| Common Name: | AMMONIA INHALANTS, ANTISEPTIC SPRAY, BZK PREP PADS AND TOWELETTE, STERILE SALINE |
| Manufacturer: | SAFETEC OF AMERICA |
| SDS Revision Date: | 4/4/2007 |
| SDS Format: | No Format Specified |
| Item Number(s): | 14U296 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
MATERIAL SAFETY DATA SHEET
MAY BE USED TO COMPLY WITH OSHA'S HAZARD COMMUNICATION STANDARD
29 CFR 1910.1200. STANDARD MUST BE CONSULTED FOR SPECIFIC REQUIREMENTS.
SAFETEC OF AMERICA
HMIS HAZARD RATING:
HEALTH 3
FLAMMABILITY 3
REACTIVITY 0
0 = INSIGNIFICANT
1 = SLIGHT
2 = MODERATE
3 = HIGH
4 = EXTREME
TRANSPORTATION INFORMATION:
PROPER SHIPPING NAME: SOLIDS CONTAINING CORROSIVE LIQUID, (N.O.S. AMMONIA)
HAZARD CLASS / PKG. GRP.: 8/II
REF.: 173.154(B)(C)
IDENTIFICATION NUMBER: UN3244
LABEL: ORM-D
| SECTION 1 - PRODUCT / COMPANY IDENTIFICATION |  |
IDENTITY (AS USED ON LABEL AND LIST): SAFETEC AMMONIA INHALANTS
MANUFACTURER'S NAME: SAFETEC OF AMERICA, INC.
ADDRESS (NUMBER, STREET, P.O. BOX): 887 KENSINGTON AVENUE
(CITY, STATE AND ZIP CODE): BUFFALO, NY 14215
EMERGENCY TELEPHONE NUMBER (24 HOURS): (800) 255-3924
TELEPHONE NUMBER FOR INFORMATION: (716) 895-1822
DATE PREPARED: APRIL 04, 2007
SUPERSEDES: MARCH 30, 2007
| SECTION 2 - HAZARDOUS INGREDIENTS / IDENTITY INFORMATION | |
HAZARDOUS COMPONENTS CAS # % (WT.) AIRBORNE LIMITS
(SPECIFIC CHEMICAL (OPTIONAL) ACGIH OSHA NIOSH
IDENTITY; COMMON
NAME(S))
AMMONIA 7664-41-7 25 PPM 50 PPM 300 PPM
(TLV/ (PEL/ (IDLH)
TWA) TWA)
35 PPM
(TLV/
STEL)
ETHANOL 64-17-5 1000 PPM 1000 PPM 3300 PPM
(TLV) (PEL) (LEL)
THIS PRODUCT IS NOT KNOWN TO CONTAIN A SUBSTANCE SUBJECT TO SECTION 313 OF
TITLE III OF THE SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986
(SARA) AND 40 CFR 372 AT OR ABOVE MINIMAL AMOUNTS.
| SECTION 3 - HEALTH HAZARD DATA | |
ROUTES OF ENTRY - SIGNS AND EMERGENCY AND FIRST AID PROCEDURES
SYMPTOMS OF EXPOSURE
INHALATION:
BRIEF (MINUTES) INHALATION WILL REMOVE VICTIM TO FRESH AIR; PROVIDE
CAUSE IRRITATION OF THE UPPER OXYGEN IF BREATHING IS DIFFICULT;
RESPIRATORY TRACT, ALTHOUGH GET MEDICAL ATTENTION.
CONSTANT INHALATION MAY ALSO CAUSE
HEADACHES, DIZZINESS, OR BREATHING
DIFFICULTY.
EYES:
CONTACT TO LIQUID OR VAPORS WILL IMMEDIATELY FLUSH EYES WITH CLEAR
CAUSE MILD TO EXTREME IRRITATION. RUNNING WATER FOR A MINIMUM OF 25
SEVERE EXPOSURE TO THE EYES MAY MINUTES WHILE HOLDING EYELIDS OPEN;
CAUSE BLINDNESS. GET MEDICAL ATTENTION.
INGESTION:
INGESTION OF THIS PRODUCT WILL CONTACT A POISON CONTROL CENTER
CAUSE SEVERE IRRITATION, BURNING, IMMEDIATELY. DO NOT INDUCE
AND PAIN ASSOCIATED SYMPTOMS SUCH VOMITING. DO NOT GIVE LIQUIDS IF
AS NAUSEA, VOMITING, DIARRHEA, THE VICTIM IS UNCONSCIOUS OR
OR DEATH. DROWSY. OTHERWISE, GIVE LARGE
AMOUNTS OF WATER. SEEK IMMEDIATE
MEDICAL ATTENTION.
