| Common Name: | AMERICAN SAFETY TECHNOLOGIES AS-2500 SC / LTC TILE RED - PART A, AMERICAN SAFETY |
| Manufacturer: | ITW ENGINEERED POLYMERS |
| SDS Revision Date: | 4/6/2014 |
| SDS Format: | No Format Specified |
| Item Number(s): | 3WAN7 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
ITW ENGINEERED POLYMERS
SAFETY DATA SHEET
| 1. IDENTIFICATION |  |
PRODUCT IDENTIFIER:
AMERICAN SAFETY TECHNOLOGIES AS-2500 SC / LTC TILE RED - PART A
OTHER MEANS OF IDENTIFICATION:
SKU#: AS263R
RECOMMENDED USE: NOT AVAILABLE.
RECOMMENDED RESTRICTIONS: NONE KNOWN.
MANUFACTURER/IMPORTER/SUPPLIER/DISTRIBUTOR INFORMATION:
MANUFACTURER:
COMPANY NAME: ITW ENGINEERED POLYMERS
ADDRESS:
130 COMMERCE DRIVE
MONTGOMERYVILLE, PA 18936
UNITED STATES
TELEPHONE:
CUSTOMER SERVICE: (215) 855-8450
WEBSITE: WWW.ITWCOATINGS.COM
E-MAIL: ORDERS@ITWCOATINGS.COM
CONTACT PERSON: EHS DEPARTMENT
EMERGENCY PHONE NUMBER:
CHEMTREC: (800) 424-9300
INTERNATIONAL: (703) 527-3887
| 2. HAZARD(S) IDENTIFICATION | |
PHYSICAL HAZARDS: NOT CLASSIFIED.
HEALTH HAZARDS:
SKIN CORROSION/IRRITATION: CATEGORY 2
SERIOUS EYE DAMAGE/EYE IRRITATION: CATEGORY 2
SENSITIZATION, SKIN: CATEGORY 1
ENVIRONMENTAL HAZARDS:
HAZARDOUS TO THE AQUATIC ENVIRONMENT, LONG-TERM HAZARD: CATEGORY 3
OSHA DEFINED HAZARDS: NOT CLASSIFIED.
LABEL ELEMENTS: EXCLAMATION MARK
SIGNAL WORD: WARNING
HAZARD STATEMENT:
CAUSES SKIN IRRITATION. MAY CAUSE AN ALLERGIC SKIN REACTION. CAUSES SERIOUS
EYE IRRITATION. HARMFUL TO AQUATIC LIFE WITH LONG LASTING EFFECTS.
PREVENTION:
AVOID BREATHING MIST OR VAPOR. WASH THOROUGHLY AFTER HANDLING. CONTAMINATED
WORK CLOTHING MUST NOT BE ALLOWED OUT OF THE WORKPLACE. AVOID RELEASE TO
THE ENVIRONMENT. WEAR PROTECTIVE GLOVES. WEAR EYE/FACE PROTECTION.
RESPONSE:
IF ON SKIN: WASH WITH PLENTY OF WATER.
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES,
IF PRESENT AND EASY TO DO. CONTINUE RINSING.
IF SKIN IRRITATION OR RASH OCCURS: GET MEDICAL ADVICE/ATTENTION.
IF EYE IRRITATION PERSISTS:
GET MEDICAL ADVICE/ATTENTION. TAKE OFF CONTAMINATED CLOTHING AND WASH
BEFORE REUSE.
STORAGE: STORE AWAY FROM INCOMPATIBLE MATERIALS.
DISPOSAL:
DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH
LOCAL/REGIONAL/NATIONAL/INTERNATIONAL REGULATIONS.
HAZARD(S) NOT OTHERWISE CLASSIFIED (HNOC): NONE KNOWN.
SUPPLEMENTAL INFORMATION:
6.98% OF THE MIXTURE CONSISTS OF COMPONENT(S) OF UNKNOWN LONG-TERM HAZARDS
TO THE AQUATIC ENVIRONMENT.
| 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
MIXTURES:
CHEMICAL NAME COMMON NAME AND SYNONYMS CAS NUMBER %
ALUMINIUM OXIDE 1344-28-1 10 - 30
CRYSTALLINE SiO2 (QUARTZ) 14808-60-7 10 - 30
EPOXY RESIN: - 25068-38-6 10 - 30
REACTION PRODUCT OF
BISPHENOL A AND
EPICHLOROHYDRIN
(REFER TO EPICHLOROHYDRIN)
1-CHLORO-4-(TRIMETHYL) 98-56-6 1 - 5
BENZENE
CARBON BLACK 1333-86-4 0.1 - 1
TITANIUM DIOXIDE 13463-67-7 0.1 - 1
OTHER COMPONENTS BELOW 15 - 40
REPORTABLE LEVELS
*DESIGNATES THAT A SPECIFIC CHEMICAL IDENTITY AND/OR PERCENTAGE OF
COMPOSITION HAS BEEN WITHHELD AS A TRADE SECRET.
| 4. FIRST-AID MEASURES | |
INHALATION:
MOVE TO FRESH AIR. CALL A PHYSICIAN IF SYMPTOMS DEVELOP OR PERSIST.
SKIN CONTACT:
REMOVE CONTAMINATED CLOTHING IMMEDIATELY AND WASH SKIN WITH SOAP AND WATER.
IN CASE OF ECZEMA OR OTHER SKIN DISORDERS: SEEK MEDICAL ATTENTION AND TAKE
ALONG THESE INSTRUCTIONS. TAKE OFF CONTAMINATED CLOTHING AND WASH BEFORE
REUSE.
EYE CONTACT:
IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES.
REMOVE CONTACT LENSES, IF PRESENT AND EASY TO DO. CONTINUE RINSING.
GET MEDICAL ATTENTION IF IRRITATION DEVELOPS AND PERSISTS.
INGESTION: RINSE MOUTH. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR.
MOST IMPORTANT SYMPTOMS/EFFECTS, ACUTE AND DELAYED:
SYMPTOMS MAY INCLUDE STINGING, TEARING, REDNESS, SWELLING, AND BLURRED
VISION. MAY CAUSE AN ALLERGIC SKIN REACTION. DERMATITIS. RASH. MAY CAUSE
REDNESS AND PAIN.
INDICATION OF IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED:
PROVIDE GENERAL SUPPORTIVE MEASURES AND TREAT SYMPTOMATICALLY. KEEP VICTIM
UNDER OBSERVATION. SYMPTOMS MAY BE DELAYED.
GENERAL INFORMATION:
ENSURE THAT MEDICAL PERSONNEL ARE AWARE OF THE MATERIAL(S) INVOLVED, AND
TAKE PRECAUTIONS TO PROTECT THEMSELVES. WASH CONTAMINATED CLOTHING BEFORE
REUSE.
| 5. FIRE-FIGHTING MEASURES | |
SUITABLE EXTINGUISHING MEDIA:
WATER FOG. FOAM. DRY CHEMICAL POWDER. CARBON DIOXIDE (CO2).
UNSUITABLE EXTINGUISHING MEDIA:
DO NOT USE WATER JET AS AN EXTINGUISHER, AS THIS WILL SPREAD THE FIRE.
SPECIFIC HAZARDS ARISING FROM THE CHEMICAL:
DURING FIRE, GASES HAZARDOUS TO HEALTH MAY BE FORMED.
SPECIAL PROTECTIVE EQUIPMENT AND PRECAUTIONS FOR FIREFIGHTERS:
SELF-CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE CLOTHING MUST BE
WORN IN CASE OF FIRE.
FIRE-FIGHTING EQUIPMENT/INSTRUCTIONS:
MOVE CONTAINERS FROM FIRE AREA IF YOU CAN DO SO WITHOUT RISK.
SPECIFIC METHODS:
MOVE CONTAINERS FROM FIRE AREA IF YOU CAN DO SO WITHOUT RISK.
