| Common Name: | EPOXY 1-GL 2PK 9100 BLACK, 9179402 |
| Manufacturer: | RUST-OLEUM |
| SDS Revision Date: | 8/7/2018 |
| SDS Format: | GHS-US |
| Item Number(s): | 6A385 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
DATE PRINTED: 8/7/2018
RUST-OLEUM CORPORATION
SAFETY DATA SHEET
TRUSTED QUALITY SINCE 1921
WWW.RUSTOLEUM.COM
| 1. IDENTIFICATION |  |
PRODUCT NAME: EPOXY 1-GL 2PK 9100 BLACK
PRODUCT IDENTIFIER: 9179402
RECOMMENDED USE: TOPCOAT/EPOXY MASTIC
REVISION DATE: 8/7/2018
SUPERCEDES DATE: 3/14/2018
SUPPLIER:
RUST-OLEUM CORPORATION
11 HAWTHORN PARKWAY
VERNON HILLS, IL 60061
USA
RUST-OLEUM CANADA (ROCA)
200 CONFEDERATION PARKWAY
CONCORD, ON L4K 4T8
CANADA
EMERGENCY PHONE: 800-387-3625
MANUFACTURER:
RUST-OLEUM CORPORATION
11 HAWTHORN PARKWAY
VERNON HILLS, IL 60061
USA
PREPARER: REGULATORY DEPARTMENT
EMERGENCY TELEPHONE:
24 HOUR HOTLINE: 847-367-7700
| 2. HAZARD IDENTIFICATION | |
CLASSIFICATION:
SYMBOL(S) OF PRODUCT:
FLAME
EXCLAMATION MARK
HEALTH HAZARD
SIGNAL WORD: WARNING
POSSIBLE HAZARDS:
28% OF THE MIXTURE CONSISTS OF INGREDIENT(S) OF UNKNOWN ACUTE TOXICITY.
GHS HAZARD STATEMENTS:
FLAMMABLE LIQUID, CATEGORY 3:
H226: FLAMMABLE LIQUID AND VAPOUR.
CARCINOGENICITY, CATEGORY 2:
H351: SUSPECTED OF CAUSING CANCER.
REPRODUCTIVE TOXICITY, CATEGORY 2:
H361: SUSPECTED OF DAMAGING FERTILITY OR THE UNBORN CHILD.
STOT, SINGLE EXPOSURE, CATEGORY 3, RTI:
H335: MAY CAUSE RESPIRATORY IRRITATION.
STOT, REPEATED EXPOSURE, CATEGORY 2:
H373: MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE.
SKIN IRRITATION, CATEGORY 2:
H315: CAUSES SKIN IRRITATION.
EYE IRRITATION, CATEGORY 2:
H319: CAUSES SERIOUS EYE IRRITATION.
SKIN SENSITIZER, CATEGORY 1:
H317: MAY CAUSE AN ALLERGIC SKIN REACTION.
GHS LABEL PRECAUTIONARY STATEMENTS:
P210:
KEEP AWAY FROM HEAT, HOT SURFACES, SPARKS, OPEN FLAMES AND OTHER IGNITION
SOURCES. NO SMOKING.
P280:
WEAR PROTECTIVE GLOVES/PROTECTIVE CLOTHING/EYE PROTECTION/FACE PROTECTION.
P303+P361+P353:
IF ON SKIN (OR HAIR):
TAKE OFF IMMEDIATELY ALL CONTAMINATED CLOTHING. RINSE SKIN WITH
WATER/SHOWER.
P370+P378:
IN CASE OF FIRE:
USE ALCOHOL FILM FORMING FOAM, CARBON DIOXIDE, DRY CHEMICAL, DRY SAND TO
EXTINGUISH.
P403+P235: STORE IN A WELL-VENTILATED PLACE. KEEP COOL.
P501:
DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH LOCAL, REGIONAL AND
NATIONAL REGULATIONS.
P201: OBTAIN SPECIAL INSTRUCTIONS BEFORE USE.