SKIN:
CONTACT WITH SKIN MAY CAUSE WASH CONTAMINATED SKIN WITH LARGE
MILD SKIN IRRITATION AND BURNS. AMOUNTS OF WATER; IF IRRITATION
OCCURS AND PERSISTS, SEEK MEDICAL
ATTENTION. WASH CONTAMINATED
CLOTHING.
HEALTH HAZARDS (ACUTE AND CHRONIC):
THIS PRODUCT IS NOT CONSIDERED A HEALTH HAZARD.
CARCINOGENICITY: NO ADDITIONAL INFORMATION
NTP?: NO
IARC MONOGRAPHS?: NO
OSHA REGULATED?: NO
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE:
PREEXISTING SKIN, EYE, OR RESPIRATORY DISORDERS MAY BECOME AGGRAVATED
THROUGH EXPOSURE.
| SECTION 4 - FIRE FIGHTING MEASURES | |
FLASH POINT (METHOD USED): 78.1 DEG. F (CLOSED CUP)
FLAMMABLE LIMITS (% VOLUME IN AIR FOR LOWEST FLASHING COMPONENT):
LEL: UNKNOWN
UEL: UNKNOWN
EXTINGUISHING MEDIA:
WATER SPRAY, DRY CHEMICALS, ALCOHOL-TYPE OR ALL-PURPOSE FOAM, CO2
SPECIAL FIRE FIGHTING PROCEDURES:
POSITIVE PRESSURE NIOSH APPROVED SELF-CONTAINED BREATHING APPARATUS.
UNUSUAL FIRE AND EXPLOSIVE HAZARDS: CONCENTRATED VAPORS MAY BE FLAMMABLE.
| SECTION 5 - PRECAUTIONS FOR SAFE HANDLING AND | |
USE / LEAK PROCEDURES
STEPS TO BE TAKEN IF MATERIAL IS SPILLED OR RELEASED:
REMOVE ALL SOURCES OF IGNITION. AVOID PROLONGED EXPOSURE TO VAPORS. SPILLS
SHOULD BE COLLECTED, NOT WASHED INTO SEWER OR ENVIRONMENT. USE SUITABLE
DISPOSAL DOT CONTAINERS. REPORT PER REGULATORY REQUIREMENTS. WEAR NIOSH
APPROVED SELF-CONTAINED BREATHING APPARATUS, PROTECTIVE CLOTHING, GLOVES,
AND GOGGLES.
WASTE DISPOSAL METHODS:
DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND FEDERAL REGULATIONS.
PRODUCTS CLASSIFIED AS NON-HAZARDOUS MAY BECOME HAZARDOUS WASTE UPON
CONTACT WITH OTHER PRODUCTS. REFER TO "40 CFR PROTECTION OF ENVIRONMENT
PARTS 260-299" FOR COMPLETE WASTE DISPOSAL REGULATIONS. CONSULT YOUR
LOCAL, STATE, OR FEDERAL ENVIRONMENTAL PROTECTION AGENCY BEFORE DISPOSING
OF ANY CHEMICALS.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE:
KEEP CONTAINER(S) TIGHTLY CLOSED WHEN NOT IN USE. AVOID INHALATION OF
VAPORS. STORE IN COOL, DRY, WELL VENTILATED AREA AWAY FROM, OXIDIZERS,
FLAME, IGNITION SOURCES, ACIDS, IODINE AND CHLORINE PRODUCTS, AND HEAT.
KEEP OUT OF REACH OF CHILDREN.
| SECTION 6 - EXPOSURE CONTROLS / PERSONAL PROTECTION | |
RESPIRATORY PROTECTION: ORDINARILY, NONE REQUIRED
PROTECTIVE GLOVES:
NONE REQUIRED FOR INDIVIDUAL PACKETS, REQUIRED FOR BULK MATERIAL.
OTHER PROTECTIVE CLOTHING OR EQUIPMENT:
EYE WASH STATIONS SHOULD BE NEARBY AND READY FOR USE.
VENTILATION: RECOMMENDED FOR INDIVIDUAL
LOCAL EXHAUST: PACKETS, REQUIRED FOR BULK MATERIAL.
VENTILATION: NONE REQUIRED FOR INDIVIDUAL
MECHANICAL (GENERAL): PACKETS, REQUIRED FOR BULK MATERIAL.
EYE PROTECTION:
NONE REQUIRED FOR INDIVIDUAL PACKETS, REQUIRED FOR BULK MATERIAL.
