| Common Name: | POWER LUBE HIGH PERFORMANCE LUBRICANT W/PTFE 03045 |
| Manufacturer: | CRC |
| SDS Revision Date: | 11/18/2013 |
| SDS Format: | GHS-US |
| Item Number(s): | 3EEE3 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
CRC(R*)
SAFETY DATA SHEET
| 1. IDENTIFICATION |  |
PRODUCT IDENTIFIER: POWER LUBE(R*) HIGH PERFORMANCE LUBRICANT W/PTFE
OTHER MEANS OF IDENTIFICATION:
PRODUCT CODE: 03045
RECOMMENDED USE: MULTI-PURPOSE LUBRICANT
RECOMMENDED RESTRICTIONS: NONE KNOWN.
MANUFACTURER/IMPORTER/SUPPLIER/DISTRIBUTOR INFORMATION:
MANUFACTURED OR SOLD BY:
COMPANY NAME: CRC INDUSTRIES, INC.
ADDRESS:
885 LOUIS DR.
WARMINSTER, PA 18974
US
TELEPHONE:
GENERAL INFORMATION: 215-674-4300
TECHNICAL ASSISTANCE: 800-521-3168
CUSTOMER SERVICE: 800-272-4620
24-HOUR EMERGENCY (CHEMTREC):
800-424-9300 (US)
703-527-3887 (INTERNATIONAL)
WEBSITE: WWW.CRCINDUSTRIES.COM
| 2. HAZARD(S) IDENTIFICATION | |
PHYSICAL HAZARDS:
FLAMMABLE AEROSOLS: CATEGORY 1
GASES UNDER PRESSURE: LIQUEFIED GAS
HEALTH HAZARDS:
SKIN CORROSION/IRRITATION: CATEGORY 2
SERIOUS EYE DAMAGE/EYE IRRITATION: CATEGORY 2A
REPRODUCTIVE TOXICITY (FERTILITY): CATEGORY 2
SPECIFIC TARGET ORGAN TOXICITY, SINGLE EXPOSURE: CATEGORY 3 NARCOTIC EFFECTS
SPECIFIC TARGET ORGAN TOXICITY, REPEATED EXPOSURE: CATEGORY 2
ASPIRATION HAZARD: CATEGORY 1
ENVIRONMENTAL HAZARDS:
HAZARDOUS TO THE AQUATIC ENVIRONMENT, ACUTE HAZARD: CATEGORY 2
OSHA DEFINED HAZARDS: NOT CLASSIFIED.
LABEL ELEMENTS:
FLAME
GAS CYLINDER
HEALTH HAZARD
EXCLAMATION MARK
SIGNAL WORD: DANGER
HAZARD STATEMENT:
EXTREMELY FLAMMABLE AEROSOL. CONTAINS GAS UNDER PRESSURE; MAY EXPLODE IF
HEATED. MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS. CAUSES SKIN
IRRITATION. CAUSES SERIOUS EYE IRRITATION. MAY CAUSE DROWSINESS OR
DIZZINESS. SUSPECTED OF DAMAGING FERTILITY. MAY CAUSE DAMAGE TO ORGANS
THROUGH PROLONGED OR REPEATED EXPOSURE. TOXIC TO AQUATIC LIFE.
PRECAUTIONARY STATEMENT:
PREVENTION:
OBTAIN SPECIAL INSTRUCTIONS BEFORE USE. DO NOT HANDLE UNTIL ALL SAFETY
PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD. KEEP AWAY FROM HEAT/SPARKS/OPEN
FLAMES/HOT SURFACES. - NO SMOKING. DO NOT SPRAY ON AN OPEN FLAME OR OTHER
IGNITION SOURCE. DO NOT APPLY WHILE EQUIPMENT IS ENERGIZED.
PRESSURIZED CONTAINER:
DO NOT PIERCE OR BURN, EVEN AFTER USE. USE ONLY WITH ADEQUATE VENTILATION;
MAINTAIN VENTILATION DURING USE AND UNTIL ALL VAPORS ARE GONE. OPEN DOORS
AND WINDOWS OR USE OTHER MEANS TO ENSURE A FRESH AIR SUPPLY DURING USE AND
WHILE PRODUCT IS DRYING. IF YOU EXPERIENCE ANY SYMPTOMS LISTED ON THIS
LABEL, INCREASE VENTILATION OR LEAVE THE AREA. EXTINGUISH ALL FLAMES, PILOT
LIGHTS AND HEATERS. VAPORS WILL ACCUMULATE READILY AND MAY IGNITE. DO NOT
BREATHE GAS, MIST OR VAPOR. WASH HANDS THOROUGHLY AFTER HANDLING. WEAR
PROTECTIVE GLOVES/PROTECTIVE CLOTHING/EYE PROTECTION/FACE PROTECTION. AVOID
RELEASE TO THE ENVIRONMENT.
RESPONSE:
IF SWALLOWED:
IMMEDIATELY CALL A POISON CENTER/DOCTOR. DO NOT INDUCE VOMITING.
IF ON SKIN: WASH WITH PLENTY OF WATER.
IF SKIN IRRITATION OCCURS:
GET MEDICAL ATTENTION. TAKE OFF CONTAMINATED CLOTHING AND WASH BEFORE REUSE.
IF INHALED:
REMOVE PERSON TO FRESH AIR AND KEEP COMFORTABLE FOR BREATHING. CALL A POISON
CENTER/DOCTOR IF YOU FEEL UNWELL.
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES, IF
PRESENT AND EASY TO DO. CONTINUE RINSING.
IF EYE IRRITATION PERSISTS: GET MEDICAL ATTENTION.
IF EXPOSED OR CONCERNED: GET MEDICAL ATTENTION.
