| Common Name: | LAG-KLOTH 5'X15' BLANKET NO. 6425, 5'X150' ROLL NO. 6426, 4"X150' TAPE NO. 6427 |
| Manufacturer: | FIBERLOCK TECHNOLOGIES |
| SDS Revision Date: | 1/1/2016 |
| SDS Format: | GHS-US |
| Item Number(s): | 9MC87, 9PLV4 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
SDS DATE: JANUARY, 2016
SAFETY DATA SHEET
PER GHS STANDARD FORMAT
| SECTION 1: CHEMICAL PRODUCT AND COMPANY IDENTIFICATION |  |
PRODUCT IDENTIFIER:
PRODUCT NAME:
LAG-KLOTH 5'X15' BLANKET NO. 6425, 5'X150' ROLL NO. 6426, 4"X150' TAPE NO.
6427
RECOMMENDED USE: REWETTABLE WOVEN FIBERGLASS PRODUCT
PRODUCT DESCRIPTION: INORGANIC FILLED WOVEN REWETTABLE FIBERGLASS PRODUCT
INFORMATION ON THE SUPPLIER OF THE SAFETY DATA SHEET:
MANUFACTURED FOR:
FIBERLOCK TECHNOLOGIES, INC.
150 DASCOMB ROAD
ANDOVER, MA 01810
P: 800-342-3755
F: 978-475-6205
EMERGENCY TELEPHONE NUMBERS:
CHEM TEL:
(U.S.): 1-800-255-3924
(OUTSIDE THE U.S.): 813-248-0585
| SECTION 2: HAZARDS IDENTIFICATION | |
SIGNAL WORD: WARNING
EXCLAMATION MARK
HEALTH HAZARD
GHS LABEL STATEMENTS:
HAZARD STATEMENTS:
CAUSES MILD SKIN IRRITATION.
MAY CAUSE RESPIRATORY IRRITATION.
MAY CAUSE CANCER.
GHS CLASSIFICATIONS:
THIS PRODUCT IS CONSIDERED HAZARDOUS BY THE 2012 OSHA HAZARD COMMUNICATION
STANDARD (29 CFR 1910.1200). HAZARDS IDENTIFIED ARE BASED ON HAZARDS OF THE
INGREDIENTS. THE FINISHED PRODUCT HAS NOT BEEN TESTED.
SKIN IRRITATION (HAZARD CATEGORY 3)
SPECIFIC TARGET ORGAN TOXICITY, SINGLE EXPOSURE:
RESPIRATORY TRACT IRRITATION (HAZARD CATEGORY 3)
CARCINOGENICITY (HAZARD CATEGORY 2)
PRECAUTIONARY STATEMENTS:
PREVENTION:
OBTAIN SPECIAL INSTRUCTIONS BEFORE USE. DO NOT HANDLE UNTIL ALL SAFETY
PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD. WEAR PROTECTIVE GLOVES,
PROTECTIVE CLOTHING, EYE PROTECTION, AND FACE PROTECTION. AVOID BREATHING
FIBERS OR DUST. USE ONLY OUTDOORS OR IN A WELL-VENTILATED AREA. KEEP
CONTAINERS TIGHTLY CLOSED.
RESPONSE:
IF EXPOSED OR CONCERNED: GET MEDICAL ADVICE/ATTENTION.
IF INHALED:
REMOVE VICTIM TO FRESH AIR AND KEEP COMFORTABLE FOR BREATHING. CALL A
POISON CENTER/DOCTOR/PHYSICIAN IF YOU FEEL UNWELL.
IF SKIN IRRITATION OCCURS: GET MEDICAL ADVICE/ATTENTION.
STORAGE:
STORE IN A WELL-VENTILATED PLACE. STORE LOCKED UP. KEEP CONTAINER TIGHTLY
CLOSED.
DISPOSAL:
DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH
LOCAL/REGIONAL/NATIONAL/INTERNATIONAL REGULATIONS.
