| Common Name: | HEXANES, REAGENT, ACS |
| Manufacturer: | SPECTRUM CHEMICAL |
| SDS Revision Date: | 10/20/2020 |
| SDS Format: | GHS-US |
| Item Number(s): | 6NML2, 6NML5 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
SPECTRUM(R*) CHEMICAL MFG CORP
SAFETY DATA SHEET
SPECTRUM(R*)
REVISION DATE: 20-OCTOBER-2020
REVISION NUMBER: 2
| 1. IDENTIFICATION |  |
PRODUCT IDENTIFIER:
PRODUCT NAME: HEXANES, REAGENT, ACS
OTHER MEANS OF IDENTIFICATION:
PRODUCT CODE(S): H1010
UN/ID NO: UN1208
SYNONYMS: NONE
RECOMMENDED USE OF THE CHEMICAL AND RESTRICTIONS ON USE:
RECOMMENDED USE: NO INFORMATION AVAILABLE
RESTRICTIONS ON USE: NO INFORMATION AVAILABLE
DETAILS OF THE SUPPLIER OF THE SAFETY DATA SHEET:
SUPPLIER ADDRESS:
SPECTRUM CHEMICAL MFG. CORP.
14422 SOUTH SAN PEDRO ST.
GARDENA, CA 90248
(310) 516-8000
EMERGENCY TELEPHONE NUMBER:
EMERGENCY TELEPHONE:
CHEMTREC: 1-800-424-9300
| 2. HAZARD(S) IDENTIFICATION | |
CLASSIFICATION:
SKIN CORROSION/IRRITATION: CATEGORY 2
SERIOUS EYE DAMAGE/EYE IRRITATION: CATEGORY 2B
REPRODUCTIVE TOXICITY: CATEGORY 2
SPECIFIC TARGET ORGAN TOXICITY (SINGLE EXPOSURE): CATEGORY 3
SPECIFIC TARGET ORGAN TOXICITY (REPEATED EXPOSURE): CATEGORY 2
ASPIRATION HAZARD: CATEGORY 1
FLAMMABLE LIQUIDS: CATEGORY 2
HAZARDS NOT OTHERWISE CLASSIFIED (HNOC): NOT APPLICABLE
LABEL ELEMENTS: DANGER
HAZARD STATEMENTS:
CAUSES SKIN IRRITATION
CAUSES EYE IRRITATION
SUSPECTED OF DAMAGING FERTILITY OR THE UNBORN CHILD
MAY CAUSE DROWSINESS OR DIZZINESS
MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE
MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS
HIGHLY FLAMMABLE LIQUID AND VAPOR
EXCLAMATION MARK
HEALTH HAZARD
FLAME
APPEARANCE: NO INFORMATION AVAILABLE
PHYSICAL STATE: LIQUID
ODOR: CHARACTERISTIC
PRECAUTIONARY STATEMENTS - PREVENTION:
OBTAIN SPECIAL INSTRUCTIONS BEFORE USE
DO NOT HANDLE UNTIL ALL SAFETY PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD
WEAR PROTECTIVE GLOVES/PROTECTIVE CLOTHING/EYE PROTECTION/FACE PROTECTION
WASH FACE, HANDS AND ANY EXPOSED SKIN THOROUGHLY AFTER HANDLING
DO NOT BREATHE DUST/FUME/GAS/MIST/VAPORS/SPRAY
USE ONLY OUTDOORS OR IN A WELL-VENTILATED AREA
KEEP AWAY FROM HEAT, HOT SURFACES, SPARKS, OPEN FLAMES AND OTHER IGNITION
SOURCES. NO SMOKING
KEEP CONTAINER TIGHTLY CLOSED
GROUND/BOND CONTAINER AND RECEIVING EQUIPMENT
USE EXPLOSION-PROOF ELECTRICAL/ VENTILATING / LIGHTING/ .? / EQUIPMENT
USE ONLY NON-SPARKING TOOLS
TAKE PRECAUTIONARY MEASURES AGAINST STATIC DISCHARGE
KEEP COOL
PRECAUTIONARY STATEMENTS - RESPONSE:
IF EXPOSED OR CONCERNED: GET MEDICAL ADVICE/ATTENTION
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES,
IF PRESENT AND EASY TO DO. CONTINUE RINSING
IF EYE IRRITATION PERSISTS: GET MEDICAL ADVICE/ATTENTION
IF SKIN IRRITATION OCCURS: GET MEDICAL ADVICE/ATTENTION
IF ON SKIN (OR HAIR):
TAKE OFF IMMEDIATELY ALL CONTAMINATED CLOTHING. RINSE SKIN WITH
WATER/ SHOWER
WASH CONTAMINATED CLOTHING BEFORE REUSE
IF INHALED: REMOVE PERSON TO FRESH AIR AND KEEP COMFORTABLE FOR BREATHING
IF SWALLOWED: IMMEDIATELY CALL A POISON CENTER OR DOCTOR
DO NOT INDUCE VOMITING
IN CASE OF FIRE: USE CO2, DRY CHEMICAL, OR FOAM TO EXTINGUISH
PRECAUTIONARY STATEMENTS - STORAGE:
STORE LOCKED UP.
