| Common Name: | TOUGH GUY BASEBOARD STRIPPER |
| Manufacturer: | W.W. GRAINGER |
| SDS Revision Date: | 9/9/2009 |
| SDS Format: | No Format Specified |
| Item Number(s): | 2DCA8, 6PEC3 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
MATERIAL SAFETY DATA SHEET
PREPARED: 09 SEPTEMBER 2009
| SECTION 1 - PRODUCT AND COMPANY IDENTIFICATION |  |
PRODUCT(S): TOUGH GUY(TM) BASEBOARD STRIPPER
FORMULA: A346
PART NUMBER(S): 6PEC3
COMPANY NAME & ADDRESS:
W.W. GRAINGER, INC.
100 GRAINGER PARKWAY
LAKE FOREST, IL 60045
1.847.565.5400
EMERGENCY NUMBERS:
IN CASE OF EMERGENCY, CALL: 1.800.228.5635
POISON CONTROL CENTER: 1-800-222-1222
MATERIAL SAFETY DATA SHEETS: WWW.GRAINGER.COM
| SECTION 2 - HAZARDS IDENTIFICATION | |
WARNING. HARMFUL IF ABSORBED THROUGH SKIN. HARMFUL IF SWALLOWED. MAY CAUSE
EYE AND SKIN IRRITATION. MAY CAUSE RESPIRATORY TRACT IRRITATION.
OCCUPATIONAL OVEREXPOSURE MAY CAUSE CENTRAL NERVOUS SYSTEM EFFECTS.
CONTENTS UNDER PRESSURE.
POTENTIAL HEALTH EFFECTS:
EYES: MAY CAUSE EYE IRRITATION.
SKIN: HARMFUL IF ABSORBED THROUGH SKIN. MAY CAUSE SKIN IRRITATION.
INHALATION: MAY CAUSE RESPIRATORY TRACT IRRITATION.
INGESTION: HARMFUL IF SWALLOWED.
SIGNS/SYMPTOMS OF EXPOSURE:
REDNESS, TEARING OR BURNING IN EYES. REDNESS, BURNING AND CRACKING OF SKIN.
INHALATION OF HIGH LEVELS MAY CAUSE DIZZINESS, DROWSINESS AND LOSS OF
COORDINATION. IF SWALLOWED MAY CAUSE BURNING OF MOUTH, THROAT, ESOPHAGUS
AND STOMACH.
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE:
PRE-EXISTING SKIN, LIVER, KIDNEY, BLOOD AND RESPIRATORY TRACT DISORDERS MAY
BE ADVERSELY AFFECTED. FOLLOW GOOD CHEMICAL HYGIENE PRACTICES TO AVOID
THESE HAZARDS.
HMIS RATING:
HEALTH 2
FLAMMABILITY 0
REACTIVITY 0
PERSONAL PROTECTION B
| SECTION 3 - COMPOSITION/INFORMATION ON INGREDIENTS | |
INGREDIENT CAS NUMBER PERCENT RANGE
WATER 7732-18-5 60 - 100
2-BUTOXYETHANOL 111-76-2 10 - 30
ISOBUTANE 75-28-5 3 - 7
MONOETHANOLAMINE 141-43-5 3 - 7
PROPANE 74-98-6 1 - 5
ANY SUBSTANCE LISTED AS HAZARDOUS BY THE STATES OF CALIFORNIA, FLORIDA,
ILLINOIS, MICHIGAN, NEW JERSEY, OHIO, PENNSYLVANIA OR TEXAS IS DESCRIBED
ABOVE IF KNOWN PRESENT IN REGULATED CONCENTRATIONS.
| SECTION 4 - FIRST AID MEASURES | |
EYES:
FLUSH EYES WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15 MINUTES WHILE
HOLDING EYELIDS OPEN. SEEK MEDICAL ATTENTION IMMEDIATELY.
SKIN:
WASH WITH SOAP AND WATER. REMOVE CONTAMINATED CLOTHING AND SHOES. IF
IRRITATION ARISES AND PERSISTS SEEK MEDICAL ATTENTION.
INHALATION:
MOVE TO FRESH AIR. IF BREATHING HAS STOPPED, QUALIFIED PERSONNEL SHOULD
ADMINISTER ARTIFICIAL RESPIRATION.
INGESTION:
IF A LARGE QUANTITY OF LIQUID IS SWALLOWED, DO NOT INDUCE VOMITING, CALL A
PHYSICIAN OR POISON CONTROL CENTER IMMEDIATELY. IF CONSCIOUS, DRINK PLENTY
OF WATER OR MILK. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
| SECTION 5 - FIRE FIGHTING MEASURES | |
FLASHPOINT (PMCC): NONE
EXTINGUISHING MEDIA:
NOT USUALLY NECESSARY AS THIS PRODUCT DOES NOT READILY SUPPORT COMBUSTION.
