| Common Name: | CUTTING FORCE PS |
| Manufacturer: | JOHNSON DIVERSEY |
| SDS Revision Date: | 2/26/2009 |
| SDS Format: | No Format Specified |
| Item Number(s): | 3UT59 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
RAMSEY(TM/MC)
BY JOHNSON DIVERSEY
MATERIAL SAFETY DATA SHEET
CUTTING FORCE PS
VERSION NUMBER: 2
PREPARATION DATE: 2009-02-26
| 1. PRODUCT AND COMPANY IDENTIFICATION |  |
PRODUCT NAME: CUTTING FORCE PS
MSDS #: MS0300208
PRODUCT CODE: 5134024, 2945067
RECOMMENDED USE:
CLEANING PRODUCT. THIS PRODUCT IS INTENDED TO BE DILUTED PRIOR TO USE.
MANUFACTURER, IMPORTER, SUPPLIER:
US HEADQUARTERS:
JOHNSON DIVERSEY, INC.
8310 16TH ST.
STURTEVANT, WISCONSIN 53177-1964
RAMSEY INFORMATION PHONE: 1-800-421-2768
MSDS INTERNET ADDRESS: WWW.RAMSEYCOMPANY.COM
EMERGENCY TELEPHONE NUMBER:
1-800-851-7145 (U.S.)
1-651-917-6133 (INT'L)
| 2. HAZARDS IDENTIFICATION | |
EMERGENCY OVERVIEW:
DANGER
CORROSIVE
CAUSES SKIN AND EYE BURNS
HARMFUL OR FATAL IF SWALLOWED
PRINCIPLE ROUTES OF EXPOSURE: EYE CONTACT. SKIN CONTACT. INHALATION.
EYE CONTACT:
CORROSIVE. CAUSES PERMANENT EYE DAMAGE, INCLUDING BLINDNESS.
SKIN CONTACT: CORROSIVE. CAUSES PERMANENT DAMAGE.
INHALATION:
MAY CAUSE IRRITATION AND CORROSIVE EFFECTS TO NOSE, THROAT AND RESPIRATORY
TRACT. USE ONLY IN WELL-VENTILATED AREAS. AVOID REPEATED OR PROLONGED
INHALATION OF VAPORS OR SPRAY MIST WHICH MAY CAUSE CUMULATIVE EFFECTS.
PERSONS WITH PRE-EXISTING RESPIRATORY CONDITIONS SHOULD BE PARTICULARLY
CAREFUL ABOUT POSSIBLE RESPIRATORY EFFECTS.
INGESTION:
CORROSIVE. CAUSES BURNS TO MOUTH, THROAT AND STOMACH. INGESTION MAY
CAUSE GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING AND DIARRHEA.
| 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
HAZARDOUS INGREDIENTS:
INGREDIENT(S) CAS # WEIGHT %
MONOETHANOLAMINE 141-43-5 3 - 7 %
SODIUM METASILICATE 6834-92-0 NF
2-BUTOXYETHANOL 111-76-2 10 - 25 %
SODIUM HYDROXIDE 1310-73-2 1 - 5 %
| 4. FIRST AID MEASURES | |
EYE CONTACT:
IMMEDIATELY FLUSH EYES WITH RUNNING WATER FOR 15-20 MINUTES, KEEPING
EYELIDS OPEN. GET MEDICAL ATTENTION IMMEDIATELY.
SKIN CONTACT:
IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR 15-20 MINUTES. GET MEDICAL
ATTENTION IMMEDIATELY.
INHALATION:
IF BREATHING IS AFFECTED, REMOVE TO FRESH AIR. GET MEDICAL ATTENTION
IMMEDIATELY.
INGESTION:
IF SWALLOWED, RINSE MOUTH. IMMEDIATELY DRINK ONE CUPFUL OF WATER OR
MILK. THEN IMMEDIATELY CONTACT A PHYSICIAN OR POISON CENTER. DO NOT
INDUCE VOMITING UNLESS DIRECTED TO DO SO BY MEDICAL PERSONNEL. NEVER
GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
AGGRAVATED MEDICAL CONDITIONS:
INDIVIDUALS WITH CHRONIC RESPIRATORY DISORDERS SUCH AS ASTHMA, CHRONIC
BRONCHITIS, EMPHYSEMA, ETC., MAY BE MORE SUSCEPTIBLE TO IRRITATING
EFFECTS.
| 5. FIRE-FIGHTING MEASURES | |
SUITABLE EXTINGUISHING MEDIA:
THE PRODUCT IS NOT FLAMMABLE. EXTINGUISH FIRE USING AGENT SUITABLE FOR
SURROUNDING FIRE.