STORAGE:
STORE IN A WELL-VENTILATED PLACE. STORE LOCKED UP. PROTECT FROM SUNLIGHT. DO
NOT EXPOSE TO TEMPERATURES EXCEEDING 50 DEG. C/122 DEG. F. EXPOSURE TO HIGH
TEMPERATURE MAY CAUSE CAN TO BURST.
DISPOSAL:
DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH LOCAL/REGIONAL/NATIONAL
REGULATIONS.
HAZARD(S) NOT OTHERWISE CLASSIFIED (HNOC):
STATIC ACCUMULATING FLAMMABLE LIQUID CAN BECOME ELECTROSTATICALLY CHARGED
EVEN IN BONDED AND GROUNDED EQUIPMENT. SPARKS MAY IGNITE LIQUID AND VAPOR.
MAY CAUSE FLASH FIRE OR EXPLOSION.
SUPPLEMENTAL INFORMATION:
55.65% OF THE MIXTURE CONSISTS OF COMPONENT(S) OF UNKNOWN ACUTE HAZARDS TO
THE AQUATIC ENVIRONMENT.
| 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
MIXTURES:
CHEMICAL NAME COMMON NAME AND SYNONYMS CAS NUMBER %
DISTILLATES (PETROLEUM), 64742-47-8 30 - 40
HYDROTREATED LIGHT
DISTILLATES (PETROLEUM), 64741-88-4 10 - 20
SOLVENT-REFINED HEAVY
PARAFFINIC
LIQUEFIED PETROLEUM GAS 68476-86-8 10 - 20
METHYL SALICYLATE 119-36-8 3 - 5
NAPHTHA (PETROLEUM), 64742-49-0 3 - 5
HYDROTREATED LIGHT
DIPROPYLENE GLYCOL 34590-94-8 1 - 3
MONOMETHYL ETHER
FATTY ACIDS, C18- 61788-89-4 1 - 3
UNSATD., DIMERS
PETROLATUM 8009-03-8 1 - 3
SODIUM PETROLEUM 68608-26-4 1 - 3
SULFONATE
N-HEXANE 110-54-3 <0.2
SPECIFIC CHEMICAL IDENTITY AND/OR PERCENTAGE OF COMPOSITION HAS BEEN
WITHHELD AS A TRADE SECRET.
| 4. FIRST-AID MEASURES | |
INHALATION:
REMOVE VICTIM TO FRESH AIR AND KEEP AT REST IN A POSITION COMFORTABLE FOR
BREATHING. CALL A POISON CENTER OR DOCTOR/PHYSICIAN IF YOU FEEL UNWELL.
SKIN CONTACT:
RINSE SKIN WITH WATER/SHOWER. IF SKIN IRRITATION OCCURS:
GET MEDICAL ADVICE/ATTENTION. TAKE OFF CONTAMINATED CLOTHING AND WASH BEFORE
REUSE.
EYE CONTACT:
IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES. REMOVE
CONTACT LENSES, IF PRESENT AND EASY TO DO. CONTINUE RINSING. GET MEDICAL
ATTENTION IF IRRITATION DEVELOPS AND PERSISTS.
INGESTION:
CALL A PHYSICIAN OR POISON CONTROL CENTER IMMEDIATELY. RINSE MOUTH. DO NOT
INDUCE VOMITING. IF VOMITING OCCURS, KEEP HEAD LOW SO THAT STOMACH CONTENT
DOESN'T GET INTO THE LUNGS. ASPIRATION MAY CAUSE PULMONARY EDEMA AND
PNEUMONITIS.
MOST IMPORTANT SYMPTOMS/EFFECTS, ACUTE AND DELAYED:
SYMPTOMS MAY INCLUDE STINGING, TEARING, REDNESS, SWELLING, AND BLURRED
VISION. SKIN IRRITATION. VAPORS HAVE A NARCOTIC EFFECT AND MAY CAUSE
HEADACHE, FATIGUE, DIZZINESS AND NAUSEA. MAY CAUSE DROWSINESS OR DIZZINESS.
MAY CAUSE REDNESS AND PAIN. PROLONGED EXPOSURE MAY CAUSE CHRONIC EFFECTS.
INDICATION OF IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED:
PROVIDE GENERAL SUPPORTIVE MEASURES AND TREAT SYMPTOMATICALLY. KEEP VICTIM
UNDER OBSERVATION. SYMPTOMS MAY BE DELAYED.
GENERAL INFORMATION:
IF EXPOSED OR CONCERNED:
GET MEDICAL ADVICE/ATTENTION. ENSURE THAT MEDICAL PERSONNEL ARE AWARE OF THE
MATERIAL(S) INVOLVED, AND TAKE PRECAUTIONS TO PROTECT THEMSELVES.
| 5. FIRE-FIGHTING MEASURES | |
SUITABLE EXTINGUISHING MEDIA:
ALCOHOL RESISTANT FOAM. WATER SPRAY. WATER FOG. DRY CHEMICALS. CARBON
DIOXIDE (CO2). DRY CHEMICAL POWDER, CARBON DIOXIDE, SAND OR EARTH MAY BE
USED FOR SMALL FIRES ONLY.
UNSUITABLE EXTINGUISHING MEDIA:
DO NOT USE WATER JET AS AN EXTINGUISHER, AS THIS WILL SPREAD THE FIRE.
SPECIFIC HAZARDS ARISING FROM THE CHEMICAL:
CONTENTS UNDER PRESSURE. PRESSURIZED CONTAINER MAY EXPLODE WHEN EXPOSED TO
HEAT OR FLAME. THIS PRODUCT IS A POOR CONDUCTOR OF ELECTRICITY AND CAN
BECOME ELECTROSTATICALLY CHARGED. IF SUFFICIENT CHARGE IS ACCUMULATED,
IGNITION OF FLAMMABLE MIXTURES CAN OCCUR. STATIC ELECTRICITY ACCUMULATION
MAY BE SIGNIFICANTLY INCREASED BY THE PRESENCE OF SMALL QUANTITIES OF WATER
OR OTHER CONTAMINANTS. MATERIAL WILL FLOAT AND MAY IGNITE ON SURFACE OF
WATER.
