| Common Name: | TOUGH GUY LEATHER CLEANER & PROTECTANT WIPES |
| Manufacturer: | W.W. GRAINGER |
| SDS Revision Date: | 10/27/2008 |
| SDS Format: | No Format Specified |
| Item Number(s): | 5EWC5 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
MATERIAL SAFETY DATA SHEET
PREPARED: 27 OCTOBER 2008
| SECTION 1 - PRODUCT AND COMPANY IDENTIFICATION |  |
PRODUCT(S): TOUGH GUY(TM) LEATHER CLEANER & PROTECTANT WIPES
FORMULA: B925
PART NUMBER(S): 5EWC5
COMPANY NAME & ADDRESS:
W.W. GRAINGER, INC.
100 GRAINGER PARKWAY
LAKE FOREST, IL 60045
1.847.565.5400
EMERGENCY NUMBERS:
IN CASE OF EMERGENCY, CALL: 1.800.228.5635
POISON CONTROL CENTER: 1-800-222-1222
MATERIAL SAFETY DATA SHEETS: WWW.GRAINGER.COM
| SECTION 2 - HAZARDS IDENTIFICATION | |
WARNING.
DIRECT EYE CONTACT WITH TOWEL CAUSES EYE ABRASION AND IRRITATION.
MAY BE HARMFUL IF SWALLOWED. MAY CAUSE SKIN IRRITATION.
POTENTIAL HEALTH EFFECTS:
EYES: CAUSES EYE ABRASION AND IRRITATION.
SKIN: MAY CAUSE SKIN IRRITATION.
INHALATION:
OVEREXPOSURE TO VAPORS (UNLIKELY) MAY CAUSE CENTRAL NERVOUS SYSTEM
EFFECTS.
INGESTION: MAY BE HARMFUL IF SWALLOWED.
SIGNS/SYMPTOMS OF EXPOSURE:
REDNESS, TEARING OR BURNING IN EYES. REDNESS, DRYING OR CRACKING OF SKIN.
IRRITATION OF THE THROAT OR STOMACH, NAUSEA, VOMITING, DIARRHEA IF
SWALLOWED. OVEREXPOSURE TO VAPORS (UNLIKELY) MAY CAUSE CENTRAL NERVOUS
SYSTEM EFFECTS SUCH AS DROWSINESS, DIZZINESS, FATIGUE OR LOSS OF
COORDINATION.
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE:
PRE-EXISTING SKIN CONDITIONS SUCH AS DERMATITIS MAY BE ADVERSELY AFFECTED
BY THIS AND OTHER OIL AND GREASE EFFECTIVE CLEANERS. PERSONS WITH
PRE-EXISTING LIVER AND KIDNEY CONDITIONS SHOULD FOLLOW GOOD CHEMICAL
HYGIENE PRACTICES TO AVOID COMPLICATIONS.
HMIS RATING:
HEALTH 1
FLAMMABILITY 1
REACTIVITY 0
PERSONAL PROTECTION NONE
| SECTION 3 - COMPOSITION/INFORMATION ON INGREDIENTS | |
INGREDIENT CAS NUMBER PERCENT RANGE
WATER 7732-18-5 40 - 70
POLYDIMETHYLSILOXANE 63148-62-9 15 - 40
METHOXYISOPROPANOL 107-98-2 1 - 5
PROPYLENE GLYCOL 57-55-6 1 - 5
C12-15 PARETH-7 68181-62-9 0.5 - 1.5
ANY SUBSTANCE LISTED AS HAZARDOUS BY THE STATES OF CALIFORNIA, FLORIDA,
ILLINOIS, MICHIGAN, NEW JERSEY, OHIO, PENNSYLVANIA OR TEXAS IS DESCRIBED
ABOVE IF KNOWN PRESENT IN REGULATED CONCENTRATIONS.
| SECTION 4 - FIRST AID MEASURES | |
EYES:
FLUSH EYES WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15 MINUTES WHILE
HOLDING EYELIDS OPEN. SEEK MEDICAL ATTENTION IMMEDIATELY.
SKIN:
FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES WHILE REMOVING
CONTAMINATED CLOTHING. IF IRRITATION ARISES AND PERSISTS SEEK MEDICAL
ATTENTION.
INHALATION:
UNLIKELY ROUTE AS LIQUID IS IMPREGNATED ON A TOWEL, MINIMIZING EXPOSURE VIA
THIS ROUTE. IF OVEREXPOSED MOVE TO FRESH AIR. IF SYMPTOMS DEVELOP SEEK
MEDICAL ATTENTION.
INGESTION:
NOT A LIKELY EXPOSURE ROUTE. IF A LARGE QUANTITY OF LIQUID IS SWALLOWED, DO
NOT INDUCE VOMITING, CALL A PHYSICIAN OR POISON CONTROL CENTER IMMEDIATELY.
NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
| SECTION 5 - FIRE FIGHTING MEASURES | |
FLASH POINT (PMCC): NONE TO BOILING, SOLUTION ON TOWEL.