P308+P313:
IF EXPOSED OR CONCERNED: GET MEDICAL ADVICE/ATTENTION.
P405: STORE LOCKED UP.
P271: USE ONLY OUTDOORS OR IN A WELL-VENTILATED AREA.
P304+P340:
IF INHALED: REMOVE PERSON TO FRESH AIR AND KEEP COMFORTABLE FOR BREATHING.
P312: CALL A POISON CENTER OR DOCTOR/PHYSICIAN IF YOU FEEL UNWELL.
P403+P233: STORE IN A WELL-VENTILATED PLACE. KEEP CONTAINER TIGHTLY CLOSED.
P260: DO NOT BREATHE DUST/FUME/GAS/MIST/VAPORS/SPRAY.
P264: WASH HANDS THOROUGHLY AFTER HANDLING.
P302+P352:
IF ON SKIN: WASH WITH PLENTY OF SOAP AND WATER.
P321: FOR SPECIFIC TREATMENT SEE LABEL
P332+P313:
IF SKIN IRRITATION OCCURS: GET MEDICAL ADVICE/ATTENTION.
P362+P364: TAKE OFF CONTAMINATED CLOTHING AND WASH IT BEFORE REUSE.
P305+P351+P338:
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES, IF
PRESENT AND EASY TO DO. CONTINUE RINSING.
P337+P313:
IF EYE IRRITATION PERSISTS: GET MEDICAL ADVICE/ATTENTION.
P272:
CONTAMINATED WORK CLOTHING SHOULD NOT BE ALLOWED OUT OF THE WORKPLACE.
P333+P313:
IF SKIN IRRITATION OR RASH OCCURS: GET MEDICAL ADVICE/ATTENTION.
GHS SDS PRECAUTIONARY STATEMENTS:
P240: GROUND/BOND CONTAINER AND RECEIVING EQUIPMENT.
P241: USE EXPLOSION-PROOF ELECTRICAL/VENTILATING/LIGHTING/EQUIPMENT.
P242: USE ONLY NON-SPARKING TOOLS.
P243: TAKE PRECAUTIONARY MEASURES AGAINST STATIC DISCHARGE.
P363: WASH CONTAMINATED CLOTHING BEFORE REUSE.
| 3. COMPOSITION / INFORMATION ON INGREDIENTS | |
HAZARDOUS SUBSTANCES:
CHEMICAL NAME CAS-NO. WT.% GHS SYMBOLS GHS STATEMENTS
EPICHLOROHYDRIN-BISPHENOL 25068-38-6 49 GHS07 H315-317-319-
A RESIN 335
HYDROUS MAGNESIUM 14807-96-6 24 NOT AVAILABLE NOT AVAILABLE
SILICATE
XYLENES (O-, M-, P- 1330-20-7 8.8 GHS02-GHS07 H226-315-319-
ISOMERS) 332
METHYL ISOBUTYL KETONE 108-10-1 6.3 GHS02-GHS06 H225-319-331-
335
PHENOL, METHYLSTYRENATED PROPRIETARY 4.0 GHS07 H315-317
ETHYLBENZENE 100-41-4 2.1 GHS02-GHS07- H225-304-332-
GHS08 351-373
CARBON BLACK 1333-86-4 0.9 NOT AVAILABLE NOT AVAILABLE
TOLUENE 108-88-3 0.1 GHS02-GHS07- H225-304-315-
GHS08 332-336-361-
373
| 4. FIRST-AID MEASURES | |
FIRST AID - EYE CONTACT:
IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES HOLDING
EYELIDS OPEN. GET MEDICAL ATTENTION. DO NOT ALLOW RUBBING OF EYES OR
KEEPING EYES CLOSED.
FIRST AID - SKIN CONTACT:
WASH SKIN WITH SOAP AND WATER. REMOVE CONTAMINATED CLOTHING. GET MEDICAL
ATTENTION IF IRRITATION DEVELOPS OR PERSISTS.
