| Common Name: | 802069PM |
| Manufacturer: | H.B. FULLER |
| SDS Revision Date: | 12/21/2006 |
| SDS Format: | No Format Specified |
| Item Number(s): | 3UUD1 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
MATERIAL SAFETY DATA SHEET
802069PM
10-04-2007
REVISION DATE: 12-21-2006
SUPERSEDES: 03-07-2005
| SECTION 1: CHEMICAL PRODUCT AND COMPANY IDENTIFICATION |  |
COMPANY INFORMATION:
H.B. FULLER COMPANY
1200 WILLOW LAKE BOULEVARD
VADNAIS HEIGHTS, MN 55110
PHONE: 651-236-5900
MEDICAL EMERGENCY PHONE NUMBER (24 HOURS): 1-888-853-1758
TRANSPORT EMERGENCY PHONE NUMBER (CHEMTREC): 1-800-424-9300
PRODUCT INFORMATION:
PRODUCT IDENTIFIER: 802069PM
PRODUCT NUMBER: EP7171T
PRODUCT DESCRIPTION: SEALANT
| SECTION 2: COMPOSITION/INFORMATION ON INGREDIENTS | |
UNLISTED INGREDIENTS ARE NOT 'HAZARDOUS' PER THE OCCUPATIONAL SAFETY AND
HEALTH ADMINISTRATION HAZARD COMMUNICATION STANDARD (29 CFR 1910.1200)
AND/OR ARE NOT FOUND ON THE CANADIAN WORKPLACE HAZARDOUS MATERIALS
INFORMATION SYSTEM INGREDIENT DISCLOSURE LIST. SEE SECTION 8 FOR ANY
ADDITIONAL EXPOSURE LIMIT GUIDELINES.
CHEMICAL NAME CAS # PERCENT OSHA PEL
CALCIUM CARBONATE 471-34-1 30 - 50 TWA (RESPIRABLE
DUST) 5 MG/M3
TWA (TOTAL DUST)
15 MG/M3
TREMOLITE 14567-73-8 10 - 30 NOT ESTABLISHED
(NON-ASBESTIFORM)
TALC 14807-96-6 5 - 10 TWA (RESPIRABLE
DUST) 2 MG/M3
WAX, 9010-79-1 1 - 5 TWA * FUME 2 MG/M3
POLYETHYLENE-POLYPROPYLENE
ANTHOPHYLLITE 17068-78-9 1 - 5 NOT ESTABLISHED
(NON-ASBESTIFORM)
TITANIUM DIOXIDE 13463-67-7 0.1 - 1 TWA (TOTAL DUST)
10 MG/M3
*THESE EXPOSURE LIMITS ARE FOR PARAFFIN WAX FUME, A RELATED MATERIAL.
| SECTION 3: HAZARDS IDENTIFICATION | |
EMERGENCY OVERVIEW:
HMIS RATING:
HEALTH 0
FLAMMABILITY 1
REACTIVITY 0
SEE SECTION 8:
EXPOSURE CONTROLS/PERSONAL PROTECTION FOR PERSONAL PROTECTIVE EQUIPMENT
RECOMMENDATIONS.
POTENTIAL HEALTH EFFECTS BY ROUTE OF ENTRY:
EYE: CAN CAUSE MINOR IRRITATION, TEARING AND REDDENING.
SKIN: CAN CAUSE MINOR SKIN IRRITATION, DEFATTING, AND DERMATITIS.
INHALATION:
CAN CAUSE MINOR RESPIRATORY IRRITATION. INHALATION OF DUSTS PRODUCED DURING
CUTTING, GRINDING OR SANDING OF THIS PRODUCT MAY CAUSE IRRITATION OF THE
RESPIRATORY TRACT.
THIS PRODUCT CONTAINS ONE OR MORE MATERIALS THAT MAY BE HAZARDOUS WHEN
PRESENT AS AN AIRBORNE DUST. DURING NORMAL HANDLING OF THE PRODUCT, THE
MATERIAL IS ENCAPSULATED WITHIN THE PRODUCT AND WILL NOT PRESENT AN
EXPOSURE RISK. ONCE THE PRODUCT HAS REACHED ITS FINAL STATE AND IS ABRADED
OR DISTURBED, DUSTING AND EXPOSURE MAY OCCUR.
