| Common Name: | DRY MOLY LUBE 03084 |
| Manufacturer: | CRC |
| SDS Revision Date: | 2/26/2015 |
| SDS Format: | GHS-US |
| Item Number(s): | 2F138 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
CRC(R*)
SAFETY DATA SHEET
| 1. IDENTIFICATION |  |
PRODUCT IDENTIFIER: DRY MOLY LUBE
OTHER MEANS OF IDENTIFICATION:
PRODUCT CODE: 03084
RECOMMENDED USE: DRY FILM LUBRICANT
RECOMMENDED RESTRICTIONS: NONE KNOWN.
MANUFACTURER/IMPORTER/SUPPLIER/DISTRIBUTOR INFORMATION:
MANUFACTURED OR SOLD BY:
COMPANY NAME: CRC INDUSTRIES, INC.
ADDRESS:
885 LOUIS DR.
WARMINSTER, PA 18974
US
TELEPHONE:
GENERAL INFORMATION: 215-674-4300
TECHNICAL ASSISTANCE: 800-521-3168
CUSTOMER SERVICE: 800-272-4620
24-HOUR EMERGENCY (CHEMTREC):
800-424-9300 (US)
703-527-3887 (INTERNATIONAL)
WEBSITE: WWW.CRCINDUSTRIES.COM
| 2. HAZARD(S) IDENTIFICATION | |
PHYSICAL HAZARDS:
FLAMMABLE AEROSOLS: CATEGORY 1
GASES UNDER PRESSURE: LIQUEFIED GAS
HEALTH HAZARDS:
SERIOUS EYE DAMAGE/EYE IRRITATION: CATEGORY 2
REPRODUCTIVE TOXICITY (THE UNBORN CHILD): CATEGORY 2
SPECIFIC TARGET ORGAN TOXICITY, SINGLE EXPOSURE:
CATEGORY 3 RESPIRATORY TRACT IRRITATION
SPECIFIC TARGET ORGAN TOXICITY, SINGLE EXPOSURE:
CATEGORY 3 NARCOTIC EFFECTS
SPECIFIC TARGET ORGAN TOXICITY, REPEATED EXPOSURE: CATEGORY 2
ASPIRATION HAZARD: CATEGORY 1
ENVIRONMENTAL HAZARDS:
HAZARDOUS TO THE AQUATIC ENVIRONMENT, ACUTE HAZARD: CATEGORY 3
HAZARDOUS TO THE AQUATIC ENVIRONMENT, LONG-TERM HAZARD: CATEGORY 3
OSHA DEFINED HAZARDS: NOT CLASSIFIED.
LABEL ELEMENTS:
FLAME
GAS CYLINDER
HEALTH HAZARD
EXCLAMATION MARK
SIGNAL WORD: DANGER
HAZARD STATEMENT:
EXTREMELY FLAMMABLE AEROSOL.
PRESSURIZED CONTAINER:
MAY BURST IF HEATED. CONTAINS GAS UNDER PRESSURE; MAY EXPLODE IF HEATED.
MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS. CAUSES SERIOUS EYE
IRRITATION. MAY CAUSE RESPIRATORY IRRITATION. MAY CAUSE DROWSINESS OR
DIZZINESS. SUSPECTED OF DAMAGING THE UNBORN CHILD. MAY CAUSE DAMAGE TO
ORGANS (BRAIN, NERVOUS SYSTEM) THROUGH PROLONGED OR REPEATED EXPOSURE.
HARMFUL TO AQUATIC LIFE. HARMFUL TO AQUATIC LIFE WITH LONG LASTING EFFECTS.
PRECAUTIONARY STATEMENT:
PREVENTION:
OBTAIN SPECIAL INSTRUCTIONS BEFORE USE. DO NOT HANDLE UNTIL ALL SAFETY
PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD. KEEP AWAY FROM HEAT/SPARKS/OPEN
FLAMES/HOT SURFACES. - NO SMOKING. DO NOT SPRAY ON AN OPEN FLAME OR OTHER
IGNITION SOURCE. DO NOT APPLY WHILE EQUIPMENT IS ENERGIZED. DO NOT PIERCE
OR BURN, EVEN AFTER USE. EXTINGUISH ALL FLAMES, PILOT LIGHTS AND HEATERS.
VAPORS WILL ACCUMULATE READILY AND MAY IGNITE. USE ONLY WITH ADEQUATE
VENTILATION; MAINTAIN VENTILATION DURING USE AND UNTIL ALL VAPORS ARE GONE.
OPEN DOORS AND WINDOWS OR USE OTHER MEANS TO ENSURE A FRESH AIR SUPPLY
DURING USE AND WHILE PRODUCT IS DRYING. IF YOU EXPERIENCE ANY SYMPTOMS
LISTED ON THIS LABEL, INCREASE VENTILATION OR LEAVE THE AREA. DO NOT
BREATHE GAS. DO NOT BREATHE MIST OR VAPOR. WASH THOROUGHLY AFTER HANDLING.
WEAR PROTECTIVE GLOVES/PROTECTIVE CLOTHING/EYE PROTECTION/FACE PROTECTION.
AVOID RELEASE TO THE ENVIRONMENT.
RESPONSE:
IF SWALLOWED:
IMMEDIATELY CALL A POISON CENTER/DOCTOR. DO NOT INDUCE VOMITING.
IF INHALED:
REMOVE PERSON TO FRESH AIR AND KEEP COMFORTABLE FOR BREATHING. CALL A
POISON CENTER/DOCTOR IF YOU FEEL UNWELL.
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES,
IF PRESENT AND EASY TO DO. CONTINUE RINSING.
IF EYE IRRITATION PERSISTS: GET MEDICAL ATTENTION.
IF EXPOSED OR CONCERNED:
GET MEDICAL ATTENTION. CALL A POISON CENTER OR DOCTOR/PHYSICIAN IF YOU
FEEL UNWELL.