STORE IN A WELL-VENTILATED PLACE. KEEP CONTAINER TIGHTLY CLOSED
PRECAUTIONARY STATEMENTS - DISPOSAL:
DISPOSE OF CONTENTS/CONTAINER TO AN APPROVED WASTE DISPOSAL PLANT
OTHER INFORMATION: NO INFORMATION AVAILABLE.
| 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
SUBSTANCE: NOT APPLICABLE.
MIXTURE:
CHEMICAL NAME CAS NO WEIGHT-% TRADE SECRET
HEXANE, OTHER ISOMERS (PREDOMINATELY MIXTURE 40 - 60 *
2-METHYLPENTANE AND 3-METHYLPENTANE)
HEXANE 110-54-3 40 - 60 *
METHYLCYCLOPENTANE 96-37-7 1 - 20 *
*THE EXACT PERCENTAGE (CONCENTRATION) OF COMPOSITION HAS BEEN WITHHELD AS
A TRADE SECRET.
| 4. FIRST-AID MEASURES | |
DESCRIPTION OF FIRST AID MEASURES:
GENERAL ADVICE:
SHOW THIS SAFETY DATA SHEET TO THE DOCTOR IN ATTENDANCE. IMMEDIATE MEDICAL
ATTENTION IS REQUIRED.
INHALATION:
REMOVE TO FRESH AIR. ASPIRATION INTO LUNGS CAN PRODUCE SEVERE LUNG DAMAGE.
IF BREATHING HAS STOPPED, GIVE ARTIFICIAL RESPIRATION. GET MEDICAL
ATTENTION IMMEDIATELY. AVOID DIRECT CONTACT WITH SKIN. USE BARRIER TO GIVE
MOUTH-TO-MOUTH RESUSCITATION. IF BREATHING IS DIFFICULT, (TRAINED
PERSONNEL SHOULD) GIVE OXYGEN. GET IMMEDIATE MEDICAL ADVICE/ATTENTION.
DELAYED PULMONARY EDEMA MAY OCCUR.
EYE CONTACT:
RINSE IMMEDIATELY WITH PLENTY OF WATER, ALSO UNDER THE EYELIDS, FOR AT
LEAST 15 MINUTES. KEEP EYE WIDE OPEN WHILE RINSING. DO NOT RUB AFFECTED
AREA. REMOVE CONTACT LENSES, IF PRESENT AND EASY TO DO. CONTINUE RINSING.
GET MEDICAL ATTENTION IF IRRITATION DEVELOPS AND PERSISTS.
SKIN CONTACT:
WASH OFF IMMEDIATELY WITH SOAP AND PLENTY OF WATER WHILE REMOVING ALL
CONTAMINATED CLOTHES AND SHOES. GET MEDICAL ATTENTION IF IRRITATION
DEVELOPS AND PERSISTS.
INGESTION:
DO NOT INDUCE VOMITING. CLEAN MOUTH WITH WATER AND DRINK AFTERWARDS PLENTY
OF WATER. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
ASPIRATION HAZARD IF SWALLOWED - CAN ENTER LUNGS AND CAUSE DAMAGE. IF
VOMITING OCCURS SPONTANEOUSLY, KEEP HEAD BELOW HIPS TO PREVENT ASPIRATION.
GET IMMEDIATE MEDICAL ADVICE/ATTENTION.
SELF-PROTECTION OF THE FIRST AIDER:
REMOVE ALL SOURCES OF IGNITION. ENSURE THAT MEDICAL PERSONNEL ARE AWARE OF
THE MATERIAL(S) INVOLVED, TAKE PRECAUTIONS TO PROTECT THEMSELVES AND
PREVENT SPREAD OF CONTAMINATION. USE PERSONAL PROTECTIVE EQUIPMENT AS
REQUIRED. SEE SECTION 8 FOR MORE INFORMATION. AVOID DIRECT CONTACT WITH
SKIN. USE BARRIER TO GIVE MOUTH-TO-MOUTH RESUSCITATION. AVOID CONTACT WITH
SKIN, EYES OR CLOTHING.
MOST IMPORTANT SYMPTOMS AND EFFECTS, BOTH ACUTE AND DELAYED:
SYMPTOMS:
DIFFICULTY IN BREATHING. COUGHING AND/ OR WHEEZING. DIZZINESS. INHALATION
OF HIGH VAPOR CONCENTRATIONS MAY CAUSE SYMPTOMS LIKE HEADACHE, DIZZINESS,
TIREDNESS, NAUSEA AND VOMITING.
