| Common Name: | RID O' RUST FORMULA 500 |
| Manufacturer: | PRO PRODUCTS |
| SDS Revision Date: | 1/17/2011 |
| SDS Format: | No Format Specified |
| Item Number(s): | 23PD91 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
PRO PRODUCTS LLC
MATERIAL SAFETY DATA SHEET
| 1. PRODUCT AND COMPANY IDENTIFICATION |  |
PRODUCT NAME: RID O' RUST FORMULA 500
CAS #: MIXTURE
PRODUCT USE: RUST STAIN PREVENTER
MANUFACTURER:
PRO PRODUCTS LLC
7201 ENGLE ROAD
FORT WAYNE, IN 46804-5875
US
PHONE: 260-483-2519
EMERGENCY PHONE: 1-800-424-9300 (CHEMTREC)
HMIS:
HEALTH 1
FLAMMABILITY 0
PHYSICAL HAZARD 0
PERSONAL PROTECTION B
NFPA:
1
0
0
LEGEND:
SEVERE: 4
SERIOUS: 3
MODERATE: 2
SLIGHT: 1
MINIMAL: 0
| 2. HAZARDS IDENTIFICATION | |
EMERGENCY OVERVIEW:
WARNING
CAUSES EYE IRRITATION.
CORROSIVE TO METALS.
POTENTIAL SHORT TERM HEALTH EFFECTS:
ROUTES OF EXPOSURE: EYE, SKIN CONTACT, INHALATION, INGESTION.
EYES: CAUSES IRRITATION.
SKIN: NON-IRRITATING BASED ON TEST DATA.
INHALATION: MAY CAUSE RESPIRATORY TRACT IRRITATION.
INGESTION: MAY CAUSE STOMACH DISTRESS, NAUSEA OR VOMITING.
TARGET ORGANS: EYES. SKIN. RESPIRATORY SYSTEM.
CHRONIC EFFECTS:
PROLONGED OR REPEATED EXPOSURE TO DILUTIONS CAN CAUSE DRYING, DEFATTING AND
DERMATITIS.
SIGNS AND SYMPTOMS:
SYMPTOMS MAY INCLUDE REDNESS, EDEMA, DRYING, DEFATTING AND CRACKING OF THE
SKIN. SYMPTOMS OF OVEREXPOSURE MAY BE HEADACHE, DIZZINESS, TIREDNESS,
NAUSEA AND VOMITING.
OSHA REGULATORY STATUS:
THIS PRODUCT IS A "HAZARDOUS CHEMICAL" AS DEFINED BY THE OSHA HAZARD
COMMUNICATION STANDARD, 29 CFR 1910.1200.
POTENTIAL ENVIRONMENTAL EFFECTS: THIS PRODUCT HAS NOT BEEN TESTED.
| 3. COMPOSITION / INFORMATION ON INGREDIENTS | |
INGREDIENT(S) CAS # PERCENT
CITRIC ACID 77-92-9 30 - 60
| 4. FIRST AID MEASURES | |
FIRST AID PROCEDURES:
EYE CONTACT:
IMMEDIATELY FLUSH WITH COOL WATER. REMOVE CONTACT LENSES, IF APPLICABLE,
AND CONTINUE FLUSHING FOR 15 MINUTES. OBTAIN MEDICAL ATTENTION IF
IRRITATION DEVELOPS OR PERSISTS.
SKIN CONTACT:
FLUSH WITH COOL WATER. WASH WITH SOAP AND WATER. OBTAIN MEDICAL ATTENTION
IF IRRITATION PERSISTS.
INHALATION:
IF SYMPTOMS DEVELOP MOVE VICTIM TO FRESH AIR. IF SYMPTOMS PERSIST, OBTAIN
MEDICAL ATTENTION.
INGESTION:
DO NOT INDUCE VOMITING. NEVER GIVE ANYTHING BY MOUTH IF VICTIM IS
UNCONSCIOUS, OR IS CONVULSING. OBTAIN MEDICAL ATTENTION.
