| Common Name: | PERMA-PATCH |
| Manufacturer: | PERMA-PATCH |
| SDS Revision Date: | 1/18/2012 |
| SDS Format: | No Format Specified |
| Item Number(s): | 13R450, 3ZC17 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
| MANUFACTURER'S NAME |
| TYPICAL COMPOSITION |
| SPECIAL PROTECTIVE INFORMATION |
| FIRE PROTECTION |
| ENVIRONMENTAL PROTECTION |
| TOXIC SUBSTANCES CONTROL ACT |
| SPECIAL PRECAUTIONS |
MATERIAL SAFETY DATA SHEET
PERMA-PATCH(R*)
MATERIAL INFORMATION BULLETIN
JANUARY 18, 2012
(APPROVED-"ESSENTIALLY SIMILAR" TO FORM OSHA 20 AND OSHA 174
MATERIAL SAFETY DATA SHEET)
IDENTITY (AS USED ON LABEL AND LIST): PERMA-PATCH
| MANUFACTURER'S NAME |  |
PERMA-PATCH, INC.
6123 OAKLEAF AVE.
BALTIMORE, MARYLAND 21215
EMERGENCY PHONE:
CHEMTREC: 800-424-9300
TELEPHONE FOR INFORMATION: 410-764-7117
| TYPICAL COMPOSITION | |
CAS NO. OSHA PEL ACGIH PEL %
PETROLEUM ASPHALT 8052-42-4 NONE 5 MG/CU.M 4.5
WITH VISCOSITY PROPRIETARY ESTABLISHED
ADJUSTING AGENT
LIMESTONE 15 MG/CU.M 10 MG/CU.M 94
ADDITIVE FOR ADHESION PROPRIETARY NON-ESTABLISHED 0.5
BY OSHA
ADDITIVES PROPRIETARY NON-ESTABLISHED 1
BY OSHA
PHYSIOLOGICAL AND HEALTH EFFECTS EMERGENCY AND FIRST AID PROCEDURES
EYES:
EXPECTED TO CAUSE NO MORE THAN MINOR WASH EYE WITH FRESH WATER FOR AT
EYE IRRITATION. LEAST 15 MINUTES. IF IRRITATION
CONTINUES, SEE A DOCTOR.
SKIN:
EXPECTED TO PRODUCE NO MORE THAN REMOVE HEAVILY CONTAMINATED
MINOR IRRITATION, BUT PROLONGED OR CLOTHING AND WASH SKIN THOROUGHLY
FREQUENTLY REPEATED SKIN CONTACT WITH SOAP AND WATER. DO NOT USE
MAY BE HARMFUL. SEE ADDITIONAL SOLVENTS OR THINNERS TO REMOVE
HEALTH DATA. MATERIALS FROM SKIN. ASPHALT CAN
BE REMOVED WITH VEGETABLE OIL OR
MINERAL OIL.
INHALATION:
PROLONGED BREATHING OF HIGH VAPOR IF THERE ARE ANY SIGNS OR SYMPTOMS
CONCENTRATIONS CAN CAUSE CENTRAL AS DESCRIBED IN THIS BULLETIN DUE
NERVOUS SYSTEM DEPRESSION. SEE TO BREATHING THIS MATERIAL, MOVE
ADDITIONAL HEALTH DATA. THE PERSON TO FRESH AIR. IF ANY OF
(ONLY PERTAINS TO LIQUID FORM) THESE EFFECTS CONTINUE, SEE A
DOCTOR.
INGESTION:
NOT EXPECTED TO BE ACUTELY TOXIC BY IF A LARGE VOLUME OF THIS MATERIAL
INGESTION. IS SWALLOWED GIVE A LARGE AMOUNT
OF WATER TO DINK, INDUCE
NOTE TO PHYSICIAN: VOMITING AND CALL A DOCTOR.
THIS MATERIAL CONTAINS LIGHT
HYDROCARBON LIQUID AND AN ASPIRATION
HAZARD MAY EXIST.
| SPECIAL PROTECTIVE INFORMATION | |
EYE PROTECTION:
AVOID CONTACT WITH EYES. EYE CONTACT CAN BE AVOIDED BY WEARING CHEMICAL
SAFETY GOGGLES.
SKIN PROTECTION:
AVOID PROLONGED OR FREQUENTLY REPEATED SKIN CONTACT WITH THIS MATERIAL.
SKIN CONTACT CAN BE MINIMIZED BY WEARING IMPERVIOUS PROTECTIVE CLOTHING
INCLUDING RUBBER GLOVES. IF SKIN CONTACT OCCURS, A WASHING FACILITY SHOULD
BE AVAILABLE NEARBY.