INDICATION OF ANY IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED:
NOTE TO PHYSICIANS:
BECAUSE OF THE DANGER OF ASPIRATION, EMESIS OR GASTRIC LAVAGE SHOULD NOT
BE EMPLOYED UNLESS THE RISK IS JUSTIFIED BY THE PRESENCE OF ADDITIONAL
TOXIC SUBSTANCES.
| 5. FIRE-FIGHTING MEASURES | |
SUITABLE EXTINGUISHING MEDIA:
DRY CHEMICAL. CARBON DIOXIDE (CO2). WATER SPRAY. ALCOHOL RESISTANT FOAM.
LARGE FIRE:
CAUTION: USE OF WATER SPRAY WHEN FIGHTING FIRE MAY BE INEFFICIENT.
UNSUITABLE EXTINGUISHING MEDIA:
DO NOT SCATTER SPILLED MATERIAL WITH HIGH PRESSURE WATER STREAMS.
SPECIFIC HAZARDS ARISING FROM THE CHEMICAL:
RISK OF IGNITION. KEEP PRODUCT AND EMPTY CONTAINER AWAY FROM HEAT AND
SOURCES OF IGNITION. IN THE EVENT OF FIRE, COOL TANKS WITH WATER SPRAY.
FIRE RESIDUES AND CONTAMINATED FIRE EXTINGUISHING WATER MUST BE DISPOSED
OF IN ACCORDANCE WITH LOCAL REGULATIONS.
EXPLOSION DATA:
SENSITIVITY TO MECHANICAL IMPACT: NONE.
SENSITIVITY TO STATIC DISCHARGE: YES.
SPECIAL PROTECTIVE EQUIPMENT FOR FIRE-FIGHTERS:
FIREFIGHTERS SHOULD WEAR SELF-CONTAINED BREATHING APPARATUS AND FULL
FIREFIGHTING TURNOUT GEAR. USE PERSONAL PROTECTION EQUIPMENT.
| 6. ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
PERSONAL PRECAUTIONS:
EVACUATE PERSONNEL TO SAFE AREAS. USE PERSONAL PROTECTIVE EQUIPMENT AS
REQUIRED. SEE SECTION 8 FOR MORE INFORMATION. AVOID CONTACT WITH SKIN,
EYES OR CLOTHING. ENSURE ADEQUATE VENTILATION. KEEP PEOPLE AWAY FROM AND
UPWIND OF SPILL/LEAK. ELIMINATE ALL IGNITION SOURCES (NO SMOKING, FLARES,
SPARKS OR FLAMES IN IMMEDIATE AREA). PAY ATTENTION TO FLASHBACK. TAKE
PRECAUTIONARY MEASURES AGAINST STATIC DISCHARGES. ALL EQUIPMENT USED WHEN
HANDLING THE PRODUCT MUST BE GROUNDED. DO NOT TOUCH OR WALK THROUGH
SPILLED MATERIAL.
OTHER INFORMATION:
VENTILATE THE AREA. REFER TO PROTECTIVE MEASURES LISTED IN SECTIONS
7 AND 8.
METHODS AND MATERIAL FOR CONTAINMENT AND CLEANING UP:
METHODS FOR CONTAINMENT:
STOP LEAK IF YOU CAN DO IT WITHOUT RISK. DO NOT TOUCH OR WALK THROUGH
SPILLED MATERIAL. A VAPOR SUPPRESSING FOAM MAY BE USED TO REDUCE VAPORS.
DIKE FAR AHEAD OF SPILL TO COLLECT RUNOFF WATER. KEEP OUT OF DRAINS,
SEWERS, DITCHES AND WATERWAYS. ABSORB WITH EARTH, SAND OR OTHER
NON-COMBUSTIBLE MATERIAL AND TRANSFER TO CONTAINERS FOR LATER DISPOSAL.
METHODS FOR CLEANING UP:
TAKE PRECAUTIONARY MEASURES AGAINST STATIC DISCHARGES. DAM UP. SOAK UP
WITH INERT ABSORBENT MATERIAL. PICK UP AND TRANSFER TO PROPERLY LABELED
CONTAINERS.
| 7. HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING:
ADVICE ON SAFE HANDLING:
USE PERSONAL PROTECTION EQUIPMENT. AVOID BREATHING VAPORS OR MISTS. KEEP
AWAY FROM HEAT, HOT SURFACES, SPARKS, OPEN FLAMES AND OTHER IGNITION
SOURCES. NO SMOKING. USE GROUNDING AND BONDING CONNECTION WHEN
TRANSFERRING THIS MATERIAL TO PREVENT STATIC DISCHARGE, FIRE OR EXPLOSION.
