| Common Name: | STEEL RED LAYOUT FLUID |
| Manufacturer: | ITW DYKEM |
| SDS Revision Date: | 9/4/2006 |
| SDS Format: | No Format Specified |
| Item Number(s): | 2C933 |
| Manufacturer Model Number(s): | 80096 |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
MATERIAL SAFETY DATA SHEET
ITW DYKEM(R*)
HMIS(R*):
HEALTH 2
FLAMMABILITY 3
REACTIVITY 1
PERSONAL PROTECTION B
| SECTION 1 CHEMICAL PRODUCT AND COMPANY IDENTIFICATION |  |
IDENTITY: STEEL RED LAYOUT FLUID
ITEM NO.: 80096
FORMULA: 8704A
PRODUCT CLASS: LAYOUT FLUIDS
ANOTHER EXCLUSIVE PRODUCT OF: ITW DYKEM
ADDRESS (NUMBER, STREET, CITY, STATE, AND ZIP CODE):
805 EAST OLD 56 HIGHWAY
OLATHE, KS 66061-4914
EMERGENCY TELEPHONE NUMBER:
1-800-535-5053 (DOMESTIC)
1-352-323-3500 (INTERNATIONAL)
TELEPHONE NUMBER FOR INFORMATION: 1-800-443-9536 OR 1-913-397-9889
NOTE:
BLANK SPACES ARE NOT PERMITTED. IF ANY ITEM IS NOT APPLICABLE, OR NO
INFORMATION IS AVAILABLE, THE SPACE MUST BE MARKED TO INDICATE THAT.
DATE PREPARED: 9/4/06
SIGNATURE OF PREPARER (OPTIONAL): REGULATORY DEPT.
| SECTION 2 COMPOSITION/INFORMATION ON INGREDIENTS | |
HAZARDOUS COMPONENTS CAS NO. OSHA PEL ACGIH-TLV
(SPECIFIC CHEMICAL IDENTITY,
COMMON NAME(S)
ETHANOL 64-17-5 TWA 1000 PPM TWA 1000 PPM
BUTYL ACETATE 123-86-4 TWA 150 PPM TWA 150 PPM
BUTANOL 71-36-3 TWA 50 PPM TWA 50 PPM
PROPANE 74-98-6 TWA 1000 PPM TWA 1000 PPM
N-BUTANE 106-97-8 TWA 800 PPM TWA 800 PPM
NITROCELLULOSE 9004-70-0 NO DATA NO DATA
n-PROPYL ACETATE 109-60-4 TWA 200 PPM TWA 200 PPM
ISOPROPANOL 67-63-0 TWA 400 PPM TWA 400 PPM
DIACETONE ALCOHOL 123-42-2 TWA 50 PPM TWA 50 PPM
C.I. SOLVENT RED 49 509-34-2 TWA 50 PPM TWA 50 PPM
C.I. SOLVENT RED 68 NO DATA NO DATA NO DATA
HAZARDOUS COMPONENTS OTHER LIMITS %(OPT.)
(SPECIFIC CHEMICAL IDENTITY, RECOMMENDED
COMMON NAME(S)
ETHANOL NO DATA 30 - 50
BUTYL ACETATE NO DATA 20 - 30
BUTANOL NO DATA 10 - 20
PROPANE NO DATA 5 - 15
n-BUTANE NO DATA 5 - 15
NITROCELLULOSE NO DATA 1 - 10
n-PROPYL ACETATE NO DATA 1 - 10
ISOPROPANOL NO DATA 1 - 10
DIACETONE ALCOHOL NO DATA 1 - 10
C.I. SOLVENT RED 49 NO DATA 1 - 10
C.I. SOLVENT RED 68 NO DATA 1 - 10
| SECTION 3 HAZARDS IDENTIFICATION | |
EMERGENCY OVERVIEW:
RED THIN VISCOSITY LIQUID WITH SWEET SOLVENT ODOR.
WARNING!
FLAMMABLE LIQUID AND VAPOR.