STORAGE:
STORE IN A WELL-VENTILATED PLACE. STORE LOCKED UP. PROTECT FROM SUNLIGHT.
DO NOT EXPOSE TO TEMPERATURES EXCEEDING 50 DEG. C/122 DEG. F. EXPOSURE TO
HIGH TEMPERATURE MAY CAUSE CAN TO BURST.
DISPOSAL:
DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH LOCAL/REGIONAL/NATIONAL
REGULATIONS.
HAZARD(S) NOT OTHERWISE CLASSIFIED (HNOC): NONE KNOWN.
| 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
MIXTURES:
CHEMICAL NAME COMMON NAME AND SYNONYMS CAS NUMBER %
ACETONE 67-64-1 30 - 40
ISOPROPYL ALCOHOL 67-63-0 20 - 30
N-BUTANE 106-97-8 20 - 30
PROPANE 74-98-6 5 - 10
HEPTANE, BRANCHED, 426260-76-6 3 - 5
CYCLIC AND LINEAR
MOLYBDENUM DISULPHIDE 1317-33-5 1 - 3
N-HEPTANE 142-82-5 1 - 3
SOLVENT NAPHTHA 64742-88-7 1 - 3
(PETROLEUM),
MEDIUM ALIPH.
SPECIFIC CHEMICAL IDENTITY AND/OR PERCENTAGE OF COMPOSITION HAS BEEN
WITHHELD AS A TRADE SECRET.
| 4. FIRST-AID MEASURES | |
INHALATION:
REMOVE VICTIM TO FRESH AIR AND KEEP AT REST IN A POSITION COMFORTABLE FOR
BREATHING. CALL A POISON CENTER OR DOCTOR/PHYSICIAN IF YOU FEEL UNWELL.
SKIN CONTACT:
RINSE SKIN WITH WATER/SHOWER. GET MEDICAL ATTENTION IF IRRITATION DEVELOPS
AND PERSISTS.
EYE CONTACT:
IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES. REMOVE
CONTACT LENSES, IF PRESENT AND EASY TO DO. CONTINUE RINSING. GET MEDICAL
ATTENTION IF IRRITATION DEVELOPS AND PERSISTS.
INGESTION:
CALL A PHYSICIAN OR POISON CONTROL CENTER IMMEDIATELY. RINSE MOUTH. DO NOT
INDUCE VOMITING. IF VOMITING OCCURS, KEEP HEAD LOW SO THAT STOMACH CONTENT
DOESN'T GET INTO THE LUNGS.
MOST IMPORTANT SYMPTOMS/EFFECTS, ACUTE AND DELAYED:
MAY CAUSE DROWSINESS AND DIZZINESS. HEADACHE. NAUSEA, VOMITING. IRRITATION
OF NOSE AND THROAT. ASPIRATION MAY CAUSE PULMONARY EDEMA AND PNEUMONITIS.
SEVERE EYE IRRITATION. SYMPTOMS MAY INCLUDE STINGING, TEARING, REDNESS,
SWELLING, AND BLURRED VISION. MAY CAUSE RESPIRATORY IRRITATION. PROLONGED
EXPOSURE MAY CAUSE CHRONIC EFFECTS.
INDICATION OF IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED:
PROVIDE GENERAL SUPPORTIVE MEASURES AND TREAT SYMPTOMATICALLY. KEEP VICTIM
UNDER OBSERVATION. SYMPTOMS MAY BE DELAYED.
GENERAL INFORMATION:
IF EXPOSED OR CONCERNED:
GET MEDICAL ADVICE/ATTENTION. ENSURE THAT MEDICAL PERSONNEL ARE AWARE OF
THE MATERIAL(S) INVOLVED, AND TAKE PRECAUTIONS TO PROTECT THEMSELVES. SHOW
THIS SAFETY DATA SHEET TO THE DOCTOR IN ATTENDANCE.
| 5. FIRE-FIGHTING MEASURES | |
SUITABLE EXTINGUISHING MEDIA:
ALCOHOL RESISTANT FOAM. WATER FOG. DRY CHEMICAL POWDER. CARBON DIOXIDE
(CO2).
UNSUITABLE EXTINGUISHING MEDIA: NONE KNOWN.
SPECIFIC HAZARDS ARISING FROM THE CHEMICAL:
CONTENTS UNDER PRESSURE. PRESSURIZED CONTAINER MAY RUPTURE WHEN EXPOSED
TO HEAT OR FLAME. DURING FIRE, GASES HAZARDOUS TO HEALTH MAY BE FORMED.
SPECIAL PROTECTIVE EQUIPMENT AND PRECAUTIONS FOR FIREFIGHTERS:
FIREFIGHTERS MUST USE STANDARD PROTECTIVE EQUIPMENT INCLUDING FLAME
RETARDANT COAT, HELMET WITH FACE SHIELD, GLOVES, RUBBER BOOTS, AND IN
ENCLOSED SPACES, SCBA.
FIRE-FIGHTING EQUIPMENT/INSTRUCTIONS:
IN CASE OF FIRE:
STOP LEAK IF SAFE TO DO SO. MOVE CONTAINERS FROM FIRE AREA IF YOU CAN DO
SO WITHOUT RISK. CONTAINERS SHOULD BE COOLED WITH WATER TO PREVENT VAPOR
PRESSURE BUILD UP.
GENERAL FIRE HAZARDS:
EXTREMELY FLAMMABLE AEROSOL. CONTENTS UNDER PRESSURE. PRESSURIZED CONTAINER
MAY RUPTURE WHEN EXPOSED TO HEAT OR FLAME.
| 6. ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
KEEP UNNECESSARY PERSONNEL AWAY. KEEP PEOPLE AWAY FROM AND UPWIND OF
SPILL/LEAK. KEEP OUT OF LOW AREAS. MANY GASES ARE HEAVIER THAN AIR AND
WILL SPREAD ALONG GROUND AND COLLECT IN LOW OR CONFINED AREAS (SEWERS,
BASEMENTS, TANKS). WEAR APPROPRIATE PROTECTIVE EQUIPMENT AND CLOTHING
DURING CLEAN-UP. DO NOT BREATHE MIST OR VAPOR. DO NOT BREATHE GAS.