USE AN EXTINGUISHING AGENT APPROPRIATE FOR FIRE'S FUEL SOURCE.
SPECIAL FIRE FIGHTING PROCEDURES:
KEEP CONTAINERS COOL AND VAPORS DOWN WITH WATER SPRAY. PREVENT RUNOFF FROM
ENTERING SEWERS AND PUBLIC WATERWAYS. WEAR SELF-CONTAINED BREATHING
APPARATUS (SCBA) IN CHEMICAL FIRES.
HAZARDOUS PRODUCTS OF COMBUSTION: OXIDES OF CARBON AND NITROGEN.
| SECTION 6 - ACCIDENTAL RELEASE MEASURES | |
SMALL SPILL:
WIPE UP SMALL RELEASES WITH A DRY ABSORBENT CLOTH OR OTHER ABSORBENT
MATERIAL.
LARGE SPILL:
VENTILATE AREA AND BLOCK TRAFFIC. ABSORB LIQUID WITH VERMICULITE, ABSORBENT
CLOTH, OR OTHER ABSORBENT MATERIAL. PREVENT MATERIAL FROM ENTERING SEWERS
AND DRAINS. TRANSFER CONTAMINATED MATERIAL INTO SUITABLE CONTAINER FOR
PROPER DISPOSAL.
| SECTION 7 - HANDLING AND STORAGE | |
HANDLING:
AVOID CONTACT WITH EYES, SKIN AND CLOTHING. DO NOT SWALLOW. WASH THOROUGHLY
AFTER HANDLING AND LAUNDER CLOTHING BEFORE REUSE. AVOID INHALING MISTS OR
VAPORS. DO NOT DELIBERATELY CONCENTRATE AND INHALE VAPORS. USE WITH
ADEQUATE VENTILATION. DIRECT SPRAY AWAY FROM FACE. SPRAY CAN IN UPRIGHT
POSITION ONLY. FOLLOW GOOD CHEMICAL HYGIENE PRACTICES WHEN HANDLING THIS
MATERIAL. USE FROM ORIGINAL CONTAINER ONLY AND FOLLOW LABEL DIRECTIONS
CAREFULLY.
STORAGE:
KEEP AWAY FROM HEAT, SPARKS, OPEN FLAME AND DIRECT SUNLIGHT. STORE IN A
COOL (LESS THAN 120 DEG. F) WELL-VENTILATED AREA. KEEP OUT OF REACH OF
CHILDREN. DO NOT CONTAMINATE WATER, FOOD OR FEED BY USE OR STORAGE. DO NOT
PUNCTURE OR INCINERATE CONTAINER. REPLACE CAP WHEN NOT IN USE.
| SECTION 8 - EXPOSURE CONTROLS/PERSONAL PROTECTION | |
ENGINEERING CONTROLS:
VENTILATION NOT USUALLY NECESSARY BUT SHOULD BE PROVIDED IN THE EVENT OF
OVEREXPOSURE.
EXPOSURE LIMITS:
2-BUTOXYETHANOL (CAS# 111-76-2):
50 PPM OSHA; 20 PPM ACGIH (SKIN DESIGNATION)
ISOBUTANE (CAS# 75-28-5): 800 PPM OSHA; 800 PPM ACGIH
MONOETHANOLAMINE (CAS# 141-435): 3 PPM OSHA; 3 PPM ACGIH; 6 PPM STEL
PROPANE (CAS# 74-98-6): 1000 PPM OSHA; ASPHYXIANT ACGIH
EYE PROTECTION:
YES, WEAR APPROVED SAFETY GLASSES OR GOGGLES IF DIRECT CONTACT IS POSSIBLE.
SKIN PROTECTION: YES, WEAR IMPERVIOUS GLOVES IF DIRECT CONTACT IS POSSIBLE.
RESPIRATORY PROTECTION:
NOT USUALLY NECESSARY. IF VAPORS ARE PRESENT OR IRRITATION IS EXPERIENCED,
USE NIOSH/MSHA APPROVED RESPIRATOR.
| SECTION 9 - PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE AND ODOR: PINK LIQUID WITH A FRUITY ODOR.
pH: 10.5
BOILING POINT: 212 DEG. F
SPECIFIC GRAVITY: 0.980
VAPOR DENSITY: >1
FLAME PROJECTION: NONE
SOLUBILITY IN WATER: COMPLETE
PRESSURE: 115 PSIG
VOLATILE ORGANIC COMPOUNDS (VOCS): 28.42% BY WEIGHT
| SECTION 10 - STABILITY AND REACTIVITY | |
HAZARDOUS POLYMERIZATION:
THIS PRODUCT WILL NOT UNDERGO HAZARDOUS POLYMERIZATION.
HAZARDOUS DECOMPOSITION OR BYPRODUCTS: OXIDES OF CARBON AND NITROGEN.