SPECIAL PROTECTIVE EQUIPMENT AND PRECAUTIONS FOR FIREFIGHTERS:
FIREFIGHTERS MUST USE STANDARD PROTECTIVE EQUIPMENT INCLUDING FLAME
RETARDANT COAT, HELMET WITH FACE SHIELD, GLOVES, RUBBER BOOTS, AND IN
ENCLOSED SPACES, SCBA.
FIRE-FIGHTING EQUIPMENT/INSTRUCTIONS:
IN CASE OF FIRE:
STOP LEAK IF SAFE TO DO SO. DO NOT MOVE CARGO OR VEHICLE IF CARGO HAS BEEN
EXPOSED TO HEAT. IF TANK, RAIL CAR OR TANK TRUCK IS INVOLVED IN A FIRE,
ISOLATE FOR 800 METERS (1/2 MILE) IN ALL DIRECTIONS; ALSO CONSIDER INITIAL
EVACUATION FOR 800 METERS (1/2 MILE) IN ALL DIRECTIONS. ALWAYS STAY AWAY
FROM TANKS ENGULFED IN FLAME. MOVE CONTAINERS FROM FIRE AREA IF YOU CAN DO
SO WITHOUT RISK. COOL CONTAINERS EXPOSED TO HEAT WITH WATER SPRAY AND REMOVE
CONTAINER, IF NO RISK IS INVOLVED. CONTAINERS SHOULD BE COOLED WITH WATER TO
PREVENT VAPOR PRESSURE BUILD UP. FOR MASSIVE FIRE IN CARGO AREA, USE
UNMANNED HOSE HOLDER OR MONITOR NOZZLES, IF POSSIBLE. IF NOT, WITHDRAW AND
LET FIRE BURN OUT. IN THE EVENT OF FIRE, COOL TANKS WITH WATER SPRAY.
GENERAL FIRE HAZARDS: EXTREMELY FLAMMABLE AEROSOL.
| 6. ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
KEEP UNNECESSARY PERSONNEL AWAY. KEEP PEOPLE AWAY FROM AND UPWIND OF
SPILL/LEAK. KEEP OUT OF LOW AREAS. REMOVE ALL POSSIBLE SOURCES OF IGNITION
IN THE SURROUNDING AREA. WEAR APPROPRIATE PROTECTIVE EQUIPMENT AND CLOTHING
DURING CLEAN-UP. DO NOT TOUCH DAMAGED CONTAINERS OR SPILLED MATERIAL UNLESS
WEARING APPROPRIATE PROTECTIVE CLOTHING. DO NOT BREATHE GAS, MIST OR VAPOR.
VENTILATE CLOSED SPACES BEFORE ENTERING THEM. USE APPROPRIATE CONTAINMENT TO
AVOID ENVIRONMENTAL CONTAMINATION. FOR PERSONAL PROTECTION, SEE SECTION 8 OF
THE SDS.
METHODS AND MATERIALS FOR CONTAINMENT AND CLEANING UP:
ELIMINATE ALL IGNITION SOURCES (NO SMOKING, FLARES, SPARKS, OR FLAMES IN
IMMEDIATE AREA). KEEP COMBUSTIBLES (WOOD, PAPER, OIL, ETC.) AWAY FROM
SPILLED MATERIAL. STOP THE FLOW OF MATERIAL, IF THIS IS WITHOUT RISK.
COLLECT SPILLAGE. WIPE UP WITH ABSORBENT MATERIAL (E.G. CLOTH, FLEECE).
CLEAN SURFACE THOROUGHLY TO REMOVE RESIDUAL CONTAMINATION. PREVENT ENTRY
INTO WATERWAYS, SEWER, BASEMENTS OR CONFINED AREAS. FOR WASTE DISPOSAL, SEE
SECTION 13 OF THE SDS.
ENVIRONMENTAL PRECAUTIONS:
AVOID RELEASE TO THE ENVIRONMENT. CONTACT LOCAL AUTHORITIES IN CASE OF
SPILLAGE TO DRAIN/AQUATIC ENVIRONMENT. PREVENT FURTHER LEAKAGE OR SPILLAGE
IF SAFE TO DO SO. DO NOT CONTAMINATE WATER. AVOID DISCHARGE INTO DRAINS,
WATER COURSES OR ONTO THE GROUND. USE APPROPRIATE CONTAINMENT TO AVOID
ENVIRONMENTAL CONTAMINATION.
| 7. HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING:
OBTAIN SPECIAL INSTRUCTIONS BEFORE USE. DO NOT HANDLE UNTIL ALL SAFETY
PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD. MINIMIZE FIRE RISKS FROM
FLAMMABLE AND COMBUSTIBLE MATERIALS (INCLUDING COMBUSTIBLE DUST AND STATIC
ACCUMULATING LIQUIDS) OR DANGEROUS REACTIONS WITH INCOMPATIBLE MATERIALS.
HANDLING OPERATIONS THAT CAN PROMOTE ACCUMULATION OF STATIC CHARGES INCLUDE
BUT ARE NOT LIMITED TO:
MIXING, FILTERING, PUMPING AT HIGH FLOW RATES, SPLASH FILLING, CREATING
MISTS OR SPRAYS, TANK AND CONTAINER FILLING, TANK CLEANING, SAMPLING,
GAUGING, SWITCH LOADING, VACUUM TRUCK OPERATIONS.
