| Common Name: | STREAMLIGHT LI-ION BATTERY PACK 3.75V 2.0AH 7.5WH |
| Manufacturer: | INTERNATIONAL COMPONENTS |
| SDS Revision Date: | 1/16/2011 |
| SDS Format: | No Format Specified |
| Item Number(s): | 21XN04, 21XN05, 22LU18, 22LU19, 5TZK3, 5TZK4, 5XA75, 5XB11 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
INTERNATIONAL COMPONENTS CORPORATION(TM)
MATERIAL SAFETY DATA SHEET
SHIPPING NAME: STREAMLIGHT LI-ION BATTERY PACK
PRODUCT NAME: STREAMLIGHT LI-ION BATTERY PACK
DOCUMENT NO.: MSDS-03133-001
REVISION: REV 02
DATE: 1/16/2011
APPROVED BY: INTERNATIONAL COMPONENTS CORPORATION CORPORATE HEADQUARTERS
MAY BE USED TO COMPLY WITH OSHA'S HAZARD COMMUNICATION STANDARD, 29 CFR
1910.1200. STANDARD MUST BE CONSULTED FOR SPECIFIC REQUIREMENTS.
MATERIAL SAFETY DATA SHEETS (MSDS) ARE A SUB-REQUIREMENT OF THE
OCCUPATIONAL SAFETY AND HEALTH ADMINISTRATION (OSHA) HAZARD COMMUNICATION
STANDARD, 29 CFR SUBPART 1910.1200. THIS HAZARD COMMUNICATION STANDARD DOES
NOT APPLY TO VARIOUS SUBCATEGORIES INCLUDING ANYTHING DEFINED BY OSHA AS AN
"ARTICLE". OSHA HAS DEFINED "ARTICLE' AS A MANUFACTURED ITEM OTHER THAN A
FLUID OR PARTICLE
(I) WHICH IS FORMED TO A SPECIFIC SHAPE OR DESIGN DURING MANUFACTURE
(II) WHICH HAS END USE FUNCTION(S) DEPENDENT IN WHOLE OR IN PART UPON ITS
SHAPE OR DESIGN DURING END USE; AND
(III) WHICH UNDER NORMAL CONDITIONS OF USE DOES NOT RELEASE MORE THAN VERY
SMALL QUANTITIES, E.G. MINUTE OR TRACE AMOUNTS OF A HAZARDOUS CHEMICAL, AND
DOES NOT POSE A PHYSICAL HAZARD OR HEALTH RISK TO EMPLOYEES. BECAUSE ALL OF
OUR BATTERY PACKS ARE DEFINED AS "ARTICLES", THEY ARE EXEMPT FROM THE
REQUIREMENTS OF THE HAZARD COMMUNICATION STANDARD.
| SECTION 1 - CHEMICAL AND COMPANY IDENTIFICATION |  |
PRODUCT IDENTIFICATION:
PRODUCT NAME: STREAMLIGHT LI-ION BATTERY PACK 3.75V 2.0AH 7.5WH
MANUFACTURER: INTERNATIONAL COMPONENTS CORPORATION
DIVISION: FABRICATORS INTERNATIONAL LTD.
MODEL NUMBER: 74175
COMPANY IDENTIFICATION:
INTERNATIONAL COMPONENTS CORPORATION
4 WESTBROOK CORPORATE CENTER, SUITE 900
WESTCHESTER, ILLINOIS 60154
USA
PH: 708-836-3800
EMERGENCY 24-HOUR TELEPHONE NUMBER:
INFOTRAC:
INSIDE THE US: 1-800-535-5053
OUTSIDE THE US: 001-352-323-3500
| SECTION 2 - COMPOSITION / INFORMATION ON INGREDIENTS | |
BATTERY PACK CONTAINS 1 LITHIUM-ION, 3.7V, 2.15AHR CELLS ENCAPSULATED IN A
PLASTIC (NYLON) ENCLOSURE.
