| Common Name: | 3-36 MULTI-PURPOSE LUBRICANT & CORROSION INHIBITOR 03006, 03007, 03009, 03011 |
| Manufacturer: | CRC |
| SDS Revision Date: | 10/31/2013 |
| SDS Format: | GHS-US |
| Item Number(s): | 1HBK4, 3APL3, 4JB29, 5VE52 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
CRC(R*)
SAFETY DATA SHEET
| 1. IDENTIFICATION |  |
PRODUCT IDENTIFIER: 3-36(R*) MULTI-PURPOSE LUBRICANT & CORROSION INHIBITOR
OTHER MEANS OF IDENTIFICATION:
PRODUCT CODE: 03006, 03007, 03009, 03011
RECOMMENDED USE: MULTI-PURPOSE LUBRICANT
RECOMMENDED RESTRICTIONS: NONE KNOWN.
MANUFACTURER/IMPORTER/SUPPLIER/DISTRIBUTOR INFORMATION:
MANUFACTURED OR SOLD BY:
COMPANY NAME: CRC INDUSTRIES, INC.
ADDRESS:
885 LOUIS DR.
WARMINSTER, PA 18974
US
TELEPHONE:
GENERAL INFORMATION: 215-674-4300
TECHNICAL ASSISTANCE: 800-521-3168
CUSTOMER SERVICE: 800-272-4620
24-HOUR EMERGENCY (CHEMTREC):
800-424-9300 (US)
703-527-3887 (INTERNATIONAL)
WEBSITE: WWW.CRCINDUSTRIES.COM
| 2. HAZARD(S) IDENTIFICATION | |
PHYSICAL HAZARDS:
FLAMMABLE LIQUIDS: CATEGORY 4
HEALTH HAZARDS:
SKIN CORROSION/IRRITATION: CATEGORY 2
SPECIFIC TARGET ORGAN TOXICITY, SINGLE EXPOSURE: CATEGORY 3 NARCOTIC EFFECTS
ASPIRATION HAZARD: CATEGORY 1
ENVIRONMENTAL HAZARDS:
HAZARDOUS TO THE AQUATIC ENVIRONMENT, ACUTE HAZARD: CATEGORY 2
OSHA DEFINED HAZARDS: NOT CLASSIFIED.
LABEL ELEMENTS:
HEALTH HAZARD
EXCLAMATION MARK
SIGNAL WORD: DANGER
HAZARD STATEMENT:
COMBUSTIBLE LIQUID. MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS. CAUSES
SKIN IRRITATION. MAY CAUSE DROWSINESS OR DIZZINESS. TOXIC TO AQUATIC LIFE.
PRECAUTIONARY STATEMENT:
PREVENTION:
KEEP AWAY FROM HEAT/SPARKS/OPEN FLAMES/HOT SURFACES. - NO SMOKING. USE WITH
ADEQUATE VENTILATION. OPEN DOORS AND WINDOWS OR USE OTHER MEANS TO ENSURE A
FRESH AIR SUPPLY DURING USE AND WHILE PRODUCT IS DRYING. IF YOU EXPERIENCE
ANY SYMPTOMS LISTED ON THIS LABEL, INCREASE VENTILATION OR LEAVE THE AREA.
AVOID BREATHING MIST OR VAPOR. WASH HANDS THOROUGHLY AFTER HANDLING. WEAR
PROTECTIVE GLOVES/EYE PROTECTION/FACE PROTECTION. AVOID RELEASE TO THE
ENVIRONMENT.
RESPONSE:
IF SWALLOWED:
IMMEDIATELY CALL A POISON CENTER/DOCTOR. DO NOT INDUCE VOMITING.
IF ON SKIN: WASH WITH PLENTY OF WATER.
IF SKIN IRRITATION OR RASH OCCURS:
GET MEDICAL ATTENTION. TAKE OFF CONTAMINATED CLOTHING AND WASH BEFORE REUSE.
IF INHALED:
REMOVE PERSON TO FRESH AIR AND KEEP COMFORTABLE FOR BREATHING. CALL A POISON
CENTER/DOCTOR IF YOU FEEL UNWELL.
IN CASE OF FIRE:
DO NOT USE WATER JET AS AN EXTINGUISHER, AS THIS WILL SPREAD THE FIRE.
STORAGE:
STORE IN A WELL-VENTILATED PLACE. KEEP CONTAINER TIGHTLY CLOSED. KEEP COOL.
STORE LOCKED UP.
DISPOSAL:
DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH LOCAL/REGIONAL/NATIONAL
REGULATIONS.
