| Common Name: | PLASTIC ADHESIVE 2262 |
| Manufacturer: | 3M |
| SDS Revision Date: | 4/27/2015 |
| SDS Format: | GHS-US |
| Item Number(s): | 2RUE8 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
3M(TM) PLASTIC ADHESIVE 2262
04/27/15
3M
SAFETY DATA SHEET
COPYRIGHT, 2015, 3M COMPANY.
ALL RIGHTS RESERVED. COPYING AND/OR DOWNLOADING OF THIS INFORMATION FOR THE
PURPOSE OF PROPERLY UTILIZING 3M PRODUCTS IS ALLOWED PROVIDED THAT:
(1) THE INFORMATION IS COPIED IN FULL WITH NO CHANGES UNLESS PRIOR WRITTEN
AGREEMENT IS OBTAINED FROM 3M, AND
(2) NEITHER THE COPY NOR THE ORIGINAL IS RESOLD OR OTHERWISE DISTRIBUTED
WITH THE INTENTION OF EARNING A PROFIT THEREON.
DOCUMENT GROUP: 10-2971-9
VERSION NUMBER: 30.00
ISSUE DATE: 04/27/15
SUPERCEDES DATE: 09/29/10
| SECTION 1: IDENTIFICATION |  |
1.1. PRODUCT IDENTIFIER: 3M(TM) PLASTIC ADHESIVE 2262
PRODUCT IDENTIFICATION NUMBERS:
62-2262-6530-4, 62-2262-6535-3, 62-2262-8530-2
1.2. RECOMMENDED USE AND RESTRICTIONS ON USE:
RECOMMENDED USE: ADHESIVE, INDUSTRIAL USE
1.3. SUPPLIER'S DETAILS:
MANUFACTURER: 3M
DIVISION: INDUSTRIAL ADHESIVES AND TAPES DIVISION
ADDRESS:
3M CENTER
ST. PAUL, MN 55144-1000
USA
TELEPHONE: 1-888-3M HELPS (1-888-364-3577)
1.4. EMERGENCY TELEPHONE NUMBER:
1-800-364-3577 OR (651) 737-6501 (24 HOURS)
| SECTION 2: HAZARD IDENTIFICATION | |
2.1. HAZARD CLASSIFICATION:
FLAMMABLE LIQUID: CATEGORY 2.
SERIOUS EYE DAMAGE/IRRITATION: CATEGORY 1.
SKIN SENSITIZER: CATEGORY 1.
SPECIFIC TARGET ORGAN TOXICITY (CENTRAL NERVOUS SYSTEM): CATEGORY 3.
2.2. LABEL ELEMENTS:
SIGNAL WORD: DANGER
SYMBOLS:
FLAME
CORROSION
EXCLAMATION MARK
PICTOGRAMS:
FLAME
CORROSION
EXCLAMATION MARK
HAZARD STATEMENTS:
HIGHLY FLAMMABLE LIQUID AND VAPOR.
CAUSES SERIOUS EYE DAMAGE.
MAY CAUSE AN ALLERGIC SKIN REACTION.
MAY CAUSE DROWSINESS OR DIZZINESS.
PRECAUTIONARY STATEMENTS:
PREVENTION:
KEEP AWAY FROM HEAT/SPARKS/OPEN FLAMES/HOT SURFACES. - NO SMOKING.
GROUND/BOND CONTAINER AND RECEIVING EQUIPMENT.
USE ONLY NON-SPARKING TOOLS.
TAKE PRECAUTIONARY MEASURES AGAINST STATIC DISCHARGE.
KEEP CONTAINER TIGHTLY CLOSED.
USE EXPLOSION-PROOF ELECTRICAL/VENTILATING/LIGHTING EQUIPMENT.
AVOID BREATHING DUST/FUME/GAS/MIST/VAPORS/SPRAY.
USE ONLY OUTDOORS OR IN A WELL-VENTILATED AREA.
WEAR PROTECTIVE GLOVES AND EYE/FACE PROTECTION.
CONTAMINATED WORK CLOTHING MUST NOT BE ALLOWED OUT OF THE WORKPLACE.
RESPONSE:
IF INHALED: REMOVE PERSON TO FRESH AIR AND KEEP COMFORTABLE FOR BREATHING.
IF ON SKIN (OR HAIR):
TAKE OFF IMMEDIATELY ALL CONTAMINATED CLOTHING. RINSE SKIN WITH
WATER/SHOWER.
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES,
IF PRESENT AND EASY TO DO. CONTINUE RINSING.
IMMEDIATELY CALL A POISON CENTER OR DOCTOR/PHYSICIAN.
IF SKIN IRRITATION OR RASH OCCURS: GET MEDICAL ADVICE/ATTENTION.
WASH CONTAMINATED CLOTHING BEFORE REUSE.
IN CASE OF FIRE:
USE A FIRE FIGHTING AGENT SUITABLE FOR FLAMMABLE LIQUIDS SUCH AS DRY
CHEMICAL OR CARBON DIOXIDE TO EXTINGUISH.
STORAGE:
KEEP COOL.
KEEP CONTAINER TIGHTLY CLOSED.
STORE LOCKED UP IN A WELL-VENTILATED PLACE.
DISPOSAL:
DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH APPLICABLE
LOCAL/REGIONAL/NATIONAL/INTERNATIONAL REGULATIONS.
