| Common Name: | EPOXY PT 4PK 5300 TOPCOAT ACTIVATOR, 5301604 |
| Manufacturer: | RUST-OLEUM |
| SDS Revision Date: | 2/25/2016 |
| SDS Format: | GHS-US |
| Item Number(s): | 6A403 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
DATE PRINTED: 2/25/2016
SAFETY DATA SHEET
RUST-OLEUM CORPORATION
TRUSTED QUALITY SINCE 1921
WWW.RUSTOLEUM.COM
| 1. IDENTIFICATION |  |
PRODUCT NAME: EPOXY PT 4PK 5300 TOPCOAT ACTIVATOR
PRODUCT IDENTIFIER: 5301604
PRODUCT USE/CLASS: TOPCOAT ACTIVATOR/WATERBASED EPOXY
REVISION DATE: 2/25/2016
SUPERCEDES DATE: 10/26/2015
SUPPLIER:
RUST-OLEUM CORPORATION
11 HAWTHORN PARKWAY
VERNON HILLS, IL 60061
USA
MANUFACTURER:
RUST-OLEUM CORPORATION
11 HAWTHORN PARKWAY
VERNON HILLS, IL 60061
USA
PREPARER: REGULATORY DEPARTMENT
EMERGENCY TELEPHONE:
24 HOUR HOTLINE: 847-367-7700
| 2. HAZARD IDENTIFICATION | |
CLASSIFICATION:
SYMBOL(S) OF PRODUCT:
CORROSION
EXCLAMATION MARK
HEALTH HAZARD
SIGNAL WORD: DANGER
GHS HAZARD STATEMENTS:
ACUTE TOXICITY, ORAL, CATEGORY 4:
H302: HARMFUL IF SWALLOWED.
SKIN IRRITATION, CATEGORY 2:
H315: CAUSES SKIN IRRITATION.
SKIN SENSITIZER, CATEGORY 1:
H317: MAY CAUSE AN ALLERGIC SKIN REACTION.
SERIOUS EYE DAMAGE, CATEGORY 1:
H318: CAUSES SERIOUS EYE DAMAGE.
ACUTE TOXICITY, INHALATION, CATEGORY 4:
H332: HARMFUL IF INHALED.
REPRODUCTIVE TOXICITY, CATEGORY 1A:
H360: MAY DAMAGE FERTILITY OR THE UNBORN CHILD.
STOT, SINGLE EXPOSURE, CATEGORY 1:
H370: CAUSES DAMAGE TO ORGANS.
STOT, REPEATED EXPOSURE, CATEGORY 1:
H372: CAUSES DAMAGE TO ORGANS.
GHS LABEL PRECAUTIONARY STATEMENTS:
P201: OBTAIN SPECIAL INSTRUCTIONS BEFORE USE.
P260: DO NOT BREATHE DUST, FUMES, GASES, MISTS, VAPORS, OR SPRAY.
P280:
WEAR PROTECTIVE GLOVES/PROTECTIVE CLOTHING/EYE PROTECTION/FACE PROTECTION.
P302+P352:
IF ON SKIN: WASH WITH PLENTY OF SOAP AND WATER.
P305+P351+P338:
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES, IF
PRESENT AND EASY TO DO. CONTINUE RINSING.
P307+P311:
IF EXPOSED: CALL A POISON CENTER OR DOCTOR/PHYSICIAN.
P308+P313:
IF EXPOSED OR CONCERNED: GET MEDICAL ADVICE/ATTENTION.
P310: IMMEDIATELY CALL A POISON CENTER OR DOCTOR/PHYSICIAN.
P333+P313:
IF SKIN IRRITATION OR RASH OCCURS: GET MEDICAL ADVICE/ATTENTION.
P362: TAKE OFF CONTAMINATED CLOTHING.
GHS SDS PRECAUTIONARY STATEMENTS:
P270: DO NOT EAT, DRINK OR SMOKE WHEN USING THIS PRODUCT.