CHEMICAL STABILITY: STABLE
INCOMPATIBLE MATERIALS: STRONG ACIDS, ALKALIS AND OXIDIZING AGENTS.
| SECTION 11 - TOXICOLOGICAL INFORMATION | |
MONOETHANOLAMINE, CAS #141-43-5:
DERMAL LD50: >1.00 G/KG RABBIT
ORAL LD50: >1.00-2.00 G/KG RAT
| SECTION 12 - ECOLOGICAL INFORMATION | |
NO DATA.
| SECTION 13 - DISPOSAL CONSIDERATIONS | |
DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE LOCAL, STATE, AND FEDERAL
REGULATIONS.
WASTE INFORMATION:
IF THIS PRODUCT BECOMES A WASTE, IT WOULD NOT BE A HAZARDOUS WASTE AS
DEFINED BY RCRA (40CFR261). HOWEVER THE WASTE SHOULD BE PROPERLY EVALUATED
IN CASE OF MODIFICATION PRIOR TO DISPOSAL.
| SECTION 14 - TRANSPORT INFORMATION | |
THE FOLLOWING TRANSPORTATION INFORMATION IS BASED ON DEPARTMENT OF
TRANSPORTATION REGULATIONS FOUND IN 49 CFR. IF SHIPPING THIS PRODUCT BY AIR
PLEASE REFER TO INTERNATIONAL AIR TRANSPORT ASSOCIATION (IATA) DANGEROUS
GOODS REGULATIONS. IF SHIPPING THIS PRODUCT BY OCEAN PLEASE REFER TO
INTERNATIONAL MARITIME DANGEROUS GOODS REGULATIONS (IMDG). TO FIND HOW TO
SHIP THIS PRODUCT PLEASE REFER TO THE UN# LISTED BELOW.
UN # PROPER SHIPPING HAZARD PACKING
DESCRIPTION CLASS GROUP
DOT INFORMATION NONE CONSUMER COMMODITY ORM-D NONE
MARINE POLLUTANTS: NONE
| SECTION 15 - REGULATORY INFORMATION | |
US FEDERAL REGULATIONS:
TOXIC SUBSTANCES CONTROL ACT (TSCA):
ALL INGREDIENTS ARE ON THE TSCA INVENTORY OR EXEMPT FROM LISTING.
CERCLA RQ: NONE
SARA 313 COMPONENTS: NONE
STATE AND LOCAL REGULATIONS:
CALIFORNIA PROPOSITION 65:
THIS PRODUCT MAY CONTAIN TRACE CHEMICALS KNOWN TO THE STATE OF CALIFORNIA
TO CAUSE CANCER, AND/OR BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM.
| SECTION 16 - OTHER INFORMATION | |
WARNING!
THE USE OF THIS PRODUCT IS BEYOND THE CONTROL OF THE MANUFACTURER;
THEREFORE, NO GUARANTEE, EXPRESSED OR IMPLIED, IS MADE AS TO THE EFFECTS OF
SUCH OR THE RESULTS TO BE OBTAINED IF NOT USED IN ACCORDANCE WITH
DIRECTIONS OR ESTABLISHED SAFE PRACTICE. THE USER MUST ASSUME ALL
RESPONSIBILITY, INCLUDING INJURY OR DAMAGE, RESULTING FROM ITS MISUSE AS
SUCH, OR IN COMBINATION WITH OTHER MATERIALS. THE MANUFACTURER WARRANTS
ONLY THAT THIS PRODUCT MEETS THE MANUFACTURER'S SPECIFICATIONS FOR SUCH
PRODUCT. THIS WARRANTY IS IN LIEU OF ALL OTHER WARRANTIES, EXPRESS OR
IMPLIED, AS TO DESCRIPTION, QUALITY, MERCHANTABILITY, FITNESS FOR ANY
PARTICULAR PURPOSE, PRODUCTIVENESS OR ANY OTHER MATTER, OF THIS PRODUCT.
THE MANUFACTURER SHALL BE IN NO WAY RESPONSIBLE FOR THE IMPROPER USE OF
THIS PRODUCT. THE SOLE AND EXCLUSIVE REMEDY AGAINST THE MANUFACTURER FOR
BREACH OF WARRANTY SHALL BE REIMBURSEMENT OF THE PURCHASE PRICE OF THE
PRODUCT IN THE EVENT THAT A DEFECTIVE CONDITION OF THE PRODUCT SHALL BE
FOUND TO EXIST. NO OTHER REMEDY (INCLUDING BUT NOT LIMITED TO INCIDENTAL OR
CONSEQUENTIAL DAMAGES FOR INJURY TO PERSON OR PROPERTY OR ANY OTHER
INCIDENTAL OR CONSEQUENTIAL LOSS) SHALL BE AVAILABLE.