| Common Name: | TINTABLE UV PROTECTOR |
| Manufacturer: | ETERNABOND |
| SDS Revision Date: | 4/24/2007 |
| SDS Format: | No Format Specified |
| Item Number(s): | 3GYH1 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
ETERNABOND, INC.
MATERIAL SAFETY DATA SHEET
(MARSM01O)
PROVIDED BY:
ETERNABOND, INC.
75 E. DIVISION ST.
MUNDELEIN, IL 60060
847-837-9400
THIS FORM IS DESIGNED TO MEET THE REQUIREMENTS OF THE U.S. LABOR DEPARTMENT
OSHA FORM NO 174.
| SECTION I - PRODUCT IDENTIFICATION |  |
PRODUCT: ETERNABOND TINTABLE UV PROTECTOR
24 HOUR EMERGENCY ASSISTANCE - INFOTRAC: (800)-535-5053
CHEMICAL NAME: N/A
CHEMICAL FAMILY: AQUEOUS ACRYLIC EMULSIONS
HMIS/NFPA HAZARD RATINGS:
HEALTH HAZARD 1
FLAMMABILITY HAZARD 0
REACTIVITY HAZARD 0
| SECTION II - HAZARDOUS COMPONENTS | |
INGREDIENT (CAS NO.) WEIGHT %
AMMONIA (7664-41-7) <0.2
INGREDIENT VAPOR PRESSURE OSHA ACGIH 313 LD50 LC50
MM Hg 20 DEG. F PEL-TWA TLV-TWA REPORTING
CFR 29-1983 1990 REQUIRED
AMMONIA OF WATER 35 PPM 25 PPM NO
| SECTION III - PHYSICAL DATA | |
BOILING POINT RANGE: 212 DEG. F (100 DEG. C)
PERCENT VOLATILE BY VOLUME:
VAPOR PRESSURE: 17 MM Hg
EVAPORATION RATE:
N-BUTYL ACETATE = 1: NO DATA
VAPOR DENSITY: (AIR = 1) OF WATER
APPEARANCE AND ODOR: WHITE THIXOTROPIC LIQUID WITH SLIGHT AMMONIA ODOR
SOLUBILITY IN WATER: MISCIBLE
SPECIFIC GRAVITY: 1.43
| SECTION IV - FIRE AND EXPLOSION HAZARD DATA | |
FLASH POINT AND METHOD: >205 DEG. F PENSKY MARTENS CLOSED CUP
FLAMMABLE LIMITS:
LFL: N/A
UFL: N/A
EXTINGUISHING MEDIA:
CARBON DIOXIDE, WATER, FOAM, WATER, FOG, AND WATER SPRAY
SPECIAL FIRE FIGHTING PROCEDURES:
USE WATER SPRAY TO COOL FIRE EXPOSED SURFACES AND TO PROTECT PERSONNEL.
PRESSURE-DEMAND, SELF-CONTAINED RESPIRATORY PROTECTOR SHOULD BE PROVIDED
FOR FIRE FIGHTERS IN BUILDINGS OR CONFINED SPACES WHERE THIS PRODUCT IS
STORED. FIREFIGHTERS SHOULD WEAR BUTYL RUBBER BOOTS, GLOVES AND BODY SUIT.
UNUSUAL FIRE AND EXPLOSION HAZARDS:
NO KNOWN UNUSUAL HAZARDS IN A FIRE/EXPLOSION SITUATION.
| SECTION V - HEALTH HAZARD DATA | |
PERMISSIBLE EXPOSURE LEVEL: SEE SECTION II.
EFFECTS OF OVEREXPOSURE:
EYES:
SLIGHTLY IRRITATING TO THE SKIN. EYE CONTACT WITH VAPOR AND/OR SPRAY MIST
MAY IRRITATE THE EYES. EYE CONTACT WITH LIQUID MAY RESULT.
INGESTION: SEE SECTION II FOR EXPOSURE LIMITS.
INHALATION:
VAPOR OR SPRAY MIST CAN CAUSE HEADACHE, NAUSEA AND IRRITATION OF THE NOSE,
THROAT AND LUNGS.
SKIN: NO DATA
EMERGENCY AND FIRST AID PROCEDURES:
EYES:
FLUSH WITH WATER FOR AT LEAST 15 MINUTES LIFTING UPPER AND LOWER LIDS AND
SEEK IMMEDIATE MEDICAL ATTENTION.
INGESTION:
SMALL INGESTED AMOUNTS ARE NOT EXPECTED TO PRODUCE ADVERSE HEALTH EFFECTS.
LARGE QUANTITIES, (>1 OZ.) SHOULD BE RECOVERED FROM THE STOMACH BY
ASPIRATION. GET IMMEDIATE MEDICAL ATTENTION.
INHALATION: IF BREATHING IS DIFFICULT, ADMINISTER OXYGEN.
