THRESHOLD LIMIT VALUES:
COMPONENTS TYPE VALUE
2,2-DIMETHYLBUTANE STEL 1000 PPM
(CAS 75-83-2)
TWA 500 PPM
2,3-DIMETHYLBUTANE STEL 1000 PPM
(CAS 79-29-8)
TWA 500 PPM
2-METHYLPENTANE STEL 1000 PPM
(CAS 107-83-5)
TWA 500 PPM
3-METHYLPENTANE STEL 1000 PPM
(CAS 96-14-0)
TWA 500 PPM
N-HEXANE TWA 50 PPM
(CAS 110-54-3)
US. NIOSH: POCKET GUIDE TO CHEMICAL HAZARDS
COMPONENTS TYPE VALUE
N-HEXANE TWA 180 MG/M3
(CAS 110-54-3) 50 PPM
BIOLOGICAL LIMIT VALUES:
ACGIH BIOLOGICAL EXPOSURE INDICES:
COMPONENTS VALUE DETERMINANT SPECIMEN SAMPLING TIME
N-HEXANE 0.4 MG/L 2,5-HEXANEDION, URINE *
(CAS 110-54-3) WITHOUT
HYDROLYSIS
* - FOR SAMPLING DETAILS, PLEASE SEE THE SOURCE DOCUMENT.
EXPOSURE GUIDELINES:
US - CALIFORNIA OELS SKIN DESIGNATION
N-HEXANE (CAS 110-54-3) CAN BE ABSORBED THROUGH THE SKIN.
US ACGIH THRESHOLD LIMIT VALUES SKIN DESIGNATION
N-HEXANE (CAS 110-54-3) CAN BE ABSORBED THROUGH THE SKIN.
APPROPRIATE ENGINEERING CONTROLS:
GOOD GENERAL VENTILATION (TYPICALLY 10 AIR CHANGES PER HOUR) SHOULD BE
USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS. IF APPLICABLE,
USE PROCESS ENCLOSURES, LOCAL EXHAUST VENTILATION, OR OTHER ENGINEERING
CONTROLS TO MAINTAIN AIRBORNE LEVELS BELOW RECOMMENDED EXPOSURE LIMITS. IF
EXPOSURE LIMITS HAVE NOT BEEN ESTABLISHED, MAINTAIN AIRBORNE LEVELS TO AN
ACCEPTABLE LEVEL. EYE WASH FOUNTAIN AND EMERGENCY SHOWERS ARE RECOMMENDED.
INDIVIDUAL PROTECTION MEASURES, SUCH AS PERSONAL PROTECTIVE EQUIPMENT:
EYE/FACE PROTECTION: WEAR SAFETY GLASSES WITH SIDE SHIELDS (OR GOGGLES).
SKIN PROTECTION:
HAND PROTECTION: WEAR APPROPRIATE CHEMICAL RESISTANT GLOVES.
OTHER:
WEAR APPROPRIATE CHEMICAL RESISTANT CLOTHING. USE OF AN IMPERVIOUS APRON
IS RECOMMENDED.
RESPIRATORY PROTECTION:
IF PERMISSIBLE LEVELS ARE EXCEEDED USE NIOSH MECHANICAL FILTER / ORGANIC
VAPOR CARTRIDGE OR AN AIR-SUPPLIED RESPIRATOR.
THERMAL HAZARDS:
WEAR APPROPRIATE THERMAL PROTECTIVE CLOTHING, WHEN NECESSARY.
GENERAL HYGIENE CONSIDERATIONS:
OBSERVE ANY MEDICAL SURVEILLANCE REQUIREMENTS. WHEN USING DO NOT SMOKE.
ALWAYS OBSERVE GOOD PERSONAL HYGIENE MEASURES, SUCH AS WASHING AFTER
HANDLING THE MATERIAL AND BEFORE EATING, DRINKING, AND/OR SMOKING.
ROUTINELY WASH WORK CLOTHING AND PROTECTIVE EQUIPMENT TO REMOVE
CONTAMINANTS.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE:
PHYSICAL STATE: GAS.
FORM: AEROSOL. LIQUEFIED GAS.
COLOR: RED.
