| Common Name: | ISOPROPYL RUBBING ALCOHOL 70% |
| Manufacturer: | VI-JON |
| SDS Revision Date: | 5/5/2008 |
| SDS Format: | No Format Specified |
| Item Number(s): | 14U290, 2MRZ2 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
ITEM NUMBER: 810
05/05/2008
MATERIAL SAFETY DATA SHEET
VI-JON(R*)
| SECTION 1: PRODUCT AND COMPANY IDENTIFICATION |  |
VI-JON INCORPORATED
8515 PAGE AVENUE
SAINT LOUIS, MO 63114
PHONE: 314-427-1000
IN CASE OF SPILL EMERGENCY CONTACT:
CHEMTREC: 1-800-424-9300
PRODUCT NAME: ISOPROPYL RUBBING ALCOHOL 70%
PRODUCT CODE: 810
PRODUCT USE: VARIOUS
ISSUE DATE: 05/05/2008
SUPERSEDES DATE: NONE
| SECTION 2: HAZARDS IDENTIFICATION | |
EMERGENCY OVERVIEW: KEEP OUT OF REACH OF CHILDREN.
APPEARANCE/ODOR: A CLEAR, COLORLESS, MOBILE LIQUID WITH A CHARACTERISTIC
ODOR.
WARNING: FLAMMABLE (ISOPROPYL ALCOHOL)
TARGET (ISOPROPYL ALCOHOL) RESPIRATORY SYSTEM, SKIN, EYES, CNS, LIVER, BLOOD
AND REPRODUCTIVE SYSTEM.
POTENTIAL HEALTH EFFECTS: SEE SECTION 11 FOR MORE INFORMATION.
SYMPTOMS OF EXPOSURE:
INHALATION: MAY CAUSE IRRITATION OF THE RESPIRATORY TRACT.
INGESTION: MAY CAUSE NAUSEA, VOMITING AND DIARRHEA.
EYES: MAY CAUSE IRRITATION TO THE EYES.
SKIN: MAY CAUSE IRRITATION TO THE SKIN.
THIS PRODUCT DOES NOT CONTAIN ANY CARCINOGENS OR POTENTIAL CARCINOGENS AS
LISTED BY OSHA, IARC OR NTP.
THIS MATERIAL CONTAINS A COMPONENT THAT IS CONSIDERED HAZARDOUS BY THE OSHA
HAZARD COMMUNICATION STANDARD (29 CFR 1910.1200).
POTENTIAL ENVIRONMENTAL EFFECTS: SEE SECTION 12 FOR MORE INFORMATION.
| SECTION 3: COMPOSITION/INFORMATION ON INGREDIENTS | |
COMPONENT CAS# % BY WT.
ISOPROPYL ALCOHOL 67-63-0 70%
| SECTION 4: FIRST AID MEASURES | |
EMERGENCY FIRST AID PROCEDURES BY ROUTE OF EXPOSURE:
INHALATION:
IF SYMPTOMS ARE EXPERIENCE, REMOVE SOURCE OF CONTAMINATION OR MOVE VICTIM TO
FRESH AIR. IF AFFECTED PERSON IS NOT BREATHING, APPLY ARTIFICIAL
RESPIRATION. IF BREATHING IS DIFFICULT, GIVE OXYGEN. GET MEDICAL ATTENTION.
INGESTION:
DO NOT INDUCE VOMITING. IF THE MATERIAL IS SWALLOWED, GET MEDICAL ATTENTION
OR ADVICE.
SKIN:
IF IRRITATION IS EXPERIENCED, FLUSH WITH WATER. IF IRRITATION PERSISTS, GET
MEDICAL ATTENTION.