HAZARD(S) NOT OTHERWISE CLASSIFIED (HNOC): NONE KNOWN.
SUPPLEMENTAL INFORMATION:
33.67% OF THE MIXTURE CONSISTS OF COMPONENT(S) OF UNKNOWN ACUTE HAZARDS TO
THE AQUATIC ENVIRONMENT.
| 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
MIXTURES:
CHEMICAL NAME COMMON NAME AND SYNONYMS CAS NUMBER %
DISTILLATES (PETROLEUM), 64742-47-8 60 - 70
HYDROTREATED LIGHT
DISTILLATES (PETROLEUM), 64741-88-4 10 - 20
SOLVENT-REFINED HEAVY
PARAFFINIC
N-BUTYL STEARATE 123-95-5 3 - 5
FATTY ACIDS, C18-UNSATD., 61788-89-4 1 - 3
DIMERS
PETROLATUM 8009-03-8 1 - 3
D-LIMONENE 5989-27-5 <0.2
SPECIFIC CHEMICAL IDENTITY AND/OR PERCENTAGE OF COMPOSITION HAS BEEN
WITHHELD AS A TRADE SECRET.
| 4. FIRST-AID MEASURES | |
INHALATION:
REMOVE VICTIM TO FRESH AIR AND KEEP AT REST IN A POSITION COMFORTABLE FOR
BREATHING. CALL A POISON CENTER OR DOCTOR/PHYSICIAN IF YOU FEEL UNWELL.
SKIN CONTACT: RINSE SKIN WITH WATER/SHOWER.
IF SKIN IRRITATION OCCURS:
GET MEDICAL ADVICE/ATTENTION. TAKE OFF CONTAMINATED CLOTHING AND WASH BEFORE
REUSE.
EYE CONTACT:
RINSE WITH WATER. GET MEDICAL ATTENTION IF IRRITATION DEVELOPS AND PERSISTS.
INGESTION:
CALL A PHYSICIAN OR POISON CONTROL CENTER IMMEDIATELY. RINSE MOUTH. DO NOT
INDUCE VOMITING. IF VOMITING OCCURS, KEEP HEAD LOW SO THAT STOMACH CONTENT
DOESN'T GET INTO THE LUNGS. ASPIRATION MAY CAUSE PULMONARY EDEMA AND
PNEUMONITIS.
MOST IMPORTANT SYMPTOMS/EFFECTS, ACUTE AND DELAYED:
DIRECT CONTACT WITH EYES MAY CAUSE TEMPORARY IRRITATION. SKIN IRRITATION.
VAPORS HAVE A NARCOTIC EFFECT AND MAY CAUSE HEADACHE, FATIGUE, DIZZINESS AND
NAUSEA. MAY CAUSE REDNESS AND PAIN.
INDICATION OF IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED:
PROVIDE GENERAL SUPPORTIVE MEASURES AND TREAT SYMPTOMATICALLY. KEEP VICTIM
UNDER OBSERVATION. SYMPTOMS MAY BE DELAYED.
GENERAL INFORMATION:
ENSURE THAT MEDICAL PERSONNEL ARE AWARE OF THE MATERIAL(S) INVOLVED, AND
TAKE PRECAUTIONS TO PROTECT THEMSELVES.
| 5. FIRE-FIGHTING MEASURES | |
SUITABLE EXTINGUISHING MEDIA:
ALCOHOL RESISTANT FOAM. WATER SPRAY. WATER FOG. DRY CHEMICAL POWDER. DRY
CHEMICALS. CARBON DIOXIDE (CO2).
UNSUITABLE EXTINGUISHING MEDIA:
WATER. DO NOT USE WATER JET AS AN EXTINGUISHER, AS THIS WILL SPREAD THE
FIRE.
SPECIFIC HAZARDS ARISING FROM THE CHEMICAL:
THE PRODUCT IS COMBUSTIBLE, AND HEATING MAY GENERATE VAPORS WHICH MAY FORM
EXPLOSIVE VAPOR/AIR MIXTURES. DURING FIRE, GASES HAZARDOUS TO HEALTH MAY BE
FORMED.
SPECIAL PROTECTIVE EQUIPMENT AND PRECAUTIONS FOR FIREFIGHTERS:
SELF-CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE CLOTHING MUST BE WORN
IN CASE OF FIRE.
FIRE-FIGHTING EQUIPMENT/INSTRUCTIONS:
IN CASE OF FIRE AND/OR EXPLOSION DO NOT BREATHE FUMES. MOVE CONTAINERS FROM
FIRE AREA IF YOU CAN DO SO WITHOUT RISK. COOL CONTAINERS EXPOSED TO HEAT
WITH WATER SPRAY AND REMOVE CONTAINER, IF NO RISK IS INVOLVED.