2.3. HAZARDS NOT OTHERWISE CLASSIFIED: NONE.
| SECTION 3: COMPOSITION/INFORMATION ON INGREDIENTS | |
INGREDIENT C.A.S. NO. % BY WT
ACETONE 67-64-1 65 - 75 TRADE SECRET *
ACRYLIC POLYMER TRADE SECRET* 20 - 30 TRADE SECRET *
TETRAHYDROFURAN 109-99-9 3 - 7 TRADE SECRET *
GLYCEROL ESTERS OF ROSIN ACIDS 8050-31-5 1 - 5 TRADE SECRET *
NITRILE RUBBER 9010-81-5 0.5 - 1.5 TRADE SECRET *
UNREACTED MONOMERS TRADE SECRET* <1 TRADE SECRET *
*THE SPECIFIC CHEMICAL IDENTITY AND/OR EXACT PERCENTAGE (CONCENTRATION)
OF THIS COMPOSITION HAS BEEN WITHHELD AS A TRADE SECRET.
| SECTION 4: FIRST AID MEASURES | |
4.1. DESCRIPTION OF FIRST AID MEASURES:
INHALATION:
REMOVE PERSON TO FRESH AIR. IF YOU FEEL UNWELL, GET MEDICAL ATTENTION.
SKIN CONTACT:
IMMEDIATELY WASH WITH SOAP AND WATER. REMOVE CONTAMINATED CLOTHING AND WASH
BEFORE REUSE. IF SIGNS/SYMPTOMS DEVELOP, GET MEDICAL ATTENTION.
EYE CONTACT:
IMMEDIATELY FLUSH WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15 MINUTES.
REMOVE CONTACT LENSES IF EASY TO DO. CONTINUE RINSING. IMMEDIATELY GET
MEDICAL ATTENTION.
IF SWALLOWED:
RINSE MOUTH. IF YOU FEEL UNWELL, GET MEDICAL ATTENTION.
4.2. MOST IMPORTANT SYMPTOMS AND EFFECTS, BOTH ACUTE AND DELAYED:
SEE SECTION 11.1. INFORMATION ON TOXICOLOGICAL EFFECTS.
4.3. INDICATION OF ANY IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT
REQUIRED: NOT APPLICABLE
| SECTION 5: FIRE-FIGHTING MEASURES | |
5.1. SUITABLE EXTINGUISHING MEDIA:
IN CASE OF FIRE:
USE A FIRE FIGHTING AGENT SUITABLE FOR FLAMMABLE LIQUIDS SUCH AS DRY
CHEMICAL OR CARBON DIOXIDE TO EXTINGUISH.
5.2. SPECIAL HAZARDS ARISING FROM THE SUBSTANCE OR MIXTURE:
CLOSED CONTAINERS EXPOSED TO HEAT FROM FIRE MAY BUILD PRESSURE AND EXPLODE.
HAZARDOUS DECOMPOSITION OR BY-PRODUCTS:
SUBSTANCE CONDITION
CARBON MONOXIDE DURING COMBUSTION
CARBON DIOXIDE DURING COMBUSTION
5.3. SPECIAL PROTECTIVE ACTIONS FOR FIRE-FIGHTERS:
WATER MAY NOT EFFECTIVELY EXTINGUISH FIRE; HOWEVER, IT SHOULD BE USED TO
KEEP FIRE-EXPOSED CONTAINERS AND SURFACES COOL AND PREVENT EXPLOSIVE
RUPTURE.
| SECTION 6: ACCIDENTAL RELEASE MEASURES | |
6.1. PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
EVACUATE AREA. KEEP AWAY FROM HEAT/SPARKS/OPEN FLAMES/HOT SURFACES. - NO
SMOKING. USE ONLY NON-SPARKING TOOLS. VENTILATE THE AREA WITH FRESH AIR.
FOR LARGE SPILL, OR SPILLS IN CONFINED SPACES, PROVIDE MECHANICAL
VENTILATION TO DISPERSE OR EXHAUST VAPORS, IN ACCORDANCE WITH GOOD
INDUSTRIAL HYGIENE PRACTICE.
WARNING!
A MOTOR COULD BE AN IGNITION SOURCE AND COULD CAUSE FLAMMABLE GASES OR
VAPORS IN THE SPILL AREA TO BURN OR EXPLODE. REFER TO OTHER SECTIONS OF
THIS SDS FOR INFORMATION REGARDING PHYSICAL AND HEALTH HAZARDS, RESPIRATORY
PROTECTION, VENTILATION, AND PERSONAL PROTECTIVE EQUIPMENT.
6.2. ENVIRONMENTAL PRECAUTIONS:
AVOID RELEASE TO THE ENVIRONMENT. FOR LARGER SPILLS, COVER DRAINS AND BUILD
DIKES TO PREVENT ENTRY INTO SEWER SYSTEMS OR BODIES OF WATER.
6.3. METHODS AND MATERIAL FOR CONTAINMENT AND CLEANING UP:
CONTAIN SPILL. COVER SPILL AREA WITH A FIRE-EXTINGUISHING FOAM. AN
APPROPRIATE AQUEOUS FILM FORMING FOAM (AFFF) IS RECOMMENDED. WORKING FROM
AROUND THE EDGES OF THE SPILL INWARD, COVER WITH BENTONITE, VERMICULITE, OR
COMMERCIALLY AVAILABLE INORGANIC ABSORBENT MATERIAL. MIX IN SUFFICIENT
ABSORBENT UNTIL IT APPEARS DRY. REMEMBER, ADDING AN ABSORBENT MATERIAL DOES
NOT REMOVE A PHYSICAL, HEALTH, OR ENVIRONMENTAL HAZARD. COLLECT AS MUCH OF
THE SPILLED MATERIAL AS POSSIBLE USING NON-SPARKING TOOLS. PLACE IN A METAL
CONTAINER APPROVED FOR TRANSPORTATION BY APPROPRIATE AUTHORITIES. CLEAN UP
RESIDUE WITH AN APPROPRIATE SOLVENT SELECTED BY A QUALIFIED AND AUTHORIZED
PERSON. VENTILATE THE AREA WITH FRESH AIR. READ AND FOLLOW SAFETY
PRECAUTIONS ON THE SOLVENT LABEL AND SDS. SEAL THE CONTAINER. DISPOSE OF
COLLECTED MATERIAL AS SOON AS POSSIBLE.
