| Common Name: | POXY PART A, POXY PART B, POXY PART C |
| Manufacturer: | TILE REDI |
| SDS Revision Date: | 10/1/2010 |
| SDS Format: | ANSI-OSHA |
| Item Number(s): | 29TA42, 29TA44, 29TA45, 29TA46, 29TA47, 29TA53, 29TA55, 29TA59, 29TA60, 29TA61, 29TA62, 29TA64, 29TA66, 29TA68, 29TA70, 29TA71, 29TA76, 29TA78, 29TA79, 29TA80, 29TA81, 29TA83, 29TA84, 29TA90, 29TA91, 29TA93, 29TA94, 29TA95, 29TA96, 29TA97, 29TC01, 29TC02, 29TC03, 29TC05, 29TC06, 29TC11, 29TC14, 29TC15, 29TC17, 29TC20, 29TC21, 29TC24, 29TC25, 29TC26, 29TC28, 29TC30, 29TC32, 29TC36, 29TC37, 29TC38, 29TC39, 29TC40, 29TC41, 29TC44, 29TC46, 29TC47, 29TC49, 29TC50, 29TC51, 29TC56, 29TC59, 29TC60, 29TC64, 29TC65, 29TC66, 29TC67, 29TC71, 29TC72, 29TC73, 29TC79, 29TC80, 29TC81, 29TC83, 29TC84, 29TC85, 29TC86, 29TC93, 29TC94, 29TC95 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
MATERIAL SAFETY DATA SHEET
| I. PRODUCT IDENTIFICATION |  |
TRADE NAME (AS LABELED): REDI POXY PART A
CHEMICAL FAMILY: AMINE EPOXY CURING AGENT
MANUFACTURER'S NAME:
TILE REDI USA, LLC
TILE REDI LTD
TILE REDI INTERNET SALES, LLC
4450 N.W. 126TH AVE SUITE 101
CORAL SPRINGS, FLORIDA 33065
PHONE NUMBER FOR ADDITIONAL INFORMATION: 800-232-6156
DATE PREPARED OR REVISED: 10/2010
NAME OF PREPARER: S.B. FINE
| II. HAZARDOUS INGREDIENTS | |
CHEMICAL NAMES CAS NUMBERS PERCENT ACGIH OSHA OTHER
TLV PEL (SPECIFY)
TETRAETHLYENE PENTAMINE 68953-36-6 70-75 N/A N/A
REACTION PRODUCTS WITH
TALL OIL FATTY ACIDS
TETRAETHLYENE PENTAMINE 112-57-2 5-10 N/A N/A
1-(2-AMINOETHYLPIPERAZINE) 140-31-8 1-4 N/A N/A
TRIS2-4-6(DIAMINOMETHYL) 90-72-2 1-3 N/A N/A
PHENOL
N/A = NOT APPLICABLE OR AVAILABLE
| III. HEALTH HAZARD INFORMATION | |
SYMPTOMS OF OVEREXPOSURE FOR EACH POTENTIAL ROUTE OF EXPOSURE. (POSSIBLE
LONGER TERM EFFECTS).:
SENSITIZATION AND ASTHMATIC REACTION MAY DEVELOP WITH CONTINUED EXPOSURE
TO VAPORS.
SIGNS AND SYMPTOMS OF EXPOSURE (ACUTE EFFECTS):
INHALED:
BREATHING VAPORS MAY CAUSE IRRITATION OF THE NOSE AND THROAT. SYMPTOMS
ASSOCIATED WITH PRE-EXISTING LUNG DISORDERS MAY BE AGGRAVATED BY EXPOSURE
TO THIS MATERIAL.
CONTACT WITH SKIN OR EYES:
THIS MATERIAL CAUSES SEVERE EYE IRRITATION. DIRECT CONTACT WITH THE
MATERIAL OR EXPOSURE TO VAPOR OR MISTS MAY CAUSE STINGING, TEARING,
REDNESS, BLURRED VISION, AND CHEMICAL BURNS OF THE CORNEA. BURNS OF THE
EYE MAY CAUSE BLINDNESS. THIS MATERIAL IS CORROSIVE TO SKIN. SKIN
SENSITIZATION AND ALLERGIC REACTION ARE POSSIBLE.
ABSORBED THROUGH SKIN: N/A
SWALLOWED:
NOT LIKELY TO OCCUR IN TYPICAL INDUSTRIAL ENVIRONMENTS HOWEVER INGESTION OF
THIS MATERIAL MAY BE HARMFUL OR FATAL.
