| Common Name: | ETK ACID TEST KIT |
| Manufacturer: | VIRGINIA KMP |
| SDS Revision Date: | 7/23/2008 |
| SDS Format: | No Format Specified |
| Item Number(s): | 3VJ59 |
| Manufacturer Model Number(s): | ETK |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
ETK ACID TEST KIT
MATERIAL SAFETY DATA SHEET
| SECTION I - COMPANY IDENTIFICATION |  |
PRODUCT: ETK ACID TEST KIT
CAT. NO.: ETK
MANUFACTURED BY:
VIRGINIA KMP CORPORATION
4100 PLATINUM WAY
DALLAS, TEXAS 75237
TELEPHONE NUMBERS:
OFFICE: 1-(214) 330-7731
EMERGENCY ONLY: 1-(800) 424-9300
| SECTION II - HAZARDOUS INGREDIENTS | |
OSHA HAZARDOUS COMPONENTS EXPOSURE LIMITS: 8 HR. TWA
(29 CFR 1910.1200) OSHA PEL ACGIH TLV
TOLUENE 100 PPM 100 PPM
(CAS#: 108-88-3)
CL: 300 PPM
PK:
500 PPM / 10 MIN / 8 HR SHIFT
STEL: 150 PPM STEL: 150 PPM
ETHYL ALCOHOL 1000 PPM 1000 PPM
(64-17-5)
| SECTION III - HAZARDS IDENTIFICATIONS | |
EMERGENCY OVERVIEW:
DANGER!
FLAMMABLE LIQUID. INHALATION MAY CAUSE SEVERE NARCOTIC EFFECTS.
POTENTIAL HEALTH EFFECTS:
INHALATION:
CAUSES IRRITATION OF RESPIRATORY TRACT, NERVOUS SYSTEM DEPRESSION,
HEADACHES, DIZZINESS, STAGGERING GAIT, CONFUSION, UNCONSCIOUSNESS AND
COMA. ASPIRATION CAUSES RAPIDLY DEVELOPING PULMONARY EDEMA.
EYE CONTACT:
IRRITATION DEVELOPS IMMEDIATELY AFTER CONTACT WITH LIQUID OR VAPOR.
SKIN CONTACT:
IRRITATION DEVELOPS AFTER PROLONGED CONTACT WITH LIQUID OR VAPOR.
AGGRAVATES PRE-EXISTING SKIN DISORDERS.
INGESTION:
CAUSES GASTROINTESTINAL DISTRESS, IRRITATION AND POSSIBLE NAUSEA. MAY
CAUSE CNS DEPRESSION.
CHRONIC EFFECTS: KIDNEY AND LIVER DAMAGE; BONE MARROW AND BLOOD CHANGES.
NOTE: ETHYL ALCOHOL IS ON IARC LIST ONLY AS BEVERAGE.
CARCINOGENICITY:
LISTED IN NTP?: NO
IARC?: NO
OSHA REGULATED?: NO
| SECTION IV - FIRST AID MEASURES | |
INHALATION:
REMOVE VICTIM TO FRESH AIR AND, IF NEEDED, IMMEDIATELY BEGIN ARTIFICIAL
RESPIRATION. GIVE OXYGEN IF BREATHING IS LABORED. GET EMERGENCY MEDICAL
HELP. CONTACT A PHYSICIAN IMMEDIATELY.
EYE CONTACT:
FLUSH EYES WITH WATER FOR 15 MINUTES. GET MEDICAL ATTENTION IF SYMPTOMS
DEVELOP AND PERSIST.
SKIN CONTACT:
FLUSH WITH WATER OR SOAP AND WATER FOR 15 MINUTES OR UNTIL ALL TRACES HAVE
BEEN REMOVED. SEEK MEDICAL ATTENTION IF SYMPTOMS DEVELOP AND PERSIST.