FIRST AID - INHALATION:
REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE ARTIFICIAL RESPIRATION. IF
BREATHING IS DIFFICULT, GIVE OXYGEN. GET IMMEDIATE MEDICAL ATTENTION. DO
NOT USE MOUTH-TO-MOUTH RESUSCITATION. IF YOU EXPERIENCE DIFFICULTY IN
BREATHING, LEAVE THE AREA TO OBTAIN FRESH AIR. IF CONTINUED DIFFICULTY IS
EXPERIENCED, GET MEDICAL ASSISTANCE IMMEDIATELY.
FIRST AID - INGESTION:
IF SWALLOWED, DO NOT INDUCE VOMITING. IF VICTIM IS CONSCIOUS AND ALERT,
GIVE 2 TO 4 CUPFULS OF WATER OR MILK. CALL A PHYSICIAN OR POISON CONTROL
CENTER IMMEDIATELY. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
TREAT SYMPTOMATICALLY AND SUPPORTIVELY. ASPIRATION HAZARD: DO NOT INDUCE
VOMITING OR GIVE ANYTHING BY MOUTH BECAUSE THIS MATERIAL CAN ENTER THE
LUNGS AND CAUSE SEVERE LUNG DAMAGE. GET IMMEDIATE MEDICAL ATTENTION. IF
SWALLOWED, GET MEDICAL ATTENTION.
| 5. FIRE-FIGHTING MEASURES | |
EXTINGUISHING MEDIA:
ALCOHOL FILM FORMING FOAM, CARBON DIOXIDE, DRY CHEMICAL, WATER FOG
UNUSUAL FIRE AND EXPLOSION HAZARDS:
COMBUSTIBLE LIQUID AND VAPOR. NO UNUSUAL FIRE OR EXPLOSION HAZARDS NOTED.
CLOSED CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT DUE TO BUILDUP
OF STEAM. KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE FROM HEAT, ELECTRICAL
EQUIPMENT, SPARKS AND OPEN FLAME.
SPECIAL FIREFIGHTING PROCEDURES:
WATER MAY BE USED TO COOL CLOSED CONTAINERS TO PREVENT PRESSURE BUILDUP AND
POSSIBLE AUTOIGNITION OR EXPLOSION. FULL PROTECTIVE EQUIPMENT INCLUDING
SELF-CONTAINED BREATHING APPARATUS SHOULD BE USED. EVACUATE AREA AND FIGHT
FIRE FROM A SAFE DISTANCE. USE WATER SPRAY TO KEEP FIRE-EXPOSED CONTAINERS
COOL. CONTAINERS MAY EXPLODE WHEN HEATED.
SPECIAL FIRE AND EXPLOSION HAZARD (COMBUSTIBLE DUST): NO INFORMATION
| 6. ACCIDENTAL RELEASE MEASURES | |
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED:
ISOLATE THE HAZARD AREA AND DENY ENTRY TO UNNECESSARY AND UNPROTECTED
PERSONNEL. REMOVE ALL SOURCES OF IGNITION, VENTILATE AREA AND REMOVE WITH
INERT ABSORBENT AND NON-SPARKING TOOLS. DISPOSE OF ACCORDING TO LOCAL,
STATE (PROVINCIAL) AND FEDERAL REGULATIONS. DO NOT INCINERATE CLOSED
CONTAINERS. VENTILATE AREA, ISOLATE SPILLED MATERIAL, AND REMOVE WITH
INERT ABSORBENT. DISPOSE OF CONTAMINATED ABSORBENT, CONTAINER, AND UNUSED
CONTENTS IN ACCORDANCE WITH LOCAL, STATE, AND FEDERAL REGULATIONS.
| 7. HANDLING AND STORAGE | |
HANDLING:
WASH THOROUGHLY AFTER HANDLING. USE ONLY IN A WELL-VENTILATED AREA. FOLLOW
ALL SDS AND LABEL PRECAUTIONS EVEN AFTER CONTAINER IS EMPTIED BECAUSE IT
MAY RETAIN PRODUCT RESIDUES. AVOID BREATHING FUMES, VAPORS, OR MIST. AVOID
PROLONGED OR REPEATED CONTACT WITH SKIN. WASH HANDS BEFORE EATING. REMOVE
CONTAMINATED CLOTHING AND LAUNDER BEFORE REUSE. USE ONLY WITH ADEQUATE
VENTILATION. AVOID CONTACT WITH EYES, SKIN AND CLOTHING.