GENERAL FIRE HAZARDS: NO UNUSUAL FIRE OR EXPLOSION HAZARDS NOTED.
| 6. ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
KEEP UNNECESSARY PERSONNEL AWAY. KEEP PEOPLE AWAY FROM AND UPWIND OF
SPILL/LEAK. KEEP OUT OF LOW AREAS. WEAR APPROPRIATE PROTECTIVE EQUIPMENT
AND CLOTHING DURING CLEAN-UP. DO NOT TOUCH DAMAGED CONTAINERS OR SPILLED
MATERIAL UNLESS WEARING APPROPRIATE PROTECTIVE CLOTHING. AVOID INHALATION
OF VAPORS OR MISTS. ENSURE ADEQUATE VENTILATION. LOCAL AUTHORITIES SHOULD
BE ADVISED IF SIGNIFICANT SPILLAGES CANNOT BE CONTAINED. FOR PERSONAL
PROTECTION, SEE SECTION 8 OF THE SDS.
METHODS AND MATERIALS FOR CONTAINMENT AND CLEANING UP:
LARGE SPILLS:
STOP THE FLOW OF MATERIAL, IF THIS IS WITHOUT RISK. DIKE THE SPILLED
MATERIAL, WHERE THIS IS POSSIBLE. COVER WITH PLASTIC SHEET TO PREVENT
SPREADING. ABSORB IN VERMICULITE, DRY SAND OR EARTH AND PLACE INTO
CONTAINERS. PREVENT ENTRY INTO WATERWAYS, SEWER, BASEMENTS OR CONFINED
AREAS. FOLLOWING PRODUCT RECOVERY, FLUSH AREA WITH WATER.
SMALL SPILLS:
WIPE UP WITH ABSORBENT MATERIAL (E.G. CLOTH, FLEECE). CLEAN SURFACE
THOROUGHLY TO REMOVE RESIDUAL CONTAMINATION.
NEVER RETURN SPILLS TO ORIGINAL CONTAINERS FOR RE-USE. FOR WASTE DISPOSAL,
SEE SECTION 13 OF THE SDS.
ENVIRONMENTAL PRECAUTIONS:
AVOID RELEASE TO THE ENVIRONMENT. CONTACT LOCAL AUTHORITIES IN CASE OF
SPILLAGE TO DRAIN/AQUATIC ENVIRONMENT. PREVENT FURTHER LEAKAGE OR SPILLAGE
IF SAFE TO DO SO. DO NOT CONTAMINATE WATER. AVOID DISCHARGE INTO DRAINS,
WATER COURSES OR ONTO THE GROUND.
| 7. HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING:
AVOID BREATHING MIST OR VAPOR. AVOID CONTACT WITH SKIN. AVOID CONTACT WITH
EYES. AVOID PROLONGED EXPOSURE. AVOID CONTACT WITH CLOTHING. PROVIDE
ADEQUATE VENTILATION. WEAR APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT.
OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES. AVOID RELEASE TO THE
ENVIRONMENT. DO NOT EMPTY INTO DRAINS.
CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES:
STORE IN ORIGINAL TIGHTLY CLOSED CONTAINER. STORE AWAY FROM INCOMPATIBLE
MATERIALS (SEE SECTION 10 OF THE SDS).
| 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
OCCUPATIONAL EXPOSURE LIMITS:
US. OSHA TABLE Z-1 LIMITS FOR AIR CONTAMINANTS (29 CFR 1910.1000):
COMPONENTS TYPE VALUE FORM
ALUMINIUM OXIDE PEL 5 MG/M3 RESPIRABLE FRACTION.
(CAS 1344-28-1) 15 MG/M3 TOTAL DUST.
CARBON BLACK PEL 3.5 MG/M3
(CAS 1333-86-4)
TITANIUM DIOXIDE PEL 15 MG/M3 TOTAL DUST.
(CAS 13463-67-7)
US. OSHA TABLE Z-3 (29 CFR 1910.1000):
COMPONENTS TYPE VALUE FORM
CRYSTALLINE SiO2 (QUARTZ) TWA 0.3 MG/M3 TOTAL DUST.
(CAS 14808-60-7) 0.1 MG/M3 RESPIRABLE.
2.4 MILLIONS OF RESPIRABLE.
PARTICLE
US. ACGIH THRESHOLD LIMIT VALUES:
COMPONENTS TYPE VALUE FORM
ALUMINIUM OXIDE TWA 1 MG/M3 RESPIRABLE FRACTION.
(CAS 1344-28-1)
CARBON BLACK TWA 3 MG/M3 INHALABLE FRACTION.
(CAS 1333-86-4)
CRYSTALLINE SiO2 (QUARTZ) TWA 0.025 MG/M3 RESPIRABLE FRACTION.
(CAS 14808-60-7)
TITANIUM DIOXIDE TWA 10 MG/M3
(CAS 13463-67-7)
US. NIOSH: POCKET GUIDE TO CHEMICAL HAZARDS
COMPONENTS TYPE VALUE FORM
CARBON BLACK TWA 0.1 MG/M3
(CAS 1333-86-4)
CRYSTALLINE SiO2 (QUARTZ) TWA 0.05 MG/M3 RESPIRABLE DUST.
(CAS 14808-60-7)
BIOLOGICAL LIMIT VALUES:
NO BIOLOGICAL EXPOSURE LIMITS NOTED FOR THE INGREDIENT(S).
APPROPRIATE ENGINEERING CONTROLS:
GOOD GENERAL VENTILATION (TYPICALLY 10 AIR CHANGES PER HOUR) SHOULD BE
USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS. IF APPLICABLE,
USE PROCESS ENCLOSURES, LOCAL EXHAUST VENTILATION, OR OTHER ENGINEERING
CONTROLS TO MAINTAIN AIRBORNE LEVELS BELOW RECOMMENDED EXPOSURE LIMITS.
IF EXPOSURE LIMITS HAVE NOT BEEN ESTABLISHED, MAINTAIN AIRBORNE LEVELS TO
AN ACCEPTABLE LEVEL. EYE WASH FACILITIES AND EMERGENCY SHOWER MUST BE
AVAILABLE WHEN HANDLING THIS PRODUCT.
INDIVIDUAL PROTECTION MEASURES, SUCH AS PERSONAL PROTECTIVE EQUIPMENT:
EYE/FACE PROTECTION: WEAR SAFETY GLASSES WITH SIDE SHIELDS (OR GOGGLES).
HAND PROTECTION: WEAR APPROPRIATE CHEMICAL RESISTANT GLOVES.
SKIN PROTECTION:
OTHER: WEAR APPROPRIATE CHEMICAL RESISTANT CLOTHING.
RESPIRATORY PROTECTION:
IN CASE OF INSUFFICIENT VENTILATION, WEAR SUITABLE RESPIRATORY EQUIPMENT.
THERMAL HAZARDS:
WEAR APPROPRIATE THERMAL PROTECTIVE CLOTHING, WHEN NECESSARY.
GENERAL HYGIENE CONSIDERATIONS:
ALWAYS OBSERVE GOOD PERSONAL HYGIENE MEASURES, SUCH AS WASHING AFTER
HANDLING THE MATERIAL AND BEFORE EATING, DRINKING, AND/OR SMOKING.
ROUTINELY WASH WORK CLOTHING AND PROTECTIVE EQUIPMENT TO REMOVE
CONTAMINANTS. CONTAMINATED WORK CLOTHING SHOULD NOT BE ALLOWED OUT OF THE
WORKPLACE.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE: LIQUID.
PHYSICAL STATE: LIQUID.
FORM: LIQUID.
COLOR: BLACK., YELLOW, RED OR GREY.
ODOR: SLIGHT.
ODOR THRESHOLD: NOT AVAILABLE.
PH: NOT AVAILABLE.
MELTING POINT/FREEZING POINT: NOT AVAILABLE.
INITIAL BOILING POINT AND BOILING RANGE: >300 DEG. F (>148.89 DEG. C)
FLASH POINT: >400.0 DEG. F (>204.4 DEG. C)
EVAPORATION RATE: <1 BUAC
FLAMMABILITY (SOLID, GAS): NOT AVAILABLE.
