| Common Name: | CHAIN AND WIRE ROPE LUBRICANT 03050 |
| Manufacturer: | CRC |
| SDS Revision Date: | 3/30/2015 |
| SDS Format: | GHS-US |
| Item Number(s): | 2F139 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
CRC(R*)
SAFETY DATA SHEET
| 1. IDENTIFICATION |  |
PRODUCT IDENTIFIER: CHAIN AND WIRE ROPE LUBRICANT
OTHER MEANS OF IDENTIFICATION:
PRODUCT CODE: 03050
RECOMMENDED USE: LUBRICANT
RECOMMENDED RESTRICTIONS: NONE KNOWN.
MANUFACTURER/IMPORTER/SUPPLIER/DISTRIBUTOR INFORMATION:
MANUFACTURED OR SOLD BY:
COMPANY NAME: CRC INDUSTRIES, INC.
ADDRESS:
885 LOUIS DR.
WARMINSTER, PA 18974
US
TELEPHONE:
GENERAL INFORMATION: 215-674-4300
TECHNICAL ASSISTANCE: 800-521-3168
CUSTOMER SERVICE: 800-272-4620
24-HOUR EMERGENCY (CHEMTREC):
800-424-9300 (US)
703-527-3887 (INTERNATIONAL)
WEBSITE: WWW.CRCINDUSTRIES.COM
| 2. HAZARD(S) IDENTIFICATION | |
PHYSICAL HAZARDS:
FLAMMABLE AEROSOLS: CATEGORY 1
GASES UNDER PRESSURE: LIQUEFIED GAS
HEALTH HAZARDS:
SERIOUS EYE DAMAGE/EYE IRRITATION: CATEGORY 2B
REPRODUCTIVE TOXICITY (FERTILITY): CATEGORY 2
SPECIFIC TARGET ORGAN TOXICITY, SINGLE EXPOSURE:
CATEGORY 3 NARCOTIC EFFECTS
SPECIFIC TARGET ORGAN TOXICITY, REPEATED EXPOSURE: CATEGORY 2
ASPIRATION HAZARD: CATEGORY 1
ENVIRONMENTAL HAZARDS:
HAZARDOUS TO THE AQUATIC ENVIRONMENT, LONG-TERM HAZARD: CATEGORY 3
OSHA DEFINED HAZARDS: NOT CLASSIFIED.
LABEL ELEMENTS:
FLAME
GAS CYLINDER
HEALTH HAZARD
EXCLAMATION MARK
SIGNAL WORD: DANGER
HAZARD STATEMENT:
EXTREMELY FLAMMABLE AEROSOL. CONTAINS GAS UNDER PRESSURE; MAY EXPLODE
IF HEATED. MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS. CAUSES EYE
IRRITATION. MAY CAUSE DROWSINESS OR DIZZINESS. SUSPECTED OF DAMAGING
FERTILITY. MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED
EXPOSURE. HARMFUL TO AQUATIC LIFE WITH LONG LASTING EFFECTS.
PRECAUTIONARY STATEMENT:
PREVENTION:
OBTAIN SPECIAL INSTRUCTIONS BEFORE USE. DO NOT HANDLE UNTIL ALL SAFETY
PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD. KEEP AWAY FROM HEAT/SPARKS/OPEN
FLAMES/HOT SURFACES. - NO SMOKING. DO NOT SPRAY ON AN OPEN FLAME OR OTHER
IGNITION SOURCE. DO NOT APPLY WHILE EQUIPMENT IS ENERGIZED.
PRESSURIZED CONTAINER:
DO NOT PIERCE OR BURN, EVEN AFTER USE. EXTINGUISH ALL FLAMES, PILOT LIGHTS
AND HEATERS. VAPORS WILL ACCUMULATE READILY AND MAY IGNITE. USE ONLY WITH
ADEQUATE VENTILATION; MAINTAIN VENTILATION DURING USE AND UNTIL ALL VAPORS
ARE GONE. OPEN DOORS AND WINDOWS OR USE OTHER MEANS TO ENSURE A FRESH AIR
SUPPLY DURING USE AND WHILE PRODUCT IS DRYING. IF YOU EXPERIENCE ANY
SYMPTOMS LISTED ON THIS LABEL, INCREASE VENTILATION OR LEAVE THE AREA.
WASH HANDS THOROUGHLY AFTER HANDLING. WEAR PROTECTIVE GLOVES/PROTECTIVE
CLOTHING/EYE PROTECTION/FACE PROTECTION. DO NOT BREATHE GAS, MIST OR VAPOR.
AVOID RELEASE TO THE ENVIRONMENT.
RESPONSE:
IF SWALLOWED:
IMMEDIATELY CALL A POISON CENTER/DOCTOR. DO NOT INDUCE VOMITING.
IF INHALED:
REMOVE PERSON TO FRESH AIR AND KEEP COMFORTABLE FOR BREATHING. CALL A
POISON CENTER/DOCTOR IF YOU FEEL UNWELL.
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES, IF
PRESENT AND EASY TO DO. CONTINUE RINSING.
IF EYE IRRITATION PERSISTS: GET MEDICAL ATTENTION.
IF EXPOSED OR CONCERNED: GET MEDICAL ATTENTION.
STORAGE:
STORE IN A WELL-VENTILATED PLACE. STORE LOCKED UP. PROTECT FROM SUNLIGHT.