EXTINGUISHING MEDIA WHICH MUST NOT BE USED FOR SAFETY REASONS: NONE.
SPECIAL PROTECTIVE EQUIPMENT FOR FIREFIGHTERS:
AS IN ANY FIRE, WEAR SELF-CONTAINED BREATHING APPARATUS PRESSURE-DEMAND,
MSHA/NIOSH (APPROVED OR EQUIVALENT) AND FULL PROTECTIVE GEAR.
SPECIFIC HAZARDS: NONE KNOWN.
UNUSUAL HAZARDS: CORROSIVE MATERIAL (SEE SECTIONS 8 AND 10).
SPECIFIC METHODS: NONE KNOWN.
AUTOIGNITION TEMPERATURE: NO INFORMATION AVAILABLE.
NFPA:
HEALTH 3
FLAMMABILITY 0
INSTABILITY 0
| 6. ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS:
PUT ON APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT (SEE SECTION 8.).
ENVIRONMENTAL PRECAUTIONS AND CLEAN-UP METHODS:
CLEAN-UP METHODS - LARGE SPILLAGE. SOAK UP WITH INERT ABSORBENT MATERIAL.
SWEEP UP AND SHOVEL INTO SUITABLE CONTAINERS FOR DISPOSAL. USE A WATER
RINSE FOR FINAL CLEAN-UP.
| 7. HANDLING AND STORAGE | |
HANDLING:
AVOID CONTACT WITH SKIN, EYES AND CLOTHING. DO NOT TASTE OR SWALLOW.
AVOID BREATHING VAPORS OR MISTS. USE ONLY IN WELL-VENTILATED AREAS.
REMOVE AND WASH CONTAMINATED CLOTHING AND FOOTWEAR BEFORE RE-USE.
WASH THOROUGHLY AFTER HANDLING. PRODUCT RESIDUE MAY REMAIN ON/IN EMPTY
CONTAINERS. ALL PRECAUTIONS FOR HANDLING THE PRODUCT MUST BE USED IN
HANDLING THE EMPTY CONTAINER AND RESIDUE. MIX ONLY WITH WATER. DO NOT
MIX WITH ANY OTHER PRODUCT OR CHEMICAL. MAY REACT TO RELEASE HAZARDOUS
GASES. FOR COMMERCIAL AND INDUSTRIAL USE ONLY.
STORAGE:
PROTECT FROM FREEZING. KEEP TIGHTLY CLOSED IN A DRY, COOL AND
WELL-VENTILATED PLACE. KEEP OUT OF REACH OF CHILDREN.
| 8. EXPOSURE CONTROLS / PERSONAL PROTECTION | |
ENGINEERING MEASURES TO REDUCE EXPOSURE:
GOOD GENERAL VENTILATION SHOULD BE SUFFICIENT TO CONTROL AIRBORNE
LEVELS. RESPIRATORY PROTECTION IS NOT REQUIRED IF GOOD VENTILATION
IS MAINTAINED.
PERSONAL PROTECTIVE EQUIPMENT:
EYE PROTECTION: CHEMICAL-SPLASH GOGGLES.
HAND PROTECTION: CHEMICAL-RESISTANT GLOVES
SKIN AND BODY PROTECTION:
PROTECTIVE FOOTWEAR. IF MAJOR EXPOSURE IS POSSIBLE, WEAR SUITABLE
PROTECTIVE CLOTHING AND FOOTWEAR.
RESPIRATORY PROTECTION:
IN CASE OF INSUFFICIENT VENTILATION WEAR SUITABLE RESPIRATORY EQUIPMENT.