STORAGE:
KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE FROM HEAT, ELECTRICAL EQUIPMENT,
SPARKS AND OPEN FLAME. DO NOT STORE ABOVE 120 DEG. F. STORE LARGE
QUANTITIES IN BUILDINGS DESIGNED AND PROTECTED FOR STORAGE OF NFPA CLASS II
COMBUSTIBLE LIQUIDS. PRODUCT SHOULD BE STORED IN TIGHTLY SEALED CONTAINERS
AND PROTECTED FROM HEAT, MOISTURE, AND FOREIGN MATERIALS. STORE IN A DRY,
WELL VENTILATED PLACE. KEEP CONTAINER TIGHTLY CLOSED WHEN NOT IN USE. KEEP
AWAY FROM HEAT, SPARKS, FLAME AND SOURCES OF IGNITION. AVOID EXCESS HEAT.
ADVICE ON SAFE HANDLING OF COMBUSTIBLE DUST: NO INFORMATION
| 8. EXPOSURE CONTROLS / PERSONAL PROTECTION | |
CHEMICAL NAME CAS-NO. WEIGHT % LESS THAN
EPICHLOROHYDRIN-BISPHENOL A RESIN 25068-38-6 50.0
HYDROUS MAGNESIUM SILICATE 14807-96-6 25.0
XYLENES (O-, M-, P- ISOMERS) 1330-20-7 10.0
METHYL ISOBUTYL KETONE 108-10-1 10.0
PHENOL, METHYLSTYRENATED PROPRIETARY 5.0
ETHYLBENZENE 100-41-4 5.0
CARBON BLACK 1333-86-4 1.0
TOLUENE 108-88-3 1.0
CHEMICAL NAME ACGIH TLV-TWA ACGIH TLV-STEL OSHA PEL-TWA OSHA PEL-
CEILING
EPICHLOROHYDRIN- N.E. N.E. N.E. N.E.
BISPHENOL A RESIN
HYDROUS MAGNESIUM 2 MG/M3 N.E. N.E. N.E.
SILICATE
XYLENES (O-, M-, 100 PPM 150 PPM 100 PPM N.E.
P- ISOMERS)
METHYL ISOBUTYL 20 PPM 75 PPM 100 PPM N.E.
KETONE
PHENOL, N.E. N.E. N.E. N.E.
METHYLSTYRENATED
ETHYLBENZENE 20 PPM N.E. 100 PPM N.E.
CARBON BLACK 3 MG/M3 N.E. 3.5 MG/M3 N.E.
TOLUENE 20 PPM N.E. 200 PPM 300 PPM
PERSONAL PROTECTION:
ENGINEERING CONTROLS:
USE PROCESS ENCLOSURES, LOCAL EXHAUST VENTILATION, OR OTHER ENGINEERING
CONTROLS TO CONTROL AIRBORNE LEVELS BELOW RECOMMENDED EXPOSURE LIMITS.
PREVENT BUILD-UP OF VAPORS BY OPENING ALL DOORS AND WINDOWS TO ACHIEVE
CROSS-VENTILATION.
RESPIRATORY PROTECTION:
A NIOSH/MSHA APPROVED AIR PURIFYING RESPIRATOR WITH AN ORGANIC VAPOR
CARTRIDGE OR CANISTER MAY BE PERMISSIBLE UNDER CERTAIN CIRCUMSTANCES
WHERE AIRBORNE CONCENTRATIONS ARE EXPECTED TO EXCEED EXPOSURE LIMITS.