| SECTION 7: HANDLING AND STORAGE | |
7.1. PRECAUTIONS FOR SAFE HANDLING:
FOR INDUSTRIAL OR PROFESSIONAL USE ONLY. KEEP AWAY FROM HEAT/SPARKS/OPEN
FLAMES/HOT SURFACES. - NO SMOKING. USE ONLY NON-SPARKING TOOLS. TAKE
PRECAUTIONARY MEASURES AGAINST STATIC DISCHARGE. AVOID BREATHING
DUST/FUME/GAS/MIST/VAPORS/SPRAY. DO NOT GET IN EYES, ON SKIN, OR ON
CLOTHING. DO NOT EAT, DRINK OR SMOKE WHEN USING THIS PRODUCT. WASH
THOROUGHLY AFTER HANDLING. CONTAMINATED WORK CLOTHING SHOULD NOT BE ALLOWED
OUT OF THE WORKPLACE. WASH CONTAMINATED CLOTHING BEFORE REUSE. AVOID
CONTACT WITH OXIDIZING AGENTS (EG. CHLORINE, CHROMIC ACID ETC.) WEAR LOW
STATIC OR PROPERLY GROUNDED SHOES. TO MINIMIZE THE RISK OF IGNITION,
DETERMINE APPLICABLE ELECTRICAL CLASSIFICATIONS FOR THE PROCESS USING THIS
PRODUCT AND SELECT SPECIFIC LOCAL EXHAUST VENTILATION EQUIPMENT TO AVOID
FLAMMABLE VAPOR ACCUMULATION. GROUND/BOND CONTAINER AND RECEIVING EQUIPMENT
IF THERE IS POTENTIAL FOR STATIC ELECTRICITY ACCUMULATION DURING TRANSFER.
7.2. CONDITIONS FOR SAFE STORAGE INCLUDING ANY INCOMPATIBILITIES:
STORE IN A WELL-VENTILATED PLACE. KEEP COOL. KEEP CONTAINER TIGHTLY CLOSED.
STORE AWAY FROM HEAT. STORE AWAY FROM ACIDS. STORE AWAY FROM OXIDIZING
AGENTS.
| SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION | |
8.1. CONTROL PARAMETERS:
OCCUPATIONAL EXPOSURE LIMITS:
IF A COMPONENT IS DISCLOSED IN SECTION 3 BUT DOES NOT APPEAR IN THE TABLE
BELOW, AN OCCUPATIONAL EXPOSURE LIMIT IS NOT AVAILABLE FOR THE COMPONENT.
INGREDIENT C.A.S. NO. AGENCY LIMIT TYPE ADDITIONAL COMMENTS
TETRAHYDROFURAN 109-99-9 OSHA TWA:
590 MG/M3
(200 PPM)
TETRAHYDROFURAN 109-99-9 CMRG TWA: 25 PPM
STEL: 75 PPM
TETRAHYDROFURAN 109-99-9 ACGIH TWA: 50 PPM A3:
STEL: 100 PPM CONFIRMED ANIMAL
CARCIN., SKIN NOTATION
ACETONE 67-64-1 OSHA TWA:
2400 MG/M3
(1000 PPM)
ACETONE 67-64-1 ACGIH TWA: 500 PPM A4:
STEL: 750 PPM NOT CLASS. AS HUMAN
CARCIN
ACGIH: AMERICAN CONFERENCE OF GOVERNMENTAL INDUSTRIAL HYGIENISTS
AIHA: AMERICAN INDUSTRIAL HYGIENE ASSOCIATION
CMRG: CHEMICAL MANUFACTURER'S RECOMMENDED GUIDELINES
OSHA:
UNITED STATES DEPARTMENT OF LABOR - OCCUPATIONAL SAFETY AND HEALTH
ADMINISTRATION
TWA: TIME-WEIGHTED-AVERAGE
STEL: SHORT TERM EXPOSURE LIMIT
CEIL: CEILING
8.2. EXPOSURE CONTROLS:
8.2.1. ENGINEERING CONTROLS:
USE GENERAL DILUTION VENTILATION AND/OR LOCAL EXHAUST VENTILATION TO
CONTROL AIRBORNE EXPOSURES TO BELOW RELEVANT EXPOSURE LIMITS AND/OR CONTROL
DUST/FUME/GAS/MIST/VAPORS/SPRAY. IF VENTILATION IS NOT ADEQUATE, USE
RESPIRATORY PROTECTION EQUIPMENT. USE EXPLOSION-PROOF VENTILATION
EQUIPMENT.
8.2.2. PERSONAL PROTECTIVE EQUIPMENT (PPE):
EYE/FACE PROTECTION:
SELECT AND USE EYE/FACE PROTECTION TO PREVENT CONTACT BASED ON THE RESULTS
OF AN EXPOSURE ASSESSMENT.
THE FOLLOWING EYE/FACE PROTECTION(S) ARE RECOMMENDED:
FULL FACE SHIELD
INDIRECT VENTED GOGGLES
SKIN/HAND PROTECTION:
SELECT AND USE GLOVES AND/OR PROTECTIVE CLOTHING APPROVED TO RELEVANT LOCAL
STANDARDS TO PREVENT SKIN CONTACT BASED ON THE RESULTS OF AN EXPOSURE
ASSESSMENT. SELECTION SHOULD BE BASED ON USE FACTORS SUCH AS EXPOSURE
LEVELS, CONCENTRATION OF THE SUBSTANCE OR MIXTURE, FREQUENCY AND DURATION,
PHYSICAL CHALLENGES SUCH AS TEMPERATURE EXTREMES, AND OTHER USE CONDITIONS.
CONSULT WITH YOUR GLOVE AND/OR PROTECTIVE CLOTHING MANUFACTURER FOR
SELECTION OF APPROPRIATE COMPATIBLE GLOVES/PROTECTIVE CLOTHING.
NOTE:
NITRILE GLOVES MAY BE WORN OVER POLYMER LAMINATE GLOVES TO IMPROVE
DEXTERITY.
