| Common Name: | ZEROL 150 REFRIGERATION OIL |
| Manufacturer: | NU-CALGON WHOLESALER |
| SDS Revision Date: | 6/22/2006 |
| SDS Format: | No Format Specified |
| Item Number(s): | 12N578, 12N579, 12N580, 12N582, 12N583, 12N584, 12N585, 12N587, 12N588, 12N589, 12N592, 12N593, 12N594, 12N595, 12N596, 12N597, 12N598 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
NU-CALGON WHOLESALER, INC.
MATERIAL SAFETY DATA SHEET
ZEROL 150 REFRIGERATION OIL
| I - PRODUCT IDENTIFICATION |  |
COMPANY NAME: NU-CALGON WHOLESALER, INC.
ADDRESS:
2008 ALTOM COURT
ST. LOUIS, MO 63146-4151
PRODUCT NAME: ZEROL 150 REFRIGERATION OIL
SYNONYMS: REFRIGERATION FLUID
TEL NO:
(314) 469-7000
(800) 554-5499
CHEMTREC: (800) 424-9300
PRODUCT NUMBER: 4310
| II - HAZARDOUS INGREDIENTS OF MIXTURES | |
MATERIAL CAS# % BY WT TLV PEL
ALKYL BENZENE 68855-24-3 100 N/A N/A
ALL INGREDIENTS APPEAR ON THE INVENTORY OF CHEMICAL SUBSTANCES PUBLISHED BY
THE EPA UNDER AUTHORITY OF THE TOXIC SUBSTANCES CONTROL ACT (TSCA)
APPROX DIELECTIC CONSTANT: 2.1 (AIR=1)(NON-ADDITIZED OIL)
ALL INGREDIENTS ARE TSCA LISTED.
| III - PHYSICAL DATA | |
VAPOR PRESSURE:
MMHg: N/A
VAPOR DENSITY (AIR=1) 60-90 DEG. F: N/A
EVAPORATION RATE:
(ETHER=1): N/A
VOC CONTENT (% BY WT.): N/A
SOLUBILITY IN H2O: INSOLUBLE
pH @ N/AV SOLUTION: N/AV
FREEZING POINT DEG. F: N/AV
pH AS DISTRIBUTED: N/AV
BOILING POINT DEG. F: 315 DEG. C
APPEARANCE: WATER WHITE LIQUID
SPECIFIC GRAVITY H2O=1 @ 25 DEG. C: 0.87
ODOR: CHARACTERISTIC
| IV - FIRE AND EXPLOSION | |
FLASH POINT F: (COC) 311 DEG. F (MIN)
FLAMMABLE LIMITS: N/A
EXTINGUISHING MEDIA: CO2, DRY CHEMICAL, FOAM, WATER FOG.
SPECIAL FIRE FIGHTING PROCEDURES:
FOR FIRES INVOLVING THIS MATERIAL, DO NOT ENTER ANY CLOSED OR CONFINED FIRE
SPACE WITHOUT PROPER PROTECTION EQUIPMENT. THIS MAY INCLUDE SELF-CONTAINED
BREATHING APPARATUS TO PROTECT AGAINST THE HAZARDOUS EFFECT OF NORMAL
PRODUCTS OF COMBUSTION OR OXYGEN DEFICIENCY. READ ENTIRE MSDS.
UNUSUAL FIRE AND EXPLOSION HAZARDS: N/AV
| V - REACTIVITY DATA | |
STABILITY - CONDITIONS TO AVOID: STABLE
INCOMPATIBILITY: MAY REACT WITH STRONG OXIDIZING MATERIALS.
HAZARDOUS DECOMPOSITION PRODUCTS:
NORMAL COMBUSTION FORMS CARBON DIOXIDE AND WATER VAPOR; INCOMPLETE
COMBUSTION CAN PRODUCE CARBON MONOXIDE.
CONDITIONS CONTRIBUTING TO HAZARDOUS POLYMERIZATIONS: WILL NOT OCCUR.
| VI - HEALTH HAZARD DATA | |
EFFECTS OF OVEREXPOSURE (MEDICAL CONDITIONS AGGRAVATED/TARGET ORGAN
EFFECTS):
A. ACUTE (PRIMARY ROUTE OF EXPOSURE):
EYES:
APPLICATIONS INTO THE EYES OF RABBITS PRODUCED SLIGHT MEMBRANE IRRITATION
WITHOUT CORNEAL INJURY.