WORK / HYGIENIC PRACTICES:
PRACTICE SAFE WORK HABITS. USE ACCORDING TO LABEL INSTRUCTIONS.
| SECTION 7 - PHYSICAL / CHEMICAL PROPERTIES | |
BOILING POINT: NA
VAPOR PRESSURE (MMHg): NO DATA
VAPOR DENSITY (AIR=1): NO DATA
SOLUBILITY IN WATER: LIQUID IS SOLUBLE
APPEARANCE AND ODOR: OFF-WHITE, PREMOISTENED TOWELETTE; AMMONIA ODOR
SPECIFIC GRAVITY (WATER=1): 0.91
MELTING POINT: NOT APPLICABLE
pH: >12
EVAPORATION RATE (IPA=1): NA
% VOLATILES (BY VOLUME): NA
| SECTION 8 - STABILITY AND REACTIVITY | |
STABILITY:
UNSTABLE ( )
STABLE (XXX)
CONDITIONS TO AVOID: FLAME, SOURCES OF IGNITION, HEAT.
INCOMPATIBILITIES (MATERIALS TO AVOID):
OXIDIZERS, ACIDS, BLEACH, IODINE, METALS, DIMETHYL SULFATE, IODINE AND
CHLORINE CONTAINING PRODUCTS
HAZARDOUS DECOMPOSITION OR BYPRODUCTS:
THERMAL DECOMPOSITION MAY EMIT AMMONIA, CARBON OXIDES, NITROGEN OXIDES AND
HYDROGEN; OTHER UNIDENTIFIED ORGANIC COMPOUNDS.
HAZARDOUS POLYMERIZATION:
MAY OCCUR ( )
WILL NOT OCCUR (XXX)
THE INFORMATION CONTAINED HEREIN IS BELIEVED TO BE ACCURATE BUT IS NOT
WARRANTED TO BE SO. USERS ARE ADVISED TO CONFIRM IN ADVANCE OF NEED THAT
INFORMATION IS CURRENT, APPLICABLE AND SUITED TO THE CIRCUMSTANCES OF USE.
VENDOR ASSUMES NO RESPONSIBILITY FOR INJURY TO VENDEE OR THIRD PERSONS
PROXIMATELY CAUSED BY THE MATERIAL IF REASONABLE SAFETY PROCEDURES ARE
NOT ADHERED TO AS STIPULATED IN THE DATA SHEET. FURTHERMORE, VENDOR
ASSUMES NO RESPONSIBILITY FOR INJURY CAUSED BY ABNORMAL USE OF THIS
MATERIAL EVEN IF REASONABLE SAFETY PROCEDURES ARE FOLLOWED.
MSDS PREPARED BY:
SAFETEC OF AMERICA, INC.
887 KENSINGTON AVENUE
BUFFALO, NY 14215
(716) 895-1822
FORM REVISED: 6/2000
MATERIAL SAFETY DATA SHEET
ARI WHEN QUALITY COUNTS
PO BOX 510
ORCHARD HILL, GA 30266
DATE: JANUARY 1, 2010
1/5/2010 1:40 PM
FROM: ARI ARI
TO: +1 (239) 210-2983
| SECTION I - PRODUCT IDENTIFICATION | |
MANUFACTURER'S NAME: ARI
ADDRESS:
PO BOX 510
ORCHARD HILL, GA 30266
EMERGENCY PHONE #: 800-241-5064
TRADE NAME: ANTISEPTIC SPRAY
SYNONYMS: AEROSOL ANTISEPTIC SPRAY
HMIS:
HEALTH 1
FIRE 3
REACTIVITY 0
| SECTION II - MATERIAL ANALYSIS/ACTIVE INGREDIENTS | |
COMPONENT OR MATERIAL % OF MIXTURE CAS # TLV
CHEMICAL NAME
BENZOCAINE, USP 4.5% 94-09-7 NOT ESTABLISHED
BENZETHONIUM CHLORIDE .09% 57-09-0 NOT ESTABLISHED
DIPROPYLENE GLYCOL 40.41% 025265-71-8 NOT ESTABLISHED
A-46 HYDROCARBON 55.0% 68476-86-8 1000 PPM
| SECTION III - PHYSICAL DATA | |
BOILING POINT: 449 DEG. F
SOLUBILITY IN H2O % BY WEIGHT: COMPLETELY MISCIBLE
SPECIFIC GRAVITY H2O = 1: 1.032
VAPOR PRESSURE IN CAN PSI AT 70 DEG. F: 46
% VOLATILES BY VOLUME: 55.0%
pH: N/A
APPEARANCE AND ODOR: COLORLESS LIQUID, SLIGHT MENTHOL ODOR
| SECTION IV - FIRE AND EXPLOSION DATA | |
FLASH POINT (CLOSED CUP): >200 DEG. F
FLAME EXTENSION: WILL NOT EXTEND FLAME
FLAMMABLE EXPLOSIVE LIMITS (% VOLUME IN AIR):
LOWER: N/A
UPPER: 120 DEG. F
EXTINGUISHING METHODS: DRY CHEMICAL OR CO2
SPECIAL FIRE AND EXPLOSION PROCEDURES:
COOL CONTAINERS WITH WATER IF EXPOSED
UNUSUAL FIRE AND EXPLOSION HAZARD:
PRODUCT PACKAGED IN AEROSOL FORM, WILL EXPLODE UNDER EXTREME HEAT.
| SECTION V - HEALTH HAZARD INFORMATION | |
HEALTH HAZARD DATA:
ROUTES OF EXPOSURE:
INHALATION: MAY IRRITATE UPPER RESPIRATORY TRACT AND CAUSE NUMBNESS.
