| Common Name: | ANTI-CLOG |
| Manufacturer: | COMSTAR INTERNATIONAL |
| SDS Revision Date: | 5/1/2012 |
| SDS Format: | No Format Specified |
| Item Number(s): | 4PDC6, 4PDC7 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
COMSTAR(R*)
MATERIAL SAFETY DATA SHEET
COMPLIES WITH OSHA HAZARD COMMUNICATION AND WHIMS STANDARD 29 CFR 1910-1200
PRINT DATE: 05/01/12
PRODUCT NAME: ANTI-CLOG
PRODUCT NUMBER: 90-660, 90-661
| I - CHEMICAL PRODUCT AND COMPANY IDENTIFICATION |  |
MANUFACTURER: COMSTAR INTERNATIONAL INC.
ADDRESS:
20-45 128TH STREET
COLLEGE POINT, NY 11356
TEL: 718-445-7900, 800-328-0142
FAX: 718-353-5998
CHEMICAL NAME: BLENDED FORMULA
SYNONYM(S): NONE
| II - INGREDIENTS/IDENTITY INFORMATION | |
HAZARDOUS COMPONENTS OSHA PEL ACGIH TLV CAS NO. %
(SPECIFIC CHEMICAL IDENTITY)
ALKYL (60% C14, 30% C16, 5% C12, LD50: 500 MG/KG N/A 68391-01-5 >3
5% C18) DIMETHYL BENZYL AMMONIUM
CHLORIDE
ALKYL (68% C12, 32% C14) N/A N/A 68956-79-6 <3
DIMETHYL ETHYBENZYL AMMONIUM
CHLORIDE
| III - HAZARDS IDENTIFICATION | |
NFPA HAZARD RATINGS:
HEALTH 1
FLAMMABILITY 1
CHEMICAL REACTIVITY 1
HMIS HAZARD RATINGS:
HEALTH 1
FIRE 1
REACTIVITY 1
SPECIFIC 0
NOTE:
NFPA AND HMIS RATINGS INVOLVE DATA AND INTERPRETATIONS THAT MAY VARY FROM
COMPANY TO COMPANY. THEY ARE INTENDED ONLY FOR RAPID, GENERAL
IDENTIFICATION OF THE MAGNITUDE OF THE SPECIFIC HAZARD. TO DEAL ADEQUATELY
WITH THE SAFE HANDLING OF THIS MATERIAL, ALL THE INFORMATION CONTAINED IN
THIS MSDS MUST BE CONSIDERED.
| IV - FIRST-AID MEASURES | |
INHALATION:
IF SYMPTOMATIC, MOVE TO FRESH AIR. GET MEDICAL ATTENTION IF SYMPTOMS
PERSIST.
EYES:
IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES. GET MEDICAL
ATTENTION.
SKIN:
REMOVE CONTAMINATED CLOTHING, WASH AFFECTED SKIN WITH SOAP AND WATER
IMMEDIATELY. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR.
INGESTION:
PROMPTLY DRINK LARGE QUANTITIES OF MILK, EGG WHITES, GELATIN SOLUTION OR
WATER. AVOID ALCOHOL. DO NOT INDUCE VOMITING. SEEK IMMEDIATE MEDICAL
ATTENTION.
| V - FIRE FIGHTING MEASURES | |
FLASH POINT (DEG. F): N/A
FLAMMABILITY LIMIT: NOT ESTABLISHED
LET: N/A
UEL: N/A
EXTINGUISHING MEDIA: CO2, WATER, DRY CHEMICALS, FOAM
SPECIAL FIRE FIGHTING PROCEDURES:
WEAR SELF-CONTAINED BREATHING APPARATUS AND PROTECTIVE CLOTHING.
HAZARDOUS COMBUSTION PRODUCTS:
OXIDES OF CARBON NITROGEN AND OTHER TOXIC DECOMPOSITION PRODUCTS MAY OCCUR
IN CASES OF INCOMPLETE COMBUSTION
UNUSUAL FIRE AND EXPOSURE HAZARDS: NONE KNOWN. KEEP PRODUCT COOL.
| VI - ACCIDENTAL RELEASE MEASURES | |
SHOULD PRODUCT INADVERTENTLY BE REMOVED FROM ITS CASE AND PULVERIZED, PICK
UP MATERIAL WITH SCOOP, SHOVEL OR VACUUM AND PLACE IN CLOSED CONTAINER.
