| Common Name: | TOUGH GUY CITRUS FOAMING OVEN CLEANER |
| Manufacturer: | W.W. GRAINGER |
| SDS Revision Date: | 8/30/2007 |
| SDS Format: | No Format Specified |
| Item Number(s): | 2DBX5 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
MATERIAL SAFETY DATA SHEET
HMIS(R*):
HEALTH 3
FLAMMABILITY 1
REACTIVITY 1
PERSONAL PROTECTION B
IDENTITY: TOUGH GUY CITRUS FOAMING OVEN CLEANER
PART NUMBER: 2DBX5
NOTE:
BLANK SPACES ARE NOT PERMITTED. IF ANY ITEM IS NOT APPLICABLE, OR NO
INFORMATION IS AVAILABLE, THE SPACE MUST BE MARKED TO INDICATE THAT.
| SECTION 1: COMPANY IDENTIFICATION |  |
MANUFACTURED FOR: W.W. GRAINGER, INC.
ADDRESS (NUMBER, STREET, CITY, STATE, AND ZIP CODE):
100 GRAINGER PARKWAY
LAKE FOREST, IL 60045
EMERGENCY TELEPHONE NUMBER: 1-800-228-5635
TELEPHONE NUMBER FOR INFORMATION: 1-847-535-5400
SIGNATURE OF PREPARER (OPTIONAL):
| SECTION 2: INGREDIENTS/IDENTITY INFORMATION | |
COMPONENTS CAS NO. OSHA ACGIH- OTHER LIMITS %
(CHEMICAL IDENTITY, PEL TLV RECOMMENDED (OPT.)
COMMON NAME(S))
WATER 7732-18-5 NONE NONE 60 - 100%
POTASSIUM 1310-58-3 NONE NONE 2 MG/M3 7 - 13%
HYDROXIDE (CEILING)
BUTOXYLDIGLYCOL 112-34-5 NONE NONE 3 - 7%
ISOBUTANE 75-28-5 800 800 3 - 7%
PPM PPM
D'LIMONENE 5989-27-5 NONE NONE 30 PPM 1 - 5%
(R-P-MENTHA-1, (MANU.)
8-DIENE)
PROPANE 74-98-6 1000 2500 0.5 - 1.5%
PPM PPM
ANY SUBSTANCE LISTED AS HAZARDOUS BY THE STATES OF CALIFORNIA, FLORIDA,
ILLINOIS, MICHIGAN, NEW JERSEY, OHIO, PENNSYLVANIA OR TEXAS IS DESCRIBED
ABOVE IF KNOWN PRESENT IN REGULATED CONCENTRATIONS.
| SECTION 3: HAZARDS IDENTIFICATION | |
ROUTE(S) OF ENTRY:
EYES?: YES
INHALATION?: YES
SKIN?: YES
INGESTION?: YES
ACUTE HEALTH HAZARDS:
DANGER:
CORROSIVE (CONTAINS POTASSIUM HYDROXIDE). MAY BE HARMFUL OR FATAL IF
SWALLOWED. CAUSES BURNS TO EYES AND SKIN WITH DIRECT CONTACT. MAY CAUSE
RESPIRATORY TRACT IRRITATION. USE PROPER CHEMICAL HYGIENE TO AVOID THESE
HAZARDS.
CHRONIC HEALTH HAZARDS: NONE KNOWN
CARCINOGENICITY:
CHEMICAL: NONE
OSHA: NO
NTP: NO
IARC: NO
SIGNS AND SYMPTOMS OF EXPOSURE:
BURNING OR TEARING IN EYES. IRRITATION OF NOSE AND THROAT. REDNESS,
IRRITATION OR SLICK FEELING ON SKIN. NAUSEA, LOSS OF COORDINATION, FATIGUE
MAY OCCUR FROM EXCESSIVE INHALATION OF FUMES.
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE:
PRE-EXISTING SKIN AND LUNG DISORDERS (I.E. - ASTHMA) CAN BE EFFECTED BY
PROLONGED OR REPEATED OCCUPATIONAL OVEREXPOSURE.
| SECTION 4: EMERGENCY AND FIRST AID PROCEDURES | |
EYES:
IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES LIFTING
EYELIDS TO INSURE COMPLETE REMOVAL. GET IMMEDIATE MEDICAL ATTENTION.
INGESTION:
CALL A PHYSICIAN OR POISON CONTROL CENTER IMMEDIATELY. DO NOT INDUCE
VOMITING UNLESS DIRECTED BY A PHYSICIAN. RINSE OUT MOUTH WITH WATER.
IF CONSCIOUS, GIVE LARGE QUANTITIES OF WATER AND SEEK IMMEDIATE MEDICAL
ATTENTION. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
INHALATION:
GET TO FRESH AIR. IF BREATHING HAS STOPPED, QUALIFIED PERSONNEL SHOULD
ADMINISTER ARTIFICIAL RESPIRATION.