P363: WASH CONTAMINATED CLOTHING BEFORE REUSE.
| 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
HAZARDOUS SUBSTANCES:
CHEMICAL NAME CAS-NO. WT.% GHS SYMBOLS GHS STATEMENTS
RANGE
POLYETHYLENE PROPRIETARY 10-25 GHS07-GHS08 H302-315-317-
POLYAMINE ADDUCT 370-372
ETHYLENE GLYCOL 2807-30-9 10-25 GHS06 H311-319-331
MONOPROPYL ETHER
AMINE RESIN PROPRIETARY 10-25 GHS05-GHS07- H315-317-318-360
GHS08
GLACIAL ACETIC ACID 64-19-7 2.5-10 GHS02-GHS05- H226-312-314-332
GHS07
METHANOL 67-56-1 0.1-1.0 GHS02-GHS06- H225-311-331-370
GHS08
| 4. FIRST-AID MEASURES | |
FIRST AID - EYE CONTACT:
IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES HOLDING
EYELIDS OPEN. GET MEDICAL ATTENTION. DO NOT ALLOW RUBBING OF EYES OR
KEEPING EYES CLOSED.
FIRST AID - SKIN CONTACT:
WASH SKIN WITH SOAP AND WATER. REMOVE CONTAMINATED CLOTHING. GET MEDICAL
ATTENTION IF IRRITATION DEVELOPS OR PERSISTS.
FIRST AID - INHALATION:
REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE ARTIFICIAL RESPIRATION. IF
BREATHING IS DIFFICULT, GIVE OXYGEN. GET IMMEDIATE MEDICAL ATTENTION. DO
NOT USE MOUTH-TO-MOUTH RESUSCITATION. IF YOU EXPERIENCE DIFFICULTY IN
BREATHING, LEAVE THE AREA TO OBTAIN FRESH AIR. IF CONTINUED DIFFICULTY IS
EXPERIENCED, GET MEDICAL ASSISTANCE IMMEDIATELY.
FIRST AID - INGESTION:
IF SWALLOWED, RINSE MOUTH WITH WATER. IF FEELING UNWELL, GET MEDICAL
ATTENTION. SWALLOWING LESS THAN AN OUNCE WILL NOT CAUSE SIGNIFICANT HARM.
FOR LARGER AMOUNTS, DO NOT INDUCE VOMITING, BUT GIVE ONE OR TWO GLASSES OF
WATER TO DRINK AND GET MEDICAL ATTENTION. IF SWALLOWED, INDUCE VOMITING
IMMEDIATELY AS DIRECTED BY MEDICAL PERSONNEL. NEVER GIVE ANYTHING BY MOUTH
TO AN UNCONSCIOUS PERSON. GET MEDICAL ATTENTION IMMEDIATELY.
| 5. FIRE-FIGHTING MEASURES | |
EXTINGUISHING MEDIA:
ALCOHOL FILM FORMING FOAM, CARBON DIOXIDE, DRY CHEMICAL, WATER FOG
UNUSUAL FIRE AND EXPLOSION HAZARDS:
KEEP CONTAINERS TIGHTLY CLOSED. FLASH POINT IS TESTED TO BE GREATER THAN
200 DEGREES F. NO UNUSUAL FIRE OR EXPLOSION HAZARDS NOTED.
SPECIAL FIREFIGHTING PROCEDURES:
WATER MAY BE USED TO COOL CLOSED CONTAINERS TO PREVENT BUILDUP OF STEAM. IF
WATER IS USED, FOG NOZZLES ARE PREFERRED.
| 6. ACCIDENTAL RELEASE MEASURES | |
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED:
IF SPILLED, CONTAIN SPILLED MATERIAL AND REMOVE WITH INERT ABSORBENT.
DISPOSE OF CONTAMINATED ABSORBENT, CONTAINER, AND UNUSED CONTENTS IN
ACCORDANCE WITH LOCAL, STATE, AND FEDERAL REGULATIONS. DO NOT INCINERATE
CLOSED CONTAINERS
| 7. HANDLING AND STORAGE | |
HANDLING:
WASH THOROUGHLY AFTER HANDLING. WASH HANDS BEFORE EATING. REMOVE
CONTAMINATED CLOTHING AND LAUNDER BEFORE REUSE. USE ONLY WITH ADEQUATE
VENTILATION. FOLLOW ALL MSDS/LABEL PRECAUTIONS EVEN AFTER CONTAINER IS
EMPTIED BECAUSE IT MAY RETAIN PRODUCT RESIDUES. AVOID BREATHING FUMES,
VAPORS, OR MIST. AVOID CONTACT WITH EYES, SKIN AND CLOTHING.