ODOR: MILD. SOLVENT.
ODOR THRESHOLD: NOT ESTABLISHED
PH: NOT APPLICABLE
MELTING POINT/FREEZING POINT: NOT APPLICABLE
INITIAL BOILING POINT AND BOILING RANGE: APPROX. 70.2 DEG. C (158 DEG. F)
FLASH POINT: >-20.2 DEG. F (> -29.0 DEG. C) (BULK LIQUID) ESTIMATED
EVAPORATION RATE: <1 (ETHYL ETHER = 1)
FLAMMABILITY (SOLID, GAS): NOT AVAILABLE.
UPPER/LOWER FLAMMABILITY OR EXPLOSIVE LIMITS:
FLAMMABILITY LIMIT - LOWER (%): 1.8%
FLAMMABILITY LIMIT - UPPER (%): 9.5%
EXPLOSIVE LIMIT - LOWER (%): NOT AVAILABLE.
EXPLOSIVE LIMIT - UPPER (%): NOT AVAILABLE.
VAPOR PRESSURE: 2500 - 3500 MMHg @20 DEG. C (CALCULATED AEROSOL)
VAPOR DENSITY: 2 - 3 (AIR = 1)
RELATIVE DENSITY: NOT AVAILABLE.
SOLUBILITY(IES):
SOLUBILITY (WATER): NOT SOLUBLE IN WATER
PARTITION COEFFICIENT (N-OCTANOL/WATER): NOT ESTABLISHED
AUTO-IGNITION TEMPERATURE: NOT ESTABLISHED
DECOMPOSITION TEMPERATURE: NOT ESTABLISHED
VISCOSITY: 3100 - 4000 CP (BULK LIQUID)
OTHER INFORMATION:
EXPLOSIVE PROPERTIES: NOT EXPLOSIVE.
HEAT OF COMBUSTION: >30 KJ/G
OXIDIZING PROPERTIES: NOT OXIDIZING.
PERCENT VOLATILE: 65%
SPECIFIC GRAVITY: 0.77 - 0.8 @ 20 DEG. C
VOC: 65% PER STATE AND FEDERAL CONSUMER PRODUCT REGULATIONS
| 10. STABILITY AND REACTIVITY | |
REACTIVITY:
THE PRODUCT IS STABLE AND NON-REACTIVE UNDER NORMAL CONDITIONS OF USE,
STORAGE AND TRANSPORT.
CHEMICAL STABILITY: MATERIAL IS STABLE UNDER NORMAL CONDITIONS.
POSSIBILITY OF HAZARDOUS REACTIONS:
HAZARDOUS POLYMERIZATION DOES NOT OCCUR.
CONDITIONS TO AVOID:
HEAT. AVOID TEMPERATURES EXCEEDING THE FLASH POINT. CONTACT WITH
INCOMPATIBLE MATERIALS.
INCOMPATIBLE MATERIALS: STRONG OXIDIZING AGENTS.
HAZARDOUS DECOMPOSITION PRODUCTS: CARBON OXIDES.
| 11. TOXICOLOGICAL INFORMATION | |
INFORMATION ON LIKELY ROUTES OF EXPOSURE:
INHALATION:
MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE BY
INHALATION. MAY CAUSE DROWSINESS AND DIZZINESS. HEADACHE. NAUSEA,
VOMITING.
SKIN CONTACT: CAUSES SKIN IRRITATION.
EYE CONTACT: DIRECT CONTACT WITH EYES MAY CAUSE TEMPORARY IRRITATION.
INGESTION: EXPECTED TO BE A LOW INGESTION HAZARD.
SYMPTOMS RELATED TO THE PHYSICAL, CHEMICAL AND TOXICOLOGICAL
CHARACTERISTICS:
MAY CAUSE DROWSINESS AND DIZZINESS. NARCOSIS. HEADACHE. NAUSEA, VOMITING.
BEHAVIORAL CHANGES. DECREASE IN MOTOR FUNCTIONS. SKIN IRRITATION. MAY CAUSE
REDNESS AND PAIN.
INFORMATION ON TOXICOLOGICAL EFFECTS:
ACUTE TOXICITY: NOT EXPECTED TO BE ACUTELY TOXIC.