USE WITH LOCAL EXHAUST VENTILATION. USE SPARK-PROOF TOOLS AND
EXPLOSION-PROOF EQUIPMENT. KEEP IN AN AREA EQUIPPED WITH SPRINKLERS. USE
ACCORDING TO PACKAGE LABEL INSTRUCTIONS. HANDLE IN ACCORDANCE WITH GOOD
INDUSTRIAL HYGIENE AND SAFETY PRACTICE. AVOID CONTACT WITH SKIN, EYES OR
CLOTHING. DO NOT EAT, DRINK OR SMOKE WHEN USING THIS PRODUCT. REMOVE
CONTAMINATED CLOTHING AND SHOES. TAKE OFF CONTAMINATED CLOTHING AND WASH
BEFORE REUSE. IN CASE OF INSUFFICIENT VENTILATION, WEAR SUITABLE
RESPIRATORY EQUIPMENT.
CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES:
STORAGE CONDITIONS:
KEEP CONTAINERS TIGHTLY CLOSED IN A DRY, COOL AND WELL-VENTILATED PLACE.
KEEP AWAY FROM HEAT, SPARKS, FLAME AND OTHER SOURCES OF IGNITION (I.E.,
PILOT LIGHTS, ELECTRIC MOTORS AND STATIC ELECTRICITY). KEEP IN PROPERLY
LABELED CONTAINERS. DO NOT STORE NEAR COMBUSTIBLE MATERIALS. KEEP IN AN
AREA EQUIPPED WITH SPRINKLERS. STORE IN ACCORDANCE WITH THE PARTICULAR
NATIONAL REGULATIONS. STORE IN ACCORDANCE WITH LOCAL REGULATIONS. STORE
LOCKED UP. KEEP OUT OF THE REACH OF CHILDREN. STORE AWAY FROM OTHER
MATERIALS.
| 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
CONTROL PARAMETERS:
EXPOSURE LIMITS:
CHEMICAL NAME ACGIH TLV OSHA PEL NIOSH IDLH
HEXANE NO DATA AVAILABLE 500 PPM TWA
110-54-3 1800 MG/M3 TWA
APPROPRIATE ENGINEERING CONTROLS:
ENGINEERING CONTROLS:
SHOWERS
EYEWASH STATIONS
VENTILATION SYSTEMS.
INDIVIDUAL PROTECTION MEASURES, SUCH AS PERSONAL PROTECTIVE EQUIPMENT:
EYE/FACE PROTECTION: TIGHT SEALING SAFETY GOGGLES.
HAND PROTECTION: WEAR SUITABLE GLOVES. IMPERVIOUS GLOVES.
SKIN AND BODY PROTECTION:
WEAR SUITABLE PROTECTIVE CLOTHING. LONG SLEEVED CLOTHING. CHEMICAL
RESISTANT APRON. ANTISTATIC BOOTS.
RESPIRATORY PROTECTION:
NO PROTECTIVE EQUIPMENT IS NEEDED UNDER NORMAL USE CONDITIONS. IF EXPOSURE
LIMITS ARE EXCEEDED OR IRRITATION IS EXPERIENCED, VENTILATION AND
EVACUATION MAY BE REQUIRED.
GENERAL HYGIENE CONSIDERATIONS:
DO NOT EAT, DRINK OR SMOKE WHEN USING THIS PRODUCT. CONTAMINATED WORK
CLOTHING SHOULD NOT BE ALLOWED OUT OF THE WORKPLACE. REGULAR CLEANING
OF EQUIPMENT, WORK AREA AND CLOTHING IS RECOMMENDED. WASH HANDS BEFORE
BREAKS AND IMMEDIATELY AFTER HANDLING THE PRODUCT. WEAR SUITABLE GLOVES
AND EYE/FACE PROTECTION. AVOID CONTACT WITH SKIN, EYES OR CLOTHING.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
INFORMATION ON BASIC PHYSICAL AND CHEMICAL PROPERTIES:
PHYSICAL STATE: LIQUID
APPEARANCE: NO INFORMATION AVAILABLE
COLOR: COLORLESS
ODOR: CHARACTERISTIC
ODOR THRESHOLD: NO INFORMATION AVAILABLE
PROPERTY VALUES REMARKS - METHOD
PH NO DATA AVAILABLE NONE KNOWN
MELTING POINT / FREEZING POINT -95 DEG. C / NONE KNOWN
-139 DEG. F
BOILING POINT / BOILING RANGE 66 - 70 DEG. C / NONE KNOWN
150.8 - 158
DEG. F
FLASH POINT -22 DEG. C / NONE KNOWN
-7.6 DEG. F
EVAPORATION RATE NO DATA AVAILABLE NONE KNOWN
FLAMMABILITY (SOLID, GAS) NO DATA AVAILABLE NONE KNOWN
FLAMMABILITY LIMIT IN AIR NONE KNOWN
UPPER FLAMMABILITY OR EXPLOSIVE LIMITS 7.5 %
LOWER FLAMMABILITY OR EXPLOSIVE LIMITS 1.1 %