STORAGE:
STORE IN A DRY, WELL VENTILATED PLACE. KEEP CONTAINER TIGHTLY CLOSED WHEN
NOT IN USE.
| 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
CHEMICAL NAME CAS-NO. WEIGHT % LESS THAN
POLYETHYLENE POLYAMINE ADDUCT PROPRIETARY 25.0
ETHYLENE GLYCOL MONOPROPYL 2807-30-9 20.0
ETHER
AMINE RESIN PROPRIETARY 15.0
GLACIAL ACETIC ACID 64-19-7 5.0
METHANOL 67-56-1 1.0
CHEMICAL NAME ACGIH ACGIH OSHA OSHA
TLV-TWA TLV-STEL PEL-TWA PEL-CEILING
POLYETHYLENE POLYAMINE N.E. N.E. N.E. N.E.
ADDUCT
ETHYLENE GLYCOL N.E. N.E. N.E. N.E.
MONOPROPYL ETHER
AMINE RESIN N.E. N.E. N.E. N.E.
GLACIAL ACETIC ACID 10 PPM 15 PPM 10 PPM N.E.
METHANOL 200 PPM 250 PPM 200 PPM N.E.
PERSONAL PROTECTION:
ENGINEERING CONTROLS:
USE PROCESS ENCLOSURES, LOCAL EXHAUST VENTILATION, OR OTHER ENGINEERING
CONTROLS TO CONTROL AIRBORNE LEVELS BELOW RECOMMENDED EXPOSURE LIMITS.
PREVENT BUILD-UP OF VAPORS BY OPENING ALL DOORS AND WINDOWS TO ACHIEVE
CROSS-VENTILATION.
RESPIRATORY PROTECTION:
A RESPIRATORY PROTECTION PROGRAM THAT MEETS OSHA 1910.134 AND ANSI Z88.2
REQUIREMENTS MUST BE FOLLOWED WHENEVER WORKPLACE CONDITIONS WARRANT A
RESPIRATOR'S USE.
SKIN PROTECTION:
USE GLOVES TO PREVENT PROLONGED SKIN CONTACT. NITRILE OR NEOPRENE GLOVES
MAY AFFORD ADEQUATE SKIN PROTECTION.
EYE PROTECTION:
USE SAFETY EYEWEAR DESIGNED TO PROTECT AGAINST SPLASH OF LIQUIDS.
OTHER PROTECTIVE EQUIPMENT:
REFER TO SAFETY SUPERVISOR OR INDUSTRIAL HYGIENIST FOR FURTHER GUIDANCE
REGARDING TYPES OF PERSONAL PROTECTIVE EQUIPMENT AND THEIR APPLICATIONS.
HYGIENIC PRACTICES:
WASH THOROUGHLY WITH SOAP AND WATER BEFORE EATING, DRINKING OR SMOKING.
REMOVE CONTAMINATED CLOTHING IMMEDIATELY AND LAUNDER BEFORE REUSE.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE: LIQUID
PHYSICAL STATE: LIQUID
ODOR: SOLVENT LIKE
ODOR THRESHOLD: N.E.
RELATIVE DENSITY: 1.042
PH: N.D.
FREEZE POINT, DEG. C: N.D.
VISCOSITY: N.D.
SOLUBILITY IN WATER: SOLUABLE
PARTITION COEFFICIENT, N-OCTANOL/WATER: N.D.
DECOMPOSITION TEMP., DEG. C: N.D.
BOILING RANGE, DEG. C: 100 - 177
EXPLOSIVE LIMITS, VOL%: 1.6 - 19.9
FLAMMABILITY: DOES NOT SUPPORT COMBUSTION
FLASH POINT, DEG. C: 94
EVAPORATION RATE: SLOWER THAN ETHER
AUTO-IGNITION TEMP., DEG. C: N.D.