GHS HAZARD AND PRECAUTIONARY STATEMENT CODES: SEE SECTION 16.
| SECTION 3: COMPOSITION INFORMATION ON INGREDIENTS | |
CHEMICAL PRODUCT NAME: FIBERGLASS FABRIC
SYNONYMS: FIBROUS GLASS
COMPONENT CAS NO. MAX. WEIGHT, %*
GLASS, OXIDE, CHEMICALS 65997-17-3 55.0
FIBROUS GLASS DUST NOT ASSIGNED NOT ASSIGNED
NORMAL TEXTILE SIZING NOT ASSIGNED 3.0
BENTONITE 1302-78-9 30.0
INORGANIC CLAYS AND FILLERS NOT ASSIGNED 20.0
CRYSTALLINE SILICA (AS PORTION OF BENTONITE) 14808-60-7 3.0
INORGANIC DISPERSANTS NOT ASSIGNED 1.0
ORGANIC MATERIALS AND PIGMENTS NOT ASSIGNED 1.0
*THE EXACT CONCENTRATION OF COMPOSITION HAS BEEN WITHHELD AS A TRADE
SECRET.
| SECTION 4: FIRST AID MEASURES | |
SKIN CONTACT:
FLUSH WITH AMPLE COOL WATER FOLLOWED BY WASHING WITH MILD SOAP TO REMOVE
ACCUMULATED FIBERS.
EYE CONTACT:
FLUSH WITH FLOWING WATER FOR 15 MINUTES - SEEK MEDICAL ATTENTION IF
NECESSARY.
INHALATION: IF PROCESSING DUST IS INHALED, MOVE THE PERSON TO FRESH AIR.
INGESTION:
NOT LIKELY TO OCCUR THROUGH NORMAL USE. SHOULD INGESTION OCCUR, SEEK
MEDICAL ATTENTION.
MOST IMPORTANT SYMPTOMS/EFFECTS:
SUSPECTED OF CAUSING CANCER. DIRECT SKIN CONTACT WITH FIBROUS GLASS OR ITS
DUST MAY CAUSE MECHANICAL IRRITATION AND TRANSITORY DERMATITIS. BREATHING
OF FIBERS OR DUST MAY CAUSE MECHANICAL IRRITATION OF THE MOUTH, NOSE, AND
THROAT.
INDICATION OF IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED:
GET MEDICAL ATTENTION IF PRODUCT COMES INTO CONTACT WITH SKIN OR EYES, OR
IF IT IS INHALED OR INGESTED.
| SECTION 5: FIRE-FIGHTING MEASURES | |
EXTINGUISHING MEDIA:
WATER, DRY POWDER, OR FOAM (NEEDED FOR PACKAGING ONLY).
HAZARDOUS COMBUSTION PRODUCTS:
CO, CO2, AND LOW MOLECULAR WEIGHT HYDROCARBONS.
PROTECTIVE EQUIPMENT:
FIREFIGHTERS SHOULD BE EQUIPPED WITH SELF-CONTAINED BREATHING APPARATUS AND
TURN OUT GEAR.
FIRE FIGHTING PROCEDURES/PRECAUTIONS:
FIBERGLASS ITSELF WILL NOT SUPPORT COMBUSTION, BUT IN A SUSTAINED FIRE,
PROPER PROTECTION AGAINST PRODUCTS OF COMBUSTION FROM THE FUEL MUST BE
WORN.
| SECTION 6: ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS:
A RELEASE OF THIS PRODUCT IS NOT EXPECTED TO POSE RISKS TO WORKERS UNDER
NORMAL CIRCUMSTANCES. IF THE MATERIAL IS INVOLVED IN A FIRE, OR IF DUSTS
ARE PRODUCED, NO ACTION SHALL BE TAKEN INVOLVING ANY PERSONAL RISK OR
WITHOUT SUITABLE TRAINING. KEEP UNNECESSARY AND UNPROTECTED PERSONNEL FROM
ENTERING. PUT ON APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT.
PROTECTIVE EQUIPMENT:
WEAR PROTECTIVE GLOVES/EYE PROTECTION/SKIN PROTECTION.
METHODS/MATERIALS FOR CONTAINMENT AND CLEANING UP:
DUST OR LOOSE FIBERS CAN BE VACUUMED OR SWEPT WITH THE AID OF A DUST
SUPPRESSANT. DISPOSE OF IN ACCORDANCE WITH ALL GOVERNMENT REGULATIONS. DO
NOT DISCHARGE INTO WATERWAYS OR SEWER SYSTEMS WITHOUT PROPER AUTHORITY.
| SECTION 7: HANDLING AND STORAGE | |
PRECAUTIONS:
THIS PRODUCT SHOULD BE HANDLED UNDER CONDITIONS OF GOOD INDUSTRIAL HYGIENE
AND IN CONFORMITY WITH ANY LOCAL REGULATIONS TO AVOID UNNECESSARY EXPOSURE.
USE IN A WELL-VENTILATED AREA. DO NOT BREATHE DUST. AVOID CONTACT WITH
SKIN.