DO NOT EXPOSE TO TEMPERATURES EXCEEDING 50 DEG. C/122 DEG. F. EXPOSURE TO
HIGH TEMPERATURE MAY CAUSE CAN TO BURST.
DISPOSAL:
DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH LOCAL/REGIONAL/NATIONAL
REGULATIONS.
HAZARD(S) NOT OTHERWISE CLASSIFIED (HNOC):
STATIC ACCUMULATING FLAMMABLE LIQUID CAN BECOME ELECTROSTATICALLY CHARGED
EVEN IN BONDED AND GROUNDED EQUIPMENT. SPARKS MAY IGNITE LIQUID AND VAPOR.
MAY CAUSE FLASH FIRE OR EXPLOSION.
| 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
MIXTURES:
CHEMICAL NAME COMMON NAME AND SYNONYMS CAS NUMBER %
NAPHTHA (PETROLEUM), 64742-49-0 40 - 50
HYDROTREATED LIGHT
LIQUEFIED PETROLEUM GAS 68476-86-8 20 - 30
2-METHYLPENTANE 107-83-5 10 - 20
ACRYLIC COPOLYMER PROPRIETARY 5 - 10
N-HEXANE 110-54-3 1 - 3
WHITE MINERAL OIL 8042-47-5 <1
2,2-DIMETHYLBUTANE 75-83-2 <0.2
SPECIFIC CHEMICAL IDENTITY AND/OR PERCENTAGE OF COMPOSITION HAS BEEN
WITHHELD AS A TRADE SECRET.
| 4. FIRST-AID MEASURES | |
INHALATION:
REMOVE VICTIM TO FRESH AIR AND KEEP AT REST IN A POSITION COMFORTABLE FOR
BREATHING. CALL A POISON CENTER OR DOCTOR/PHYSICIAN IF YOU FEEL UNWELL.
SKIN CONTACT:
TAKE OFF CONTAMINATED CLOTHING AND WASH BEFORE REUSE. RINSE SKIN WITH
WATER/SHOWER. GET MEDICAL ATTENTION IF IRRITATION DEVELOPS AND PERSISTS.
EYE CONTACT:
IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES. REMOVE
CONTACT LENSES, IF PRESENT AND EASY TO DO. CONTINUE RINSING. GET MEDICAL
ATTENTION IF IRRITATION DEVELOPS AND PERSISTS.
INGESTION:
CALL A PHYSICIAN OR POISON CONTROL CENTER IMMEDIATELY. RINSE MOUTH. DO NOT
INDUCE VOMITING. IF VOMITING OCCURS, KEEP HEAD LOW SO THAT STOMACH CONTENT
DOESN'T GET INTO THE LUNGS. ASPIRATION MAY CAUSE PULMONARY EDEMA AND
PNEUMONITIS.
MOST IMPORTANT SYMPTOMS/EFFECTS, ACUTE AND DELAYED:
EXPOSED INDIVIDUALS MAY EXPERIENCE EYE TEARING, REDNESS, AND DISCOMFORT.
VAPORS HAVE A NARCOTIC EFFECT AND MAY CAUSE HEADACHE, FATIGUE, DIZZINESS
AND NAUSEA. MAY CAUSE DROWSINESS OR DIZZINESS. PROLONGED EXPOSURE MAY CAUSE
CHRONIC EFFECTS.
INDICATION OF IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED:
PROVIDE GENERAL SUPPORTIVE MEASURES AND TREAT SYMPTOMATICALLY. IN CASE OF
SHORTNESS OF BREATH, GIVE OXYGEN. KEEP VICTIM WARM. KEEP VICTIM UNDER
OBSERVATION. SYMPTOMS MAY BE DELAYED.
GENERAL INFORMATION:
IF EXPOSED OR CONCERNED:
GET MEDICAL ADVICE/ATTENTION. ENSURE THAT MEDICAL PERSONNEL ARE AWARE OF
THE MATERIAL(S) INVOLVED, AND TAKE PRECAUTIONS TO PROTECT THEMSELVES.
| 5. FIRE-FIGHTING MEASURES | |
SUITABLE EXTINGUISHING MEDIA:
WATER SPRAY. WATER FOG. FOAM. DRY CHEMICAL POWDER, CARBON DIOXIDE, SAND OR
EARTH MAY BE USED FOR SMALL FIRES ONLY.
UNSUITABLE EXTINGUISHING MEDIA:
DO NOT USE WATER JET AS AN EXTINGUISHER, AS THIS WILL SPREAD THE FIRE.
SPECIFIC HAZARDS ARISING FROM THE CHEMICAL:
CONTENTS UNDER PRESSURE. PRESSURIZED CONTAINER MAY RUPTURE WHEN EXPOSED TO
HEAT OR FLAME. THIS PRODUCT IS A POOR CONDUCTOR OF ELECTRICITY AND CAN
BECOME ELECTROSTATICALLY CHARGED. IF SUFFICIENT CHARGE IS ACCUMULATED,
IGNITION OF FLAMMABLE MIXTURES CAN OCCUR. STATIC ELECTRICITY ACCUMULATION
MAY BE SIGNIFICANTLY INCREASED BY THE PRESENCE OF SMALL QUANTITIES OF WATER
OR OTHER CONTAMINANTS. MATERIAL WILL FLOAT AND MAY IGNITE ON SURFACE OF
WATER.