PROTECTION PROVIDED BY AIR PURIFYING RESPIRATORS IS LIMITED. USE A
POSITIVE PRESSURE AIR SUPPLIED RESPIRATOR IF THERE IS ANY POTENTIAL FOR
AN UNCONTROLLED RELEASE, EXPOSURE LEVELS ARE NOT KNOWN, OR IN ANY OTHER
CIRCUMSTANCES WHERE AIR PURIFYING RESPIRATORS MAY NOT PROVIDE ADEQUATE
PROTECTION. A RESPIRATORY PROTECTION PROGRAM THAT MEETS OSHA 1910.134 AND
ANSI Z88.2 REQUIREMENTS MUST BE FOLLOWED WHENEVER WORKPLACE CONDITIONS
WARRANT A RESPIRATOR'S USE.
SKIN PROTECTION:
USE GLOVES TO PREVENT PROLONGED SKIN CONTACT. NITRILE OR NEOPRENE GLOVES
MAY AFFORD ADEQUATE SKIN PROTECTION.
EYE PROTECTION:
USE SAFETY EYEWEAR DESIGNED TO PROTECT AGAINST SPLASH OF LIQUIDS.
OTHER PROTECTIVE EQUIPMENT:
REFER TO SAFETY SUPERVISOR OR INDUSTRIAL HYGIENIST FOR FURTHER INFORMATION
REGARDING PERSONAL PROTECTIVE EQUIPMENT AND ITS APPLICATION. REFER TO
SAFETY SUPERVISOR OR INDUSTRIAL HYGIENIST FOR FURTHER GUIDANCE REGARDING
TYPES OF PERSONAL PROTECTIVE EQUIPMENT AND THEIR APPLICATIONS.
HYGIENIC PRACTICES:
WASH THOROUGHLY WITH SOAP AND WATER BEFORE EATING, DRINKING OR SMOKING.
REMOVE CONTAMINATED CLOTHING IMMEDIATELY AND LAUNDER BEFORE REUSE.
ENGINEERING MEASURES FOR COMBUSTIBLE DUST: NO INFORMATION
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE: LIQUID
PHYSICAL STATE: LIQUID
ODOR: SOLVENT LIKE
ODOR THRESHOLD: N.E.
RELATIVE DENSITY: 1.280
PH: N.A.
FREEZE POINT, DEG. C: N.D.
VISCOSITY: N.D.
SOLUBILITY IN WATER: NEGLIGIBLE
PARTITION COEFFICIENT, N-OCTANOL/WATER: N.D.
DECOMPOSITION TEMP., DEG. C: N.D.
BOILING RANGE, DEG. C: 117 - 537
EXPLOSIVE LIMITS, VOL%: 1.2 - 8.0
FLAMMABILITY: SUPPORTS COMBUSTION
FLASH POINT, DEG. C: 27
EVAPORATION RATE: SLOWER THAN ETHER
AUTO-IGNITION TEMP., DEG. C: N.D.
VAPOR DENSITY: HEAVIER THAN AIR
VAPOR PRESSURE: N.D.
(SEE "OTHER INFORMATION" SECTION FOR ABBREVIATION LEGEND)
| 10. STABILITY AND REACTIVITY | |
CONDITIONS TO AVOID:
AVOID TEMPERATURES ABOVE 120 DEG. F (49 DEG. C). AVOID ALL POSSIBLE SOURCES
OF IGNITION.
INCOMPATIBILITY:
PRODUCT SLOWLY CORRODES COPPER, ALUMINUM, ZINC, AND GALVANIZED SURFACES.
INCOMPATIBLE WITH STRONG OXIDIZING AGENTS, STRONG ACIDS AND STRONG ALKALIS.
HAZARDOUS DECOMPOSITION:
CONTAINS SOLVENTS WHICH MAY FORM CARBON MONOXIDE, CARBON DIOXIDE, AND
FORMALDEHYDE. WHEN HEATED TO DECOMPOSITION, IT EMITS ACRID SMOKE AND
IRRITATING FUMES. BY OPEN FLAME, CARBON MONOXIDE AND CARBON DIOXIDE.