VAPOR PRESSURE 16.5 - 18.7 @ NONE KNOWN
20 DEG. C (KPA)
VAPOR DENSITY 2.97 NONE KNOWN
RELATIVE DENSITY 0.66 - 0.68 NONE KNOWN
WATER SOLUBILITY INSOLUBLE IN NONE KNOWN
WATER
SOLUBILITY(IES) NO DATA AVAILABLE NONE KNOWN
PARTITION COEFFICIENT NO DATA AVAILABLE NONE KNOWN
AUTOIGNITION TEMPERATURE 224 - 252 DEG. C NONE KNOWN
/ 435.2 - 485.6
DEG. F
DECOMPOSITION TEMPERATURE NONE KNOWN
KINEMATIC VISCOSITY NO DATA AVAILABLE NONE KNOWN
DYNAMIC VISCOSITY NO DATA AVAILABLE NONE KNOWN
OTHER INFORMATION:
EXPLOSIVE PROPERTIES NO INFORMATION
AVAILABLE
OXIDIZING PROPERTIES NO INFORMATION
AVAILABLE
SOFTENING POINT NO INFORMATION
AVAILABLE
MOLECULAR WEIGHT 86.18
VOC CONTENT (%) NO INFORMATION
AVAILABLE
LIQUID DENSITY NO INFORMATION
AVAILABLE
BULK DENSITY NO INFORMATION
AVAILABLE
| 10. STABILITY AND REACTIVITY | |
REACTIVITY: NO INFORMATION AVAILABLE.
CHEMICAL STABILITY: STABLE UNDER NORMAL CONDITIONS.
POSSIBILITY OF HAZARDOUS REACTIONS: NONE UNDER NORMAL PROCESSING.
CONDITIONS TO AVOID: HEAT, FLAMES AND SPARKS.
INCOMPATIBLE MATERIALS:
STRONG ACIDS. STRONG BASES. STRONG OXIDIZING AGENTS.
HAZARDOUS DECOMPOSITION PRODUCTS:
NONE KNOWN BASED ON INFORMATION SUPPLIED.
| 11. TOXICOLOGICAL INFORMATION | |
INFORMATION ON LIKELY ROUTES OF EXPOSURE:
PRODUCT INFORMATION:
INHALATION:
SPECIFIC TEST DATA FOR THE SUBSTANCE OR MIXTURE IS NOT AVAILABLE.
ASPIRATION INTO LUNGS CAN PRODUCE SEVERE LUNG DAMAGE. MAY CAUSE
PULMONARY EDEMA. PULMONARY EDEMA CAN BE FATAL. MAY CAUSE IRRITATION
OF RESPIRATORY TRACT. MAY CAUSE DROWSINESS OR DIZZINESS.
EYE CONTACT:
SPECIFIC TEST DATA FOR THE SUBSTANCE OR MIXTURE IS NOT AVAILABLE.
IRRITATING TO EYES. (BASED ON COMPONENTS). CAUSES EYE IRRITATION.
SKIN CONTACT:
REPEATED EXPOSURE MAY CAUSE SKIN DRYNESS OR CRACKING. SPECIFIC TEST
DATA FOR THE SUBSTANCE OR MIXTURE IS NOT AVAILABLE. CAUSES SKIN
IRRITATION. (BASED ON COMPONENTS).
INGESTION:
SPECIFIC TEST DATA FOR THE SUBSTANCE OR MIXTURE IS NOT AVAILABLE.
POTENTIAL FOR ASPIRATION IF SWALLOWED. MAY CAUSE LUNG DAMAGE IF
SWALLOWED. ASPIRATION MAY CAUSE PULMONARY EDEMA AND PNEUMONITIS.
MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS. INGESTION MAY CAUSE
GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING AND DIARRHEA.
SYMPTOMS RELATED TO THE PHYSICAL, CHEMICAL AND TOXICOLOGICAL
CHARACTERISTICS:
SYMPTOMS:
DIFFICULTY IN BREATHING. COUGHING AND/ OR WHEEZING. DIZZINESS. REDNESS.
MAY CAUSE REDNESS AND TEARING OF THE EYES. INHALATION OF HIGH VAPOR
CONCENTRATIONS MAY CAUSE SYMPTOMS LIKE HEADACHE, DIZZINESS, TIREDNESS,
NAUSEA AND VOMITING.
ACUTE TOXICITY:
NUMERICAL MEASURES OF TOXICITY:
THE FOLLOWING VALUES ARE CALCULATED BASED ON CHAPTER 3.1 OF THE GHS
DOCUMENT:
ATEMIX (ORAL): 8,333.30 MG/KG
CHEMICAL NAME ORAL LD50 DERMAL LD50 INHALATION LC50
HEXANE = 25 G/KG (RAT) = 3000 MG/KG (RABBIT) = 48000 PPM
110-54-3 (RAT) 4 H
DELAYED AND IMMEDIATE EFFECTS AS WELL AS CHRONIC EFFECTS FROM SHORT AND
LONG-TERM EXPOSURE:
SKIN CORROSION/IRRITATION:
CLASSIFICATION BASED ON DATA AVAILABLE FOR INGREDIENTS. IRRITATING TO SKIN.
