| Common Name: | LIGHT STICK - ALL COLORS, ALL TYPES, COMMERCIAL ABC DRY CHEMICAL (FIRE EXTINGUIS |
| Manufacturer: | AMERIGLO |
| SDS Revision Date: | 5/9/2004 |
| SDS Format: | No Format Specified |
| Item Number(s): | 1DGV4, 1FBJ9, 1FBK1, 1RK32, 2EHE6, 4T300, 4T301, 4T889, 4XP78, 4XP79, 4XP83, 4XP84, 4XP87, 4XP88, 4XP89, 4XP90, 5T899, 5T903, 5T904 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
AMERIGLO, LLC
SAFETY DATA SHEET
ACCORDING TO 91/155/EEC
AMERIGLO SAFETY DATA SHEET
VERSION: 2.02
DATE/REVISED: 05.09.2004
PRODUCT: LIGHT STICK - ALL COLORS, ALL TYPES
| 1. PRODUCT AND COMPANY IDENTIFICATION |  |
NAME ON LABEL: LIGHT STICK
SUPPLIER:
AMERIGLO, 5579B CHAMBLEE DUNWOODY ROAD
SUITE 214, ATLANTA, GA 30338
USA
ALTERNATIVE NAMES: GLOWING STICK, MARKER LIGHTS, CHEMILUMINESCENT TUBE
| 2. COMPOSITION/INFORMATION ON INGREDIENT | |
CHEMICAL NATURE:
PLASTIC ARTICLE CONTAINING LUMINESCER AND ACTIVATOR COMPONENTS
HAZARDOUS INGREDIENTS:
NAME: 2-METHYL-2-PROPANOL
CONCENTRATION RANGE: 3.0%-6.5% (W/W)
CAS NO.: 75-65-0
| 3. HAZARDS IDENTIFICATION | |
DESIGNATION: NO SPECIFIC HAZARD
RISK PHRASES: NONE SPECIFIED
| 4. FIRST-AID MEASURES | |
GENERAL ADVICE: REMOVE CONTAMINATED CLOTHING.
IF INHALED: REMOVE TO FRESH AIR. SEEK MEDICAL ADVICE IF SYMPTOMS PERSIST.
ON SKIN CONTACT: WASH THOROUGHLY WITH SOAP AND WATER.
ON CONTACT WITH EYES:
WASH AFFECTED EYES FOR AT LEAST 15 MINUTES UNDER RUNNING WATER WITH EYELIDS
HELD OPEN, CONSULT AN EYE SPECIALIST.
ON INGESTION:
RINSE OUT MOUTH AND DRINK PLENTY OF WATER. IF UNUSUAL SYMPTOMS ARE
OBSERVED, SEEK MEDICAL ADVICE.
| 5. FIRE-FIGHTING MEASURES | |
EXTINGUISHING MEDIA:
POWDER, FOAM, CARBON DIOXIDE FIRE EXTINGUISHING AGENT
| 6. ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS:
WEAR PROTECTIVE EQUIPMENT INCLUDING RUBBER GLOVES, AND EYE PROTECTION.
KEEP UNPROTECTED PERSONS AWAY.
ENVIRONMENTAL PRECAUTIONS:
TAKE PRECAUTIONS TO ENSURE PRODUCT DOES NOT ENTER THE DRAINAGE SYSTEM.
METHODS FOR CLEANING UP:
MIX WITH VERMICULITE OR PROPRIETARY ABSORBENT MATERIAL AND TRANSFER TO
SEALED CONTAINERS FOR DISPOSAL.
| 7. HANDLING AND STORAGE | |
HANDLING:
CHEMICALS SHOULD BE USED ONLY BY THOSE TRAINED IN HANDLING POTENTIALLY
HAZARDOUS MATERIALS. RUBBER GLOVES, EYE PROTECTION AND PROTECTIVE CLOTHING
SHOULD BE WORN.
STORAGE:
STORE IN A COOL AND DRY PLACE. KEEP AWAY FROM STRONG OXIDIZING AGENTS,
STRONG ACID.
| 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
RESPIRATION: AVOID IN HALATION OF PRODUCT.