INGESTION:
INGESTION IS NOT AN ANTICIPATED ROUTE OF EXPOSURE. NO HAZARD IN NORMAL
INDUSTRIAL USE.
LONG-TERM (CHRONIC) HEALTH EFFECTS:
TARGET ORGAN(S): LUNGS
REGULATED CARCINOGEN STATUS:
UNLESS NOTED BELOW, THIS PRODUCT DOES NOT CONTAIN REGULATED LEVELS OF NTP,
IARC, ACGIH, OR OSHA LISTED CARCINOGENS.
TITANIUM DIOXIDE
EXISTING HEALTH CONDITIONS AFFECTED BY EXPOSURE: LUNG DISEASE
| SECTION 4: FIRST AID MEASURES | |
IF IN EYES:
USE AN EYE WASH TO REMOVE A CHEMICAL FROM YOUR EYE REGARDLESS OF THE LEVEL
OF HAZARD. FLUSH THE AFFECTED EYE FOR AT LEAST TWENTY MINUTES. TILT THE
HEAD TO PREVENT CHEMICAL FROM TRANSFERRING TO THE UNCONTAMINATED EYE. SEEK
MEDICAL ADVICE AFTER FLUSHING.
IF ON SKIN:
WASH WITH SOAP AND WATER. GET MEDICAL ATTENTION IF IRRITATION DEVELOPS OR
PERSISTS.
IF VAPORS INHALED:
REMOVE TO FRESH AIR. CALL A PHYSICIAN IF SYMPTOMS PERSIST.
IF SWALLOWED:
DO NOT INDUCE VOMITING. SEEK MEDICAL ATTENTION IF SYMPTOMS DEVELOP. PROVIDE
MEDICAL CARE PROVIDER WITH THIS MSDS.
| SECTION 5: FIRE FIGHTING MEASURES | |
FLASH POINT: NOT APPLICABLE
AUTOIGNITION TEMPERATURE: NOT ESTABLISHED
LOWER EXPLOSIVE LIMIT (% IN AIR): NOT ESTABLISHED
UPPER EXPLOSIVE LIMIT (% IN AIR): NOT ESTABLISHED
EXTINGUISHING MEDIA: USE WATER SPRAY, FOAM, DRY CHEMICAL OR CARBON DIOXIDE.
UNUSUAL FIRE AND EXPLOSION HAZARDS: MATERIAL WILL BURN IN A FIRE.
SPECIAL FIRE FIGHTING INSTRUCTIONS:
PERSONS EXPOSED TO PRODUCTS OF COMBUSTION SHOULD WEAR SELF-CONTAINED
BREATHING APPARATUS AND FULL PROTECTIVE EQUIPMENT.
HAZARDOUS COMBUSTION PRODUCTS: CARBON DIOXIDE, CARBON MONOXIDE
| SECTION 6: ACCIDENTAL RELEASE MEASURES | |
SPECIAL PROTECTION:
NO ADVERSE HEALTH EFFECTS EXPECTED FROM THE CLEAN-UP OF SPILLED MATERIAL.
FOLLOW PERSONAL PROTECTIVE EQUIPMENT RECOMMENDATIONS FOUND IN SECTION 8 OF
THIS MSDS.
CLEAN-UP: SCRAPE UP AND PLACE IN DISPOSAL CONTAINER.
TRANSPORT EMERGENCY PHONE NUMBER (CHEMTREC): 1-800-424-9300
| SECTION 7: HANDLING AND STORAGE | |
HANDLING: NO SPECIAL HANDLING INSTRUCTIONS DUE TO TOXICITY.
STORAGE: STORE IN A COOL, DRY PLACE.
CONSULT THE TECHNICAL DATA SHEET FOR SPECIFIC STORAGE INSTRUCTIONS.
| SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION | |
EYE PROTECTION: WEAR SAFETY GLASSES WHEN HANDLING THIS PRODUCT.
SKIN PROTECTION: AVOID SKIN CONTACT BY WEARING CHEMICALLY RESISTANT GLOVES.
GLOVES: NOT NORMALLY REQUIRED. USE NITRILE GLOVES IF CONDITIONS WARRANT.
