| Common Name: | EL 703 ELECTRIC MOTOR DEGREASER AEROSOL |
| Manufacturer: | SPRAYON PRODUCTS |
| SDS Revision Date: | 5/29/2015 |
| SDS Format: | GHS-US |
| Item Number(s): | 6KDR9 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
SAFETY DATA SHEET
S00703
| SECTION 1. IDENTIFICATION |  |
PRODUCT NAME: EL(TM)703 ELECTRIC MOTOR DEGREASER AEROSOL
PRODUCT CODE: S00703
OTHER MEANS OF IDENTIFICATION: NOT AVAILABLE.
PRODUCT TYPE: AEROSOL.
RELEVANT IDENTIFIED USES OF THE SUBSTANCE OR MIXTURE AND USES ADVISED
AGAINST: NOT APPLICABLE.
MANUFACTURER:
SPRAYON PRODUCTS
CLEVELAND, OH 44115
EMERGENCY TELEPHONE NUMBER OF THE COMPANY: (216) 566-2917
PRODUCT INFORMATION TELEPHONE NUMBER: (800)247-3266
REGULATORY INFORMATION TELEPHONE NUMBER: (216)566-2902
TRANSPORTATION EMERGENCY TELEPHONE NUMBER: (800)424-9300
| SECTION 2. HAZARDS IDENTIFICATION | |
OSHA/HCS STATUS:
THIS MATERIAL IS CONSIDERED HAZARDOUS BY THE OSHA HAZARD COMMUNICATION
STANDARD (29 CFR 1910.1200).
CLASSIFICATION OF THE SUBSTANCE OR MIXTURE:
GASES UNDER PRESSURE: COMPRESSED GAS
SKIN CORROSION/IRRITATION: CATEGORY 2
SERIOUS EYE DAMAGE/ EYE IRRITATION: CATEGORY 2B
CARCINOGENICITY: CATEGORY 1B
SPECIFIC TARGET ORGAN TOXICITY (SINGLE EXPOSURE) (RESPIRATORY TRACT
IRRITATION AND NARCOTIC EFFECTS): CATEGORY 3
SPECIFIC TARGET ORGAN TOXICITY (REPEATED EXPOSURE): CATEGORY 2
PERCENTAGE OF THE MIXTURE CONSISTING OF INGREDIENT(S) OF UNKNOWN TOXICITY:
2%
GHS LABEL ELEMENTS:
HAZARD PICTOGRAMS:
GAS CYLINDER
HEALTH HAZARD
EXCLAMATION MARK
SIGNAL WORD: DANGER
HAZARD STATEMENTS:
CONTAINS GAS UNDER PRESSURE; MAY EXPLODE IF HEATED.
CAUSES SKIN AND EYE IRRITATION.
MAY CAUSE CANCER.
MAY CAUSE RESPIRATORY IRRITATION.
MAY CAUSE DROWSINESS AND DIZZINESS.
MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE.
PRECAUTIONARY STATEMENTS:
PREVENTION:
OBTAIN SPECIAL INSTRUCTIONS BEFORE USE. DO NOT HANDLE UNTIL ALL SAFETY
PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD. USE PERSONAL PROTECTIVE
EQUIPMENT AS REQUIRED. WEAR PROTECTIVE GLOVES. WEAR EYE OR FACE PROTECTION.
USE ONLY OUTDOORS OR IN A WELL-VENTILATED AREA. DO NOT BREATHE DUST OR
MIST. WASH HANDS THOROUGHLY AFTER HANDLING.
RESPONSE: GET MEDICAL ATTENTION IF YOU FEEL UNWELL.
IF EXPOSED OR CONCERNED: GET MEDICAL ATTENTION.
IF INHALED:
REMOVE VICTIM TO FRESH AIR AND KEEP AT REST IN A POSITION COMFORTABLE FOR
BREATHING. CALL A POISON CENTER OR PHYSICIAN IF YOU FEEL UNWELL.
IF ON SKIN:
WASH WITH PLENTY OF SOAP AND WATER. TAKE OFF CONTAMINATED CLOTHING. WASH
CONTAMINATED CLOTHING BEFORE REUSE.
IF SKIN IRRITATION OCCURS: GET MEDICAL ATTENTION.
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES, IF
PRESENT AND EASY TO DO. CONTINUE RINSING.
IF EYE IRRITATION PERSISTS: GET MEDICAL ATTENTION.
STORAGE:
STORE LOCKED UP. PROTECT FROM SUNLIGHT. STORE IN A WELL-VENTILATED PLACE.
DISPOSAL:
DISPOSE OF CONTENTS AND CONTAINER IN ACCORDANCE WITH ALL LOCAL, REGIONAL,
NATIONAL AND INTERNATIONAL REGULATIONS.
SUPPLEMENTAL LABEL ELEMENTS:
DELAYED EFFECTS FROM LONG TERM OVEREXPOSURE. CONTAINS SOLVENTS WHICH CAN
CAUSE PERMANENT BRAIN AND NERVOUS SYSTEM DAMAGE. INTENTIONAL MISUSE BY
DELIBERATELY CONCENTRATING AND INHALING THE CONTENTS CAN BE HARMFUL OR
FATAL.
WARNING:
THIS PRODUCT CONTAINS A CHEMICAL KNOWN TO THE STATE OF CALIFORNIA TO CAUSE
CANCER. FOR INDUSTRIAL USE ONLY.
PLEASE REFER TO THE SDS FOR ADDITIONAL INFORMATION. KEEP UPRIGHT IN A COOL,
DRY PLACE. DO NOT DISCARD EMPTY CAN IN TRASH COMPACTOR.
