| Common Name: | SUMA BREAK-UP II HEAVY DUTY FOAMING GREASE-RELEASE CLEANER |
| Manufacturer: | DIVERSEY |
| SDS Revision Date: | 5/29/2014 |
| SDS Format: | GHS-US |
| Item Number(s): | 32GP53 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
SEALED AIR
DIVERSEY CARE
SAFETY DATA SHEET
SUMA BREAK-UP II HEAVY DUTY FOAMING GREASE-RELEASE CLEANER
VERSION NUMBER: 1
PREPARATION DATE: 2014-05-29
| 1. IDENTIFICATION |  |
PRODUCT NAME: SUMA BREAK-UP II HEAVY DUTY FOAMING GREASE-RELEASE CLEANER
PRODUCT CODE: 95499058
SDS #: MS0800359
RECOMMENDED USE:
CLEANING PRODUCT
THIS PRODUCT IS INTENDED TO BE DILUTED PRIOR TO USE
USES ADVISED AGAINST: USES OTHER THAN THOSE IDENTIFIED ARE NOT RECOMMENDED
MANUFACTURER, IMPORTER, SUPPLIER:
US HEADQUARTERS:
DIVERSEY, INC.
8310 16TH ST.
STURTEVANT, WISCONSIN 53177-1964
PHONE: 1-888-352-2249
MSDS INTERNET ADDRESS: WWW.DIVERSEY.COM
CANADIAN HEADQUARTERS:
DIVERSEY, INC. - CANADA
2401 BRISTOL CIRCLE
OAKVILLE, ONTARIO L6H 6P1
PHONE: 1-800-668-3131
EMERGENCY TELEPHONE NUMBER:
1-800-851-7145 (U.S.)
1-651-917-6133 (INT'L)
| 2. HAZARDS IDENTIFICATION | |
CLASSIFICATION FOR THE UNDILUTED PRODUCT:
SKIN CORROSION/IRRITATION: CATEGORY 2
SERIOUS EYE DAMAGE/EYE IRRITATION: CATEGORY 1
CORROSION
SIGNAL WORD: DANGER
PRECAUTIONARY STATEMENTS:
CAUSES SKIN IRRITATION. CAUSES SERIOUS EYE DAMAGE.
AVOID CONTACT WITH EYES, SKIN AND CLOTHING. CAUSES BURNS/SERIOUS DAMAGE
TO MOUTH, THROAT AND STOMACH. KEEP CONTAINER TIGHTLY CLOSED. WASH AFFECTED
AREAS THOROUGHLY AFTER HANDLING. WEAR CHEMICAL-SPLASH GOGGLES AND
CHEMICAL-RESISTANT GLOVES.
IF SWALLOWED:
RINSE MOUTH. DO NOT INDUCE VOMITING UNLESS DIRECTED TO DO SO BY MEDICAL
PERSONNEL. DRINK A CUPFUL OF MILK OR WATER.
IF ON SKIN: WASH WITH PLENTY OF SOAP AND WATER.
IF SKIN IRRITATION OCCURS: GET MEDICAL ADVICE/ATTENTION.
IF INHALED: REMOVE PERSON TO FRESH AIR AND KEEP COMFORTABLE FOR BREATHING.
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES, IF
PRESENT AND EASY TO DO. CONTINUE RINSING FOR AT LEAST 15 MINUTES.
IMMEDIATELY CALL A POISON CENTER (1-800-851-7145) OR DOCTOR/PHYSICIAN.
TAKE OFF CONTAMINATED CLOTHING AND WASH IT BEFORE REUSE. DISPOSE OF IN
ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL APPLICABLE REGULATIONS.
HEALTH HAZARDS NOT OTHERWISE CLASSIFIED (HHNOC): NOT APPLICABLE
PHYSICAL HAZARDS NOT OTHERWISE CLASSIFIED (PHNOC): NOT APPLICABLE
CLASSIFICATION FOR THE DILUTED PRODUCT @ 1:16:
THIS PRODUCT, WHEN DILUTED AS STATED ON THE LABEL, IS NOT CLASSIFIED AS
HAZARDOUS ACCORDING TO OSHA 29CFR 1910.1200 (HAZCOM 2012-GHS) AND CURRENT
CANADIAN CONTROLLED PRODUCTS REGULATIONS (CPR).