EYES:
IMMEDIATELY FLUSH EYES WITH WATER FOR AT LEAST 15 MINUTES WHILE HOLDING
EYELIDS OPEN. IF SYMPTOMS PERSIST, GET MEDICAL ATTENTION.
| SECTION 5: FIRE FIGHTING MEASURES | |
FLASH POINT: 70 DEG. F
AUTO IGNITION: (ISOPROPYL ALCOHOL) 399 DEG. C
FLAMMABILITY CLASSIFICATION: FLAMMABLE LIQUID IB
EXTINGUISHING MEDIA:
USE METHODS APPROPRIATE FOR THE SURROUNDING FIRE. CONSIDER WATER SPRAY OR
FOG, CARBON DIOXIDE, DRY CHEMICAL POWDER, OR ALCOHOL RESISTANT FOAM.
PRODUCTS OF COMBUSTION:
UPON DECOMPOSITION THIS PRODUCT MAY EMIT CARBON DIOXIDE, CARBON MONOXIDE
AND/OR LOW MOLECULAR WEIGHT HYDROCARBONS.
FIRE FIGHTING EQUIPMENT/INSTRUCTIONS:
WEAR PROTECTIVE CLOTHING AND EQUIPMENT SUITABLE FOR THE SURROUNDING FIRE,
INCLUDING HELMET, FACEMASK, AND SELF CONTAINED BREATHING APPARATUS.
NFPA RATING:
HEALTH 1
FIRE 3
REACTIVITY 0
HAZARD SCALE:
0 = MINIMAL
1 = SLIGHT
2 = MODERATE
3 = SERIOUS
4 = SEVERE
| SECTION 6: ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS:
FOR LARGE SPILLS WEAR GLOVES, SAFETY GLASSES AND WHEN LEVELS EXCEED OSHA PEL
USE APPROPRIATE NIOSH APPROVED RESPIRATORY PROTECTION. KEEP UNNECESSARY
PERSONNEL AWAY. ELIMINATE ALL SOURCES OF IGNITION OR FLAMMABLES THAT MAY
COME INTO CONTACT WITH A SPILL OF THIS MATERIAL.
ENVIRONMENTAL PRECAUTIONS: PREVENT DISCHARGE TO OPEN WATERS.
METHOD FOR CONTAINMENT:
ABSORB SPILLED LIQUID IN SUITABLE NON-FLAMMABLE INERT MATERIAL SUCH AS CLAY,
VERMICULITE OR DIATOMACEOUS EARTH.
METHODS FOR CLEAN-UP:
VENTILATE AREA OF LEAK OR SPILL. USE SPARK-PROOF TOOLS TO SWEEP OR SCRAPE UP
AND CONTAINERIZE IN APPROVED CHEMICAL WASTE CONTAINER. WASH SPILL AREA WITH
WATER.
| SECTION 7: HANDLING AND STORAGE | |
HANDLING:
KEEP AWAY FROM HEAT, SPARKS AND FLAME. PREVENT CONTACT WITH EYES. AVOID
INHALATION.
STORAGE:
KEEP THE CONTAINER TIGHTLY CLOSED AND IN A COOL, WELL VENTILATED PLACE.
| SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION | |
EXPOSURE GUIDELINES:
ISOPROPYL ALCOHOL (67-63-0):
ACGIH: 200 PPM TWA
OSHA: 400 PPM TWA; 980 MG/M3 TWA
ENGINEERING CONTROLS:
NORMAL ROOM VENTILATION IS USUALLY ADEQUATE UNDER NORMAL USE.
PERSONAL PROTECTIVE EQUIPMENT (PPE):
EYE/FACE PROTECTION: NONE NEEDED UNDER NORMAL USE.
SKIN PROTECTION: NONE NEEDED UNDER NORMAL USE.
RESPIRATORY PROTECTION: NONE NEEDED UNDER NORMAL USE.
GENERAL HYGIENE CONSIDERATIONS: NONE NEEDED UNDER NORMAL USE.
| SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE/COLOR: CLEAR, COLORLESS, MOBILE LIQUID
ODOR: ISOPROPYL ALCOHOL
PHYSICAL STATE: LIQUID
pH: NOT AVAILABLE.