HAZARDS NOT OTHERWISE CLASSIFIED: NONE KNOWN.
| SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
SUBSTANCE/MIXTURE: MIXTURE
OTHER MEANS OF IDENTIFICATION: NOT AVAILABLE.
CAS NUMBER/OTHER IDENTIFIERS:
INGREDIENT NAME % BY WEIGHT CAS NUMBER
TETRACHLOROETHYLENE 98.0 127-18-4
THERE ARE NO ADDITIONAL INGREDIENTS PRESENT WHICH, WITHIN THE CURRENT
KNOWLEDGE OF THE SUPPLIER AND IN THE CONCENTRATIONS APPLICABLE, ARE
CLASSIFIED AS HAZARDOUS TO HEALTH OR THE ENVIRONMENT AND HENCE REQUIRE
REPORTING IN THIS SECTION.
OCCUPATIONAL EXPOSURE LIMITS, IF AVAILABLE, ARE LISTED IN SECTION 8.
| SECTION 4. FIRST AID MEASURES | |
DESCRIPTION OF NECESSARY FIRST AID MEASURES:
EYE CONTACT:
IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER, OCCASIONALLY LIFTING THE UPPER
AND LOWER EYELIDS. CHECK FOR AND REMOVE ANY CONTACT LENSES. CONTINUE TO
RINSE FOR AT LEAST 10 MINUTES. GET MEDICAL ATTENTION.
INHALATION:
REMOVE VICTIM TO FRESH AIR AND KEEP AT REST IN A POSITION COMFORTABLE FOR
BREATHING. IF IT IS SUSPECTED THAT FUMES ARE STILL PRESENT, THE RESCUER
SHOULD WEAR AN APPROPRIATE MASK OR SELF-CONTAINED BREATHING APPARATUS. IF
NOT BREATHING, IF BREATHING IS IRREGULAR OR IF RESPIRATORY ARREST OCCURS,
PROVIDE ARTIFICIAL RESPIRATION OR OXYGEN BY TRAINED PERSONNEL. IT MAY BE
DANGEROUS TO THE PERSON PROVIDING AID TO GIVE MOUTH-TO-MOUTH RESUSCITATION.
GET MEDICAL ATTENTION. IF NECESSARY, CALL A POISON CENTER OR PHYSICIAN. IF
UNCONSCIOUS, PLACE IN RECOVERY POSITION AND GET MEDICAL ATTENTION
IMMEDIATELY. MAINTAIN AN OPEN AIRWAY. LOOSEN TIGHT CLOTHING SUCH AS A
COLLAR, TIE, BELT OR WAISTBAND. IN CASE OF INHALATION OF DECOMPOSITION
PRODUCTS IN A FIRE, SYMPTOMS MAY BE DELAYED. THE EXPOSED PERSON MAY NEED TO
BE KEPT UNDER MEDICAL SURVEILLANCE FOR 48 HOURS.
SKIN CONTACT:
FLUSH CONTAMINATED SKIN WITH PLENTY OF WATER. REMOVE CONTAMINATED CLOTHING
AND SHOES. WASH CONTAMINATED CLOTHING THOROUGHLY WITH WATER BEFORE REMOVING
IT, OR WEAR GLOVES. CONTINUE TO RINSE FOR AT LEAST 10 MINUTES. GET MEDICAL
ATTENTION. WASH CLOTHING BEFORE REUSE. CLEAN SHOES THOROUGHLY BEFORE REUSE.
INGESTION:
WASH OUT MOUTH WITH WATER. REMOVE DENTURES IF ANY. REMOVE VICTIM TO FRESH
AIR AND KEEP AT REST IN A POSITION COMFORTABLE FOR BREATHING. IF MATERIAL
HAS BEEN SWALLOWED AND THE EXPOSED PERSON IS CONSCIOUS, GIVE SMALL
QUANTITIES OF WATER TO DRINK. STOP IF THE EXPOSED PERSON FEELS SICK AS
VOMITING MAY BE DANGEROUS. DO NOT INDUCE VOMITING UNLESS DIRECTED TO DO SO
BY MEDICAL PERSONNEL. IF VOMITING OCCURS, THE HEAD SHOULD BE KEPT LOW SO
THAT VOMIT DOES NOT ENTER THE LUNGS. GET MEDICAL ATTENTION. IF NECESSARY,
CALL A POISON CENTER OR PHYSICIAN. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON. IF UNCONSCIOUS, PLACE IN RECOVERY POSITION AND GET
MEDICAL ATTENTION IMMEDIATELY. MAINTAIN AN OPEN AIRWAY. LOOSEN TIGHT
CLOTHING SUCH AS A COLLAR, TIE, BELT OR WAISTBAND.
MOST IMPORTANT SYMPTOMS/EFFECTS, ACUTE AND DELAYED:
POTENTIAL ACUTE HEALTH EFFECTS:
EYE CONTACT: CAUSES SERIOUS EYE IRRITATION.
INHALATION:
CAN CAUSE CENTRAL NERVOUS SYSTEM (CNS) DEPRESSION. MAY CAUSE DROWSINESS AND
DIZZINESS. MAY CAUSE RESPIRATORY IRRITATION. EXPOSURE TO DECOMPOSITION
PRODUCTS MAY CAUSE A HEALTH HAZARD. SERIOUS EFFECTS MAY BE DELAYED
FOLLOWING EXPOSURE.
SKIN CONTACT: CAUSES SKIN IRRITATION.
INGESTION:
CAN CAUSE CENTRAL NERVOUS SYSTEM (CNS) DEPRESSION. IRRITATING TO MOUTH,
THROAT AND STOMACH.