SUSPECTED CANCER AGENT?:
(X) NO: THIS PRODUCT'S INGREDIENTS ARE NOT FOUND IN THE LISTS BELOW.
YES:
( ) FEDERAL OSHA
( ) NTP
( ) IARC
| IV. FIRST AID: EMERGENCY PROCEDURES | |
EYE CONTACT:
HOLD EYELIDS APART AND IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER FOR AT
LEAST 15 MINUTES. GET MEDICAL ATTENTION IMMEDIATELY.
SKIN CONTACT:
REMOVE PRODUCT AND IMMEDIATELY FLUSH AFFECTED AREA WITH WATER FOR AT LEAST
15 MINUTES. CALL A PHYSICIAN. EXCEPT IN THE MOST MINOR, SUPERFICIAL AND
LOCALIZED BURNS, COVER THE AFFECTED AREA WITH A STERILE DRESSING OR CLEAN
SHEETING AND TRANSPORT FOR MEDICAL CARE. DO NOT APPLY GREASES OR OINTMENTS.
CONTROL SHOCK, IF PRESENT. LAUNDER CONTAMINATED CLOTHING PRIOR TO REUSE.
CONTAMINATED LEATHER WEAR SHOULD BE DISCARDED. VICTIMS OF A MAJOR SKIN AREA
CONTACT SHOULD REMAIN UNDER MEDICAL OBSERVATION FOR AT LEAST 24 HOURS DUE
TO POSSIBLE DELAYED EFFECTS.
INHALED:
IF BREATHING HAS STOPPED OR IS LABORED GIVE ASSISTED RESPIRATION (E.G.
MOUTH-TO-MOUTH). SUPPLEMENTAL OXYGEN MAY BE INDICATED. PREVENT ASPIRATION
OF VOMIT. TURN VICTIM'S HEAD TO THE SIDE. ASSURE MUCUS DOES NOT OBSTRUCT
AIRWAY. CALL A PHYSICIAN
SWALLOWED:
IN THE EVENT OF INGESTION, DO NOT INDUCE VOMITING. OBTAIN MEDICAL CARE AND
HOSPITAL TREATMENT IMMEDIATELY.
| V. FIRE AND EXPLOSION | |
FLASH POINT (METHOD): 350 DEG. F (CLEVELAND OPEN CUP)
AUTO IGNITION TEMPERATURE, DEG. F:
FLAMMABLE LIMITS IN AIR, VOLUME %:
LOWER (LEL):
UPPER (UEL):
FIRE EXTINGUISHING MATERIALS:
(X) WATER SPRAY
(X) CARBON DIOXIDE
(X) FOAM
(X) DRY CHEMICAL
( ) OTHER
SPECIAL FIRE FIGHTING PROCEDURES:
NFPA CLASS II OF HMIS CLASS I RATING. WEAR FULL PROTECTIVE GEAR AND
NIOSH/MSHA APPROVED SELF-CONTAINED BREATHING APPARATUS. RETAIN EXPENDED
LIQUIDS FROM FIRE FIGHTING FOR LATER DISPOSAL.
UNUSUAL FIRE AND EXPLOSION HAZARDS: N/A
| VI. SPILL, LEAK, AND DISPOSAL PROCEDURES | |
SPILL RESPONSE PROCEDURES (INCLUDE EMPLOYEE PROTECTION MEASURES):
DAM AND ABSORB SPILL WITH ABSORBENT MATERIALS, MINIMIZE BREATHING VAPORS.
INCREASE VENTILATION. WEAR IMPERVIOUS GLOVES, SAFETY GOGGLES, AND NIOSH
APPROVED ORGANIC VAPOR CANISTER TYPE RESPIRATOR.
PREPARING WASTES FOR DISPOSAL (CONTAINER TYPES, NEUTRALIZATION, ETC.):
ABSORB SPILL ON SAND, EARTH, OR VERMICULITE. CAREFULLY COLLECT INTO CLOSED
CONTAINERS FOR DISPOSAL. WASH SPILL AREA WITH 5% ACETIC ACID THEN FLUSH
WITH WATER. DO NOT SEWER.