VAPOR DENSITY: (ISOPROPYL ALCOHOL) 2.07 (AIR = 1)
BOILING POINT: (ISOPROPYL ALCOHOL) 82.5 DEG. C (DIN 43171)
VAPOR PRESSURE: (ISOPROPYL ALCOHOL) 42 HPA AT 20 DEG. C
MELTING POINT: (ISOPROPYL ALCOHOL) -90 DEG. C
FREEZING POINT: NOT AVAILABLE
FLASH POINT: (SEE SECTION 5)
FLAMMABILITY PROPERTIES: (SEE SECTION 5)
SOLUBILITY (IN WATER): SOLUBLE
SPECIFIC GRAVITY @ 25 DEG. C: 0.876-0.881
EVAPORATION RATE: NOT AVAILABLE
OCTANOL/WATER PARTITION COEFFICIENT (KOW):
(ISOPROPYL ALCOHOL): 0.05 AT 25 DEG. C
AUTO-IGNITION TEMPERATURE: (ISOPROPYL ALCOHOL) 399 DEG. C
DECOMPOSITION TEMPERATURE: NOT AVAILABLE
| SECTION 10: STABILITY AND REACTIVITY | |
STABILITY: STABLE UNDER NORMAL AMBIENT TEMPERATURES 70 DEG. C (21 DEG. C).
CONDITION TO AVOID: AVOID EXCESSIVE HEAT OR SOURCES OF IGNITION.
INCOMPATIBLE MATERIALS:
THIS PRODUCT REACTS WITH STRONG ACID, STRONG BASES, AND OXIDIZING AGENTS.
HAZARDOUS DECOMPOSITION:
UPON DECOMPOSITION, THIS PRODUCT EVOLVES CARBON MONOXIDE, CARBON DIOXIDE,
AND/ OR LOW WEIGHT HYDROCARBONS.
HAZARDOUS REACTIONS: HAZARDOUS POLYMERIZATION WILL NOT OCCUR.
| SECTION 11: TOXICOLOGY INFORMATION | |
ACUTE EFFECTS:
A:
GENERAL PRODUCT INFORMATION: PRODUCT CONTAINS ISOPROPYL ALCOHOL.
B:
COMPONENT ANALYSIS LD50:
ISOPROPYL ALCOHOL (67-63-0)
INHALATION LC50 RAT: 72.6 MG/L/4H
ORAL LD50 RAT: 4396 MG/KG
DERMAL LD50 RAT: 12800 MG/KG
DERMAL LD50 RABBIT: 12870 MG/KG
CHRONIC EFFECTS:
COMPONENT:
ISOPROPYL ALCOHOL (67-63-0)
CARCINOGENICITY: ACGIH A4 - NOT CLASSIFIABLE AS A HUMAN CARCINOGEN
NEUROTOXICITY:
THIS PRODUCT CONTAINS ISOPROPYL ALCOHOL, A CENTRAL NERVOUS SYSTEM TARGET.
MUTAGENICITY: NO INFORMATION AVAILABLE FOR PRODUCT.
REPRODUCTIVE: NO INFORMATION AVAILABLE FOR PRODUCT.
DEVELOPMENTAL: THIS PRODUCT CONTAINS ISOPROPYL ALCOHOL, A DEVELOPMENTAL
HAZARD.
TARGET ORGANS: SKIN, EYES, CNS, KIDNEY, DEVELOPMENTAL AND RESPIRATORY
SYSTEM.
| SECTION 12: ECOLOGICAL INFORMATION | |
ECOTOXICITY: ISOPROPYL ALCOHOL (67-63-0)
96 HR EC50 SCENEDESMUS SUBSPICATUS: >1000 MG/L
72 HR EC50 SCENEDESMUS SUBSPICATUS: >1000 MG/L
96 HR LC50 PIMEPHALES PROMELAS: 9640 MG/L (FLOW THROUGH)
96 HR LC50 PIMEPHALES PROMELAS: 94900 MG/L (FLOW THROUGH) (29 DAYS OLD)
96 HR LC50 PIMEPHALES PROMELAS: 61200 MG/L (FLOW THROUGH) (31 DAYS OLD)
5 MIN EC50 PHOTOBACTERIUM PHOSPHOREUM: 35390 MG/L
48 HR EC50 DAPHNIA MAGNA: 13299 MG/L
| SECTION 13: DISPOSAL CONSIDERATIONS | |
DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE, AND LOCAL REGULATIONS.
