| Common Name: | CLEAN 2030 |
| Manufacturer: | MASTER CHEMICAL |
| SDS Revision Date: | 2/8/2011 |
| SDS Format: | No Format Specified |
| Item Number(s): | 6VKL4, 6VKL5, 6VKL6 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
MATERIAL SAFETY DATA SHEET
CLEAN 2030
| 1. CHEMICAL PRODUCT AND COMPANY IDENTIFICATION |  |
PRODUCT NAME: CLEAN 2030
MATERIAL TYPE:
CLEANER/CORROSION INHIBITOR FOR ULTRASONIC AND IMMERSION WASHERS
CLASSIFICATION/SYNONYM(S): NONE/NONE
PRODUCT USE: WASHING COMPOUND FOR ULTRASONIC AND IMMERSION WASHERS
MANUFACTURER ADDRESS:
MASTER CHEMICAL CORPORATION
501 WEST BOUNDARY
PERRYSBURG, OH 43551-1200
EMERGENCY TELEPHONE: 419-874-7902
FAX NUMBER: 419-874-0684
| 2. COMPOSITION/INFORMATION ON INGREDIENTS | |
COMPONENT OSHA ACGIH OTHER LIMITS CAS # % RANGE
PEL TLV RECOM.
THE EXACT CHEMICAL IDENTITIES AND PERCENTAGES OF THE RAW MATERIALS
USED IN CLEAN 2030 ARE TRADE SECRETS. THIS INFORMATION IS BEING
WITHHELD AS PROVIDED FOR IN THE OCCUPATIONAL SAFETY AND HEALTH
ADMINISTRATION'S HAZARD COMMUNICATION RULE (29 CFR 1910.1200).
| 3. HAZARDS IDENTIFICATION | |
EMERGENCY OVERVIEW:
YELLOW LIQUID
FIRE MAY PRODUCE OXIDES OF CARBON AND NITROGEN
POTENTIAL HEALTH EFFECTS:
ACUTE EFFECTS OF OVEREXPOSURE EXPECTED TO BE:
EYE CONTACT: NONIRRITANT
SKIN CONTACT: NONIRRITANT
CHRONIC EFFECTS OF OVEREXPOSURE: NONE CURRENTLY KNOWN
PRODUCT/INGREDIENTS LISTED AS CARCINOGEN OR POTENTIAL CARCINOGEN?:
NTP ANNUAL REPORT: NO
IARC MONOGRAPHS: NO
OSHA: NO
SIGNS AND SYMPTOMS OF EXPOSURE: NONE
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE: NONE KNOWN
| 4. FIRST AID MEASURES | |
EMERGENCY AND FIRST AID PROCEDURES:
EYES: FLUSH IMMEDIATELY WITH COOL, CLEAN WATER FOR AT LEAST 15 MINUTES
SKIN: WASH WITH MILD SOAP AND WARM WATER
INHALATION: MOVE TO FRESH AIR
INGESTION: IF LARGE QUANTITIES ARE INGESTED, CONTACT A PHYSICIAN
IN EVERY CASE GET MEDICAL ATTENTION AS REQUIRED
| 5. FIRE FIGHTING MEASURES | |
FLASH POINT (TEST METHOD): NONE TO BOILING (COC)
FLAMMABLE LIMITS: NOT DETERMINED
EXTINGUISHING MEDIA:
AS APPROPRIATE FOR THE SURROUNDING FIRE:
WATER (FLOOD WITH WATER), DRY CHEMICAL, CO2, OR "ALCOHOL" FOAM
SPECIAL FIRE FIGHTING PROCEDURES: NONE
UNUSUAL FIRE AND EXPLOSION HAZARDS: NONE
| 6. ACCIDENTAL RELEASE MEASURES | |
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED:
MOP UP OR USE DRY ABSORBENT
| 7. HANDLING AND STORAGE | |
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING:
AVOID CONTACT WITH EYES. AVOID PROLONGED OR REPEATED SKIN CONTACT WITH THE
CONCENTRATE. WASH THOROUGHLY AFTER HANDLING. DO NOT SWALLOW. REFER TO
CONTAINER LABELS.
OTHER PRECAUTIONS: NONE
| 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
RESPIRATORY PROTECTION (SPECIFY TYPE): NONE
VENTILATION:
LOCAL EXHAUST: NOT NORMALLY REQUIRED
MECHANICAL (GENERAL): GENERAL ROOM VENTILATION SHOULD BE SUFFICIENT
SPECIAL: NONE
OTHER: NONE
PROTECTIVE GLOVES: NONE NORMALLY REQUIRED.