GLOVES MADE FROM THE FOLLOWING MATERIAL(S) ARE RECOMMENDED:
POLYMER LAMINATE
IF THIS PRODUCT IS USED IN A MANNER THAT PRESENTS A HIGHER POTENTIAL FOR
EXPOSURE (EG. SPRAYING, HIGH SPLASH POTENTIAL ETC.), THEN USE OF PROTECTIVE
COVERALLS MAY BE NECESSARY. SELECT AND USE BODY PROTECTION TO PREVENT
CONTACT BASED ON THE RESULTS OF AN EXPOSURE ASSESSMENT.
THE FOLLOWING PROTECTIVE CLOTHING MATERIAL(S) ARE RECOMMENDED:
APRON - POLYMER LAMINATE
RESPIRATORY PROTECTION:
AN EXPOSURE ASSESSMENT MAY BE NEEDED TO DECIDE IF A RESPIRATOR IS REQUIRED.
IF A RESPIRATOR IS NEEDED, USE RESPIRATORS AS PART OF A FULL RESPIRATORY
PROTECTION PROGRAM. BASED ON THE RESULTS OF THE EXPOSURE ASSESSMENT, SELECT
FROM THE FOLLOWING RESPIRATOR TYPE(S) TO REDUCE INHALATION EXPOSURE:
HALF FACEPIECE OR FULL FACEPIECE AIR-PURIFYING RESPIRATOR SUITABLE FOR
ORGANIC VAPORS AND PARTICULATES
FOR QUESTIONS ABOUT SUITABILITY FOR A SPECIFIC APPLICATION, CONSULT WITH
YOUR RESPIRATOR MANUFACTURER.
| SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES | |
9.1. INFORMATION ON BASIC PHYSICAL AND CHEMICAL PROPERTIES:
GENERAL PHYSICAL FORM: LIQUID
ODOR, COLOR, GRADE: CLEAR LIQUID - KETONE ODOR
ODOR THRESHOLD: NO DATA AVAILABLE
PH: NOT APPLICABLE
MELTING POINT: NOT APPLICABLE
BOILING POINT: >=56 DEG. C [DETAILS: ACETONE]
FLASH POINT: -4 DEG. F [TEST METHOD: CLOSED CUP] [DETAILS: ACETONE]
EVAPORATION RATE: 1.9 [REF STD: ETHER=1]
FLAMMABILITY (SOLID, GAS): NOT APPLICABLE
FLAMMABLE LIMITS(LEL): 1.8% VOLUME
FLAMMABLE LIMITS(UEL): 12.8% VOLUME
VAPOR PRESSURE: <=185 MMHg [@ 68 DEG. F]
VAPOR DENSITY: 2 [REF STD: AIR=1]
DENSITY: 0.89 G/ML
SPECIFIC GRAVITY: 0.89 [REF STD: WATER=1]
SOLUBILITY IN WATER: SLIGHT (LESS THAN 10%)
SOLUBILITY- NON-WATER: NO DATA AVAILABLE
PARTITION COEFFICIENT N-OCTANOL/ WATER: NO DATA AVAILABLE
AUTOIGNITION TEMPERATURE: 465 DEG. C [DETAILS: ACETONE]
DECOMPOSITION TEMPERATURE: NO DATA AVAILABLE
VISCOSITY: 375 - 675 CENTIPOISE [@ 73.4 DEG. F]
HAZARDOUS AIR POLLUTANTS: 0% WEIGHT [TEST METHOD: CALCULATED]
VOC LESS H2O & EXEMPT SOLVENTS:
<=183 G/L [TEST METHOD: CALCULATED SCAQMD RULE 443.1]
SOLIDS CONTENT: 21 - 37%
| SECTION 10: STABILITY AND REACTIVITY | |
10.1. REACTIVITY:
THIS MATERIAL MAY BE REACTIVE WITH CERTAIN AGENTS UNDER CERTAIN
CONDITIONS - SEE THE REMAINING HEADINGS IN THIS SECTION.
10.2. CHEMICAL STABILITY: STABLE.
10.3. POSSIBILITY OF HAZARDOUS REACTIONS:
HAZARDOUS POLYMERIZATION WILL NOT OCCUR.
10.4. CONDITIONS TO AVOID:
HEAT
SPARKS AND/OR FLAMES
10.5. INCOMPATIBLE MATERIALS: STRONG OXIDIZING AGENTS
10.6. HAZARDOUS DECOMPOSITION PRODUCTS:
SUBSTANCE CONDITION
NONE KNOWN.
REFER TO SECTION 5.2 FOR HAZARDOUS DECOMPOSITION PRODUCTS DURING
COMBUSTION.
| SECTION 11: TOXICOLOGICAL INFORMATION | |
THE INFORMATION BELOW MAY NOT BE CONSISTENT WITH THE MATERIAL
CLASSIFICATION IN SECTION 2 IF SPECIFIC INGREDIENT CLASSIFICATIONS ARE
MANDATED BY A COMPETENT AUTHORITY. IN ADDITION, TOXICOLOGICAL DATA ON
INGREDIENTS MAY NOT BE REFLECTED IN THE MATERIAL CLASSIFICATION AND/OR THE
SIGNS AND SYMPTOMS OF EXPOSURE, BECAUSE AN INGREDIENT MAY BE PRESENT BELOW
THE THRESHOLD FOR LABELING, AN INGREDIENT MAY NOT BE AVAILABLE FOR
EXPOSURE, OR THE DATA MAY NOT BE RELEVANT TO THE MATERIAL AS A WHOLE.
11.1. INFORMATION ON TOXICOLOGICAL EFFECTS:
SIGNS AND SYMPTOMS OF EXPOSURE:
BASED ON TEST DATA AND/OR INFORMATION ON THE COMPONENTS, THIS MATERIAL MAY
PRODUCE THE FOLLOWING HEALTH EFFECTS:
INHALATION:
RESPIRATORY TRACT IRRITATION:
SIGNS/SYMPTOMS MAY INCLUDE COUGH, SNEEZING, NASAL DISCHARGE, HEADACHE,
HOARSENESS, AND NOSE AND THROAT PAIN.