STORAGE: STORE IN A WELL-VENTILATED, DRY LOCATION.
| SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION | |
EXPOSURE LIMITS:
COMPONENT CAS OSHA PEL ACGIH TLV
FIBROUS DUST* NONE 5 MG/M3 5 MG/M3
BENTONITE* 1302-78-9 15 MG/M3 (TOTAL) NONE
5 MG/M3 ESTABLISHED
(RESPIRABLE)
CRYSTALLINE SILICA AS QUARTZ* 14808-60-7 10 MG/M3 0.025 MG/M3
(AS PORTION OF BENTONITE) (RESPIRABLE)
*DUST MAY BE PRODUCED DURING HANDLING
ENGINEERING CONTROLS:
NORMAL AREA VENTILATION IS SUFFICIENT IN MOST CASES TO KEEP DUST AND FIBER
LEVELS BELOW THE TLV OR PEL.
PERSONAL PROTECTION MEASURES/EQUIPMENT:
SKIN PROTECTION:
BARRIER CREAMS, GLOVES, AND LONG SLEEVE LOOSE FITTING CLOTHING MAY BE
REQUIRED FOR CERTAIN WORKERS WHO HAVE SENSITIVE SKIN OR CONTACT DERMATITIS.
WORK CLOTHING SHOULD BE LAUNDERED SEPARATELY FROM OTHER CLOTHING BEFORE
REUSE.
EYE PROTECTION:
NOT NORMALLY REQUIRED, BUT AS A GOOD SAFETY WORK PRACTICE, EYE PROTECTION
SUCH AS SAFETY GLASSES/SIDE SHIELDS OR EQUIVALENT WHENEVER USE OF THE
PRODUCT RELEASES AIRBORNE FIBROUS GLASS.
RESPIRATORY PROTECTION:
IF THE USE OR MANUFACTURING OF THIS PRODUCT GENERATES DUST CONCENTRATIONS
ABOVE THE EXPOSURE LIMIT, USE CERTIFIED RESPIRATORS.
OTHER PROTECTION: OBSERVE GOOD PERSONAL HYGIENE.
| SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE (PHYSICAL STATE, COLOR, ETC.): SOLID
ODOR: ODORLESS
ODOR THRESHOLD: NONE
PH: NONE
MELTING POINT/FREEZING POINT: >800 DEG. C (>1472 DEG. F)
INITIAL BOILING POINT: NOT APPLICABLE
FLASH POINT: NOT APPLICABLE
EVAPORATION RATE: NOT APPLICABLE
FLAMMABILITY: NOT APPLICABLE
UPPER/LOWER FLAMMABILITY OR EXPLOSIVE LIMITS: NOT APPLICABLE
VAPOR PRESSURE: NOT APPLICABLE
VAPOR DENSITY: NOT APPLICABLE
RELATIVE DENSITY/SPECIFIC GRAVITY: 2.4 TO 2.7 (GLASS)
SOLUBILITY: INSOLUBLE
PARTITION COEFFICIENT: NOT KNOWN
AUTO-IGNITION TEMPERATURE: NOT KNOWN
DECOMPOSITION TEMPERATURE: NOT KNOWN
VOLATILITY: NOT KNOWN
VISCOSITY: NOT APPLICABLE
| SECTION 10: STABILITY AND REACTIVITY | |
REACTIVITY: NOT SELF-REACTIVE, WATER-REACTIVE, OR SPONTANEOUSLY COMBUSTIBLE
CHEMICAL STABILITY: THIS PRODUCT IS STABLE.
HAZARDOUS REACTIONS:
UNDER NORMAL CONDITIONS OF STORAGE AND USE, HAZARDOUS REACTIONS WILL NOT
OCCUR.
CONDITIONS TO AVOID:
WHEN EXPOSED TO HIGH TEMPERATURES, MAY PRODUCE HAZARDOUS DECOMPOSITION
PRODUCTS.
INCOMPATIBLE MATERIALS: NOT KNOWN
HAZARDOUS DECOMPOSITION PRODUCTS:
FIBERGLASS PRODUCTS MAY RELEASE SMALL AMOUNTS OF ACETIC ACID AND OTHER
ORGANIC MATERIALS AT ELEVATED TEMPERATURES.
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR
| SECTION 11: TOXICOLOGICAL INFORMATION | |
RELEVANT ROUTE OF EXPOSURE/TARGET ORGANS: DERMAL, INHALATION
SYMPTOMS:
SUSPECTED OF CAUSING CANCER. CAUSES MILD SKIN IRRITATION. MAY CAUSE
IRRITATION OR THE MOUTH, NOSE, AND THROAT AFTER INHALATION EXPOSURE.