GENERAL FIRE HAZARDS: COMBUSTIBLE LIQUID.
| 6. ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
KEEP UNNECESSARY PERSONNEL AWAY. KEEP PEOPLE AWAY FROM AND UPWIND OF
SPILL/LEAK. KEEP OUT OF LOW AREAS. ELIMINATE ALL IGNITION SOURCES
(NO SMOKING, FLARES, SPARKS, OR FLAMES IN IMMEDIATE AREA). WEAR APPROPRIATE
PROTECTIVE EQUIPMENT AND CLOTHING DURING CLEAN-UP. DO NOT TOUCH DAMAGED
CONTAINERS OR SPILLED MATERIAL UNLESS WEARING APPROPRIATE PROTECTIVE
CLOTHING. AVOID INHALATION OF VAPORS OR MISTS. ENSURE ADEQUATE VENTILATION.
LOCAL AUTHORITIES SHOULD BE ADVISED IF SIGNIFICANT SPILLAGES CANNOT BE
CONTAINED. FOR PERSONAL PROTECTION, SEE SECTION 8 OF THE SDS.
METHODS AND MATERIALS FOR CONTAINMENT AND CLEANING UP:
ELIMINATE ALL IGNITION SOURCES (NO SMOKING, FLARES, SPARKS, OR FLAMES IN
IMMEDIATE AREA). KEEP COMBUSTIBLES (WOOD, PAPER, OIL, ETC.) AWAY FROM
SPILLED MATERIAL.
LARGE SPILLS:
STOP THE FLOW OF MATERIAL, IF THIS IS WITHOUT RISK. DIKE THE SPILLED
MATERIAL, WHERE THIS IS POSSIBLE. COVER WITH PLASTIC SHEET TO PREVENT
SPREADING. USE A NON-COMBUSTIBLE MATERIAL LIKE VERMICULITE, SAND OR EARTH TO
SOAK UP THE PRODUCT AND PLACE INTO A CONTAINER FOR LATER DISPOSAL. USE WATER
SPRAY TO REDUCE VAPORS OR DIVERT VAPOR CLOUD DRIFT. PREVENT ENTRY INTO
WATERWAYS, SEWER, BASEMENTS OR CONFINED AREAS. FOLLOWING PRODUCT RECOVERY,
FLUSH AREA WITH WATER.
SMALL SPILLS:
WIPE UP WITH ABSORBENT MATERIAL (E.G. CLOTH, FLEECE). CLEAN SURFACE
THOROUGHLY TO REMOVE RESIDUAL CONTAMINATION.
NEVER RETURN SPILLS TO ORIGINAL CONTAINERS FOR RE-USE. FOR WASTE DISPOSAL,
SEE SECTION 13 OF THE SDS.
ENVIRONMENTAL PRECAUTIONS:
AVOID RELEASE TO THE ENVIRONMENT. CONTACT LOCAL AUTHORITIES IN CASE OF
SPILLAGE TO DRAIN/AQUATIC ENVIRONMENT. PREVENT FURTHER LEAKAGE OR SPILLAGE
IF SAFE TO DO SO. DO NOT CONTAMINATE WATER. AVOID DISCHARGE INTO DRAINS,
WATER COURSES OR ONTO THE GROUND.
| 7. HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING:
KEEP AWAY FROM OPEN FLAMES, HOT SURFACES AND SOURCES OF IGNITION. WHEN USING
DO NOT SMOKE. AVOID BREATHING MIST OR VAPOR. AVOID CONTACT WITH SKIN. AVOID
CONTACT WITH EYES. AVOID PROLONGED OR REPEATED CONTACT WITH SKIN. AVOID
PROLONGED EXPOSURE. AVOID CONTACT WITH CLOTHING. USE ONLY IN WELL-VENTILATED
AREAS. WEAR APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT. WASH HANDS THOROUGHLY
AFTER HANDLING. OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES. AVOID RELEASE TO
THE ENVIRONMENT. DO NOT EMPTY INTO DRAINS. FOR PRODUCT USAGE INSTRUCTIONS,
PLEASE SEE THE PRODUCT LABEL.
CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES:
KEEP AWAY FROM HEAT AND SOURCES OF IGNITION. STORE IN ORIGINAL TIGHTLY
CLOSED CONTAINER. STORE IN A COOL, DRY PLACE OUT OF DIRECT SUNLIGHT. STORE
IN A WELL-VENTILATED PLACE. STORE AWAY FROM INCOMPATIBLE MATERIALS (SEE
SECTION 10 OF THE SDS). KEEP IN AN AREA EQUIPPED WITH SPRINKLERS.
| 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
OCCUPATIONAL EXPOSURE LIMITS:
U.S. - OSHA:
COMPONENTS TYPE VALUE FORM
FATTY ACIDS, C18-UNSATD., DIMERS TWA 5 MG/M3 RESPIRABLE
(CAS 61788-89-4)
US. OSHA TABLE Z-1 LIMITS FOR AIR CONTAMINANTS (29 CFR 1910.1000):
COMPONENTS TYPE VALUE FORM
DISTILLATES (PETROLEUM), PEL 5 MG/M3 MIST.
SOLVENT-REFINED HEAVY PARAFFINIC 2000 MG/M3
(CAS 64741-88-4) 500 PPM
PETROLATUM PEL 5 MG/M3 MIST.
(CAS 8009-03-8)
ACGIH:
COMPONENTS TYPE VALUE FORM
FATTY ACIDS, C18-UNSATD., DIMERS STEL 10 MG/M3 RESPIRABLE
(CAS 61788-89-4) TWA 5 MG/M3 RESPIRABLE
US. ACGIH THRESHOLD LIMIT VALUES:
COMPONENTS TYPE VALUE FORM
DISTILLATES (PETROLEUM), TWA 5 MG/M3 INHALABLE FRACTION.
SOLVENT-REFINED HEAVY PARAFFINIC
(CAS 64741-88-4)
N-BUTYL STEARATE TWA 10 MG/M3
(CAS 123-95-5)
PETROLATUM TWA 5 MG/M3 INHALABLE FRACTION.
(CAS 8009-03-8)
US. NIOSH: POCKET GUIDE TO CHEMICAL HAZARDS
COMPONENTS TYPE VALUE FORM
DISTILLATES (PETROLEUM), TWA 100 MG/M3
HYDROTREATED LIGHT
(CAS 64742-47-8)
DISTILLATES (PETROLEUM), STEL 10 MG/M3 MIST.
SOLVENT-REFINED HEAVY PARAFFINIC TWA 5 MG/M3 MIST.
(CAS 64741-88-4)
PETROLATUM STEL 10 MG/M3 MIST.
(CAS 8009-03-8) TWA 5 MG/M3 MIST.
US. AIHA WORKPLACE ENVIRONMENTAL EXPOSURE LEVEL (WEEL) GUIDES:
COMPONENTS TYPE VALUE
D-LIMONENE TWA 165.5 MG/M3
(CAS 5989-27-5) 30 PPM
BIOLOGICAL LIMIT VALUES:
NO BIOLOGICAL EXPOSURE LIMITS NOTED FOR THE INGREDIENT(S).
APPROPRIATE ENGINEERING CONTROLS:
GOOD GENERAL VENTILATION (TYPICALLY 10 AIR CHANGES PER HOUR) SHOULD BE USED.
VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS. IF APPLICABLE, USE
PROCESS ENCLOSURES, LOCAL EXHAUST VENTILATION, OR OTHER ENGINEERING CONTROLS
TO MAINTAIN AIRBORNE LEVELS BELOW RECOMMENDED EXPOSURE LIMITS. IF EXPOSURE
LIMITS HAVE NOT BEEN ESTABLISHED, MAINTAIN AIRBORNE LEVELS TO AN ACCEPTABLE
LEVEL. EYE WASH FACILITIES AND EMERGENCY SHOWER MUST BE AVAILABLE WHEN
HANDLING THIS PRODUCT.
INDIVIDUAL PROTECTION MEASURES, SUCH AS PERSONAL PROTECTIVE EQUIPMENT:
EYE/FACE PROTECTION: WEAR SAFETY GLASSES WITH SIDE SHIELDS (OR GOGGLES).
SKIN PROTECTION:
HAND PROTECTION: WEAR PROTECTIVE GLOVES SUCH AS NEOPRENE OR NITRILE.
OTHER: WEAR APPROPRIATE CHEMICAL RESISTANT CLOTHING.
RESPIRATORY PROTECTION:
IF ENGINEERING CONTROLS DO NOT MAINTAIN AIRBORNE CONCENTRATIONS BELOW
RECOMMENDED EXPOSURE LIMITS (WHERE APPLICABLE) OR TO AN ACCEPTABLE LEVEL
(IN COUNTRIES WHERE EXPOSURE LIMITS HAVE NOT BEEN ESTABLISHED), AN APPROVED
RESPIRATOR MUST BE WORN. WEAR POSITIVE PRESSURE SELF-CONTAINED BREATHING
APPARATUS (SCBA). AIR MONITORING IS NEEDED TO DETERMINE ACTUAL EMPLOYEE
EXPOSURE LEVELS.