MAY CAUSE ADDITIONAL HEALTH EFFECTS (SEE BELOW).
SKIN CONTACT:
DERMAL DEFATTING:
SIGNS/SYMPTOMS MAY INCLUDE LOCALIZED REDNESS, ITCHING, DRYING AND CRACKING
OF SKIN.
ALLERGIC SKIN REACTION (NON-PHOTO INDUCED):
SIGNS/SYMPTOMS MAY INCLUDE REDNESS, SWELLING, BLISTERING, AND ITCHING.
EYE CONTACT:
CORROSIVE (EYE BURNS):
SIGNS/SYMPTOMS MAY INCLUDE CLOUDY APPEARANCE OF THE CORNEA, CHEMICAL BURNS,
SEVERE PAIN, TEARING, ULCERATIONS, SIGNIFICANTLY IMPAIRED VISION OR
COMPLETE LOSS OF VISION.
INGESTION:
GASTROINTESTINAL IRRITATION:
SIGNS/SYMPTOMS MAY INCLUDE ABDOMINAL PAIN, STOMACH UPSET, NAUSEA, VOMITING
AND DIARRHEA.
MAY CAUSE ADDITIONAL HEALTH EFFECTS (SEE BELOW).
ADDITIONAL HEALTH EFFECTS:
SINGLE EXPOSURE MAY CAUSE TARGET ORGAN EFFECTS:
CENTRAL NERVOUS SYSTEM (CNS) DEPRESSION:
SIGNS/SYMPTOMS MAY INCLUDE HEADACHE, DIZZINESS, DROWSINESS, INCOORDINATION,
NAUSEA, SLOWED REACTION TIME, SLURRED SPEECH, GIDDINESS, AND
UNCONSCIOUSNESS.
TOXICOLOGICAL DATA:
IF A COMPONENT IS DISCLOSED IN SECTION 3 BUT DOES NOT APPEAR IN A TABLE
BELOW, EITHER NO DATA ARE AVAILABLE FOR THAT ENDPOINT OR THE DATA ARE NOT
SUFFICIENT FOR CLASSIFICATION.
ACUTE TOXICITY:
NAME ROUTE SPECIES VALUE
OVERALL PRODUCT INGESTION NO DATA AVAILABLE;
CALCULATED ATE:
>5,000 MG/KG
ACETONE DERMAL RABBIT LD50: >15,688 MG/KG
ACETONE INHALATION- RAT LC50: 76 MG/L
VAPOR
(4 HOURS)
ACETONE INGESTION RAT LD50: 5,800 MG/KG
TETRAHYDROFURAN DERMAL RAT LD50: >2,000 MG/KG
TETRAHYDROFURAN INHALATION- RAT LC50: 54 MG/L
VAPOR
(4 HOURS)
TETRAHYDROFURAN INGESTION RAT LD50: 3,180 MG/KG
GLYCEROL ESTERS OF DERMAL RABBIT LD50: >5,000 MG/KG
ROSIN ACIDS
GLYCEROL ESTERS OF INGESTION RAT LD50: >2,000 MG/KG
ROSIN ACIDS
NITRILE RUBBER DERMAL LD50 ESTIMATED TO BE
>5,000 MG/KG
NITRILE RUBBER INGESTION LD50 ESTIMATED TO BE
2,000 - 5,000 MG/KG
ATE = ACUTE TOXICITY ESTIMATE
SKIN CORROSION/IRRITATION:
NAME SPECIES VALUE
ACETONE MOUSE MINIMAL IRRITATION
TETRAHYDROFURAN RABBIT MINIMAL IRRITATION
GLYCEROL ESTERS OF ROSIN ACIDS RABBIT MINIMAL IRRITATION
NITRILE RUBBER PROFESSIONAL NO SIGNIFICANT IRRITATION
JUDGEMENT
SERIOUS EYE DAMAGE/IRRITATION:
NAME SPECIES VALUE
ACETONE RABBIT SEVERE IRRITANT
TETRAHYDROFURAN RABBIT CORROSIVE
GLYCEROL ESTERS OF ROSIN ACIDS RABBIT MILD IRRITANT
NITRILE RUBBER PROFESSIONAL NO SIGNIFICANT IRRITATION
JUDGEMENT
SKIN SENSITIZATION:
NAME SPECIES VALUE
TETRAHYDROFURAN HUMAN AND ANIMAL NOT SENSITIZING
GLYCEROL ESTERS OF ROSIN ACIDS GUINEA PIG NOT SENSITIZING
RESPIRATORY SENSITIZATION:
FOR THE COMPONENT/COMPONENTS, EITHER NO DATA ARE CURRENTLY AVAILABLE OR
THE DATA ARE NOT SUFFICIENT FOR CLASSIFICATION.
