| Common Name: | MINERAL FIBER ACOUSTICAL CEILING TILES AND WALL PANELS (FIREGUARD)- MSDS 2 |
| Manufacturer: | ARMSTRONG WORLD INDUSTRIES |
| SDS Revision Date: | 6/12/2013 |
| SDS Format: | GHS-US |
| Item Number(s): | 31LC01, 31LC02, 36N477, 5NGJ5, 5NGK2 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
ARMSTRONG
SAFETY DATA SHEET
PRODUCT IDENTIFIER: MINERAL FIBER ACOUSTICAL CEILING TILES - MSDS #2
SDS ID: ARM-004
| SECTION 1 - IDENTIFICATION |  |
MATERIAL NAME:
MINERAL FIBER ACOUSTICAL CEILING TILES AND WALL PANELS (FIREGUARD)- MSDS #2
CHEMICAL FAMILY: MAN-MADE VITREOUS FIBER CEILING TILE
RECOMMENDED USE: ACOUSTICAL CEILING TILES
RESTRICTIONS ON USE: NONE KNOWN.
MANUFACTURER INFORMATION:
ARMSTRONG WORLD INDUSTRIES
2500 COLUMBIA AVE.
LANCASTER, PA 17603
PHONE #: 877-276-7876
EMAIL: TECHLINE@ARMSTRONG.COM
EMERGENCY #: 1-800-255-3924 (CHEMTEL)
WWW.ARMSTRONG.COM
| SECTION 2 - HAZARD(S) IDENTIFICATION | |
CLASSIFICATION IN ACCORDANCE WITH 29 CFR 1910.1200.:
CARCINOGENICITY, CATEGORY 1A
SPECIFIC TARGET ORGAN TOXICITY - SINGLE EXPOSURE, CATEGORY 3 (RESPIRATORY
SYSTEM)
SPECIFIC TARGET ORGAN TOXICITY - REPEATED EXPOSURE, CATEGORY 2 (LUNGS)
GHS LABEL ELEMENTS:
SYMBOL(S):
HEALTH HAZARD
EXCLAMATION MARK
SIGNAL WORD: DANGER
HAZARD STATEMENT(S):
CAUSES SKIN IRRITATION
CAUSES EYE IRRITATION
MAY CAUSE CANCER
MAY CAUSE DAMAGE TO LUNG DAMAGE THROUGH PROLONGED OR REPEATED EXPOSURE.
MAY CAUSE RESPIRATORY IRRITATION
PRECAUTIONARY STATEMENT(S):
PREVENTION:
PANELS DO NOT RELEASE RESPIRABLE DUST IN THEIR INSTALLED STATE AND,
THEREFORE, DO NOT PRESENT ANY KNOWN HEALTH HAZARDS WHEN INSTALLED AND
PROPERLY MAINTAINED.
DURING THE INSTALLATION BE CERTAIN THAT THE WORK SITE IS WELL VENTILATED
AND AVOID BREATHING DUST. AVOID CONTACT WITH SKIN OR EYES. WEAR
LONG-SLEEVE, LOOSE FITTING CLOTHES, GLOVES AND EYE PROTECTION. CUT AND
TRIM WITH KNIFE, RAZOR OR HAND SAW. DO NOT CUT WITH POWER EQUIPMENT UNLESS
EITHER A DUST COLLECTOR IS USED ON THE EQUIPMENT OR LOCAL EXHAUST IS USED
AND A NIOSH APPROVED RESPIRATOR IS WORN TO PREVENT OVEREXPOSURE TO AIRBORNE
SILICA.
RESPONSE:
IF EXPOSED OR CONCERNED: GET MEDICAL ADVICE/ATTENTION.
IF INHALED: REMOVE PERSON TO FRESH AIR AND KEEP COMFORTABLE FOR BREATHING.
STORAGE:
STORE IN A WELL-VENTILATED PLACE. KEEP CONTAINER TIGHTLY CLOSED. STORE
LOCKED UP.