SKIN CONTACT: MILDLY IRRITATING
EYE CONTACT: SPRAY CAN CAUSE PAIN AND GENERAL INFLAMMATION.
INGESTION: MAY CAUSE IRRITATION AND VOMITING
EFFECTS OF OVEREXPOSURE:
BASED ON AVAILABLE DATA, REPEATED EXPOSURES ARE NOT ANTICIPATED TO CAUSE
ANY SIGNIFICANT ADVERSE EFFECTS.
EMERGENCY AND FIRST AID PROCEDURES:
EYE: FLUSH WITH LARGE AMOUNTS OF WATER, LIFTING UPPER LIDS.
SKIN: WASH AREAS WITH SOAP AND WATER
INGESTION: RINSE MOUTH, AND CONSULT A PHYSICIAN.
INHALATION: REMOVE TO FRESH AIR.
| SECTION VI - REACTIVITY DATA | |
CONDITION CONTRIBUTING TO INSTABILITY:
STABLE UNDER NORMAL STORAGE CONDITIONS.
INCOMPATABILITY: STRONG OXIDIZING AGENTS.
HAZARDOUS DECOMPOSITION PRODUCTS: OXIDES OF CARBON, ALDEHIDES, AND ACIDS.
CONDITIONS CONTRIBUTING TO HAZARDOUS POLYMERIZATION: WILL NOT OCCUR.
| SECTION VII - SPILL OR LEAK PROCEDURES | |
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED:
NEUTRALIZING CHEMICAL: FLUSH SPILL AREA WITH WATER.
WASTE DISPOSAL METHOD:
DISPOSE OF IN ACCORDANCE WITH STATE, LOCAL AND FEDERAL REGULATIONS.
| SECTION VIII - INDUSTRIAL HYGIENE CONTROL MEASURES | |
VENTILATION REQUIREMENTS:
GOOD GENERAL VENTILATION SHOULD BE SUFFICIENT FOR MOST CONDITIONS.
SPECIFIC PERSONAL PROTECTIVE EQUIPMENT:
RESPIRATORY (SPECIFIC IN DETAIL): NONE REQUIRED.
EYE: NONE REQUIRED.
GLOVES: NONE REQUIRED.
OTHER CLOTHING AND EQUIPMENT: NONE REQUIRED.
| SECTION IX - SPECIAL PRECAUTIONS | |
PRECAUTIONARY STATEMENTS:
PACKAGED UNDER PRESSURE. DO NOT PUNCTURE, INCINERATE OR STORE ABOVE
120 DEG. F. FLAMMABLE. KEEP AWAY FROM HEAT SOURCE.
OTHER HANDLING AND STORAGE REQUIREMENTS:
STORE IN WELL VENTILATED AREAS, AWAY FROM BEAT, DIRECT SUNLIGHT, AND
SOURCES OF IGNITION. KEEP AWAY FROM OXIDIZING AGENTS. CONTAINERS SHOULD
NOT BE DROPPED. INSTALL PROTECTIVE CAPS FOR SHIPMENT.
DEPARTMENT OF TRANSPORTATION INFORMATION:
PROPER SHIPPING NAME: CONSUMER COMMODITY
HAZARD CLASS: ORM-D
PREPARED BY: ARI
DATE: JANUARY 1, 2010
DUKAL(R*)
CORPORATION
MATERIAL SAFETY DATA SHEET (MSDS)
BZK PREP PADS AND TOWELETTE
DUKAL CORPORATION
2 FLEETWOOD COURT
RONKONKOMA, NY 11779
631-656-3800
| SECTION I - PRODUCT IDENTIFICATION | |
PRODUCT: BZK PREP PADS AND TOWELETTE
PRODUCT TRADE NAME: DUKAL BZK PADS AND TOWELETTE (PRIVATE LABEL INCLUDED)
CHEMICAL NAME AND SYNONYMS: BENZALKONIUM CHLORIDE
CHEMICAL FORMULA: C22H40ClN
EMERGENCY TELEPHONE NUMBER: 631-656-3800
| SECTION II - HAZARDOUS INGREDIENTS | |
HAZARDOUS COMPONENTS OSHA PEL ACGIH TLV OTHER % (OPTIONAL)
(SPECIFIC CHEMICAL
IDENTITY COMMON NAME(S))
NO COMPONENT OVER: 1%
NFPA:
HEALTH 0
FLAMMABILITY 0
REACTIVITY 0
| SECTION III - PHYSICAL / CHEMICAL CHARACTERISTICS | |
PHYSICAL STATE: INDIVIDUALLY SEALED BZK PACKET
BOILING POINT: N/A
VAPOR PRESSURE (MMHg): N/A
VAPOR DENSITY: N/A
SPECIFIC GRAVITY: 0.878
MELTING POINT: N/A
EVAPORATION RATE (BUTYL ACETATE=1): N/A
SOLUBILITY IN WATER: PAD IS NOT SOLUBLE IN WATER
APPEARANCE AND ODOR: WHITE TOWELETTE SATURATED WITH SOLUTION
| SECTION IV - FIRE AND EXPLOSION HAZARD DATA | |
FLASH POINT (METHOD USED): N/A
FLAMMABLE LIMITS: N/A
LEL: N/A
UEL: N/A
EXTINGUISHING MEDIA: ANY TYPE
SPECIAL FIRE FIGHTING PROCEDURES:
WEAR PROPER PROTECTION, FIGHT FIRE FROM A SAFE DISTANCE.