EXTINGUISING MEDIA:
DRY CHEMICAL, CARBON DIOXIDE, FOAM, FOG OR WATER SPRAY. IF PLASTIC MATERIAL
IS IGNITED, IT IS DIFFICULT TO EXTINGUISH.
SPECIAL FIRE FIGHTING PROCEDURES:
KEEP CONTAINERS COOL AND VAPORS DOWN WITH WATER SPRAY. PREVENT RUNOFF FROM
ENTERING SEWERS AND PUBLIC WATERWAYS.
HAZARDOUS PRODUCTS OF COMBUSTION:
CARBON MONOXIDE, CARBON DIOXIDE, SILICONE DIOXIDE, FORMALDEHYDE
(>300 DEG. F), HYDROGEN SULFIDE, SULFUR DIOXIDE, SMOKE, SOOT AND
VARIOUS ORGANIC OXIDATION BY-PRODUCTS.
| SECTION 6 - ACCIDENTAL RELEASE MEASURES | |
SMALL SPILL:
CAUTION, SLIP HAZARD.
WIPE UP SMALL RELEASES WITH A DRY ABSORBENT CLOTH OR OTHER ABSORBENT
MATERIAL.
LARGE SPILL:
ABSORB LIQUID WITH VERMICULITE, ABSORBENT CLOTH, OR OTHER ABSORBENT
MATERIAL. PREVENT MATERIAL FROM ENTERING SEWERS AND DRAINS. VENTILATE AREA
AND BLOCK TRAFFIC. TRANSFER CONTAMINATED MATERIAL INTO SUITABLE CONTAINER
FOR PROPER DISPOSAL. CLEAN ANY SLIPPERY RESIDUES WITH SOAP AND WATER.
| SECTION 7 - HANDLING AND STORAGE | |
HANDLING:
DO NOT ALLOW TOWEL CONTACT WITH EYES. WASH THOROUGHLY AFTER HANDLING. AVOID
SWALLOWING. AVOID CONTACT WITH SKIN AND CLOTHING. AVOID INHALING VAPORS. DO
NOT SMOKE WHILE USING. FOLLOW GOOD CHEMICAL HYGIENE PRACTICES WHEN HANDLING
THIS MATERIAL. USE FROM ORIGINAL CONTAINER ONLY AND FOLLOW LABEL DIRECTIONS
CAREFULLY.
STORAGE:
KEEP CONTAINER CLOSED WHEN NOT IN USE. KEEP AWAY FROM HEAT SOURCES. STORE
IN A COOL WELL-VENTILATED AREA. KEEP OUT OF REACH OF CHILDREN. DO NOT
CONTAMINATE WATER, FOOD OR FEED BY USE OR STORAGE. KEEP FROM FREEZING.
| SECTION 8 - EXPOSURE CONTROLS/PERSONAL PROTECTION | |
ENGINEERING CONTROLS:
VENTILATION NOT USUALLY NECESSARY BUT SHOULD BE PROVIDED IN THE EVENT OF
OVEREXPOSURE.
EXPOSURE LIMITS:
METHOXYISOPROPANOL (CAS# 107-98-2):
100 PPM ACGIH-TLV
150 PPM STEL
EYE PROTECTION:
NONE NECESSARY. DO NOT ALLOW TOWEL TO DIRECTLY CONTACT EYES.
SKIN PROTECTION:
NONE NECESSARY. IF REPEATED OR PROLONGED CONTACT IS POSSIBLE, WEAR
IMPERVIOUS GLOVES.
RESPIRATORY PROTECTION:
NOT USUALLY NECESSARY. IF VAPORS ARE PRESENT OR IRRITATION IS EXPERIENCED,
USE NIOSH/MSHA APPROVED RESPIRATOR.
| SECTION 9 - PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE AND ODOR:
THIN, WHITE OPAQUE LIQUID WITH MINIMAL SCENT SATURATED ONTO TOWELS.
pH: 7.7 +/- 0.5
BOILING POINT: 212 F
SPECIFIC GRAVITY: 0.995
VAPOR DENSITY: >1
VAPOR PRESSURE: NO DATA
SOLUBILITY IN WATER: DISPERSIBLE
EVAPORATION RATE: NO DATA
VOLATILE ORGANIC COMPOUNDS (VOCS): 2.95% BY WEIGHT
| SECTION 10 - STABILITY AND REACTIVITY | |
HAZARDOUS POLYMERIZATION:
THIS PRODUCT WILL NOT UNDERGO HAZARDOUS POLYMERIZATION.
HAZARDOUS DECOMPOSITION OR BYPRODUCTS:
CARBON MONOXIDE, CARBON DIOXIDE, HYDROGEN SULFIDE, SULFUR DIOXIDE, SILICONE
DIOXIDE, FORMALDEHYDE (>300 DEG. F), SMOKE, SOOT AND VARIOUS ORGANIC
OXIDATION BY-PRODUCTS.