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR UNDER NORMAL CONDITIONS.
STABILITY:
MAY FORM PEROXIDES OF UNKNOWN STABILITY. THIS PRODUCT IS STABLE UNDER
NORMAL STORAGE CONDITIONS.
| 11. TOXICOLOGICAL INFORMATION | |
EFFECTS OF OVEREXPOSURE - EYE CONTACT:
SUBSTANCE CAUSES SEVERE EYE IRRITATION. INJURY MAY BE PERMANENT. CAUSES
SERIOUS EYE IRRITATION
EFFECTS OF OVEREXPOSURE - SKIN CONTACT:
MAY BE ABSORBED THROUGH THE SKIN IN HARMFUL AMOUNTS. MAY CAUSE SKIN
SENSITIZATION, AN ALLERGIC REACTION, WHICH BECOMES EVIDENT UPON RE-EXPOSURE
TO THIS MATERIAL. CAUSES SKIN IRRITATION. ALLERGIC REACTIONS ARE POSSIBLE.
EFFECTS OF OVEREXPOSURE - INHALATION:
HIGH VAPOR CONCENTRATIONS ARE IRRITATING TO THE EYES, NOSE, THROAT AND
LUNGS. HARMFUL IF INHALED. HIGH GAS, VAPOR, MIST OR DUST CONCENTRATIONS
MAY BE HARMFUL IF INHALED. AVOID BREATHING FUMES, SPRAY, VAPORS, OR MIST.
PROLONGED OR EXCESSIVE INHALATION MAY CAUSE RESPIRATORY TRACT IRRITATION.
EFFECTS OF OVEREXPOSURE - INGESTION: HARMFUL IF SWALLOWED.
EFFECTS OF OVEREXPOSURE - CHRONIC HAZARDS:
OVEREXPOSURE TO XYLENE IN LABORATORY ANIMALS HAS BEEN ASSOCIATED WITH LIVER
ABNORMALITIES, KIDNEY, LUNG, SPLEEN, EYE AND BLOOD DAMAGE AS WELL AS
REPRODUCTIVE DISORDERS. EFFECTS IN HUMANS, DUE TO CHRONIC OVEREXPOSURE,
HAVE INCLUDED LIVER, CARDIAC ABNORMALITIES AND NERVOUS SYSTEM DAMAGE. IARC
LISTS ETHYLBENZENE AS A POSSIBLE HUMAN CARCINOGEN (GROUP 2B). CONTAINS
CARBON BLACK. CHRONIC INFLAMMATION, LUNG FIBROSIS, AND LUNG TUMORS HAVE
BEEN OBSERVED IN SOME RATS EXPERIMENTALLY EXPOSED FOR LONG PERIODS OF TIME
TO EXCESSIVE CONCENTRATIONS OF CARBON BLACK AND SEVERAL INSOLUBLE FINE DUST
PARTICLES. TUMORS HAVE NOT BEEN OBSERVED IN OTHER ANIMAL SPECIES (I.E.,
MOUSE AND HAMSTER) UNDER SIMILAR CIRCUMSTANCES AND STUDY CONDITIONS.
EPIDEMIOLOGICAL STUDIES OF NORTH AMERICAN WORKERS SHOW NO EVIDENCE OF
CLINICALLY SIGNIFICANT ADVERSE HEALTH EFFECTS DUE TO OCCUPATIONAL EXPOSURE
TO CARBON BLACK.