EYE: AVOID EYE CONTACT. WEAR SAFETY SPECTACLES OR GOGGLES.
HANDS AND BODY:
AVOID UNNECESSARY SKIN CONTACT. WEAR RUBBER GLOVES AND PROTECTIVE CLOTHING.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE:
ARTICLE CONSISTING OF PLASTIC TUBE OR SHAPE CONTAINING GLASS AMPOULE WITH
LUMINESCER AND ACTIVATOR COMPONENTS.
PH: NOT APPLICABLE
BOILING POINT: >340 DEG. C
FLASH POINT: >94.2 DEG. C (CLOSED CUP)
EXPLOSION PROPERTIES: NOT APPLICABLE
DENSITY: 1.1-1.2
WATER SOLUBILITY: UNSOLUBLE
| 10. STABILITY AND REACTIVITY | |
STABILITY: STABLE
POLYMERIZATION: WILL NOT OCCUR
INCOMPATIBILITIES: NONE KNOWN
DECOMPOSITION:
HAZARDOUS DECOMPOSITION PRODUCTS MAY INCLUDE: CARBON MONOXIDE, CARBON
DIOXIDE.
| 11. TOXICOLOGICAL INFORMATION | |
ACUTE TOXICITY:
THE ACUTE ORAL (RAT) AND ACUTE DERMAL (RABBIT) LD50 VALUES ESTIMATED TO BE
GREATER THAN 5.0 G/KG.
IRRITATION:
DIRECT CONTACT WITH THIS MATERIAL MAY RESULT IN MINIMAL EYE IRRITATION.
| 12. ECOLOGICAL INFORMATION | |
GENERAL:
TAKE CARE TO PREVENT CHEMICALS FROM ENTERING THE GROUND, WATER SYSTEMS OR
DRAINAGE SYSTEMS.
| 13. DISPOSAL CONSIDERATIONS | |
DISPOSAL:
MUST BE DUMPED OR INCINERATED IN ACCORDANCE WITH LOCAL REGULATIONS.
| 14. TRANSPORT INFORMATION | |
TRANSPORT: NOT CLASSIFIED AS HAZARDOUS UNDER TRANSPORT REGULATIONS.
| 15. REGULATORY INFORMATION | |
HAZARD INDICATION: NO SPECIFIC HAZARD
| 16. OTHER INFORMATION | |
IT MUST BE RECOGNIZED THAT THE PHYSICAL AND CHEMICAL PROPERTIES OF ANY
PRODUCT MAY NOT BE FULLY UNDERSTOOD AND THAT NEW, POSSIBLY HAZARDOUS
PRODUCTS MAY ARISE FROM REACTIONS BETWEEN CHEMICALS. THE INFORMATION GIVEN
IN THIS DATA SHEET IS BASED ON OUR PRESENT KNOWLEDGE AND SHALL NOT
CONSTITUTE A GUARANTEE FOR ANY SPECIFIC PRODUCT FEATURES AND SHALL NOT
ESTABLISH A LEGALLY VALID CONTRACTUAL RELATIONSHIP.