SPECIAL PROTECTIVE EQUIPMENT AND PRECAUTIONS FOR FIREFIGHTERS:
FIREFIGHTERS MUST USE STANDARD PROTECTIVE EQUIPMENT INCLUDING FLAME
RETARDANT COAT, HELMET WITH FACE SHIELD, GLOVES, RUBBER BOOTS, AND IN
ENCLOSED SPACES, SCBA.
FIRE-FIGHTING EQUIPMENT/INSTRUCTIONS:
IN CASE OF FIRE:
STOP LEAK IF SAFE TO DO SO. DO NOT MOVE CARGO OR VEHICLE IF CARGO HAS BEEN
EXPOSED TO HEAT. MOVE CONTAINERS FROM FIRE AREA IF YOU CAN DO SO WITHOUT
RISK. CONTAINERS SHOULD BE COOLED WITH WATER TO PREVENT VAPOR PRESSURE
BUILD UP. FOR MASSIVE FIRE IN CARGO AREA, USE UNMANNED HOSE HOLDER OR
MONITOR NOZZLES, IF POSSIBLE. IF NOT, WITHDRAW AND LET FIRE BURN OUT.
IN THE EVENT OF FIRE, COOL TANKS WITH WATER SPRAY.
GENERAL FIRE HAZARDS: EXTREMELY FLAMMABLE AEROSOL.
| 6. ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
KEEP UNNECESSARY PERSONNEL AWAY. KEEP PEOPLE AWAY FROM AND UPWIND OF
SPILL/LEAK. KEEP OUT OF LOW AREAS. REMOVE ALL POSSIBLE SOURCES OF IGNITION
IN THE SURROUNDING AREA. WEAR APPROPRIATE PROTECTIVE EQUIPMENT AND CLOTHING
DURING CLEAN-UP. DO NOT BREATHE MIST OR VAPOR. DO NOT TOUCH DAMAGED
CONTAINERS OR SPILLED MATERIAL UNLESS WEARING APPROPRIATE PROTECTIVE
CLOTHING. AVOID BREATHING GAS. VENTILATE CLOSED SPACES BEFORE ENTERING
THEM. USE APPROPRIATE CONTAINMENT TO AVOID ENVIRONMENTAL CONTAMINATION.
LOCAL AUTHORITIES SHOULD BE ADVISED IF SIGNIFICANT SPILLAGES CANNOT BE
CONTAINED. FOR PERSONAL PROTECTION, SEE SECTION 8 OF THE SDS.
METHODS AND MATERIALS FOR CONTAINMENT AND CLEANING UP:
ELIMINATE ALL IGNITION SOURCES (NO SMOKING, FLARES, SPARKS, OR FLAMES IN
IMMEDIATE AREA). KEEP COMBUSTIBLES (WOOD, PAPER, OIL, ETC.) AWAY FROM
SPILLED MATERIAL. THIS PRODUCT IS MISCIBLE IN WATER. STOP THE FLOW OF
MATERIAL, IF THIS IS WITHOUT RISK. COLLECT SPILLAGE. DIKE FAR AHEAD OF
SPILL FOR LATER DISPOSAL. WIPE UP WITH ABSORBENT MATERIAL (E.G. CLOTH,
FLEECE). CLEAN SURFACE THOROUGHLY TO REMOVE RESIDUAL CONTAMINATION. PREVENT
ENTRY INTO WATERWAYS, SEWER, BASEMENTS OR CONFINED AREAS. FOR WASTE
DISPOSAL, SEE SECTION 13 OF THE SDS.
ENVIRONMENTAL PRECAUTIONS:
AVOID RELEASE TO THE ENVIRONMENT. CONTACT LOCAL AUTHORITIES IN CASE OF
SPILLAGE TO DRAIN/AQUATIC ENVIRONMENT. PREVENT FURTHER LEAKAGE OR SPILLAGE
IF SAFE TO DO SO. DO NOT CONTAMINATE WATER. AVOID DISCHARGE INTO DRAINS,
WATER COURSES OR ONTO THE GROUND. USE APPROPRIATE CONTAINMENT TO AVOID
ENVIRONMENTAL CONTAMINATION.
| 7. HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING:
OBTAIN SPECIAL INSTRUCTIONS BEFORE USE. DO NOT HANDLE UNTIL ALL SAFETY
PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD. MINIMIZE FIRE RISKS FROM
FLAMMABLE AND COMBUSTIBLE MATERIALS (INCLUDING COMBUSTIBLE DUST AND STATIC
ACCUMULATING LIQUIDS) OR DANGEROUS REACTIONS WITH INCOMPATIBLE MATERIALS.
HANDLING OPERATIONS THAT CAN PROMOTE ACCUMULATION OF STATIC CHARGES INCLUDE
BUT ARE NOT LIMITED TO:
MIXING, FILTERING, PUMPING AT HIGH FLOW RATES, SPLASH FILLING, CREATING
MISTS OR SPRAYS, TANK AND CONTAINER FILLING, TANK CLEANING, SAMPLING,
GAUGING, SWITCH LOADING, VACUUM TRUCK OPERATIONS.