PRECAUTIONARY STATEMENTS:
| 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
CLASSIFIED INGREDIENTS:
INGREDIENT(S) CAS # WEIGHT %
COCAMIDOPROPYL BETAINE 61789-40-0 3% - <5%
ALCOHOL ETHOXYLATES 68439-46-3 3% - <5%
LAURYL DIMETHYL AMINE OXIDE 1643-20-5 1% - <3%
TETRASODIUM SALT OF EDTA 64-02-8 1% - <3%
SODIUM CHLORIDE 7647-14-5 1% - <3%
POTASSIUM HYDROXIDE 1310-58-3 >0.1% - <1%
*EXACT PERCENTAGES ARE BEING WITHHELD AS TRADE SECRET INFORMATION
| 4. FIRST AID MEASURES | |
UNDILUTED PRODUCT:
EYES:
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES,
IF PRESENT AND EASY TO DO. CONTINUE RINSING FOR AT LEAST 15 MINUTES.
SKIN:
IF ON SKIN: WASH WITH PLENTY OF SOAP AND WATER.
IF SKIN IRRITATION OCCURS: GET MEDICAL ADVICE/ATTENTION.
INHALATION:
IF INHALED: REMOVE PERSON TO FRESH AIR AND KEEP COMFORTABLE FOR BREATHING.
INGESTION:
IF SWALLOWED:
RINSE MOUTH. DO NOT INDUCE VOMITING UNLESS DIRECTED TO DO SO BY MEDICAL
PERSONNEL. DRINK A CUPFUL OF MILK OR WATER.
MOST IMPORTANT SYMPTOMS/EFFECTS: NO INFORMATION AVAILABLE.
IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED: NOT APPLICABLE.
AGGRAVATED MEDICAL CONDITIONS: NONE KNOWN.
DILUTED PRODUCT:
EYES:
RINSE WITH PLENTY OF WATER IF IRRITATION OCCURS AND PERSISTS, GET MEDICAL
ATTENTION
SKIN:
RINSE WITH PLENTY OF WATER IF IRRITATION OCCURS AND PERSISTS, GET MEDICAL
ATTENTION
INHALATION: NO SPECIFIC FIRST AID MEASURES ARE REQUIRED
INGESTION: RINSE MOUTH WITH WATER.
| 5. FIRE-FIGHTING MEASURES | |
SPECIFIC METHODS: NO SPECIAL METHODS REQUIRED
SUITABLE EXTINGUISHING MEDIA:
THE PRODUCT IS NOT FLAMMABLE. EXTINGUISH FIRE USING AGENT SUITABLE FOR
SURROUNDING FIRE.
SPECIFIC HAZARDS: NOT APPLICABLE.
SPECIAL PROTECTIVE EQUIPMENT FOR FIREFIGHTERS:
AS IN ANY FIRE, WEAR SELF-CONTAINED BREATHING APPARATUS PRESSURE-DEMAND,
MSHA/NIOSH (APPROVED OR EQUIVALENT) AND FULL PROTECTIVE GEAR.
EXTINGUISHING MEDIA WHICH MUST NOT BE USED FOR SAFETY REASONS:
NO INFORMATION AVAILABLE.
| 6. ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS:
PUT ON APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT (SEE SECTION 8.).
ENVIRONMENTAL PRECAUTIONS AND CLEAN-UP METHODS:
CLEAN-UP METHODS - LARGE SPILLAGE. SOAK UP WITH INERT ABSORBENT MATERIAL.