EMERGENCY PERSONNEL NEED SELF-CONTAINED BREATHING EQUIPMENT. DO NOT TOUCH
DAMAGED CONTAINERS OR SPILLED MATERIAL UNLESS WEARING APPROPRIATE
PROTECTIVE CLOTHING. VENTILATE CLOSED SPACES BEFORE ENTERING THEM. LOCAL
AUTHORITIES SHOULD BE ADVISED IF SIGNIFICANT SPILLAGES CANNOT BE CONTAINED.
FOR PERSONAL PROTECTION, SEE SECTION 8 OF THE SDS.
METHODS AND MATERIALS FOR CONTAINMENT AND CLEANING UP:
ELIMINATE ALL IGNITION SOURCES (NO SMOKING, FLARES, SPARKS, OR FLAMES IN
IMMEDIATE AREA). KEEP COMBUSTIBLES (WOOD, PAPER, OIL, ETC.) AWAY FROM
SPILLED MATERIAL. STOP THE FLOW OF MATERIAL, IF THIS IS WITHOUT RISK. WIPE
UP WITH ABSORBENT MATERIAL (E.G. CLOTH, FLEECE). CLEAN SURFACE THOROUGHLY
TO REMOVE RESIDUAL CONTAMINATION. FOR WASTE DISPOSAL, SEE SECTION 13 OF THE
SDS. PREVENT ENTRY INTO WATERWAYS, SEWER, BASEMENTS OR CONFINED AREAS.
ENVIRONMENTAL PRECAUTIONS:
AVOID RELEASE TO THE ENVIRONMENT. PREVENT FURTHER LEAKAGE OR SPILLAGE IF
SAFE TO DO SO. AVOID DISCHARGE INTO DRAINS, WATER COURSES OR ONTO THE
GROUND. INFORM APPROPRIATE MANAGERIAL OR SUPERVISORY PERSONNEL OF ALL
ENVIRONMENTAL RELEASES.
| 7. HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING:
OBTAIN SPECIAL INSTRUCTIONS BEFORE USE. DO NOT HANDLE UNTIL ALL SAFETY
PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD.
PRESSURIZED CONTAINER:
DO NOT PIERCE OR BURN, EVEN AFTER USE. DO NOT USE IF SPRAY BUTTON IS
MISSING OR DEFECTIVE. DO NOT SPRAY ON A NAKED FLAME OR ANY OTHER
INCANDESCENT MATERIAL. DO NOT SMOKE WHILE USING OR UNTIL SPRAYED SURFACE
IS THOROUGHLY DRY. DO NOT CUT, WELD, SOLDER, DRILL, GRIND, OR EXPOSE
CONTAINERS TO HEAT, FLAME, SPARKS, OR OTHER SOURCES OF IGNITION. USE
CAUTION AROUND ENERGIZED EQUIPMENT. THE METAL CONTAINER WILL CONDUCT
ELECTRICITY IF IT CONTACTS A LIVE SOURCE. THIS MAY RESULT IN INJURY TO THE
USER FROM ELECTRICAL SHOCK AND/OR FLASH FIRE. DO NOT BREATHE MIST OR VAPOR.
DO NOT BREATHE GAS. AVOID CONTACT WITH EYES. AVOID PROLONGED EXPOSURE.
PREGNANT OR BREASTFEEDING WOMEN MUST NOT HANDLE THIS PRODUCT. SHOULD BE
HANDLED IN CLOSED SYSTEMS, IF POSSIBLE. USE ONLY IN WELL-VENTILATED AREAS.
WEAR APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT. WASH HANDS THOROUGHLY AFTER
HANDLING. AVOID RELEASE TO THE ENVIRONMENT. OBSERVE GOOD INDUSTRIAL
HYGIENE PRACTICES. FOR PRODUCT USAGE INSTRUCTIONS, PLEASE SEE THE PRODUCT
LABEL.
CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES:
LEVEL 3 AEROSOL.
PRESSURIZED CONTAINER. PROTECT FROM SUNLIGHT AND DO NOT EXPOSE TO
TEMPERATURES EXCEEDING 50 DEG. C/122 DEG. F. DO NOT PUNCTURE, INCINERATE OR
CRUSH. DO NOT HANDLE OR STORE NEAR AN OPEN FLAME, HEAT OR OTHER SOURCES OF
IGNITION. THIS MATERIAL CAN ACCUMULATE STATIC CHARGE WHICH MAY CAUSE SPARK
AND BECOME AN IGNITION SOURCE. STORE IN A WELL-VENTILATED PLACE. STORE AWAY
FROM INCOMPATIBLE MATERIALS (SEE SECTION 10 OF THE SDS).
| 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
OCCUPATIONAL EXPOSURE LIMITS:
US. OSHA TABLE Z-1 LIMITS FOR AIR CONTAMINANTS (29 CFR 1910.1000):
COMPONENTS TYPE VALUE FORM
ACETONE (CAS 67-64-1) PEL 2400 MG/M3
1000 PPM
ISOPROPYL ALCOHOL PEL 980 MG/M3
(CAS 67-63-0) 400 PPM
MOLYBDENUM DISULPHIDE PEL 15 MG/M3 TOTAL DUST.