DATE OF LAST REVISION: 05.09.2004
KIDDE
A UTC FIRE & SECURITY COMPANY
MATERIAL SAFETY DATA SHEET
COMMERCIAL ABC DRY CHEMICAL (FIRE EXTINGUISHING AGENT)
| 1. IDENTIFICATION OF THE SUBSTANCE/PREPARATIONS | |
AND OF THE COMPANY UNDERTAKING
PRODUCT NAME: COMMERCIAL ABC DRY CHEMICAL (FIRE EXTINGUISHING AGENT)
OTHER TRADE NAMES:
MULTI-PURPOSE, AMMONIUM PHOSPHATE, MONOAMMONIUM PHOSPHATE
PRODUCT DESCRIPTION: FIRE EXTINGUISHING AGENT
MANUFACTURER/SUPPLIER: KIDDE - RESIDENTIAL AND COMMERCIAL
ADDRESS:
1016 CORPORATE PARK DRIVE
MEBANE, NC 27302
USA
PHONE NUMBER:
(919) 563-5911
(919) 304-8200
CHEMTREC NUMBER (FOR EMERGENCIES ONLY):
(800) 424-9300
(703) 527-3887 (INTERNATIONAL)
REVISION DATE: MARCH 4, 2010
MSDS DATE: JANUARY 15, 2007
SAFETY DATA SHEET ACCORDING TO EC DIRECTIVE 2001/59/EC AND OSHA'S HAZCOM
STANDARD (29 CFR 1910.1200)
| 2. HAZARDS IDENTIFICATION | |
EU MAIN HAZARDS: NON HAZARDOUS POWDER
ROUTES OF ENTRY:
EYE CONTACT
INHALATION
SKIN CONTACT
CARCINOGENIC STATUS: SEE SECTION 11 - TOXICITY
TARGET ORGANS:
RESPIRATORY SYSTEM
SKIN
EYE
HEALTH EFFECTS - EYES:
CONTACT FOR SHORT PERIODS OF TIME MAY CAUSE IRRITATION.
HEALTH EFFECTS - SKIN: CONTACT MAY CAUSE MILD IRRITATION.
HEALTH EFFECTS - INGESTION:
INGESTION IS NOT AN EXPECTED ROUTE OF EXPOSURE.
HEALTH EFFECTS - INHALATION:
MAY IRRITATE THE RESPIRATORY TRACT. MAY CAUSE TRANSIENT COUGH AND SHORTNESS
OF BREATH.
| 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
COMPONENT NAME CAS#/CODES CONCENTRATION R PHRASES EU CLASSIFICATION
MONOAMMONIUM 7722-76-1 55 - 65% NONE NONE
PHOSPHATE EC#2317645
AMMONIUM SULFATE 7783-20-2 30 - 40% NONE NONE
EC#2319841
MICA 12001-26-2 1 - 4% NONE NONE
CLAY 8031-18-3 <2% NONE NONE
AMORPHOUS SILICA 7631-86-9 <2% NONE NONE
EC#2315454
DYE NA <0.1% NONE NONE
| 4. FIRST AID MEASURES | |
EYES:
IMMEDIATELY FLOOD THE EYE WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES,
HOLDING THE EYE OPEN. OBTAIN MEDICAL ATTENTION IF SORENESS OR REDNESS
PERSISTS.
SKIN:
WASH AFFECTED AREA WITH SOAP AND WATER. OBTAIN MEDICAL ATTENTION IF
IRRITATION PERSISTS.
INGESTION:
DILUTE BY DRINKING LARGE QUANTITIES OF WATER AND OBTAIN MEDICAL ATTENTION.
INHALATION:
MOVE VICTIM TO FRESH AIR. OBTAIN MEDICAL ATTENTION IMMEDIATELY FOR ANY
BREATHING DIFFICULTY.
ADVICE TO PHYSICIANS: TREAT SYMPTOMATICALLY.
| 5. FIRE - FIGHTING MEASURES | |
EXTINGUISHING MEDIA:
THIS PREPARATION IS USED AS AN EXTINGUISHING AGENT AND THEREFORE IS NOT A
PROBLEM WHEN TRYING TO CONTROL A BLAZE. USE EXTINGUISHING AGENT APPROPRIATE
TO OTHER MATERIALS INVOLVED. KEEP PRESSURIZED EXTINGUISHERS AND
SURROUNDINGS COOL WITH WATER SPRAY AS THEY MAY RUPTURE OR BURST IN THE HEAT
OF A FIRE.
UNUSUAL FIRE AND EXPLOSION HAZARDS:
PRESSURIZED CONTAINERS MAY EXPLODE IN HEAT OF FIRE.