UPPER/LOWER FLAMMABILITY OR EXPLOSIVE LIMITS:
FLAMMABILITY LIMIT - LOWER (%): NOT AVAILABLE.
FLAMMABILITY LIMIT - UPPER (%): NOT AVAILABLE.
EXPLOSIVE LIMIT - LOWER (%): NOT AVAILABLE.
EXPLOSIVE LIMIT - UPPER (%): NOT AVAILABLE.
VAPOR PRESSURE: <1 MMHg
VAPOR DENSITY: NOT AVAILABLE.
RELATIVE DENSITY: NOT AVAILABLE.
SOLUBILITY(IES):
SOLUBILITY (WATER): NOT AVAILABLE.
PARTITION COEFFICIENT (N-OCTANOL/WATER): NOT AVAILABLE.
AUTO-IGNITION TEMPERATURE: NOT AVAILABLE.
DECOMPOSITION TEMPERATURE: NOT AVAILABLE.
VISCOSITY: NOT AVAILABLE.
OTHER INFORMATION:
DENSITY: 16.74 LB/GAL
FLAMMABILITY CLASS: COMBUSTIBLE IIIB ESTIMATED
SPECIFIC GRAVITY: 2.01
VOC (WEIGHT %): 0
| 10. STABILITY AND REACTIVITY | |
REACTIVITY:
THE PRODUCT IS STABLE AND NON-REACTIVE UNDER NORMAL CONDITIONS OF USE,
STORAGE AND TRANSPORT.
CHEMICAL STABILITY: MATERIAL IS STABLE UNDER NORMAL CONDITIONS.
POSSIBILITY OF HAZARDOUS REACTIONS:
HAZARDOUS POLYMERIZATION DOES NOT OCCUR.
CONDITIONS TO AVOID:
AVOID TEMPERATURES EXCEEDING THE FLASH POINT. CONTACT WITH INCOMPATIBLE
MATERIALS.
INCOMPATIBLE MATERIALS: STRONG OXIDIZING AGENTS.
HAZARDOUS DECOMPOSITION PRODUCTS:
NO HAZARDOUS DECOMPOSITION PRODUCTS ARE KNOWN.
| 11. TOXICOLOGICAL INFORMATION | |
INFORMATION ON LIKELY ROUTES OF EXPOSURE:
INGESTION: EXPECTED TO BE A LOW INGESTION HAZARD.
INHALATION: PROLONGED INHALATION MAY BE HARMFUL.
SKIN CONTACT: CAUSES SKIN IRRITATION. MAY CAUSE AN ALLERGIC SKIN REACTION.
EYE CONTACT: CAUSES SERIOUS EYE IRRITATION.
SYMPTOMS RELATED TO THE PHYSICAL, CHEMICAL AND TOXICOLOGICAL
CHARACTERISTICS:
SYMPTOMS MAY INCLUDE STINGING, TEARING, REDNESS, SWELLING, AND BLURRED
VISION. MAY CAUSE AN ALLERGIC SKIN REACTION. SKIN IRRITATION. MAY CAUSE
REDNESS AND PAIN. DERMATITIS. RASH.
INFORMATION ON TOXICOLOGICAL EFFECTS:
ACUTE TOXICITY: MAY CAUSE AN ALLERGIC SKIN REACTION.
SKIN CORROSION/IRRITATION: CAUSES SKIN IRRITATION.
SERIOUS EYE DAMAGE/EYE IRRITATION: CAUSES SERIOUS EYE IRRITATION.
RESPIRATORY OR SKIN SENSITIZATION:
RESPIRATORY SENSITIZATION: NOT AVAILABLE.
SKIN SENSITIZATION: MAY CAUSE AN ALLERGIC SKIN REACTION.
GERM CELL MUTAGENICITY:
NO DATA AVAILABLE TO INDICATE PRODUCT OR ANY COMPONENTS PRESENT AT GREATER
THAN 0.1% ARE MUTAGENIC OR GENOTOXIC.
CARCINOGENICITY:
IARC MONOGRAPHS. OVERALL EVALUATION OF CARCINOGENICITY:
CARBON BLACK (CAS 1333-86-4): 2B POSSIBLY CARCINOGENIC TO HUMANS.
CRYSTALLINE SiO2 (QUARTZ) (CAS 14808-60-7): 1 CARCINOGENIC TO HUMANS.
TITANIUM DIOXIDE (CAS 13463-67-7): 2B POSSIBLY CARCINOGENIC TO HUMANS.
US. NATIONAL TOXICOLOGY PROGRAM (NTP) REPORT ON CARCINOGENS:
CRYSTALLINE SiO2 (QUARTZ) (CAS 14808-60-7): KNOWN TO BE HUMAN CARCINOGEN.
REPRODUCTIVE TOXICITY:
THIS PRODUCT IS NOT EXPECTED TO CAUSE REPRODUCTIVE OR DEVELOPMENTAL
EFFECTS.
SPECIFIC TARGET ORGAN TOXICITY - SINGLE EXPOSURE: NOT CLASSIFIED.
SPECIFIC TARGET ORGAN TOXICITY - REPEATED EXPOSURE: NOT CLASSIFIED.
ASPIRATION HAZARD: NOT AVAILABLE.
CHRONIC EFFECTS: PROLONGED INHALATION MAY BE HARMFUL.
| 12. ECOLOGICAL INFORMATION | |
ECOTOXICITY:
HARMFUL TO AQUATIC LIFE WITH LONG LASTING EFFECTS. ACCUMULATION IN AQUATIC
ORGANISMS IS EXPECTED.
PERSISTENCE AND DEGRADABILITY:
NO DATA IS AVAILABLE ON THE DEGRADABILITY OF THIS PRODUCT.
BIOACCUMULATIVE POTENTIAL: NO DATA AVAILABLE.
MOBILITY IN SOIL: NO DATA AVAILABLE.
OTHER ADVERSE EFFECTS:
NO OTHER ADVERSE ENVIRONMENTAL EFFECTS (E.G. OZONE DEPLETION, PHOTOCHEMICAL
OZONE CREATION POTENTIAL, ENDOCRINE DISRUPTION, GLOBAL WARMING POTENTIAL)
ARE EXPECTED FROM THIS COMPONENT.
| 13. DISPOSAL CONSIDERATIONS | |
DISPOSAL INSTRUCTIONS:
COLLECT AND RECLAIM OR DISPOSE IN SEALED CONTAINERS AT LICENSED WASTE
DISPOSAL SITE. THIS MATERIAL AND ITS CONTAINER MUST BE DISPOSED OF AS
HAZARDOUS WASTE. DO NOT ALLOW THIS MATERIAL TO DRAIN INTO SEWERS/WATER
SUPPLIES. DO NOT CONTAMINATE PONDS, WATERWAYS OR DITCHES WITH CHEMICAL OR
USED CONTAINER. DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH
LOCAL/REGIONAL/NATIONAL/INTERNATIONAL REGULATIONS.
LOCAL DISPOSAL REGULATIONS:
DISPOSE IN ACCORDANCE WITH ALL APPLICABLE REGULATIONS.
HAZARDOUS WASTE CODE:
THE WASTE CODE SHOULD BE ASSIGNED IN DISCUSSION BETWEEN THE USER, THE
PRODUCER AND THE WASTE DISPOSAL COMPANY.
WASTE FROM RESIDUES / UNUSED PRODUCTS:
DISPOSE OF IN ACCORDANCE WITH LOCAL REGULATIONS. EMPTY CONTAINERS OR LINERS
MAY RETAIN SOME PRODUCT RESIDUES. THIS MATERIAL AND ITS CONTAINER MUST BE
DISPOSED OF IN A SAFE MANNER (SEE: DISPOSAL INSTRUCTIONS).