OVER-EXPOSURE SIGNS/SYMPTOMS:
EYE CONTACT:
ADVERSE SYMPTOMS MAY INCLUDE THE FOLLOWING:
PAIN OR IRRITATION
WATERING
REDNESS
INHALATION:
ADVERSE SYMPTOMS MAY INCLUDE THE FOLLOWING:
RESPIRATORY TRACT IRRITATION
COUGHING
NAUSEA OR VOMITING
HEADACHE
DROWSINESS/FATIGUE
DIZZINESS/VERTIGO
UNCONSCIOUSNESS
SKIN CONTACT:
ADVERSE SYMPTOMS MAY INCLUDE THE FOLLOWING:
IRRITATION
REDNESS
INGESTION: NO SPECIFIC DATA.
INDICATION OF IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED, IF
NECESSARY:
NOTES TO PHYSICIAN:
IN CASE OF INHALATION OF DECOMPOSITION PRODUCTS IN A FIRE, SYMPTOMS MAY BE
DELAYED. THE EXPOSED PERSON MAY NEED TO BE KEPT UNDER MEDICAL SURVEILLANCE
FOR 48 HOURS.
SPECIFIC TREATMENTS: NO SPECIFIC TREATMENT.
PROTECTION OF FIRST-AIDERS:
NO ACTION SHALL BE TAKEN INVOLVING ANY PERSONAL RISK OR WITHOUT SUITABLE
TRAINING. IF IT IS SUSPECTED THAT FUMES ARE STILL PRESENT, THE RESCUER
SHOULD WEAR AN APPROPRIATE MASK OR SELF-CONTAINED BREATHING APPARATUS. IT
MAY BE DANGEROUS TO THE PERSON PROVIDING AID TO GIVE MOUTH-TO-MOUTH
RESUSCITATION. WASH CONTAMINATED CLOTHING THOROUGHLY WITH WATER BEFORE
REMOVING IT, OR WEAR GLOVES.
SEE TOXICOLOGICAL INFORMATION (SECTION 11)
| SECTION 5. FIRE-FIGHTING MEASURES | |
EXTINGUISHING MEDIA:
SUITABLE EXTINGUISHING MEDIA:
USE AN EXTINGUISHING AGENT SUITABLE FOR THE SURROUNDING FIRE.
UNSUITABLE EXTINGUISHING MEDIA: NONE KNOWN.
SPECIFIC HAZARDS ARISING FROM THE CHEMICAL:
IN A FIRE OR IF HEATED, A PRESSURE INCREASE WILL OCCUR AND THE CONTAINER
MAY BURST. BURSTING AEROSOL CONTAINERS MAY BE PROPELLED FROM A FIRE AT HIGH
SPEED. FIRE WATER CONTAMINATED WITH THIS MATERIAL MUST BE CONTAINED AND
PREVENTED FROM BEING DISCHARGED TO ANY WATERWAY, SEWER OR DRAIN.
HAZARDOUS THERMAL DECOMPOSITION PRODUCTS:
DECOMPOSITION PRODUCTS MAY INCLUDE THE FOLLOWING MATERIALS:
CARBON DIOXIDE
CARBON MONOXIDE
HALOGENATED COMPOUNDS
CARBONYL HALIDES
SPECIAL PROTECTIVE ACTIONS FOR FIRE-FIGHTERS:
PROMPTLY ISOLATE THE SCENE BY REMOVING ALL PERSONS FROM THE VICINITY OF THE
INCIDENT IF THERE IS A FIRE. NO ACTION SHALL BE TAKEN INVOLVING ANY
PERSONAL RISK OR WITHOUT SUITABLE TRAINING. MOVE CONTAINERS FROM FIRE AREA
IF THIS CAN BE DONE WITHOUT RISK. USE WATER SPRAY TO KEEP FIRE-EXPOSED
CONTAINERS COOL.
SPECIAL PROTECTIVE EQUIPMENT FOR FIRE-FIGHTERS:
FIRE-FIGHTERS SHOULD WEAR APPROPRIATE PROTECTIVE EQUIPMENT AND
SELF-CONTAINED BREATHING APPARATUS (SCBA) WITH A FULL FACE-PIECE
OPERATED IN POSITIVE PRESSURE MODE.
| SECTION 6. ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
FOR NON-EMERGENCY PERSONNEL:
NO ACTION SHALL BE TAKEN INVOLVING ANY PERSONAL RISK OR WITHOUT SUITABLE
TRAINING. EVACUATE SURROUNDING AREAS. KEEP UNNECESSARY AND UNPROTECTED
PERSONNEL FROM ENTERING. IN THE CASE OF AEROSOLS BEING RUPTURED, CARE
SHOULD BE TAKEN DUE TO THE RAPID ESCAPE OF THE PRESSURIZED CONTENTS AND
PROPELLANT. IF A LARGE NUMBER OF CONTAINERS ARE RUPTURED, TREAT AS A BULK
MATERIAL SPILLAGE ACCORDING TO THE INSTRUCTIONS IN THE CLEAN-UP SECTION.
DO NOT TOUCH OR WALK THROUGH SPILLED MATERIAL. AVOID BREATHING VAPOR OR
MIST. PROVIDE ADEQUATE VENTILATION. WEAR APPROPRIATE RESPIRATOR WHEN
VENTILATION IS INADEQUATE. PUT ON APPROPRIATE PERSONAL PROTECTIVE
EQUIPMENT.
FOR EMERGENCY RESPONDERS:
IF SPECIALISED CLOTHING IS REQUIRED TO DEAL WITH THE SPILLAGE, TAKE NOTE OF
ANY INFORMATION IN SECTION 8 ON SUITABLE AND UNSUITABLE MATERIALS. SEE ALSO
THE INFORMATION IN "FOR NON-EMERGENCY PERSONNEL".