(CAS 1317-33-5)
N-HEPTANE PEL 2000 MG/M3
(CAS 142-82-5) 500 PPM
PROPANE (CAS 74-98-6) PEL 1800 MG/M3
1000 PPM
US. OSHA TABLE Z-2 (29 CFR 1910.1000):
COMPONENTS TYPE VALUE
TOLUENE (CAS 108-88-3) CEILING 300 PPM
TWA 200 PPM
US. ACGIH THRESHOLD LIMIT VALUES:
COMPONENTS TYPE VALUE FORM
ACETONE (CAS 67-64-1) STEL 750 PPM
TWA 500 PPM
ISOPROPYL ALCOHOL STEL 400 PPM
(CAS 67-63-0) TWA 200 PPM
MOLYBDENUM DISULPHIDE TWA 3 MG/M3 RESPIRABLE FRACTION.
(CAS 1317-33-5) 10 MG/M3 INHALABLE FRACTION.
N-BUTANE STEL 1000 PPM
(CAS 106-97-8)
N-HEPTANE STEL 500 PPM
(CAS 142-82-5) TWA 400 PPM
SOLVENT NAPHTHA TWA 200 MG/M3 NON-AEROSOL.
(PETROLEUM),
MEDIUM ALIPH.
(CAS 64742-88-7)
TOLUENE (CAS 108-88-3) TWA 20 PPM
US. NIOSH: POCKET GUIDE TO CHEMICAL HAZARDS
COMPONENTS TYPE VALUE
ACETONE (CAS 67-64-1) TWA 590 MG/M3
250 PPM
ISOPROPYL ALCOHOL STEL 1225 MG/M3
(CAS 67-63-0) 500 PPM
TWA 980 MG/M3
400 PPM
N-BUTANE TWA 1900 MG/M3
(CAS 106-97-8) 800 PPM
N-HEPTANE CEILING 1800 MG/M3
(CAS 142-82-5) 440 PPM
TWA 350 MG/M3
85 PPM
PROPANE (CAS 74-98-6) TWA 1800 MG/M3
1000 PPM
SOLVENT NAPHTHA TWA 100 MG/M3
(PETROLEUM),
MEDIUM ALIPH.
(CAS 64742-88-7)
TOLUENE (CAS 108-88-3) STEL 560 MG/M3
150 PPM
TWA 375 MG/M3
100 PPM
BIOLOGICAL LIMIT VALUES:
ACGIH BIOLOGICAL EXPOSURE INDICES:
COMPONENTS VALUE DETERMINANT SPECIMEN SAMPLING TIME
ACETONE 50 MG/L ACETONE URINE *
(CAS 67-64-1)
ISOPROPYL 40 MG/L ACETONE URINE *
ALCOHOL
(CAS 67-63-0)
TOLUENE 0.3 MG/G O-CRESOL, WITH CREATININE IN *
(CAS 108-88-3) HYDROLYSIS URINE
0.03 MG/L TOLUENE URINE *
0.02 MG/L TOLUENE BLOOD *
* - FOR SAMPLING DETAILS, PLEASE SEE THE SOURCE DOCUMENT.
EXPOSURE GUIDELINES:
US - CALIFORNIA OELS SKIN DESIGNATION
TOLUENE (CAS 108-88-3) CAN BE ABSORBED THROUGH THE SKIN.
US - MINNESOTA HAZ SUBS SKIN DESIGNATION APPLIES
TOLUENE (CAS 108-88-3) SKIN DESIGNATION APPLIES.
US ACGIH THRESHOLD LIMIT VALUES SKIN DESIGNATION
SOLVENT NAPHTHA (PETROLEUM), CAN BE ABSORBED THROUGH THE SKIN.
MEDIUM ALIPH. (CAS 64742-88-7)
APPROPRIATE ENGINEERING CONTROLS:
GOOD GENERAL VENTILATION (TYPICALLY 10 AIR CHANGES PER HOUR) SHOULD BE
USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS. IF APPLICABLE,
USE PROCESS ENCLOSURES, LOCAL EXHAUST VENTILATION, OR OTHER ENGINEERING
CONTROLS TO MAINTAIN AIRBORNE LEVELS BELOW RECOMMENDED EXPOSURE LIMITS.
IF EXPOSURE LIMITS HAVE NOT BEEN ESTABLISHED, MAINTAIN AIRBORNE LEVELS
TO AN ACCEPTABLE LEVEL. PROVIDE EYEWASH STATION.
INDIVIDUAL PROTECTION MEASURES, SUCH AS PERSONAL PROTECTIVE EQUIPMENT:
EYE/FACE PROTECTION: WEAR SAFETY GLASSES WITH SIDE SHIELDS (OR GOGGLES).
SKIN PROTECTION:
HAND PROTECTION:
WEAR PROTECTIVE GLOVES SUCH AS: NITRILE. NEOPRENE.
OTHER:
WEAR SUITABLE PROTECTIVE CLOTHING. USE OF AN IMPERVIOUS APRON IS
RECOMMENDED.
RESPIRATORY PROTECTION:
IF ENGINEERING CONTROLS ARE NOT FEASIBLE OR IF EXPOSURE EXCEEDS THE
APPLICABLE EXPOSURE LIMITS, USE A NIOSH-APPROVED CARTRIDGE RESPIRATOR WITH
AN ORGANIC VAPOR CARTRIDGE. USE A SELF-CONTAINED BREATHING APPARATUS IN
CONFINED SPACES AND FOR EMERGENCIES. AIR MONITORING IS NEEDED TO DETERMINE
ACTUAL EMPLOYEE EXPOSURE LEVELS.
THERMAL HAZARDS:
WEAR APPROPRIATE THERMAL PROTECTIVE CLOTHING, WHEN NECESSARY.
GENERAL HYGIENE CONSIDERATIONS:
WHEN USING, DO NOT EAT, DRINK OR SMOKE. ALWAYS OBSERVE GOOD PERSONAL
HYGIENE MEASURES, SUCH AS WASHING AFTER HANDLING THE MATERIAL AND BEFORE
EATING, DRINKING, AND/OR SMOKING. ROUTINELY WASH WORK CLOTHING AND
PROTECTIVE EQUIPMENT TO REMOVE CONTAMINANTS.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE:
PHYSICAL STATE: LIQUID.