SERIOUS EYE DAMAGE/EYE IRRITATION:
CLASSIFICATION BASED ON DATA AVAILABLE FOR INGREDIENTS. IRRITATING TO EYES.
RESPIRATORY OR SKIN SENSITIZATION: NO INFORMATION AVAILABLE.
GERM CELL MUTAGENICITY: NO INFORMATION AVAILABLE.
REPRODUCTIVE TOXICITY:
CONTAINS A KNOWN OR SUSPECTED REPRODUCTIVE TOXIN. CLASSIFICATION BASED ON
DATA AVAILABLE FOR INGREDIENTS. SUSPECTED OF DAMAGING FERTILITY OR THE
UNBORN CHILD.
STOT - SINGLE EXPOSURE: MAY CAUSE DROWSINESS OR DIZZINESS.
STOT - REPEATED EXPOSURE:
MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE.
TARGET ORGAN EFFECTS:
RESPIRATORY SYSTEM, EYES, SKIN, CENTRAL NERVOUS SYSTEM, PERIPHERAL NERVOUS
SYSTEM (PNS).
ASPIRATION HAZARD: MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS.
OTHER ADVERSE EFFECTS: NO INFORMATION AVAILABLE.
INTERACTIVE EFFECTS: NO INFORMATION AVAILABLE.
| 12. ECOLOGICAL INFORMATION | |
ECOTOXICITY:
CHEMICAL NAME ALGAE/AQUATIC FISH TOXICITY TO CRUSTACEA
PLANTS MICROORGANISMS
HEXANE LC50: EC50:
110-54-3 2.1 - 2.98MG/L >1000MG/L
(96H, (24H,
PIMEPHALES DAPHNIA
PROMELAS) MAGNA)
PERSISTENCE AND DEGRADABILITY: NO INFORMATION AVAILABLE.
BIOACCUMULATION: INHERENTLY BIODEGRADABLE.
OTHER ADVERSE EFFECTS: NO INFORMATION AVAILABLE.
| 13. DISPOSAL CONSIDERATIONS | |
WASTE TREATMENT METHODS:
WASTE FROM RESIDUES/UNUSED PRODUCTS:
SHOULD NOT BE RELEASED INTO THE ENVIRONMENT. DISPOSE OF IN ACCORDANCE WITH
LOCAL REGULATIONS. DISPOSE OF WASTE IN ACCORDANCE WITH ENVIRONMENTAL
LEGISLATION.
CONTAMINATED PACKAGING:
EMPTY CONTAINERS POSE A POTENTIAL FIRE AND EXPLOSION HAZARD. DO NOT CUT,
PUNCTURE OF WELD CONTAINERS.
| 14. TRANSPORT INFORMATION | |
DOT:
UN/ID NO: UN1208
PROPER SHIPPING NAME: HEXANES
HAZARD CLASS: 3
PACKING GROUP: II
SPECIAL PROVISIONS: IB2, T4, TP2
MARINE POLLUTANT: SEVERE MARINE POLLUTANT
DESCRIPTION: UN1208, HEXANES, 3, II
EMERGENCY RESPONSE GUIDE NUMBER: 128
TDG:
UN-NO: UN1208
PROPER SHIPPING NAME: HEXANES
HAZARD CLASS: 3
PACKING GROUP: II
DESCRIPTION: UN1208, HEXANES, 3, II
MEX:
UN-NO: UN1208
PROPER SHIPPING NAME: HEXANES
HAZARD CLASS: 3
PACKING GROUP: II
DESCRIPTION: UN1208, HEXANES, 3, II
ICAO (AIR):
UN-NO: UN1208
PROPER SHIPPING NAME: HEXANES
HAZARD CLASS: 3
PACKING GROUP: II
DESCRIPTION: UN1208, HEXANES, 3, II
IATA:
UN NUMBER: UN1208
PROPER SHIPPING NAME: HEXANES
TRANSPORT HAZARD CLASS(ES): 3
PACKING GROUP: II
DESCRIPTION: UN1208, HEXANES, 3, II
IMDG:
UN NUMBER: UN1208
PROPER SHIPPING NAME: HEXANES
TRANSPORT HAZARD CLASS(ES): 3
PACKING GROUP: II
EMS-NO: F-E, S-D
MARINE POLLUTANT: P
DESCRIPTION: UN1208, HEXANES, 3, II, (-22DEG. C C.C.), MARINE POLLUTANT
RID:
UN NUMBER: UN1208
PROPER SHIPPING NAME: HEXANES