ENVIRONMENTAL PRECAUTIONS:
AVOID DISPERSAL OF SPILLED MATERIAL AND RUNOFF AND CONTACT WITH SOIL,
WATERWAYS, DRAINS AND SEWERS. INFORM THE RELEVANT AUTHORITIES IF THE
PRODUCT HAS CAUSED ENVIRONMENTAL POLLUTION (SEWERS, WATERWAYS, SOIL OR
AIR). WATER POLLUTING MATERIAL. MAY BE HARMFUL TO THE ENVIRONMENT IF
RELEASED IN LARGE QUANTITIES.
METHODS AND MATERIALS FOR CONTAINMENT AND CLEANING UP:
SMALL SPILL:
STOP LEAK IF WITHOUT RISK. MOVE CONTAINERS FROM SPILL AREA. DILUTE WITH
WATER AND MOP UP IF WATER-SOLUBLE. ALTERNATIVELY, OR IF WATER-INSOLUBLE,
ABSORB WITH AN INERT DRY MATERIAL AND PLACE IN AN APPROPRIATE WASTE
DISPOSAL CONTAINER. DISPOSE OF VIA A LICENSED WASTE DISPOSAL CONTRACTOR.
LARGE SPILL:
STOP LEAK IF WITHOUT RISK. MOVE CONTAINERS FROM SPILL AREA. APPROACH
RELEASE FROM UPWIND. PREVENT ENTRY INTO SEWERS, WATER COURSES, BASEMENTS OR
CONFINED AREAS. WASH SPILLAGES INTO AN EFFLUENT TREATMENT PLANT OR PROCEED
AS FOLLOWS. CONTAIN AND COLLECT SPILLAGE WITH NON-COMBUSTIBLE, ABSORBENT
MATERIAL E.G. SAND, EARTH, VERMICULITE OR DIATOMACEOUS EARTH AND PLACE IN
CONTAINER FOR DISPOSAL ACCORDING TO LOCAL REGULATIONS (SEE SECTION 13).
DISPOSE OF VIA A LICENSED WASTE DISPOSAL CONTRACTOR. CONTAMINATED ABSORBENT
MATERIAL MAY POSE THE SAME HAZARD AS THE SPILLED PRODUCT.
NOTE:
SEE SECTION 1 FOR EMERGENCY CONTACT INFORMATION AND SECTION 13 FOR WASTE
DISPOSAL.
| SECTION 7. HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING:
PROTECTIVE MEASURES:
PUT ON APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT (SEE SECTION 8).
PRESSURIZED CONTAINER:
PROTECT FROM SUNLIGHT AND DO NOT EXPOSE TO TEMPERATURES EXCEEDING
50 DEG. C. DO NOT PIERCE OR BURN, EVEN AFTER USE. AVOID EXPOSURE - OBTAIN
SPECIAL INSTRUCTIONS BEFORE USE. DO NOT HANDLE UNTIL ALL SAFETY PRECAUTIONS
HAVE BEEN READ AND UNDERSTOOD. DO NOT GET IN EYES OR ON SKIN OR CLOTHING.
DO NOT BREATHE VAPOR OR MIST. DO NOT INGEST. AVOID BREATHING GAS. AVOID
RELEASE TO THE ENVIRONMENT. USE ONLY WITH ADEQUATE VENTILATION. WEAR
APPROPRIATE RESPIRATOR WHEN VENTILATION IS INADEQUATE. EMPTY CONTAINERS
RETAIN PRODUCT RESIDUE AND CAN BE HAZARDOUS.
ADVICE ON GENERAL OCCUPATIONAL HYGIENE:
EATING, DRINKING AND SMOKING SHOULD BE PROHIBITED IN AREAS WHERE THIS
MATERIAL IS HANDLED, STORED AND PROCESSED. WORKERS SHOULD WASH HANDS AND
FACE BEFORE EATING, DRINKING AND SMOKING. REMOVE CONTAMINATED CLOTHING AND
PROTECTIVE EQUIPMENT BEFORE ENTERING EATING AREAS. SEE ALSO SECTION 8 FOR
ADDITIONAL INFORMATION ON HYGIENE MEASURES.
CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES:
STORE IN ACCORDANCE WITH LOCAL REGULATIONS. STORE AWAY FROM DIRECT SUNLIGHT
IN A DRY, COOL AND WELL-VENTILATED AREA, AWAY FROM INCOMPATIBLE MATERIALS
(SEE SECTION 10) AND FOOD AND DRINK. PROTECT FROM SUNLIGHT. STORE LOCKED
UP. USE APPROPRIATE CONTAINMENT TO AVOID ENVIRONMENTAL CONTAMINATION.
| SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
CONTROL PARAMETERS:
OCCUPATIONAL EXPOSURE LIMITS:
INGREDIENT NAME EXPOSURE LIMITS
TETRACHLOROETHYLENE ACGIH TLV (UNITED STATES, 4/2014).
TWA: 25 PPM 8 HOURS.
TWA: 170 MG/M3 8 HOURS.
STEL: 100 PPM 15 MINUTES.
STEL: 685 MG/M3 15 MINUTES.
OSHA PEL Z2 (UNITED STATES, 2/2013).
TWA: 100 PPM 8 HOURS.
CEIL: 200 PPM
AMP: 300 PPM 5 MINUTES.
APPROPRIATE ENGINEERING CONTROLS:
USE ONLY WITH ADEQUATE VENTILATION. USE PROCESS ENCLOSURES, LOCAL EXHAUST
VENTILATION OR OTHER ENGINEERING CONTROLS TO KEEP WORKER EXPOSURE TO
AIRBORNE CONTAMINANTS BELOW ANY RECOMMENDED OR STATUTORY LIMITS.