NOTE:
DISPOSE OF ALL WASTES IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL
REGULATIONS.
| VII. HANDLING AND STORAGE | |
STORE IN COOL DRY AREA.
| VIII. EXPOSURE CONTROLS AND PERSONAL PROTECTION | |
VENTILATION AND ENGINEERING CONTROLS:
GENERAL VENTILATION SHOULD BE ADEQUATE.
RESPIRATORY PROTECTION (TYPE):
IN CONFINED AREAS, A NIOSH APPROVED ORGANIC VAPOR CANISTER TYPE RESPIRATOR
SHOULD BE WORN.
EYE PROTECTION (TYPE): CHEMICAL SPLASH PROOF GOGGLES.
GLOVES (SPECIFY MATERIAL):
NITRILE RUBBER GLOVES. IN EMERGENCY SITUATIONS, WEAR IMPERMEABLE GLOVES
WITH CUFFS TO PREVENT SPREAD OF MATERIAL TO AREA ABOVE THE WRISTS.
OTHER CLOTHING AND EQUIPMENT: LONG SLEEVED SHIRT AND LONG TROUSERS
WORK PRACTICES, HYGIENIC PRACTICES:
WASH AT THE END OF EACH WORK SHIFT AND BEFORE EATING, SMOKING OR USING
THE TOILET. LAUNDER OR DISCARD CONTAMINATED CLOTHING. DISCARD CONTAMINATED
LEATHER ARTICLES. EXAMINE PROTECTIVE GLOVES BEFORE USING. DISCARD IF FIND
EVIDENCE OF HOLES OR CRACKS
OTHER HANDLING AND STORAGE REQUIREMENTS: N/A
PROTECTIVE MEASURES DURING MAINTENANCE OF CONTAMINATED EQUIPMENT:
SEE ABOVE.
| IX. PHYSICAL PROPERTIES | |
VAPOR DENSITY (AIR=1): N/A
MELTING POINT OR RANGE, DEG. F: N/A
SPECIFIC GRAVITY: 0.99
BOILING POINT OR RANGE, DEG. F: N/A
SOLUBILITY IN WATER: SLIGHTLY SOLUBLE
EVAPORATION RATE (BUTYL ACETATE = 1): N/A
VAPOR PRESSURE, MMHg AT 20 DEG. C: N/A
APPEARANCE AND ODOR: AMBER COLORED LIQUID WITH AMINE ODOR
HOW TO DETECT THIS SUBSTANCE (WARNING PROPERTIES OF SUBSTANCE AS A GAS,
VAPOR, DUST, OR MIST):
| X. REACTIVITY DATA | |
STABILITY:
(X) STABLE
( ) UNSTABLE
CONDITIONS TO AVOID: N/A
INCOMPATIBILITY (MATERIALS TO AVOID):
OXIDIZING AGENTS (I.E. PERCHLORATES, NITRATES ETC.). CLEANING SOLUTIONS,
SUCH AS CHROMERGE (SULFURIC ACID/DICHROMATE) AND AQUA REGIA. A REACTION
ACCOMPANIED BY LARGE HEAT RELEASE OCCURS WHEN THE PRODUCT IS MIXED WITH
ACIDS.
HAZARDOUS DECOMPOSITION PRODUCTS (INCLUDING COMBUSTION PRODUCTS):
(FROM BURNING, HEATING, OR REACTION WITH OTHER MATERIALS).
CARBON MONOXIDE, CARBON DIOXIDE, OXIDES OF NITROGEN.
HAZARDOUS POLYMERIZATION:
( ) MAY OCCUR
(X) WILL NOT OCCUR
CONDITIONS TO AVOID: N/A.
| XI. TOXICOLOGY INFORMATION | |
POLYAMIDE RESIN - ORAL (RAT) LD50: >2000 MG/KG
IRRITATION DATA SKIN - RABBIT: >660 MG/KG
CORROSIVE EYE - RABBIT: SEVERE
| XII. ECOLOGICAL INFORMATION | |
LC50 (24 H): 222 MG/L
SPECIES: RAINBOW TROUT (ONCORHYNCHUS MYKISS).
LC100 (96 H): 240 MG/L
SPECIES: RAINBOW TROUT (ONCORHYNCHUS MYKISS).
LC0 (96 H): 180 MG/L
SPECIES: RAINBOW TROUT (ONCORHYNCHUS MYKISS).
LC50 (24 H): 249 MG/L
SPECIES: CARP (CYPRINUS CARPIO).
LC50 (96 H): 175 MG/L
SPECIES: CARP (CYPRINUS CARPIO).