DISPOSAL: DISPOSE IN ACCORDANCE WITH ALL APPLICABLE REGULATIONS.
| SECTION 3 - COMPOSITION / INFORMATION ON INGREDIENTS | |
CAS COMPONENT PERCENT
NOT AVAILABLE MINERAL-WOOL 30-40
1332-58-7 ALUMINIUM HYDROUS SILICATE: KAOLIN CLAY 20-30
130885-09-5 PERLITE 20-21
NOT AVAILABLE NEWSPRINT 5-6
9005-25-8 STARCH 4-5
14808-60-7 QUARTZ(INBOUND) 1-5
1317-65-3 GROUND CALCIUM CARBONATE 1-2
13463-67-7 TITANIUM DIOXIDE 0.1-1
| SECTION 4 - FIRST-AID MEASURES | |
DESCRIPTION OF NECESSARY MEASURES:
INHALATION:
IF INHALED:
REMOVE PERSON TO FRESH AIR AND KEEP COMFORTABLE FOR BREATHING. CALL A
POISON CENTER OR DOCTOR/PHYSICIAN IF YOU FEEL UNWELL.
SKIN CONTACT:
IF ON SKIN: WASH WITH PLENTY OF SOAP AND WATER.
IF SKIN IRRITATION OCCURS:
GET MEDICAL ADVICE/ATTENTION. TAKE OFF CONTAMINATED CLOTHING AND WASH
BEFORE RE-USE.
EYE CONTACT:
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES, IF
PRESENT AND EASY TO DO. CONTINUE RINSING.
IF EYE IRRITATION PERSISTS: GET MEDICAL ADVICE/ATTENTION.
INGESTION: IF A LARGE AMOUNT IS SWALLOWED, GET IMMEDIATE MEDICAL ATTENTION.
MOST IMPORTANT SYMPTOMS/EFFECTS:
ACUTE:
MAY CAUSE EYE IRRITATION, SKIN IRRITATION. CAUSES RESPIRATORY TRACT
IRRITATION.
DELAYED: CANCER HAZARD, LUNG DAMAGE
INDICATION OF IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED, IF
NEEDED: TREAT SYMPTOMATICALLY AND SUPPORTIVELY.
| SECTION 5 - FIRE-FIGHTING MEASURES | |
SUITABLE EXTINGUISHING MEDIA:
CARBON DIOXIDE, REGULAR DRY CHEMICAL, REGULAR FOAM, WATER SPRAY
UNSUITABLE EXTINGUISHING MEDIA: NONE KNOWN.
SPECIAL HAZARDS ARISING FROM THE CHEMICAL:
COMBUSTIBLE DUST. AVOID GENERATING DUST; FINE DUST DISPERSED IN AIR IN
SUFFICIENT CONCENTRATIONS, AND IN THE PRESENCE OF AN IGNITION SOURCE IS A
POTENTIAL DUST EXPLOSION HAZARD. UPON DECOMPOSITION, THIS PRODUCT EMITS
CARBON MONOXIDE, CARBON DIOXIDE AND/OR LOW MOLECULAR WEIGHT HYDROCARBONS.
TOXIC FUMES MAY BE RELEASED IN CASE OF FIRE.
HAZARDOUS COMBUSTION PRODUCTS:
COMBUSTION:
UPON DECOMPOSITION, THIS PRODUCT EMITS CARBON MONOXIDE, CARBON DIOXIDE
AND/OR LOW MOLECULAR WEIGHT HYDROCARBONS.
FIRE FIGHTING MEASURES:
KEEP AWAY FROM SOURCES OF IGNITION - NO SMOKING. AVOID INHALATION OF
MATERIAL OR COMBUSTION BY-PRODUCTS. MOVE MATERIAL FROM FIRE AREA IF IT CAN
BE DONE WITHOUT RISK. USE EXTINGUISHING AGENTS APPROPRIATE FOR SURROUNDING
FIRE. DIKE FOR LATER DISPOSAL. STAY UPWIND AND KEEP OUT OF LOW AREAS.