SKIN:
PRODUCT MAY CAUSE SKIN IRRITATION ON PROLONGED OR FREQUENTLY REPEATED
CONTACT. APPLICATION ONTO THE SKIN OF RABBITS PRODUCED MODERATE ERYTHEMA AND
EDEMA.
INGESTION: NOT EXPECTED TO BE ACUTELY TOXIC. (ORAL LD50 RATS >5G/KG).
INHALATION: NOT ACUTELY TOXIC.
B. SUBCHRONIC, CHRONIC, OTHER: NO AVAILABLE INFORMATION WAS FOUND.
C. MEDICAL CONDITIONS AGGRAVATED BY OVEREXPOSURE:
| VII - EMERGENCY AND FIRST AID PROCEDURES | |
INHALATION: N/A
EYES:
FLUSH EYES IMMEDIATELY WITH FRESH WATER FOR AT LEAST 15 MINUTES WHILE
HOLDING EYELIDS OPEN. IF IRRITATION PERSISTS, SEE A DOCTOR.
SKIN:
WASH SKIN THOROUGHLY WITH SOAP AND WATER. SEE A DOCTOR IF RASH OR BURN
OCCURS. LAUNDER CONTAMINATED CLOTHING.
INGESTION:
IF SWALLOWED, GIVE WATER OR MILK TO DRINK AND TELEPHONE FOR MEDICAL ADVICE.
CONSULT MEDICAL PERSONNEL BEFORE INDUCING VOMITING. IF MEDICAL ADVICE CANNOT
BE OBTAINED, THEN TAKE THE PERSON AND PRODUCT CONTAINER TO THE NEAREST
EMERGENCY TREATMENT CENTER OR HOSPITAL.
| VIII - SPILL OR LEAK PROCEDURE | |
SPILL MANAGEMENT:
STOP THE SOURCE OF THE LEAK OR RELEASE. CLEAN UP RELEASES AS SOON AS
POSSIBLE. CONTAIN LIQUID TO PREVENT FURTHER CONTAMINATION OF SOIL, SURFACE
WATER OR GROUND WATER. CLEAN UP SMALL SPILLS WITH ABSORBENT MATERIAL AND
REMOVE CONTAMINATED SOIL. REPORT AND RESPOND TO LARGER RELEASE
WASTE DISPOSAL METHODS:
PLACE CONTAMINATED MATERIALS IN DISPOSABLE CONTAINERS AND DISPOSE OF IN A
MANNER CONSISTENT WITH APPLICABLE REGULATIONS. CONTACT LOCAL AUTHORITIES FOR
APPROVED DISPOSAL.
| IX - PROTECTION INFORMATION/CONTROL MEASURES | |
RESPIRATORY: NONE NORMALLY REQUIRED
EYE PROTECTION: SAFETY GOGGLES
GLOVE: RUBBER GLOVES
OTHER CLOTHING AND EQUIPMENT: WEAR IMPERVIOUS CLOTHING.
VENTILATION: N/AV
| X - SPECIAL PRECAUTIONS | |
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING:
DO NOT WELD, HEAT OR DRILL CONTAINER. RESIDUE MAY IGNITE WITH EXPLOSIVE
VIOLENCE IF HEATED SUFFICIENTLY.
CAUTION!
DO NOT USE PRESSURE TO EMPTY DRUM OR EXPLOSION MAY RESULT.
ADDITIONAL INFORMATION: READ AND OBSERVE ALL LABEL PRECAUTIONS.
NFPA:
HEALTH HAZARD 0
FIRE HAZARD 1
REACTIVITY 0
SPECIFIC HAZARD
HMIS RATING:
HEALTH HAZARD 0
FIRE HAZARD 1
REACTIVITY 0
PERSONAL PROTECTION X (SEC. 9)
REVISION DATE: 06/22/2006
SELLER MAKES NO WARRANTY, EXPRESSED OR IMPLIED, CONCERNING THE USE OF THIS
PRODUCT OTHER THAN INDICATED ON THE LABEL. BUYER ASSUMES ALL RISK OF USE
AND/OR HANDLING OF THIS MATERIAL WHEN SUCH USE AND/OR HANDLING IS CONTRARY
TO LABEL INSTRUCTIONS. WHILE SELLER BELIEVES THAT THE INFORMATION CONTAINED
HEREIN IS ACCURATE, SUCH INFORMATION IS OFFERED SOLELY FOR ITS CUSTOMERS'
CONSIDERATION AND VERIFICATION UNDER THEIR SPECIFIC USE CONDITIONS.
CATEGORY: REFRIGERATION OIL