SWEEP UP AND SHOVEL INTO SUITABLE CONTAINERS FOR DISPOSAL. USE A WATER
RINSE FOR FINAL CLEAN-UP.
| 7. HANDLING AND STORAGE | |
HANDLING:
AVOID CONTACT WITH SKIN, EYES AND CLOTHING. DO NOT TASTE OR SWALLOW. REMOVE
AND WASH CONTAMINATED CLOTHING AND FOOTWEAR BEFORE RE-USE. WASH THOROUGHLY
AFTER HANDLING. PRODUCT RESIDUE MAY REMAIN ON/IN EMPTY CONTAINERS. ALL
PRECAUTIONS FOR HANDLING THE PRODUCT MUST BE USED IN HANDLING THE EMPTY
CONTAINER AND RESIDUE. FOR COMMERCIAL AND INDUSTRIAL USE ONLY.
STORAGE:
PROTECT FROM FREEZING. KEEP TIGHTLY CLOSED IN A DRY, COOL AND
WELL-VENTILATED PLACE. KEEP OUT OF REACH OF CHILDREN.
AEROSOL LEVEL (IF APPLICABLE): NOT APPLICABLE
| 8. EXPOSURE CONTROLS / PERSONAL PROTECTION | |
EXPOSURE GUIDELINES:
INGREDIENT(S) CAS # ACGIH OSHA
COCAMIDOPROPYL BETAINE 61789-40-0
ALCOHOL ETHOXYLATES 68439-46-3
LAURYL DIMETHYL AMINE OXIDE 1643-20-5
TETRASODIUM SALT OF EDTA 64-02-8
SODIUM CHLORIDE 7647-14-5
POTASSIUM HYDROXIDE 1310-58-3 2 MG/M3 (CEILING)
UNDILUTED PRODUCT:
ENGINEERING MEASURES TO REDUCE EXPOSURE:
NO SPECIAL VENTILATION REQUIREMENTS GENERAL ROOM VENTILATION IS ADEQUATE
PERSONAL PROTECTIVE EQUIPMENT:
EYE PROTECTION: CHEMICAL-SPLASH GOGGLES.
HAND PROTECTION: CHEMICAL-RESISTANT GLOVES.
SKIN AND BODY PROTECTION: NO SPECIAL PROTECTIVE CLOTHING IS REQUIRED.
RESPIRATORY PROTECTION: NO SPECIAL PROTECTIVE CLOTHING IS REQUIRED.
HYGIENE MEASURES:
HANDLE IN ACCORDANCE WITH GOOD INDUSTRIAL HYGIENE AND SAFETY PRACTICE.
DILUTED PRODUCT:
PERSONAL PROTECTIVE EQUIPMENT:
EYE PROTECTION: NO SPECIAL REQUIREMENTS UNDER NORMAL USE CONDITIONS.
HAND PROTECTION: NO SPECIAL REQUIREMENTS UNDER NORMAL USE CONDITIONS.
SKIN AND BODY PROTECTION:
NO SPECIAL REQUIREMENTS UNDER NORMAL USE CONDITIONS.
RESPIRATORY PROTECTION:
NO SPECIAL REQUIREMENTS UNDER NORMAL USE CONDITIONS.
HYGIENE MEASURES:
HANDLE IN ACCORDANCE WITH GOOD INDUSTRIAL HYGIENE AND SAFETY PRACTICE.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
PHYSICAL STATE: LIQUID
COLOR: CLEAR, YELLOW
EVAPORATION RATE: NO INFORMATION AVAILABLE
ODOR: SOLVENT
ODOR THRESHOLD: NO INFORMATION AVAILABLE.
BOILING POINT/RANGE: NOT DETERMINED
MELTING POINT/RANGE: NOT DETERMINED
DECOMPOSITION TEMPERATURE: NOT DETERMINED
AUTOIGNITION TEMPERATURE: NO INFORMATION AVAILABLE
SOLUBILITY: COMPLETELY SOLUBLE
SOLUBILITY IN OTHER SOLVENTS: NO INFORMATION AVAILABLE
RELATIVE DENSITY (RELATIVE TO WATER): 1.026
DENSITY:
8.56 LBS/GAL
1.026
VAPOR DENSITY: NO INFORMATION AVAILABLE
BULK DENSITY: NO INFORMATION AVAILABLE
VAPOR PRESSURE: NO INFORMATION AVAILABLE.