UNUSUAL FIRE AND EXPLOSION HAZARDS: NONE KNOWN
| SECTION V - REACTIVITY DATA | |
STABILITY: STABLE
INCOMPATIBILITY (MATERIALS TO AVOID): NONE KNOWN
HAZARDOUS DECOMPOSITION OR BYPRODUCTS: NONE
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR
| SECTION VI - HEALTH AND HAZARD DATA | |
ROUTE(S) OF ENTRY:
INHALATION?: NONE
SKIN?: DISCONTINUE IF RASH OR IRRITATION OCCURS
INGESTION?: NONE
HEALTH HAZARDS (ACUTE AND CHRONIC):
PROLONGED BREATHING OF VAPORS MAY CAUSE COUGHING, SHORTNESS OF BREATH,
INTOXICATION. EYE CONTACT MAY CAUSE MODERATE IRRITATION.
CARCINOGENICITY:
NTP?: NA
LARC MONOGRAPH?: NA
OSHA REGULATED?: NA
SIGNS AND SYMPTOMS OF EXPOSURE: COUGHING, DIZZINESS AND WATERY EYES
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE:
SENSITIVE OR INFLAMED SKIN MAY BECOME IRRITATED.
EMERGENCY AND FIRST AID PROCEDURES:
IF LARGE QUANTITIES ARE INGESTED, ADMINISTER WARM WATER AND CONTACT
PHYSICIAN. WITH EYE CONTACT, FLUSH WITH WATER. IF IRRITATION PERSISTS,
CONTACT PHYSICIAN.
| SECTION VII - PRECAUTION FOR SAFE HANDLING AND USE | |
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED:
ELIMINATE ALL SOURCES OF IGNITION AND FLUSH WITH LARGE QUANTITIES OF WATER
SPRAY.
WASTE DISPOSAL METHOD: FOLLOW LOCAL, STATE AND FEDERAL REGULATIONS
STORAGE: NONE
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: NONE KNOWN
OTHER PRECAUTIONS: NONE KNOWN
| SECTION VIII - CONTROL MEASURES | |
RESPIRATORY PROTECTION (SPECIFIC TYPE): NA
VENTILATION:
LOCAL EXHAUST: NONE
MECHANICAL (GENERAL): NONE
SPECIAL: NA
OTHER: NA
PROTECTIVE GLOVES: NA
EYE PROTECTION:
GOGGLES: USE EYE BATH IF EYE CONTACT OCCURS.
OTHER PROTECTIVE CLOTHING OR EQUIPMENT: NA
WORK / HYGIENE PRACTICES: GOOD HYGIENIC PRACTICE.
| SECTION IX - INTERNATIONAL TRANSPORT INFORMATION | |
PRODUCT CLASS: DOT NOT REGULATED
UN NUMBER:
ISSUE DATE: 8-26-10
PREPARED BY: JIM VILARDI
DISCLAIMER:
THE INFORMATION PROVIDED ON THIS MSDS IS CORRECT TO THE BEST OF OUR
KNOWLEDGE, INFORMATION AND BELIEF AT THE DATE OF ITS PUBLICATION. THE
INFORMATION GIVEN IS DESIGNED ONLY AS A GUIDE FOR SAFE HANDLING, USE,
PROCESSING, STORAGE, TRANSPORTATION, DISPOSAL AND RELEASE AND IS NOT TO BE
CONSIDERED AS A WARRANTY OR QUALITY SPECIFICATION. THE INFORMATION RELATES
ONLY TO THE SPECIFIC MATERIAL DESIGNATED AND MAY NOT BE VALID FOR SUCH
MATERIAL USED IN COMBINATION WITH ANY OTHER MATERIAL OR IN ANY PROCESS,
UNLESS SPECIFIED IN THE TEXT
MAY BE USED TO COMPLY WITH OSHA'S HAZARD COMMUNICATION STANDARD
MATERIAL DATA SAFETY SHEET
HMIS RATINGS:
HEALTH 0
FLAMMABILITY 0
REACTIVITY 0
IDENTITY: SPERIAN(R*) STERILE SALINE SOLUTION
PRODUCT #S:
32-ST1050, 32-ST2050, 32-000440, 32-000445, 32-00446, 32-000448, 32-000449,
32-000451, 32-000452, 32-000454, 32-000455, 32-000457, 32-000458,
32-000460, 32-000461, 32-000462, 32-000463, 32-000465, 32-000470,
32-000471, 32-000494, 32-000497, 32-000498
| SECTION I | |
MANUFACTURER: SPERIAN EYE & FACE PROTECTION, INC.