VAPOR DENSITY: HEAVIER THAN AIR
VAPOR PRESSURE: N.D.
(SEE "OTHER INFORMATION" SECTION FOR ABBREVIATION LEGEND)
| 10. STABILITY AND REACTIVITY | |
CONDITIONS TO AVOID: AVOID CONTACT WITH STRONG ACID AND STRONG BASES.
INCOMPATIBILITY:
INCOMPATIBLE WITH STRONG OXIDIZING AGENTS, STRONG ACIDS AND STRONG
ALKALIES.
HAZARDOUS DECOMPOSITION:
WHEN HEATED TO DECOMPOSITION, IT EMITS ACRID SMOKE AND IRRITATING FUMES.
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR UNDER NORMAL CONDITIONS.
STABILITY: THIS PRODUCT IS STABLE UNDER NORMAL STORAGE CONDITIONS.
| 11. TOXICOLOGICAL INFORMATION | |
EFFECTS OF OVEREXPOSURE - EYE CONTACT:
IRRITATING, AND MAY INJURE EYE TISSUE IF NOT REMOVED PROMPTLY.
EFFECTS OF OVEREXPOSURE - SKIN CONTACT:
LOW HAZARD FOR USUAL INDUSTRIAL HANDLING OR COMMERCIAL HANDLING BY TRAINED
PERSONNEL.
EFFECTS OF OVEREXPOSURE - INHALATION:
HIGH GAS, VAPOR, MIST OR DUST CONCENTRATIONS MAY BE HARMFUL IF INHALED.
AVOID BREATHING FUMES, SPRAY, VAPORS, OR MIST.
EFFECTS OF OVEREXPOSURE - INGESTION:
SUBSTANCE MAY BE HARMFUL IF SWALLOWED. POISON, MAY BE FATAL OR CAUSE
BLINDNESS IF SWALLOWED.
EFFECTS OF OVEREXPOSURE - CHRONIC HAZARDS: NO INFORMATION
PRIMARY ROUTE(S) OF ENTRY:
EYE CONTACT, INGESTION, INHALATION, SKIN ABSORPTION, SKIN CONTACT
ACUTE TOXICITY VALUES:
THE ACUTE EFFECTS OF THIS PRODUCT HAVE NOT BEEN TESTED. DATA ON INDIVIDUAL
COMPONENTS ARE TABULATED BELOW:
CAS-NO. CHEMICAL NAME ORAL LD50 DERMAL LD50 VAPOR LC50
2807-30-9 ETHYLENE GLYCOL 3089 MG/KG 870 MG/KG N.I.
MONOPROPYL ETHER RAT RABBIT
PROPRIETARY AMINE RESIN 5500 N.I. N.I.
64-19-7 GLACIAL ACETIC 3310 MG/KG 1060 MG/KG 11.4 MG/L RAT
ACID RAT RABBIT
67-56-1 METHANOL 6200 MG/KG N.I. N.I.
RAT
N.I. - NO INFORMATION
| 12. ECOLOGICAL INFORMATION | |
ECOLOGICAL INFORMATION: PRODUCT IS A MIXTURE OF LISTED COMPONENTS.
| 13. DISPOSAL INFORMATION | |
DISPOSAL INFORMATION:
DISPOSE OF MATERIAL IN ACCORDANCE TO LOCAL, STATE, AND FEDERAL REGULATIONS
AND ORDINANCES. DO NOT ALLOW TO ENTER WATERWAYS, WASTEWATER, SOIL, STORM
DRAINS OR SEWER SYSTEMS.
| 14. TRANSPORT INFORMATION | |
DOMESTIC INTERNATIONAL AIR (IATA) TDG (CANADA)
(USDOT) (IMDG)
UN NUMBER N.A. N.A. N.A. N.A.
PROPER SHIPPING NOT REGULATED NOT REGULATED NOT REGULATED NOT REGULATED
NAME
HAZARD CLASS N.A. N.A. N.A. N.A.
PACKING GROUP N.A. N.A. N.A. N.A.