FLASH POINT:
>200 DEG. F
>93.3 DEG. C
PARTITION COEFFICIENT (N-OCTANOL/WATER): NO INFORMATION AVAILABLE
DILUTION FLASH POINT:
>200 DEG. F
>93.3 DEG. C
VISCOSITY: NO INFORMATION AVAILABLE
ELEMENTAL PHOSPHORUS: 0 % BY WT.
VOC: 0.07 % *
PH: 12.64
VOC % BY WT. AT USE DILUTION: 0.00 % *
DILUTION PH: 11.36 @ 1:16
FLAMMABILITY (SOLID OR GAS): NOT APPLICABLE
METAL CORROSION: NOT DETERMINED
EXPLOSION LIMITS:
UPPER: NOT DETERMINED
LOWER: NOT DETERMINED
* - TITLE 17, CALIFORNIA CODE OF REGULATIONS, DIVISION 3, CHAPTER 1,
SUBCHAPTER 8.5, ARTICLE 2, CONSUMER PRODUCTS, SECTIONS 94508
| 10. STABILITY AND REACTIVITY | |
REACTIVITY: NOT APPLICABLE
STABILITY: THE PRODUCT IS STABLE
HAZARDOUS DECOMPOSITION PRODUCTS: NONE REASONABLY FORESEEABLE.
MATERIALS TO AVOID: NONE KNOWN.
CONDITIONS TO AVOID: NO INFORMATION AVAILABLE.
| 11. TOXICOLOGICAL INFORMATION | |
INFORMATION ON LIKELY ROUTES OF EXPOSURE:
EYE CONTACT, SKIN CONTACT, INHALATION, INGESTION
DELAYED, IMMEDIATE, OR CHRONIC EFFECTS AND SYMPTOMS FROM SHORT AND
LONG-TERM EXPOSURE:
SKIN CONTACT:
CAUSES SKIN IRRITATION. SYMPTOMS MAY INCLUDE PAIN (WHICH MAY BE DELAYED),
REDNESS, AND/OR DISCOMFORT.
EYE CONTACT:
CORROSIVE. CAUSES SERIOUS EYE DAMAGE. SYMPTOMS MAY INCLUDE PAIN, BURNING
SENSATION, REDNESS, WATERING, BLURRED VISION OR LOSS OF VISION.
INGESTION:
CAUSES BURNS/SERIOUS DAMAGE TO MOUTH, THROAT AND STOMACH. SYMPTOMS MAY
INCLUDE STOMACH PAIN AND NAUSEA.
INHALATION:
MAY CAUSE IRRITATION AND CORROSIVE EFFECTS TO NOSE, THROAT AND RESPIRATORY
TRACT. SYMPTOMS MAY INCLUDE COUGHING AND DIFFICULTY BREATHING.
SENSITIZATION: NO KNOWN EFFECTS.
NUMERICAL MEASURES OF TOXICITY:
ATE - ORAL (MG/KG): >5000
ATE - INHALATORY, MISTS (MG/L): >20
| 12. ECOLOGICAL INFORMATION | |
ECOTOXICITY: NO INFORMATION AVAILABLE.
PERSISTENCE AND DEGRADABILITY: NO INFORMATION AVAILABLE.
BIOACCUMULATION: NO INFORMATION AVAILABLE.
| 13. DISPOSAL CONSIDERATIONS | |
WASTE FROM RESIDUES / UNUSED PRODUCTS:
THIS PRODUCT, AS SOLD, IF DISCARDED OR DISPOSED, IS A HAZARDOUS WASTE
ACCORDING TO FEDERAL REGULATIONS (40 CFR 261.4 (B)(4)). DISPOSE IN
COMPLIANCE WITH ALL FEDERAL, STATE, PROVINCIAL, AND LOCAL LAWS AND
REGULATIONS. THIS PRODUCT, WHEN DILUTED AS STATED ON THIS SDS, IS NOT A
HAZARDOUS WASTE ACCORDING TO FEDERAL REGULATIONS (40 CFR 261.4 (B)(4)).