KEEP AWAY FROM HEAT SPARKS AND FLAMES. MAY CAUSE EYE, SKIN AND RESPIRATORY
TRACT IRRITATION. IF SWALLOWED DO NOT INDUCE VOMITING. GET IMMEDIATE MEDICAL
ATTENTION.
POTENTIAL HEALTH EFFECTS:
EYES: LIQUID IS MODERATELY IRRITATING TO THE EYES.
SKIN: LIQUID IS MILDLY IRRITATING TO THE SKIN.
INGESTION: INGESTION OF LIQUID MAY CAUSE VOMITING.
INHALATION:
HIGH CONCENTRATION OF VAPORS MAY PRODUCE IRRITATION OF THE RESPIRATORY
TRACT, HEADACHE, DIZZINESS, AND NAUSEA.
CHRONIC HEALTH EFFECTS:
PROLONGED OR REPEATED CONTACT MAY CAUSE SKIN SENSITIZATION OR DERMATITIS.
REPORTS HAVE ASSOCIATED REPEATED AND PROLONGED OCCUPATIONAL OVEREXPOSURE TO
SOLVENTS WITH IRREVERSIBLE BRAIN AND NERVOUS SYSTEM DAMAGE. INTENTIONAL
MISUSE BY DELIBERATELY CONCENTRATING OR INHALING THIS PRODUCT MAY BE HARMFUL
OR FATAL.
| SECTION 4 FIRST AID MEASURES | |
EYES:
IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES. GET
MEDICAL ATTENTION IMMEDIATELY.
INHALATION:
REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE ARTIFICIAL RESPIRATION. IF
BREATHING IS DIFFICULT, GIVE OXYGEN. GET MEDICAL ATTENTION IMMEDIATELY.
SKIN:
FLUSH SKIN WITH PLENTY OF WATER. REMOVE CONTAMINATED CLOTHING AND SHOES.
INGESTION:
IF LARGE QUANTITIES OF THIS MATERIAL ARE SWALLOWED, GET IMMEDIATE MEDICAL
ATTENTION. DO NOT INDUCE VOMITING. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON.
| SECTION 5 FIRE FIGHTING MEASURES | |
FLASH POINT (METHOD USED): -156 DEG. F (PROPELLANT)
PRODUCT HAS A FLASH POINT OF 53 DEG. F
FLAMMABLE LIMITS:
LEL: 1.40
UEL: 19.0
EXTINGUISHING MEDIA:
USE WATER FOG, FOAM, DRY CHEMICAL OR CO2. USE WATER SPRAY TO COOL
FIRE-EXPOSED CONTAINERS AND TO PROTECT PERSONNEL.
SPECIAL FIRE FIGHTING PROCEDURES:
KEEP CONTAINERS COOL AND VAPORS DOWN WITH WATER SPRAY. PREVENT SPILL FROM
ENTERING DRAINS, SEWERS, STREAMS OR OTHER BODIES OF WATER. IF RUN-OFF
OCCURS, NOTIFY PROPER AUTHORITIES. DO NOT ENTER CONFINED FIRE SPACE WITHOUT
FULL BUNKER GEAR (HELMET WITH FACE SHIELD, BUNKER COATS, GLOVES AND RUBBER
BOOTS), INCLUDING A POSITIVE PRESSURE NIOSH APPROVED SELF-CONTAINED
BREATHING APPARATUS.
UNUSUAL FIRE AND EXPLOSION HAZARDS:
VAPORS ARE HEAVIER THAN AIR AND MAY TRAVEL ALONG GROUND, OR BE MOVED BY
VENTILATION AND BE IGNITED BY IGNITION SOURCE.
| SECTION 6 ACCIDENTAL RELEASE MEASURES | |
SMALL SPILL:
ABSORB LIQUID WITH NON-COMBUSTIBLE FLOOR ABSORBENT AND PLACE IN NON-LEAKING
CONTAINER; SEAL PROPERLY AND DISPOSE OF PROPERLY IN COMPLIANCE WITH FEDERAL,
STATE, AND LOCAL REGULATIONS.