PRESSURIZED CONTAINER:
DO NOT PIERCE OR BURN, EVEN AFTER USE. DO NOT USE IF SPRAY BUTTON IS
MISSING OR DEFECTIVE. DO NOT SPRAY ON A NAKED FLAME OR ANY OTHER
INCANDESCENT MATERIAL. DO NOT SMOKE WHILE USING OR UNTIL SPRAYED SURFACE
IS THOROUGHLY DRY. DO NOT CUT, WELD, SOLDER, DRILL, GRIND, OR EXPOSE
CONTAINERS TO HEAT, FLAME, SPARKS, OR OTHER SOURCES OF IGNITION. USE
CAUTION AROUND ENERGIZED EQUIPMENT. THE METAL CONTAINER WILL CONDUCT
ELECTRICITY IF IT CONTACTS A LIVE SOURCE. THIS MAY RESULT IN INJURY TO THE
USER FROM ELECTRICAL SHOCK AND/OR FLASH FIRE. DO NOT BREATHE MIST OR VAPOR.
DO NOT BREATHE GAS. DO NOT TASTE OR SWALLOW. AVOID CONTACT WITH SKIN AND
EYES. AVOID CONTACT DURING PREGNANCY/WHILE NURSING. AVOID PROLONGED
EXPOSURE. USE ONLY IN WELL-VENTILATED AREAS. WEAR APPROPRIATE PERSONAL
PROTECTIVE EQUIPMENT. WHEN USING, DO NOT EAT, DRINK OR SMOKE. WASH HANDS
THOROUGHLY AFTER HANDLING. OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES. AVOID
RELEASE TO THE ENVIRONMENT. DO NOT EMPTY INTO DRAINS. FOR PRODUCT USAGE
INSTRUCTIONS, PLEASE SEE THE PRODUCT LABEL.
CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES:
LEVEL 3 AEROSOL.
PRESSURIZED CONTAINER. PROTECT FROM SUNLIGHT AND DO NOT EXPOSE TO
TEMPERATURES EXCEEDING 50 DEG. C/122 DEG. F. DO NOT PUNCTURE, INCINERATE OR
CRUSH. DO NOT HANDLE OR STORE NEAR AN OPEN FLAME, HEAT OR OTHER SOURCES OF
IGNITION. THIS MATERIAL CAN ACCUMULATE STATIC CHARGE WHICH MAY CAUSE SPARK
AND BECOME AN IGNITION SOURCE. AVOID SPARK PROMOTERS. THESE ALONE MAY BE
INSUFFICIENT TO REMOVE STATIC ELECTRICITY. STORE IN A WELL-VENTILATED
PLACE. STORE AWAY FROM INCOMPATIBLE MATERIALS (SEE SECTION 10 OF THE SDS).
KEEP OUT OF THE REACH OF CHILDREN.
| 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
OCCUPATIONAL EXPOSURE LIMITS:
US. OSHA TABLE Z-1 LIMITS FOR AIR CONTAMINANTS (29 CFR 1910.1000):
COMPONENTS TYPE VALUE FORM
N-HEXANE (CAS 110-54-3) PEL 1800 MG/M3
500 PPM
WHITE MINERAL OIL PEL 5 MG/M3 MIST.
(CAS 8042-47-5)
US. ACGIH THRESHOLD LIMIT VALUES:
COMPONENTS TYPE VALUE FORM
2,2-DIMETHYLBUTANE STEL 1000 PPM
(CAS 75-83-2) TWA 500 PPM
2-METHYLPENTANE STEL 1000 PPM
(CAS 107-83-5) TWA 500 PPM
N-HEXANE (CAS 110-54-3) TWA 50 PPM
WHITE MINERAL OIL TWA 5 MG/M3 INHALABLE FRACTION.
(CAS 8042-47-5)
US. NIOSH: POCKET GUIDE TO CHEMICAL HAZARDS
COMPONENTS TYPE VALUE FORM
2,2-DIMETHYLBUTANE CEILING 1800 MG/M3
(CAS 75-83-2) 510 PPM
TWA 350 MG/M3
100 PPM
2-METHYLPENTANE CEILING 1800 MG/M3
(CAS 107-83-5) 510 PPM
TWA 350 MG/M3
100 PPM
N-HEXANE (CAS 110-54-3) TWA 180 MG/M3
50 PPM
WHITE MINERAL OIL STEL 10 MG/M3 MIST.
(CAS 8042-47-5)
TWA 5 MG/M3 MIST.
BIOLOGICAL LIMIT VALUES:
ACGIH BIOLOGICAL EXPOSURE INDICES:
COMPONENTS VALUE DETERMINANT SPECIMEN SAMPLING TIME
N-HEXANE 0.4 MG/L 2,5-HEXANEDION, URINE *
(CAS 110-54-3) WITHOUT
HYDROLYSIS
* - FOR SAMPLING DETAILS, PLEASE SEE THE SOURCE DOCUMENT.
EXPOSURE GUIDELINES:
US - CALIFORNIA OELS SKIN DESIGNATION
N-HEXANE (CAS 110-54-3) CAN BE ABSORBED THROUGH THE SKIN.
US ACGIH THRESHOLD LIMIT VALUES SKIN DESIGNATION
N-HEXANE (CAS 110-54-3) CAN BE ABSORBED THROUGH THE SKIN.
APPROPRIATE ENGINEERING CONTROLS:
GOOD GENERAL VENTILATION (TYPICALLY 10 AIR CHANGES PER HOUR) SHOULD BE
USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS. IF APPLICABLE,
USE PROCESS ENCLOSURES, LOCAL EXHAUST VENTILATION, OR OTHER ENGINEERING
CONTROLS TO MAINTAIN AIRBORNE LEVELS BELOW RECOMMENDED EXPOSURE LIMITS.