COMPONENTS SPECIES TEST RESULTS
DISTILLATES PETROLEUM HYDROTREATED LIGHT (CAS 64742-47-8):
ACUTE:
DERMAL:
LD50 RABBIT >2000 MG/KG
INHALATION:
VAPOR:
LC50 RAT >4.5 MG/L, 4 HOURS
N-HEXANE (CAS 110-54-3):
ACUTE:
DERMAL:
LD50 RABBIT >2000 MG/KG, 4 HOURS
PETROLEUM OIL (CAS 64742-52-5):
ACUTE:
DERMAL:
LD50 RABBIT >2000 MG/KG
INHALATION:
LC50 RAT >3.9 MG/L, 4 HOURS
ORAL:
LD50 RAT >2000 MG/KG
SKIN CORROSION/IRRITATION: CAUSES SKIN IRRITATION.
SERIOUS EYE DAMAGE/EYE IRRITATION:
DIRECT CONTACT WITH EYES MAY CAUSE TEMPORARY IRRITATION.
RESPIRATORY OR SKIN SENSITIZATION:
RESPIRATORY SENSITIZATION: NOT A RESPIRATORY SENSITIZER.
SKIN SENSITIZATION:
THIS PRODUCT IS NOT EXPECTED TO CAUSE SKIN SENSITIZATION.
GERM CELL MUTAGENICITY:
NO DATA AVAILABLE TO INDICATE PRODUCT OR ANY COMPONENTS PRESENT AT GREATER
THAN 0.1% ARE MUTAGENIC OR GENOTOXIC.
CARCINOGENICITY:
THIS PRODUCT IS NOT CONSIDERED TO BE A CARCINOGEN BY IARC, ACGIH, NTP,
OR OSHA.
IARC MONOGRAPHS. OVERALL EVALUATION OF CARCINOGENICITY: NOT LISTED.
OSHA SPECIFICALLY REGULATED SUBSTANCES (29 CFR 1910.1001-1050):
NOT REGULATED.
US. NATIONAL TOXICOLOGY PROGRAM (NTP) REPORT ON CARCINOGENS: NOT LISTED.
REPRODUCTIVE TOXICITY: SUSPECTED OF DAMAGING FERTILITY OR THE UNBORN CHILD.
SPECIFIC TARGET ORGAN TOXICITY - SINGLE EXPOSURE:
MAY CAUSE DROWSINESS AND DIZZINESS.
SPECIFIC TARGET ORGAN TOXICITY - REPEATED EXPOSURE:
MAY CAUSE DAMAGE TO ORGANS (NERVOUS SYSTEM) THROUGH PROLONGED OR REPEATED
EXPOSURE BY INHALATION.
ASPIRATION HAZARD: NOT LIKELY, DUE TO THE FORM OF THE PRODUCT.
CHRONIC EFFECTS:
MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE.
PROLONGED INHALATION MAY BE HARMFUL.
FURTHER INFORMATION: SYMPTOMS MAY BE DELAYED.
| 12. ECOLOGICAL INFORMATION | |
ECOTOXICITY:
THE PRODUCT IS NOT CLASSIFIED AS ENVIRONMENTALLY HAZARDOUS. HOWEVER, THIS
DOES NOT EXCLUDE THE POSSIBILITY THAT LARGE OR FREQUENT SPILLS CAN HAVE A
HARMFUL OR DAMAGING EFFECT ON THE ENVIRONMENT.
COMPONENTS SPECIES TEST RESULTS
DISTILLATES PETROLEUM HYDROTREATED LIGHT (CAS 64742-47-8):
AQUATIC:
FISH LC50 RAINBOW TROUT, DONALDSON 2.9 MG/L, 96 HOURS
TROUT (ONCORHYNCHUS MYKISS)
N-HEXANE (CAS 110-54-3):
AQUATIC:
FISH LC50 FATHEAD MINNOW 2.101 - 2.981 MG/L,
(PIMEPHALES PROMELAS) 96 HOURS
* ESTIMATES FOR PRODUCT MAY BE BASED ON ADDITIONAL COMPONENT DATA NOT
SHOWN.