EC50(96H): 718 MG/L
SPECIES: GRASS SHRIMP (PALAEMONETES).
EC100 (96 H): 1,000 MG/L
SPECIES: MUD CRAB (NEOPANOPE).
EC0 (96 H): 750 MG/L
SPECIES: MUD CRAB (NEOPANOPE).
EC50 (72 H): 84 MG/L
SPECIES: SCENEDESMUS SUBSPICATUS
TOXICITY TO OTHER ORGANISMS: NO DATA AVAILABLE.
PERSISTENCE AND DEGRADABILITY:
BIODEGRADABILITY:
ACCORDING TO THE RESULTS OF TESTS OF BIODEGRADABILITY THIS PRODUCT IS NOT
READILY BIODEGRADABLE.
MOBILITY: NO DATA AVAILABLE.
BIOACCUMULATION: NO DATA IS AVAILABLE ON THE PRODUCT ITSELF.
| XIII. DISPOSAL INFORMATION | |
DISPOSE IN COMPLIANCE WITH LOCAL, STATE, AND FEDERAL REGULATIONS.
| XIV. TRANSPORT INFORMATION | |
DOT:
DOT PROPER SHIPPING NAME: AMINES LIQUID CORROSIVE, N.O.S
TECHNICAL NAME:
(TETRAETHYLENEPENTAMINE AND TRIS-2,4,6-(DIMETHYLAMINOMETHYL)PHENOL))
HAZARD CLASS: 8
UN/ID NUMBER: UN2735
PACKING GROUP: II.
FOR MATERIAL IN INNER PACKAGINGS NOT OVER 1 LITER (0.3 GALLON) CAN BE
CLASSIFIED CONSUMER COMMODITY ORM-D.
IATA:
PROPER SHIPPING NAME: AMINES LIQUID CORROSIVE, N.O.S
TECHNICAL NAME:
(TETRAETHYLENEPENTAMINE AND TRIS-2,4,6-(DIMETHYLAMINOMETHYL)PHENOL)
HAZARD CLASS: 8
UN/ID NUMBER: UN2735
PACKING GROUP: II.
IMDG:
PROPER SHIPPING NAME: AMINES LIQUID CORROSIVE, N.O.S
TECHNICAL NAME:
(TETRAETHYLENEPENTAMINE AND TRIS-2,4,6-(DIMETHYLAMINOMETHYL)PHENOL))
HAZARD CLASS: 8
UN/ID NUMBER: UN2735
PACKING GROUP: II
TDG:
PROPER SHIPPING NAME: AMINES LIQUID CORROSIVE, N.O.S
TECHNICAL NAME:
(TETRAETHYLENEPENTAMINE AND TRIS-2,4,6-(DIMETHYLAMINOMETHYL)PHENOL))
HAZARD CLASS: 8
UN/ID NUMBER: UN2735
PACKING GROUP: II
| XV. REGULATORY INFORMATION | |
ALL INGREDIENTS ARE LISTED ON THE U.S. EPA TSCA INVENTORY OF CHEMICAL
SUBSTANCES.
SARA SECTION 311/312 HAZARD CLASSIFICATION:
IMMEDIATE (ACUTE) HEALTH, DELAYED (CHRONIC) HEALTH.
W.H.M.I.S. CODE: E
| XVI OTHER INFORMATION | |
THIS INFORMATION IS FURNISHED WITHOUT WARRANTY, REPRESENTATION, INDUCEMENT
OR LICENSE OF ANY KIND; EXCEPT THAT IT IS ACCURATE TO THE BEST OF OUR
KNOWLEDGE, OR OBTAINED FROM SOURCES BELIEVED BY US TO BE ACCURATE.