ENVIRONMENTAL EXPOSURE CONTROLS:
EMISSIONS FROM VENTILATION OR WORK PROCESS EQUIPMENT SHOULD BE CHECKED
TO ENSURE THEY COMPLY WITH THE REQUIREMENTS OF ENVIRONMENTAL PROTECTION
LEGISLATION. IN SOME CASES, FUME SCRUBBERS, FILTERS OR ENGINEERING
MODIFICATIONS TO THE PROCESS EQUIPMENT WILL BE NECESSARY TO REDUCE
EMISSIONS TO ACCEPTABLE LEVELS.
INDIVIDUAL PROTECTION MEASURES:
HYGIENE MEASURES:
WASH HANDS, FOREARMS AND FACE THOROUGHLY AFTER HANDLING CHEMICAL PRODUCTS,
BEFORE EATING, SMOKING AND USING THE LAVATORY AND AT THE END OF THE WORKING
PERIOD. APPROPRIATE TECHNIQUES SHOULD BE USED TO REMOVE POTENTIALLY
CONTAMINATED CLOTHING. WASH CONTAMINATED CLOTHING BEFORE REUSING. ENSURE
THAT EYEWASH STATIONS AND SAFETY SHOWERS ARE CLOSE TO THE WORKSTATION
LOCATION.
EYE/FACE PROTECTION:
SAFETY EYEWEAR COMPLYING WITH AN APPROVED STANDARD SHOULD BE USED WHEN A
RISK ASSESSMENT INDICATES THIS IS NECESSARY TO AVOID EXPOSURE TO LIQUID
SPLASHES, MISTS, GASES OR DUSTS. IF CONTACT IS POSSIBLE, THE FOLLOWING
PROTECTION SHOULD BE WORN, UNLESS THE ASSESSMENT INDICATES A HIGHER DEGREE
OF PROTECTION: CHEMICAL SPLASH GOGGLES.
SKIN PROTECTION:
HAND PROTECTION:
CHEMICAL-RESISTANT, IMPERVIOUS GLOVES COMPLYING WITH AN APPROVED STANDARD
SHOULD BE WORN AT ALL TIMES WHEN HANDLING CHEMICAL PRODUCTS IF A RISK
ASSESSMENT INDICATES THIS IS NECESSARY. CONSIDERING THE PARAMETERS
SPECIFIED BY THE GLOVE MANUFACTURER, CHECK DURING USE THAT THE GLOVES ARE
STILL RETAINING THEIR PROTECTIVE PROPERTIES. IT SHOULD BE NOTED THAT THE
TIME TO BREAKTHROUGH FOR ANY GLOVE MATERIAL MAY BE DIFFERENT FOR DIFFERENT
GLOVE MANUFACTURERS. IN THE CASE OF MIXTURES, CONSISTING OF SEVERAL
SUBSTANCES, THE PROTECTION TIME OF THE GLOVES CANNOT BE ACCURATELY
ESTIMATED.
BODY PROTECTION:
PERSONAL PROTECTIVE EQUIPMENT FOR THE BODY SHOULD BE SELECTED BASED ON THE
TASK BEING PERFORMED AND THE RISKS INVOLVED AND SHOULD BE APPROVED BY A
SPECIALIST BEFORE HANDLING THIS PRODUCT.
OTHER SKIN PROTECTION:
APPROPRIATE FOOTWEAR AND ANY ADDITIONAL SKIN PROTECTION MEASURES SHOULD BE
SELECTED BASED ON THE TASK BEING PERFORMED AND THE RISKS INVOLVED AND
SHOULD BE APPROVED BY A SPECIALIST BEFORE HANDLING THIS PRODUCT.
RESPIRATORY PROTECTION:
USE A PROPERLY FITTED, AIR-PURIFYING OR AIR-FED RESPIRATOR COMPLYING WITH
AN APPROVED STANDARD IF A RISK ASSESSMENT INDICATES THIS IS NECESSARY.
RESPIRATOR SELECTION MUST BE BASED ON KNOWN OR ANTICIPATED EXPOSURE LEVELS,
THE HAZARDS OF THE PRODUCT AND THE SAFE WORKING LIMITS OF THE SELECTED
RESPIRATOR.
| SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE:
PHYSICAL STATE: LIQUID.
COLOR: NOT AVAILABLE.
ODOR: NOT AVAILABLE.
ODOR THRESHOLD: NOT AVAILABLE.
PH: NOT AVAILABLE.
MELTING POINT: NOT AVAILABLE.
BOILING POINT: NOT AVAILABLE.
FLASH POINT:
CLOSED CUP: >93.3 DEG. C (>199.9 DEG. F)
EVAPORATION RATE: 2.59 (BUTYL ACETATE = 1)
FLAMMABILITY (SOLID, GAS): NOT AVAILABLE.
LOWER AND UPPER EXPLOSIVE (FLAMMABLE) LIMITS: NOT AVAILABLE.
VAPOR PRESSURE: 13.5 KPA (101.325 MMHg) [AT 20 DEG. C]
VAPOR DENSITY: 5.83 [AIR = 1]
RELATIVE DENSITY: 1.6
SOLUBILITY: NOT AVAILABLE.
PARTITION COEFFICIENT N-OCTANOL/WATER: NOT AVAILABLE.
AUTO-IGNITION TEMPERATURE: NOT AVAILABLE.
DECOMPOSITION TEMPERATURE: NOT AVAILABLE.
VISCOSITY:
KINEMATIC (ROOM TEMPERATURE): <0.205 CM2/S (<20.5 CST)
KINEMATIC (40 DEG. C (104 DEG. F)): <0.205 CM2/S (<20.5 CST)
AEROSOL PRODUCT:
TYPE OF AEROSOL: SPRAY
HEAT OF COMBUSTION: 0.000004019 KJ/G
| SECTION 10. STABILITY AND REACTIVITY | |
REACTIVITY:
NO SPECIFIC TEST DATA RELATED TO REACTIVITY AVAILABLE FOR THIS PRODUCT OR
ITS INGREDIENTS.