INGESTION:
DO NOT INDUCE VOMITING. RINSE MOUTH OUT WITH WATER. GET IMMEDIATE MEDICAL
ATTENTION.
| SECTION V - FIRE FIGHTING MEASURES | |
FLASHPOINT (TEST METHOD): 4.4 C (ASTMD92), 40 F
FLAMMABLE LIMITS:
LOWER: 1.4%
UPPER: 7.0%
AUTOIGNITION TEMPERATURE:
GENERAL HAZARD:
FLASHBACK ALONG VAPOR TRAIL, VAPOR MAY EXPLODE IF IN CONTAINED AREA.
FIRE FIGHTING INSTRUCTIONS:
APPROACH FIRE FROM UPWIND SIDE. AVOID BREATHING SMOKE, FUMES, MIST OR
VAPORS ON THE DOWNWIND SIDE. FIREFIGHTERS WEAR PROTECTIVE CLOTHING AND
SELF CONTAINED BREATHING APPARATUS. COOL EXPOSED CONTAINERS WITH WATER.
EXTINGUISHING MEDIA: ALCOHOL FOAM, CO2, DRY CHEMICAL.
HAZARDOUS COMBUSTION PRODUCTS: ACRID SMOKE, IRRITATING FUMES, CO, CO2.
| SECTION VI - ACCIDENTAL RELEASE MEASURES | |
LAND SPILL: ELIMINATE ALL IGNITION SOURCES.
SMALL SPILLS:
PICK UP WITH ABSORBENT MATERIALS AND PLACE IN NON-LEAKING CONTAINERS;
SEAL TIGHTLY FOR PROPER DISPOSAL OR REUSE.
LARGE SPILLS:
EVACUATE THE HAZARD AREA OF UNPROTECTED PERSONNEL. WEAR APPROPRIATE
RESPIRATOR AND PROTECTIVE CLOTHING. SHUT OFF SOURCE OF LEAK IF SAFE TO
DO SO. DIKE AND CONTAIN. REMOVE WITH VACUUM TRUCKS OR PUMP TO
STORAGE/SALVAGE VESSELS.
WATER SPILL: NOTIFY PROPER AUTHORITIES.
CLEAN UP LEAKS/SPILLS IMMEDIATELY TO PREVENT SOIL OR WATER CONTAMINATION.
| SECTION VII - HANDLING AND STORAGE | |
HANDLING:
AVOID CONTACT WITH SKIN, EYES, AND CLOTHING. AFTER HANDLING THIS PRODUCT,
WASH HANDS BEFORE EATING, DRINKING, OR SMOKING. IF CONTACT OCCURS, REMOVE
CONTAMINATED CLOTHING. IF NEEDED, TAKE FIRST AID ACTION SHOWN IN
SECTION IV. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
STORAGE:
STORE IN A COOL PLACE AWAY FROM IGNITION SOURCES. STORE AWAY FROM
OXIDIZERS.
| SECTION VIII - EXPOSURE CONTROLS/PERSONAL PROTECTION | |
ENGINEERING CONTROLS: LOCAL EXHAUST VENTILATION IS RECOMMENDED.
PERSONAL PROTECTION:
NIOSH APPROVED RESPIRATOR, CHEMICAL RESISTANT GLOVES, CHEMICAL GOGGLES OR
FULL FACE SHIELD. BOOTS, APRONS, DRENCH SHOWERS, EYE WASH AS NEEDED FOR
PROTECTION AGAINST SPILLS AND/OR SPLASHES.
| SECTION IX - PHYSICAL AND CHEMICAL PROPERTIES | |
VAPOR PRESSURE: 19 MMHg
VAPOR DENSITY (AIR=1): 1.6
SPECIFIC GRAVITY (H2O=1): 0.86
EVAPORATION RATE (BuAc=1): <1
SOLUBILITY IN WATER: PARTIALLY
VOC (G/L): 860
pH: NA
FREEZING POINT:
BOILING POINT: 172 F
APPEARANCE & ODOR: CLEAR LIQUID, SOLVENT ODOR.
| SECTION X - STABILITY AND REACTIVITY | |
STABILITY: STABLE.