PRESSURIZED CONTAINER:
DO NOT PIERCE OR BURN, EVEN AFTER USE. DO NOT USE IF SPRAY BUTTON IS MISSING
OR DEFECTIVE. DO NOT SPRAY ON A NAKED FLAME OR ANY OTHER INCANDESCENT
MATERIAL. DO NOT SMOKE WHILE USING OR UNTIL SPRAYED SURFACE IS THOROUGHLY
DRY. DO NOT CUT, WELD, SOLDER, DRILL, GRIND, OR EXPOSE CONTAINERS TO HEAT,
FLAME, SPARKS, OR OTHER SOURCES OF IGNITION. USE CAUTION AROUND ENERGIZED
EQUIPMENT. THE METAL CONTAINER WILL CONDUCT ELECTRICITY IF IT CONTACTS A
LIVE SOURCE. THIS MAY RESULT IN INJURY TO THE USER FROM ELECTRICAL SHOCK
AND/OR FLASH FIRE. DO NOT BREATHE MIST OR VAPOR. DO NOT BREATHE GAS. AVOID
CONTACT WITH SKIN. AVOID CONTACT WITH EYES. AVOID CONTACT DURING
PREGNANCY/WHILE NURSING. AVOID CONTACT WITH CLOTHING. USE ONLY IN
WELL-VENTILATED AREAS. WEAR APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT. WHEN
USING, DO NOT EAT, DRINK OR SMOKE. WASH HANDS THOROUGHLY AFTER HANDLING.
OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES. AVOID RELEASE TO THE ENVIRONMENT.
DO NOT EMPTY INTO DRAINS. FOR PRODUCT USAGE INSTRUCTIONS, PLEASE SEE THE
PRODUCT LABEL.
CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES:
LEVEL 3 AEROSOL.
PRESSURIZED CONTAINER. PROTECT FROM SUNLIGHT AND DO NOT EXPOSE TO
TEMPERATURES EXCEEDING 50 DEG. C/122 DEG. F. DO NOT PUNCTURE, INCINERATE OR
CRUSH. DO NOT HANDLE OR STORE NEAR AN OPEN FLAME, HEAT OR OTHER SOURCES OF
IGNITION. THIS MATERIAL CAN ACCUMULATE STATIC CHARGE WHICH MAY CAUSE SPARK
AND BECOME AN IGNITION SOURCE. AVOID SPARK PROMOTERS. THESE ALONE MAY BE
INSUFFICIENT TO REMOVE STATIC ELECTRICITY. STORE IN A WELL-VENTILATED PLACE.
STORE AWAY FROM INCOMPATIBLE MATERIALS (SEE SECTION 10 OF THE SDS). KEEP OUT
OF THE REACH OF CHILDREN.
| 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
OCCUPATIONAL EXPOSURE LIMITS:
U.S. - OSHA:
COMPONENTS TYPE VALUE FORM
FATTY ACIDS, C18-UNSATD., TWA 5 MG/M3 RESPIRABLE
DIMERS
(CAS 61788-89-4)
US. OSHA TABLE Z-1 LIMITS FOR AIR CONTAMINANTS (29 CFR 1910.1000):
COMPONENTS TYPE VALUE FORM
DIPROPYLENE GLYCOL PEL 600 MG/M3
MONOMETHYL ETHER 100 PPM
(CAS 34590-94-8)
DISTILLATES (PETROLEUM), PEL 5 MG/M3 MIST.
SOLVENT-REFINED HEAVY 2000 MG/M3
PARAFFINIC 500 PPM
(CAS 64741-88-4)
N-HEXANE PEL 1800 MG/M3
(CAS 110-54-3) 500 PPM
PETROLATUM PEL 5 MG/M3 MIST.
(CAS 8009-03-8)
ACGIH:
COMPONENTS TYPE VALUE FORM
FATTY ACIDS, C18-UNSATD., STEL 10 MG/M3 RESPIRABLE
DIMERS TWA 5 MG/M3 RESPIRABLE
(CAS 61788-89-4)
US. ACGIH THRESHOLD LIMIT VALUES:
COMPONENTS TYPE VALUE FORM
DIPROPYLENE GLYCOL STEL 150 PPM
MONOMETHYL ETHER TWA 100 PPM
(CAS 34590-94-8)
DISTILLATES (PETROLEUM), TWA 5 MG/M3 INHALABLE FRACTION.
SOLVENT-REFINED HEAVY
PARAFFINIC
(CAS 64741-88-4)
N-HEXANE TWA 50 PPM
(CAS 110-54-3)
PETROLATUM TWA 5 MG/M3 INHALABLE FRACTION.
(CAS 8009-03-8)
US. NIOSH: POCKET GUIDE TO CHEMICAL HAZARDS
COMPONENTS TYPE VALUE FORM
DIPROPYLENE GLYCOL STEL 900 MG/M3
MONOMETHYL ETHER 150 PPM
(CAS 34590-94-8)
TWA 600 MG/M3
100 PPM
DISTILLATES (PETROLEUM), TWA 100 MG/M3
HYDROTREATED LIGHT
(CAS 64742-47-8)
DISTILLATES (PETROLEUM), STEL 10 MG/M3 MIST.
SOLVENT-REFINED HEAVY
PARAFFINIC TWA 5 MG/M3 MIST.
(CAS 64741-88-4)
N-HEXANE TWA 180 MG/M3
(CAS 110-54-3) 50 PPM
PETROLATUM STEL 10 MG/M3 MIST.
(CAS 8009-03-8)
TWA 5 MG/M3 MIST.
BIOLOGICAL LIMIT VALUES:
ACGIH BIOLOGICAL EXPOSURE INDICES:
COMPONENTS VALUE DETERMINANT SPECIMEN SAMPLING TIME
N-HEXANE 0.4 MG/L 2,5-HEXANEDION, URINE *
(CAS 110-54-3) WITHOUT
HYDROLYSIS
* - FOR SAMPLING DETAILS, PLEASE SEE THE SOURCE DOCUMENT.
EXPOSURE GUIDELINES:
US - CALIFORNIA OELS SKIN DESIGNATION
DIPROPYLENE GLYCOL MONOMETHYL ETHER CAN BE ABSORBED THROUGH THE SKIN.