PROTECTIVE EQUIPMENT FOR FIRE-FIGHTING:
WEAR FULL PROTECTIVE CLOTHING AND SELF-CONTAINED BREATHING APPARATUS AS
APPROPRIATE FOR SPECIFIC FIRE CONDITIONS.
| 6. ACCIDENTAL RELEASE MEASURES | |
SWEEP UP OR VACUUM. PREVENT SKIN AND EYE CONTACT. WEAR APPROPRIATE
PROTECTIVE EQUIPMENT.
| 7. HANDLING AND STORAGE | |
PRESSURIZED EXTINGUISHERS SHOULD BE PROPERLY STORED AND SECURED TO PREVENT
FALLING OR BEING KNOCKED OVER. DO NOT DRAG, SLIDE OR ROLL EXTINGUISHERS. DO
NOT DROP EXTINGUISHERS OR PERMIT THEM TO STRIKE AGAINST EACH OTHER. NEVER
APPLY FLAME OR LOCALIZED HEAT DIRECTLY TO ANY PART OF THE EXTINGUISHER OR
PLASTIC CONTAINER. STORE PRESSURIZED EXTINGUISHERS AND PLASTIC CONTAINERS
AWAY FROM HIGH HEAT SOURCES.
STORAGE AREA SHOULD BE:
COOL
DRY
WELL VENTILATED
UNDER COVER
OUT OF DIRECT SUNLIGHT
| 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
OCCUPATIONAL EXPOSURE STANDARDS:
OCCUPATIONAL EXPOSURE LIMITS ARE LISTED BELOW, IF THEY EXIST.
MICA:
ACGIH TLV: 3 MG/M3 TWA, MEASURED AS RESPIRABLE FRACTION OF THE AEROSOL.
OSHA PEL: 20 MPPCF, <1% CRYSTALLINE SILICA
NUISANCE DUST LIMIT:
OSHA PEL:
50 MPPCF OR 15 MG/M3 TWA, TOTAL DUST
15 MPPCF OR 5 MG/M3 TWA, RESPIRABLE FRACTION
ENGINEERING CONTROL MEASURES:
USE WITH ADEQUATE VENTILATION. THERE SHOULD BE LOCAL PROCEDURES FOR THE
SELECTION, TRAINING, INSPECTION AND MAINTENANCE OF THIS EQUIPMENT. WHEN
USED IN LARGE VOLUMES, USE LOCAL EXHAUST VENTILATION.
RESPIRATORY PROTECTION:
NOT NORMALLY REQUIRED. USE DUST MASK WHERE DUSTINESS IS PREVALENT, OR TLV
IS EXCEEDED.
HAND PROTECTION:
NOT NORMALLY NEEDED WHEN USED AS A PORTABLE FIRE EXTINGUISHER. USE GLOVES
IF IRRITATION OCCURS.
EYE PROTECTION: CHEMICAL GOGGLES OR SAFETY GLASSES WITH SIDE SHIELDS.
BODY PROTECTION: NORMAL WORK WEAR.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
PHYSICAL STATE: POWDER
COLOR: PALE YELLOW
ODOR: ODORLESS
SPECIFIC GRAVITY: NOT AVAILABLE
BOILING RANGE/POINT (DEG. C/F): NOT APPLICABLE
FLASH POINT (PMCC) (DEG. C/F): NOT FLAMMABLE
SOLUBILITY IN WATER: NOT APPLICABLE
VAPOR DENSITY (AIR = 1): HEAVIER THAN AIR.
VAPOR PRESSURE: NOT APPLICABLE
EVAPORATION RATE: NOT APPLICABLE
| 10. STABILITY AND REACTIVITY | |
STABILITY: STABLE UNDER NORMAL CONDITIONS.
CONDITIONS TO AVOID:
HEAT
HIGH TEMPERATURES
EXPOSURE TO DIRECT SUNLIGHT
MATERIALS TO AVOID:
STRONG OXIDIZING AGENTS
STRONG ACIDS
SODIUM HYPOCHLORITE
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR.
HAZARDOUS DECOMPOSITION PRODUCTS:
OXIDES OF CARBON
AMMONIA
OXIDES OF PHOSPHORUS
NITROGEN OXIDES
| 11. TOXICOLOGICAL INFORMATION | |
ACUTE TOXICITY: LOW ORDER OF ACUTE TOXICITY.