THE FOLLOWING MATERIALS ARE FOUND IN THE ENCLOSED CELLS OF THE LITHIUM ION
BATTERY PACK:
COMPONENT MATERIAL FORMULA
POSITIVE ELECTRODE LITHIUM COBALT OXIDE LiCoO2
NEGATIVE ELECTRODE GRAPHITE C
ELECTROLYTE ETHYLENE CARBONATE - SOLVENT C3H4O3
DIETHYL CARBONATE - SOLVENT C5H10O3
LITHIUM HEXAFLUROPHOSPHATE - SALT LiPF6
(THE OVERALL REACTION IS: LixC + Li1-x CoO2C = C + LiCoO2)
MECHANICAL SPECIFICATIONS:
WEIGHT WATT HOURS EQUIVALENT LITHIUM CONTENT
BATTERY PACK 50G 7.5 WH 0.65G
| SECTION 3 - HAZARDS IDENTIFICATION | |
CELLS MAY EXPLODE IN A FIRE CAUSING THE RELEASE OF HYDROGEN FLUORIDE GAS.
USE EXTINGUISHING MEDIA SUITABLE FOR MATERIALS BURNING IN FIRE.
PRIMARY ROUTES OF ENTRY:
SKIN CONTACT: NO EFFECT UNDER ROUTINE HANDLING AND USE
SKIN ABSORPTION: NO EFFECT UNDER ROUTINE HANDLING AND USE
EYE CONTACT: NO EFFECT UNDER ROUTINE HANDLING AND USE
INHALATION: NO EFFECT UNDER ROUTINE HANDLING AND USE
INGESTION: NO EFFECT UNDER ROUTINE HANDLING AND USE
SYMPTOMS OF EXPOSURE:
UNDER ROUTINE HANDLING AND USE, THERE WILL BE NO EFFECT FROM EXPOSURE.
SKIN CONTACT: NO EFFECT UNDER ROUTINE HANDLING AND USE
SKIN ABSORPTION: NO EFFECT UNDER ROUTINE HANDLING AND USE
EYE CONTACT: NO EFFECT UNDER ROUTINE HANDLING AND USE
INHALATION: NO EFFECT UNDER ROUTINE HANDLING AND USE
INGESTION: REPORTED AS CARCINOGEN NOT APPLICABLE
| SECTION 4 - FIRST AID MEASURES | |
IF EXPOSURE TO INTERNAL MATERIALS WITHIN CELL DUE TO DAMAGED OUTER CASING,
THE FOLLOWING ACTIONS ARE RECOMMENDED.
SKIN CONTACT:
WASH AREA THOROUGHLY WITH SOAP AND WATER AND SEEK MEDICAL ATTENTION.
EYE CONTACT:
RINSE EYES WITH WATER FOR 15 MINUTES AND SEEK MEDICAL ATTENTION.
INHALATION: LEAVE AREA IMMEDIATELY AND SEEK MEDICAL ATTENTION.
INGESTION: DRINK MILK/WATER AND INDUCE VOMITING; SEEK MEDICAL ATTENTION.
| SECTION 5 - FIRE FIGHTING MEASURES | |
GENERAL HAZARD:
CELL IS NOT FLAMMABLE BUT INTERNAL ORGANIC MATERIAL WILL BURN IF THE CELL
IS INCINERATED. COMBUSTION PRODUCTS INCLUDE, BUT ARE NOT LIMITED TO
HYDROGEN FLUORIDE, CARBON MONOXIDE AND CARBON DIOXIDE.
EXTINGUISHING MEDIA:
USE EXTINGUISHING MEDIA SUITABLE FOR THE MATERIALS THAT ARE BURNING.
SPECIAL FIREFIGHTING INSTRUCTIONS:
IF POSSIBLE, REMOVE CELL(S) FROM FIRE FIGHTING AREA. IF HEATED ABOVE 125
DEG. C, CELL(S) MAY EXPLODE/VENT.