CONTAMINATED PACKAGING:
EMPTY CONTAINERS SHOULD BE TAKEN TO AN APPROVED WASTE HANDLING SITE FOR
RECYCLING OR DISPOSAL. SINCE EMPTIED CONTAINERS MAY RETAIN PRODUCT RESIDUE,
FOLLOW LABEL WARNINGS EVEN AFTER CONTAINER IS EMPTIED.
| 14. TRANSPORT INFORMATION | |
DOT: NOT REGULATED AS DANGEROUS GOODS.
IATA:
UN NUMBER: UN3082
UN PROPER SHIPPING NAME:
ENVIRONMENTALLY HAZARDOUS SUBSTANCE, LIQUID, N.O.S. (EPOXY RESIN: -
REACTION PRODUCT OF BISPHENOL A AND EPICHLOROHYDRIN (REFER TO
EPICHLOROHYDRIN))
TRANSPORT HAZARD CLASS(ES):
CLASS: 9
SUBSIDIARY RISK:
PACKING GROUP: III
ENVIRONMENTAL HAZARDS: NO.
ERG CODE: 9L
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
OTHER INFORMATION:
PASSENGER AND CARGO AIRCRAFT: ALLOWED.
CARGO AIRCRAFT ONLY: ALLOWED.
IMDG:
UN NUMBER: UN3082
UN PROPER SHIPPING NAME:
ENVIRONMENTALLY HAZARDOUS SUBSTANCE, LIQUID, N.O.S. (EPOXY RESIN: -
REACTION PRODUCT OF BISPHENOL A AND EPICHLOROHYDRIN (REFER TO
EPICHLOROHYDRIN)), MARINE POLLUTANT
TRANSPORT HAZARD CLASS(ES):
CLASS: 9
SUBSIDIARY RISK:
PACKING GROUP: III
ENVIRONMENTAL HAZARDS:
MARINE POLLUTANT: YES
EMS: F-A, S-F
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
TRANSPORT IN BULK ACCORDING TO ANNEX II OF MARPOL 73/78 AND THE IBC CODE:
NOT AVAILABLE.
IATA; IMDG: CLASS 9, MISCELLANEOUS PRODUCTS, SUBSTANCES, OR ORGANISMS
MARINE POLLUTANT: ENVIRONMENT
| 15. REGULATORY INFORMATION | |
US FEDERAL REGULATIONS:
THIS PRODUCT IS A "HAZARDOUS CHEMICAL" AS DEFINED BY THE OSHA HAZARD
COMMUNICATION STANDARD, 29 CFR 1910.1200.
TSCA SECTION 12(B) EXPORT NOTIFICATION (40 CFR 707, SUBPT. D):
1-CHLORO-4-(TRIMETHYL)BENZENE (CAS 98-56-6):
1.0% ONE-TIME EXPORT NOTIFICATION ONLY.
CERCLA HAZARDOUS SUBSTANCE LIST (40 CFR 302.4): NOT LISTED.
US. OSHA SPECIFICALLY REGULATED SUBSTANCES (29 CFR 1910.1001-1050):
NOT LISTED.
SARA 304 EMERGENCY RELEASE NOTIFICATION: NOT REGULATED.
US EPCRA (SARA TITLE III) SECTION 313 - DE MINIMIS CONCENTRATION
TOXIC CHEMICAL
ALUMINIUM OXIDE (CAS 1344-28-1) % 1.0
US EPCRA (SARA TITLE III) SECTION 313 - LISTED SUBSTANCE
TOXIC CHEMICAL
ALUMINIUM OXIDE (CAS 1344-28-1) LISTED.
SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 (SARA):
HAZARD CATEGORIES:
IMMEDIATE HAZARD: YES
DELAYED HAZARD: NO
FIRE HAZARD: NO
PRESSURE HAZARD: NO
REACTIVITY HAZARD: NO
SARA 302 EXTREMELY HAZARDOUS SUBSTANCE: NO
SARA 311/312 HAZARDOUS CHEMICAL: NO
SARA 313 (TRI REPORTING):
CHEMICAL NAME CAS NUMBER % BY WT.
ALUMINIUM OXIDE 1344-28-1 10 - 30
XYLENE 1330-20-7 0.1 - 1
BENZENE 71-43-2 0 - 0.1
ETHYL BENZENE 100-41-4 0 - 0.1
OTHER FEDERAL REGULATIONS:
CLEAN AIR ACT (CAA) SECTION 112 HAZARDOUS AIR POLLUTANTS (HAPS) LIST:
NOT REGULATED.
CLEAN AIR ACT (CAA) SECTION 112(R) ACCIDENTAL RELEASE PREVENTION
(40 CFR 68.130): NOT REGULATED.
SAFE DRINKING WATER ACT (SDWA): NOT REGULATED.
US STATE REGULATIONS:
US. MASSACHUSETTS RTK - SUBSTANCE LIST:
ALUMINIUM OXIDE (CAS 1344-28-1)
CARBON BLACK (CAS 1333-86-4)
CRYSTALLINE SiO2 (QUARTZ) (CAS 14808-60-7)
TITANIUM DIOXIDE (CAS 13463-67-7)
US. NEW JERSEY WORKER AND COMMUNITY RIGHT-TO-KNOW ACT:
ALUMINIUM OXIDE (CAS 1344-28-1): 500 LBS
US. PENNSYLVANIA RTK - HAZARDOUS SUBSTANCES:
ALUMINIUM OXIDE (CAS 1344-28-1)
CARBON BLACK (CAS 1333-86-4)
CRYSTALLINE SiO2 (QUARTZ) (CAS 14808-60-7)
TITANIUM DIOXIDE (CAS 13463-67-7)
US. RHODE ISLAND RTK: ALUMINIUM OXIDE (CAS 1344-28-1)
US. CALIFORNIA PROPOSITION 65:
WARNING:
THIS PRODUCT CONTAINS A CHEMICAL KNOWN TO THE STATE OF CALIFORNIA TO CAUSE
CANCER AND BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM.
US - CALIFORNIA PROPOSITION 65 - CRT LISTED DATE/CARCINOGENIC
SUBSTANCE
ATTAPULGITE (CAS 12174-11-7) LISTED: DECEMBER 28, 1999
BENZENE (CAS 71-43-2) LISTED: FEBRUARY 27, 1987
CARBON BLACK (CAS 1333-86-4) LISTED: FEBRUARY 21, 2003
CRYSTALLINE SiO2 (QUARTZ) (CAS 14808-60-7) LISTED: OCTOBER 1, 1988
CUMENE (CAS 98-82-8) LISTED: APRIL 6, 2010
ETHYL BENZENE (CAS 100-41-4) LISTED: JUNE 11, 2004
TITANIUM DIOXIDE (CAS 13463-67-7) LISTED: SEPTEMBER 2, 2011
US - CALIFORNIA PROPOSITION 65 - CRT LISTED DATE/DEVELOPMENTAL TOXIN
BENZENE (CAS 71-43-2) LISTED: DECEMBER 26, 1997
TOLUENE (CAS 108-88-3) LISTED: JANUARY 1, 1991
US - CALIFORNIA PROPOSITION 65 - CRT LISTED DATE/FEMALE REPRODUCTIVE
TOXIN
TOLUENE (CAS 108-88-3) LISTED: AUGUST 7, 2009
US - CALIFORNIA PROPOSITION 65 - CRT LISTED DATE/MALE REPRODUCTIVE
TOXIN
BENZENE (CAS 71-43-2) LISTED: DECEMBER 26, 1997
INTERNATIONAL INVENTORIES:
COUNTRY(S) OR REGION INVENTORY NAME ON INVENTORY
(YES/NO)*
AUSTRALIA AUSTRALIAN INVENTORY OF CHEMICAL NO
SUBSTANCES (AICS)
CANADA DOMESTIC SUBSTANCES LIST (DSL) NO
CANADA NON-DOMESTIC SUBSTANCES LIST (NDSL) NO
CHINA INVENTORY OF EXISTING CHEMICAL NO
SUBSTANCES IN CHINA (IECSC)
EUROPE EUROPEAN INVENTORY OF EXISTING NO
COMMERCIAL CHEMICAL SUBSTANCES (EINECS)
EUROPE EUROPEAN LIST OF NOTIFIED CHEMICAL NO
SUBSTANCES (ELINCS)
JAPAN INVENTORY OF EXISTING AND NEW CHEMICAL NO
SUBSTANCES (ENCS)
KOREA EXISTING CHEMICALS LIST (ECL) NO
NEW ZEALAND NEW ZEALAND INVENTORY YES
PHILIPPINES PHILIPPINE INVENTORY OF CHEMICALS AND NO
CHEMICAL SUBSTANCES (PICCS)
UNITED STATES & TOXIC SUBSTANCES CONTROL ACT (TSCA) NO
PUERTO RICO INVENTORY
*A "YES" INDICATES THAT ALL COMPONENTS OF THIS PRODUCT COMPLY WITH THE
INVENTORY REQUIREMENTS ADMINISTERED BY THE GOVERNING COUNTRY(S)
A "NO" INDICATES THAT ONE OR MORE COMPONENTS OF THE PRODUCT ARE NOT LISTED
OR EXEMPT FROM LISTING ON THE INVENTORY ADMINISTERED BY THE GOVERNING
COUNTRY(S).