LARGE SPILL:
EVACUATE AREA OF UNPROTECTED PERSONNEL. ELIMINATE ALL IGNITION SOURCES. STOP
SPILL AT SOURCE IF SAFE TO DO SO. HANDLING EQUIPMENT MUST BE GROUNDED TO
PREVENT SPARKING. PREVENT SPILL FROM ENTERING DRAINS, SEWERS, STREAMS OR
OTHER BODIES OF WATER. IF RUN-OFF OCCURS, NOTIFY PROPER AUTHORITIES. PUMP OR
VACUUM TRANSFER SPILLED PRODUCT TO CLEAN CONTAINERS FOR RECOVERY. ABSORB
UNRECOVERABLE PRODUCT. TRANSFER CONTAMINATED ABSORBENT, SOIL AND OTHER
MATERIALS TO CONTAINERS FOR DISPOSAL. DISPOSE OF PROPERLY IN COMPLIANCE WITH
FEDERAL, STATE, AND LOCAL REGULATIONS.
| SECTION 7 HANDLING AND STORAGE | |
HANDLING:
EMPTY CONTAINERS RETAIN RESIDUE (LIQUID AND/OR VAPOR) AND CAN BE DANGEROUS.
DO NOT PRESSURIZE, CUT, WELD, BRAZE, SOLDER, DRILL, GRIND, OR EXPOSE SUCH
CONTAINERS TO HEAT, SPARKS, FLAMES, STATIC ELECTRICITY, OR OTHER SOURCES OF
IGNITION. MANY HOT ORGANIC CHEMICAL VAPORS OR MISTS ARE SUSCEPTIBLE TO
SUDDEN SPONTANEOUS COMBUSTION WHEN MIXED WITH AIR. IGNITION MAY OCCUR AT
TEMPERATURES BELOW THOSE PUBLISHED IN THE LITERATURE AS "AUTOIGNITION" OR
IGNITION TEMPERATURES. IGNITION TEMPERATURES DECREASE WITH INCREASING VAPOR
VOLUME AND VAPOR VOLUME AND VAPOR/AIR CONTACT TIME, AND ARE INFLUENCED BY
PRESSURE CHANGES. IGNITION OF ORGANIC CHEMICAL VAPORS MAY OCCUR AT TYPICAL
ELEVATED-TEMPERATURE PROCESS CONDITIONS, ESPECIALLY IN PROCESSES OPERATING
UNDER VACUUM IF SUBJECTED TO SUDDEN INCREASE OF AIR, OR OUTSIDE PROCESS
EQUIPMENT OPERATING UNDER ELEVATED PRESSURE IF SUDDEN ESCAPE OF VAPORS OR
MISTS TO THE ATMOSPHERE OCCURS. ANY PROPOSED USE OF THIS PRODUCT IN
ELEVATED-TEMPERATURE PROCESSES SHOULD BE THOROUGHLY EVALUATED TO ASSURE THAT
SAFE OPERATING CONDITIONS ARE ESTABLISHED AND MAINTAINED.
STORAGE:
CONTENTS UNDER PRESSURE. KEEP AWAY FROM HEAT, SPARKS AND OPEN FLAMES. KEEP
OUT OF REACH OF CHILDREN. KEEP CONTAINER TIGHTLY SEALED WHEN NOT IN USE.
STORE IN COOL, WELL-VENTILATED PLACE AWAY FROM INCOMPATIBLE MATERIALS.
| SECTION 8 EXPOSURE CONTROLS/PERSONAL PROTECTION | |
RESPIRATORY PROTECTION (SPECIFY TYPE):
NOT USUALLY NECESSARY. USE WITH ADEQUATE VENTILATION. USE NIOSH/MSHA
APPROVED RESPIRATOR IF PELS OR TLVS ARE EXCEEDED.
ENGINEERING CONTROLS:
LOCAL EXHAUST: NOT USUALLY NEEDED
MECHANICAL (GENERAL): YES
SPECIAL: NONE
OTHER: NONE
PROTECTIVE GLOVES:
CHEMICAL RESISTANT GLOVES IF SKIN CONTACT IS POSSIBLE (CONSULT YOUR SAFETY
EQUIPMENT SUPPLIER).