(CAS 34590-94-8)
N-HEXANE CAN BE ABSORBED THROUGH THE SKIN.
(CAS 110-54-3)
US - TENNESSE OELS SKIN DESIGNATION
DIPROPYLENE GLYCOL MONOMETHYL ETHER CAN BE ABSORBED THROUGH THE SKIN.
(CAS 34590-94-8)
US ACGIH THRESHOLD LIMIT VALUES SKIN DESIGNATION
DIPROPYLENE GLYCOL MONOMETHYL ETHER CAN BE ABSORBED THROUGH THE SKIN.
(CAS 34590-94-8)
N-HEXANE CAN BE ABSORBED THROUGH THE SKIN.
(CAS 110-54-3)
US NIOSH POCKET GUIDE TO CHEMICAL HAZARDS SKIN DESIGNATION
DIPROPYLENE GLYCOL MONOMETHYL ETHER CAN BE ABSORBED THROUGH THE SKIN.
(CAS 34590-94-8)
US. OSHA TABLE Z-1 LIMITS FOR AIR CONTAMINANTS (29 CFR 1910.1000):
DIPROPYLENE GLYCOL MONOMETHYL ETHER (CAS 34590-94-8):
CAN BE ABSORBED THROUGH THE SKIN.
APPROPRIATE ENGINEERING CONTROLS:
GOOD GENERAL VENTILATION (TYPICALLY 10 AIR CHANGES PER HOUR) SHOULD BE USED.
VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS. IF APPLICABLE, USE
PROCESS ENCLOSURES, LOCAL EXHAUST VENTILATION, OR OTHER ENGINEERING CONTROLS
TO MAINTAIN AIRBORNE LEVELS BELOW RECOMMENDED EXPOSURE LIMITS. IF EXPOSURE
LIMITS HAVE NOT BEEN ESTABLISHED, MAINTAIN AIRBORNE LEVELS TO AN ACCEPTABLE
LEVEL. EYE WASH FACILITIES AND EMERGENCY SHOWER MUST BE AVAILABLE WHEN
HANDLING THIS PRODUCT.
INDIVIDUAL PROTECTION MEASURES, SUCH AS PERSONAL PROTECTIVE EQUIPMENT:
EYE/FACE PROTECTION: WEAR SAFETY GLASSES WITH SIDE SHIELDS (OR GOGGLES).
SKIN PROTECTION:
HAND PROTECTION:
WEAR PROTECTIVE GLOVES: NITRILE. POLYVINYL CHLORIDE (PVC).
OTHER: WEAR APPROPRIATE CHEMICAL RESISTANT CLOTHING.
RESPIRATORY PROTECTION:
WEAR POSITIVE PRESSURE SELF-CONTAINED BREATHING APPARATUS (SCBA). AIR
MONITORING IS NEEDED TO DETERMINE ACTUAL EMPLOYEE EXPOSURE LEVELS.
THERMAL HAZARDS:
WEAR APPROPRIATE THERMAL PROTECTIVE CLOTHING, WHEN NECESSARY.
GENERAL HYGIENE CONSIDERATIONS:
WHEN USING, DO NOT EAT, DRINK OR SMOKE. ALWAYS OBSERVE GOOD PERSONAL HYGIENE
MEASURES, SUCH AS WASHING AFTER HANDLING THE MATERIAL AND BEFORE EATING,
DRINKING, AND/OR SMOKING. ROUTINELY WASH WORK CLOTHING AND PROTECTIVE
EQUIPMENT TO REMOVE CONTAMINANTS.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE:
PHYSICAL STATE: LIQUID.
FORM: AEROSOL.
COLOR: AMBER. WHITE PRECIPITATE.
ODOR: WINTERGREEN.
ODOR THRESHOLD: NOT AVAILABLE.
PH: NOT AVAILABLE.
MELTING POINT/FREEZING POINT: -112 DEG. F (-80 DEG. C) ESTIMATED
INITIAL BOILING POINT AND BOILING RANGE: 118.4 DEG. F (48 DEG. C) ESTIMATED
FLASH POINT: <20 DEG. F (<-6.7 DEG. C) TAG CLOSED CUP
EVAPORATION RATE: FAST.
FLAMMABILITY (SOLID, GAS): NOT AVAILABLE.
UPPER/LOWER FLAMMABILITY OR EXPLOSIVE LIMITS:
FLAMMABILITY LIMIT - LOWER (%): 0.6% ESTIMATED
FLAMMABILITY LIMIT - UPPER (%): 14% ESTIMATED
VAPOR PRESSURE: 1125.6 HPA ESTIMATED
VAPOR DENSITY: >1 (AIR = 1)
RELATIVE DENSITY: 0.86 ESTIMATED
SOLUBILITY (WATER): NOT AVAILABLE.
PARTITION COEFFICIENT (N-OCTANOL/WATER): NOT AVAILABLE.
AUTO-IGNITION TEMPERATURE: 404.6 DEG. F (207 DEG. C) ESTIMATED
DECOMPOSITION TEMPERATURE: NOT AVAILABLE.
VISCOSITY (KINEMATIC): NOT AVAILABLE.
PERCENT VOLATILE: 86.9% ESTIMATED
| 10. STABILITY AND REACTIVITY | |
REACTIVITY:
THE PRODUCT IS STABLE AND NON-REACTIVE UNDER NORMAL CONDITIONS OF USE,
STORAGE AND TRANSPORT.
CHEMICAL STABILITY: MATERIAL IS STABLE UNDER NORMAL CONDITIONS.
POSSIBILITY OF HAZARDOUS REACTIONS:
NO DANGEROUS REACTION KNOWN UNDER CONDITIONS OF NORMAL USE.