SKIN: WASH WITH SOAP AND LARGE QUANTITIES OF WATER
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE: N/A
CHEMICALS CONTAINED HEREIN LISTED AS CARCINOGENS OR POTENTIAL CARCINOGENS:
NTP: NONE
IARC: NONE
OSHA: NONE
| SECTION VI - REACTIVITY DATA | |
STABILITY:
STABLE. INCOMPATIBILITY (MATERIAL TO AVOID): AVOID CONTACT WITH MINERAL
ACIDS (I.E. SULFURIC, PHOSPHORIC, ETC.) ALKALIS (I.E. SODIUM OR POTASSIUM
HYDROXIDE, ETC.)
HAZARDOUS DECOMPOSITION PRODUCTS:
INVOLVEMENT IN FIRE OR HIGH TEMPERATURES MAY YIELD ACRYLIC MONOMER.
CARBON MONOXIDE AND CARBON DIOXIDE AND IRRITATING AND TOXIC FUMES.
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR.
| SECTION VII - SPILL OR LEAK PROCEDURES | |
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED:
CONSTRUCT DIKE TO CONTROL SPREADING. KEEP PEOPLE AWAY. RECOVER FREE LIQUID.
ADD ABSORBENT TO SPILL AREA. VENTILATE ENCLOSED SPACES. KEEP OUT OF STREAMS
AND SEWERS.
WASTE DISPOSAL METHOD:
DISPOSE OF UNUSED PRODUCT OR CONTAMINATED PRODUCT AND MATERIALS USED IN
CLEANING UP SPILLS OR LEAKS IN A MANNER APPROVED FOR THIS MATERIAL. CONSULT
APPROPRIATE FEDERAL, STATE AND LOCAL REGULATORY AGENCIES TO ASCERTAIN
PROPER DISPOSAL PROCEDURES. EMPTY CONTAINERS WILL RETAIN PRODUCT RESIDUE
AND VAPORS AND ARE SUBJECT TO PROPER WASTE DISPOSAL, AS ABOVE.
| SECTION VIII - SPECIAL PROTECTION INFORMATION | |
RESPIRATORY PROTECTION:
NOT REQUIRED UNDER NORMAL CONDITIONS. WEAR A NIOSH APPROVED RESPIRATOR
APPROPRIATE FOR THE VAPOR OR MIST CONCENTRATION AT THE POINT OF USE.
APPROPRIATE RESPIRATORS MAY BE FULL FACE-PIECE OR A HALF MASK AIR-PURIFYING
CARTRIDGE RESPIRATOR EQUIPPED FOR ORGANIC VAPORS/MISTS, A SELF-CONTAINED
BREATHING APPARATUS IN THE PRESSURE DEMAND MODE, OR A SUPPLIED-AIR
RESPIRATOR. REFER TO OSHA STANDARD 29 CFR 1910.134 FOR ADDITIONAL
INFORMATION.
EYE PROTECTION: CHEMICAL GOGGLES
VENTILATION:
WORK IN WELL-VENTILATED AREAS. MAINTAIN AIR CONCENTRATIONS IN WORKSPACES IN
ACCORD WITH STANDARDS OUTLINED IN SECTIONS 2 AND 3.
PROTECTIVE GLOVES: RUBBER GLOVES.
| SECTION IX - SPECIAL PRECAUTIONS | |
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING:
FOR INDUSTRIAL USE ONLY. KEEP OUT OF REACH OF CHILDREN. KEEP CONTAINER
CLOSED. AVOID FREEZING TEMPERATURES DURING STORAGE. DO NOT TAKE INTERNALLY.
STORE IN A COOL PLACE. STORE IN TIGHTLY CLOSED CONTAINERS. IF HEADSPACE
VENTILATION IS REQUIRED, USE HUMIDIFIED AIR TO REDUCE SKIN FORMATION ON
EMULSION SURFACE.
| SECTION X - NOTES | |
NOTE:
N/A = NOT APPLICABLE
N/E = NOT ESTABLISHED
ISSUE DATE: AUGUST 19, 1999
ISSUED BY: KEN KONOPKA
REVISION DATE: APRIL 24, 2007
INFORMATION HEREIN IS GIVEN IN GOOD FAITH AND IS, TO THE BEST OF OUR
KNOWLEDGE AND BELIEF, ACCURATE AND RELIABLE. HOWEVER, SINCE INFORMATION
HEREIN WAS OBTAINED, IN PART, FROM INDEPENDENT SUPPLIERS NOT UNDER THE
DIRECTION AND SUPERVISION OF ETERNABOND, INC., ETERNABOND, INC., MAKES
NO WARRANTY OR REPRESENTATION, EXPRESS OR IMPLIED, THAT INFORMATION IS
ACCURATE, RELIABLE, COMPLETE OR REPRESENTATIVE. ETERNABOND, INC., WARRANTS
ONLY THAT IT HAS MADE NO EFFORT TO CENSOR OTHER THAN TRADE SECRET
INFORMATION OR TO CONCEAL DELETERIOUS ASPECTS OF ITS PRODUCTS. THE DATA
SHOWN ABOVE IN NO WAY MODIFIES, AMENDS, OR ENLARGES ANY SPECIFICATIONS OR
WARRANTY.
ALL COMPONENTS OF THIS PRODUCT ARE LISTED IN THE EPA/TSCA INVENTORY OR
CHEMICAL SUBSTANCES.