THERMAL HAZARDS:
WEAR APPROPRIATE THERMAL PROTECTIVE CLOTHING, WHEN NECESSARY.
GENERAL HYGIENE CONSIDERATIONS:
WHEN USING, DO NOT EAT, DRINK OR SMOKE. ALWAYS OBSERVE GOOD PERSONAL HYGIENE
MEASURES, SUCH AS WASHING AFTER HANDLING THE MATERIAL AND BEFORE EATING,
DRINKING, AND/OR SMOKING. ROUTINELY WASH WORK CLOTHING AND PROTECTIVE
EQUIPMENT TO REMOVE CONTAMINANTS.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE:
PHYSICAL STATE: LIQUID.
FORM: LIQUID.
COLOR: BLUE GREEN.
ODOR: PLEASANT.
ODOR THRESHOLD: NOT AVAILABLE.
PH: NOT AVAILABLE.
MELTING POINT/FREEZING POINT: -72.4 DEG. F (-58 DEG. C) ESTIMATED
INITIAL BOILING POINT AND BOILING RANGE: 380 DEG. F (193.3 DEG. C) ESTIMATED
FLASH POINT: 192 DEG. F (88.9 DEG. C) TAG CLOSED CUP
EVAPORATION RATE: SLOW
FLAMMABILITY (SOLID, GAS): NOT AVAILABLE.
UPPER/LOWER FLAMMABILITY OR EXPLOSIVE LIMITS:
FLAMMABILITY LIMIT - LOWER (%): 0.6% ESTIMATED
FLAMMABILITY LIMIT - UPPER (%): 5.5% ESTIMATED
VAPOR PRESSURE: 0.2 HPA ESTIMATED
VAPOR DENSITY: >1 (AIR = 1)
RELATIVE DENSITY: 0.83
SOLUBILITY (WATER): NOT AVAILABLE.
PARTITION COEFFICIENT (N-OCTANOL/WATER): NOT AVAILABLE.
AUTO-IGNITION TEMPERATURE: 456.8 DEG. F (236 DEG. C) ESTIMATED
DECOMPOSITION TEMPERATURE: NOT AVAILABLE.
VISCOSITY (KINEMATIC): NOT AVAILABLE.
PERCENT VOLATILE: 90.8% ESTIMATED
| 10. STABILITY AND REACTIVITY | |
REACTIVITY:
THE PRODUCT IS STABLE AND NON-REACTIVE UNDER NORMAL CONDITIONS OF USE,
STORAGE AND TRANSPORT.
CHEMICAL STABILITY: MATERIAL IS STABLE UNDER NORMAL CONDITIONS.
POSSIBILITY OF HAZARDOUS REACTIONS:
NO DANGEROUS REACTION KNOWN UNDER CONDITIONS OF NORMAL USE.
CONDITIONS TO AVOID:
AVOID HEAT, SPARKS, OPEN FLAMES AND OTHER IGNITION SOURCES. AVOID
TEMPERATURES EXCEEDING THE FLASH POINT. CONTACT WITH INCOMPATIBLE MATERIALS.
INCOMPATIBLE MATERIALS: STRONG OXIDIZING AGENTS.
HAZARDOUS DECOMPOSITION PRODUCTS: CARBON OXIDES. SULFUR OXIDES.
| 11. TOXICOLOGICAL INFORMATION | |
INFORMATION ON LIKELY ROUTES OF EXPOSURE:
INGESTION: MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS.
INHALATION:
VAPORS HAVE A NARCOTIC EFFECT AND MAY CAUSE HEADACHE, FATIGUE, DIZZINESS AND
NAUSEA. PROLONGED INHALATION MAY BE HARMFUL.
SKIN CONTACT: CAUSES SKIN IRRITATION.
EYE CONTACT: DIRECT CONTACT WITH EYES MAY CAUSE TEMPORARY IRRITATION.
SYMPTOMS RELATED TO THE PHYSICAL, CHEMICAL AND TOXICOLOGICAL
CHARACTERISTICS: SKIN IRRITATION. MAY CAUSE REDNESS AND PAIN. SYMPTOMS OF
OVEREXPOSURE MAY BE HEADACHE, DIZZINESS, TIREDNESS, NAUSEA AND VOMITING.