| 16. OTHER INFORMATION, INCLUDING DATE OF PREPARATION | |
OR LAST REVISION
ISSUE DATE: 04-06-2014
VERSION #: 01
HMIS(R*) RATINGS:
HEALTH 2*
FLAMMABILITY 1
PHYSICAL HAZARD 1
PERSONAL PROTECTION X
NFPA RATINGS:
HEALTH 2
FLAMMABILITY 1
INSTABILITY 1
DISCLAIMER:
THE INFORMATION IN THE SHEET WAS WRITTEN BASED ON THE BEST KNOWLEDGE AND
EXPERIENCE CURRENTLY AVAILABLE.
REVISION INFORMATION:
PRODUCT AND COMPANY IDENTIFICATION: ALTERNATE TRADE NAMES
PHYSICAL & CHEMICAL PROPERTIES: MULTIPLE PROPERTIES
MATERIAL NAME:
AMERICAN SAFETY TECHNOLOGIES AS-2500 SC / LTC TILE RED - PART A
2150
SDS US
ITW ENGINEERED POLYMERS
SAFETY DATA SHEET
| 1. IDENTIFICATION | |
PRODUCT IDENTIFIER:
AMERICAN SAFETY TECHNOLOGIES AS-2500 SC HARDENER - PART B
OTHER MEANS OF IDENTIFICATION:
SKU#: AS274H
RECOMMENDED USE: NOT AVAILABLE.
RECOMMENDED RESTRICTIONS: NONE KNOWN.
MANUFACTURER/IMPORTER/SUPPLIER/DISTRIBUTOR INFORMATION:
MANUFACTURER:
COMPANY NAME: ITW ENGINEERED POLYMERS
ADDRESS:
130 COMMERCE DRIVE
MONTGOMERYVILLE, PA 18936
UNITED STATES
TELEPHONE:
CUSTOMER SERVICE: (215) 855-8450
WEBSITE: WWW.ITWCOATINGS.COM
E-MAIL: ORDERS@ITWCOATINGS.COM
CONTACT PERSON: EHS DEPARTMENT
EMERGENCY PHONE NUMBER:
CHEMTREC: (800) 424-9300
INTERNATIONAL: (703) 527-3887
| 2. HAZARD(S) IDENTIFICATION | |
PHYSICAL HAZARDS: NOT CLASSIFIED.
HEALTH HAZARDS:
ACUTE TOXICITY, ORAL: CATEGORY 4
ACUTE TOXICITY, DERMAL: CATEGORY 4
SKIN CORROSION/IRRITATION: CATEGORY 1B
SERIOUS EYE DAMAGE/EYE IRRITATION: CATEGORY 1
SENSITIZATION, SKIN: CATEGORY 1
ENVIRONMENTAL HAZARDS: NOT CLASSIFIED.
OSHA DEFINED HAZARDS: NOT CLASSIFIED.
LABEL ELEMENTS:
CORROSION
EXCLAMATION MARK
SIGNAL WORD: DANGER
HAZARD STATEMENT:
HARMFUL IF SWALLOWED. HARMFUL IN CONTACT WITH SKIN. CAUSES SEVERE SKIN
BURNS AND EYE DAMAGE. MAY CAUSE AN ALLERGIC SKIN REACTION. CAUSES SERIOUS
EYE DAMAGE.
PREVENTION:
DO NOT BREATHE MIST OR VAPOR. WASH THOROUGHLY AFTER HANDLING. DO NOT EAT,
DRINK OR SMOKE WHEN USING THIS PRODUCT. CONTAMINATED WORK CLOTHING MUST NOT
BE ALLOWED OUT OF THE WORKPLACE. WEAR PROTECTIVE GLOVES/PROTECTIVE
CLOTHING/EYE PROTECTION/FACE PROTECTION.
RESPONSE:
IF SWALLOWED: CALL A POISON CENTER/DOCTOR IF YOU FEEL UNWELL.
IF SWALLOWED: RINSE MOUTH. DO NOT INDUCE VOMITING.
IF ON SKIN (OR HAIR):
TAKE OFF IMMEDIATELY ALL CONTAMINATED CLOTHING. RINSE SKIN WITH
WATER/SHOWER.
IF INHALED: REMOVE PERSON TO FRESH AIR AND KEEP COMFORTABLE FOR BREATHING.
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES,
IF PRESENT AND EASY TO DO. CONTINUE RINSING.
IF SKIN IRRITATION OR RASH OCCURS:
GET MEDICAL ADVICE/ATTENTION. TAKE OFF CONTAMINATED CLOTHING AND WASH
BEFORE REUSE.
STORAGE: STORE LOCKED UP.
DISPOSAL:
DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH
LOCAL/REGIONAL/NATIONAL/INTERNATIONAL REGULATIONS.
HAZARD(S) NOT OTHERWISE CLASSIFIED (HNOC): NONE KNOWN.
SUPPLEMENTAL INFORMATION:
99.58% OF THE MIXTURE CONSISTS OF COMPONENT(S) OF UNKNOWN ACUTE ORAL
TOXICITY.
| 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
MIXTURES:
CHEMICAL NAME COMMON NAME AND SYNONYMS CAS NUMBER %
FATTY ACIDS, TALL OIL 68605-86-7 60 - 100
POLYMERS WITH LINOLEIC
ACID DIMERS AND
TETRAETHYLENEPENTAMINE
HYDROPHOBIC SILICON 67762-90-7 5 - 10
DIOXIDE, AMORPHOUS
OTHER COMPONENTS BELOW 5 - 10
REPORTABLE LEVELS
*DESIGNATES THAT A SPECIFIC CHEMICAL IDENTITY AND/OR PERCENTAGE OF
COMPOSITION HAS BEEN WITHHELD AS A TRADE SECRET.
| 4. FIRST-AID MEASURES | |
INHALATION:
MOVE TO FRESH AIR. CALL A PHYSICIAN IF SYMPTOMS DEVELOP OR PERSIST.
SKIN CONTACT:
REMOVE CONTAMINATED CLOTHING IMMEDIATELY AND WASH SKIN WITH SOAP AND WATER.
CHEMICAL BURNS MUST BE TREATED BY A PHYSICIAN. WASH CONTAMINATED CLOTHING
BEFORE REUSE.
EYE CONTACT:
IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES. REMOVE
CONTACT LENSES, IF PRESENT AND EASY TO DO. CONTINUE RINSING.
INGESTION:
CALL A PHYSICIAN OR POISON CONTROL CENTER IMMEDIATELY. RINSE MOUTH. DO NOT
INDUCE VOMITING. IF VOMITING OCCURS, KEEP HEAD LOW SO THAT STOMACH CONTENT
DOESN'T GET INTO THE LUNGS.