CONDITIONS TO AVOID:
HEAT, FLAMES AND SPARKS. CONTACT WITH INCOMPATIBLE MATERIALS.
INCOMPATIBLE MATERIALS: STRONG OXIDIZING AGENTS.
HAZARDOUS DECOMPOSITION PRODUCTS:
CARBON OXIDES. SULFUR OXIDES. SALICYLIC ACID. HYDROCARBONS.
| 11. TOXICOLOGICAL INFORMATION | |
INFORMATION ON LIKELY ROUTES OF EXPOSURE:
INGESTION: MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS.
INHALATION:
VAPORS HAVE A NARCOTIC EFFECT AND MAY CAUSE HEADACHE, FATIGUE, DIZZINESS AND
NAUSEA. MAY CAUSE DAMAGE TO ORGANS BY INHALATION.
SKIN CONTACT: CAUSES SKIN IRRITATION.
EYE CONTACT: CAUSES SERIOUS EYE IRRITATION.
SYMPTOMS RELATED TO THE PHYSICAL, CHEMICAL AND TOXICOLOGICAL
CHARACTERISTICS: SYMPTOMS MAY INCLUDE STINGING, TEARING, REDNESS, SWELLING,
AND BLURRED VISION. SKIN IRRITATION. MAY CAUSE REDNESS AND PAIN. SYMPTOMS OF
OVEREXPOSURE MAY BE HEADACHE, DIZZINESS, TIREDNESS, NAUSEA AND VOMITING.
INFORMATION ON TOXICOLOGICAL EFFECTS:
ACUTE TOXICITY:
MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS. NARCOTIC EFFECTS.
PRODUCT SPECIES TEST RESULTS
POWER LUBE(R*) HIGH PERFORMANCE LUBRICANT W/PTFE:
ACUTE:
DERMAL:
LD50 RABBIT 8159.9121 MG/KG ESTIMATED
INHALATION:
LC50 RAT 53066.3281 PPM, 4 HOURS ESTIMATED
ORAL:
LD50 RAT 10395.3311 MG/KG ESTIMATED
TDL0 HUMAN 950.1966 G/KG ESTIMATED
CHRONIC:
ORAL:
NOEL RAT 32765.4004 MG/KG, 90 DAYS ESTIMATED
SUBCHRONIC:
ORAL:
LD50 RAT 745.1509 G/KG, 14 DAYS ESTIMATED
* ESTIMATES FOR PRODUCT MAY BE BASED ON ADDITIONAL COMPONENT DATA NOT SHOWN.
SKIN CORROSION/IRRITATION: CAUSES SKIN IRRITATION.
SERIOUS EYE DAMAGE/EYE IRRITATION: CAUSES SERIOUS EYE IRRITATION.
RESPIRATORY SENSITIZATION: NOT AVAILABLE.
SKIN SENSITIZATION:
THIS PRODUCT IS NOT EXPECTED TO CAUSE SKIN SENSITIZATION.
GERM CELL MUTAGENICITY:
NO DATA AVAILABLE TO INDICATE PRODUCT OR ANY COMPONENTS PRESENT AT GREATER
THAN 0.1% ARE MUTAGENIC OR GENOTOXIC.
CARCINOGENICITY:
THIS PRODUCT IS NOT CONSIDERED TO BE A CARCINOGEN BY IARC, ACGIH, NTP, OR
OSHA.
REPRODUCTIVE TOXICITY: SUSPECTED OF DAMAGING FERTILITY.
SPECIFIC TARGET ORGAN TOXICITY - SINGLE EXPOSURE: NARCOTIC EFFECTS.
SPECIFIC TARGET ORGAN TOXICITY - REPEATED EXPOSURE:
MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE.
ASPIRATION HAZARD: MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS.
CHRONIC EFFECTS:
MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE.
| 12. ECOLOGICAL INFORMATION | |
ECOTOXICITY: TOXIC TO AQUATIC LIFE.
PRODUCT SPECIES TEST RESULTS
POWER LUBE(R*) HIGH PERFORMANCE LUBRICANT W/PTFE:
ACUTE:
FISH LC50 FISH 4561.4033 PPM, 96 HOURS ESTIMATED
COMPONENTS SPECIES TEST RESULTS
DIPROPYLENE GLYCOL MONOMETHYL ETHER (CAS 34590-94-8):
ACUTE:
CRUSTACEA EC50 DAPHNIA >5000 MG/L, 48 HOURS
AQUATIC:
ACUTE:
FISH LC50 FATHEAD MINNOW 10000 MG/L, 96 HOURS
(PIMEPHALES PROMELAS)
DISTILLATES (PETROLEUM), HYDROTREATED LIGHT (CAS 64742-47-8):
AQUATIC:
ACUTE:
FISH LC50 BLUEGILL (LEPOMIS 2.2 MG/L, 96 HOURS
MACROCHIRUS)
N-HEXANE (CAS 110-54-3):
AQUATIC:
FISH LC50 FATHEAD MINNOW 2.101 - 2.981 MG/L, 96 HOURS
(PIMEPHALES PROMELAS)
* ESTIMATES FOR PRODUCT MAY BE BASED ON ADDITIONAL COMPONENT DATA NOT SHOWN.
PERSISTENCE AND DEGRADABILITY:
NO DATA IS AVAILABLE ON THE DEGRADABILITY OF THIS PRODUCT.
BIOACCUMULATIVE POTENTIAL: NO DATA AVAILABLE.
PARTITION COEFFICIENT N-OCTANOL / WATER (LOG KOW):
FATTY ACIDS, C18-UNSATD., DIMERS: 1 - 2.5, LOGKOW
METHYL SALICYLATE: 2.55
N-HEXANE: 3.9
MOBILITY IN SOIL: NO DATA AVAILABLE.