SPECIAL PROTECTIVE EQUIPMENT AND PRECAUTIONS FOR FIREFIGHTERS:
FIREFIGHTERS SHOULD WEAR FULL-FACE, SELF CONTAINED BREATHING APPARATUS AND
IMPERVIOUS PROTECTIVE CLOTHING. FIREFIGHTERS SHOULD AVOID INHALING ANY
COMBUSTION PRODUCTS.
| SECTION 6 - ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
DUST DEPOSITS SHOULD NOT BE ALLOWED TO ACCUMULATE ON SURFACES, AS THESE
MAY FORM AN EXPLOSIVE MIXTURE IF THEY ARE RELEASED INTO THE ATMOSPHERE IN
SUFFICIENT CONCENTRATION. WEAR APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT.
KEEP UNNECESSARY PEOPLE AWAY, ISOLATE HAZARD AREA AND DENY ENTRY. AVOID
CONTACT WITH SKIN AND EYES. DO NOT BREATHE DUST. IF RESPIRABLE DUSTS ARE
GENERATED, RESPIRATORY PROTECTION MAY BE NEEDED. COLLECT SPILLAGE. IN CASE
OF SPILLAGE, STOP THE FLOW OF MATERIAL AND BLOCK ANY POTENTIAL ROUTES TO
WATER SYSTEMS. ONLY PERSONNEL TRAINED FOR THE HAZARDS OF THIS MATERIAL
SHOULD PERFORM CLEAN UP AND DISPOSAL. AVOID RELEASE TO THE ENVIRONMENT.
METHODS AND MATERIALS FOR CONTAINMENT AND CLEANING UP:
KEEP OUT OF WATER SUPPLIES, SEWERS AND SOIL. IN CASE OF SPILLAGE, STOP THE
FLOW OF MATERIAL AND BLOCK ANY POTENTIAL ROUTES TO WATER SYSTEMS. COLLECT
SPILLED MATERIAL USING MECHANICAL EQUIPMENT. KEEP UNNECESSARY PEOPLE AWAY,
ISOLATE HAZARD AREA AND DENY ENTRY. AVOID DUST GENERATION AND ACCUMULATION.
KEEP CONTAINER TIGHTLY CLOSED. AVOID DISPERSAL OF DUST IN THE AIR (I.E.,
CLEARING DUST SURFACES WITH COMPRESSED AIR). USE NON-SPARKING TOOLS AND
EQUIPMENT.
| SECTION 7 - HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING:
DO NOT HANDLE UNTIL ALL SAFETY PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD.
KEEP AWAY FROM ALL IGNITION SOURCES. DO NOT BREATHE DUST. USE METHODS TO
MINIMIZE DUST. AVOID CONTACT WITH SKIN AND EYES. DO NOT EAT, DRINK, OR
SMOKE WHEN USING THIS PRODUCT. ALWAYS WEAR RECOMMENDED PERSONAL PROTECTIVE
EQUIPMENT. WEAR PERSONAL PROTECTIVE CLOTHING AND EQUIPMENT, SEE SECTION 8.
MINIMIZE DUST GENERATION AND ACCUMULATION. ROUTINE HOUSEKEEPING SHOULD BE
INSTITUTED TO ENSURE THAT DUSTS DO NOT ACCUMULATE ON SURFACES. TAKE
PRECAUTIONARY MEASURES AGAINST STATIC DISCHARGE. DISSIPATE STATIC
ELECTRICITY DURING TRANSFER BY EARTHING (GROUNDING AND BONDING)
CONTAINERS AND EQUIPMENT.
CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES:
STORE IN A COOL, DRY PLACE. STORE IN A WELL-VENTILATED PLACE. AVOID
CONTACT WITH MOLTEN MATERIAL. KEEP SEPARATED FROM INCOMPATIBLE SUBSTANCES.
KEEP CONTAINER TIGHTLY CLOSED. EMPTY CONTAINERS MAY CONTAIN PRODUCT
RESIDUE. DO NOT REUSE EMPTY CONTAINERS WITHOUT COMMERCIAL CLEANING OR
RECONDITIONING. STORE AND HANDLE IN ACCORDANCE WITH ALL CURRENT REGULATIONS
AND STANDARDS.