INFORMATION ON TOXICOLOGICAL EFFECTS:
ACUTE TOXICITY:
MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS. NARCOTIC EFFECTS. EXPECTED TO
BE A LOW HAZARD FOR USUAL INDUSTRIAL OR COMMERCIAL HANDLING BY TRAINED
PERSONNEL.
PRODUCT SPECIES TEST RESULTS
3-36(R*) MULTI-PURPOSE LUBRICANT & CORROSION INHIBITOR:
ACUTE:
DERMAL:
LD50 RABBIT 2730.2576 MG/KG ESTIMATED
INHALATION:
LC50 RAT 113.9506 MG/L ESTIMATED
ORAL:
LD50 RAT 6571.6235 MG/KG ESTIMATED
SUBCHRONIC:
ORAL:
LD50 RAT 757.9653 G/KG, 14 DAYS ESTIMATED
* ESTIMATES FOR PRODUCT MAY BE BASED ON ADDITIONAL COMPONENT DATA NOT SHOWN.
SKIN CORROSION/IRRITATION: CAUSES SKIN IRRITATION.
SERIOUS EYE DAMAGE/EYE IRRITATION:
DIRECT CONTACT WITH EYES MAY CAUSE TEMPORARY IRRITATION.
RESPIRATORY SENSITIZATION: NOT AVAILABLE.
SKIN SENSITIZATION:
THIS PRODUCT IS NOT EXPECTED TO CAUSE SKIN SENSITIZATION.
GERM CELL MUTAGENICITY:
NO DATA AVAILABLE TO INDICATE PRODUCT OR ANY COMPONENTS PRESENT AT GREATER
THAN 0.1% ARE MUTAGENIC OR GENOTOXIC.
CARCINOGENICITY:
THIS PRODUCT IS NOT CONSIDERED TO BE A CARCINOGEN BY IARC, ACGIH, NTP, OR
OSHA.
IARC MONOGRAPHS. OVERALL EVALUATION OF CARCINOGENICITY:
D-LIMONENE (CAS 5989-27-5):
3 NOT CLASSIFIABLE AS TO CARCINOGENICITY TO HUMANS.
REPRODUCTIVE TOXICITY:
THIS PRODUCT IS NOT EXPECTED TO CAUSE REPRODUCTIVE OR DEVELOPMENTAL EFFECTS.
SPECIFIC TARGET ORGAN TOXICITY - SINGLE EXPOSURE: NARCOTIC EFFECTS.
SPECIFIC TARGET ORGAN TOXICITY - REPEATED EXPOSURE: NOT CLASSIFIED.
ASPIRATION HAZARD: MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS.
CHRONIC EFFECTS: PROLONGED INHALATION MAY BE HARMFUL.
| 12. ECOLOGICAL INFORMATION | |
ECOTOXICITY: TOXIC TO AQUATIC LIFE.
PRODUCT SPECIES TEST RESULTS
3-36(R8) MULTI-PURPOSE LUBRICANT & CORROSION INHIBITOR:
ACUTE:
FISH LC50 FISH 4797.0479 PPM, 96 HOURS ESTIMATED
COMPONENTS SPECIES TEST RESULTS
DISTILLATES (PETROLEUM), HYDROTREATED LIGHT (CAS 64742-47-8):
AQUATIC:
ACUTE:
FISH LC50 BLUEGILL 2.2 MG/L, 96 HOURS
(LEPOMIS MACROCHIRUS)
D-LIMONENE (CAS 5989-27-5):
AQUATIC:
CRUSTACEA EC50 WATER FLEA 69.6 MG/L, 48 HOURS
(DAPHNIA PULEX)
FISH LC50 FATHEAD MINNOW 0.619 - 0.796 MG/L, 96 HOURS
(PIMEPHALES PROMELAS)
FATTY ACIDS, C18-UNSATD., DIMERS (CAS 61788-89-4):
ACUTE:
CRUSTACEA NOEL DAPHNIA 1000 MG/L, 48 HOURS LOADING RATE
WAF
FISH NOEL FISH 1000 MG/L, 96 HOURS LOADING RATE
WAF
* ESTIMATES FOR PRODUCT MAY BE BASED ON ADDITIONAL COMPONENT DATA NOT SHOWN.
PERSISTENCE AND DEGRADABILITY:
NO DATA IS AVAILABLE ON THE DEGRADABILITY OF THIS PRODUCT.
BIOACCUMULATIVE POTENTIAL: NO DATA AVAILABLE.