CHEMICAL STABILITY: STABLE
INCOMPATIBLE MATERIALS:
STRONG OXIDIZERS, STRONG ACIDS AND BASES, LIME, AMMONIA, ORGANIC AMINES,
CHLORATES, CHLORINE, SODIUM HYDROXIDE.
| SECTION 11 - TOXICOLOGICAL INFORMATION | |
METHOXYISOPROPANOL, CAS# 107-98-2:
DERMAL LD50: 13,000 MG/KG RABBIT
ORAL LD50: 7200 MG/KG, RAT
| SECTION 12 - ECOLOGICAL INFORMATION | |
NO DATA.
| SECTION 13 - DISPOSAL CONSIDERATIONS | |
DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE LOCAL, STATE, AND FEDERAL
REGULATIONS.
WASTE INFORMATION:
IF THIS PRODUCT BECOMES A WASTE, IT WOULD NOT BE HAZARDOUS AS DEFINED BY
RCRA (40 CFR 261). HOWEVER THE WASTE SHOULD BE PROPERLY EVALUATED IN CASE
OF MODIFICATION PRIOR TO DISPOSAL.
| SECTION 14 - TRANSPORT INFORMATION | |
THE FOLLOWING TRANSPORTATION INFORMATION IS BASED ON DEPARTMENT OF
TRANSPORTATION REGULATIONS FOUND IN 49 CFR. IF SHIPPING THIS PRODUCT BY
AIR PLEASE REFER TO INTERNATIONAL AIR TRANSPORT ASSOCIATION (IATA) DANGER
GOODS REGULATIONS. IF SHIPPING THIS PRODUCT BY OCEAN PLEASE REFER TO
INTERNATIONAL MARITIME DANGEROUS GOODS REGULATIONS (IMDG). TO FIND HOW
TO SHIP THIS PRODUCT PLEASE REFER TO THE UN# LISTED BELOW.
DOT INFORMATION:
UN #: NONE
PROPER SHIPPING DESCRIPTION: NOT REGULATED
HAZARD CLASS: NONE
PACKING GROUP: NONE
MARINE POLLUTANTS: NONE
| SECTION 15 - REGULATORY INFORMATION | |
US FEDERAL REGULATIONS:
TOXIC SUBSTANCES CONTROL ACT (TSCA):
ALL INGREDIENTS ARE ON THE TSCA INVENTORY OR EXEMPT FROM LISTING.
CERCLA RQ: NONE
SARA 313 COMPONENTS: NONE
STATE AND LOCAL REGULATIONS:
CALIFORNIA PROPOSITION 65:
WARNING:
THIS PRODUCT CONTAINS A TRACE CHEMICAL (ACETALDEHYDE) KNOWN TO THE STATE OF
CALIFORNIA TO CAUSE CANCER, AND/OR BIRTH DEFECTS OR OTHER REPRODUCTIVE
HARM.
| SECTION 16 - OTHER INFORMATION | |
WARNING!
THE USE OF THIS PRODUCT IS BEYOND THE CONTROL OF THE MANUFACTURER;
THEREFORE, NO GUARANTEE, EXPRESSED OR IMPLIED, IS MADE AS TO THE EFFECTS
OF SUCH OR THE RESULTS TO BE OBTAINED IF NOT USED IN ACCORDANCE WITH
DIRECTIONS OR ESTABLISHED SAFE PRACTICE. THE USER MUST ASSUME ALL
RESPONSIBILITY, INCLUDING INJURY OR DAMAGE, RESULTING FROM ITS MISUSE AS
SUCH, OR IN COMBINATION WITH OTHER MATERIALS. THE MANUFACTURER WARRANTS
ONLY THAT THIS PRODUCT MEETS THE MANUFACTURER'S SPECIFICATIONS FOR SUCH
PRODUCT. THIS WARRANTY IS IN LIEU OF ALL OTHER WARRANTIES, EXPRESS OR
IMPLIED, AS TO DESCRIPTION, QUALITY, MERCHANTABILITY. FITNESS FOR ANY
PARTICULAR PURPOSE, PRODUCTIVENESS OR ANY OTHER MATTER, OF THIS PRODUCT.
THE MANUFACTURER SHALL BE IN NO WAY RESPONSIBLE FOR THE IMPROPER USE OF
THIS PRODUCT. THE SOLE AND EXCLUSIVE REMEDY AGAINST THE MANUFACTURER FOR
BREACH OF WARRANTY SHALL BE REIMBURSEMENT OF THE PURCHASE PRICE OF THE
PRODUCT IN THE EVENT THAT A DEFECTIVE CONDITION OF THE PRODUCT SHALL BE
FOUND TO EXIST. NO OTHER REMEDY (INCLUDING BUT NOT LIMITED TO INCIDENTAL
OR CONSEQUENTIAL DAMAGES FOR INJURY TO PERSON OR PROPERTY OR ANY OTHER
INCIDENTAL OR CONSEQUENTIAL LOSS) SHALL BE AVAILABLE.