ADDRESS:
825 EAST HIGHWAY 151
PLATTEVILLE, WI 53818
USA
EMERGENCY TELEPHONE: 1-800-336-3255
INFORMATION TELEPHONE: 1-800-543-4842
DATE PREPARED: 05/27/10
| SECTION II - HAZARDOUS INGREDIENTS/IDENTIFY INFORMATION | |
HAZARDOUS COMPONENTS OSHA ACGIH OUTER LIMITS % (OPTIONAL)
(SPECIFIC CHEMICAL PEL TLV RECOMMENDED
IDENTITY; COMMON NAME(S))
NONE NONE NONE N/A N/A
| SECTION III - PHYSICAL/CHEMICAL CHARACTERISTICS | |
BOILING POINT: 200 DEG. F (93.3 DEG. C)
VAPOR PRESSURE (MMHg): 760
VAPOR DENSITY (AIR = 1): NOT DETERMINED
SOLUBILITY IN WATER: 100%
SPECIFIC GRAVITY (H2O = 1): NOT DETERMINED
MELTING POINT: N/A
EVAPORATION RATE (BUTYL ACETATE = 1): NOT DETERMINED
APPEARANCE AND ODOR: COLORLESS LIQUID WITH NO DISCERNABLE ODOR.
| SECTION IV - FIRE AND EXPLOSION HAZARD DATA | |
FLASH POINT (METHOD USED): N/A
FLAMMABLE LIMITS:
LEL: N/A
UEL: N/A
EXTINGUISHING MEDIA: THIS IS A NONFLAMMABLE AQUEOUS SOLUTION.
SPECIAL FIRE FIGHTING PROCEDURES: N/A
UNUSUAL FIRE AND EXPLOSION HAZARDS: N/A
| SECTION V - REACTIVITY DATA | |
STABILITY:
UNSTABLE: NO
STABLE: YES
CONDITIONS TO AVOID:
THIS PRODUCT IS STABLE AND CONSIDERED NON-REACTIVE UNDER NORMAL
CONDITIONS OF STORAGE AND USAGE.
INCOMPATIBILITY (MATERIALS TO AVOID): NONE KNOWN
HAZARDOUS DECOMPOSITION OR BYPRODUCTS: NONE
HAZARDOUS POLYMERIZATION:
MAY OCCUR: NO
WILL NOT OCCUR: YES
CONDITIONS TO AVOID: NONE
| SECTION VI - HEALTH HAZARD DATA | |
ROUTE(S) OF ENTRY:
INHALATION?: NO
SKIN?: NO
INGESTION?: YES
HEALTH HAZARDS (ACUTE AND CHRONIC):
INGESTION OF VOLUMES IN EXCESS OF 20 LITERS MAY CAUSE GASTRIC IRRITATION.
CARCINOGENICITY:
NTP?: NO
IARC MONOGRAPHS?: NO
OSHA REGULATED?: NO
SIGNS AND SYMPTOMS OF EXPOSURE: N/A
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE: N/A
EMERGENCY FIRST AID PROCEDURES:
NOTES TO PHYSICIAN:
IN THE UNLIKELY EVENT OF RAPID INGESTIONS OF LARGE VOLUMES OF THE SOLUTION,
INDUCE VOMITING AND OBSERVE THE PATIENT FOR GASTRIC IRRITATION.
| SECTION VII - PRECAUTIONS FOR SAFE HANDLING AND USE | |
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED:
FLUSH AREA WITH WATER. THE SOLUTION IS NOT RCRA HAZARDOUS WASTE.
WASTE DISPOSAL METHOD: N/A
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING:
DO NOT FREEZE OR EXPOSE TO TEMPERATURES IN EXCESS OF 110 DEG. C
(43 DEG. C) FOR EXTENDED PERIODS.