RESPIRATORY PROTECTION:
IF OPERATING CONDITIONS CREATE HIGH AIRBORNE CONCENTRATIONS WHICH EXCEED
THE EXPOSURE STANDARD, THE USE OF AN APPROVED RESPIRATOR IS RECOMMENDED.
(ONLY PERTAINS TO LIQUID FORM)
VENTILATION:
USE ADEQUATE VENTILATION TO KEEP THE AIRBORNE CONCENTRATIONS OF THIS
MATERIAL BELOW THE EXPOSURE STANDARD.
| FIRE PROTECTION | |
LIQUID EVAPORATES AND FORMS VAPOR (FUMES) WHICH CAN CATCH FIRE AND BURN
WITH EXPLOSIVE VIOLENCE. INVISIBLE VAPOR SPREADS EASILY AND CAN BE SET
ON FIRE BY MANY SOURCES SUCH AS PILOT LIGHTS, WELDING EQUIPMENT, AND
ELECTRICAL MOTORS AND SWITCHES. FIRE HAZARD IS GREATER AS LIQUID
TEMPERATURE RISES ABOVE 85 DEGREES F. (ONLY PERTAINS TO LIQUID FORM)
| ENVIRONMENTAL PROTECTION | |
ENVIRONMENTAL IMPACT:
THIS MATERIAL IS NOT EXPECTED TO PRESENT ANY ENVIRONMENTAL PROBLEMS.
PRECAUTIONS IF MATERIAL IS RELEASED OR SPILLED:
ELIMINATE OPEN FLAMES IN VICINITY OF SPILL OR RELEASED VAPOR. CLEAN UP
SPILLS AS SOON AS POSSIBLE, OBSERVING PRECAUTIONS IN SPECIAL PROTECTIVE
INFORMATION AND PRODUCT LABEL. PLACE SPILLED MATERIAL IN DISPOSABLE
CONTAINERS. HYDROCARBONS MATERIAL SUCH AS KEROSENE OR MINERAL OIL CAN BE
USED TO DISSOLVE ANY REMAINING MATERIAL; AND THIS MATERIAL MAY BE ABSORBED
WITH CLAY OR DIATOMACEOUS EARTH.
WASTE DISPOSAL METHODS:
PLACE CONTAMINATED MATERIAL IN DISPOSAL CONTAINERS AND BURY IN APPROVED
DUMPING AREA.
REACTIVITY DATA: STABILITY (THERMAL, LIGHT, ETC.) STABLE.
PETROLEUM ASPHALT WITH VISCOSITY ADJUSTING AGENT AND ADDITIVE FOR
ADHESION:
LIQUID ONLY:
FLASH POINT (TOC): 170 F (MIN)
AUTO IGNITION TEMPERATURE: 480 F (MIN)
FLAMMABILITY LIMITS (ASPHALT):
LEL: 0.9
VEL: 6.0
EXTINGUISHING MEDIA: CO2, DRY CHEMICAL, FOAM, WATER SPRAY.
NFPA RATINGS:
HEALTH 0
FLAMMABILITY 2
REACTIVITY 0
SPECIAL NDA
(LEAST-0, SLIGHT-1, MODERATE-2, HIGH-3, EXTREME-4).
THESE VALUES ARE OBTAINED USING THE GUIDELINES OR PUBLISHED EVALUATIONS
PREPARED BY THE NATIONAL FIRE PROTECTION ASSOCIATION OR IF APPLICABLE, THE
NATIONAL PAINT AND COATING ASSOCIATION, AND DO NOT NECESSARILY REFLECT THE
HAZARD EVALUATION OF PERMA-PATCH, INC. READ THE ENTIRE DOCUMENT AND LABEL
BEFORE USING THIS PRODUCT. THIS LIQUID IS MIXED WITH 1/4" LIMESTONE AND IS
ONLY 5% OF THE FINISHED PRODUCT (60 LB. BAG). THIS DESCRIPTION REFERS ONLY
TO THE PURE LIQUID AND NOT TO THE FINISHED PRODUCT.
SPECIAL FIRE FIGHTING PROCEDURES:
FOR FIRES INVOLVING THIS MATERIAL, DO NOT ENTER ANY ENCLOSED OR CONFINED
FIRE SPACE WITHOUT PROPER PROTECTIVE EQUIPMENT, INCLUDING SELF CONTAINED
BREATHING APPARATUS. SEE HAZARDOUS DECOMPOSITION PRODUCTS. READ THE ENTIRE
BULLETIN. (ONLY PERTAINS TO LIQUID FORM)
SPECIAL PRECAUTIONS: SEE IN THE END OF THIS MSDS.
INCOMPATIBILITY (MATERIALS TO AVOID):
MAY REACT WITH STRONG OXIDIZING MATERIALS.