CARBON BLACK IS LISTED AS A GROUP 2B-"POSSIBLY CARCINOGENIC TO HUMANS" BY
IARC AND IS PROPOSED TO BE LISTED AS A4- "NOT CLASSIFIED AS A HUMAN
CARCINOGEN" BY THE AMERICAN CONFERENCE OF GOVERNMENTAL INDUSTRIAL
HYGIENISTS. SIGNIFICANT EXPOSURE IS NOT ANTICIPATED DURING BRUSH
APPLICATION OR DRYING. RISK OF OVEREXPOSURE DEPENDS ON DURATION AND LEVEL
OF EXPOSURE TO DUST FROM REPEATED SANDING OF SURFACES OR SPRAY MIST AND
THE ACTUAL CONCENTRATION OF CARBON BLACK IN THE FORMULA. REPORTS HAVE
ASSOCIATED REPEATED AND PROLONGED OCCUPATIONAL OVEREXPOSURE TO SOLVENTS
WITH PERMANENT BRAIN AND NERVOUS SYSTEM DAMAGE. HIGH CONCENTRATIONS MAY
LEAD TO CENTRAL NERVOUS SYSTEM EFFECTS (DROWSINESS, DIZZINESS, NAUSEA,
HEADACHES, PARALYSIS, AND BLURRED VISION) AND/OR DAMAGE.
PRIMARY ROUTE(S) OF ENTRY:
EYE CONTACT, INGESTION, INHALATION, SKIN ABSORPTION, SKIN CONTACT
ACUTE TOXICITY VALUES:
THE ACUTE EFFECTS OF THIS PRODUCT HAVE NOT BEEN TESTED. DATA ON INDIVIDUAL
COMPONENTS ARE TABULATED BELOW:
CAS-NO. CHEMICAL NAME ORAL LD50 DERMAL LD50 VAPOR LC50
25068-38-6 EPICHLOROHYDRIN- 11400 MG/KG >5000 25 G/L
BISPHENOL A RESIN RAT
14807-96-6 HYDROUS MAGNESIUM 6000 N.E. 30
SILICATE
1330-20-7 XYLENES (O-, M-, 3500 MG/KG >4350 MG/KG 29.08 MG/L RAT
P- ISOMERS) RAT RABBIT
108-10-1 METHYL ISOBUTYL 2080 MG/KG 3000 MG/KG 8.2 MG/L RAT
KETONE RAT RABBIT
100-41-4 ETHYLBENZENE 3500 MG/KG 15400 MG/KG 17.4 MG/L RAT
RAT RABBIT
1333-86-4 CARBON BLACK >15400 MG/KG N.E. N.E.
RAT
108-88-3 TOLUENE 2600 MG/KG 12000 MG/KG 12.5 MG/L RAT
RAT RABBIT
N.E. - NOT ESTABLISHED
| 12. ECOLOGICAL INFORMATION | |
ECOLOGICAL INFORMATION:
PRODUCT IS A MIXTURE OF LISTED COMPONENTS. PRODUCT IS A MIXTURE OF LISTED
COMPONENTS.
| 13. DISPOSAL INFORMATION | |
DISPOSAL INFORMATION:
DISPOSE OF MATERIAL IN ACCORDANCE TO LOCAL, STATE, AND FEDERAL REGULATIONS
AND ORDINANCES. DO NOT ALLOW TO ENTER WATERWAYS, WASTEWATER, SOIL, STORM
DRAINS OR SEWER SYSTEMS. DO NOT INCINERATE CLOSED CONTAINERS.
| 14. TRANSPORT INFORMATION | |
DOMESTIC INTERNATIONAL AIR (IATA) TDG (CANADA)
(USDOT) (IMDG)
UN NUMBER N.A. 1263 1263 N.A.
PROPER SHIPPING PAINT PRODUCTS PAINT PAINT PAINT PRODUCTS
NAME IN LIMITED IN LIMITED
QUANTITIES QUANTITIES
HAZARD CLASS N.A. 3 3 N.A.
PACKING GROUP N.A. III III N.A.