IF EXPOSURE LIMITS HAVE NOT BEEN ESTABLISHED, MAINTAIN AIRBORNE LEVELS
TO AN ACCEPTABLE LEVEL. PROVIDE EYEWASH STATION.
INDIVIDUAL PROTECTION MEASURES, SUCH AS PERSONAL PROTECTIVE EQUIPMENT:
EYE/FACE PROTECTION: WEAR SAFETY GLASSES WITH SIDE SHIELDS (OR GOGGLES).
SKIN PROTECTION:
HAND PROTECTION:
WEAR PROTECTIVE GLOVES SUCH AS:
NITRILE. POLYVINYL CHLORIDE (PVC). VITON(R*).
OTHER: WEAR APPROPRIATE CHEMICAL RESISTANT CLOTHING.
RESPIRATORY PROTECTION:
IF ENGINEERING CONTROLS ARE NOT FEASIBLE OR IF EXPOSURE EXCEEDS THE
APPLICABLE EXPOSURE LIMITS, USE A NIOSH-APPROVED CARTRIDGE RESPIRATOR WITH
AN ORGANIC VAPOR CARTRIDGE. USE A SELF-CONTAINED BREATHING APPARATUS IN
CONFINED SPACES AND FOR EMERGENCIES. AIR MONITORING IS NEEDED TO DETERMINE
ACTUAL EMPLOYEE EXPOSURE LEVELS.
THERMAL HAZARDS:
WEAR APPROPRIATE THERMAL PROTECTIVE CLOTHING, WHEN NECESSARY.
GENERAL HYGIENE CONSIDERATIONS:
WHEN USING, DO NOT EAT, DRINK OR SMOKE. ALWAYS OBSERVE GOOD PERSONAL
HYGIENE MEASURES, SUCH AS WASHING AFTER HANDLING THE MATERIAL AND BEFORE
EATING, DRINKING, AND/OR SMOKING. ROUTINELY WASH WORK CLOTHING AND
PROTECTIVE EQUIPMENT TO REMOVE CONTAMINANTS.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE:
PHYSICAL STATE: LIQUID.
FORM: AEROSOL.
COLOR: GREEN.
ODOR: MILD SOLVENT.
ODOR THRESHOLD: NOT AVAILABLE.
PH: NOT AVAILABLE.
MELTING POINT/FREEZING POINT: <-76 DEG. F (<-60 DEG. C)
INITIAL BOILING POINT AND BOILING RANGE: 95 DEG. F (35 DEG. C) ESTIMATED
FLASH POINT: <0 DEG. F (<-17.8 DEG. C) TAG CLOSED CUP
EVAPORATION RATE: VERY FAST.
FLAMMABILITY (SOLID, GAS): NOT AVAILABLE.
UPPER/LOWER FLAMMABILITY OR EXPLOSIVE LIMITS:
FLAMMABILITY LIMIT - LOWER (%): 1% ESTIMATED
FLAMMABILITY LIMIT - UPPER (%): 8% ESTIMATED
VAPOR PRESSURE: 1562.8 HPA ESTIMATED
VAPOR DENSITY: >1 (AIR = 1)
RELATIVE DENSITY: 0.64 ESTIMATED
SOLUBILITY (WATER): NEGLIGIBLE.
PARTITION COEFFICIENT (N-OCTANOL/WATER): NOT AVAILABLE.
AUTO-IGNITION TEMPERATURE: 437 DEG. F (225 DEG. C) ESTIMATED
DECOMPOSITION TEMPERATURE: NOT AVAILABLE.
VISCOSITY (KINEMATIC): NOT AVAILABLE.
PERCENT VOLATILE: 93% ESTIMATED
| 10. STABILITY AND REACTIVITY | |
REACTIVITY:
THE PRODUCT IS STABLE AND NON-REACTIVE UNDER NORMAL CONDITIONS OF USE,
STORAGE AND TRANSPORT.
CHEMICAL STABILITY: MATERIAL IS STABLE UNDER NORMAL CONDITIONS.
POSSIBILITY OF HAZARDOUS REACTIONS:
NO DANGEROUS REACTION KNOWN UNDER CONDITIONS OF NORMAL USE.
CONDITIONS TO AVOID:
HEAT, FLAMES AND SPARKS. CONTACT WITH INCOMPATIBLE MATERIALS.
INCOMPATIBLE MATERIALS: STRONG OXIDIZING AGENTS. CHLORINE.
HAZARDOUS DECOMPOSITION PRODUCTS: CARBON OXIDES.
| 11. TOXICOLOGICAL INFORMATION | |
INFORMATION ON LIKELY ROUTES OF EXPOSURE:
INGESTION: MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS.
INHALATION:
VAPORS HAVE A NARCOTIC EFFECT AND MAY CAUSE HEADACHE, FATIGUE, DIZZINESS
AND NAUSEA. PROLONGED INHALATION MAY BE HARMFUL. MAY CAUSE DAMAGE TO ORGANS
BY INHALATION.
SKIN CONTACT: PROLONGED SKIN CONTACT MAY CAUSE TEMPORARY IRRITATION.
EYE CONTACT: CAUSES EYE IRRITATION.