OTHER PRECAUTIONS: N/A
| SECTION VIII - CONTROL MEASURES | |
RESPIRATORY PROTECTION: N/A
VENTILATION:
LOCAL EXHAUST: N/A
MECHANICAL: N/A
SPECIAL: N/A
OTHER: N/A
PROTECTIVE GLOVES: N/A
EYE PROTECTION: N/A
OTHER PROTECTIVE CLOTHING: N/A
WORK HYGIENIC PRACTICES: N/A
PART #32-005591
REV. D
RAPID AID(TM)
MATERIAL SAFETY DATA SHEET
IDENTITY: RAPID AID INSTANT COLD PACK
| SECTION I | |
MANUFACTURER'S NAME: RAPID AID LTD.
ADDRESS:
4120 SLADEVIEW CRESCENT
MISSISSAUGA, ONTARIO
L5L 5Z3
EMERGENCY TELEPHONE NUMBER: 905-820-4788
TELEPHONE NUMBER FOR INFORMATION: 905-820-4788
DATE PREPARED: NOVEMBER 2001
SIGNATURE OF PREPARER (OPTIONAL):
| SECTION II - HAZARD INGREDIENTS/IDENTITY INFORMATION | |
HAZARDOUS COMPONENTS OSHA ACGIH OTHER LIMITS % (OPTIONAL)
(SPECIFIC CHEMICAL PEL TLV RECOMMENDED
IDENTITY; COMMON NAME(S))
AMMONIUM NITRATE N/A 10 MG/M3 N/A
| SECTION III - PHYSICAL/CHEMICAL CHARACTERISTICS | |
BOILING POINT: DECOMPOSES @ 350 DEG. F
VAPOR PRESSURE (MMHg.): NOT APPLICABLE
VAPOR DENSITY (AIR = 1): NOT APPLICABLE
SPECIFIC GRAVITY (H2O = 1): 1.725
MELTING POINT: NOT APPLICABLE
EVAPORATION RATE (BUTYL ACETATE = 1): NOT APPLICABLE
SOLUBILITY IN WATER: COMPLETE
APPEARANCE AND ODOR: WHITE, ODORLESS SOLID CHEMICAL WITH WATER BAG
| SECTION IV - FIRE AND EXPLOSION HAZARD DATA | |
FLASH POINT (METHOD USED): NOT APPLICABLE
FLAMMABLE LIMITS: N/A
LEL: N/A
UEL: N/A
EXTINGUISHING MEDIA:
FLOOD AND COOL HOT NITRATE WITH STRAIGHT STREAM NOZZLES. DO NOT USE SLAT
WATER. WATER IS EFFECTIVE IN DESENSITIZING MOLTEN OR CONTAMINATED NITRATE.
SPECIAL FIRE FIGHTING PROCEDURES:
IMMEDIATELY VENTILATE STRUCTURE. DO NOT USE SPRAY OR FOG NOZZLES. USE
STRAIGHT STREAM NOZZLES TO COOL AND DESENSITIZE MOLTEN NITRATE.
RESPIRATORY PROTECTION REQUIRED FOR FIRE FIGHTING PERSONNEL. WHEN ANY FIRE
IS BURNING OUT OF CONTROL AND WATER CANNOT SAFELY BE APPLIED TO
DESENSITIZE, NITRATE FIRE CREWS SHOULD WITHDRAW A SAFE DISTANCE AND USE
UNMANNED FIRE LINES
UNUSUAL FIRE AND EXPLOSION HAZARDS:
DECOMPOSES INTO FLAMMABLE AND HAZARDOUS NITROGEN OXIDES. AS AN OXIDIZER,
IT YIELDS NITROUS OXIDE READILY TO STIMULATE THE COMBUSTION OF ORGANIC
MATTER OR ETHER FUEL. IN UNCONFINED FIRE SITUATIONS, AMMONIUM NITRATE
FERTILIZER CREATES A SELF-LIMITING EFFECT AS THE ENDOTHERMIC EFFECT OF ITS
DISSOCIATION INTO AMMONIA AND NITRIC ACID ABSORBS THE HEAT PRODUCED BY THE
EXOTHERMIC DECOMPOSITION OF NITROUS OXIDE AND WATER VAPOR. AMMONIUM
NITRATE FERTILIZER IS NOT EXPLOSIVE. DETONATION POTENTIAL UNDER
CONFINEMENT AND HIGH TEMPERATURES, OR WHEN HEATED WITH CONTAMINANTS SUCH
AS ORGANIC OR CARBONACEOUS MATERIAL, METALLIC POWDERS, ACIDS, OR
COMBINATION WITH COPPER PRODUCES TETRA MINE CUPRIC HYDRATE, A SALT WITH
HIGH SENSITIVITY. ZONAL DECOMPOSITION A POSSIBILITY.