HAZARDOUS DECOMPOSITION PRODUCTS:
NORMAL COMBUSTION FORMS CARBON DIOXIDE AND WATER VAPOR, AND MAY PRODUCE
OXIDE SULFUR, INCOMPLETE COMBUSTION CAN PRODUCE CARBON MONOXIDE. (ONLY
PERTAINS TO LIQUID FORM)
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR.
SOLUBILITY:
SOLUBLE IN MOST HALOGENATED HYDROCARBONS AND BENZENE; INSOLUBLE IN WATER
AND ALCOHOLS.
APPEARANCE (COLOR, ODOR, ETC): OILY SMELLING, BLACK VISCOUS LIQUID.
INITIAL BOILING POINT: 600 F (MIN)
MELTING POINT: N/A
SPECIFIC GRAVITY: 0.98 @ 15.6/15.6C
VAPOR PRESSURE: 2 MMHg @ 100 F
VAPOR DENSITY (AIR=1): NDA
PERCENT VOLATILE (VOLUME 96): 25%
EVAPORATION; (=1): N/A
VISCOSITY: 250-500 CST @ 140 F
N/A = NOT AVAILABLE
NDA = NO DATA AVAILABLE
THE INFORMATION LISTED ABOVE IS BASED ON DATA OF WHICH WE ARE AWARE AND
IS BELIEVED TO BE CORRECT AS OF DATE HERE. SINCE THE INFORMATION CONTAINED
HEREIN MAY BE APPLIED UNDER CONDITIONS BEYOND OUR CONTROL AND WITH WHICH
WE MAY BE UNFAMILIAR AND SINCE DATA MADE AVAILABLE SUBSEQUENT TO THE DATE
HEREOF MAY SUGGEST MODIFICATIONS OF THE INFORMATION, WE DO NOT ASSUME
ANY RESPONSIBILITY FOR THE RESULTS OF ITS USE. THE INFORMATION IS
FURNISHED UPON THE CONDITION THAT THE PERSON RECEIVING IT SHALL MAKE
HIS/HER OWN DETERMINATION OF THE SUITABILITY OF THE MATERIAL FOR
HIS/HER PARTICULAR PURPOSE.
ADDITIONAL HEALTH DATA:
SIGNS AND SYMPTOMS OF VENTRAL NERVOUS SYSTEM DEPRESSION MAY INCLUDE ONE OR
MORE OF THE FOLLOWING:
HEADACHE, DIZZINESS, LOSS OF APPETITE, WEAKNESS AND LOSS OF COORDINATION.
AFFECTED PERSONS USUALLY EXPERIENCE COMPLETE RECOVERY WHEN REMOVED FROM
THE EXPOSURE AREA.
NO ASSOCIATION HAS BEEN ESTABLISHED BETWEEN INDUSTRIAL EXPOSURE TO
PETROLEUM ASPHALT AND CANCER IN HUMANS. ASPHALTS CONTAIN SMALL AMOUNTS OF
POLYNUCLEAR AROMATIC HYDROCARBONS (ONS'S) WHICH WHEN CONCENTRATED, HAVE
BEEN SHOWN TO CAUSE SKIN CANCER IN MICE AFTER PROLONGED AND FREQUENT
CONTACT. STUDIES IN WHICH MICE WERE EXPOSED TO A VARIETY OF WHOLE ASPHALTS
DID NOT RESULT IN ANY INCREASED CANCER RATE. BRIEF OR INTERMITTENT SKIN
CONTACT WITH THIS ASPHALT PRODUCT IS NOT EXPECTED TO PRODUCE ANY SERIOUS
EFFECTS. WHILE NORMAL HANDLING OF THIS PRODUCT IS NOT LIKELY TO CAUSE
CANCER IN HUMANS, SKIN CONTACT AND BREATHING OF MISTS, FUMES OR VAPORS
SHOULD BE REDUCED TO A MINIMUM. WE STRONGLY RECOMMEND THAT THE PRECAUTIONS
OUTLINED IN THIS BULLETIN BE FOLLOWED WHEN HANDLING THIS MATERIAL.
| TOXIC SUBSTANCES CONTROL ACT | |
ALL CHEMICALS USED IN THIS PRODUCT ARE EITHER ON OR EXEMPT FROM THE TSCA
INVENTORY PURSUANT TO SECTION 8(B) OF THE TOXIC SUBSTANCES CONTROL ACT
(TSCA), 15 U.S.C. SUBSECTION 2601 ET SEQ.
| SPECIAL PRECAUTIONS | |
READ AND OBSERVE ALL PRECAUTIONS ON PRODUCT LABEL.
DO NOT USE OR STORE NEAR FLAME, SPARKS OR HOT SURFACES. USE ONLY IN WELL
VENTILATED AREA. (ONLY PERTAINS TO LIQUID FORM).