PERSISTENCE AND DEGRADABILITY: NOT INHERENTLY BIODEGRADABLE.
BIOACCUMULATIVE POTENTIAL:
PARTITION COEFFICIENT N-OCTANOL / WATER (LOG KOW):
2,2-DIMETHYLBUTANE: 3.82
2,3-DIMETHYLBUTANE: 3.42
2-METHYLPENTANE: 3.74
3-METHYLPENTANE: 3.6
N-HEXANE: 3.9
MOBILITY IN SOIL: NO DATA AVAILABLE.
OTHER ADVERSE EFFECTS:
THE PRODUCT CONTAINS VOLATILE ORGANIC COMPOUNDS WHICH HAVE A PHOTOCHEMICAL
OZONE CREATION POTENTIAL.
| 13. DISPOSAL CONSIDERATIONS | |
DISPOSAL INSTRUCTIONS:
COLLECT AND RECLAIM OR DISPOSE IN SEALED CONTAINERS AT LICENSED WASTE
DISPOSAL SITE. CONTENTS UNDER PRESSURE. DO NOT PUNCTURE, INCINERATE OR
CRUSH. DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH
LOCAL/REGIONAL/NATIONAL/INTERNATIONAL REGULATIONS.
LOCAL DISPOSAL REGULATIONS:
DISPOSE IN ACCORDANCE WITH ALL APPLICABLE REGULATIONS.
HAZARDOUS WASTE CODE:
THE WASTE CODE SHOULD BE ASSIGNED IN DISCUSSION BETWEEN THE USER, THE
PRODUCER AND THE WASTE DISPOSAL COMPANY.
D001: WASTE FLAMMABLE MATERIAL WITH A FLASH POINT <140 F
D003: WASTE REACTIVE MATERIAL
WASTE FROM RESIDUES / UNUSED PRODUCTS:
DISPOSE OF IN ACCORDANCE WITH LOCAL REGULATIONS. EMPTY CONTAINERS OR
LINERS MAY RETAIN SOME PRODUCT RESIDUES. THIS MATERIAL AND ITS CONTAINER
MUST BE DISPOSED OF IN A SAFE MANNER (SEE: DISPOSAL INSTRUCTIONS).
CONTAMINATED PACKAGING:
SINCE EMPTIED CONTAINERS MAY RETAIN PRODUCT RESIDUE, FOLLOW LABEL WARNINGS
EVEN AFTER CONTAINER IS EMPTIED. EMPTY CONTAINERS SHOULD BE TAKEN TO AN
APPROVED WASTE HANDLING SITE FOR RECYCLING OR DISPOSAL. DO NOT RE-USE
EMPTY CONTAINERS.
| 14. TRANSPORT INFORMATION | |
DOT:
UN NUMBER: UN1950
UN PROPER SHIPPING NAME:
AEROSOLS, FLAMMABLE, (EACH NOT EXCEEDING 1 L CAPACITY)
TRANSPORT HAZARD CLASS(ES):
CLASS: 2.1
SUBSIDIARY RISK:
LABEL(S): 2.1
PACKING GROUP: NOT AVAILABLE.
ENVIRONMENTAL HAZARDS:
MARINE POLLUTANT: NO
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
SPECIAL PROVISIONS: N82
PACKAGING EXCEPTIONS: 306
PACKAGING NON BULK: NONE
PACKAGING BULK: NONE
IATA:
UN NUMBER: UN1950
UN PROPER SHIPPING NAME: AEROSOLS, FLAMMABLE
TRANSPORT HAZARD CLASS(ES):
CLASS: 2.1
SUBSIDIARY RISK:
PACKING GROUP: NOT AVAILABLE.
ENVIRONMENTAL HAZARDS: YES
ERG CODE: 10L
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
OTHER INFORMATION:
PASSENGER AND CARGO AIRCRAFT: ALLOWED WITH RESTRICTIONS.
CARGO AIRCRAFT ONLY: ALLOWED WITH RESTRICTIONS.