INCOMPATIBILITIES: NOT AVAILABLE
| SECTION 8 - EXPOSURE CONTROLS / PERSONAL PROTECTION | |
EXPOSURE LIMITS:
FOLLOW ALL APPLICABLE EXPOSURE LIMITS. MINIMIZE DUST GENERATION AND
ACCUMULATION.
COMPONENT EXPOSURE LIMITS:
ALUMINIUM HYDROUS SILICATE: KAOLIN CLAY (1332-58-7)
ACGIH:
2 MG/M3 TWA (PARTICULATE MATTER CONTAINING NO ASBESTOS AND <1% CRYSTALLINE
SILICA, RESPIRABLE FRACTION)
OSHA:
15 MG/M3 TWA (TOTAL DUST)
5 MG/M3 TWA (RESPIRABLE FRACTION)
NIOSH:
10 MG/M3 TWA (TOTAL DUST)
5 MG/M3 TWA (RESPIRABLE DUST)
MEXICO:
10 MG/M3 TWA LMPE-PPT
20 MG/M3 STEL [LMPE-CT]
STARCH (9005-25-8):
ACGIH: 10 MG/M3 TWA
OSHA:
15 MG/M3 TWA (TOTAL DUST)
5 MG/M3 TWA (RESPIRABLE FRACTION)
NIOSH:
10 MG/M3 TWA (TOTAL DUST)
5 MG/M3 TWA (RESPIRABLE DUST)
QUARTZ(INBOUND) (14808-60-7):
ACGIH: 0.025 MG/M3 TWA (RESPIRABLE FRACTION)
NIOSH: 0.05 MG/M3 TWA (RESPIRABLE DUST)
MEXICO 0.1 MG/M3 TWA LMPE-PPT (RESPIRABLE FRACTION)
GROUND CALCIUM CARBONATE (1317-65-3):
OSHA:
15 MG/M3 TWA (TOTAL DUST)
5 MG/M3 TWA (RESPIRABLE FRACTION)
NIOSH:
10 MG/M3 TWA (TOTAL DUST)
5 MG/M3 TWA (RESPIRABLE DUST)
MEXICO:
10 MG/M3 TWA LMPE-PPT
20 MG/M3 STEL [LMPE-CT]
TITANIUM DIOXIDE (13463-67-7):
ACGIH: 10 MG/M3 TWA
OSHA: 15 MG/M3 TWA (TOTAL DUST)
MEXICO:
10 MG/M3 TWA LMPE-PPT (AS Ti)
20 MG/M3 STEL [LMPE-CT] (AS Ti)
APPROPRIATE ENGINEERING CONTROLS:
VENTILATION EQUIPMENT SHOULD BE EXPLOSION-RESISTANT IF EXPLOSIVE
CONCENTRATIONS OF MATERIAL ARE PRESENT. PROVIDE LOCAL EXHAUST VENTILATION
SYSTEM. IT IS RECOMMENDED THAT ALL DUST CONTROL EQUIPMENT SUCH AS LOCAL
EXHAUST VENTILATION AND MATERIAL TRANSPORT SYSTEMS INVOLVED IN HANDLING OF
THESE PRODUCT CONTAIN EXPLOSION RELIEF VENTS OR AN EXPLOSION SUPPRESSION
SYSTEM OR AN OXYGEN-DEFICIENT ENVIRONMENT.
ENSURE THAT DUST-HANDLING SYSTEMS (SUCH AS EXHAUST DUCTS, DUST COLLECTORS,
VESSELS, AND PROCESSING EQUIPMENT) ARE DESIGNED IN A MANNER TO PREVENT THE
ESCAPE OF DUST INTO THE WORK AREA (I.E., THERE IS NO LEAKAGE FROM THE
EQUIPMENT).
USE ONLY APPROPRIATELY CLASSIFIED ELECTRICAL EQUIPMENT AND POWERED
INDUSTRIAL TRUCKS.
INDIVIDUAL PROTECTION MEASURES, SUCH AS PERSONAL PROTECTIVE EQUIPMENT:
EYES/FACE PROTECTION:
WEAR SPLASH RESISTANT SAFETY GOGGLES WITH A FACESHIELD.