GENERAL ADVICE:
IF YOU FEEL UNWELL, SEEK MEDICAL ADVICE (SHOW THE LABEL WHERE POSSIBLE).
ENSURE THAT MEDICAL PERSONNEL ARE AWARE OF THE MATERIAL(S) INVOLVED, AND
TAKE PRECAUTIONS TO PROTECT THEMSELVES. SHOW THIS SAFETY DATA SHEET TO THE
DOCTOR IN ATTENDANCE. AVOID CONTACT WITH EYES. WEAR SAFETY GLASSES. KEEP
OUT OF REACH OF CHILDREN.
| 5. FIRE FIGHTING MEASURES | |
FLAMMABLE PROPERTIES: NOT FLAMMABLE BY WHMIS/OSHA CRITERIA.
EXTINGUISHING MEDIA:
SUITABLE EXTINGUISHING MEDIA:
CARBON DIOXIDE. WATER SPRAY. DRY CHEMICAL. FOAM.
UNSUITABLE EXTINGUISHING MEDIA: NOT AVAILABLE
PROTECTION OF FIREFIGHTERS:
SPECIFIC HAZARDS ARISING FROM THE CHEMICAL: NOT AVAILABLE
PROTECTIVE EQUIPMENT FOR FIREFIGHTERS:
FIREFIGHTERS SHOULD WEAR FULL PROTECTIVE CLOTHING INCLUDING SELF CONTAINED
BREATHING APPARATUS.
HAZARDOUS COMBUSTION PRODUCTS:
MAY INCLUDE AND ARE NOT LIMITED TO: OXIDES OF CARBON.
EXPLOSION DATA:
SENSITIVITY TO MECHANICAL IMPACT: NOT AVAILABLE
SENSITIVITY TO STATIC DISCHARGE: NOT AVAILABLE
| 6. ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS:
KEEP UNNECESSARY PERSONNEL AWAY. DO NOT TOUCH OR WALK THROUGH SPILLED
MATERIAL. DO NOT TOUCH DAMAGED CONTAINERS OR SPILLED MATERIAL UNLESS
WEARING APPROPRIATE PROTECTIVE CLOTHING. KEEP PEOPLE AWAY FROM AND UPWIND
OF SPILL/LEAK.
ENVIRONMENTAL PRECAUTIONS: DO NOT CONTAMINATE WATER.
METHODS FOR CONTAINMENT:
STOP LEAK IF YOU CAN DO SO WITHOUT RISK. PREVENT ENTRY INTO WATERWAYS,
SEWERS, BASEMENTS OR CONFINED AREAS. USE WATER SPRAY TO REDUCE VAPORS OR
DIVERT VAPOR CLOUD DRIFT.
METHODS FOR CLEANING UP:
BEFORE ATTEMPTING CLEAN UP, REFER TO HAZARD DATA GIVEN ABOVE. SMALL SPILLS
MAY BE ABSORBED WITH NON-REACTIVE ABSORBENT AND PLACED IN SUITABLE,
COVERED, LABELLED CONTAINERS. PREVENT LARGE SPILLS FROM ENTERING SEWERS OR
WATERWAYS. CONTACT EMERGENCY SERVICES AND SUPPLIER FOR ADVICE. NEVER RETURN
SPILLS IN ORIGINAL CONTAINERS FOR RE-USE.
LARGE SPILLS:
WET DOWN WITH WATER AND DIKE FOR LATER DISPOSAL. AFTER REMOVAL FLUSH
CONTAMINATED AREA THOROUGHLY WITH WATER.
| 7. HANDLING AND STORAGE | |
HANDLING: USE GOOD INDUSTRIAL HYGIENE PRACTICES IN HANDLING THIS MATERIAL.