CHRONIC TOXICITY/CARCINOGENICITY:
THIS PRODUCT IS NOT EXPECTED TO CAUSE LONG TERM ADVERSE HEALTH EFFECTS.
MICA AND CLAY MAY CONTAIN SMALL QUANTITIES OF QUARTZ (CRYSTALLINE SILICA)
AS AN IMPURITY. PROLONGED EXPOSURE TO RESPIRABLE CRYSTALLINE SILICA DUST
AT CONCENTRATIONS EXCEEDING THE OCCUPATIONAL EXPOSURE LIMITS MAY INCREASE
THE RISK OF DEVELOPING A DISABLING LUNG DISEASE KNOWN AS SILICOSIS. IARC
FOUND LIMITED EVIDENCE FOR PULMONARY CARCINOGENICITY OF CRYSTALLINE SILICA
IN HUMANS.
GENOTOXICITY: THIS PRODUCT IS NOT EXPECTED TO CAUSE ANY MUTAGENIC EFFECTS.
REPRODUCTIVE/DEVELOPMENTAL TOXICITY:
THIS PRODUCT IS NOT EXPECTED TO CAUSE ADVERSE REPRODUCTIVE EFFECTS.
| 12. ECOLOGICAL INFORMATION | |
MOBILITY: NO RELEVANT STUDIES IDENTIFIED.
PERSISTENCE/DEGRADABILITY: NO RELEVANT STUDIES IDENTIFIED.
BIO-ACCUMULATION: NO RELEVANT STUDIES IDENTIFIED.
ECOTOXICITY: NO RELEVANT STUDIES IDENTIFIED.
| 13. DISPOSAL CONSIDERATIONS | |
DISPOSE OF CONTAINER IN ACCORDANCE WITH ALL APPLICABLE LOCAL AND NATIONAL
REGULATIONS. DO NOT CUT, PUNCTURE OR WELD ON OR NEAR TO THE CONTAINER. NO
HARM TO THE ENVIRONMENT IS EXPECTED FROM THIS PREPARATION.
| 14. TRANSPORT INFORMATION | |
DOT CFR 172.101 DATA: NOT REGULATED
UN PROPER SHIPPING NAME: NOT REGULATED
UN CLASS: NONE
UN NUMBER: NONE
UN PACKAGING GROUP: NONE
| 15. REGULATORY INFORMATION | |
EU LABEL INFORMATION:
CLASSIFICATION AND LABELLING HAVE BEEN PERFORMED ACCORDING TO EU DIRECTIVES
67/548/EEC AND 99/45/EC INCLUDING AMENDMENTS(2001/60/EC AND 2006/8/EC)
EU HAZARD SYMBOL AND INDICATION OF DANGER.:
THIS PREPARATION IS NOT CLASSIFIED AS DANGEROUS.
R PHRASES: NONE
S PHRASES: NONE.
US REGULATIONS (FEDERAL, STATE) AND INTERNATIONAL CHEMICAL REGISTRATION
LAWS:
TSCA LISTING:
THIS PRODUCT CONTAINS INGREDIENTS THAT ARE LISTED ON OR EXEMPT FROM LISTING
ON THE EPA TOXIC SUBSTANCE CONTROL ACT CHEMICAL SUBSTANCE INVENTORY.
EINECS LISTING:
ALL INGREDIENTS IN THIS PRODUCT HAVE NOT BEEN VERIFIED FOR LISTING ON THE
EUROPEAN INVENTORY OF EXISTING COMMERCIAL CHEMICAL SUBSTANCES (EINECS) OR
THE EUROPEAN LIST OF NEW CHEMICAL SUBSTANCES (ELINCS).
DSL/NDSL (CANADIAN) LISTING:
ALL INGREDIENTS IN THIS PRODUCT ARE LISTED ON THE DOMESTIC SUBSTANCE LIST
(DSL) OR THE NON-DOMESTIC SUBSTANCE LIST (NDSL) OR ARE EXEMPT FROM LISTING.