UNDER RCRA, IT IS THE RESPONSIBILITY OF THE USER OF THE PRODUCT TO
DETERMINE, AT THE TIME OF DISPOSAL, WHETHER THE WASTE SOLUTION MEETS RCRA
CRITERIA FOR HAZARDOUS WASTE. DISPOSE IN COMPLIANCE WITH ALL FEDERAL,
STATE, PROVINCIAL, AND LOCAL LAWS AND REGULATIONS.
CONTAMINATED PACKAGING: DO NOT RE-USE EMPTY CONTAINERS.
RCRA HAZARD CLASS (UNDILUTED PRODUCT): D002 CORROSIVE WASTE
RCRA HAZARD CLASS (DILUTED PRODUCT): NOT REGULATED
| 14. TRANSPORT INFORMATION | |
DOT/TDG/IMDG:
PLEASE REFER TO THE DIVERSEY HAZMAT LIBRARY, ONLY AVAILABLE THROUGH
INTERNET EXPLORER, HTTP://NAEXTRANET.DIVERSEY.COM/DOT/, FOR UP TO DATE
SHIPPING INFORMATION.
DOT (GROUND) BILL OF LADING DESCRIPTION:
CLEANING, WASHING, BUFFING, OR POLISHING COMPOUNDS LIQUID
IMDG (OCEAN) BILL OF LADING DESCRIPTION:
CLEANING, WASHING, BUFFING, OR POLISHING COMPOUNDS LIQUID
| 15. REGULATORY INFORMATION | |
INTERNATIONAL INVENTORIES AT CAS# LEVEL:
ALL COMPONENTS OF THIS PRODUCT ARE LISTED ON THE FOLLOWING INVENTORIES:
U.S.A. (TSCA), CANADA (DSL/NDSL).
U.S. REGULATIONS:
CALIFORNIA PROPOSITION 65:
THIS PRODUCT IS NOT SUBJECT TO THE REPORTING REQUIREMENTS UNDER
CALIFORNIA'S PROPOSITION 65.
RIGHT TO KNOW (RTK):
INGREDIENT(S) CAS # MARTK NJRTK PARTK RIRTK
WATER 7732-18-5
COCAMIDOPROPYL BETAINE 61789-40-0
ALCOHOL ETHOXYLATES 68439-46-3
LAURYL DIMETHYL AMINE OXIDE 1643-20-5
TETRASODIUM SALT OF EDTA 64-02-8
SODIUM CHLORIDE 7647-14-5
POTASSIUM HYDROXIDE 1310-58-3 X X X X
CERCLA/SARA:
INGREDIENT(S) CAS # WEIGHT % CERCLA/SARA SECTION 302 SECTION
RQ (LBS) TPQ (LBS) 313
POTASSIUM 1310-58-3 >0.1% - <1% 1000
HYDROXIDE
SARA 311/312 HAZARD CATEGORIES:
IMMEDIATE (X)
DELAYED ( )
FIRE ( )
REACTIVITY ( )
SUDDEN RELEASE OF PRESSURE ( )
CANADA:
| 16. OTHER INFORMATION | |
NFPA:
HEALTH 3
FLAMMABILITY 0
INSTABILITY 0
VERSION NUMBER: 1
PREPARATION DATE: 2014-05-29
REASON FOR REVISION: NOT APPLICABLE
PREPARED BY: NAPRAC
ADDITIONAL ADVICE: DOES NOT CONTAIN AN ADDED FRAGRANCE
NOTICE TO READER:
THIS DOCUMENT HAS BEEN PREPARED USING DATA FROM SOURCES CONSIDERED
TECHNICALLY RELIABLE. IT DOES NOT CONSTITUTE A WARRANTY, EXPRESS OR
IMPLIED, AS TO THE ACCURACY OF THE INFORMATION CONTAINED WITHIN. ACTUAL
CONDITIONS OF USE AND HANDLING ARE BEYOND SELLER'S CONTROL. USER IS
RESPONSIBLE TO EVALUATE ALL AVAILABLE INFORMATION WHEN USING PRODUCT FOR
ANY PARTICULAR USE AND TO COMPLY WITH ALL FEDERAL, STATE, PROVINCIAL AND
LOCAL LAWS AND REGULATIONS.