| SECTION V - REACTIVITY DATA | |
STABILITY
UNSTABLE (X)
STABLE ( )
CONDITIONS TO AVOID: HEAT AND FIRE. INSENSITIVE TO IMPACT IN DRY FORM
INCOMPATIBILITY (MATERIALS TO AVOID):
CHEMICAL FROM DAMAGED COLD PACK SHOULD NOT BE MIXED WITH ACETIC ACIDS,
METALS, CHLORIDES, ORGANIC MATTER, PHOSPHOROUS, SODIUM, POTASSIUM,
SULPHUR, INORGANIC ZINC, COPPER. COPPER REPRESENTS THE GREATEST
CONTAMINATION HAZARD
HAZARDOUS DECOMPOSITION OR BYPRODUCTS: HAZARDOUS OXIDES OF NITROGEN.
HAZARDOUS POLYMERIZATION:
MAY OCCUR ( )
WILL NOT OCCUR (X)
CONDITIONS TO AVOID: HEAT AND FIRE
| SECTION VI - HEALTH HAZARD DATA | |
ROUTE(S) OF ENTRY: EYE CONTACT; SKIN CONTACT; INHALATION; INGESTION
HEALTH HAZARDS (ACUTE AND CHRONIC):
DRY CHEMICAL OF COLD PACK MAY BE AN EYE IRRITANT
DRY CHEMICAL OF COLD PACK IS A SKIN IRRITANT WITH PROLONGED CONTACT
DRY CHEMICAL OF COLD PACK HAS SLIGHT TO MODERATE TOXICITY WHEN INGESTED
MINIMAL HAZARD OF INHALATION UNDER NORMAL CONDITIONS.
NO HEALTH HAZARDS WHEN DRY CHEMICAL AND WATER ARE IN SOLUTION.
CARCINOGENICITY: N/A
SIGNS AND SYMPTOMS OF EXPOSURE:
EYE CONTACT WITH DRY CHEMICAL MAY RESULT IN EYE DISCOMFORT AND AGGRAVATION.
SKIN CONTACT WITH DRY CHEMICAL MAY RESULT IN MECHANICAL DISCOMFORT AND
RASH WITH PROLONGED CONTACT.
SWALLOWING LARGE AMOUNTS OF DRY CHEMICAL MAY HAVE SERIOUS OR EVEN FATAL
EFFECTS.
INHALATION OF LARGE AMOUNTS OF DRY CHEMICAL DUST MAY HAVE SERIOUS OR EVEN
FATAL EFFECTS.
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE: NOT AVAILABLE
EMERGENCY, AND FIRST AID PROCEDURES (FOR DRY CHEMICAL OF THE COLD PACK):
EYES:
IF MATERIAL GETS INTO THE EYES, IMMEDIATELY FLUSH EYES GENTLY WITH WATER
FOR AT LEAST 15 MINUTES WHILE HOLDING EYELIDS APART.
SEEK IMMEDIATE MEDICAL ATTENTION.
SKIN: WASH WITH MILD SOAP AND WATER.
SWALLOWING:
CALL POISON CONTROL FOR ADVICE. SEEK IMMEDIATE MEDICAL ATTENTION.
YOU MAY BE ADVISED TO ADMINISTER 2-3 GLASSES OF WATER AND INDUCE VOMITING.
INHALATION:
EXPOSURE TO THERMAL DECOMPOSITION - EVACUATE PERSON TO FRESH AIR, GIVE
RESPIRATORY SUPPORT.
SEEK IMMEDIATE MEDICAL ATTENTION.
| SECTION VII - PRECAUTIONS FOR SAFE HANDLING AND USE | |
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED:
SWEEP UP MATERIAL FOR DISPOSAL
WASTE DISPOSAL METHOD: DISPOSE PRODUCT IN TRASH
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING:
AVOID CONTACT WITH INCOMPATIBLE MATERIALS. AVOID EXPOSURE TO HEAT SOURCES.
AVOID CONTAMINATION WITH ORGANIC MATTER. DO NOT STORE NEAR FOOD STUFF.
OTHER PRECAUTIONS: NONE
| SECTION VIII - CONTROL MEASURES | |
RESPIRATORY PROTECTION (SPECIFY TYPE): ADEQUATE TO CONTROL DUST
VENTILATION:
LOCAL EXHAUST: NOT REQUIRED
MECHANICAL (GENERAL): NOT REQUIRED
SPECIAL: NOT REQUIRED
OTHER: NOT REQUIRED
PROTECTIVE GLOVES: CONVENTIONAL WORK GLOVES
EYE PROTECTION: SAFETY GLASSES WITH SIDE SHIELDS
OTHER PROTECTIVE CLOTHING OR EQUIPMENT: NOT REQUIRED
WORK/HYGIENIC PRACTICES: STANDARD