IMDG:
UN NUMBER: UN1950
UN PROPER SHIPPING NAME: AEROSOLS (HEXANES), MARINE POLLUTANT
TRANSPORT HAZARD CLASS(ES):
CLASS: 2
SUBSIDIARY RISK:
PACKING GROUP: NOT AVAILABLE.
ENVIRONMENTAL HAZARDS:
MARINE POLLUTANT: YES
EMS: F-D, S-U
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
TRANSPORT IN BULK ACCORDING TO ANNEX II OF MARPOL 73/78 AND THE IBC CODE:
NOT APPLICABLE.
DOT: FLAMMABLE GAS, CLASS/DIVISION 2.1
IATA; IMDG: CLASS 2.1, FLAMMABLE GASES
MARINE POLLUTANT: ENVIRONMENT
GENERAL INFORMATION:
IMDG REGULATED MARINE POLLUTANT. AVOID TRANSPORT ON VEHICLES WHERE THE
LOAD SPACE IS NOT SEPARATED FROM THE DRIVER'S COMPARTMENT. ENSURE VEHICLE
DRIVER IS AWARE OF THE POTENTIAL HAZARDS OF THE LOAD AND KNOWS WHAT TO DO
IN THE EVENT OF AN ACCIDENT OR AN EMERGENCY. BEFORE TRANSPORTING PRODUCT
CONTAINERS: ENSURE THAT CONTAINERS ARE FIRMLY SECURED. ENSURE CYLINDER
VALVE IS CLOSED AND NOT LEAKING. ENSURE VALVE OUTLET CAP NUT OR PLUG
(WHERE PROVIDED) IS CORRECTLY FITTED. ENSURE VALVE PROTECTION DEVICE
(WHERE PROVIDED) IS CORRECTLY FITTED. ENSURE ADEQUATE VENTILATION. ENSURE
COMPLIANCE WITH APPLICABLE REGULATIONS.
| 15. REGULATORY INFORMATION | |
US FEDERAL REGULATIONS:
THIS PRODUCT IS A "HAZARDOUS CHEMICAL" AS DEFINED BY THE OSHA HAZARD
COMMUNICATION STANDARD, 29 CFR 1910.1200.
TSCA SECTION 12(B) EXPORT NOTIFICATION (40 CFR 707, SUBPT. D):
NOT REGULATED.
CERCLA HAZARDOUS SUBSTANCE LIST (40 CFR 302.4):
N-HEXANE (CAS 110-54-3): LISTED.
SARA 304 EMERGENCY RELEASE NOTIFICATION: NOT REGULATED.
OSHA SPECIFICALLY REGULATED SUBSTANCES (29 CFR 1910.1001-1050):
NOT REGULATED.
SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 (SARA):
HAZARD CATEGORIES:
IMMEDIATE HAZARD: YES
DELAYED HAZARD: YES
FIRE HAZARD: YES
PRESSURE HAZARD: YES
REACTIVITY HAZARD: NO
SARA 302 EXTREMELY HAZARDOUS SUBSTANCE: NOT LISTED.
SARA 311/312 HAZARDOUS CHEMICAL: YES
SARA 313 (TRI REPORTING):
CHEMICAL NAME CAS NUMBER % BY WT.
N-HEXANE 110-54-3 1 - 5
OTHER FEDERAL REGULATIONS:
CLEAN AIR ACT (CAA) SECTION 112 HAZARDOUS AIR POLLUTANTS (HAPS) LIST:
N-HEXANE (CAS 110-54-3)
CLEAN AIR ACT (CAA) SECTION 112(R) ACCIDENTAL RELEASE PREVENTION
(40 CFR 68.130): NOT REGULATED.
SAFE DRINKING WATER ACT (SDWA): NOT REGULATED.
US STATE REGULATIONS:
CALIFORNIA SAFE DRINKING WATER AND TOXIC ENFORCEMENT ACT OF 1986
(PROPOSITION 65):
THIS MATERIAL IS NOT KNOWN TO CONTAIN ANY CHEMICALS CURRENTLY LISTED AS
CARCINOGENS OR REPRODUCTIVE TOXINS.