FIREFIGHTING EQUIPMENT:
USE NIOSH/MSHA APPROVED FULL-FACE SELF-CONTAINED BREATHING APPARATUS (SCBA)
WITH FULL PROTECTIVE GEAR.
| SECTION 6 - ACCIDENTAL RELEASE MEASURES | |
ON LAND:
PLACE MATERIAL INTO SUITABLE CONTAINERS AND CALL LOCAL FIRE/POLICE
DEPARTMENT.
IN WATER:
IF POSSIBLE, REMOVE FROM WATER AND CALL LOCAL FIRE/POLICE DEPARTMENT.
| SECTION 7 - HANDLING AND STORAGE | |
HANDLING:
NO SPECIAL PROTECTIVE CLOTHING REQUIRED FOR HANDLING BATTERY PACKS.
STORAGE: STORE IN A COOL, DRY PLACE
| SECTION 8 - EXPOSURE CONTROLS / PERSONAL PROTECTION | |
ENGINEERING CONTROLS:
KEEP AWAY FROM HEAT AND OPEN FLAME; STORE IN A COOL, DRY PLACE.
PERSONAL PROTECTION:
RESPIRATOR:
NOT REQUIRED DURING NORMAL OPERATIONS. SCBA REQUIRED IN THE EVENT OF A
FIRE.
EYE/FACE PROTECTION: NOT REQUIRED BEYOND SAFETY PRACTICES OF EMPLOYER.
GLOVES: NOT REQUIRED FOR HANDLING OF BATTERY PACKS.
FOOT PROTECTION: STEEL TOED SHOES RECOMMENDED FOR LARGE CONTAINER HANDLING.
| SECTION 9 - PHYSICAL AND CHEMICAL PROPERTIES | |
STATE: SOLID
ODOR: N/A
PH: N/A
VAPOR PRESSURE: N/A
VAPOR DENSITY: N/A
BOILING POINT: N/A
SOLUBILITY IN WATER: INSOLUBLE
SPECIFIC GRAVITY: N/A
DENSITY: N/A
| SECTION 10 - STABILITY AND REACTIVITY | |
REACTIVITY: NONE
STABILITY: STABLE UNDER ROUTINE USE
INCOMPATIBILITIES: NONE DURING NORMAL OPERATION
HAZARDOUS DECOMPOSITION PRODUCTS:
NONE DURING NORMAL OPERATING CONDITIONS
IF CELLS ARE OPENED, HYDROGEN FLUORIDE AND CARBON MONOXIDE MAY BE RELEASED
CONDITIONS TO AVOID:
AVOID EXPOSURE TO HEAT AND OPEN FLAME.
DO NOT PUNCTURE, CRUSH, OR INCINERATE.
| SECTION 11 - TOXICOLOGICAL INFORMATION | |
THIS PRODUCT DOES NOT EMIT TOXINS DURING ROUTINE HANDLING AND USE.
SENSITIZATION: NO
TERATOGENICITY: NO
REPRODUCTIVE TOXICITY: NO
ACUTE TOXICITY: NO
IF THE CELLS ARE OPENED THROUGH MISUSE OR DAMAGE, DISCARD IMMEDIATELY.
INTERNAL COMPONENTS OF CELL ARE IRRITANTS AND SENSITIZERS.
| SECTION 12 - ECOLOGICAL INFORMATION | |
SOME MATERIALS WITHIN THE CELL ARE BIO-ACCUMULATIVE. UNDER NORMAL
CONDITIONS, THESE MATERIALS ARE CONTAINED AND POSE NO RISK TO PERSONS OR
THE SURROUNDING ENVIRONMENT.
| SECTION 13 - DISPOSAL CONSIDERATIONS | |
RECOMMENDED METHODS FOR SAFE AND ENVIRONMENTALLY PREFERRED DISPOSAL:
PRODUCT:
RECYCLE THROUGH A RECYCLING COMPANY. DO NOT THROW A USED BATTERY OR BATTERY
PACK INTO THE ENVIRONMENT.