SKIN:
FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES. IF IRRITATION ARISES
AND PERSISTS, SEEK MEDICAL ATTENTION.
| SECTION 5: FIRE FIGHTING MEASURES | |
USA FLAME PROJECTION TEST: 0" (EXTINGUISHES FLAME) NON-FLAMMABLE
FLAMMABLE LIMITS: NO DATA
LEL: NO DATA
UEL: NO DATA
EXTINGUISHING MEDIA:
NOT USUALLY NECESSARY AS THIS PRODUCT DOES NOT READILY SUPPORT COMBUSTION.
USE EXTINGUISHING AGENT SUITABLE TO FUEL SOURCE.
SPECIAL FIRE FIGHTING PROCEDURES:
KEEP CONTAINERS COOL AND VAPORS DOWN WITH WATER SPRAY. PREVENT RUNOFF
FROM ENTERING SEWERS AND PUBLIC WATERWAYS. WEAR SCBA IN CHEMICAL FIRES.
HAZARDOUS PRODUCTS OF COMBUSTION:
CARBON DIOXIDE, CARBON MONOXIDE, OXIDES OF SILICON AND NITROGEN, AND
HYDROGEN.
UNUSUAL FIRE AND EXPLOSION HAZARDS:
AEROSOL CONTAINER (PRESSURIZED) MAY BURST IF HEATED OVER 120 DEG. F.
CORROSIVE CONTENTS.
| SECTION 6: ACCIDENTAL RELEASE MEASURES | |
SMALL SPILL:
WIPE UP SMALL RELEASES WITH A DRY ABSORBENT CLOTH OR OTHER ABSORBENT
MATERIAL.
LARGE SPILL:
ABSORB LIQUID WITH VERMICULITE, ABSORBENT CLOTH, OR OTHER ABSORBENT
MATERIAL. PREVENT MATERIAL FROM ENTERING SEWERS OR DRAINS. VENTILATE AREA
AND BLOCK TRAFFIC. TRANSFER CONTAMINATED MATERIAL INTO SUITABLE CONTAINER
FOR PROPER DISPOSAL.
| SECTION 7: HANDLING AND STORAGE | |
HANDLING:
DO NOT GET IN EYES, ON SKIN OR CLOTHING. DO NOT SWALLOW. DO NOT INHALE
MIST OR VAPORS. DO NOT DELIBERATELY CONCENTRATE AND INHALE VAPORS. LAUNDER
CONTAMINATED CLOTHING BEFORE REUSE. DIRECT SPRAY AWAY FROM FACE. DO NOT USE
IN OR AROUND IGNITION SOURCES SUCH AS HEAT, SPARKS, OPEN FLAME, ETC.
STORAGE:
FOLLOW LABEL DIRECTIONS CAREFULLY. KEEP OUT OF REACH OF CHILDREN. STORE
IN A COOL (UNDER 120 DEG. F) DRY LOCATION AWAY FROM HEAT, SPARKS, OPEN
FLAME, AND DIRECT SUNLIGHT. REPLACE CAP WHEN NOT IN USE.
| SECTION 8: EXPOSURE CONTROLS / PERSONAL PROTECTION | |
EYE PROTECTION: YES, SAFETY GLASSES OR GOGGLES (ANSI Z87).
SKIN PROTECTION: YES, IMPERVIOUS.
RESPIRATORY PROTECTIONS:
NOT USUALLY NECESSARY. USE WITH ADEQUATE VENTILATION. USE NIOSH/MSHA
APPROVED RESPIRATOR IF PELS OR TLVS ARE EXCEEDED.
ENGINEERING CONTROLS:
VENTILATION NOT USUALLY NECESSARY BUT SHOULD BE PROVIDED IN THE EVENT OF
OVEREXPOSURE.
| SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE AND ODOR:
VISCOUS TAN LIQUID WITH A CITRUS SCENT IN AN AEROSOL CAN.
pH: 13.5 +/- 0.5
SPECIFIC GRAVITY (70 DEG. F): 1.040
BOILING POINT: 212 DEG. F
MELTING POINT: NO DATA
EVAPORATION RATE (BUTYL ACETATE = 1): NO DATA
PRESSURE (PSIG. @ 70 DEG. F): 60 +/- 10
VAPOR DENSITY (AIR = 1): >1
SOLUBILITY IN WATER: COMPLETE
VOLATILE ORGANIC COMPOUNDS (VOCS):
78.5 GRAMS PER LITER OR 7.9% BY WEIGHT VOCS
| SECTION 10: STABILITY AND REACTIVITY | |
HAZARDOUS POLYMERIZATION:
THIS PRODUCT WILL NOT UNDERGO HAZARDOUS POLYMERIZATION.
HAZARDOUS DECOMPOSITION OR BYPRODUCTS:
CARBON DIOXIDE, CARBON MONOXIDE, OXIDES OF SILICON AND NITROGEN, AND
HYDROGEN.