A RESPIRATORY PROTECTION PROGRAM THAT MEETS OSHA'S 29 CFR 1910.134 AND
ANSI Z88.2 REQUIREMENTS MUST BE FOLLOWED WHENEVER WORKPLACE CONDITIONS
WARRANT A RESPIRATOR'S USE.
HYGIENE MEASURES:
HANDLE IN ACCORDANCE WITH GOOD INDUSTRIAL HYGIENE AND SAFETY PRACTICE
INGREDIENT(S) ACGIH OSHA MEXICO
MONOETHANOLAMINE 6 PPM (STEL) 3 PPM (TWA) 6 PPM (STEL)
3 PPM (TWA) 6 MG/M3 (TWA) 15 MG/M3 (STEL)
8 MG/M3 (TWA)
3 PPM (TWA)
2-BUTOXYETHANOL 20 PPM (TWA) SKIN 75 PPM (STEL)
240 MG/M3 (TWA) 360 MG/M3 (STEL)
50 PPM (TWA) 26 PPM (TWA)
120 MG/M3 (TWA)
SODIUM HYDROXIDE 2 MG/M3 2 MG/M3 (TWA) 2 MG/M3 (CEILING)
(CEILING)
HMIS:
HEALTH 3
FIRE HAZARD 0
REACTIVITY 0
PERSONAL PROTECTIVE EQUIPMENT:
SAFETY GLASSES
GLOVES
BOOTS
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
PHYSICAL STATE: LIQUID
APPEARANCE: LIQUID
COLOR: BLUE
ODOR: SOLVENT
pH: 13.5
DILUTION pH: 12.23 (1:10)
SPECIFIC GRAVITY: 1.05
DENSITY: 8.76 LBS/GAL
BULK DENSITY: NO INFORMATION AVAILABLE
VAPOR DENSITY: NO INFORMATION AVAILABLE
EVAPORATION RATE: NO INFORMATION AVAILABLE
VISCOSITY: NO INFORMATION AVAILABLE
SOLUBILITY: COMPLETELY SOLUBLE
VOC: 19.28%*
SOLUBILITY IN OTHER SOLVENTS: NO INFORMATION AVAILABLE
PARTITION COEFFICIENT (n-OCTANOL/WATER): NO INFORMATION AVAILABLE
BOILING POINT/RANGE: NOT DETERMINED
MELTING POINT/RANGE: NOT DETERMINED
FLASH POINT:
>200 DEG. F
>93.3 DEG. C
DECOMPOSITION TEMPERATURE: NOT DETERMINED
AUTOIGNITION TEMPERATURE: NO INFORMATION AVAILABLE
ELEMENTAL PHOSPHORUS: 0% P
* - TITLE 17, CALIFORNIA CODE OF REGULATIONS, DIVISION 3, CHAPTER 1,
SUBCHAPTER 8.5, ARTICLE 2, CONSUMER PRODUCTS, SECTIONS 94508
| 10. STABILITY AND REACTIVITY | |
STABILITY: STABLE.
POLYMERIZATION: NONE UNDER NORMAL PROCESSING.
MATERIALS TO AVOID: OXIDISING AGENTS. ACIDS.
CONDITIONS TO AVOID: DO NOT MIX WITH ANY OTHER PRODUCT OR CHEMICAL.
HAZARDOUS DECOMPOSITION PRODUCTS: NONE KNOWN.
| 11. TOXICOLOGICAL INFORMATION | |
HAZARDOUS INGREDIENTS:
INGREDIENT(S) LD50 ORAL - RAT LD50 LC50
(MG/KG) DERMAL - RABBIT INHALATION - RAT
MONOETHANOLAMINE 1720 1 ML/KG NOT AVAILABLE
SODIUM METASILICATE 600 NOT AVAILABLE NOT AVAILABLE
2-BUTOXYETHANOL 470 220 MG/KG 2.21 MG/L (4 H);
450 PPM (4 H)
SODIUM HYDROXIDE 140 1350 MG/KG NOT AVAILABLE
ACUTE TOXICITY:
CORROSIVE. ORAL LD50 ESTIMATED TO BE BETWEEN 2000 - 3000 MG/KG.