CONTAMINATED PACKAGE:
THE BATTERY PACK IS NOT CONTAMINATED UNDER NORMAL USE. IF INTERNAL
MATERIALS LEAK, DISPOSE AS INDUSTRIAL WASTES SUBJECT TO SPECIAL CONTROL.
CALIFORNIA REGULATED DEBRIS RCRA WASTE CODE: NON-REGULATED DISPOSE OF
ACCORDING TO ALL FEDERAL, STATE, AND LOCAL REGULATIONS.
| SECTION 14 - TRANSPORT INFORMATION | |
THE BATTERY MEETS THE REQUIREMENTS OF THE TEST IN THE UNITED NATIONS (UN)
MANUAL OF TESTS AND CRITERIA, PART III, SUB-SECTION 38.3
DOT: REFER TO ATTACHMENT ERG 2008 GUIDE 138 (EMERGENCY RESPONSE GUIDE)
IMDG: REFER TO IMDG/OCEAN TRANSPORT ENS F-A, S-I
IATA: REFER TO IATA-ICAO/AIR TRANSPORT ERG CODE 9F
BATTERY PACK:
PROPER SHIPPING NAME: LITHIUM ION BATTERIES.
WHEN LARGE AMOUNT OF BATTERIES ARE TRANSPORTED BY SHIP, VEHICLE AND
RAILROAD, AVOID HIGH TEMPERATURE AND DEW CONDENSATION.
AVOID TRANSPORTATION WHICH MAY CAUSE DAMAGE OF PACKAGE.
| SECTION 15 - REGULATORY INFORMATION | |
THE TRANSPORT OF RECHARGEABLE LITHIUM-ION BATTERIES IS REGULATED BY VARIOUS
BODIES, (IATA, IMO. US-DOT) THAT FOLLOW THE UNITED NATIONS "RECOMMENDATIONS
ON THE TRANSPORT OF DANGEROUS GOODS.
REGULATIONS SPECIFICALLY APPLICABLE TO THE PRODUCT:
ICAO 2009/2010 EDITION OF ICAO TECHNICAL INSTRUCTIONS FOR THE SAFETY
TRANSPORT OF DANGEROUS GOODS BY AIR
IMO IMDG AMENDMENT 34-08 2008-2010
IATA 52ND EDITION (2011) OF THE IATA DANGEROUS GOODS REGULATIONS (DGR)
US DEPARTMENT OF TRANSPORTATION DOT (49 CFR 100-185), (USA)
OSHA HAZARD COMMUNICATION STANDARD (29 CFR 1910.1200):
HAZARDOUS ( )
NON-HAZARDOUS (X)
THE BATTERY MEETS THE REQUIREMENTS OF PACKING INSTRUCTIONS 965, SECTION II
OF THE IATA REGULATION.
| SECTION 16 - OTHER INFORMATION | |
THE INFORMATION CONTAINED IN THIS DOCUMENT IS BASED ON THE PRESENT
KNOWLEDGE AND CURRENT LEGISLATION. IT PROVIDES GUIDANCE ON HEALTH, SAFETY,
AND ENVIRONMENTAL ASPECTS FOR THE IDENTIFIED PRODUCT AND SHOULD NOT BE
UNDERSTOOD AS ANY GUARANTEE OF TECHNICAL PERFORMANCE OR SUITABILITY FOR
PARTICULAR APPLICATIONS.
UN TEST RESULTS:
THIS PRODUCT HAS BEEN TESTED AND FOUND TO CONFORM TO UN TESTS AS RECOGNIZED
BY THE CERTIFICATE BELOW.
4 WESTBROOK CORPORATE CENTER, SUITE 900
WESTCHESTER, IL 60154
USA
TEL: 708-836-3800
FAX: 703-836-3801