SKIN PROTECTION: WEAR APPROPRIATE CHEMICAL RESISTANT CLOTHING.
GLOVE RECOMMENDATIONS: WEAR APPROPRIATE CHEMICAL RESISTANT GLOVES.
RESPIRATORY PROTECTION:
A NIOSH APPROVED RESPIRATOR WITH ORGANIC VAPOR CARTRIDGES AND N95
FILTERS MAY BE PERMISSIBLE UNDER CERTAIN CIRCUMSTANCES WHERE AIRBORNE
CONCENTRATIONS ARE EXPECTED TO EXCEED EXPOSURE LIMITS, OR WHEN SYMPTOMS
HAVE BEEN OBSERVED THAT ARE INDICATIVE OF OVEREXPOSURE.
| SECTION 9 - PHYSICAL AND CHEMICAL PROPERTIES | |
PHYSICAL STATE: SOLID
APPEARANCE: FIBROUS FORMS
COLOR: VARIOUS COLORS
PHYSICAL FORM: SOLID
ODOR: NONE
ODOR THRESHOLD: NOT AVAILABLE
PH: NOT AVAILABLE
MELTING POINT: NOT AVAILABLE
BOILING POINT: NOT AVAILABLE
FLASH POINT: NOT AVAILABLE
DECOMPOSITION: NOT AVAILABLE
EVAPORATION RATE: NOT AVAILABLE
OSHA FLAMMABILITY CLASS: NOT AVAILABLE
VAPOR PRESSURE: NOT AVAILABLE
VAPOR DENSITY (AIR = 1): NOT AVAILABLE
DENSITY: NOT AVAILABLE
SPECIFIC GRAVITY (WATER = 1): NOT AVAILABLE
WATER SOLUBILITY: INSOLUBLE
LOG KOW: NOT AVAILABLE
COEFF. WATER/OIL DIST: NOT AVAILABLE
AUTO IGNITION: NOT AVAILABLE
VISCOSITY: NOT AVAILABLE
VOC: NOT AVAILABLE
VOLATILITY: NOT AVAILABLE
MOLECULAR FORMULA: NOT AVAILABLE
| SECTION 10 - STABILITY AND REACTIVITY | |
REACTIVITY: NONE KNOWN.
CHEMICAL STABILITY: STABLE AT NORMAL TEMPERATURES AND PRESSURE.
POSSIBILITY OF HAZARDOUS REACTIONS:
HAZARDOUS POLYMERIZATION WILL NOT OCCUR.
CONDITIONS TO AVOID:
AVOID HEAT, FLAMES, SPARKS AND OTHER SOURCES OF IGNITION. AVOID CONTACT
WITH INCOMPATIBLE MATERIALS. AVOID GENERATING DUST. AVOID CONTACT WITH
MOLTEN MATERIAL.
INCOMPATIBLE MATERIALS: NOT AVAILABLE
HAZARDOUS DECOMPOSITION:
COMBUSTION:
UPON DECOMPOSITION, THIS PRODUCT EMITS CARBON MONOXIDE, CARBON DIOXIDE
AND/OR LOW MOLECULAR WEIGHT HYDROCARBONS.
| SECTION 11 - TOXICOLOGICAL INFORMATION | |
ACUTE TOXICITY:
NO INFORMATION AVAILABLE FOR THE PRODUCT. SEE COMPONENT DATA.
COMPONENT ANALYSIS - LD50/LC50:
THE COMPONENTS OF THIS MATERIAL HAVE BEEN REVIEWED IN VARIOUS SOURCES AND
THE FOLLOWING SELECTED ENDPOINTS ARE PUBLISHED:
QUARTZ(INBOUND) (14808-60-7):
ORAL LD50 RAT: 500 MG/KG
TITANIUM DIOXIDE (13463-67-7):
ORAL LD50 RAT: >10000 MG/KG
INFORMATION ON LIKELY ROUTES OF EXPOSURE:
INHALATION: CAUSES RESPIRATORY TRACT IRRITATION.