| SECTION 14: TRANSPORTATION INFORMATION | |
SHIPPING NAME: CONSUMER COMMODITY ORM-D
PROPER SHIPPING NAME FOR NON-CONSUMER COMMODITY: ISOPROPANOL, 3, UN1219,
PGII.
| SECTION 15: REGULATORY INFORMATION | |
ISOPROPYL ALCOHOL, A COMPONENT OF THIS PRODUCT, IS ON THE TSCA INVENTORY.
THE FOLLOWING COMPONENTS APPEAR ON ONE OR MORE OF THE FOLLOWING STATE
HAZARDOUS SUBSTANCE LISTS:
COMPONENT CAS# CA MA MN NJ PA
ISOPROPYL ALCOHOL 67-63-0 YES YES YES YES YES
| SECTION 16: OTHER INFORMATION | |
PREPARED BY: VI-JON INC.
DISCLAIMER:
THE INFORMATION AND RECOMMENDATIONS CONTAINED IN THE MATERIAL SAFETY DATA
SHEET (MSDS) ARE SUPPLIED PURSUANT TO 29 CFR 1910.1200 OF THE OCCUPATIONAL
SAFETY AND HEALTH STANDARDS HAZARD COMMUNICATION RULE. THE INFORMATION AND
RECOMMENDATIONSSET FORTH HEREIN ARE PRESENTED IN GOOD FAITH AND BELIEVED TO
BE CORRECT AS OF THIS DATE HEREOF.
VI-JON, HOWEVER, MAKES NO REPRESENTATION AS TO THE COMPLETENESS OR ACCURACY
THEREOF, AND INFORMATION IS SUPPLIED UPON THE EXPRESS CONDITION THAT THE
PERSONS RECEIVING THE INFORMATION WILL BE REQUIRED TO MAKE THEIR OWN
DETERMINATION AS TO ITS SUITABILITY FOR THEIR PURPOSES PRIOR TO USE. IN NO
EVENT WILL VI-JON BE RESPONSIBLE FOR ANY DAMAGES OF ANY NATURE WHATSOEVER
RESULTING FROM THE USE OF, RELIANCE UPON, OR THE MISUSE OF THIS INFORMATION.
USER ASSUMES ALL RISK OF USE, STORAGE AND HANDLING OF THE PRODUCT IN
COMPLIANCE WITH APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND REGULATIONS.
NO REPRESENTATIONS OR WARRANTIES, EITHER EXPRESSED OR IMPLIED, OF
MERCHANTABILITY, FITNESS FOR A PARTICULAR PURPOSE, OR OF ANY OTHER NATURE,
ARE MADE BY VI-JON HEREUNDER WITH RESPECT TO INFORMATION OR THE PRODUCT TO
WHICH THE INFORMATION REFERS. THE INFORMATION AS SUPPLIED HEREIN IS SIMPLY
TO BE INFORMATIVE AND INTENDED SOLELY TO ALERT THE USER OF THE SUBSTANCE
WHICH IS THE SUBJECT MATTER OF THIS MSDS. THE ULTIMATE COMPLIANCE WITH
FEDERAL, STATE OR LOCAL REGULATIONS CONCERNING THE USE OF THIS COMPOUND, OR
COMPLIANCE WITH RESPECT TO PRODUCT LIABILITY, RESTS SOLELY UPON THE
PURCHASER THEREOF.
THIS INFORMATION RELATES TO THE MATERIAL DESIGNATED AND MAY NOT BE VALID
FOR SUCH MATERIAL USED IN COMBINATION WITH ANY OTHER MATERIALS NOR IN ANY
PROCESS.