FORM: AEROSOL.
COLOR: GRAY.
ODOR: SOLVENT.
ODOR THRESHOLD: NOT AVAILABLE.
PH: NOT AVAILABLE.
MELTING POINT/FREEZING POINT: NOT AVAILABLE.
INITIAL BOILING POINT AND BOILING RANGE:
<395 DEG. F (<201.7 DEG. C)
FLASH POINT: <0 DEG. F (<-17.8 DEG. C) TAG CLOSED CUP
EVAPORATION RATE: NOT AVAILABLE.
FLAMMABILITY (SOLID, GAS): NOT AVAILABLE.
UPPER/LOWER FLAMMABILITY OR EXPLOSIVE LIMITS:
FLAMMABILITY LIMIT - LOWER (%): 1%
FLAMMABILITY LIMIT - UPPER (%): 12.8%
VAPOR PRESSURE: 1494.5 HPA ESTIMATED
VAPOR DENSITY: >1 (AIR = 1)
RELATIVE DENSITY: 0.71
SOLUBILITY (WATER): NOT AVAILABLE.
PARTITION COEFFICIENT (N-OCTANOL/WATER): NOT AVAILABLE.
AUTO-IGNITION TEMPERATURE: 410 DEG. F (210 DEG. C) ESTIMATED
DECOMPOSITION TEMPERATURE: NOT AVAILABLE.
VISCOSITY (KINEMATIC): NOT AVAILABLE.
PERCENT VOLATILE: 98%
| 10. STABILITY AND REACTIVITY | |
REACTIVITY:
THE PRODUCT IS STABLE AND NON-REACTIVE UNDER NORMAL CONDITIONS OF USE,
STORAGE AND TRANSPORT.
CHEMICAL STABILITY: MATERIAL IS STABLE UNDER NORMAL CONDITIONS.
POSSIBILITY OF HAZARDOUS REACTIONS:
NO DANGEROUS REACTION KNOWN UNDER CONDITIONS OF NORMAL USE.
CONDITIONS TO AVOID:
HEAT, FLAMES AND SPARKS. CONTACT WITH INCOMPATIBLE MATERIALS.
INCOMPATIBLE MATERIALS:
ACIDS. STRONG OXIDIZING AGENTS. NITRATES. ISOCYANATES. FLUORINE. CHLORINE.
HAZARDOUS DECOMPOSITION PRODUCTS: CARBON OXIDES.
| 11. TOXICOLOGICAL INFORMATION | |
INFORMATION ON LIKELY ROUTES OF EXPOSURE:
INGESTION:
DROPLETS OF THE PRODUCT ASPIRATED INTO THE LUNGS THROUGH INGESTION OR
VOMITING MAY CAUSE A SERIOUS CHEMICAL PNEUMONIA.
INHALATION:
MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE BY
INHALATION. MAY CAUSE DROWSINESS AND DIZZINESS. HEADACHE. NAUSEA, VOMITING.
MAY CAUSE IRRITATION TO THE RESPIRATORY SYSTEM. PROLONGED INHALATION MAY BE
HARMFUL.
SKIN CONTACT: PROLONGED SKIN CONTACT MAY CAUSE TEMPORARY IRRITATION.
EYE CONTACT: CAUSES SERIOUS EYE IRRITATION.
SYMPTOMS RELATED TO THE PHYSICAL, CHEMICAL AND TOXICOLOGICAL
CHARACTERISTICS:
MAY CAUSE DROWSINESS AND DIZZINESS. HEADACHE. NAUSEA, VOMITING. IRRITATION
OF NOSE AND THROAT. ASPIRATION MAY CAUSE PULMONARY EDEMA AND PNEUMONITIS.
SEVERE EYE IRRITATION. SYMPTOMS MAY INCLUDE STINGING, TEARING, REDNESS,
SWELLING, AND BLURRED VISION. MAY CAUSE RESPIRATORY IRRITATION.
INFORMATION ON TOXICOLOGICAL EFFECTS:
ACUTE TOXICITY:
MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS. NARCOTIC EFFECTS. MAY CAUSE
RESPIRATORY IRRITATION.
PRODUCT SPECIES TEST RESULTS
DRY MOLY LUBE:
ACUTE:
DERMAL:
LD50 RABBIT 9027.8184 MG/KG ESTIMATED
INHALATION:
LC50 RAT 25927.2324 PPM, 4 HOURS ESTIMATED
1108.0551 MG/L, 4 HOURS ESTIMATED
ORAL:
LD50 RAT 8209.0645 MG/KG ESTIMATED
* ESTIMATES FOR PRODUCT MAY BE BASED ON ADDITIONAL COMPONENT DATA NOT
SHOWN.
SKIN CORROSION/IRRITATION:
PROLONGED SKIN CONTACT MAY CAUSE TEMPORARY IRRITATION.
SERIOUS EYE DAMAGE/EYE IRRITATION: CAUSES SERIOUS EYE IRRITATION.
RESPIRATORY SENSITIZATION: NOT AVAILABLE.
SKIN SENSITIZATION:
THIS PRODUCT IS NOT EXPECTED TO CAUSE SKIN SENSITIZATION.
GERM CELL MUTAGENICITY:
NO DATA AVAILABLE TO INDICATE PRODUCT OR ANY COMPONENTS PRESENT AT GREATER
THAN 0.1% ARE MUTAGENIC OR GENOTOXIC.
CARCINOGENICITY:
THIS PRODUCT IS NOT CONSIDERED TO BE A CARCINOGEN BY IARC, ACGIH, NTP, OR
OSHA.
REPRODUCTIVE TOXICITY: SUSPECTED OF DAMAGING THE UNBORN CHILD.