MOST IMPORTANT SYMPTOMS/EFFECTS, ACUTE AND DELAYED:
BURNING PAIN AND SEVERE CORROSIVE SKIN DAMAGE. CAUSES SERIOUS EYE DAMAGE.
SYMPTOMS MAY INCLUDE STINGING, TEARING, REDNESS, SWELLING, AND BLURRED
VISION. PERMANENT EYE DAMAGE INCLUDING BLINDNESS COULD RESULT. MAY CAUSE AN
ALLERGIC SKIN REACTION. DERMATITIS. RASH.
INDICATION OF IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED:
PROVIDE GENERAL SUPPORTIVE MEASURES AND TREAT SYMPTOMATICALLY.
CHEMICAL BURNS:
FLUSH WITH WATER IMMEDIATELY. WHILE FLUSHING, REMOVE CLOTHES WHICH DO NOT
ADHERE TO AFFECTED AREA. CALL AN AMBULANCE. CONTINUE FLUSHING DURING
TRANSPORT TO HOSPITAL. IN CASE OF SHORTNESS OF BREATH, GIVE OXYGEN. KEEP
VICTIM WARM. KEEP VICTIM UNDER OBSERVATION. SYMPTOMS MAY BE DELAYED.
GENERAL INFORMATION:
IN THE CASE OF ACCIDENT OR IF YOU FEEL UNWELL, SEEK MEDICAL ADVICE
IMMEDIATELY (SHOW THE LABEL WHERE POSSIBLE). ENSURE THAT MEDICAL PERSONNEL
ARE AWARE OF THE MATERIAL(S) INVOLVED, AND TAKE PRECAUTIONS TO PROTECT
THEMSELVES. WASH CONTAMINATED CLOTHING BEFORE REUSE.
| 5. FIRE-FIGHTING MEASURES | |
SUITABLE EXTINGUISHING MEDIA:
WATER FOG. FOAM. DRY CHEMICAL POWDER. CARBON DIOXIDE (CO2).
UNSUITABLE EXTINGUISHING MEDIA:
DO NOT USE WATER JET AS AN EXTINGUISHER, AS THIS WILL SPREAD THE FIRE.
SPECIFIC HAZARDS ARISING FROM THE CHEMICAL:
DURING FIRE, GASES HAZARDOUS TO HEALTH MAY BE FORMED.
SPECIAL PROTECTIVE EQUIPMENT AND PRECAUTIONS FOR FIREFIGHTERS:
SELF-CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE CLOTHING MUST BE
WORN IN CASE OF FIRE.
FIRE-FIGHTING EQUIPMENT/INSTRUCTIONS:
MOVE CONTAINERS FROM FIRE AREA IF YOU CAN DO SO WITHOUT RISK.
SPECIFIC METHODS:
MOVE CONTAINERS FROM FIRE AREA IF YOU CAN DO SO WITHOUT RISK.
GENERAL FIRE HAZARDS: NO UNUSUAL FIRE OR EXPLOSION HAZARDS NOTED.
| 6. ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
KEEP UNNECESSARY PERSONNEL AWAY. KEEP PEOPLE AWAY FROM AND UPWIND OF
SPILL/LEAK. KEEP OUT OF LOW AREAS. WEAR APPROPRIATE PROTECTIVE EQUIPMENT
AND CLOTHING DURING CLEAN-UP. DO NOT BREATHE MIST OR VAPOR. DO NOT TOUCH
DAMAGED CONTAINERS OR SPILLED MATERIAL UNLESS WEARING APPROPRIATE
PROTECTIVE CLOTHING. ENSURE ADEQUATE VENTILATION. LOCAL AUTHORITIES SHOULD
BE ADVISED IF SIGNIFICANT SPILLAGES CANNOT BE CONTAINED. FOR PERSONAL
PROTECTION, SEE SECTION 8 OF THE SDS.
METHODS AND MATERIALS FOR CONTAINMENT AND CLEANING UP:
LARGE SPILLS:
STOP THE FLOW OF MATERIAL, IF THIS IS WITHOUT RISK. DIKE THE SPILLED
MATERIAL, WHERE THIS IS POSSIBLE. COVER WITH PLASTIC SHEET TO PREVENT
SPREADING. ABSORB IN VERMICULITE, DRY SAND OR EARTH AND PLACE INTO
CONTAINERS. PREVENT ENTRY INTO WATERWAYS, SEWER, BASEMENTS OR CONFINED
AREAS. FOLLOWING PRODUCT RECOVERY, FLUSH AREA WITH WATER.
SMALL SPILLS:
WIPE UP WITH ABSORBENT MATERIAL (E.G. CLOTH, FLEECE). CLEAN SURFACE
THOROUGHLY TO REMOVE RESIDUAL CONTAMINATION.
NEVER RETURN SPILLS TO ORIGINAL CONTAINERS FOR RE-USE. FOR WASTE DISPOSAL,
SEE SECTION 13 OF THE SDS.
ENVIRONMENTAL PRECAUTIONS:
AVOID DISCHARGE INTO DRAINS, WATER COURSES OR ONTO THE GROUND.
| 7. HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING:
DO NOT BREATHE MIST OR VAPOR. DO NOT GET THIS MATERIAL IN CONTACT WITH
EYES. DO NOT GET THIS MATERIAL IN CONTACT WITH SKIN. DO NOT TASTE OR
SWALLOW. DO NOT GET THIS MATERIAL ON CLOTHING. PROVIDE ADEQUATE
VENTILATION. WEAR APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT. OBSERVE GOOD
INDUSTRIAL HYGIENE PRACTICES. WHEN USING, DO NOT EAT, DRINK OR SMOKE.
WASH HANDS THOROUGHLY AFTER HANDLING. WASH CONTAMINATED CLOTHING BEFORE
REUSE.
CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES:
STORE LOCKED UP. STORE IN ORIGINAL TIGHTLY CLOSED CONTAINER. STORE AWAY
FROM INCOMPATIBLE MATERIALS (SEE SECTION 10 OF THE SDS).
| 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
OCCUPATIONAL EXPOSURE LIMITS: NO EXPOSURE LIMITS NOTED FOR INGREDIENT(S).
BIOLOGICAL LIMIT VALUES:
NO BIOLOGICAL EXPOSURE LIMITS NOTED FOR THE INGREDIENT(S).
APPROPRIATE ENGINEERING CONTROLS:
GOOD GENERAL VENTILATION (TYPICALLY 10 AIR CHANGES PER HOUR) SHOULD BE
USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS. IF APPLICABLE,
USE PROCESS ENCLOSURES, LOCAL EXHAUST VENTILATION, OR OTHER ENGINEERING
CONTROLS TO MAINTAIN AIRBORNE LEVELS BELOW RECOMMENDED EXPOSURE LIMITS.
IF EXPOSURE LIMITS HAVE NOT BEEN ESTABLISHED, MAINTAIN AIRBORNE LEVELS TO
AN ACCEPTABLE LEVEL. EYE WASH FACILITIES AND EMERGENCY SHOWER MUST BE
AVAILABLE WHEN HANDLING THIS PRODUCT.
INDIVIDUAL PROTECTION MEASURES, SUCH AS PERSONAL PROTECTIVE EQUIPMENT:
EYE/FACE PROTECTION:
WEAR EYE/FACE PROTECTION. WEAR SAFETY GLASSES WITH SIDE SHIELDS
(OR GOGGLES) AND A FACE SHIELD.
HAND PROTECTION: WEAR APPROPRIATE CHEMICAL RESISTANT GLOVES.
SKIN PROTECTION:
OTHER: WEAR APPROPRIATE CHEMICAL RESISTANT CLOTHING.
RESPIRATORY PROTECTION:
IN CASE OF INSUFFICIENT VENTILATION, WEAR SUITABLE RESPIRATORY EQUIPMENT.
THERMAL HAZARDS:
WEAR APPROPRIATE THERMAL PROTECTIVE CLOTHING, WHEN NECESSARY.