MATERIAL SAFETY DATA SHEET
| I. PRODUCT IDENTIFICATION | |
TRADE NAME (AS LABELED): REDI POXY PART B
CHEMICAL FAMILY: EPOXY RESIN
MANUFACTURER'S NAME:
TILE REDI USA, LLC
TILE REDI LTD
TILE REDI INTERNET SALES, LLC
4450 N.W. 126TH AVE SUITE 101
CORAL SPRINGS, FLORIDA 33065
PHONE NUMBER FOR ADDITIONAL INFORMATION: 800-232-6156
DATE PREPARED OR REVISED: 10/2010
NAME OF PREPARER: S.B. FINE
| II. HAZARDOUS INGREDIENTS | |
CHEMICAL NAMES CAS NUMBERS PERCENT ACGIH OSHA OTHER
TLV PEL (SPECIFY)
PROPANE, 2,2-BIS[P- 25085-99-8 60-70 N/A N/A N/A
(2,3-EPOXYPROPOXY)
PHENYL]-,POLYMERS
ALKYL GLYCIDYL ETHER 28064-14-4 15-25 N/A N/A N/A
REACTION PRODUCT: 68609-97-2 10-20 N/A N/A N/A
BISPHANOL F-
(EPICHLORHYDRIN);
EPOXY RESIN
N/A = NOT APPLICABLE OR AVAILABLE
| III. HEALTH HAZARD INFORMATION | |
SYMPTOMS OF OVEREXPOSURE FOR EACH POTENTIAL ROUTE OF EXPOSURE.
(POSSIBLE LONGER TERM EFFECTS): NONE KNOWN
SIGNS AND SYMPTOMS OF EXPOSURE (ACUTE EFFECTS):
INHALED: MAY CAUSE IRRITATION OF RESPIRATORY TRACT.
CONTACT WITH SKIN OR EYES:
MINOR TRANSIENT IRRITATION FOR EYE CONTACT. NO CORNEAL INJURY LIKELY. MAY
CAUSE ALLERGIC SKIN REACTION. PROLONGED EXPOSURE NOT LIKELY TO CAUSE SKIN
IRRITATION.
SKIN SENSITIZER ABSORBED THROUGH SKIN:
NOT LIKELY TO ABSORB THROUGH SKIN IN TOXIC AMOUNT IN A SINGLE PROLONGED
EXPOSURE. LD50 FOR SKIN ABSORPTION FOR RABBITS: 20,000 MG/KG.
SWALLOWED:
CAUSES GASTROINTESTINAL IRRITATION AND POSSIBLE BURNS IF SWALLOWED
SUSPECTED CANCER AGENT?:
(X) NO: THIS PRODUCT'S INGREDIENTS ARE NOT FOUND IN THE LISTS BELOW.
YES:
( ) FEDERAL OSHA
( ) NTP
( ) IARC
| IV. FIRST AID: EMERGENCY PROCEDURES | |
EYE CONTACT:
HOLD EYELIDS APART AND IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER FOR AT
LEAST 15 MINUTES. GET MEDICAL ATTENTION IMMEDIATELY.
SKIN CONTACT:
CONTACT WILL PROBABLY CAUSE NO MORE THAN IRRITATION. WASH OFF IN FLOWING
WATER OR SHOWER. WASH CLOTHING BEFORE REUSE.
INHALED:
IF INHALED, REMOVE TO FRESH AIR. IF EFFECTS OCCUR CONSULT A PHYSICIAN
SWALLOWED DO NOT INDUCE VOMITING. CALL A PHYSICIAN
| V. FIRE AND EXPLOSION | |
FLASH POINT (METHOD): 245 DEG. F
METHOD USED: PMCC
AUTO IGNITION TEMPERATURE, DEG. F: N/A
FLAMMABLE LIMITS IN AIR, VOLUME %:
LOWER (LEL):
UPPER (UEL):
FIRE EXTINGUISHING MATERIALS:
( ) WATER SPRAY
(X) CARBON DIOXIDE
(X) FOAM
(X) DRY CHEMICAL
( ) OTHER
SPECIAL FIRE FIGHTING PROCEDURES:
WEAR POSITIVE PRESSURE SELF CONTAINED BREATHING APPARATUS
UNUSUAL FIRE AND EXPLOSION HAZARDS: NONE KNOWN.
| VI. SPILL, LEAK, AND DISPOSAL PROCEDURES | |
SPILL RESPONSE PROCEDURES (INCLUDE EMPLOYEE PROTECTION MEASURES):
SOAK UP IN ABSORBENT MATERIAL OR SCRAPE UP. RESIDUAL CAN BE REMOVED WITH
HOT WATER AND A NONIONIC SURFACTANT. WEAR GOGGLES, RUBBER GLOVES, LONG
SLEEVED CLOTHING.
PREPARING WASTES FOR DISPOSAL (CONTAINER TYPES, NEUTRALIZATION, ETC.):
BURN IN ADEQUATE INCINERATOR OR BURY IN AN APPROVED LANDFILL.