OTHER ADVERSE EFFECTS:
NO OTHER ADVERSE ENVIRONMENTAL EFFECTS (E.G. OZONE DEPLETION, PHOTOCHEMICAL
OZONE CREATION POTENTIAL, ENDOCRINE DISRUPTION, GLOBAL WARMING POTENTIAL)
ARE EXPECTED FROM THIS COMPONENT.
| 13. DISPOSAL CONSIDERATIONS | |
DISPOSAL OF WASTE FROM RESIDUES / UNUSED PRODUCTS:
IF DISCARDED, THIS PRODUCT IS CONSIDERED A RCRA IGNITABLE WASTE, D001. THIS
MATERIAL AND ITS CONTAINER MUST BE DISPOSED OF AS HAZARDOUS WASTE. CONSULT
AUTHORITIES BEFORE DISPOSAL. CONTENTS UNDER PRESSURE. DO NOT PUNCTURE,
INCINERATE OR CRUSH. DO NOT ALLOW THIS MATERIAL TO DRAIN INTO SEWERS/WATER
SUPPLIES. DO NOT CONTAMINATE PONDS, WATERWAYS OR DITCHES WITH CHEMICAL OR
USED CONTAINER. DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH
LOCAL/REGIONAL/NATIONAL REGULATIONS.
HAZARDOUS WASTE CODE:
D001: WASTE FLAMMABLE MATERIAL WITH A FLASH POINT <140 F
CONTAMINATED PACKAGING:
EMPTY CONTAINERS SHOULD BE TAKEN TO AN APPROVED WASTE HANDLING SITE FOR
RECYCLING OR DISPOSAL. SINCE EMPTIED CONTAINERS MAY RETAIN PRODUCT RESIDUE,
FOLLOW LABEL WARNINGS EVEN AFTER CONTAINER IS EMPTIED. DO NOT RE-USE EMPTY
CONTAINERS.
| 14. TRANSPORT INFORMATION | |
DOT:
UN NUMBER: UN1950
UN PROPER SHIPPING NAME: AEROSOLS, FLAMMABLE, LIMITED QUANTITY
TRANSPORT HAZARD CLASS(ES):
CLASS: 2.1
SUBSIDIARY RISK:
LABEL(S): 2.1
PACKING GROUP: NOT APPLICABLE.
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
SPECIAL PROVISIONS: N82
PACKAGING EXCEPTIONS: 306
PACKAGING NON BULK: NONE
PACKAGING BULK: NONE
IATA:
UN NUMBER: UN1950
UN PROPER SHIPPING NAME: AEROSOLS, FLAMMABLE, LIMITED QUANTITY
TRANSPORT HAZARD CLASS(ES):
CLASS: 2.1
SUBSIDIARY RISK:
PACKING GROUP: NOT APPLICABLE.
ENVIRONMENTAL HAZARDS: NO.
ERG CODE: 10L
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
OTHER INFORMATION:
PASSENGER AND CARGO AIRCRAFT: ALLOWED.
CARGO AIRCRAFT ONLY: ALLOWED.
IMDG:
UN NUMBER: UN1950
UN PROPER SHIPPING NAME: AEROSOLS, LIMITED QUANTITY
TRANSPORT HAZARD CLASS(ES):
CLASS: 2
SUBSIDIARY RISK:
PACKING GROUP: NOT APPLICABLE.
ENVIRONMENTAL HAZARDS:
MARINE POLLUTANT: NO.
EMS: NOT AVAILABLE.
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
| 15. REGULATORY INFORMATION | |
US FEDERAL REGULATIONS:
THIS PRODUCT IS A "HAZARDOUS CHEMICAL" AS DEFINED BY THE OSHA HAZARD
COMMUNICATION STANDARD, 29 CFR 1910.1200.
ALL COMPONENTS ARE ON THE U.S. EPA TSCA INVENTORY LIST.
TSCA SECTION 12(B) EXPORT NOTIFICATION (40 CFR 707, SUBPT. D):
NOT REGULATED.
SARA 304 EMERGENCY RELEASE NOTIFICATION: NOT REGULATED.
US. OSHA SPECIFICALLY REGULATED SUBSTANCES (29 CFR 1910.1001-1050):
NOT LISTED.
US EPCRA (SARA TITLE III) SECTION 313 - TOXIC CHEMICAL LISTED SUBSTANCE
N-HEXANE (CAS 110-54-3)
CERCLA HAZARDOUS SUBSTANCE LIST (40 CFR 302.4): N-HEXANE (CAS 110-54-3)
CERCLA HAZARDOUS SUBSTANCES REPORTABLE QUANTITY
N-HEXANE (CAS 110-54-3) 5000 LBS
SPILLS OR RELEASES RESULTING IN THE LOSS OF ANY INGREDIENT AT OR ABOVE ITS
RQ REQUIRE IMMEDIATE NOTIFICATION TO THE NATIONAL RESPONSE CENTER
(800-424-8802) AND TO YOUR LOCAL EMERGENCY PLANNING COMMITTEE.
CLEAN AIR ACT (CAA) SECTION 112 HAZARDOUS AIR POLLUTANTS (HAPS) LIST:
N-HEXANE (CAS 110-54-3)
CLEAN AIR ACT (CAA) SECTION 112(R) ACCIDENTAL RELEASE PREVENTION
(40 CFR 68.130): NOT REGULATED.
SAFE DRINKING WATER ACT (SDWA): NOT REGULATED.
FOOD AND DRUG ADMINISTRATION (FDA): NOT REGULATED.
SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 (SARA):
SECTION 311/312 HAZARD CATEGORIES:
IMMEDIATE HAZARD: YES
DELAYED HAZARD: YES
FIRE HAZARD: YES
PRESSURE HAZARD: YES
REACTIVITY HAZARD: NO
SARA 302 EXTREMELY HAZARDOUS SUBSTANCE: NO
US STATE REGULATIONS:
US. NEW JERSEY RTK - SUBSTANCES LISTED SUBSTANCE
DIPROPYLENE GLYCOL MONOMETHYL ETHER (CAS 34590-94-8)
N-HEXANE (CAS 110-54-3)
US. MASSACHUSETTS RTK - SUBSTANCE LIST:
DIPROPYLENE GLYCOL MONOMETHYL ETHER (CAS 34590-94-8)
US. PENNSYLVANIA RTK - HAZARDOUS SUBSTANCES:
DIPROPYLENE GLYCOL MONOMETHYL ETHER (CAS 34590-94-8)
DISTILLATES (PETROLEUM), HYDROTREATED LIGHT (CAS 64742-47-8)
METHYL SALICYLATE (CAS 119-36-8)
N-HEXANE (CAS 110-54-3)
US. RHODE ISLAND RTK: N-HEXANE (CAS 110-54-3)
US. CALIFORNIA PROPOSITION 65:
WARNING:
THIS PRODUCT CONTAINS A CHEMICAL KNOWN TO THE STATE OF CALIFORNIA TO CAUSE
CANCER AND BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM.
US - CALIFORNIA PROPOSITION 65 - CRT LISTED DATE/CARCINOGENIC SUBSTANCE
BENZENE (CAS 71-43-2) LISTED: FEBRUARY 27, 1987
CUMENE (CAS 98-82-8) LISTED: APRIL 6, 2010
ETHANAL (CAS 75-07-0) LISTED: APRIL 1, 1988
US - CALIFORNIA PROPOSITION 65 - CRT LISTED DATE/DEVELOPMENTAL TOXIN
BENZENE (CAS 71-43-2) LISTED: DECEMBER 26, 1997
US - CALIFORNIA PROPOSITION 65 - CRT LISTED DATE/MALE REPRODUCTIVE TOXIN
BENZENE (CAS 71-43-2) LISTED: DECEMBER 26, 1997
VOLATILE ORGANIC COMPOUNDS (VOC) REGULATIONS:
EPA:
VOC CONTENT (40 CFR 51.100(S)): 97.8%
CONSUMER PRODUCTS (40 CFR 59, SUBPT. C): NOT REGULATED
STATE:
CONSUMER PRODUCTS:
THIS PRODUCT IS REGULATED AS A MULTI-PURPOSE LUBRICANT. THIS PRODUCT IS
COMPLIANT FOR USE IN ALL 50 STATES.
VOC CONTENT (CA): 23.9%
VOC CONTENT (OTC): 23.9%
INTERNATIONAL INVENTORIES:
COUNTRY(S) OR REGION INVENTORY NAME ON INVENTORY
(YES/NO)*
AUSTRALIA AUSTRALIAN INVENTORY OF CHEMICAL YES
SUBSTANCES (AICS)
CANADA DOMESTIC SUBSTANCES LIST (DSL) NO
CANADA NON-DOMESTIC SUBSTANCES LIST (NDSL) YES
CHINA INVENTORY OF EXISTING CHEMICAL YES
SUBSTANCES IN CHINA (IECSC)
EUROPE EUROPEAN INVENTORY OF EXISTING NO
COMMERCIAL CHEMICAL SUBSTANCES
(EINECS)
EUROPE EUROPEAN LIST OF NOTIFIED CHEMICAL NO
SUBSTANCES (ELINCS)
JAPAN INVENTORY OF EXISTING AND NEW NO
CHEMICAL SUBSTANCES (ENCS)
KOREA EXISTING CHEMICALS LIST (ECL) YES
NEW ZEALAND NEW ZEALAND INVENTORY NO
PHILIPPINES PHILIPPINE INVENTORY OF CHEMICALS NO
AND CHEMICAL SUBSTANCES (PICCS)
UNITED STATES & TOXIC SUBSTANCES CONTROL ACT (TSCA) YES
PUERTO RICO INVENTORY
*A "YES" INDICATES THAT ALL COMPONENTS OF THIS PRODUCT COMPLY WITH THE
INVENTORY REQUIREMENTS ADMINISTERED BY THE GOVERNING COUNTRY(S)
A "NO" INDICATES THAT ONE OR MORE COMPONENTS OF THE PRODUCT ARE NOT LISTED
OR EXEMPT FROM LISTING ON THE INVENTORY ADMINISTERED BY THE GOVERNING
COUNTRY(S).
| 16. OTHER INFORMATION, INCLUDING DATE OF | |
PREPARATION OR LAST REVISION
ISSUE DATE: 11-18-2013
PREPARED BY: ALLISON CHO
VERSION #: 01
FURTHER INFORMATION: CRC # 494K-L
HMIS(R*) RATINGS:
HEALTH 2*
FLAMMABILITY 4
PHYSICAL HAZARD 0
PERSONAL PROTECTION B
NFPA RATINGS:
HEALTH 2
FLAMMABILITY 4
INSTABILITY 0
DISCLAIMER:
THE INFORMATION CONTAINED IN THIS DOCUMENT APPLIES TO THIS SPECIFIC MATERIAL
AS SUPPLIED. IT MAY NOT BE VALID FOR THIS MATERIAL IF IT IS USED IN
COMBINATION WITH ANY OTHER MATERIALS. THIS INFORMATION IS ACCURATE TO THE
BEST OF CRC INDUSTRIES' KNOWLEDGE OR OBTAINED FROM SOURCES BELIEVED BY CRC
TO BE ACCURATE. BEFORE USING ANY PRODUCT, READ ALL WARNINGS AND DIRECTIONS
ON THE LABEL. FOR FURTHER CLARIFICATION OF ANY INFORMATION CONTAINED ON THIS
(M)SDS CONSULT YOUR SUPERVISOR, A HEALTH & SAFETY PROFESSIONAL, OR CRC
INDUSTRIES.
MATERIAL NAME: POWER LUBE(R*) HIGH PERFORMANCE LUBRICANT W/PTFE
1735
SDS: US