GERM CELL MUTAGENICITY:
NAME ROUTE VALUE
ACETONE IN VIVO NOT MUTAGENIC
ACETONE IN VITRO SOME POSITIVE DATA EXIST, BUT
THE DATA ARE NOT SUFFICIENT FOR
CLASSIFICATION
TETRAHYDROFURAN IN VITRO NOT MUTAGENIC
TETRAHYDROFURAN IN VIVO NOT MUTAGENIC
GLYCEROL ESTERS OF ROSIN ACIDS IN VITRO NOT MUTAGENIC
CARCINOGENICITY:
NAME ROUTE SPECIES VALUE
ACETONE NOT SPECIFIED MULTIPLE ANIMAL SPECIES NOT CARCINOGENIC
TETRAHYDROFURAN INHALATION MULTIPLE ANIMAL SPECIES SOME POSITIVE DATA
EXIST, BUT THE
DATA ARE NOT
SUFFICIENT FOR
CLASSIFICATION
REPRODUCTIVE TOXICITY:
REPRODUCTIVE AND/OR DEVELOPMENTAL EFFECTS:
NAME ROUTE VALUE
ACETONE INGESTION NOT TOXIC TO FEMALE REPRODUCTION
ACETONE INGESTION SOME POSITIVE MALE REPRODUCTIVE DATA
EXIST, BUT THE DATA ARE NOT SUFFICIENT
FOR CLASSIFICATION
ACETONE INHALATION SOME POSITIVE DEVELOPMENTAL DATA EXIST,
BUT THE DATA ARE NOT SUFFICIENT FOR
CLASSIFICATION
TETRAHYDROFURAN INGESTION NOT TOXIC TO FEMALE REPRODUCTION
TETRAHYDROFURAN INGESTION NOT TOXIC TO MALE REPRODUCTION
TETRAHYDROFURAN INGESTION SOME POSITIVE DEVELOPMENTAL DATA EXIST,
BUT THE DATA ARE NOT SUFFICIENT FOR
CLASSIFICATION
TETRAHYDROFURAN INHALATION SOME POSITIVE DEVELOPMENTAL DATA EXIST,
BUT THE DATA ARE NOT SUFFICIENT FOR
CLASSIFICATION
GLYCEROL ESTERS OF INGESTION NOT TOXIC TO FEMALE REPRODUCTION
ROSIN ACIDS
GLYCEROL ESTERS OF INGESTION NOT TOXIC TO MALE REPRODUCTION
ROSIN ACIDS
NAME SPECIES TEST RESULT EXPOSURE DURATION
ACETONE MOUSE NOAEL: 11,298 MG/KG/DAY 13 WEEKS
ACETONE RAT NOAEL: 1,700 MG/KG/DAY 13 WEEKS
ACETONE RAT NOAEL: 5.2 MG/L DURING ORGANOGENESIS
TETRAHYDROFURAN RAT NOAEL: 782 MG/KG/DAY 2 GENERATION
TETRAHYDROFURAN RAT NOAEL: 782 MG/KG/DAY 2 GENERATION
TETRAHYDROFURAN RAT NOAEL: 305 MG/KG/DAY 2 GENERATION
TETRAHYDROFURAN MOUSE NOAEL: 1.8 MG/L DURING GESTATION
GLYCEROL ESTERS OF RAT NOAEL: 5,000 MG/KG/DAY 90 DAYS
ROSIN ACIDS
GLYCEROL ESTERS OF RAT NOAEL: 5,000 MG/KG/DAY 90 DAYS
ROSIN ACIDS
TARGET ORGAN(S):
SPECIFIC TARGET ORGAN TOXICITY - SINGLE EXPOSURE:
NAME ROUTE TARGET ORGAN(S) VALUE
ACETONE INHALATION CENTRAL NERVOUS MAY CAUSE DROWSINESS OR
SYSTEM DEPRESSION DIZZINESS
ACETONE INHALATION RESPIRATORY SOME POSITIVE DATA EXIST,
IRRITATION BUT THE DATA ARE NOT
SUFFICIENT FOR
CLASSIFICATION
ACETONE INHALATION IMMUNE SYSTEM SOME POSITIVE DATA EXIST,
BUT THE DATA ARE NOT
SUFFICIENT FOR
CLASSIFICATION
ACETONE INHALATION LIVER SOME POSITIVE DATA EXIST,
BUT THE DATA ARE NOT
SUFFICIENT FOR
CLASSIFICATION
ACETONE INGESTION CENTRAL NERVOUS MAY CAUSE DROWSINESS OR
SYSTEM DEPRESSION DIZZINESS
TETRAHYDROFURAN INHALATION CENTRAL NERVOUS MAY CAUSE DROWSINESS OR
SYSTEM DEPRESSION DIZZINESS
TETRAHYDROFURAN INHALATION RESPIRATORY MAY CAUSE RESPIRATORY
IRRITATION IRRITATION
TETRAHYDROFURAN INHALATION RESPIRATORY SOME POSITIVE DATA EXIST,
SYSTEM BUT THE DATA ARE NOT
SUFFICIENT FOR
CLASSIFICATION
TETRAHYDROFURAN INGESTION CENTRAL NERVOUS MAY CAUSE DROWSINESS OR
SYSTEM DEPRESSION DIZZINESS
NAME SPECIES TEST RESULT EXPOSURE DURATION
ACETONE HUMAN NOAEL: NOT AVAILABLE
ACETONE HUMAN NOAEL: NOT AVAILABLE
ACETONE HUMAN NOAEL: 1.19 MG/L 6 HOURS
ACETONE GUINEA PIG NOAEL: NOT AVAILABLE
ACETONE HUMAN NOAEL: NOT AVAILABLE POISONING AND/OR
ABUSE
TETRAHYDROFURAN HUMAN NOAEL: NOT AVAILABLE
TETRAHYDROFURAN NOAEL: NOT AVAILABLE
TETRAHYDROFURAN RABBIT NOAEL: 2.9 MG/L 4 HOURS
TETRAHYDROFURAN RAT NOAEL: 180 MG/KG NOT APPLICABLE
SPECIFIC TARGET ORGAN TOXICITY - REPEATED EXPOSURE
NAME ROUTE TARGET ORGAN(S) VALUE