WHMIS CLASSIFICATION:
D2B
THIS PRODUCT WAS CLASSIFIED IN ACCORDANCE WITH THE HAZARD CRITERIA OF THE
CANADIAN CONTROLLED PRODUCTS REGULATIONS AND THE MSDS CONTAINS ALL THE
INFORMATION REQUIRED BY THESE REGULATIONS.
MA RIGHT TO KNOW LAW:
ALL COMPONENTS HAVE BEEN CHECKED FOR INCLUSION ON THE MASSACHUSETTS
SUBSTANCE LIST (MSL).
THOSE COMPONENTS PRESENT AT OR ABOVE THE DE MINIMIS CONCENTRATION INCLUDE:
MICA (12001-26-2) 1-4%
AMORPHOUS SILICA (7631-86-9) <2%
AMMONIUM SULFATE (7783-20-2) 30-40%
PA RIGHT TO KNOW LAW:
THIS PRODUCT CONTAINS THE FOLLOWING CHEMICALS FOUND ON THE PENNSYLVANIA
HAZARDOUS SUBSTANCE LIST:
MICA (12001-26-2) 1-4%
AMORPHOUS SILICA (7631-86-9) <2%
AMMONIUM SULFATE (7783-20-2) 30-40%
NJ RIGHT TO KNOW LAW:
THIS PRODUCT CONTAINS THE FOLLOWING CHEMICALS FOUND ON THE NJ RIGHT TO KNOW
HAZARDOUS SUBSTANCE LIST:
MICA (12001-26-2) 1-4%
AMORPHOUS SILICA (7631-86-9) <2%
CALIFORNIA PROPOSITION 65:
THIS PRODUCT DOES NOT CONTAIN MATERIALS WHICH THE STATE OF CALIFORNIA HAS
FOUND TO CAUSE CANCER, BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM.
SARA TITLE III SECT. 302 (EHS):
THIS PRODUCT DOES NOT CONTAIN ANY CHEMICALS SUBJECT TO SARA TITLE III
SECTION 302.
SARA TITLE III SECT. 304:
THIS PRODUCT DOES NOT CONTAIN ANY CHEMICALS SUBJECT TO SARA TITLE III
SECTION 304.
SARA TITLE III SECT. 311/312 CATEGORIZATION:
IMMEDIATE (ACUTE) HEALTH HAZARD
SARA TITLE III SECT. 313:
THIS PRODUCT DOES NOT CONTAIN ANY CHEMICALS THAT ARE LISTED IN SECTION 313
AT OR ABOVE DE MINIMIS CONCENTRATIONS.
| 16. OTHER INFORMATION | |
NFPA RATINGS:
NFPA CODE FOR HEALTH 1
NFPA CODE FOR FLAMMABILITY 0
NFPA CODE FOR REACTIVITY 0
NFPA CODE FOR SPECIAL HAZARDS NONE
HMIS RATINGS:
HMIS CODE FOR HEALTH 1
HMIS CODE FOR FLAMMABILITY 0
HMIS CODE FOR REACTIVITY 0
HMIS CODE FOR PERSONAL PROTECTION SEE SECTION 8
ABBREVIATIONS:
N/A: DENOTES NO APPLICABLE INFORMATION FOUND OR AVAILABLE
CAS#: CHEMICAL ABSTRACTS SERVICE NUMBER
ACGIH: AMERICAN CONFERENCE OF GOVERNMENTAL INDUSTRIAL HYGIENISTS
OSHA: OCCUPATIONAL SAFETY AND HEALTH ADMINISTRATION
TLV: THRESHOLD LIMIT VALUE
PEL: PERMISSIBLE EXPOSURE LIMIT
STEL: SHORT TERM EXPOSURE LIMIT
NTP: NATIONAL TOXICOLOGY PROGRAM
IARC: INTERNATIONAL AGENCY FOR RESEARCH ON CANCER
R: RISK
S: SAFETY
PREPARED BY: ENVIRONET LLC.
THE INFORMATION CONTAINED HEREIN IS BASED ON DATA BELIEVED TO BE ACCURATE.