OTHER PROTECTIVE EQUIPMENT: NONE
EYE PROTECTION: SAFETY GLASSES
EXPOSURE LIMITS:
NONE ESTABLISHED BY ACGIH OR OSHA FOR PRODUCT AS WHOLE REFER TO SECTION 2
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE: YELLOW LIQUID
ODOR: MILD, DETERGENT
pH OF CONCENTRATE (AS RANGE): 11.5 - 12.0
TYPICAL OPERATING pH (AS RANGE): 10.5 - 11.0
BOILING POINT (ASTM D86): 215 DEG. F (102 DEG. C)
FREEZING POINT: 35 DEG. F (2 DEG. C)
SOLUBILITY IN WATER: SOLUBLE
SPECIFIC GRAVITY (H2O=1): 1.117
V.O.C. CONTENT (EPA METHOD 24): NOT DETERMINED
EVAPORATION RATE (BUTYL ACETATE=1): NOT DETERMINED
| 10. STABILITY AND REACTIVITY | |
STABILITY: STABLE
CONDITIONS TO AVOID: NONE
INCOMPATIBILITY (MATERIALS TO AVOID): STRONG ACIDS AND OXIDIZERS
HAZARDOUS COMBUSTION OR DECOMPOSITION PRODUCTS:
THERMAL DECOMPOSITION (FIRE) MAY PRODUCE OXIDES OF CARBON AND NITROGEN
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR
CONDITIONS TO AVOID: NONE
| 11. TOXICOLOGICAL INFORMATION | |
STUDY TEST ANIMAL RESULTS
CONCENTRATE 10% SOLUTION
PRIMARY SKIN IRRITATION RABBIT NONIRRITANT NONIRRITANT
(PDI = 4.96) (PDI = 0.0)
| 12. ECOLOGICAL INFORMATION | |
NO DATA AVAILABLE
| 13. DISPOSAL CONSIDERATIONS | |
WASTE DISPOSAL METHOD:
MUST COMPLY WITH LOCAL, STATE, AND FEDERAL REGULATIONS. IF PRE-TREATMENT
IS NEEDED, CHEMICAL TREATMENT MAY BE USED. CONTACT MASTER CHEMICAL
TECH LINE (1-800-537-3365) FOR ASSISTANCE.
| 14. TRANSPORT INFORMATION | |
DEPARTMENT OF TRANSPORTATION:
DOT HAZARD CLASS: NONE
CLEAN 2030 IS NOT CLASSIFIED AS A HAZARDOUS MATERIAL BY DOT.
| 15. REGULATORY INFORMATION | |
RESOURCE CONSERVATION AND RECOVERY ACT:
EPA HAZARDOUS WASTE NUMBER(S): NONE
CLEAN 2030 IS NOT CLASSIFIED AS A HAZARDOUS WASTE BY EPA.
TOXIC SUBSTANCES CONTROL ACT:
ALL CLEAN 2030 INGREDIENTS ARE LISTED ON THE TSCA INVENTORY OF CHEMICAL
SUBSTANCES.
SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986:
CLEAN 2030 DOES NOT CONTAIN ANY SECTION 302/304 EXTREMELY HAZARDOUS
SUBSTANCES OR SECTION 313 TOXIC CHEMICALS.
| 16. OTHER INFORMATION | |
HMIS HAZARD INDEX NFPA RATING
CONCENTRATE:
(HEALTH) H 1 H 1
(FIRE) F 0 F 0
(REACTIVITY) R 0 R 0
(PERSONAL PROTECTION) PP A (SAFETY GLASSES) SPECIAL HAZARDS NONE
TYPICAL WORKING SOLUTION:
H 1 H 1
F 0 F 0
R 0 R 0
PP A (SAFETY GLASSES) SPECIAL HAZARDS NONE
KEY:
0 = MINIMAL
1 = SLIGHT
2 = MODERATE
3 = SERIOUS
4 = SEVERE
THIS INFORMATION IS INTENDED SOLELY FOR THE USE OF INDIVIDUALS TRAINED IN
THE PARTICULAR SYSTEM.
(C) 2005 - 2009 MASTER CHEMICAL CORPORATION.
THE INFORMATION HEREIN IS GIVEN IN GOOD FAITH AND BELIEVED CURRENT AS OF
THE DATE OF THIS MSDS. BECAUSE CONDITIONS OF USE ARE BEYOND OUR CONTROL,
NO GUARANTEE, REPRESENTATION, OR WARRANTY EXPRESSED OR IMPLIED IS MADE.
CONSULT MASTER CHEMICAL CORPORATION FOR FURTHER INFORMATION.
DATE OF PREPARATION: FEBRUARY 8, 2011