ACETONE DERMAL EYES SOME POSITIVE DATA EXIST,
BUT THE DATA ARE NOT
SUFFICIENT FOR
CLASSIFICATION
ACETONE INHALATION HEMATOPOIETIC SOME POSITIVE DATA EXIST,
SYSTEM BUT THE DATA ARE NOT
SUFFICIENT FOR
CLASSIFICATION
ACETONE INHALATION IMMUNE SYSTEM SOME POSITIVE DATA EXIST,
BUT THE DATA ARE NOT
SUFFICIENT FOR
CLASSIFICATION
ACETONE INHALATION KIDNEY AND/OR SOME POSITIVE DATA EXIST,
BLADDER BUT THE DATA ARE NOT
SUFFICIENT FOR
CLASSIFICATION
ACETONE INHALATION HEART ALL DATA ARE NEGATIVE
LIVER
ACETONE INGESTION KIDNEY AND/OR SOME POSITIVE DATA EXIST,
BLADDER BUT THE DATA ARE NOT
SUFFICIENT FOR
CLASSIFICATION
ACETONE INGESTION HEART SOME POSITIVE DATA EXIST,
BUT THE DATA ARE NOT
SUFFICIENT FOR
CLASSIFICATION
ACETONE INGESTION HEMATOPOIETIC SOME POSITIVE DATA EXIST,
SYSTEM BUT THE DATA ARE NOT
SUFFICIENT FOR
CLASSIFICATION
ACETONE INGESTION LIVER SOME POSITIVE DATA EXIST,
BUT THE DATA ARE NOT
SUFFICIENT FOR
CLASSIFICATION
ACETONE INGESTION EYES ALL DATA ARE NEGATIVE
ACETONE INGESTION RESPIRATORY SYSTEM ALL DATA ARE NEGATIVE
ACETONE INGESTION MUSCLES ALL DATA ARE NEGATIVE
ACETONE INGESTION SKIN ALL DATA ARE NEGATIVE
BONE, TEETH,
NAILS, AND/OR HAIR
TETRAHYDROFURAN INHALATION LIVER SOME POSITIVE DATA EXIST,
BUT THE DATA ARE NOT
SUFFICIENT FOR
CLASSIFICATION
TETRAHYDROFURAN INHALATION RESPIRATORY SYSTEM SOME POSITIVE DATA EXIST,
BUT THE DATA ARE NOT
SUFFICIENT FOR
CLASSIFICATION
TETRAHYDROFURAN INHALATION KIDNEY AND/OR SOME POSITIVE DATA EXIST,
BLADDER BUT THE DATA ARE NOT
SUFFICIENT FOR
CLASSIFICATION
TETRAHYDROFURAN INGESTION LIVER SOME POSITIVE DATA EXIST,
BUT THE DATA ARE NOT
SUFFICIENT FOR
CLASSIFICATION
GLYCEROL ESTERS INGESTION LIVER SOME POSITIVE DATA EXIST,
OF ROSIN ACIDS BUT THE DATA ARE NOT
SUFFICIENT FOR
CLASSIFICATION
GLYCEROL ESTERS INGESTION HEART ALL DATA ARE NEGATIVE
OF ROSIN ACIDS SKIN
ENDOCRINE SYSTEM
BONE, TEETH, NAILS,
AND/OR HAIR
BLOOD
BONE MARROW
HEMATOPOIETIC
SYSTEM
IMMUNE SYSTEM
MUSCLES
NERVOUS SYSTEM
EYES
KIDNEY AND/OR
BLADDER
RESPIRATORY
SYSTEM
NAME SPECIES TEST RESULT EXPOSURE DURATION
ACETONE GUINEA PIG NOAEL: NOT AVAILABLE 3 WEEKS
ACETONE HUMAN NOAEL: 3 MG/L 6 WEEKS
ACETONE HUMAN NOAEL: 1.19 MG/L 6 DAYS
ACETONE GUINEA PIG NOAEL: 119 MG/L NOT AVAILABLE
ACETONE RAT NOAEL: 45 MG/L 8 WEEKS
ACETONE RAT NOAEL: 900 MG/KG/DAY 13 WEEKS
ACETONE RAT NOAEL: 2,500 MG/KG/DAY 13 WEEKS
ACETONE RAT NOAEL: 200 MG/KG/DAY 13 WEEKS
ACETONE MOUSE NOAEL: 3,896 MG/KG/DAY 14 DAYS
ACETONE RAT NOAEL: 3,400 MG/KG/DAY 13 WEEKS
ACETONE RAT NOAEL: 2,500 MG/KG/DAY 13 WEEKS
ACETONE RAT NOAEL: 2,500 MG/KG 13 WEEKS
ACETONE MOUSE NOAEL: 11,298 MG/KG/DAY 13 WEEKS
TETRAHYDROFURAN RAT NOAEL: 0.6 MG/L 12 WEEKS
TETRAHYDROFURAN RAT NOAEL: 2.9 MG/L 12 WEEKS
TETRAHYDROFURAN RAT NOAEL: 0.6 MG/L 105 WEEKS
TETRAHYDROFURAN RAT NOAEL: NOT AVAILABLE 2 WEEKS
GLYCEROL ESTERS RAT NOAEL: 5,000 MG/KG/DAY 90 DAYS
OF ROSIN ACIDS
GLYCEROL ESTERS RAT NOAEL: 5,000 MG/KG/DAY 90 DAYS
OF ROSIN ACIDS
ASPIRATION HAZARD:
FOR THE COMPONENT/COMPONENTS, EITHER NO DATA ARE CURRENTLY AVAILABLE OR THE
DATA ARE NOT SUFFICIENT FOR CLASSIFICATION.
PLEASE CONTACT THE ADDRESS OR PHONE NUMBER LISTED IN SECTION 1 OF THIS
SDS FOR ADDITIONAL TOXICOLOGICAL INFORMATION ON THIS MATERIAL AND/OR
ITS COMPONENTS.
| SECTION 12: ECOLOGICAL INFORMATION | |
ECOTOXICOLOGICAL INFORMATION:
PLEASE CONTACT THE ADDRESS OR PHONE NUMBER LISTED IN SECTION 1 OF THIS
SDS FOR ADDITIONAL ECOTOXICOLOGICAL INFORMATION ON THIS MATERIAL AND/OR
ITS COMPONENTS.