SPECIFIC TARGET ORGAN TOXICITY - SINGLE EXPOSURE:
MAY CAUSE RESPIRATORY IRRITATION. MAY CAUSE DROWSINESS AND DIZZINESS.
SPECIFIC TARGET ORGAN TOXICITY - REPEATED EXPOSURE:
MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE:
BRAIN. NERVOUS SYSTEM.
ASPIRATION HAZARD:
MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS. IF ASPIRATED INTO LUNGS
DURING SWALLOWING OR VOMITING, MAY CAUSE CHEMICAL PNEUMONIA, PULMONARY
INJURY OR DEATH.
CHRONIC EFFECTS:
PROLONGED INHALATION MAY BE HARMFUL. MAY CAUSE DAMAGE TO ORGANS THROUGH
PROLONGED OR REPEATED EXPOSURE.
| 12. ECOLOGICAL INFORMATION | |
ECOTOXICITY: HARMFUL TO AQUATIC LIFE WITH LONG LASTING EFFECTS.
PRODUCT SPECIES TEST RESULTS
DRY MOLY LUBE:
AQUATIC:
CRUSTACEA EC50 DAPHNIA 3794.1357 MG/L, 48 HOURS
ESTIMATED
ACUTE:
FISH LC50 FISH 91.3044 MG/L, 96 HOURS
ESTIMATED
COMPONENTS SPECIES TEST RESULTS
ACETONE (CAS 67-64-1):
AQUATIC:
CRUSTACEA EC50 WATER FLEA (DAPHNIA 21.6 - 23.9 MG/L,
MAGNA) 48 HOURS
FISH LC50 RAINBOW TROUT, 4740 - 6330 MG/L,
DONALDSON TROUT 96 HOURS
(ONCORHYNCHUS MYKISS)
ISOPROPYL ALCOHOL (CAS 67-63-0):
AQUATIC:
FISH LC50 BLUEGILL (LEPOMIS >1400 MG/L, 96 HOURS
MACROCHIRUS)
N-HEPTANE (CAS 142-82-5):
AQUATIC:
ACUTE:
FISH LC50 FATHEAD MINNOW 2.1 - 2.98 MG/L,
(PIMEPHALES PROMELAS) 96 HOURS
* ESTIMATES FOR PRODUCT MAY BE BASED ON ADDITIONAL COMPONENT DATA NOT
SHOWN.
PERSISTENCE AND DEGRADABILITY:
NO DATA IS AVAILABLE ON THE DEGRADABILITY OF THIS PRODUCT.
BIOACCUMULATIVE POTENTIAL: NO DATA AVAILABLE.
PARTITION COEFFICIENT N-OCTANOL / WATER (LOG KOW):
ACETONE: -0.24
ISOPROPYL ALCOHOL: 0.05
N-BUTANE: 2.89
N-HEPTANE: 4.66
PROPANE: 2.36
MOBILITY IN SOIL: NO DATA AVAILABLE.
OTHER ADVERSE EFFECTS:
NO OTHER ADVERSE ENVIRONMENTAL EFFECTS (E.G. OZONE DEPLETION, PHOTOCHEMICAL
OZONE CREATION POTENTIAL, ENDOCRINE DISRUPTION, GLOBAL WARMING POTENTIAL)
ARE EXPECTED FROM THIS COMPONENT.
| 13. DISPOSAL CONSIDERATIONS | |
DISPOSAL OF WASTE FROM RESIDUES / UNUSED PRODUCTS:
IF DISCARDED, THIS PRODUCT IS CONSIDERED A RCRA IGNITABLE WASTE, D001.
COLLECT AND RECLAIM OR DISPOSE IN SEALED CONTAINERS AT LICENSED WASTE
DISPOSAL SITE. CONTENTS UNDER PRESSURE. DO NOT PUNCTURE, INCINERATE OR
CRUSH. DO NOT ALLOW THIS MATERIAL TO DRAIN INTO SEWERS/WATER SUPPLIES.
DO NOT CONTAMINATE PONDS, WATERWAYS OR DITCHES WITH CHEMICAL OR USED
CONTAINER. DISPOSE IN ACCORDANCE WITH ALL APPLICABLE REGULATIONS.
HAZARDOUS WASTE CODE:
D001: WASTE FLAMMABLE MATERIAL WITH A FLASH POINT <140 F
CONTAMINATED PACKAGING:
EMPTY CONTAINERS SHOULD BE TAKEN TO AN APPROVED WASTE HANDLING SITE FOR
RECYCLING OR DISPOSAL. SINCE EMPTIED CONTAINERS MAY RETAIN PRODUCT RESIDUE,
FOLLOW LABEL WARNINGS EVEN AFTER CONTAINER IS EMPTIED.
| 14. TRANSPORT INFORMATION | |
DOT:
UN NUMBER: UN1950
UN PROPER SHIPPING NAME: AEROSOLS, FLAMMABLE, LIMITED QUANTITY
TRANSPORT HAZARD CLASS(ES):
CLASS: 2.1
SUBSIDIARY RISK:
LABEL(S): 2.1
PACKING GROUP: NOT APPLICABLE.
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
SPECIAL PROVISIONS: N82
PACKAGING EXCEPTIONS: 306
PACKAGING NON BULK: NONE
PACKAGING BULK: NONE
IATA:
UN NUMBER: UN1950
UN PROPER SHIPPING NAME: AEROSOLS, FLAMMABLE, LIMITED QUANTITY
TRANSPORT HAZARD CLASS(ES):
CLASS: 2.1
SUBSIDIARY RISK:
PACKING GROUP: NOT APPLICABLE.
ENVIRONMENTAL HAZARDS: YES
ERG CODE: 10L
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
OTHER INFORMATION:
PASSENGER AND CARGO AIRCRAFT: ALLOWED.
CARGO AIRCRAFT ONLY: ALLOWED.