US. CALIFORNIA. CANDIDATE CHEMICALS LIST. SAFER CONSUMER PRODUCTS
REGULATIONS (CAL. CODE REGS, TIT. 22, 69502.3, SUBD. (A)):
N-HEXANE (CAS 110-54-3)
PETROLEUM GASES, LIQUEFIED, SWEETENED (CAS 68476-86-8)
PETROLEUM OIL (CAS 64742-52-5)
INTERNATIONAL INVENTORIES:
COUNTRY(S) OR REGION INVENTORY NAME ON INVENTORY
(YES/NO)*
AUSTRALIA AUSTRALIAN INVENTORY OF CHEMICAL YES
SUBSTANCES (AICS)
CANADA DOMESTIC SUBSTANCES LIST (DSL) YES
CANADA NON-DOMESTIC SUBSTANCES LIST (NDSL) NO
CHINA INVENTORY OF EXISTING CHEMICAL YES
SUBSTANCES IN CHINA (IECSC)
EUROPE EUROPEAN INVENTORY OF EXISTING YES
COMMERCIAL CHEMICAL SUBSTANCES
(EINECS)
EUROPE EUROPEAN LIST OF NOTIFIED CHEMICAL NO
SUBSTANCES (ELINCS)
JAPAN INVENTORY OF EXISTING AND NEW NO
CHEMICAL SUBSTANCES (ENCS)
KOREA EXISTING CHEMICALS LIST (ECL) YES
NEW ZEALAND NEW ZEALAND INVENTORY YES
PHILIPPINES PHILIPPINE INVENTORY OF CHEMICALS YES
AND CHEMICAL SUBSTANCES (PICCS)
UNITED STATES & TOXIC SUBSTANCES CONTROL ACT (TSCA) YES
PUERTO RICO INVENTORY
*A "YES" INDICATES THAT ALL COMPONENTS OF THIS PRODUCT COMPLY WITH
THE INVENTORY REQUIREMENTS ADMINISTERED BY THE GOVERNING COUNTRY(S)
A "NO" INDICATES THAT ONE OR MORE COMPONENTS OF THE PRODUCT ARE NOT LISTED
OR EXEMPT FROM LISTING ON THE INVENTORY ADMINISTERED BY THE GOVERNING
COUNTRY(S).
| 16. OTHER INFORMATION, INCLUDING DATE OF PREPARATION | |
OR LAST REVISION
ISSUE DATE: 03-31-2017
VERSION #: 01
DISCLAIMER:
ITW PRO BRANDS CANNOT ANTICIPATE ALL CONDITIONS UNDER WHICH THIS
INFORMATION AND ITS PRODUCT, OR THE PRODUCTS OF OTHER MANUFACTURERS IN
COMBINATION WITH ITS PRODUCT, MAY BE USED. IT IS THE USER'S RESPONSIBILITY
TO ENSURE SAFE CONDITIONS FOR HANDLING, STORAGE AND DISPOSAL OF THE
PRODUCT, AND TO ASSUME LIABILITY FOR LOSS, INJURY, DAMAGE OR EXPENSE DUE
TO IMPROPER USE. THE INFORMATION PROVIDED IN THIS SAFETY DATA SHEET IS
CORRECT TO THE BEST OF OUR KNOWLEDGE, INFORMATION AND BELIEF AT THE DATE
OF ITS PUBLICATION. THE INFORMATION GIVEN IS DESIGNED ONLY AS A GUIDANCE
FOR SAFE HANDLING, USE, PROCESSING, STORAGE, TRANSPORTATION, DISPOSAL AND
RELEASE AND IS NOT TO BE CONSIDERED A WARRANTY OR QUALITY SPECIFICATION.
THE INFORMATION RELATES ONLY TO THE SPECIFIC MATERIAL DESIGNATED AND MAY
NOT BE VALID FOR SUCH MATERIAL USED IN COMBINATION WITH ANY OTHER
MATERIALS OR IN ANY PROCESS, UNLESS SPECIFIED IN THE TEXT.
REVISION INFORMATION:
THIS DOCUMENT HAS UNDERGONE SIGNIFICANT CHANGES AND SHOULD BE REVIEWED IN
ITS ENTIRETY.
MATERIAL NAME: LPS(R*) RED & REDI
SDS US