EYE PROTECTION:
NOT NORMALLY REQUIRED IF USED AS INTENDED. WEAR CHEMICAL SPLASH GOGGLES IN
COMPLIANCE WITH OSHA REGULATION IF SPLASHING IS POSSIBLE.
OTHER PROTECTIVE CLOTHING OR EQUIPMENT:
NOT USUALLY NECESSARY. FOR BULK MATERIAL, IF DIRECT CONTACT IS POSSIBLE,
WEAR APRON, BOOTS, FACE SHIELD, ETC. AS NEEDED.
WORK/HYGIENIC PRACTICES:
FOLLOW LABEL INSTRUCTIONS. WASH HANDS AFTER USE AND BEFORE EATING, DRINKING,
SMOKING, USING RESTROOMS, ETC.
| SECTION 9 PHYSICAL AND CHEMICAL PROPERTIES | |
BOILING POINT: 170 DEG. F - 257 DEG. F
VAPOR PRESSURE (MM-Hg @ 70 DEG. F): NO DATA
VAPOR DENSITY (AIR = 1): GREATER THAN ONE (1)
SOLUBILITY IN WATER: NEGLIGIBLE
SPECIFIC GRAVITY (H2O = 1) @ 70 DEG. F: 0.85
MELTING POINT: NO DATA
EVAPORATION RATE (BUTYL ACETATE = 1): GREATER THAN (1)
pH: NO DATA
APPEARANCE AND ODOR: RED THIN VISCOSITY LIQUID WITH SWEET SOLVENT ODOR.
VOC: THIS PRODUCT CONTAINS 797 GRAMS PER LITER OR 93.89% BY WEIGHT VOC'S.
| SECTION 10 STABILITY AND REACTIVITY | |
CHEMICAL STABILITY:
UNSTABLE ( )
STABLE (X)
CONDITIONS TO AVOID: NONE KNOWN.
INCOMPATIBILITY (MATERIALS TO AVOID):
STRONG OXIDIZING AND REDUCING AGENTS, STRONG ALKALIES AND STRONG ACIDS.
HAZARDOUS DECOMPOSITION OR BYPRODUCTS:
CARBON DIOXIDE, CARBON MONOXIDE, SMOKE, SOOT AND VARIOUS ORGANIC OXIDATION
BY-PRODUCTS.
HAZARDOUS POLYMERIZATION:
MAY OCCUR ( )
WILL NOT OCCUR (X)
CONDITIONS TO AVOID: NO DATA
| SECTION 11 TOXICOLOGICAL INFORMATION | |
ORAL LD50 DERMAL LD50 INHALATION LC50
(RAT) (RABBIT) (RAT)
ETHANOL 7060 MG/KG NO DATA 20000 PPM/10H
BUTYL ACETATE 14 G/KG NO DATA NO DATA
BUTANOL 2500 MG/KG SLIGHT >8000 PPM/4H
NITROCELLULOSE >5000 MG/KG NO DATA NO DATA
ISOPROPANOL 5045 MG/KG NO DATA NO DATA
PLEASE REFER TO SECTION 3 FOR AVAILABLE INFORMATION ON POTENTIAL HEALTH
EFFECTS.
| SECTION 12 ECOLOGICAL INFORMATION | |
NO SPECIFIC ECOLOGICAL DATA ARE AVAILABLE FOR THIS PRODUCT. PLEASE REFER TO
SECTION 6 FOR INFORMATION REGARDING ACCIDENTAL RELEASES AND SECTION 15 FOR
REGULATORY REPORTING INFORMATION.
| SECTION 13 DISPOSAL CONSIDERATIONS | |
DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE LOCAL, STATE AND FEDERAL
REGULATIONS.