RESPIRATORY PROTECTION:
RESPIRATORY PROTECTION MAY BE REQUIRED TO AVOID OVEREXPOSURE WHEN HANDLING
THIS PRODUCT. USE A RESPIRATOR IF GENERAL ROOM VENTILATION IS NOT AVAILABLE
OR SUFFICIENT TO ELIMINATE SYMPTOMS.
RESPIRATORS SHOULD BE SELECTED BY AND USED FOLLOWING REQUIREMENTS FOUND IN
OSHA'S RESPIRATOR STANDARD (29 CFR 1910.134).
VENTILATION:
USE LOCAL EXHAUST VENTILATION OR OTHER ENGINEERING CONTROLS TO MINIMIZE
EXPOSURES.
EXPOSURE LIMITS:
CHEMICAL NAME ACGIH EXPOSURE LIMITS AIHA WEEL
CALCIUM CARBONATE TWA 10 MG/M3 NOT ESTABLISHED
TREMOLITE (NON-ASBESTIFORM) NOT ESTABLISHED NOT ESTABLISHED
TALC TWA (RESPIRABLE DUST) NOT ESTABLISHED
2 MG/M3
WAX, POLYETHYLENE-POLYPROPYLENE TWA * FUME 2 MG/M3 NOT ESTABLISHED
ANTHOPHYLLITE (NON-ASBESTIFORM) NOT ESTABLISHED NOT ESTABLISHED
TITANIUM DIOXIDE TWA 10 MG/M3 NOT ESTABLISHED
*THESE EXPOSURE LIMITS ARE FOR PARAFFIN WAX FUME, A RELATED MATERIAL.
| SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES | |
PHYSICAL STATE: SOLID
COLOR: GRAY
ODOR: NEUTRAL
ODOR THRESHOLD: NOT ESTABLISHED
WEIGHT PER GALLON (LBS.): 12.8
SPECIFIC GRAVITY: 1.53
SOLIDS (% BY WEIGHT): NOT APPLICABLE
pH: NOT ESTABLISHED
BOILING POINT (DEG. C): NOT ESTABLISHED
FREEZING/MELTING POINT (DEG. C): NOT ESTABLISHED
VAPOR PRESSURE (MMHg): NOT ESTABLISHED
VAPOR DENSITY: NOT ESTABLISHED
EVAPORATION RATE: NOT ESTABLISHED
OCTANOL/WATER COEFFICIENT: NOT ESTABLISHED
| SECTION 10: STABILITY AND REACTIVITY | |
STABILITY: STABLE UNDER NORMAL CONDITIONS.
CHEMICAL INCOMPATIBILITY: NOT ESTABLISHED
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR.
HAZARDOUS DECOMPOSITION PRODUCTS: CARBON MONOXIDE, CARBON DIOXIDE
| SECTION 11: TOXICOLOGICAL INFORMATION | |
CHEMICAL NAME LD50/LC50
CALCIUM CARBONATE ORAL LD50 RAT = 6450 MG/KG
TREMOLITE (NON-ASBESTIFORM) NOT ESTABLISHED
TALC NOT ESTABLISHED
WAX, POLYETHYLENE-POLYPROPYLENE NOT ESTABLISHED
ANTHOPHYLLITE (NON-ASBESTIFORM) NOT ESTABLISHED
TITANIUM DIOXIDE NOT ESTABLISHED
TOXICOLOGY SUMMARY: NO ADDITIONAL HEALTH INFORMATION AVAILABLE.
| SECTION 12: ECOLOGICAL INFORMATION | |
OVERVIEW: NO ECOLOGICAL INFORMATION AVAILABLE
| SECTION 13: DISPOSAL CONSIDERATIONS | |
TO THE BEST OF OUR KNOWLEDGE, THIS PRODUCT DOES NOT MEET THE DEFINITION OF
HAZARDOUS WASTE UNDER THE U.S. EPA HAZARDOUS WASTE REGULATIONS 40 CFR 261.
DISPOSE OF IN AN APPROVED LANDFILL. CONSULT YOUR STATE, LOCAL OR PROVINCIAL
AUTHORITIES AND YOUR LOCAL WASTE VENDOR FOR MORE RESTRICTIVE REQUIREMENTS.
| SECTION 14: TRANSPORTATION INFORMATION | |
CONSULT BILL OF LADING FOR TRANSPORTATION INFORMATION.