DELAYED AND IMMEDIATE EFFECTS: NOT KNOWN
CHRONIC EFFECTS (SHORT AND LONG TERM EXPOSURE): NOT KNOWN
NUMERICAL MEASURES OF TOXICITY: NO DATA AVAILABLE
CARCINOGENICITY:
CRYSTALLINE SILICA IS LISTED AS A CLASS 1 CARCINOGEN BY THE IARC AND IS
LISTED AS A CARCINOGEN ACCORDING TO THE NTP.
MUTAGENICITY: NO DATA AVAILABLE
REPRODUCTIVE TOXICITY: NO DATA AVAILABLE
| SECTION 12: ECOLOGICAL INFORMATION | |
NO DATA AVAILABLE
| SECTION 13: DISPOSAL CONSIDERATIONS | |
DO NOT DISCHARGE INTO WATERWAYS OR SEWER SYSTEMS WITHOUT PROPER AUTHORITY.
DISPOSE OF IN ACCORDANCE WITH ALL GOVERNMENT REGULATIONS.
| SECTION 14: TRANSPORT INFORMATION | |
NOT REGULATED AS A HAZARDOUS MATERIAL/DANGEROUS GOOD FOR TRANSPORTATION IN
ALL MODES OF TRANSPORTATION (US DOT, ICAO/IATA, IMO).
| SECTION 15: REGULATORY INFORMATION | |
TSCA INVENTORY STATUS: EXEMPT PER SECTION 8(A), 710.2(F), AND 704.5(A)
SARA TITLE III SECTION 302: NONE
SARA TITLE III SECTION 304: NONE
SARA TITLE III SECTION 311/312 HAZARD CATEGORIES:
IMMEDIATE (ACUTE), DELAYED (CHRONIC)
SARA TITLE III SECTION 313:
THIS PRODUCT DOES NOT CONTAIN COMPONENTS THAT ARE SUBJECT TO THE REPORTING
REQUIREMENTS OF SECTION 313 OF THE EMERGENCY PLANNING AND COMMUNITY RIGHT
TO KNOW ACT OF 1986 (EPCRA OR SARA TITLE III) AND 40 CFR 372.
CERCLA RQ: NOT LISTED
CALIFORNIA PROPOSITION 65:
CRYSTALLINE SILICA IS LISTED AS A CARCINOGEN. NO AIRBORNE, UNBOUND
PARTICLES OF RESPIRABLE SIZE ARE ANTICIPATED TO BE PRODUCED UNDER
ANTICIPATED NORMAL USE CONDITIONS. CAUTION SHOULD BE USED TO PREVENT
THE GENERATION OF AIRBORNE PARTICLES.
MASSACHUSETTS RIGHT-TO-KNOW: LESS THAN REPORTABLE QUANTITY
NEW JERSEY RIGHT-TO-KNOW: LESS THAN REPORTABLE QUANTITY
PENNSYLVANIA RIGHT-TO-KNOW: LESS THAN REPORTABLE QUANTITY
CANADA:
ALL COMPONENTS OF THIS PRODUCT ARE INCLUDED ON THE DOMESTIC SUBSTANCES LIST
(DSL) OR ARE NOT REQUIRED TO BE LISTED ON THE CANADIAN DSL.
EUROPE:
ALL COMPONENTS OF THIS PRODUCT ARE INCLUDED ON THE EUROPEAN INVENTORY OF
EXISTING COMMERCIAL CHEMICAL SUBSTANCES (EINECS) OR ARE NOT REQUIRED TO BE
LISTED ON THE EINECS.
CHINA:
ALL COMPONENTS OF THIS PRODUCT ARE INCLUDED ON THE CHINESE INVENTORY
(IECSC) OR ARE NOT REQUIRED TO BE LISTED ON THE CHINESE IECSC.
JAPAN:
ALL COMPONENTS OF THIS PRODUCT ARE INCLUDED ON THE JAPANESE (ENCS)
INVENTORY OR ARE NOT REQUIRED TO BE LISTED ON THE JAPANESE INVENTORY.
KOREA:
ALL COMPONENTS OF THIS PRODUCT ARE INCLUDED ON THE KOREAN (ECL) INVENTORY
OR ARE NOT REQUIRED TO BE LISTED ON THE KOREAN ECL.
PHILIPPINES:
ALL COMPONENTS OF THIS PRODUCT ARE INCLUDED ON THE PHILIPPINE (PICCS) OR
ARE NOT REQUIRED TO BE LISTED ON THE PHILIPPINE PICCS.