CHEMICAL STABILITY: THE PRODUCT IS STABLE.
POSSIBILITY OF HAZARDOUS REACTIONS:
UNDER NORMAL CONDITIONS OF STORAGE AND USE, HAZARDOUS REACTIONS WILL NOT
OCCUR.
CONDITIONS TO AVOID: NO SPECIFIC DATA.
INCOMPATIBLE MATERIALS: NO SPECIFIC DATA.
HAZARDOUS DECOMPOSITION PRODUCTS:
UNDER NORMAL CONDITIONS OF STORAGE AND USE, HAZARDOUS DECOMPOSITION
PRODUCTS SHOULD NOT BE PRODUCED.
| SECTION 11. TOXICOLOGICAL INFORMATION | |
INFORMATION ON TOXICOLOGICAL EFFECTS:
ACUTE TOXICITY:
PRODUCT/INGREDIENT NAME RESULT SPECIES DOSE EXPOSURE
TETRACHLOROETHYLENE LD50 ORAL RAT 2629 MG/KG
IRRITATION/CORROSION:
PRODUCT/ RESULT SPECIES SCORE EXPOSURE OBSERVATION
INGREDIENT
NAME
TETRACHLORO- EYES: RABBIT 24 HOURS
ETHYLENE MILD IRRITANT 500 MILLIGRAMS
EYES: RABBIT 162 MILLIGRAMS
MILD IRRITANT
SKIN: RABBIT 24 HOURS
MILD IRRITANT 500 MILLIGRAMS
SKIN: RABBIT 24 HOURS
SEVERE 810 MILLIGRAMS
IRRITANT
SENSITIZATION: NOT AVAILABLE.
MUTAGENICITY: NOT AVAILABLE.
CARCINOGENICITY: NOT AVAILABLE.
CLASSIFICATION:
PRODUCT/INGREDIENT NAME OSHA IARC NTP
TETRACHLOROETHYLENE 2A REASONABLY ANTICIPATED TO BE A HUMAN
CARCINOGEN.
REPRODUCTIVE TOXICITY: NOT AVAILABLE.
TERATOGENICITY: NOT AVAILABLE.
SPECIFIC TARGET ORGAN TOXICITY (SINGLE EXPOSURE):
NAME CATEGORY ROUTE OF TARGET ORGANS
EXPOSURE
TETRACHLOROETHYLENE CATEGORY 3 NOT APPLICABLE. RESPIRATORY TRACT
IRRITATION AND
NARCOTIC EFFECTS
SPECIFIC TARGET ORGAN TOXICITY (REPEATED EXPOSURE):
NAME CATEGORY ROUTE OF TARGET ORGANS
EXPOSURE
TETRACHLOROETHYLENE CATEGORY 2 NOT DETERMINED NOT DETERMINED
ASPIRATION HAZARD: NOT AVAILABLE.
INFORMATION ON THE LIKELY ROUTES OF EXPOSURE: NOT AVAILABLE.
POTENTIAL ACUTE HEALTH EFFECTS:
EYE CONTACT: CAUSES SERIOUS EYE IRRITATION.
INHALATION:
CAN CAUSE CENTRAL NERVOUS SYSTEM (CNS) DEPRESSION. MAY CAUSE DROWSINESS AND
DIZZINESS. MAY CAUSE RESPIRATORY IRRITATION. EXPOSURE TO DECOMPOSITION
PRODUCTS MAY CAUSE A HEALTH HAZARD. SERIOUS EFFECTS MAY BE DELAYED
FOLLOWING EXPOSURE.
SKIN CONTACT: CAUSES SKIN IRRITATION.
INGESTION:
CAN CAUSE CENTRAL NERVOUS SYSTEM (CNS) DEPRESSION. IRRITATING TO MOUTH,
THROAT AND STOMACH.
SYMPTOMS RELATED TO THE PHYSICAL, CHEMICAL AND TOXICOLOGICAL
CHARACTERISTICS:
EYE CONTACT:
ADVERSE SYMPTOMS MAY INCLUDE THE FOLLOWING:
PAIN OR IRRITATION
WATERING
REDNESS
INHALATION:
ADVERSE SYMPTOMS MAY INCLUDE THE FOLLOWING:
RESPIRATORY TRACT IRRITATION
COUGHING
NAUSEA OR VOMITING
HEADACHE
DROWSINESS/FATIGUE
DIZZINESS/VERTIGO
UNCONSCIOUSNESS
SKIN CONTACT:
ADVERSE SYMPTOMS MAY INCLUDE THE FOLLOWING:
IRRITATION
REDNESS
INGESTION: NO SPECIFIC DATA.
DELAYED AND IMMEDIATE EFFECTS AND ALSO CHRONIC EFFECTS FROM SHORT AND LONG
TERM EXPOSURE:
SHORT TERM EXPOSURE:
POTENTIAL IMMEDIATE EFFECTS: NOT AVAILABLE.
POTENTIAL DELAYED EFFECTS: NOT AVAILABLE.
LONG TERM EXPOSURE:
POTENTIAL IMMEDIATE EFFECTS: NOT AVAILABLE.
POTENTIAL DELAYED EFFECTS: NOT AVAILABLE.
POTENTIAL CHRONIC HEALTH EFFECTS: NOT AVAILABLE.
GENERAL: MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE.
CARCINOGENICITY:
MAY CAUSE CANCER. RISK OF CANCER DEPENDS ON DURATION AND LEVEL OF EXPOSURE.