DOT: NOT REGULATED
IATA: NOT REGULATED
| SECTION 15: REGULATORY INFORMATION | |
INVENTORY STATUS:
U.S. EPA TSCA:
THIS PRODUCT IS IN COMPLIANCE WITH THE TOXIC SUBSTANCES CONTROL ACT'S
INVENTORY REQUIREMENTS.
CANADIAN CEPA DSL:
THIS PRODUCT IS IN COMPLIANCE WITH THE CANADIAN DOMESTIC SUBSTANCE LIST
REQUIREMENTS.
IF YOU NEED MORE INFORMATION ABOUT THE INVENTORY STATUS OF THIS PRODUCT
CALL 651-236-5858.
THIS PRODUCT MAY CONTAIN CHEMICAL SUBSTANCES THAT ARE REGULATED FOR EXPORT
BY VARIOUS GOVERNMENT AGENCIES (SUCH AS THE ENVIRONMENTAL PROTECTION
AGENCY, THE BUREAU OF INDUSTRY AND SECURITY, OR THE DRUG ENFORCEMENT
ADMINISTRATION, AMONG OTHERS). BEFORE EXPORTING THIS PRODUCT FROM THE USA
OR CANADA, WE RECOMMEND YOU CONTACT US AT 651-236-5858 (USA) OR
450-655-1306 X227 (CANADA) TO REQUEST AN EXPORT REVIEW.
FEDERAL REPORTING:
EPA SARA TITLE III SECTION 313
UNLESS LISTED BELOW, THIS PRODUCT DOES NOT CONTAIN TOXIC CHEMICAL(S)
SUBJECT TO THE REPORTING REQUIREMENTS OF SECTION 313 OF TITLE III OF THE
SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 (SARA) AND 40 CFR PART
372. EPA HAS ADVISED THAT WHEN A PERCENTAGE RANGE IS LISTED THE MIDPOINT
MAY BE USED TO FULFILL REPORTING OBLIGATIONS.
CHEMICAL NAME CAS# %
WHMIS STATUS:
UNLESS LISTED BELOW, THIS PRODUCT IS NOT CONTROLLED UNDER THE CANADIAN
WORKPLACE HAZARDOUS MATERIALS INFORMATION SYSTEM.
D2A
STATE REPORTING: THIS MSDS IS NOT PREPARED FOR DISTRIBUTION IN CALIFORNIA.
| SECTION 16: ADDITIONAL INFORMATION | |
THIS MATERIAL SAFETY DATA SHEET IS PREPARED TO COMPLY WITH THE UNITED
STATES OCCUPATIONAL SAFETY AND HEALTH ADMINISTRATION (OSHA) HAZARD
COMMUNICATION STANDARD (29 CFR 1910.1200) AND THE CANADIAN WORKPLACE
HAZARDOUS MATERIALS INFORMATION SYSTEM (WHMIS).
PREPARED BY: THE GLOBAL REGULATORY DEPARTMENT
PHONE: 651-236-5842
THE INFORMATION AND RECOMMENDATIONS SET FORTH HEREIN ARE BELIEVED TO BE
ACCURATE. BECAUSE SOME OF THE INFORMATION IS DERIVED FROM INFORMATION
PROVIDED TO THE H.B. FULLER COMPANY FROM ITS SUPPLIERS, AND BECAUSE THE
H.B. FULLER COMPANY HAS NO CONTROL OVER THE CONDITIONS OF HANDLING AND USE,
THE H.B. FULLER COMPANY MAKES NO WARRANTY, EXPRESSED OR IMPLIED, REGARDING
THE ACCURACY OF THE DATA OR THE RESULTS TO BE OBTAINED FROM THE USE
THEREOF. THE INFORMATION IS SUPPLIED SOLELY FOR YOUR INFORMATION AND
CONSIDERATION, AND THE H.B. FULLER COMPANY ASSUMES NO RESPONSIBILITY FOR
USE OR RELIANCE THEREON. IT IS THE RESPONSIBILITY OF THE USER OF H.B.
FULLER COMPANY PRODUCTS TO COMPLY WITH ALL APPLICABLE FEDERAL, STATE AND
LOCAL LAWS AND REGULATIONS.