HOWEVER, NO REPRESENTATION, WARRANTY, OR GUARANTEE IS MADE TO ITS ACCURACY,
RELIABILITY OR COMPLETENESS. IT IS THE USER'S RESPONSIBILITY TO SATISFY
HIMSELF AS TO THE SUITABILITY AND COMPLETENESS OF SUCH INFORMATION FOR ITS
OWN PARTICULAR USE. KIDDE - RESIDENTIAL AND COMMERCIAL ASSUMES NO
RESPONSIBILITY FOR PERSONAL INJURY OR PROPERTY DAMAGE RESULTING FROM USE,
HANDLING OR FROM CONTACT WITH THIS PRODUCT.
REVISION DATE: MARCH 4, 2010
MATERIAL SAFETY DATA SHEET
FORD TOX #: 135423
| SECTION I - | |
MANUFACTURER'S NAME: METALTEC STEEL ABRASIVE COMPANY
ADDRESS: 41155 JOY ROAD
CITY, STATE, ZIP: CANTON, MI 48187
TELEPHONE / FAX #: (734) 459-7900 / (734) 459-7907
EMERGENCY: (734) 454-1840
PRODUCT NAMES: LOW CARBON CAST STEEL SHOT FINES AIRWASH SEPARATOR FINES
CHEMICAL FAMILY:
FERROUS
JANUARY 1, 2009
SIGNATURE:
| SECTION II - HAZARDOUS INGREDIENTS | |
CHEMICAL NAME CAS NUMBER % WEIGHT OSHA TWA ACGIH TWA
IRON 1309-37-1 >40 10 MG/M3 5 MG/M3
(AS NUISANCE DUST)
MANGANESE 74-39-96-5 1.0-1.5 5 MG/M3 5 MG/M3 C*
CARBON 7440-44-0 0.08-0.15 NONE EST. NONE EST.
SILICON 7440-21-3 0.10-0.30 15 MG/M3 10 MG/M3
(AS NUISANCE DUST)
C* = CEILING LIMIT, SHALL NOT BE EXCEEDED EVEN FOR A SHORT TIME.
| SECTION III - PHYSICAL DATA | |
MELTING POINT: 1371 - 1482C
VAPOR PRESSURE: NOT APPLICABLE
EVAPORATION RATE: NOT APPLICABLE
VAPOR DENSITY: NOT APPLICABLE
BOILING POINT: 2850 - 3150C
% SOLID BY WEIGHT: 100%
SOLUBILITY IN WATER: NOT APPLICABLE
PH: NOT APPLICABLE
APPEARANCE AND ODOR:
STEEL SHOT IS NEAR SPHERICAL IN SHAPE AND LIGHT GRAY TO SILVER IN COLOR
| SECTION IV - FIRE AND EXPLOSION HAZARD DATA | |
FLASH POINT: NOT APPLICABLE
AUTO IGNITION TEMPERATURE: (SOLID IRON EXPOSED TO OXYGEN) 930C
CAST STEEL SHOT WILL NOT BURN OR EXPLODE
THE SOLID FORM OF MATERIAL IS NOT COMBUSTIBLE. FIRE EXPLOSION HAZARDS ARE
MODERATE WHEN MATERIAL IS IN THE FORM OF DUST AND EXPOSED TO HEAT OF
FLAMES, CHEMICAL REACTION, OR CONTACT WITH POWERFUL OXIDIZERS.
FIRE EXTINGUISHING METHOD: USE DRY CHEMICALS OR SAND TO EXCLUDE AIR.
| SECTION V - HEALTH HAZARD DATA | |
THRESHOLD LIMIT: SEE SECTION II
CARCINOGENICITY: NONE OF THE INGREDIENTS LISTED BY N.T.P., IARC OR OSHA
PERMISSIBLE EXPOSURE LIMIT: SEE SECTION II
PRIMARY ROUTES OF ENTRY:
INHALATION OF DUST OR FUMES CREATED DURING USE, OR DUST PARTICULATE IN
EYES.
OVEREXPOSURE TO DUST CONTAINING THE COMPONENT ELEMENTS OF CAST STEEL SHOT
MAY CAUSE SKIN, NOSE, MOUTH AND EYE IRRITATION.