CHEMICAL FATE INFORMATION:
PLEASE CONTACT THE ADDRESS OR PHONE NUMBER LISTED IN SECTION 1 OF THIS
SDS FOR ADDITIONAL CHEMICAL FATE INFORMATION ON THIS MATERIAL AND/OR
ITS COMPONENTS.
| SECTION 13: DISPOSAL CONSIDERATIONS | |
13.1. DISPOSAL METHODS:
DISPOSE OF CONTENTS/ CONTAINER IN ACCORDANCE WITH THE
LOCAL/REGIONAL/NATIONAL/INTERNATIONAL REGULATIONS.
INCINERATE IN A PERMITTED WASTE INCINERATION FACILITY. AS A DISPOSAL
ALTERNATIVE, UTILIZE AN ACCEPTABLE PERMITTED WASTE DISPOSAL FACILITY.
EMPTY DRUMS/BARRELS/CONTAINERS USED FOR TRANSPORTING AND HANDLING HAZARDOUS
CHEMICALS (CHEMICAL SUBSTANCES/MIXTURES/PREPARATIONS CLASSIFIED AS
HAZARDOUS AS PER APPLICABLE REGULATIONS) SHALL BE CONSIDERED, STORED,
TREATED & DISPOSED OF AS HAZARDOUS WASTES UNLESS OTHERWISE DEFINED BY
APPLICABLE WASTE REGULATIONS. CONSULT WITH THE RESPECTIVE REGULATING
AUTHORITIES TO DETERMINE THE AVAILABLE TREATMENT AND DISPOSAL FACILITIES.
EPA HAZARDOUS WASTE NUMBER (RCRA): D001 (IGNITABLE)
| SECTION 14: TRANSPORT INFORMATION | |
FOR TRANSPORT INFORMATION, PLEASE VISIT HTTP://3M.COM/TRANSPORTINFO OR CALL
1-800-364-3577 OR 651-737-6501.
| SECTION 15: REGULATORY INFORMATION | |
15.1. US FEDERAL REGULATIONS: CONTACT 3M FOR MORE INFORMATION.
311/312 HAZARD CATEGORIES:
FIRE HAZARD: YES
PRESSURE HAZARD: NO
REACTIVITY HAZARD: NO
IMMEDIATE HAZARD: YES
DELAYED HAZARD: YES
15.2. STATE REGULATIONS: CONTACT 3M FOR MORE INFORMATION.
15.3. CHEMICAL INVENTORIES:
THE COMPONENTS OF THIS PRODUCT ARE IN COMPLIANCE WITH THE CHEMICAL
NOTIFICATION REQUIREMENTS OF TSCA.
CONTACT 3M FOR MORE INFORMATION.
15.4. INTERNATIONAL REGULATIONS: CONTACT 3M FOR MORE INFORMATION.
THIS SDS HAS BEEN PREPARED TO MEET THE U.S. OSHA HAZARD COMMUNICATION
STANDARD, 29 CFR 1910.1200.
| SECTION 16: OTHER INFORMATION | |
NFPA HAZARD CLASSIFICATION:
HEALTH 3
FLAMMABILITY 3
INSTABILITY 0
SPECIAL HAZARDS NONE
NATIONAL FIRE PROTECTION ASSOCIATION (NFPA) HAZARD RATINGS ARE DESIGNED
FOR USE BY EMERGENCY RESPONSE PERSONNEL TO ADDRESS THE HAZARDS THAT ARE
PRESENTED BY SHORT-TERM, ACUTE EXPOSURE TO A MATERIAL UNDER CONDITIONS OF
FIRE, SPILL, OR SIMILAR EMERGENCIES. HAZARD RATINGS ARE PRIMARILY BASED ON
THE INHERENT PHYSICAL AND TOXIC PROPERTIES OF THE MATERIAL BUT ALSO INCLUDE
THE TOXIC PROPERTIES OF COMBUSTION OR DECOMPOSITION PRODUCTS THAT ARE KNOWN
TO BE GENERATED IN SIGNIFICANT QUANTITIES.
DOCUMENT GROUP: 10-2971-9
VERSION NUMBER: 30.00
ISSUE DATE: 04/27/15
SUPERCEDES DATE: 09/29/10
DISCLAIMER:
THE INFORMATION IN THIS SAFETY DATA SHEET (SDS) IS BELIEVED TO BE CORRECT
AS OF THE DATE ISSUED. 3M MAKES NO WARRANTIES, EXPRESSED OR IMPLIED,
INCLUDING, BUT NOT LIMITED TO, ANY IMPLIED WARRANTY OF MERCHANTABILITY OR
FITNESS FOR A PARTICULAR PURPOSE OR COURSE OF PERFORMANCE OR USAGE OF
TRADE. USER IS RESPONSIBLE FOR DETERMINING WHETHER THE 3M PRODUCT IS FIT
FOR A PARTICULAR PURPOSE AND SUITABLE FOR USER'S METHOD OF USE OR
APPLICATION. GIVEN THE VARIETY OF FACTORS THAT CAN AFFECT THE USE AND
APPLICATION OF A 3M PRODUCT, SOME OF WHICH ARE UNIQUELY WITHIN THE USER'S
KNOWLEDGE AND CONTROL, IT IS ESSENTIAL THAT THE USER EVALUATE THE 3M
PRODUCT TO DETERMINE WHETHER IT IS FIT FOR A PARTICULAR PURPOSE AND
SUITABLE FOR USER'S METHOD OF USE OR APPLICATION.
3M PROVIDES INFORMATION IN ELECTRONIC FORM AS A SERVICE TO ITS CUSTOMERS.
DUE TO THE REMOTE POSSIBILITY THAT ELECTRONIC TRANSFER MAY HAVE RESULTED
IN ERRORS, OMISSIONS OR ALTERATIONS IN THIS INFORMATION, 3M MAKES NO
REPRESENTATIONS AS TO ITS COMPLETENESS OR ACCURACY. IN ADDITION,
INFORMATION OBTAINED FROM A DATABASE MAY NOT BE AS CURRENT AS THE
INFORMATION IN THE SDS AVAILABLE DIRECTLY FROM 3M
3M USA SDSS ARE AVAILABLE AT WWW.3M.COM