GENERAL HYGIENE CONSIDERATIONS:
WHEN USING, DO NOT EAT, DRINK OR SMOKE. ALWAYS OBSERVE GOOD PERSONAL
HYGIENE MEASURES, SUCH AS WASHING AFTER HANDLING THE MATERIAL AND BEFORE
EATING, DRINKING, AND/OR SMOKING. ROUTINELY WASH WORK CLOTHING AND
PROTECTIVE EQUIPMENT TO REMOVE CONTAMINANTS. CONTAMINATED WORK CLOTHING
SHOULD NOT BE ALLOWED OUT OF THE WORKPLACE.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE: LIQUID.
PHYSICAL STATE: LIQUID.
FORM: LIQUID.
COLOR: YELLOW
ODOR: AMMONIACAL.
ODOR THRESHOLD: NOT AVAILABLE.
PH: NOT AVAILABLE.
MELTING POINT/FREEZING POINT: NOT AVAILABLE.
INITIAL BOILING POINT AND BOILING RANGE: NOT AVAILABLE.
FLASH POINT: >230.0 DEG. F (>110.0 DEG. C)
EVAPORATION RATE: NOT AVAILABLE.
FLAMMABILITY (SOLID, GAS): NOT AVAILABLE.
UPPER/LOWER FLAMMABILITY OR EXPLOSIVE LIMITS:
FLAMMABILITY LIMIT - LOWER (%): NOT AVAILABLE.
FLAMMABILITY LIMIT - UPPER (%): NOT AVAILABLE.
EXPLOSIVE LIMIT - LOWER (%): NOT AVAILABLE.
EXPLOSIVE LIMIT - UPPER (%): NOT AVAILABLE.
VAPOR PRESSURE: NOT AVAILABLE.
VAPOR DENSITY: NOT AVAILABLE.
RELATIVE DENSITY: NOT AVAILABLE.
SOLUBILITY(IES):
SOLUBILITY (WATER): NOT AVAILABLE.
PARTITION COEFFICIENT (N-OCTANOL/WATER): NOT AVAILABLE.
AUTO-IGNITION TEMPERATURE: NOT AVAILABLE.
DECOMPOSITION TEMPERATURE: NOT AVAILABLE.
VISCOSITY: NOT AVAILABLE.
OTHER INFORMATION:
DENSITY: 8.28 LB/GAL
FLAMMABILITY CLASS: COMBUSTIBLE IIIB ESTIMATED
SPECIFIC GRAVITY: 0.99
VOC (WEIGHT %): 0
| 10. STABILITY AND REACTIVITY | |
REACTIVITY:
THE PRODUCT IS STABLE AND NON-REACTIVE UNDER NORMAL CONDITIONS OF USE,
STORAGE AND TRANSPORT.
CHEMICAL STABILITY: MATERIAL IS STABLE UNDER NORMAL CONDITIONS.
POSSIBILITY OF HAZARDOUS REACTIONS:
HAZARDOUS POLYMERIZATION DOES NOT OCCUR.
CONDITIONS TO AVOID:
AVOID TEMPERATURES EXCEEDING THE FLASH POINT. CONTACT WITH INCOMPATIBLE
MATERIALS.
INCOMPATIBLE MATERIALS: STRONG OXIDIZING AGENTS.
HAZARDOUS DECOMPOSITION PRODUCTS:
NO HAZARDOUS DECOMPOSITION PRODUCTS ARE KNOWN.
| 11. TOXICOLOGICAL INFORMATION | |
INFORMATION ON LIKELY ROUTES OF EXPOSURE:
INGESTION: CAUSES DIGESTIVE TRACT BURNS. HARMFUL IF SWALLOWED.
INHALATION: MAY CAUSE IRRITATION TO THE RESPIRATORY SYSTEM.
SKIN CONTACT:
CAUSES SEVERE SKIN BURNS. HARMFUL IN CONTACT WITH SKIN. MAY CAUSE AN
ALLERGIC SKIN REACTION.
EYE CONTACT: CAUSES SERIOUS EYE DAMAGE.
SYMPTOMS RELATED TO THE PHYSICAL, CHEMICAL AND TOXICOLOGICAL
CHARACTERISTICS:
BURNING PAIN AND SEVERE CORROSIVE SKIN DAMAGE. CAUSES SERIOUS EYE DAMAGE.
SYMPTOMS MAY INCLUDE STINGING, TEARING, REDNESS, SWELLING, AND BLURRED
VISION. PERMANENT EYE DAMAGE INCLUDING BLINDNESS COULD RESULT. MAY CAUSE
AN ALLERGIC SKIN REACTION. DERMATITIS. RASH.
INFORMATION ON TOXICOLOGICAL EFFECTS:
ACUTE TOXICITY:
HARMFUL IF SWALLOWED. HARMFUL IN CONTACT WITH SKIN. MAY CAUSE AN ALLERGIC
SKIN REACTION.
SKIN CORROSION/IRRITATION: CAUSES SEVERE SKIN BURNS AND EYE DAMAGE.
SERIOUS EYE DAMAGE/EYE IRRITATION: CAUSES SERIOUS EYE DAMAGE.
RESPIRATORY OR SKIN SENSITIZATION:
RESPIRATORY SENSITIZATION: NOT AVAILABLE.
SKIN SENSITIZATION: MAY CAUSE AN ALLERGIC SKIN REACTION.
GERM CELL MUTAGENICITY:
NO DATA AVAILABLE TO INDICATE PRODUCT OR ANY COMPONENTS PRESENT AT GREATER
THAN 0.1% ARE MUTAGENIC OR GENOTOXIC.
CARCINOGENICITY: NOT AVAILABLE.
REPRODUCTIVE TOXICITY:
THIS PRODUCT IS NOT EXPECTED TO CAUSE REPRODUCTIVE OR DEVELOPMENTAL
EFFECTS.
SPECIFIC TARGET ORGAN TOXICITY - SINGLE EXPOSURE: NOT CLASSIFIED.
SPECIFIC TARGET ORGAN TOXICITY - REPEATED EXPOSURE: NOT CLASSIFIED.
ASPIRATION HAZARD: NOT AVAILABLE.
| 12. ECOLOGICAL INFORMATION | |
ECOTOXICITY:
THE PRODUCT IS NOT CLASSIFIED AS ENVIRONMENTALLY HAZARDOUS. HOWEVER, THIS
DOES NOT EXCLUDE THE POSSIBILITY THAT LARGE OR FREQUENT SPILLS CAN HAVE A
HARMFUL OR DAMAGING EFFECT ON THE ENVIRONMENT.
PERSISTENCE AND DEGRADABILITY:
NO DATA IS AVAILABLE ON THE DEGRADABILITY OF THIS PRODUCT.
BIOACCUMULATIVE POTENTIAL: NO DATA AVAILABLE.
MOBILITY IN SOIL: NO DATA AVAILABLE.
OTHER ADVERSE EFFECTS:
NO OTHER ADVERSE ENVIRONMENTAL EFFECTS (E.G. OZONE DEPLETION, PHOTOCHEMICAL
OZONE CREATION POTENTIAL, ENDOCRINE DISRUPTION, GLOBAL WARMING POTENTIAL)
ARE EXPECTED FROM THIS COMPONENT.
| 13. DISPOSAL CONSIDERATIONS | |
DISPOSAL INSTRUCTIONS:
COLLECT AND RECLAIM OR DISPOSE IN SEALED CONTAINERS AT LICENSED WASTE
DISPOSAL SITE. THIS MATERIAL AND ITS CONTAINER MUST BE DISPOSED OF AS
HAZARDOUS WASTE. DO NOT ALLOW THIS MATERIAL TO DRAIN INTO SEWERS/WATER
SUPPLIES. DO NOT CONTAMINATE PONDS, WATERWAYS OR DITCHES WITH CHEMICAL OR
USED CONTAINER. DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH
LOCAL/REGIONAL/NATIONAL/INTERNATIONAL REGULATIONS.