TRANSPORT HAZARD CLASS(ES): 3
PACKING GROUP: II
CLASSIFICATION CODE: F1
DESCRIPTION: UN1208, HEXANES, 3, II, ENVIRONMENTALLY HAZARDOUS
LABELS: 3
ADR:
UN NUMBER: 1208
PROPER SHIPPING NAME: HEXANES
TRANSPORT HAZARD CLASS(ES): 3
PACKING GROUP: II
CLASSIFICATION CODE: F1
TUNNEL RESTRICTION CODE: (D/E)
DESCRIPTION: 1208, HEXANES, 3, II, (D/E), ENVIRONMENTALLY HAZARDOUS
LABELS: 3
ADN:
UN/ID NO: UN1208
PROPER SHIPPING NAME: HEXANES
TRANSPORT HAZARD CLASS(ES): 3
PACKING GROUP: II
CLASSIFICATION CODE: F1
DESCRIPTION: UN1208, HEXANES, 3, II, ENVIRONMENTALLY HAZARDOUS
HAZARD LABEL(S): 3
LIMITED QUANTITY (LQ): 1 L
VENTILATION: VE01
EQUIPMENT REQUIREMENTS: PP, EX, A
| 15. REGULATORY INFORMATION | |
INTERNATIONAL INVENTORIES:
TSCA: NOT LISTED
NOTE:
*CONTACT SUPPLIER FOR DETAILS. ONE OR MORE SUBSTANCES IN THIS PRODUCT ARE
EITHER NOT LISTED ON THE US TSCA INVENTORY, LISTED ON THE CONFIDENTIAL US
TSCA INVENTORY OR ARE OTHERWISE EXEMPTED FROM INVENTORY LISTING
REQUIREMENTS
DSL/NDSL: DOES NOT COMPLY
EINECS/ELINCS: DOES NOT COMPLY
ENCS: THIS PRODUCT COMPLIES WITH ENCS
IECSC: THIS PRODUCT DOES NOT COMPLY WITH CHINA
KECL: DOES NOT COMPLY
PICCS: DOES NOT COMPLY
AICS: THIS PRODUCT DOES NOT COMPLY WITH AICS
LEGEND:
TSCA:
UNITED STATES TOXIC SUBSTANCES CONTROL ACT SECTION 8(B) INVENTORY
DSL/NDSL:
CANADIAN DOMESTIC SUBSTANCES LIST/NON-DOMESTIC SUBSTANCES LIST
EINECS/ELINCS:
EUROPEAN INVENTORY OF EXISTING CHEMICAL SUBSTANCES/EUROPEAN LIST OF
NOTIFIED CHEMICAL SUBSTANCES
ENCS: JAPAN EXISTING AND NEW CHEMICAL SUBSTANCES
IECSC: CHINA INVENTORY OF EXISTING CHEMICAL SUBSTANCES
KECL: KOREAN EXISTING AND EVALUATED CHEMICAL SUBSTANCES
PICCS: PHILIPPINES INVENTORY OF CHEMICALS AND CHEMICAL SUBSTANCES
US FEDERAL REGULATIONS:
SARA 313:
SECTION 313 OF TITLE III OF THE SUPERFUND AMENDMENTS AND REAUTHORIZATION
ACT OF 1986 (SARA). THIS PRODUCT CONTAINS A CHEMICAL OR CHEMICALS WHICH
ARE SUBJECT TO THE REPORTING REQUIREMENTS OF THE ACT AND TITLE 40 OF THE
CODE OF FEDERAL REGULATIONS, PART 372.
CHEMICAL NAME SARA 313 - THRESHOLD VALUES %
HEXANE - 110-54-3 1.0
SARA 311/312 HAZARD CATEGORIES:
SHOULD THIS PRODUCT MEET EPCRA 311/312 TIER REPORTING CRITERIA AT 40 CFR
370, REFER TO SECTION 2 OF THIS SDS FOR APPROPRIATE CLASSIFICATIONS.
CWA (CLEAN WATER ACT):
THIS PRODUCT DOES NOT CONTAIN ANY SUBSTANCES REGULATED AS POLLUTANTS
PURSUANT TO THE CLEAN WATER ACT (40 CFR 122.21 AND 40 CFR 122.42).
CERCLA:
THIS MATERIAL, AS SUPPLIED, CONTAINS ONE OR MORE SUBSTANCES REGULATED AS
A HAZARDOUS SUBSTANCE UNDER THE COMPREHENSIVE ENVIRONMENTAL RESPONSE
COMPENSATION AND LIABILITY ACT (CERCLA) (40 CFR 302).