STORAGE:
KEEP OUT OF THE REACH OF CHILDREN. STORE IN A CLOSED CONTAINER AWAY FROM
INCOMPATIBLE MATERIALS.
| 8. EXPOSURE CONTROLS / PERSONAL PROTECTION | |
EXPOSURE LIMITS:
INGREDIENT(S) EXPOSURE LIMITS
CITRIC ACID ACGIH-TLV:
TWA: 10 MG/M3
OSHA-PEL:
TWA: 10 MG/M3
ENGINEERING CONTROLS:
NOT NORMALLY REQUIRED IF GOOD VENTILATION IS MAINTAINED.
PERSONAL PROTECTIVE EQUIPMENT:
EYE / FACE PROTECTION: WEAR SAFETY GLASSES WITH SIDE SHIELDS.
HAND PROTECTION: NOT NORMALLY REQUIRED.
SKIN AND BODY PROTECTION: AS REQUIRED BY EMPLOYER CODE.
RESPIRATORY PROTECTION:
WHERE EXPOSURE GUIDELINE LEVELS MAY BE EXCEEDED, USE AN APPROVED NIOSH
RESPIRATOR.
GENERAL HYGIENE CONSIDERATIONS:
USE GOOD INDUSTRIAL HYGIENE PRACTICES IN HANDLING THIS MATERIAL. WHEN USING
DO NOT EAT OR DRINK. WASH HANDS BEFORE BREAKS AND IMMEDIATELY AFTER
HANDLING THE PRODUCT.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE: CLEAR.
COLOR: BLUE
FORM: LIQUID
ODOR: ODORLESS
ODOR THRESHOLD: NOT AVAILABLE
PHYSICAL STATE: LIQUID
PH: <1.0
MELTING POINT: NOT AVAILABLE
FREEZING POINT: NOT AVAILABLE
BOILING POINT: NOT AVAILABLE
POUR POINT: NOT AVAILABLE
EVAPORATION RATE: NOT AVAILABLE
FLASH POINT: NOT AVAILABLE
AUTO-IGNITION TEMPERATURE: NOT AVAILABLE
FLAMMABILITY LIMITS IN AIR, LOWER, % BY VOLUME: NOT AVAILABLE
FLAMMABILITY LIMITS IN AIR, UPPER, % BY VOLUME: NOT AVAILABLE
VAPOR PRESSURE: NOT AVAILABLE
VAPOR DENSITY: NOT AVAILABLE
SPECIFIC GRAVITY: 1.19
OCTANOL/WATER COEFFICIENT: NOT AVAILABLE
PERCENT VOLATILE: NOT AVAILABLE
| 10. STABILITY AND REACTIVITY | |
REACTIVITY: THIS PRODUCT MAY REACT WITH STRONG ALKALIES.
POSSIBILITY OF HAZARDOUS REACTIONS:
HAZARDOUS POLYMERIZATION DOES NOT OCCUR.
CHEMICAL STABILITY: STABLE UNDER RECOMMENDED STORAGE CONDITIONS.
CONDITIONS TO AVOID: DO NOT MIX WITH OTHER CHEMICALS.
INCOMPATIBLE MATERIALS: CAUSTICS. OXIDIZERS. REDUCING AGENTS.
HAZARDOUS DECOMPOSITION PRODUCTS:
MAY INCLUDE AND ARE NOT LIMITED TO: OXIDES OF CARBON.
| 11. TOXICOLOGICAL INFORMATION | |
COMPONENT ANALYSIS - LC50:
INGREDIENT(S) LC50
CITRIC ACID NOT AVAILABLE
COMPONENT ANALYSIS - ORAL LD50:
INGREDIENT(S) LD50
CITRIC ACID 5040 MG/KG MOUSE
3000 MG/KG RAT
EFFECTS OF ACUTE EXPOSURE:
EYE: CAUSES IRRITATION.
SKIN: NON-IRRITATING BASED ON TEST DATA.
INHALATION: MAY CAUSE RESPIRATORY TRACT IRRITATION.
INGESTION: MAY CAUSE STOMACH DISTRESS, NAUSEA OR VOMITING.
SENSITIZATION: NON-HAZARDOUS BY WHMIS/OSHA CRITERIA.