MUTAGENICITY: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
TERATOGENICITY: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
DEVELOPMENTAL EFFECTS: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
FERTILITY EFFECTS: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
NUMERICAL MEASURES OF TOXICITY:
ACUTE TOXICITY ESTIMATES:
ROUTE ATE VALUE
ORAL 2682.7 MG/KG
| SECTION 12. ECOLOGICAL INFORMATION | |
TOXICITY:
PRODUCT/INGREDIENT RESULT SPECIES EXPOSURE
NAME
TETRACHLOROETHYLENE ACUTE EC50: ALGAE - SKELETONEMA 96 HOURS
504 PPM COSTATUM
MARINE WATER
ACUTE EC50: ALGAE - CHLAMYDOMONAS 72 HOURS
3.64 MG/L REINHARDTII -
FRESH WATER EXPONENTIAL GROWTH
PHASE
ACUTE EC50: DAPHNIA - DAPHNIA 48 HOURS
7500 (MICRO)G/L MAGNA - INSTAR
FRESH WATER
ACUTE LC50: CRUSTACEANS - ELMINIUS 48 HOURS
3.5 MG/L MODESTUS
MARINE WATER
ACUTE LC50: FISH - JORDANELLA 96 HOURS
4000 (MICRO)G/L FLORIDAE - JUVENILE
FRESH WATER (FLEDGLING, HATCHLING,
WEANLING)
CHRONIC EC10: ALGAE - CHLAMYDOMONAS 72 HOURS
1.77 MG/L REINHARDTII -
FRESH WATER EXPONENTIAL GROWTH
PHASE
CHRONIC NOEC: DAPHNIA - DAPHNIA 21 DAYS
0.4 MG/L MAGNA
FRESH WATER
CHRONIC NOEC: FISH - PIMEPHALES 32 DAYS
500 (MICRO)G/L PROMELAS - LARVAE
FRESH WATER
PERSISTENCE AND DEGRADABILITY: NOT AVAILABLE.
BIOACCUMULATIVE POTENTIAL:
PRODUCT/INGREDIENT NAME LOGPOW BCF POTENTIAL
TETRACHLOROETHYLENE 49 LOW
MOBILITY IN SOIL:
SOIL/WATER PARTITION COEFFICIENT (KOC): NOT AVAILABLE.
OTHER ADVERSE EFFECTS: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
| SECTION 13. DISPOSAL CONSIDERATIONS | |
DISPOSAL METHODS:
THE GENERATION OF WASTE SHOULD BE AVOIDED OR MINIMIZED WHEREVER POSSIBLE.
DISPOSAL OF THIS PRODUCT, SOLUTIONS AND ANY BY-PRODUCTS SHOULD AT ALL TIMES
COMPLY WITH THE REQUIREMENTS OF ENVIRONMENTAL PROTECTION AND WASTE DISPOSAL
LEGISLATION AND ANY REGIONAL LOCAL AUTHORITY REQUIREMENTS. DISPOSE OF
SURPLUS AND NON-RECYCLABLE PRODUCTS VIA A LICENSED WASTE DISPOSAL
CONTRACTOR. WASTE SHOULD NOT BE DISPOSED OF UNTREATED TO THE SEWER UNLESS
FULLY COMPLIANT WITH THE REQUIREMENTS OF ALL AUTHORITIES WITH JURISDICTION.
WASTE PACKAGING SHOULD BE RECYCLED. INCINERATION OR LANDFILL SHOULD ONLY BE
CONSIDERED WHEN RECYCLING IS NOT FEASIBLE. THIS MATERIAL AND ITS CONTAINER
MUST BE DISPOSED OF IN A SAFE WAY. EMPTY CONTAINERS OR LINERS MAY RETAIN
SOME PRODUCT RESIDUES. DO NOT PUNCTURE OR INCINERATE CONTAINER.
| SECTION 14. TRANSPORT INFORMATION | |
DOT TDG MEXICO
CLASSIFICATION CLASSIFICATION CLASSIFICATION
UN NUMBER UN1950 UN1950 UN1950
UN PROPER SHIPPING NAME AEROSOLS AEROSOLS AEROSOLS
TRANSPORT HAZARD CLASS(ES) 2.2 2.2 2.2
NON-FLAMMABLE CLASS 2.2, CLASS 2.2,
GAS, CLASS/ NON-FLAMMABLE NON-FLAMMABLE
DIVISION 2.2 AND NON-TOXIC AND NON-TOXIC
GASES GASES
PACKING GROUP
ENVIRONMENTAL HAZARDS NO. NO. NO.
ADDITIONAL INFORMATION SPECIAL SPECIAL SPECIAL
PROVISIONS: PROVISIONS: PROVISIONS:
LIMITED NOT APPLICABLE (ERG#126)
QUANTITY
IATA IMDG
UN NUMBER UN1950 UN1950
UN PROPER SHIPPING NAME AEROSOLS, AEROSOLS.
NON-FLAMMABLE, MARINE POLLUTANT
TOXIC, CONTAINING (TETRACHLOROETHYLENE)
SUBSTANCES IN
DIVISION 6.1,
PACKING GROUP III
TRANSPORT HAZARD CLASS(ES) 2.2 (6.1) 2.2
CLASS 2.2, CLASS 2.2 - NON-
NON-FLAMMABLE FLAMMABLE GASES
AND NON-TOXIC GASES
CLASS 6.1, TOXIC ENVIRONMENT
PACKING GROUP
ENVIRONMENTAL HAZARDS NO. YES.
ADDITIONAL INFORMATION THE ENVIRONMENTALLY THE MARINE POLLUTANT
HAZARDOUS MARK IS NOT REQUIRED
SUBSTANCE MARK WHEN TRANSPORTED IN
MAY APPEAR IF SIZES OF </=5 L OR
REQUIRED BY OTHER </=5 KG.