LOCAL DISPOSAL REGULATIONS:
DISPOSE IN ACCORDANCE WITH ALL APPLICABLE REGULATIONS.
HAZARDOUS WASTE CODE:
THE WASTE CODE SHOULD BE ASSIGNED IN DISCUSSION BETWEEN THE USER, THE
PRODUCER AND THE WASTE DISPOSAL COMPANY.
WASTE FROM RESIDUES / UNUSED PRODUCTS:
DISPOSE OF IN ACCORDANCE WITH LOCAL REGULATIONS. EMPTY CONTAINERS OR LINERS
MAY RETAIN SOME PRODUCT RESIDUES. THIS MATERIAL AND ITS CONTAINER MUST BE
DISPOSED OF IN A SAFE MANNER (SEE: DISPOSAL INSTRUCTIONS).
CONTAMINATED PACKAGING:
EMPTY CONTAINERS SHOULD BE TAKEN TO AN APPROVED WASTE HANDLING SITE FOR
RECYCLING OR DISPOSAL. SINCE EMPTIED CONTAINERS MAY RETAIN PRODUCT RESIDUE,
FOLLOW LABEL WARNINGS EVEN AFTER CONTAINER IS EMPTIED.
| 14. TRANSPORT INFORMATION | |
DOT:
UN NUMBER: UN3066
UN PROPER SHIPPING NAME: PAINT
TRANSPORT HAZARD CLASS(ES):
CLASS: 8
SUBSIDIARY RISK:
LABEL(S): 8
PACKING GROUP: III
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
SPECIAL PROVISIONS: B52, IB3, T4, TP1, TP29
PACKAGING EXCEPTIONS: 154
PACKAGING NON BULK: 173
PACKAGING BULK: 241
IATA:
UN NUMBER: UN3066
UN PROPER SHIPPING NAME: PAINT
TRANSPORT HAZARD CLASS(ES):
CLASS: 8
SUBSIDIARY RISK:
PACKING GROUP: III
ENVIRONMENTAL HAZARDS: NO.
ERG CODE: 8L
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
OTHER INFORMATION:
PASSENGER AND CARGO AIRCRAFT: ALLOWED.
CARGO AIRCRAFT ONLY: ALLOWED.
IMDG:
UN NUMBER: UN3066
UN PROPER SHIPPING NAME: PAINT
TRANSPORT HAZARD CLASS(ES):
CLASS: 8
SUBSIDIARY RISK:
PACKING GROUP: III
ENVIRONMENTAL HAZARDS:
MARINE POLLUTANT: NO.
EMS: F-A, S-B
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
TRANSPORT IN BULK ACCORDING TO ANNEX II OF MARPOL 73/78 AND THE IBC CODE:
NOT AVAILABLE.
DOT: CORROSIVE, CLASS/DIVISION 8
IATA; IMDG: CLASS 8, CORROSIVES
| 15. REGULATORY INFORMATION | |
US FEDERAL REGULATIONS:
THIS PRODUCT IS A "HAZARDOUS CHEMICAL" AS DEFINED BY THE OSHA HAZARD
COMMUNICATION STANDARD, 29 CFR 1910.1200.
TSCA SECTION 12(B) EXPORT NOTIFICATION (40 CFR 707, SUBPT. D):
NOT REGULATED.
CERCLA HAZARDOUS SUBSTANCE LIST (40 CFR 302.4): NOT LISTED.
US. OSHA SPECIFICALLY REGULATED SUBSTANCES (29 CFR 1910.1001-1050):
NOT LISTED.
SARA 304 EMERGENCY RELEASE NOTIFICATION: NOT REGULATED.
SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 (SARA):
HAZARD CATEGORIES:
IMMEDIATE HAZARD: YES
DELAYED HAZARD: NO
FIRE HAZARD: NO
PRESSURE HAZARD: NO
REACTIVITY HAZARD: NO
SARA 302 EXTREMELY HAZARDOUS SUBSTANCE: NO
SARA 311/312 HAZARDOUS CHEMICAL: NO
SARA 313 (TRI REPORTING): NOT REGULATED.
OTHER FEDERAL REGULATIONS:
CLEAN AIR ACT (CAA) SECTION 112 HAZARDOUS AIR POLLUTANTS (HAPS) LIST:
NOT REGULATED.
CLEAN AIR ACT (CAA) SECTION 112(R) ACCIDENTAL RELEASE PREVENTION
(40 CFR 68.130): NOT REGULATED.
SAFE DRINKING WATER ACT (SDWA): NOT REGULATED.
US STATE REGULATIONS:
US. MASSACHUSETTS RTK - SUBSTANCE LIST: NOT REGULATED.
US. NEW JERSEY WORKER AND COMMUNITY RIGHT-TO-KNOW ACT: NOT REGULATED.
US. PENNSYLVANIA RTK - HAZARDOUS SUBSTANCES: NOT REGULATED.
US. RHODE ISLAND RTK: NOT REGULATED.
US. CALIFORNIA PROPOSITION 65:
CALIFORNIA SAFE DRINKING WATER AND TOXIC ENFORCEMENT ACT OF 1986
(PROPOSITION 65):
THIS MATERIAL IS NOT KNOWN TO CONTAIN ANY CHEMICALS CURRENTLY LISTED AS
CARCINOGENS OR REPRODUCTIVE TOXINS.
INTERNATIONAL INVENTORIES:
COUNTRY(S) OR REGION INVENTORY NAME ON INVENTORY
(YES/NO)*
AUSTRALIA AUSTRALIAN INVENTORY OF CHEMICAL NO
SUBSTANCES (AICS)
CANADA DOMESTIC SUBSTANCES LIST (DSL) NO
CANADA NON-DOMESTIC SUBSTANCES LIST (NDSL) YES
CHINA INVENTORY OF EXISTING CHEMICAL YES
SUBSTANCES IN CHINA (IECSC)
EUROPE EUROPEAN INVENTORY OF EXISTING NO
COMMERCIAL CHEMICAL SUBSTANCES (EINECS)
EUROPE EUROPEAN LIST OF NOTIFIED CHEMICAL NO
SUBSTANCES (ELINCS)
JAPAN INVENTORY OF EXISTING AND NEW CHEMICAL NO
SUBSTANCES (ENCS)
KOREA EXISTING CHEMICALS LIST (ECL) NO
NEW ZEALAND NEW ZEALAND INVENTORY YES
PHILIPPINES PHILIPPINE INVENTORY OF CHEMICALS AND YES
CHEMICAL SUBSTANCES (PICCS)
UNITED STATES & TOXIC SUBSTANCES CONTROL ACT (TSCA) YES
PUERTO RICO INVENTORY
*A "YES" INDICATES THAT ALL COMPONENTS OF THIS PRODUCT COMPLY WITH THE
INVENTORY REQUIREMENTS ADMINISTERED BY THE GOVERNING COUNTRY(S)
A "NO" INDICATES THAT ONE OR MORE COMPONENTS OF THE PRODUCT ARE NOT LISTED
OR EXEMPT FROM LISTING ON THE INVENTORY ADMINISTERED BY THE GOVERNING
COUNTRY(S).
| 16. OTHER INFORMATION, INCLUDING DATE OF PREPARATION | |
OR LAST REVISION
ISSUE DATE: 04-03-2014
VERSION #: 01
HMIS(R*) RATINGS:
HEALTH 3
FLAMMABILITY 1
PHYSICAL HAZARD 1
PERSONAL PROTECTION X
NFPA RATINGS:
HEALTH 3
FLAMMABILITY 1
INSTABILITY 1
DISCLAIMER:
THE INFORMATION IN THE SHEET WAS WRITTEN BASED ON THE BEST KNOWLEDGE AND
EXPERIENCE CURRENTLY AVAILABLE.
MATERIAL NAME: AMERICAN SAFETY TECHNOLOGIES AS-2500 SC HARDENER - PART B
2151
SDS US