LIMITED YES YES YES YES
QUANTITY
| 15. REGULATORY INFORMATION | |
U.S. FEDERAL REGULATIONS:
CERCLA - SARA HAZARD CATEGORY:
THIS PRODUCT HAS BEEN REVIEWED ACCORDING TO THE EPA 'HAZARD CATEGORIES'
PROMULGATED UNDER SECTIONS 311 AND 312 OF THE SUPERFUND AMENDMENT AND
REAUTHORIZATION ACT OF 1986 (SARA TITLE III) AND IS CONSIDERED, UNDER
APPLICABLE DEFINITIONS, TO MEET THE FOLLOWING CATEGORIES:
FLAMMABLE (GASES, AEROSOLS, LIQUIDS, OR SOLIDS), CARCINOGENICITY,
REPRODUCTIVE TOXICITY, SKIN CORROSION OR IRRITATION, RESPIRATORY OR SKIN
SENSITIZATION, SERIOUS EYE DAMAGE OR EYE IRRITATION, SPECIFIC TARGET ORGAN
TOXICITY (SINGLE OR REPEATED EXPOSURE)
SARA SECTION 313:
THIS PRODUCT CONTAINS THE FOLLOWING SUBSTANCES SUBJECT TO THE REPORTING
REQUIREMENTS OF SECTION 313 OF TITLE III OF THE SUPERFUND AMENDMENT AND
REAUTHORIZATION ACT OF 1986 AND 40 CFR PART 372:
CHEMICAL NAME CAS-NO.
XYLENES (O-, M-, P- ISOMERS) 1330-20-7
METHYL ISOBUTYL KETONE 108-10-1
ETHYLBENZENE 100-41-4
TOLUENE 108-88-3
TOXIC SUBSTANCES CONTROL ACT:
THIS PRODUCT CONTAINS THE FOLLOWING CHEMICAL SUBSTANCES SUBJECT TO THE
REPORTING REQUIREMENTS OF TSCA 12(B) IF EXPORTED FROM THE UNITED STATES:
NO TSCA 12(B) COMPONENTS EXIST IN THIS PRODUCT.
| 16. OTHER INFORMATION | |
HMIS RATINGS:
HEALTH 2*
FLAMMABILITY 3
PHYSICAL HAZARD 0
PERSONAL PROTECTION X
NFPA RATINGS:
HEALTH 2
FLAMMABILITY 3
INSTABILITY 1
VOLATILE ORGANIC COMPOUNDS: 225 G/L
SDS REVISION DATE: 8/7/2018
REASON FOR REVISION:
SUBSTANCE AND/OR PRODUCT PROPERTIES CHANGED IN SECTION(S):
15 - REGULATORY INFORMATION
16 - OTHER INFORMATION
REVISION STATEMENT(S) CHANGED
LEGEND:
N.A. - NOT APPLICABLE
N.E. - NOT ESTABLISHED
N.D. - NOT DETERMINED
THE MANUFACTURER BELIEVES, TO THE BEST OF ITS KNOWLEDGE, INFORMATION AND
BELIEF, THE INFORMATION CONTAINED HEREIN TO BE ACCURATE AND RELIABLE AS OF
THE DATE OF THIS SAFETY DATA SHEET. HOWEVER, BECAUSE THE CONDITIONS OF
HANDLING, USE, AND STORAGE OF THESE MATERIALS ARE BEYOND OUR CONTROL, WE
ASSUME NO RESPONSIBILITY OR LIABILITY FOR PERSONAL INJURY OR PROPERTY
DAMAGE INCURRED BY THE USE OF THESE MATERIALS. THE MANUFACTURER MAKES NO
WARRANTY, EXPRESSED OR IMPLIED, REGARDING THE ACCURACY OR RELIABILITY OF
THE DATA OR RESULTS OBTAINED FROM THEIR USE. ALL MATERIALS MAY PRESENT
UNKNOWN HAZARDS AND SHOULD BE USED WITH CAUTION. THE INFORMATION AND
RECOMMENDATIONS IN THIS MATERIAL SAFETY DATA SHEET ARE OFFERED FOR THE
USERS' CONSIDERATION AND EXAMINATION. IT IS THE RESPONSIBILITY OF THE USER
TO DETERMINE THE FINAL SUITABILITY OF THIS INFORMATION AND TO COMPLY WITH
ALL APPLICABLE INTERNATIONAL, FEDERAL, STATE, AND LOCAL LAWS AND
REGULATIONS.