NOTE:
DISPOSE OF ALL WASTES IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL
REGULATIONS.
| VII. HANDLING AND STORAGE | |
STORE IN COOL DRY AREA.
| VIII. EXPOSURE CONTROLS AND PERSONAL PROTECTION | |
VENTILATION AND ENGINEERING CONTROLS:
GOOD ROOM VENTILATION SHOULD BE ADEQUATE FOR MOST OPERATIONS
RESPIRATORY PROTECTION (TYPE): NONE NORMALLY NEEDED
EYE PROTECTION (TYPE): CHEMICAL SPLASH PROOF GOGGLES, SAFETY GLASSES
GLOVES (SPECIFY MATERIAL): RUBBER OR POLYETHYLENE GLOVES
OTHER CLOTHING AND EQUIPMENT: CLEAN, BODY-COVERING CLOTHING
WORK PRACTICES, HYGIENIC PRACTICES: N/A
OTHER HANDLING AND STORAGE REQUIREMENTS: N/A
PROTECTIVE MEASURES DURING MAINTENANCE OF CONTAMINATED EQUIPMENT: SEE ABOVE
| IX. PHYSICAL PROPERTIES | |
VAPOR DENSITY (AIR=1): N/A
MELTING POINT OR RANGE, DEG. F: N/A
SPECIFIC GRAVITY: 1.12
BOILING POINT OR RANGE, DEG. F: N/A
SOLUBILITY IN WATER: INSOLUBLE
EVAPORATION RATE (BUTYL ACETATE = 1): N/A
VAPOR PRESSURE, MMHg AT 20 DEG. C: N/A
VOC: 0.04 LB/GAL.
APPEARANCE AND ODOR: THICK OPAQUE LIQUID
HOW TO DETECT THIS SUBSTANCE (WARNING PROPERTIES OF SUBSTANCE AS A GAS,
VAPOR, DUST, OR MIST):
| X. REACTIVITY DATA | |
STABILITY:
(X) STABLE
( ) UNSTABLE
CONDITIONS TO AVOID:
EXCESS HEATING OVER LONG PERIODS OF TIME DEGRADES THE RESIN
INCOMPATIBILITY (MATERIALS TO AVOID): BASES
HAZARDOUS DECOMPOSITION PRODUCTS (INCLUDING COMBUSTION PRODUCTS):
(FROM BURNING, HEATING, OR REACTION WITH OTHER MATERIALS). INCOMPLETE
PYROLOSIS OR COMBUSTION RESULTS IN PHENOLICS, CARBON MONOXIDE, CARBON
DIOXIDE, AND WATER. THERMAL DECOMPOSITION SHOULD BE TRACED AS A POTENTIALLY
HAZARDOUS SUBSTANCE.
HAZARDOUS POLYMERIZATION:
( ) MAY OCCUR
(X) WILL NOT OCCUR
CONDITIONS TO AVOID:
MASSES OF MORE THAN 1 POUND OF PRODUCT PLUS AN ALIPHATIC AMINE WILL CAUSE
IRREVERSIBLE POLYMERIZATION WITH CONSIDERABLE HEAT BUILD UP.
| XI. TOXICOLOGY INFORMATION | |
LD50 FOR SKIN ABSORPTION FOR RABBITS: 20,000 MG/KG
| XII. ECOLOGICAL INFORMATION | |
NONE KNOWN
| XIII. DISPOSAL INFORMATION | |
DISPOSE IN COMPLIANCE WITH LOCAL, STATE, AND FEDERAL REGULATIONS.
| XIV. TRANSPORT INFORMATION | |
NO SPECIAL LABELING OR TRANSPORTATION PLACARDING IS REQUIRED.
| XV. REGULATORY INFORMATION | |
ALL INGREDIENTS ARE LISTED ON THE U.S. EPA TSCA INVENTORY OF CHEMICAL
SUBSTANCES.
| XVI OTHER INFORMATION | |
THIS INFORMATION IS FURNISHED WITHOUT WARRANTY, REPRESENTATION, INDUCEMENT
OR LICENSE OF ANY KIND; EXCEPT THAT IT IS ACCURATE TO THE BEST OF OUR
KNOWLEDGE, OR OBTAINED FROM SOURCES BELIEVED BY US TO BE ACCURATE.