IMDG:
UN NUMBER: UN1950
UN PROPER SHIPPING NAME: AEROSOLS, LIMITED QUANTITY, MARINE POLLUTANT
TRANSPORT HAZARD CLASS(ES):
CLASS: 2
SUBSIDIARY RISK:
PACKING GROUP: NOT APPLICABLE.
ENVIRONMENTAL HAZARDS:
MARINE POLLUTANT: YES
EMS: F-D, S-U
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
| 15. REGULATORY INFORMATION | |
US FEDERAL REGULATIONS:
THIS PRODUCT IS A "HAZARDOUS CHEMICAL" AS DEFINED BY THE OSHA HAZARD
COMMUNICATION STANDARD, 29 CFR 1910.1200.
ALL COMPONENTS ARE ON THE U.S. EPA TSCA INVENTORY LIST.
TSCA SECTION 12(B) EXPORT NOTIFICATION (40 CFR 707, SUBPT. D):
NOT REGULATED.
SARA 304 EMERGENCY RELEASE NOTIFICATION: NOT REGULATED.
US. OSHA SPECIFICALLY REGULATED SUBSTANCES (29 CFR 1910.1001-1050):
NOT LISTED.
US EPCRA (SARA TITLE III) SECTION 313 - LISTED SUBSTANCE
TOXIC CHEMICAL
NOT LISTED.
CERCLA HAZARDOUS SUBSTANCE LIST (40 CFR 302.4):
ACETONE (CAS 67-64-1)
ISOPROPYL ALCOHOL (CAS 67-63-0)
TOLUENE (CAS 108-88-3)
CERCLA HAZARDOUS SUBSTANCES REPORTABLE QUANTITY
ACETONE (CAS 67-64-1) 5000 LBS
ISOPROPYL ALCOHOL (CAS 67-63-0) 100 LBS
TOLUENE (CAS 108-88-3) 1000 LBS
SPILLS OR RELEASES RESULTING IN THE LOSS OF ANY INGREDIENT AT OR ABOVE
ITS RQ REQUIRE IMMEDIATE NOTIFICATION TO THE NATIONAL RESPONSE CENTER
(800-424-8802) AND TO YOUR LOCAL EMERGENCY PLANNING COMMITTEE.
CLEAN AIR ACT (CAA) SECTION 112 HAZARDOUS AIR POLLUTANTS (HAPS) LIST:
NOT REGULATED.
CLEAN AIR ACT (CAA) SECTION 112(R) ACCIDENTAL RELEASE PREVENTION (40 CFR
68.130):
N-BUTANE (CAS 106-97-8)
PROPANE (CAS 74-98-6)
SAFE DRINKING WATER ACT (SDWA): NOT REGULATED.
DRUG ENFORCEMENT ADMINISTRATION (DEA). LIST 2, ESSENTIAL CHEMICALS (21 CFR
1310.02(B) AND 1310.04(F)(2) AND CHEMICAL CODE NUMBER:
ACETONE (CAS 67-64-1): 6532
TOLUENE (CAS 108-88-3): 6594
DRUG ENFORCEMENT ADMINISTRATION (DEA). LIST 1 & 2 EXEMPT CHEMICAL MIXTURES
(21 CFR 1310.12(C)):
ACETONE (CAS 67-64-1): 35% WV
TOLUENE (CAS 108-88-3): 35% WV
DEA EXEMPT CHEMICAL MIXTURES CODE NUMBER:
ACETONE (CAS 67-64-1): 6532
TOLUENE (CAS 108-88-3): 594
FOOD AND DRUG ADMINISTRATION (FDA): NOT REGULATED.
SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 (SARA):
SECTION 311/312 HAZARD CATEGORIES:
IMMEDIATE HAZARD: YES
DELAYED HAZARD: YES
FIRE HAZARD: YES
PRESSURE HAZARD: YES
REACTIVITY HAZARD: NO
SARA 302 EXTREMELY HAZARDOUS SUBSTANCE: NO
US STATE REGULATIONS:
US. CALIFORNIA CONTROLLED SUBSTANCES. CA DEPARTMENT OF JUSTICE (CALIFORNIA
HEALTH AND SAFETY CODE SECTION 11100): NOT LISTED.
US. NEW JERSEY WORKER AND COMMUNITY RIGHT-TO-KNOW ACT:
ACETONE (CAS 67-64-1)
N-HEPTANE (CAS 142-82-5)
ISOPROPYL ALCOHOL (CAS 67-63-0)
N-BUTANE (CAS 106-97-8)
PROPANE (CAS 74-98-6)
SOLVENT NAPHTHA (PETROLEUM), MEDIUM ALIPH. (CAS 64742-88-7)
TOLUENE (CAS 108-88-3)
US. MASSACHUSETTS RTK - SUBSTANCE LIST:
ACETONE (CAS 67-64-1)
ISOPROPYL ALCOHOL (CAS 67-63-0)
MOLYBDENUM DISULPHIDE (CAS 1317-33-5)
N-BUTANE (CAS 106-97-8)
N-HEPTANE (CAS 142-82-5)
PROPANE (CAS 74-98-6)
SOLVENT NAPHTHA (PETROLEUM), MEDIUM ALIPH. (CAS 64742-88-7)
US. PENNSYLVANIA WORKER AND COMMUNITY RIGHT-TO-KNOW LAW:
ACETONE (CAS 67-64-1)
ISOPROPYL ALCOHOL (CAS 67-63-0)
TOLUENE (CAS 108-88-3)
N-BUTANE (CAS 106-97-8)
N-HEPTANE (CAS 142-82-5)
PROPANE (CAS 74-98-6)
SOLVENT NAPHTHA (PETROLEUM), MEDIUM ALIPH. (CAS 64742-88-7)
US. RHODE ISLAND RTK:
ACETONE (CAS 67-64-1)
ISOPROPYL ALCOHOL (CAS 67-63-0)
N-BUTANE (CAS 106-97-8)
PROPANE (CAS 74-98-6)
TOLUENE (CAS 108-88-3)
US. CALIFORNIA PROPOSITION 65:
WARNING:
THIS PRODUCT CONTAINS A CHEMICAL KNOWN TO THE STATE OF CALIFORNIA TO CAUSE
CANCER AND BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM.