SYMPTOMS RELATED TO THE PHYSICAL, CHEMICAL AND TOXICOLOGICAL
CHARACTERISTICS:
EXPOSED INDIVIDUALS MAY EXPERIENCE EYE TEARING, REDNESS, AND DISCOMFORT.
SYMPTOMS OF OVEREXPOSURE MAY BE HEADACHE, DIZZINESS, TIREDNESS, NAUSEA AND
VOMITING. PROLONGED OR EXCESSIVE INHALATION MAY CAUSE RESPIRATORY TRACT
IRRITATION.
INFORMATION ON TOXICOLOGICAL EFFECTS:
ACUTE TOXICITY:
MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS. NARCOTIC EFFECTS.
PRODUCT SPECIES TEST RESULTS
CHAIN AND WIRE ROPE LUBRICANT:
ACUTE:
DERMAL:
LD50 RABBIT 3436.5364 MG/KG ESTIMATED
INHALATION:
LC50 RAT 62747.5625 PPM, 4 HOURS ESTIMATED
53.1125 MG/L, 4 HOURS ESTIMATED
ORAL:
LD50 RAT 8211.2344 MG/KG ESTIMATED
*ESTIMATES FOR PRODUCT MAY BE BASED ON ADDITIONAL COMPONENT DATA NOT SHOWN.
SKIN CORROSION/IRRITATION:
PROLONGED SKIN CONTACT MAY CAUSE TEMPORARY IRRITATION.
SERIOUS EYE DAMAGE/EYE IRRITATION: CAUSES EYE IRRITATION.
RESPIRATORY SENSITIZATION: NOT AVAILABLE.
SKIN SENSITIZATION:
THIS PRODUCT IS NOT EXPECTED TO CAUSE SKIN SENSITIZATION.
GERM CELL MUTAGENICITY:
NO DATA AVAILABLE TO INDICATE PRODUCT OR ANY COMPONENTS PRESENT AT GREATER
THAN 0.1% ARE MUTAGENIC OR GENOTOXIC.
CARCINOGENICITY:
THIS PRODUCT IS NOT CONSIDERED TO BE A CARCINOGEN BY IARC, ACGIH, NTP, OR
OSHA.
IARC MONOGRAPHS. OVERALL EVALUATION OF CARCINOGENICITY:
WHITE MINERAL OIL (CAS 8042-47-5):
3: NOT CLASSIFIABLE AS TO CARCINOGENICITY TO HUMANS.
REPRODUCTIVE TOXICITY: SUSPECTED OF DAMAGING FERTILITY.
SPECIFIC TARGET ORGAN TOXICITY - SINGLE EXPOSURE: NARCOTIC EFFECTS.
SPECIFIC TARGET ORGAN TOXICITY - REPEATED EXPOSURE:
MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE.
ASPIRATION HAZARD: MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS.
CHRONIC EFFECTS:
PROLONGED INHALATION MAY BE HARMFUL. MAY CAUSE DAMAGE TO ORGANS THROUGH
PROLONGED OR REPEATED EXPOSURE.
| 12. ECOLOGICAL INFORMATION | |
ECOTOXICITY:
HARMFUL TO AQUATIC LIFE WITH LONG LASTING EFFECTS. ACCUMULATION IN AQUATIC
ORGANISMS IS EXPECTED.
PRODUCT SPECIES TEST RESULTS
CHAIN AND WIRE ROPE LUBRICANT:
AQUATIC:
CRUSTACEA EC50 DAPHNIA 2094.2 MG/L, 48 HOURS
ESTIMATED
FISH LC50 FISH 1557.55 MG/L, 96 HOURS
ESTIMATED
COMPONENTS SPECIES TEST RESULTS
N-HEXANE (CAS 110-54-3):
AQUATIC:
FISH LC50 FATHEAD MINNOW (PIMEPHALES 2.101 - 2.981 MG/L,
PROMELAS) 96 HOURS
*ESTIMATES FOR PRODUCT MAY BE BASED ON ADDITIONAL COMPONENT DATA NOT SHOWN.
PERSISTENCE AND DEGRADABILITY:
NO DATA IS AVAILABLE ON THE DEGRADABILITY OF THIS PRODUCT.
BIOACCUMULATIVE POTENTIAL: NO DATA AVAILABLE.
PARTITION COEFFICIENT N-OCTANOL / WATER (LOG KOW):
2,2-DIMETHYLBUTANE: 3.82
2-METHYLPENTANE: 3.74
N-HEXANE: 3.9
MOBILITY IN SOIL: NO DATA AVAILABLE.
OTHER ADVERSE EFFECTS:
NO OTHER ADVERSE ENVIRONMENTAL EFFECTS (E.G. OZONE DEPLETION, PHOTOCHEMICAL
OZONE CREATION POTENTIAL, ENDOCRINE DISRUPTION, GLOBAL WARMING POTENTIAL)
ARE EXPECTED FROM THIS COMPONENT.
| 13. DISPOSAL CONSIDERATIONS | |
DISPOSAL OF WASTE FROM RESIDUES / UNUSED PRODUCTS:
IF DISCARDED, THIS PRODUCT IS CONSIDERED A RCRA IGNITABLE WASTE, D001.
EMPTY CONTAINER CAN BE RECYCLED. CONSULT AUTHORITIES BEFORE DISPOSAL.