CHEMICAL STABILITY: STABLE
INCOMPATIBILITY (MATERIALS TO AVOID):
STRONG ACIDS, REDUCING AND OXIDIZING AGENTS; ACRYLONITRILE, CHLORINATED
HYDROCARBONS, CHLORINE DIOXIDE, MALEIC ANHYDRIDE, NITROETHANE,
NITROPARAFFINS, 2-NITROPHENOL, NITROPROPANE, PHOSPHORUS, POTASSIUM
PERSULFATE, TETRAHYDROFURAN AND HYDROXYL COMPOUNDS.
| SECTION 11: TOXICOLOGICAL INFORMATION | |
NO DATA
| SECTION 12: ECOLOGICAL INFORMATION | |
NO DATA
| SECTION 13: DISPOSAL CONSIDERATION | |
DISPOSAL METHOD:
DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE LOCAL, STATE, AND FEDERAL
REGULATIONS.
RCRA WASTE INFORMATION:
IF THIS PRODUCT BECOMES A WASTE, IT WOULD BE A HAZARDOUS WASTE (D002) AS
DEFINED BY RCRA (40 CFR 261). HOWEVER THE WASTE SHOULD BE PROPERLY
CHARACTERIZED TO EVALUATE WHETHER ITS COMPOSITION HAS BEEN MODIFIED PRIOR
TO DISPOSAL.
| SECTION 14: TRANSPORT INFORMATION | |
DOT INFORMATION - 49 CFR 172.101:
PROPER SHIPPING DESCRIPTION: CONSUMER COMMODITY
HAZARD CLASS: ORM-D
IDENTIFICATION NUMBER: NONE
PACKING GROUP: NONE
WATER TRANSPORTATION:
PROPER SHIPPING DESCRIPTION: AEROSOLS
HAZARD CLASS: 2
IDENTIFICATION NUMBER: UN 1950
PACKING GROUP: NONE
AIR TRANSPORTATION:
PROPER SHIPPING DESCRIPTION: FORBIDDEN IN ALL AIRCRAFT.
HAZARD CLASS: N/A
IDENTIFICATION NUMBER: N/A
PACKING GROUP: N/A
MARINE POLLUTANTS: NONE
| SECTION 15: REGULATORY INFORMATION | |
US FEDERAL REGULATIONS:
TSCA (TOXIC SUBSTANCES CONTROL ACT) STATUS:
ALL INGREDIENTS ARE ON THE TSCA INVENTORY OR ARE NOT REQUIRED TO BE LISTED
ON THE TSCA INVENTORY.
CERCLA RQ - 40 CFR 302.4 (A): NONE LISTED
SARA 313 COMPONENTS - 40 CFR 372.65:
BUTOXYLDIGLYCOL (CAS: 112-34-5) 4.75%
STATE AND LOCAL REGULATIONS:
CALIFORNIA PROPOSITION 65:
WARNING:
THIS PRODUCT CONTAINS TRACE CHEMICALS (ETHYLENE OXIDE AND PROPYLENE OXIDE)
KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER, AND/OR BIRTH DEFECTS OR
OTHER REPRODUCTIVE HARM.
| SECTION 16: ADDITIONAL INFORMATION | |
DATE PREPARED: 08/30/07
WARNING!
THE USE OF THIS PRODUCT IS BEYOND THE CONTROL OF THE MANUFACTURER;
THEREFORE, NO GUARANTEE, EXPRESSED OR IMPLIED, IS MADE AS TO THE EFFECTS
OF SUCH OR THE RESULTS TO BE OBTAINED IF NOT USED IN ACCORDANCE WITH
DIRECTIONS OR ESTABLISHED SAFE PRACTICE. THE USER MUST ASSUME ALL
RESPONSIBILITY, INCLUDING INJURY OR DAMAGE, RESULTING FROM ITS MISUSE AS
SUCH, OR IN COMBINATION WITH OTHER MATERIALS. THE MANUFACTURER WARRANTS
ONLY THAT THIS PRODUCT MEETS THE MANUFACTURER'S SPECIFICATIONS FOR SUCH
PRODUCT. THIS WARRANTY IS IN LIEU OF ALL OTHER WARRANTIES, EXPRESS OR
IMPLIED, AS TO DESCRIPTION, QUALITY, MERCHANTABILITY. FITNESS FOR ANY
PARTICULAR PURPOSE, PRODUCTIVENESS, OR ANY OTHER MATTER, OF THIS PRODUCT.
THE MANUFACTURER SHALL BE IN NO WAY RESPONSIBLE FOR THE IMPROPER USE OF
THIS PRODUCT. THE SOLE AND EXCLUSIVE REMEDY AGAINST THE MANUFACTURER FOR
BREACH OF WARRANTY SHALL BE REIMBURSEMENT OF THE PURCHASE PRICE OF THE
PRODUCT IN THE EVENT THAT A DEFECTIVE CONDITION OF THE PRODUCT SHALL BE
FOUND TO EXIST. NO OTHER REMEDY (INCLUDING BUT NOT LIMITED TO INCIDENTAL
OR CONSEQUENTIAL DAMAGES FOR INJURY TO PERSON OR PROPERTY OR ANY OTHER
INCIDENTAL OR CONSEQUENTIAL LOSS) SHALL BE AVAILABLE.