EMERGENCY AND FIRST AID PROCEDURE:
EYE CONTACT:
FLUSH WITH RUNNING WATER TO REMOVE PARTICLES. SEEK ADDITIONAL MEDICAL
ATTENTION IF NECESSARY.
SKIN CONTACT: BRUSH OFF EXCESS DUST, WASH AREA WITH SOAP AND WATER.
INHALATION: REMOVE TO FRESH AIR. SEEK MEDICAL ATTENTION
INGESTION:
SEEK MEDICAL HELP IF LARGE QUANTITIES OF MATERIAL HAVE BEEN INGESTED.
| SECTION VI - REACTION DATA | |
STABILITY: STABLE
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR
HAZARDOUS DECOMPOSITION PRODUCTS: NONE
CAST STEEL SHOT WILL WEAR AWAY AT A CONTROLLED RATE THROUGH NORMAL USE.
| SECTION VII - SPILL AND LEAK PROCEDURE | |
CAST STEEL SHOT SPILLED OR LEAKED ONTO FLOORS CAN CAUSE HAZARDOUS WALKING
CONDITIONS. SPILLS OR LEAKS SHOULD BE VACUUMED OR SWEPT FROM WORKING AREAS.
WHEN CLEANING UP LARGE QUANTITIES OF DUST, A NIOSH APPROVED RESPIRATOR
SHOULD BE WORN. SPILLED CAST STEEL SHOT CAN BE REUSED OR DISPOSED OF AS A
NON-HAZARDOUS WASTE. COLLECTED DUST FROM BLAST CLEANING OR SHOT PEENING
OPERATIONS ALWAYS CONTAIN CONTAMINANTS FROM THE SURFACE OF THE PARTS BEING
PROCESSED, AND THEREFORE THE DUST MAY BE CLASSIFIED AS A HAZARDOUS WASTE
AN, AS SUCH, MUST BE DISPOSED OF ACCORDING TO APPROPRIATE LOCAL, STATE OR
FEDERAL REGULATIONS.
| SECTION VIII - SPECIAL PROTECTION INFORMATION | |
VENTILATION:
GENERAL AND LOCAL EXHAUST VENTILATION SHOULD BE PROVIDED TO KEEP THE DUST
LEVELS BELOW TLV'S SHOWN IN SECTION II.
RESPIRATORY PROTECTION:
IF DUST CREATED BY USE EXCEEDS THE TLV'S INDICATED IN SECTION II, A NIOSH
APPROVED RESPIRATOR SHOULD BE WORN.
EYE PROTECTION:
APPROVED SAFETY GLASSES WITH SIDE SHIELDS SHOULD BE WORN AT ALL TIMES.
SAFETY EYEWASH STATIONS SHOULD BE PROVIDED IN CLOSE PROXIMITY TO THE WORK
AREA.
OTHER PROTECTION EQUIPMENT: NONE REQUIRED.
| SECTION IX - SPECIAL PRECAUTIONS | |
HANDLING AND STORAGE PRECAUTIONS:
STORE MATERIAL AWAY FROM INCOMPATIBLE MATERIALS AND KEEP DUST AWAY FROM
SOURCES OF IGNITION. KEEP DRY TO REDUCE RUSTING. OBSERVE MAXIMUM FLOOR
LOADING LIMITATIONS.
OTHER PRECAUTIONS:
THE COMPANY HAS NO CONTROL OVER THIS PRODUCT OR ITS USE AFTER IT LEAVES
OUR FACILITY. THE COMPANY ASSUMES NO LIABILITY FOR LOSS OR DAMAGE FROM THE
PROPER OR IMPROPER USE OF THIS PRODUCT. THE INFORMATION PRESENTED HERE HAS
BEEN COMPILED FROM SOURCES CONSIDERED TO BE RELIABLE AND ACCURATE TO THE
BEST OF OUR KNOWLEDGE AND BELIEF, BUT IS NOT GUARANTEED TO BE SO.
MTF-227-14
REV. DATE: 01/01/2005