CONTENTS UNDER PRESSURE. DO NOT PUNCTURE, INCINERATE OR CRUSH. DO NOT ALLOW
THIS MATERIAL TO DRAIN INTO SEWERS/WATER SUPPLIES. DO NOT CONTAMINATE
PONDS, WATERWAYS OR DITCHES WITH CHEMICAL OR USED CONTAINER. DISPOSE IN
ACCORDANCE WITH ALL APPLICABLE REGULATIONS.
HAZARDOUS WASTE CODE:
D001: WASTE FLAMMABLE MATERIAL WITH A FLASH POINT <140 F
CONTAMINATED PACKAGING:
EMPTY CONTAINERS SHOULD BE TAKEN TO AN APPROVED WASTE HANDLING SITE FOR
RECYCLING OR DISPOSAL. SINCE EMPTIED CONTAINERS MAY RETAIN PRODUCT RESIDUE,
FOLLOW LABEL WARNINGS EVEN AFTER CONTAINER IS EMPTIED.
| 14. TRANSPORT INFORMATION | |
DOT:
UN NUMBER: UN1950
UN PROPER SHIPPING NAME: AEROSOLS, FLAMMABLE, LIMITED QUANTITY
TRANSPORT HAZARD CLASS(ES):
CLASS: 2.1
SUBSIDIARY RISK:
LABEL(S): 2.1
PACKING GROUP: NOT APPLICABLE.
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
SPECIAL PROVISIONS: N82
PACKAGING EXCEPTIONS: 306
PACKAGING NON BULK: NONE
PACKAGING BULK: NONE
IATA:
UN NUMBER: UN1950
UN PROPER SHIPPING NAME: AEROSOLS, FLAMMABLE, LIMITED QUANTITY
TRANSPORT HAZARD CLASS(ES):
CLASS: 2.1
SUBSIDIARY RISK:
PACKING GROUP: NOT APPLICABLE.
ENVIRONMENTAL HAZARDS: NO.
ERG CODE: 10L
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
OTHER INFORMATION:
PASSENGER AND CARGO AIRCRAFT: ALLOWED.
CARGO AIRCRAFT ONLY: ALLOWED.
IMDG:
UN NUMBER: UN1950
UN PROPER SHIPPING NAME: AEROSOLS, LIMITED QUANTITY
TRANSPORT HAZARD CLASS(ES):
CLASS: 2
SUBSIDIARY RISK:
PACKING GROUP: NOT APPLICABLE.
ENVIRONMENTAL HAZARDS:
MARINE POLLUTANT: NO.
EMS: NOT AVAILABLE.
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
| 15. REGULATORY INFORMATION | |
US FEDERAL REGULATIONS:
THIS PRODUCT IS A "HAZARDOUS CHEMICAL" AS DEFINED BY THE OSHA HAZARD
COMMUNICATION STANDARD, 29 CFR 1910.1200.
ALL COMPONENTS ARE ON THE U.S. EPA TSCA INVENTORY LIST.
TSCA SECTION 12(B) EXPORT NOTIFICATION (40 CFR 707, SUBPT. D):
NOT REGULATED.
SARA 304 EMERGENCY RELEASE NOTIFICATION: NOT REGULATED.
US. OSHA SPECIFICALLY REGULATED SUBSTANCES (29 CFR 1910.1001-1050):
NOT LISTED.
US EPCRA (SARA TITLE III) SECTION 313 - LISTED SUBSTANCE
TOXIC CHEMICAL
N-HEXANE (CAS 110-54-3)
CERCLA HAZARDOUS SUBSTANCE LIST (40 CFR 302.4):
N-HEXANE (CAS 110-54-3)
CERCLA HAZARDOUS SUBSTANCES REPORTABLE QUANTITY
N-HEXANE (CAS 110-54-3) 5000 LBS
SPILLS OR RELEASES RESULTING IN THE LOSS OF ANY INGREDIENT AT OR ABOVE
ITS RQ REQUIRE IMMEDIATE NOTIFICATION TO THE NATIONAL RESPONSE CENTER
(800-424-8802) AND TO YOUR LOCAL EMERGENCY PLANNING COMMITTEE.
CLEAN AIR ACT (CAA) SECTION 112 HAZARDOUS AIR POLLUTANTS (HAPS) LIST:
N-HEXANE (CAS 110-54-3)
CLEAN AIR ACT (CAA) SECTION 112(R) ACCIDENTAL RELEASE PREVENTION (40 CFR
68.130): NOT REGULATED.
SAFE DRINKING WATER ACT (SDWA): NOT REGULATED.
FOOD AND DRUG ADMINISTRATION (FDA): NOT REGULATED.
SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 (SARA):
SECTION 311/312 HAZARD CATEGORIES:
IMMEDIATE HAZARD: YES
DELAYED HAZARD: YES
FIRE HAZARD: YES
PRESSURE HAZARD: YES
REACTIVITY HAZARD: NO
SARA 302 EXTREMELY HAZARDOUS SUBSTANCE: NO
US STATE REGULATIONS:
US. CALIFORNIA CONTROLLED SUBSTANCES. CA DEPARTMENT OF JUSTICE (CALIFORNIA
HEALTH AND SAFETY CODE SECTION 11100): NOT LISTED.