US - CALIFORNIA PROPOSITION 65 - CRT LISTED DATE/CARCINOGENIC SUBSTANCE
BENZENE (CAS 71-43-2) LISTED: FEBRUARY 27, 1987
ETHANAL (CAS 75-07-0) LISTED: APRIL 1, 1988
US - CALIFORNIA PROPOSITION 65 - CRT LISTED DATE/DEVELOPMENTAL TOXIN
BENZENE (CAS 71-43-2) LISTED: DECEMBER 26, 1997
TOLUENE (CAS 108-88-3) LISTED: JANUARY 1, 1991
US - CALIFORNIA PROPOSITION 65 - CRT LISTED DATE/FEMALE REPRODUCTIVE
TOXIN
TOLUENE (CAS 108-88-3) LISTED: AUGUST 7, 2009
US - CALIFORNIA PROPOSITION 65 - CRT LISTED DATE/MALE REPRODUCTIVE TOXIN
BENZENE (CAS 71-43-2) LISTED: DECEMBER 26, 1997
VOLATILE ORGANIC COMPOUNDS (VOC) REGULATIONS:
EPA:
VOC CONTENT (40 CFR 51.100(S)): 61.8%
CONSUMER PRODUCTS (40 CFR 59, SUBPT. C): NOT REGULATED
STATE:
CONSUMER PRODUCTS:
THIS PRODUCT IS REGULATED AS A DRY LUBRICANT. THIS PRODUCT IS COMPLIANT FOR
USE IN ALL 50 STATES.
VOC CONTENT (CA): 61.8%
VOC CONTENT (OTC): 61.8%
INTERNATIONAL INVENTORIES:
COUNTRY(S) OR REGION INVENTORY NAME ON INVENTORY
(YES/NO)*
AUSTRALIA AUSTRALIAN INVENTORY OF CHEMICAL NO
SUBSTANCES (AICS)
CANADA DOMESTIC SUBSTANCES LIST (DSL) YES
CANADA NON-DOMESTIC SUBSTANCES LIST (NDSL) NO
CHINA INVENTORY OF EXISTING CHEMICAL NO
SUBSTANCES IN CHINA (IECSC)
EUROPE EUROPEAN INVENTORY OF EXISTING NO
COMMERCIAL CHEMICAL SUBSTANCES
(EINECS)
EUROPE EUROPEAN LIST OF NOTIFIED CHEMICAL NO
SUBSTANCES (ELINCS)
JAPAN INVENTORY OF EXISTING AND NEW NO
CHEMICAL SUBSTANCES (ENCS)
KOREA EXISTING CHEMICALS LIST (ECL) NO
NEW ZEALAND NEW ZEALAND INVENTORY NO
PHILIPPINES PHILIPPINE INVENTORY OF CHEMICALS AND YES
CHEMICAL SUBSTANCES (PICCS)
UNITED STATES TOXIC SUBSTANCES CONTROL ACT (TSCA) YES
& PUERTO RICO INVENTORY
*A "YES" INDICATES THAT ALL COMPONENTS OF THIS PRODUCT COMPLY WITH THE
INVENTORY REQUIREMENTS ADMINISTERED BY THE GOVERNING COUNTRY(S)
A "NO" INDICATES THAT ONE OR MORE COMPONENTS OF THE PRODUCT ARE NOT LISTED
OR EXEMPT FROM LISTING ON THE INVENTORY ADMINISTERED BY THE GOVERNING
COUNTRY(S).
| 16. OTHER INFORMATION, INCLUDING DATE OF PREPARATION | |
OR LAST REVISION
ISSUE DATE: 02-26-2015
PREPARED BY: ALLISON CHO
VERSION #: 01
FURTHER INFORMATION: NOT AVAILABLE.
HMIS(R*) RATINGS:
HEALTH 2*
FLAMMABILITY 4
PHYSICAL HAZARD 0
PERSONAL PROTECTION B
NFPA RATINGS:
HEALTH 2
FLAMMABILITY 4
INSTABILITY 0
NFPA RATINGS:
2
4
0
DISCLAIMER:
CRC CANNOT ANTICIPATE ALL CONDITIONS UNDER WHICH THIS INFORMATION AND ITS
PRODUCT, OR THE PRODUCTS OF OTHER MANUFACTURERS IN COMBINATION WITH ITS
PRODUCT, MAY BE USED. IT IS THE USER'S RESPONSIBILITY TO ENSURE SAFE
CONDITIONS FOR HANDLING, STORAGE AND DISPOSAL OF THE PRODUCT, AND TO ASSUME
LIABILITY FOR LOSS, INJURY, DAMAGE OR EXPENSE DUE TO IMPROPER USE. THE
INFORMATION CONTAINED IN THIS DOCUMENT APPLIES TO THIS SPECIFIC MATERIAL
AS SUPPLIED. IT MAY NOT BE VALID FOR THIS MATERIAL IF IT IS USED IN
COMBINATION WITH ANY OTHER MATERIALS. THIS INFORMATION IS ACCURATE TO THE
BEST OF CRC INDUSTRIES' KNOWLEDGE OR OBTAINED FROM SOURCES BELIEVED BY CRC
TO BE ACCURATE. BEFORE USING ANY PRODUCT, READ ALL WARNINGS AND DIRECTIONS
ON THE LABEL. FOR FURTHER CLARIFICATION OF ANY INFORMATION CONTAINED ON
THIS (M)SDS CONSULT YOUR SUPERVISOR, A HEALTH & SAFETY PROFESSIONAL, OR
CRC INDUSTRIES.
MATERIAL NAME: DRY MOLY LUBE
SDS: US