TRANSPORTATION
REGULATIONS. EMERGENCY SCHEDULES
(EMS): F-D, S-U
SPECIAL PROVISIONS:
LIMITED QUANTITY
SPECIAL PRECAUTIONS FOR USER:
MULTI-MODAL SHIPPING DESCRIPTIONS ARE PROVIDED FOR INFORMATIONAL PURPOSES
AND DO NOT CONSIDER CONTAINER SIZES. THE PRESENCE OF A SHIPPING DESCRIPTION
FOR A PARTICULAR MODE OF TRANSPORT (SEA, AIR, ETC.), DOES NOT INDICATE THAT
THE PRODUCT IS PACKAGED SUITABLY FOR THAT MODE OF TRANSPORT. ALL PACKAGING
MUST BE REVIEWED FOR SUITABILITY PRIOR TO SHIPMENT, AND COMPLIANCE WITH THE
APPLICABLE REGULATIONS IS THE SOLE RESPONSIBILITY OF THE PERSON OFFERING
THE PRODUCT FOR TRANSPORT. PEOPLE LOADING AND UNLOADING DANGEROUS GOODS
MUST BE TRAINED ON ALL OF THE RISKS DERIVING FROM THE SUBSTANCES AND ON ALL
ACTIONS IN CASE OF EMERGENCY SITUATIONS.
TRANSPORT IN BULK ACCORDING TO ANNEX II OF MARPOL 73/78 AND THE IBC CODE:
NOT AVAILABLE.
| SECTION 15. REGULATORY INFORMATION | |
U.S. FEDERAL REGULATIONS:
STATE REGULATIONS:
CALIFORNIA PROP. 65:
WARNING:
THIS PRODUCT CONTAINS A CHEMICAL KNOWN TO THE STATE OF CALIFORNIA TO CAUSE
CANCER.
| SECTION 16. OTHER INFORMATION | |
HAZARDOUS MATERIAL INFORMATION SYSTEM (U.S.A.):
HEALTH 2*
FLAMMABILITY 2
PHYSICAL HAZARDS 0
CAUTION:
HMIS(R*) RATINGS ARE BASED ON A 0-4 RATING SCALE, WITH 0 REPRESENTING
MINIMAL HAZARDS OR RISKS, AND 4 REPRESENTING SIGNIFICANT HAZARDS OR RISKS
ALTHOUGH HMIS(R*) RATINGS ARE NOT REQUIRED ON SDSS UNDER 29 CFR 1910.1200,
THE PREPARER MAY CHOOSE TO PROVIDE THEM. HMIS(R*) RATINGS ARE TO BE USED
WITH A FULLY IMPLEMENTED HMIS(R*) PROGRAM. HMIS(R*) IS A REGISTERED MARK
OF THE NATIONAL PAINT & COATINGS ASSOCIATION (NPCA). HMIS(R*) MATERIALS
MAY BE PURCHASED EXCLUSIVELY FROM J. J. KELLER (800) 327-6868.
THE CUSTOMER IS RESPONSIBLE FOR DETERMINING THE PPE CODE FOR THIS MATERIAL.
NOTICE TO READER:
IT IS RECOMMENDED THAT EACH CUSTOMER OR RECIPIENT OF THIS SAFETY DATA SHEET
(SDS) STUDY IT CAREFULLY AND CONSULT RESOURCES, AS NECESSARY OR
APPROPRIATE, TO BECOME AWARE OF AND UNDERSTAND THE DATA CONTAINED IN THIS
SDS AND ANY HAZARDS ASSOCIATED WITH THE PRODUCT. THIS INFORMATION IS
PROVIDED IN GOOD FAITH AND BELIEVED TO BE ACCURATE AS OF THE EFFECTIVE DATE
HEREIN. HOWEVER, NO WARRANTY, EXPRESS OR IMPLIED, IS GIVEN. THE INFORMATION
PRESENTED HERE APPLIES ONLY TO THE PRODUCT AS SHIPPED. THE ADDITION OF ANY
MATERIAL CAN CHANGE THE COMPOSITION, HAZARDS AND RISKS OF THE PRODUCT.
REGULATORY REQUIREMENTS ARE SUBJECT TO CHANGE AND MAY DIFFER BETWEEN
VARIOUS LOCATIONS AND JURISDICTIONS. THE CUSTOMER/BUYER/USER IS RESPONSIBLE
TO ENSURE THAT HIS ACTIVITIES COMPLY WITH ALL COUNTRY, FEDERAL, STATE,
PROVINCIAL OR LOCAL LAWS. THE CONDITIONS FOR USE OF THE PRODUCT ARE NOT
UNDER THE CONTROL OF THE MANUFACTURER; THE CUSTOMER/BUYER/USER IS
RESPONSIBLE TO DETERMINE THE CONDITIONS NECESSARY FOR THE SAFE USE OF THIS
PRODUCT. THE CUSTOMER/BUYER/USER SHOULD NOT USE THE PRODUCT FOR ANY PURPOSE
OTHER THAN THE PURPOSE SHOWN IN THE APPLICABLE SECTION OF THIS SDS WITHOUT
FIRST REFERRING TO THE SUPPLIER AND OBTAINING WRITTEN HANDLING
INSTRUCTIONS. DUE TO THE PROLIFERATION OF SOURCES FOR INFORMATION SUCH AS
MANUFACTURER-SPECIFIC SDS, THE MANUFACTURER CANNOT BE RESPONSIBLE FOR SDSS
OBTAINED FROM ANY OTHER SOURCE.
DATE OF ISSUE/DATE OF REVISION: 5/29/2015.
DATE OF PREVIOUS ISSUE: NO PREVIOUS VALIDATION.
VERSION: 1