CONDITIONS TO AVOID: HEAT AND FLAMES, LACK OF VENTILATION.
MATERIALS TO AVOID: OXIDIZERS.
HAZARDOUS DECOMPOSITION PRODUCTS:
FROM COMBUSTION: ACRID SMOKE, IRRITATING FUMES, CO, CO2.
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR.
| SECTION XI - TOXICOLOGICAL INFORMATION | |
ETHYL ALCOHOL:
TDLO: 41 G/KG (ORAL - WMN)
TDLO: 50 G/KG (ORAL - MAN)
LDLO: 1400 MG/KG (ORAL - HUMAN)
LC50: 20000 PPM/10 HR (INH - RAT)
TOLUENE: 300 PPM (EYE - HUMAN)
| SECTION XII - ECOLOGICAL INFORMATION | |
DANGEROUS TO AQUATIC LIFE AT HIGH CONCENTRATIONS.
ETHYL ALCOHOL: 250 PPM / 6 HR / GOLDFISH / LETHAL / FRESH WATER
TOLUENE: 1180 MG/L / 96 HR / SUNFISH / TLM / FRESH WATER
| SECTION XIII - DISPOSAL CONSIDERATIONS | |
DISPOSE AS HAZARDOUS WASTE. CLASSIFICATION AND DOCUMENTATION IS REQUIRED
BEFORE DISPOSAL. FOLLOW ALL LOCAL, STATE AND FEDERAL REGULATIONS.
| SECTION XIV - TRANSPORTATION INFORMATION | |
PROPER SHIPPING NAME:
FLAMMABLE LIQUIDS, N.O.S., (TOLUENE ETHANOL), 3, UN1993, PG II, LIMITED
QUANTITY
HAZARD CLASS: 3.2
IDENTIFICATION NUMBER: UN1993
DOT EMERGENCY GUIDE #: 128
REPORTABLE QUANTITY (RQ): 230 GALLONS (TOLUENE)
INTERNATIONAL:
FLAMMABLE LIQUIDS, N.O.S., (TOLUENE ETHANOL), 3.2, PG II, IMDG 3230
| SECTION XV - REGULATORY INFORMATION | |
TSCA (TOXIC SUBSTANCE CONTROL ACT):
COMPONENTS OF THIS PRODUCT ARE LISTED ON THE TSCA INVENTORY.
CERCLA (COMPREHENSIVE ENVIRONMENTAL RESPONSE, COMPENSATION AND LIABILITY
ACT):
REPORTABLE QUANTITY IS 230 GALLONG (TOLUENE).
CONTACT LOCAL AUTHORITIES FOR OTHER REPORTING REQUIREMENTS.
SARA TITLE III (SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT):
SECTION 313:
TOLUENE CAS# 108-88-3) 40-60%
ETHYL ALCOHOL (CAS# 64-17-5) 45-55%
CALIFORNIA PROPOSITION 65: NOT LISTED.
| SECTION XVI - OTHER INFORMATION | |
STATE RIGHT-TO-KNOW PROGRAMS: MA, NJ, PA
NFPA RATINGS:
HEALTH 2
FLAMMABILITY 3
REACTIVITY 0
HMIS PROTECTIVE EQUIPMENT X SEE YOUR SUPERVISOR
PREPARED BY: VIRGINIA KMP CORPORATION
REVISED: 7/23/2008
THIS INFORMATION IS FURNISHED WITHOUT WARRANTY, EXPRESSED OR IMPLIED,
EXCEPT THAT IT IS ACCURATE TO THE BEST KNOWLEDGE OF VIRGINIA KMP. THE DATA
ON THIS SHEET RELATED ONLY TO SPECIFIC MATERIAL DESIGNATED HERE IN.
VIRGINIA KMP ASSUMES NO LEGAL RESPONSIBILITY FOR USE OR RELIANCE UPON
THESE DATA.