AUSTRALIA:
ALL COMPONENTS OF THIS PRODUCT ARE INCLUDED ON THE AUSTRALIAN (AICS) OR ARE
NOT REQUIRED TO BE LISTED ON THE AUSTRALIAN AICS.
| SECTION 16: OTHER INFORMATION | |
DATE OF PREPARATION OR REVISION: 6/10/2015
THIS PRODUCT IS CLASSIFIED AS A SKIN IRRITANT CATEGORY 3, HOWEVER OSHA DOES
NOT INCLUDE CATEGORY 3 SUBSTANCES IN ITS HAZARD CLASSIFICATION SYSTEM.
ABBREVIATIONS:
ACGIH/TLV:
AMERICAN CONFERENCE OF INDUSTRIAL HYGIENISTS THRESHOLD LIMIT VALUE
CAS: CHEMICAL ABSTRACTS SERVICE
CERCLA: COMPREHENSIVE ENVIRONMENTAL RESPONSE COMPENSATION AND LIABILITY ACT
CFR US: CODE OF FEDERAL REGULATIONS
CO: CARBON MONOXIDE
CO2: CARBON DIOXIDE
DOT: US DEPARTMENT OF TRANSPORTATION
EPCRA: EMERGENCY PLANNING AND COMMUNITY RIGHT TO KNOW ACT
GHS: UN GLOBALLY HARMONIZED SYSTEM OF CLASSIFICATION
HCS: HAZARD COMMUNICATION STANDARD
IARC: INTERNATIONAL AGENCY FOR RESEARCH ON CANCER
ICAO/IATA:
INTERNATIONAL CIVIL AVIATION ORGANIZATION/INTERNATIONAL AIR TRANSPORT
ASSOCIATION
IMO/IMDG:
INTERNATIONAL MARITIME ORGANIZATION/INTERNATIONAL MARITIME DANGEROUS GOODS
CODE
NTP: NATIONAL TOXICOLOGY PROGRAM
OSHA: US OCCUPATIONAL SAFETY HEALTH ADMINISTRATION
PEL: PERMISSIBLE EXPOSURE LIMIT
RQ: REPORTABLE QUANTITY
SARA: SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT
SDS: SAFETY DATA SHEET
TSCA: TOXIC SUBSTANCES CONTROL ACT
UN: UNITED NATIONS
US/USA: UNITED STATES
WHILE THIS COMPANY BELIEVES THAT THE DATA CONTAINED HEREIN ARE FACTUAL AND
THE OPINIONS EXPRESSED ARE BASED ON TESTS AND DATA BELIEVED TO BE RELIABLE,
IT IS THE USER'S RESPONSIBILITY TO DETERMINE THE SAFETY, TOXICITY, AND
SUITABILITY FOR HIS OR HER OWN USE OF THE PRODUCT DESCRIBED HEREIN. SINCE
THE ACTUAL USE BY OTHERS IS BEYOND OUR CONTROL, NO GUARANTEE, EXPRESSED OR
IMPLIED, IS MADE BY THIS COMPANY AS TO THE EFFECTS OF SUCH USE, THE RESULTS
TO BE OBTAINED, OR THE SAFETY AND TOXICITY OF THE PRODUCT, NOR DOES THIS
COMPANY ASSUME ANY LIABILITY ARISING OUT OF USE, BY OTHERS, OF THE PRODUCT
REFERRED TO HEREIN. NOR IS THE INFORMATION HEREIN TO BE CONSTRUED AS
ABSOLUTELY COMPLETE SINCE ADDITIONAL INFORMATION MAY BE NECESSARY OR
DESIRABLE WHEN PARTICULAR OR EXCEPTIONAL CONDITIONS OR CIRCUMSTANCES EXIST
OR BECAUSE OF APPLICABLE LAWS OR GOVERNMENTAL REGULATIONS.
WARNING!
IF YOU SCRAPE, SAND OR REMOVE OLD PAINT, YOU MAY RELEASE LEAD DUST. LEAD IS
TOXIC. EXPOSURE TO LEAD DUST CAN CAUSE SERIOUS ILLNESS, SUCH AS BRAIN
DAMAGE, ESPECIALLY IN CHILDREN. PREGNANT WOMEN SHOULD ALSO AVOID EXPOSURE.
WEAR NIOSH-APPROVED RESPIRATOR TO CONTROL LEAD EXPOSURE. CLEAN UP CAREFULLY
WITH A HEPA VACUUM AND WET MOP. BEFORE YOU START, FIND OUT HOW TO PROTECT
YOURSELF AND YOUR FAMILY BY CONTACTING THE NATIONAL LEAD INFORMATION
HOTLINE AT 1-800-424-LEAD (5323) OR LOG ON TO: WWW.EPA.GOV/LEAD