MATERIAL SAFETY DATA SHEET
| I. PRODUCT IDENTIFICATION | |
TRADE NAME (AS LABELED): REDI POXY PART C
CHEMICAL FAMILY: PROPRIETARY BLEND
MANUFACTURER'S NAME:
TILE REDI USA, LLC
TILE REDI LTD
TILE REDI INTERNET SALES, LLC
4450 N.W. 126TH AVE SUITE 101
CORAL SPRINGS, FLORIDA 33065
PHONE NUMBER FOR ADDITIONAL INFORMATION: 800-232-6156
DATE PREPARED OR REVISED: 10/2010
NAME OF PREPARER: S.B. FINE
| II. HAZARDOUS INGREDIENTS | |
CHEMICAL NAMES CAS NUMBERS PERCENT ACGIH TLV OSHA PEL OTHER
(SPECIFY)
SILICA SAND 14808-60-7 50 - 90 50 MICRO G/M3 10 MG/M3 N/A
ALUMINUM OXIDE 1344-28-1 0 - 4 10 MG/M3 15 MG/M3 N/A
TITANIUM DIOXIDE 13463-67-7 0 - 12 10 MG/M3 15 MG/M3 N/A
N/A = NOT APPLICABLE OR AVAILABLE
| III. HEALTH HAZARD INFORMATION | |
SYMPTOMS OF OVEREXPOSURE FOR EACH POTENTIAL ROUTE OF EXPOSURE. (POSSIBLE
LONGER TERM EFFECTS):
INHALED:
SYMPTOMS ARE DYSPNEA-CAUSED BY MANY LUNG SCARS THAT DEVELOP FROM THE
DUST-PAIN IN CHEST, DECREASED VITAL CHRONIC LUNG SCARRING LEADS TO A
PROGRESSIVE MASSIVE FIBROSIS THAT IS OFTEN ACCOMPANIED BY INCREASED
SUSCEPTIBILITY TO THE RISK OF IMPAIRED HEALTH DUE TO A COMBINATION OF
SMOKING AND DUST EXPOSURE. PERSONS WITH REDUCED PULMONARY FUNCTION MAY BE
AT INCREASED RISK.
CAPACITY AND COUGH. INHALATION OF THE DUST CAN CAUSE SILICOSIS AND MAY
CAUSE LUNG CANCER DEPENDING ON DURATION AND LEVEL OF EXPOSURE
SIGNS AND SYMPTOMS OF EXPOSURE (ACUTE EFFECTS):
EYE CONTACT MAY CAUSE EYE IRRITATION. INHALATION OF DUST MAY CAUSE LUNG
IRRITATION.
SUSPECTED CANCER AGENT?:
( ) NO: THIS PRODUCT'S INGREDIENTS ARE NOT FOUND IN THE LISTS BELOW.
YES:
( ) FEDERAL OSHA
( ) NTP
(X) IARC
| IV. FIRST AID: EMERGENCY PROCEDURES | |
EYE CONTACT:
HOLD EYELIDS APART AND IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER FOR AT
LEAST 15 MINUTES. GET MEDICAL ATTENTION IMMEDIATELY.
SKIN CONTACT:
IF IRRITATION OCCURS, REMOVE AFFECTED CLOTHING AND WASH THE SKIN EXPOSED.
INHALED:
REMOVE TO FRESH AREA. FOR EXTREME RESPIRATORY DISTRESS, ADMINISTER OXYGEN.
SWALLOWED REFER TO PHYSICIAN
| V. FIRE AND EXPLOSION | |
FLASH POINT (METHOD): NON FLAMMABLE OR COMBUSTIBLE
AUTO IGNITION TEMPERATURE, DEG. F: N/A
FLAMMABLE LIMITS IN AIR, VOLUME %:
LOWER (LEL):
UPPER (UEL):
FIRE EXTINGUISHING MATERIALS:
(X) WATER SPRAY
(X) CARBON DIOXIDE
(X) FOAM
(X) DRY CHEMICAL
( ) OTHER
SPECIAL FIRE FIGHTING PROCEDURES:
WEAR SELF-CONTAINED BREATHING APPARATUS WITH FULL FACE PIECE AND PROTECTIVE
CLOTHING.
UNUSUAL FIRE AND EXPLOSION HAZARDS:
THIS PRODUCT MAY FORM EXPLOSIVE DUST CLOUDS IN AIR.
| VI. SPILL, LEAK, AND DISPOSAL PROCEDURES | |
SPILL RESPONSE PROCEDURES (INCLUDE EMPLOYEE PROTECTION MEASURES):
CLEAN UP WITH DUSTLESS METHOD (USE VACUUM OR WET SWEEPING). WEAR NIOSH
APPROVED DUST MASK, SAFETY GLASSES, GLOVES.