FLUSH AREA WITH WATER.
| VII - HANDLING AND STORAGE | |
PERSONAL PRECAUTIONARY MEASURES:
AVOID CONTACT WITH EYES AND SKIN. WASH THOROUGHLY AFTER HANDLING. DO NOT
BREATHE VAPORS OR FUMES.
PREVENTION OF FIRE AND EXPLOSION:
KEEP FROM CONTACT WITH OXIDIZING MATERIALS, ALKALIS AND ACIDS. STORE AWAY
FROM HEAT, SUNLIGHT AND MOISTURE.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE:
TABLET SHOULD NEVER BE REMOVED FROM ITS HOUSING. IT MUST NOT COME IN
CONTACT WITH FOOD. AVOID CONTACT WITH SKIN AND EYES. STORE IN A COOL, DRY
PLACE BETWEEN 50 DEG. - 120 DEG. F. KEEP AWAY FROM HEAT, SPARKS AND FLAMES.
DO NOT TAKE INTERNALLY. FOR USE BY SERVICE PERSONNEL ONLY.
| VIII - EXPOSURE CONTROLS/PERSONAL PROTECTION | |
EXPOSURE LIMITS:
ACGIH THRESHOLD LIMIT VALUE (TLV): SEE SECTION II
OSHA (USA) PERMISSIBLE EXPOSURE LIMIT (PEL): SEE SECTION II
VENTILATION:
GOOD GENERAL VENTILATION (TYPICALLY 10 AIR CHANGES PER HOUR) SHOULD BE
USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS. SUPPLEMENTARY
LOCAL EXHAUST VENTILATION, CLOSED SYSTEMS, OR RESPIRATORY PROTECTION MAY BE
NEEDED IN SPECIAL CIRCUMSTANCES SUCH AS POORLY VENTILATED SPACES,
EVAPORATION FROM LARGE SURFACES, SPRAYING, HEATING, ETC.
RESPIRATORY PROTECTION:
IF ENGINEERING CONTROLS DO NOT MAINTAIN AIRBORNE CONCENTRATIONS TO AN
ACCEPTABLE LEVEL, A NIOSH APPROVED RESPIRATOR MUST BE WORN.
RESPIRATOR TYPE:
ORGANIC VAPOR. IF RESPIRATORS ARE USED, A PROGRAM SHOULD BE INSTITUTED TO
ASSURE COMPLIANCE WITH OSHA STANDARD 29 CFR 1910.134.
EYE PROTECTION:
WEAR SAFETY GLASSES WITH SIDE SHIELDS (OR GOGGLES) AND A FACE SHIELD.
SKIN PROTECTION:
IT IS A GOOD INDUSTRIAL HYGIENE PRACTICE TO MINIMIZE SKIN CONTACT.
RECOMMENDED DECONTAMINATION FACILITIES: EYE BATH, WASHING FACILITIES
| IX - PHYSICAL AND CHEMICAL PROPERTIES | |
BOILING POINT (DEG. F): N/A
SPECIFIC GRAVITY (H2O = 1): .965 - .985
VAPOR PRESSURE @ 70 DEG. F: N/A
MELTING POINT: 170 DEG. - 180 DEG. F
VAPOR DENSITY (AIR = 1): N/A
EVAPORATION RATE: (BUTYL ACETATE = 1): N/A
PH: @ 5
SOLUBILITY IN WATER: 73 - 85%
APPEARANCE & ODOR:
SOLID, LIGHT BROWN CONTENTS WITH SLIGHT SOAPY ODOR PACKAGED IN RED PLASTIC
CONTAINER
ODOR THRESHOLD: NOT AVAILABLE
VOLATILE FRACTION BY WEIGHT: N/A
VISCOSITY AT 25 DEG. C (77 DEG. F): N/A
OCTANOL/WATER PARTITION COEFFICIENT: NOT AVAILABLE
AUTO IGNITION TEMPERATURE (ASTM D 2155): N/A
| X - STABILITY AND REACTIVITY | |
STABILITY: PRODUCT IS CONSIDERED STABLE.
INCOMPATIBILITY: STRONG OXIDIZING AGENTS ALKALIS AND ACIDS
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR
| XI - TOXICOLOGICAL INFORMATION | |
INHALATION: LOW HAZARD FOR USUAL INDUSTRIAL HANDLING BY TRAINED PERSONNEL.