| SECTION 14 TRANSPORT INFORMATION | |
(NOT MEANT TO BE ALL INCLUSIVE)
DOMESTIC HIGHWAY (CONTAINERS <1 QUART ARE ORM-D):
PROPER SHIPPING NAME: NO DATA
HAZARD CLASS/SUBSIDIARY HAZARD: CONSUMER COMMODITY ORM-D
UN/NA NO.: NO DATA
PACKING GROUP: NO DATA
LABEL REQUIRED: NO DATA
DOMESTIC AIR SHIPMENTS: VARIES
PROPER SHIPPING NAME: NO DATA
HAZARD CLASS/SUBSIDIARY HAZARD: NO DATA
UN/NA NO.: NO DATA
PACKING GROUP: NO DATA
LABEL REQUIRED: NO DATA
| SECTION 15 REGULATORY INFORMATION | |
(NOT MEANT TO BE ALL INCLUSIVE - SELECTED REGULATIONS REPRESENTED)
U.S. FEDERAL REGULATIONS:
TSCA: COMPONENTS OF THIS PRODUCT ARE LISTED ON THE TSCA INVENTORY.
CARCINOGENICITY:
NTP?: NO
IARC MONOGRAPHS?: NO
OSHA REGULATED?: NO
OSHA:
HAZARDOUS BY DEFINITION OF HAZARD COMMUNICATION STANDARD (29 CFR 1910.1200).
SECTION 313:
THIS PRODUCT CONTAINS BUTANOL (71-36-3) WHICH IS LISTED AND MAY REQUIRE
REPORTING UNDER SARA TITLE III SEC. 313 IF USED OVER THE THRESHOLD REPORTING
QUANTITY. THIS INFORMATION MUST BE INCLUDED IN ALL MSDSS THAT ARE COPIED AND
DISTRIBUTED FOR THIS MATERIAL.
STATE REGULATIONS:
CALIFORNIA PROPOSITION 65:
THIS PRODUCT IS NOT KNOWN TO CONTAIN ANY MATERIAL LISTED UNDER CALIFORNIA'S
PROPOSITION 65.
| SECTION 16 OTHER INFORMATION | |
MSDS STATUS:
REVISED SECTION(S): 4/14/04 FLASH POINT DATA UPDATED.
WARNING!
THE USE OF THIS PRODUCT IS BEYOND THE CONTROL OF THE MANUFACTURER AND
DISTRIBUTOR; THEREFORE, NO GUARANTEE, EXPRESSED OR IMPLIED, IS MADE AS TO
THE EFFECTS OF SUCH OR THE RESULTS TO BE OBTAINED IF NOT USED IN ACCORDANCE
WITH DIRECTIONS OR ESTABLISHED SAFE PRACTICE. THE USER MUST ASSUME ALL
RESPONSIBILITY, INCLUDING INJURY OR DAMAGE, RESULTING FROM ITS MISUSE AS
SUCH, OR IN COMBINATION WITH OTHER MATERIALS. THE MANUFACTURER AND
DISTRIBUTOR WARRANT ONLY THAT THIS PRODUCT MEETS THE SPECIFICATIONS FOR SUCH
PRODUCT. THIS WARRANTY IS IN LIEU OF ALL OTHER WARRANTIES, EXPRESS OR
IMPLIED, AS TO DESCRIPTION, QUALITY, MERCHANTABILITY, FITNESS FOR ANY
PARTICULAR PURPOSE, PRODUCTIVENESS, OR ANY OTHER MATTER OF THIS PRODUCT. THE
MANUFACTURER AND DISTRIBUTOR SHALL BE IN NO WAY RESPONSIBLE FOR THE PROPER
USE OF THIS PRODUCT. THE SOLE AND EXCLUSIVE REMEDY AGAINST THE MANUFACTURER
AND DISTRIBUTOR FOR BREACH OF WARRANTY SHALL BE REIMBURSEMENT OF THE
PURCHASE PRICE OF THE PRODUCT IN THE EVENT THAT A DEFECTIVE CONDITION OF THE
PRODUCT SHALL BE FOUND TO EXIST. NO OTHER REMEDY (INCLUDING BUT NOT LIMITED
TO INCIDENTAL OR CONSEQUENTIAL DAMAGES FOR INJURY TO PERSON OR PROPERTY OR
ANY OTHER INCIDENTAL OR CONSEQUENTIAL LOSS) SHALL BE AVAILABLE.