CHEMICAL NAME HAZARDOUS SUBSTANCES RQS EXTREMELY HAZARDOUS SUBSTANCES RQS
HEXANE 5000 LB FINAL RQ
110-54-3 2270 KG FINAL RQ
US STATE REGULATIONS:
CALIFORNIA PROPOSITION 65:
THIS PRODUCT DOES NOT CONTAIN ANY PROPOSITION 65 CHEMICALS.
U.S. STATE RIGHT-TO-KNOW REGULATIONS:
THIS PRODUCT DOES NOT CONTAIN ANY SUBSTANCES REGULATED UNDER APPLICABLE
STATE RIGHT-TO-KNOW REGULATIONS
U.S. EPA LABEL INFORMATION:
EPA PESTICIDE REGISTRATION NUMBER: NOT APPLICABLE
| 16. OTHER INFORMATION | |
NFPA:
HEALTH HAZARDS 2
FLAMMABILITY 3
INSTABILITY 0
PHYSICAL AND CHEMICAL PROPERTIES
HMIS:
HEALTH HAZARDS 2*
FLAMMABILITY 3
PHYSICAL HAZARDS 0
PERSONAL PROTECTION X
CHRONIC HAZARD STAR LEGEND:
* = CHRONIC HEALTH HAZARD
KEY OR LEGEND TO ABBREVIATIONS AND ACRONYMS USED IN THE SAFETY DATA SHEET:
LEGEND SECTION 8:
EXPOSURE CONTROLS/PERSONAL PROTECTION:
TWA: TWA (TIME-WEIGHTED AVERAGE)
STEL: STEL (SHORT TERM EXPOSURE LIMIT)
CEILING: MAXIMUM LIMIT VALUE
KEY LITERATURE REFERENCES AND SOURCES FOR DATA USED TO COMPILE THE SDS:
AGENCY FOR TOXIC SUBSTANCES AND DISEASE REGISTRY (ATSDR)
U.S. ENVIRONMENTAL PROTECTION AGENCY CHEMVIEW DATABASE
EUROPEAN FOOD SAFETY AUTHORITY (EFSA)
EPA (ENVIRONMENTAL PROTECTION AGENCY)
ACUTE EXPOSURE GUIDELINE LEVEL(S) (AEGL(S))
U.S. ENVIRONMENTAL PROTECTION AGENCY FEDERAL INSECTICIDE, FUNGICIDE, AND
RODENTICIDE ACT
U.S. ENVIRONMENTAL PROTECTION AGENCY HIGH PRODUCTION VOLUME CHEMICALS
FOOD RESEARCH JOURNAL
HAZARDOUS SUBSTANCE DATABASE
INTERNATIONAL UNIFORM CHEMICAL INFORMATION DATABASE (IUCLID)
JAPAN GHS CLASSIFICATION
AUSTRALIA NATIONAL INDUSTRIAL CHEMICALS NOTIFICATION AND ASSESSMENT SCHEME
(NICNAS)
NIOSH (NATIONAL INSTITUTE FOR OCCUPATIONAL SAFETY AND HEALTH)
NATIONAL LIBRARY OF MEDICINE'S CHEMID PLUS (NLM CIP)
NATIONAL LIBRARY OF MEDICINE'S PUBMED DATABASE (NLM PUBMED)
NATIONAL TOXICOLOGY PROGRAM (NTP)
NEW ZEALAND'S CHEMICAL CLASSIFICATION AND INFORMATION DATABASE (CCID)
ORGANIZATION FOR ECONOMIC CO-OPERATION AND DEVELOPMENT ENVIRONMENT,
HEALTH, AND SAFETY PUBLICATIONS
ORGANIZATION FOR ECONOMIC CO-OPERATION AND DEVELOPMENT HIGH PRODUCTION
VOLUME CHEMICALS PROGRAM
ORGANIZATION FOR ECONOMIC CO-OPERATION AND DEVELOPMENT SCREENING
INFORMATION DATA SET
WORLD HEALTH ORGANIZATION
REVISION DATE: 20-OCTOBER-2020
REVISION NOTE: NO INFORMATION AVAILABLE.
DISCLAIMER:
THE INFORMATION PROVIDED IN THIS SAFETY DATA SHEET IS CORRECT TO THE BEST
OF OUR KNOWLEDGE, INFORMATION AND BELIEF AT THE DATE OF ITS PUBLICATION.
THE INFORMATION GIVEN IS DESIGNED ONLY AS A GUIDANCE FOR SAFE HANDLING,
USE, PROCESSING, STORAGE, TRANSPORTATION, DISPOSAL AND RELEASE AND IS NOT
TO BE CONSIDERED A WARRANTY OR QUALITY SPECIFICATION. THE INFORMATION
RELATES ONLY TO THE SPECIFIC MATERIAL DESIGNATED AND MAY NOT BE VALID FOR
SUCH MATERIAL USED IN COMBINATION WITH ANY OTHER MATERIALS OR IN ANY
PROCESS, UNLESS SPECIFIED IN THE TEXT.