EYES: CAUSES SEVERE IRRITATION
SKIN: SEVERE IRRITATION
INGESTION: NOT KNOWN. EXPECTED TO CAUSE NAUSEA AND DIARRHEA
ACUTE TOXICITY DATA:
ORAL LD-50 (RABBIT): NOT AVAILABLE
INHALATION LC-50: NOT AVAILABLE
| XII - ECOLOGICAL INFORMATION | |
SEE SECTION XIII DISPOSAL CONSIDERATIONS.
| XIII - DISPOSAL CONSIDERATIONS | |
DISPOSAL IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.
PESTICIDES ARE ACUTELY HAZARDOUS AND IMPROPER DISPOSAL OF EXCESS IS A
VIOLATION OF FEDERAL LAW. PLASTIC HOUSING CANNOT BE RECYCLED.
| XIV - TRANSPORT INFORMATION | |
DOT (USA) STATUS: NOT REGULATED
TDG (CANADA) STATUS: NOT REGULATED
AIR: INTERNATIONAL CIVIL AVIATION ORGANIZATION (ICAO)
ICAO STATUS: CHECK WITH AIR FREIGHT FORWARDER FOR RULING.
SEA: INTERNATIONAL MARITIME DANGEROUS GOODS (IMDG)
IMDG STATUS: NOT REGULATED
| XV - REGULATORY INFORMATION | |
THIS DOCUMENT HAS BEEN PREPARED IN ACCORDANCE WITH THE MSDS REQUIREMENTS OF
THE OSHA HAZARD COMMUNICATION STANDARD 29 CFR 910.1200.
OSHA HAZARDOUS CHEMICAL(S): TRADE SECRET (BLENDED FORMULA).
MASSACHUSETTS SUBSTANCE LIST: NONE.
NEW JERSEY WORKPLACE HAZARDOUS SUBSTANCE LIST: NONE
PENNSYLVANIA HAZARDOUS SUBSTANCE LIST: NONE
THIS DOCUMENT HAS BEEN PREPARED IN ACCORDANCE WITH THE MSDS REQUIREMENTS OF
THE WHMIS CONTROLLED PRODUCTS REGULATION.
WHMIS (CANADA) INGREDIENT DISCLOSURE LIST: TRADE SECRET (BLENDED FORMULA).
WHMIS (CANADA) STATUS: NOT LISTED.
WHMIS (CANADA) CONTROLLED MATERIAL(S): NOT LISTED.
WHMIS (CANADA) HAZARD CLASSIFICATION: NOT CLASSIFIED.
CARCINOGENICITY CLASSIFICATION (COMPONENTS PRESENT AT 0.1% OR MORE): NONE
INTERNATIONAL AGENCY FOR RESEARCH ON CANCER (IARC): NOT LISTED
AMERICAN CONFERENCE OF GOVERNMENTAL INDUSTRIAL HYGIENIST (ACGIH):
NOT LISTED
NATIONAL TOXICOLOGY PROGRAM (NTP): NOT LISTED
OCCUPATIONAL SAFETY AND HEALTH ADMINISTRATION (OSHA): NOT LISTED
CHEMICAL(S) SUBJECT TO THE REPORTING REQUIREMENTS OF SECTION 313 OR TITLE
III OF THE SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT (SARA) OF 1986 AND
40 CFR PART 372: NONE.
SARA (U.S.A.) SECTIONS 311 AND 312 HAZARD CLASSIFICATION(S): NOT LISTED.
NOTE:
THE OPINIONS EXPRESSED ARE THOSE OF QUALIFIED EXPERTS WITHIN COMSTAR
INTERNATIONAL INC. WE BELIEVE THAT THE INFORMATION CONTAINED IS CURRENT AS
OF THE DATE OF THE MATERIAL SAFETY DATA SHEET. SINCE THE USE OF THIS
INFORMATION AND OF THESE OPINIONS AND THE CONDITIONS OF THE USE OF THE
PRODUCT ARE NOT WITHIN THE CONTROL OF COMSTAR INTERNATIONAL INC., IT IS THE
USER'S OBLIGATION TO DETERMINE THE CONDITIONS OF SAFE USE OF THE PRODUCT.