PREPARING WASTES FOR DISPOSAL (CONTAINER TYPES, NEUTRALIZATION, ETC.): N/A
NOTE:
DISPOSE OF ALL WASTES IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL
REGULATIONS.
| VII. HANDLING AND STORAGE | |
STORE IN COOL DRY AREA.
| VIII. EXPOSURE CONTROLS AND PERSONAL PROTECTION | |
VENTILATION AND ENGINEERING CONTROLS: NORMAL VENTILATION
RESPIRATORY PROTECTION (TYPE):
NIOSH APPROVED DISPOSABLE DUST MASK IF TLVL IS EXCEEDED
EYE PROTECTION (TYPE): SAFETY GLASSES
GLOVES (SPECIFY MATERIAL): CLOTH OR IMPERMEABLE GLOVES
OTHER CLOTHING AND EQUIPMENT: LONG SLEEVED CLOTHING
WORK PRACTICES, HYGIENIC PRACTICES: NORMAL GOOD HOUSEKEEPING
OTHER HANDLING AND STORAGE REQUIREMENTS:
KEEP AWAY FROM STRONG ALKALIS AND OXIDIZERS
PROTECTIVE MEASURES DURING MAINTENANCE OF CONTAMINATED EQUIPMENT:
WEAR NIOSH APPROVED DUST MASK, SAFETY GLASSES, GLOVES
| IX. PHYSICAL PROPERTIES | |
VAPOR DENSITY (AIR=1): N/A
MELTING POINT OR RANGE, DEG. F: N/A
SPECIFIC GRAVITY: 2.3
BOILING POINT OR RANGE, DEG. F: N/A
SOLUBILITY IN WATER: INSOLUBLE
EVAPORATION RATE (BUTYL ACETATE = 1): N/A
VAPOR PRESSURE, MMHg AT 20 DEG. C: N/A
VOC: 0 LB/GAL
APPEARANCE AND ODOR: ODORLESS FREE FLOWING COLORED POWDER
HOW TO DETECT THIS SUBSTANCE (WARNING PROPERTIES OF SUBSTANCE AS A GAS,
VAPOR, DUST, OR MIST): N/A
| X. REACTIVITY DATA | |
STABILITY:
(X) STABLE
( ) UNSTABLE
CONDITIONS TO AVOID: N/A
INCOMPATIBILITY (MATERIALS TO AVOID):
EXPOSURE TO HYDROFLUORIC ACID OR STRONG ALKALIS OR OXIDIZERS.
HAZARDOUS DECOMPOSITION PRODUCTS (INCLUDING COMBUSTION PRODUCTS):
(FROM BURNING, HEATING, OR REACTION WITH OTHER MATERIALS). MAY RELEASE
CARBON MONOXIDE, CARBON DIOXIDE, NITROGEN OXIDE, AMMONIA UPON COMBUSTION.
HAZARDOUS POLYMERIZATION:
( ) MAY OCCUR
(X) WILL NOT OCCUR
CONDITIONS TO AVOID: EXPOSURE TO STRONG OXIDIZERS OR ALKALIS
| XI. TOXICOLOGY INFORMATION | |
N/A
| XII. ECOLOGICAL INFORMATION | |
N/A
| XIII. DISPOSAL INFORMATION | |
DISPOSE IN COMPLIANCE WITH LOCAL, STATE, AND FEDERAL REGULATIONS.
| XIV. TRANSPORT INFORMATION | |
NO SPECIAL LABELING OR TRANSPORTATION PLACARDING IS REQUIRED.
| XV. REGULATORY INFORMATION | |
ALL INGREDIENTS ARE LISTED ON THE U.S. EPA TSCA INVENTORY OF CHEMICAL
SUBSTANCES.
THIS PRODUCT CONTAINS A CHEMICAL KNOWN TO THE STATE OF CALIFORNIA TO CAUSE
CANCER OR REPRODUCTIVE HARM.
| XVI OTHER INFORMATION | |
THIS INFORMATION IS FURNISHED WITHOUT WARRANTY, REPRESENTATION, INDUCEMENT
OR LICENSE OF ANY KIND; EXCEPT THAT IT IS ACCURATE TO THE BEST OF OUR
KNOWLEDGE, OR OBTAINED FROM SOURCES BELIEVED BY US TO BE ACCURATE.