DERMAL LD50 ESTIMATED TO BE >2000 MG/KG
CHRONIC TOXICITY: NONE KNOWN
SPECIFIC EFFECTS:
CARCINOGENIC EFFECTS: NONE KNOWN
MUTAGENIC EFFECTS: NONE KNOWN
REPRODUCTIVE TOXICITY: NONE KNOWN
TARGET ORGAN EFFECTS: NONE KNOWN
HAZARDOUS INGREDIENTS:
INGREDIENTS NTP IARC OSHA
2-BUTOXYETHANOL 3
111-76-2
| 12. ECOLOGICAL INFORMATION | |
ENVIRONMENTAL INFORMATION: NO DATA AVAILABLE
| 13. DISPOSAL CONSIDERATIONS | |
WASTE FROM RESIDUES / UNUSED PRODUCTS:
UNDILUTED PRODUCT IS REGULATED UNDER ENVIRONMENTAL AND TRANSPORTATION
LAWS AS A CORROSIVE WASTE. DISPOSE OF ACCORDING TO ALL FEDERAL, STATE
AND LOCAL APPLICABLE REGULATIONS.
RCRA HAZARD CLASS: D002
| 14. TRANSPORT INFORMATION | |
DOT/TDG:
PLEASE REFER TO THE BILL OF LADING/RECEIVING DOCUMENTS FOR UP TO DATE
SHIPPING INFORMATION
| 15. REGULATORY INFORMATION | |
INTERNATIONAL INVENTORIES:
ALL COMPONENTS OF THIS PRODUCT ARE LISTED ON THE FOLLOWING INVENTORIES:
U.S.A. (TSCA), CANADA (DSL/NDSL).
U.S. REGULATIONS:
CALIFORNIA PROPOSITION 65:
THIS PRODUCT IS NOT SUBJECT TO THE REPORTING REQUIREMENTS UNDER
CALIFORNIA'S PROPOSITION 65
STATE RIGHT TO KNOW:
INGREDIENT(S) CAS # MARTK NJRTK PARTK RIRTK
MONOETHANOLAMINE 141-43-5 X X X X
WATER 7732-18-5
SODIUM XYLENE SULFONATE 1300-72-7
2-BUTOXYETHANOL 111-76-2 X X X X
SODIUM HYDROXIDE 1310-73-2 X X X X
TETRASODIUM SALT OF EDTA 64-02-8
ALCOHOL ETHOXYLATES 34398-01-1
CERCLA/SARA:
INGREDIENT(S) WEIGHT % CERCLA/SARA SECTION 302 SECTION 313
RQ (LBS) TPQ (LBS)
2-BUTOXYETHANOL 10 - 25 % X
111-76-2
SODIUM HYDROXIDE 1 - 5 % 1000
1310-73-2
INGREDIENT(S) CAA HAP CAA ODS CWA PRIORITY POLLUTANTS
2-BUTOXYETHANOL X
111-76-2
SARA 311/312 HAZARD CATEGORIES:
IMMEDIATE (X)
DELAYED ( )
FIRE ( )
REACTIVITY ( )
SUDDEN RELEASE OF PRESSURE ( )
CANADA:
WHMIS HAZARD CLASS: E CORROSIVE MATERIAL.
INGREDIENT(S) CAS # NPRI
MONOETHANOLAMINE 141-43-5 X
2-BUTOXYETHANOL 111-76-2 X
| 16. OTHER INFORMATION | |
REASON FOR REVISION: NOT APPLICABLE
PREPARED BY: NAPRAC
ADDITIONAL ADVICE: NONE
NOTICE TO READER:
THIS DOCUMENT HAS BEEN PREPARED USING DATA FROM SOURCES CONSIDERED
TECHNICALLY RELIABLE. IT DOES NOT CONSTITUTE A WARRANTY, EXPRESS
OR IMPLIED, AS TO THE ACCURACY OF THE INFORMATION CONTAINED WITHIN.
ACTUAL CONDITIONS OF USE AND HANDLING ARE BEYOND SELLER'S CONTROL.
USER IS RESPONSIBLE TO EVALUATE ALL AVAILABLE INFORMATION WHEN USING
PRODUCT FOR ANY PARTICULAR USE AND TO COMPLY WITH ALL FEDERAL, STATE,
PROVINCIAL AND LOCAL LAWS AND REGULATIONS.