PARTITION COEFFICIENT N-OCTANOL / WATER (LOG KOW):
D-LIMONENE: 4.232
FATTY ACIDS, C18-UNSATD., DIMERS: 1 - 2.5, LOGKOW
MOBILITY IN SOIL: NO DATA AVAILABLE.
OTHER ADVERSE EFFECTS:
NO OTHER ADVERSE ENVIRONMENTAL EFFECTS (E.G. OZONE DEPLETION, PHOTOCHEMICAL
OZONE CREATION POTENTIAL, ENDOCRINE DISRUPTION, GLOBAL WARMING POTENTIAL)
ARE EXPECTED FROM THIS COMPONENT.
| 13. DISPOSAL CONSIDERATIONS | |
DISPOSAL OF WASTE FROM RESIDUES / UNUSED PRODUCTS:
THIS PRODUCT IS NOT A RCRA HAZARDOUS WASTE (SEE 40 CFR PART
261.20 - 261.33). EMPTY CONTAINERS MAY BE RECYCLED. COLLECT AND RECLAIM OR
DISPOSE IN SEALED CONTAINERS AT LICENSED WASTE DISPOSAL SITE. DO NOT ALLOW
THIS MATERIAL TO DRAIN INTO SEWERS/WATER SUPPLIES. DO NOT CONTAMINATE PONDS,
WATERWAYS OR DITCHES WITH CHEMICAL OR USED CONTAINER.
HAZARDOUS WASTE CODE: NOT REGULATED.
CONTAMINATED PACKAGING:
EMPTY CONTAINERS SHOULD BE TAKEN TO AN APPROVED WASTE HANDLING SITE FOR
RECYCLING OR DISPOSAL. SINCE EMPTIED CONTAINERS MAY RETAIN PRODUCT RESIDUE,
FOLLOW LABEL WARNINGS EVEN AFTER CONTAINER IS EMPTIED.
| 14. TRANSPORT INFORMATION | |
DOT: NOT REGULATED AS DANGEROUS GOODS.
IATA: NOT REGULATED AS DANGEROUS GOODS.
IMDG: NOT REGULATED AS DANGEROUS GOODS.
| 15. REGULATORY INFORMATION | |
US FEDERAL REGULATIONS:
THIS PRODUCT IS A "HAZARDOUS CHEMICAL" AS DEFINED BY THE OSHA HAZARD
COMMUNICATION STANDARD, 29 CFR 1910.1200.
TSCA SECTION 12(B) EXPORT NOTIFICATION (40 CFR 707, SUBPT. D):
NOT REGULATED.
SARA 304 EMERGENCY RELEASE NOTIFICATION:
NOT REGULATED.
US. OSHA SPECIFICALLY REGULATED SUBSTANCES (29 CFR 1910.1001-1050):
NOT LISTED.
US EPCRA (SARA TITLE III) SECTION 313 - TOXIC CHEMICAL LISTED SUBSTANCE
NOT LISTED.
CERCLA HAZARDOUS SUBSTANCE LIST (40 CFR 302.4): NOT LISTED.
CERCLA HAZARDOUS SUBSTANCES REPORTABLE QUANTITY
NOT LISTED.
SPILLS OR RELEASES RESULTING IN THE LOSS OF ANY INGREDIENT AT OR ABOVE ITS
RQ REQUIRE IMMEDIATE NOTIFICATION TO THE NATIONAL RESPONSE CENTER
(800-424-8802) AND TO YOUR LOCAL EMERGENCY PLANNING COMMITTEE.
CLEAN AIR ACT (CAA) SECTION 112 HAZARDOUS AIR POLLUTANTS (HAPS) LIST:
NOT REGULATED.
CLEAN AIR ACT (CAA) SECTION 112(R) ACCIDENTAL RELEASE PREVENTION
(40 CFR 68.130): NOT REGULATED.
SAFE DRINKING WATER ACT (SDWA): NOT REGULATED.
FOOD AND DRUG ADMINISTRATION (FDA): NOT REGULATED.
SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 (SARA):
SECTION 311/312 HAZARD CATEGORIES:
IMMEDIATE HAZARD: YES
DELAYED HAZARD: NO
FIRE HAZARD: YES
PRESSURE HAZARD: NO
REACTIVITY HAZARD: NO
SARA 302 EXTREMELY HAZARDOUS SUBSTANCE: NO
US STATE REGULATIONS:
US. NEW JERSEY RTK - SUBSTANCES LISTED SUBSTANCE
NONE.
US. MASSACHUSETTS RTK - SUBSTANCE LIST: NONE.