LIMITED NO NO NO NO
QUANTITY
| 15. REGULATORY INFORMATION | |
U.S. FEDERAL REGULATIONS:
CERCLA - SARA HAZARD CATEGORY:
THIS PRODUCT HAS BEEN REVIEWED ACCORDING TO THE EPA 'HAZARD CATEGORIES'
PROMULGATED UNDER SECTIONS 311 AND 312 OF THE SUPERFUND AMENDMENT AND
REAUTHORIZATION ACT OF 1986 (SARA TITLE III) AND IS CONSIDERED, UNDER
APPLICABLE DEFINITIONS, TO MEET THE FOLLOWING CATEGORIES:
ACUTE HEALTH HAZARD, CHRONIC HEALTH HAZARD
SARA SECTION 313:
THIS PRODUCT CONTAINS THE FOLLOWING SUBSTANCES SUBJECT TO THE REPORTING
REQUIREMENTS OF SECTION 313 OF TITLE III OF THE SUPERFUND AMENDMENT AND
REAUTHORIZATION ACT OF 1986 AND 40 CFR PART 372:
CHEMICAL NAME CAS-NO.
ETHYLENE GLYCOL MONOPROPYL ETHER 2807-30-9
METHANOL 67-56-1
TOXIC SUBSTANCES CONTROL ACT:
THIS PRODUCT CONTAINS THE FOLLOWING CHEMICAL SUBSTANCES SUBJECT TO THE
REPORTING REQUIREMENTS OF TSCA 12(B) IF EXPORTED FROM THE UNITED STATES:
NO TSCA 12(B) COMPONENTS EXIST IN THIS PRODUCT.
| 16. OTHER INFORMATION | |
HMIS RATINGS:
HEALTH 3*
FLAMMABILITY 2
PHYSICAL HAZARD 0
PERSONAL PROTECTION X
NFPA RATINGS:
HEALTH 3
FLAMMABILITY 2
INSTABILITY 0
VOLATILE ORGANIC COMPOUNDS, G/L: 357
SDS REVISION DATE: 2/25/2016
REASON FOR REVISION:
PRODUCT COMPOSITION CHANGED
SUBSTANCE REGULATORY CAS NUMBER CHANGED
SUBSTANCE AND/OR PRODUCT PROPERTIES CHANGED IN SECTION(S):
16 - OTHER INFORMATION
STATEMENT(S) CHANGED
LEGEND:
N.A. - NOT APPLICABLE
N.E. - NOT ESTABLISHED
N.D. - NOT DETERMINED
RUST-OLEUM CORPORATION BELIEVES, TO THE BEST OF ITS KNOWLEDGE, INFORMATION
AND BELIEF, THE INFORMATION CONTAINED HEREIN TO BE ACCURATE AND RELIABLE AS
OF THE DATE OF THIS SAFETY DATA SHEET. HOWEVER, BECAUSE THE CONDITIONS OF
HANDLING, USE, AND STORAGE OF THESE MATERIALS ARE BEYOND OUR CONTROL, WE
ASSUME NO RESPONSIBILITY OR LIABILITY FOR PERSONAL INJURY OR PROPERTY
DAMAGE INCURRED BY THE USE OF THESE MATERIALS. RUST-OLEUM CORPORATION MAKES
NO WARRANTY, EXPRESSED OR IMPLIED, REGARDING THE ACCURACY OR RELIABILITY OF
THE DATA OR RESULTS OBTAINED FROM THEIR USE. ALL MATERIALS MAY PRESENT
UNKNOWN HAZARDS AND SHOULD BE USED WITH CAUTION. THE INFORMATION AND
RECOMMENDATIONS IN THIS MATERIAL SAFETY DATA SHEET ARE OFFERED FOR THE
USERS' CONSIDERATION AND EXAMINATION. IT IS THE RESPONSIBILITY OF THE USER
TO DETERMINE THE FINAL SUITABILITY OF THIS INFORMATION AND TO COMPLY WITH
ALL APPLICABLE INTERNATIONAL, FEDERAL, STATE, AND LOCAL LAWS AND
REGULATIONS.