US. NEW JERSEY WORKER AND COMMUNITY RIGHT-TO-KNOW ACT:
2,2-DIMETHYLBUTANE (CAS 75-83-2)
2-METHYLPENTANE (CAS 107-83-5)
N-HEXANE (CAS 110-54-3)
US. MASSACHUSETTS RTK - SUBSTANCE LIST:
2-METHYLPENTANE (CAS 107-83-5)
N-HEXANE (CAS 110-54-3)
US. PENNSYLVANIA WORKER AND COMMUNITY RIGHT-TO-KNOW LAW:
2,2-DIMETHYLBUTANE (CAS 75-83-2)
2-METHYLPENTANE (CAS 107-83-5)
N-HEXANE (CAS 110-54-3)
WHITE MINERAL OIL (CAS 8042-47-5)
US. RHODE ISLAND RTK:
N-HEXANE (CAS 110-54-3)
US. CALIFORNIA PROPOSITION 65:
CALIFORNIA SAFE DRINKING WATER AND TOXIC ENFORCEMENT ACT OF 1986
(PROPOSITION 65):
THIS MATERIAL IS NOT KNOWN TO CONTAIN ANY CHEMICALS CURRENTLY LISTED AS
CARCINOGENS OR REPRODUCTIVE TOXINS.
VOLATILE ORGANIC COMPOUNDS (VOC) REGULATIONS:
EPA:
VOC CONTENT (40 CFR 51.100(S)): 92.1%
CONSUMER PRODUCTS (40 CFR 59, SUBPT. C): NOT REGULATED
STATE:
CONSUMER PRODUCTS:
THIS PRODUCT IS REGULATED AS A GEAR, CHAIN OR WIRE LUBRICANT (AEROSOL).
THIS PRODUCT IS NOT COMPLIANT TO BE SOLD FOR USE IN CALIFORNIA. THIS
PRODUCT IS COMPLIANT IN ALL OTHER STATES.
VOC CONTENT (CA): 92.1%
VOC CONTENT (OTC): 92.1%
INTERNATIONAL INVENTORIES:
COUNTRY(S) OR REGION INVENTORY NAME ON INVENTORY
(YES/NO)*
AUSTRALIA AUSTRALIAN INVENTORY OF CHEMICAL YES
SUBSTANCES (AICS)
CANADA DOMESTIC SUBSTANCES LIST (DSL) YES
CANADA NON-DOMESTIC SUBSTANCES LIST (NDSL) NO
CHINA INVENTORY OF EXISTING CHEMICAL YES
SUBSTANCES IN CHINA (IECSC)
EUROPE EUROPEAN INVENTORY OF EXISTING NO
COMMERCIAL CHEMICAL SUBSTANCES
(EINECS)
EUROPE EUROPEAN LIST OF NOTIFIED CHEMICAL NO
SUBSTANCES (ELINCS)
JAPAN INVENTORY OF EXISTING AND NEW NO
CHEMICAL SUBSTANCES (ENCS)
KOREA EXISTING CHEMICALS LIST (ECL) YES
NEW ZEALAND NEW ZEALAND INVENTORY YES
PHILIPPINES PHILIPPINE INVENTORY OF CHEMICALS AND YES
CHEMICAL SUBSTANCES (PICCS)
UNITED STATES & TOXIC SUBSTANCES CONTROL ACT (TSCA) YES
PUERTO RICO INVENTORY
*A "YES" INDICATES THAT ALL COMPONENTS OF THIS PRODUCT COMPLY WITH THE
INVENTORY REQUIREMENTS ADMINISTERED BY THE GOVERNING COUNTRY(S)
A "NO" INDICATES THAT ONE OR MORE COMPONENTS OF THE PRODUCT ARE NOT LISTED
OR EXEMPT FROM LISTING ON THE INVENTORY ADMINISTERED BY THE GOVERNING
COUNTRY(S).
| 16. OTHER INFORMATION, INCLUDING DATE OF PREPARATION | |
OR LAST REVISION
ISSUE DATE: 12-26-2013
REVISION DATE: 03-30-2015
PREPARED BY: ALLISON CHO
VERSION #: 02
FURTHER INFORMATION: CRC # 572B-E
HMIS(R*) RATINGS:
HEALTH 2*
FLAMMABILITY 4
PHYSICAL HAZARD 0
PERSONAL PROTECTION B
NFPA RATINGS:
HEALTH 2
FLAMMABILITY 4
INSTABILITY 0
NFPA RATINGS:
2
4
0
DISCLAIMER:
THE INFORMATION CONTAINED IN THIS DOCUMENT APPLIES TO THIS SPECIFIC
MATERIAL AS SUPPLIED. IT MAY NOT BE VALID FOR THIS MATERIAL IF IT IS USED
IN COMBINATION WITH ANY OTHER MATERIALS. THIS INFORMATION IS ACCURATE TO
THE BEST OF CRC INDUSTRIES' KNOWLEDGE OR OBTAINED FROM SOURCES BELIEVED BY
CRC TO BE ACCURATE. BEFORE USING ANY PRODUCT, READ ALL WARNINGS AND
DIRECTIONS ON THE LABEL. FOR FURTHER CLARIFICATION OF ANY INFORMATION
CONTAINED ON THIS (M)SDS CONSULT YOUR SUPERVISOR, A HEALTH & SAFETY
PROFESSIONAL, OR CRC INDUSTRIES.
MATERIAL NAME: CHAIN AND WIRE ROPE LUBRICANT
SDS: US