US. PENNSYLVANIA RTK - HAZARDOUS SUBSTANCES:
DISTILLATES (PETROLEUM), HYDROTREATED LIGHT (CAS 64742-47-8)
US. RHODE ISLAND RTK: NONE.
US. CALIFORNIA PROPOSITION 65:
CALIFORNIA SAFE DRINKING WATER AND TOXIC ENFORCEMENT ACT OF 1986
(PROPOSITION 65):
THIS MATERIAL IS NOT KNOWN TO CONTAIN ANY CHEMICALS CURRENTLY LISTED AS
CARCINOGENS OR REPRODUCTIVE TOXINS.
VOLATILE ORGANIC COMPOUNDS (VOC) REGULATIONS:
EPA:
VOC CONTENT (40 CFR 51.100(S)): 100%
CONSUMER PRODUCTS (40 CFR 59, SUBPT. C): NOT REGULATED
STATE:
CONSUMER PRODUCTS:
THIS PRODUCT IS REGULATED AS A MULTI-PURPOSE LUBRICANT. THIS PRODUCT IS
COMPLIANT FOR USE IN ALL 50 STATES.
VOC CONTENT (CA): 0%
VOC CONTENT (OTC): 0%
INTERNATIONAL INVENTORIES:
COUNTRY(S) INVENTORY NAME ON INVENTORY
OR REGION (YES/NO)*
AUSTRALIA AUSTRALIAN INVENTORY OF CHEMICAL SUBSTANCES NO
(AICS)
CANADA DOMESTIC SUBSTANCES LIST (DSL) NO
CANADA NON-DOMESTIC SUBSTANCES LIST (NDSL) NO
CHINA INVENTORY OF EXISTING CHEMICAL SUBSTANCES IN NO
CHINA (IECSC)
EUROPE EUROPEAN INVENTORY OF EXISTING COMMERCIAL NO
CHEMICAL SUBSTANCES (EINECS)
EUROPE EUROPEAN LIST OF NOTIFIED CHEMICAL SUBSTANCES NO
(ELINCS)
JAPAN INVENTORY OF EXISTING AND NEW CHEMICAL NO
SUBSTANCES (ENCS)
KOREA EXISTING CHEMICALS LIST (ECL) NO
NEW ZEALAND NEW ZEALAND INVENTORY NO
PHILIPPINES PHILIPPINE INVENTORY OF CHEMICALS AND CHEMICAL NO
SUBSTANCES (PICCS)
UNITED STATES & TOXIC SUBSTANCES CONTROL ACT (TSCA) INVENTORY YES
PUERTO RICO
*A "YES" INDICATES THAT ALL COMPONENTS OF THIS PRODUCT COMPLY WITH THE
INVENTORY REQUIREMENTS ADMINISTERED BY THE GOVERNING COUNTRY(S)
A "NO" INDICATES THAT ONE OR MORE COMPONENTS OF THE PRODUCT ARE NOT LISTED
OR EXEMPT FROM LISTING ON THE INVENTORY ADMINISTERED BY THE GOVERNING
COUNTRY(S).
| 16. OTHER INFORMATION, INCLUDING DATE OF | |
PREPARATION OR LAST REVISION
ISSUE DATE: 10-31-2013
PREPARED BY: ALLISON CHO
VERSION #: 01
FURTHER INFORMATION: CRC # 510F
HMIS(R*) RATINGS:
HEALTH 1
FLAMMABILITY 2
PHYSICAL HAZARD 0
PERSONAL PROTECTION B
NFPA RATINGS:
HEALTH 1
FLAMMABILITY 2
INSTABILITY 0
DISCLAIMER:
THE INFORMATION CONTAINED IN THIS DOCUMENT APPLIES TO THIS SPECIFIC MATERIAL
AS SUPPLIED. IT MAY NOT BE VALID FOR THIS MATERIAL IF IT IS USED IN
COMBINATION WITH ANY OTHER MATERIALS. THIS INFORMATION IS ACCURATE TO THE
BEST OF CRC INDUSTRIES' KNOWLEDGE OR OBTAINED FROM SOURCES BELIEVED BY CRC
TO BE ACCURATE. BEFORE USING ANY PRODUCT, READ ALL WARNINGS AND DIRECTIONS
ON THE LABEL. FOR FURTHER CLARIFICATION OF ANY INFORMATION CONTAINED ON THIS
(M)SDS CONSULT YOUR SUPERVISOR, A HEALTH & SAFETY PROFESSIONAL, OR CRC
INDUSTRIES.
MATERIAL NAME: 3-36(R*) MULTI-PURPOSE LUBRICANT & CORROSION INHIBITOR
1310
SDS: US