CHRONIC EFFECTS: NON-HAZARDOUS BY WHMIS/OSHA CRITERIA.
CARCINOGENICITY: NOT CLASSIFIED OR LISTED BY IARC, NTP, OSHA AND ACGIH.
MUTAGENICITY: NON-HAZARDOUS BY WHMIS/OSHA CRITERIA.
REPRODUCTIVE EFFECTS: NON-HAZARDOUS BY WHMIS/OSHA CRITERIA.
TERATOGENICITY: NON-HAZARDOUS BY WHMIS/OSHA CRITERIA.
NAME OF TOXICOLOGICALLY SYNERGISTIC PRODUCTS: NOT AVAILABLE
| 12. ECOLOGICAL INFORMATION | |
ECOTOXICITY: SEE BELOW
ECOTOXICITY - FRESHWATER FISH - ACUTE TOXICITY DATA:
CITRIC ACID 77-92-9 96 HR LC50 LEPOMIS MACROCHIRUS:
1516 MG/L [STATIC]
ECOTOXICITY - WATER FLEA - ACUTE TOXICITY DATA:
CITRIC ACID 77-92-9 72 HR EC50 DAPHNIA MAGNA: 120 MG/L
PERSISTENCE / DEGRADABILITY: NOT AVAILABLE
BIOACCUMULATION / ACCUMULATION: NOT AVAILABLE
MOBILITY IN ENVIRONMENTAL MEDIA: NOT AVAILABLE
ENVIRONMENTAL EFFECTS: NOT AVAILABLE
AQUATIC TOXICITY: NOT AVAILABLE
PARTITION COEFFICIENT: NOT AVAILABLE
CHEMICAL FATE INFORMATION: NOT AVAILABLE
OTHER ADVERSE EFFECTS: NOT AVAILABLE
| 13. DISPOSAL CONSIDERATIONS | |
DISPOSAL INSTRUCTIONS:
REVIEW FEDERAL, STATE/PROVINCIAL, AND LOCAL GOVERNMENT REQUIREMENTS PRIOR
TO DISPOSAL.
WASTE FROM RESIDUES / UNUSED PRODUCTS: NOT AVAILABLE
CONTAMINATED PACKAGING: NOT AVAILABLE
| 14. TRANSPORT INFORMATION | |
U.S. DEPARTMENT OF TRANSPORTATION (DOT):
BASIC SHIPPING REQUIREMENTS:
PROPER SHIPPING NAME:
CORROSIVE LIQUID, ACIDIC, ORGANIC, N.O.S. (1,2,3-PROPANETRICARBOXYLIC
ACID, 2-HYDROXY-)
HAZARD CLASS: 8
UN NUMBER: UN3265
PACKING GROUP: III
ADDITIONAL INFORMATION:
SPECIAL PROVISIONS: IB3, T7, TP1, TP28
PACKAGING EXCEPTIONS: 154
ERG NUMBER: 153
CORROSIVE, CLASS/DIVISION 8
TRANSPORTATION OF DANGEROUS GOODS (TDG - CANADA):
BASIC SHIPPING REQUIREMENTS:
PROPER SHIPPING NAME:
CORROSIVE LIQUID, ACIDIC, ORGANIC, N.O.S. (1,2,3-PROPANETRICARBOXYLIC
ACID, 2-HYDROXY-)
HAZARD CLASS: 8
UN NUMBER: UN3265
PACKING GROUP: III
ADDITIONAL INFORMATION:
SPECIAL PROVISIONS: 16
CLASS 8, CORROSIVES
| 15. REGULATORY INFORMATION | |
CANADIAN FEDERAL REGULATIONS:
THIS PRODUCT HAS BEEN CLASSIFIED IN ACCORDANCE WITH THE HAZARD CRITERIA OF
THE CONTROLLED PRODUCTS REGULATIONS AND THE MSDS CONTAINS ALL THE
INFORMATION REQUIRED BY THE CONTROLLED PRODUCTS REGULATIONS.
CANADA - WHMIS - INGREDIENT DISCLOSURE LIST:
CITRIC ACID 77-92-9 1%
WHMIS STATUS: CONTROLLED
WHMIS CLASSIFICATION: CLASS D - DIVISION 2B, CLASS E - CORROSIVE MATERIAL
WHMIS LABELING:
D2 - MATERIALS CAUSING OTHER TOXIC EFFECTS
E - CORROSIVE MATERIAL
OCCUPATIONAL SAFETY AND HEALTH ADMINISTRATION (OSHA):
29 CFR 1910.1200 HAZARDOUS CHEMICAL: YES
US FEDERAL REGULATIONS:
THIS PRODUCT IS A "HAZARDOUS CHEMICAL" AS DEFINED BY THE OSHA HAZARD
COMMUNICATION STANDARD, 29 CFR 1910.1200.
CERCLA (SUPERF UND) REPORTABLE QUANTITY: NONE
SUPERF UND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 (SARA):
HAZARD CATEGORIES:
IMMEDIATE HAZARD: YES
DELAYED HAZARD: NO
FIRE HAZARD: NO
PRESSURE HAZARD: NO
REACTIVITY HAZARD: NO
SECTION 302 EXTREMELY HAZARDOUS SUBSTANCE: NO
SECTION 311 HAZARDOUS CHEMICAL: YES
CLEAN AIR ACT (CAA): NOT AVAILABLE
CLEAN WATER ACT (CWA): NOT AVAILABLE
STATE REGULATIONS:
THIS PRODUCT DOES NOT CONTAIN A CHEMICAL KNOWN TO THE STATE OF CALIFORNIA
TO CAUSE CANCER, BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM.
INVENTORY NAME:
COUNTRY(S) OR INVENTORY NAME ON INVENTORY
REGION (YES/NO)*
CANADA DOMESTIC SUBSTANCES LIST (DSL) YES
CANADA NON-DOMESTIC SUBSTANCES LIST (NDSL) NO
UNITED STATES & TOXIC SUBSTANCES CONTROL ACT (TSCA) YES
PUERTO RICO INVENTORY
A "YES" INDICATES THAT ALL COMPONENTS OF THIS PRODUCT COMPLY WITH THE
INVENTORY REQUIREMENTS ADMINISTERED BY THE GOVERNING COUNTRY(S)
| 16. OTHER INFORMATION | |
DISCLAIMER:
INFORMATION CONTAINED HEREIN WAS OBTAINED FROM SOURCES CONSIDERED
TECHNICALLY ACCURATE AND RELIABLE. WHILE EVERY EFFORT HAS BEEN MADE TO
ENSURE FULL DISCLOSURE OF PRODUCT HAZARDS, IN SOME CASES DATA IS NOT
AVAILABLE AND IS SO STATED. SINCE CONDITIONS OF ACTUAL PRODUCT USE ARE
BEYOND CONTROL OF THE SUPPLIER, IT IS ASSUMED THAT USERS OF THIS MATERIAL
HAVE BEEN FULLY TRAINED ACCORDING TO THE REQUIREMENTS OF ALL APPLICABLE
LEGISLATION AND REGULATORY INSTRUMENTS. NO WARRANTY, EXPRESSED OR IMPLIED,
IS MADE AND SUPPLIER WILL NOT BE LIABLE FOR ANY LOSSES, INJURIES OR
CONSEQUENTIAL DAMAGES WHICH MAY RESULT FROM THE USE OF OR RELIANCE ON ANY
INFORMATION CONTAINED IN THIS DOCUMENT.
ISSUE DATE: 17-JAN-2011
EFFECTIVE DATE: 01-APR-2011
EXPIRY DATE: 01-APR-2014
PREPARED BY: DELL TECH LABORATORIES LTD. (519) 858-5021
OTHER INFORMATION:
FOR AN UPDATED MSDS, PLEASE CONTACT THE SUPPLIER/MANUFACTURER LISTED IN
SECTION 1 OF THIS DOCUMENT.
#18150