INGESTION: NO INFORMATION ON SIGNIFICANT ADVERSE EFFECTS.
SKIN CONTACT: CAUSES SKIN IRRITATION
EYE CONTACT: CAUSES EYE IRRITATION
IMMEDIATE EFFECTS:
EYE IRRITATION, SKIN IRRITATION, RESPIRATORY TRACT IRRITATION
DELAYED EFFECTS: CANCER HAZARD, LUNG DAMAGE
MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE: NO DATA AVAILABLE.
IRRITATION/CORROSIVITY DATA:
CAUSES EYE IRRITATION, SKIN IRRITATION, AND RESPIRATORY TRACT IRRITATION.
RESPIRATORY SENSITIZATION: NO INFORMATION AVAILABLE FOR THE PRODUCT.
DERMAL SENSITIZATION: NO INFORMATION AVAILABLE FOR THE PRODUCT.
GERM CELL MUTAGENICITY: NO INFORMATION AVAILABLE FOR THE PRODUCT.
CARCINOGENICITY:
COMPONENT CARCINOGENICITY:
ALUMINIUM HYDROUS SILICATE: KAOLIN CLAY (1332-58-7):
ACGIH: A4 - NOT CLASSIFIABLE AS A HUMAN CARCINOGEN
DFG: CATEGORY 3B (COULD BE CARCINOGENIC FOR MAN)
STARCH (9005-25-8):
ACGIH: A4 - NOT CLASSIFIABLE AS A HUMAN CARCINOGEN
QUARTZ(INBOUND) (14808-60-7):
ACGIH: A2 - SUSPECTED HUMAN CARCINOGEN
IARC:
MONOGRAPH 100C [2012]; MONOGRAPH 68 [1997] (GROUP 1 (CARCINOGENIC TO
HUMANS))
NTP: KNOWN HUMAN CARCINOGEN (RESPIRABLE SIZE)
DFG: CATEGORY 1 (CAUSES CANCER IN MAN, ALVEOLA FRACTION)
OSHA: PRESENT (RESPIRABLE SIZE)
TITANIUM DIOXIDE (13463-67-7):
ACGIH: A4 - NOT CLASSIFIABLE AS A HUMAN CARCINOGEN
IARC:
MONOGRAPH 93 [2010]; MONOGRAPH 47 [1989] (GROUP 2B (POSSIBLY CARCINOGENIC
TO HUMANS))
DFG:
CATEGORY 3A (COULD BE CARCINOGENIC FOR MAN, INHALABLE FRACTION WITH THE
EXCEPTION OF ULTRA SMALL PARTICLES)
OSHA: PRESENT
REPRODUCTIVE TOXICITY: NO INFORMATION AVAILABLE FOR THE PRODUCT.
SPECIFIC TARGET ORGAN TOXICITY - SINGLE EXPOSURE:
NO TARGET ORGANS IDENTIFIED.
SPECIFIC TARGET ORGAN TOXICITY - REPEATED EXPOSURE: LUNG DAMAGE
ASPIRATION HAZARD: NO DATA AVAILABLE.
| SECTION 12 - ECOLOGICAL INFORMATION | |
ECOTOXICITY: NO INFORMATION AVAILABLE FOR THE PRODUCT.
COMPONENT ANALYSIS - AQUATIC TOXICITY:
NO LOLI ECOTOXICITY DATA ARE AVAILABLE FOR THIS PRODUCT'S COMPONENTS.
PERSISTENCE AND DEGRADABILITY: NO INFORMATION AVAILABLE FOR THE PRODUCT.
BIOACCUMULATION: NO INFORMATION AVAILABLE FOR THE PRODUCT.
MOBILITY: NO INFORMATION AVAILABLE FOR THE PRODUCT.
| SECTION 13 - DISPOSAL CONSIDERATIONS | |
DISPOSAL METHODS:
DISPOSE IN ACCORDANCE WITH ALL APPLICABLE REGULATIONS. REGULATIONS VARY.
CONSULT LOCAL AUTHORITIES BEFORE DISPOSAL.
COMPONENT WASTE NUMBERS:
THE U.S. EPA HAS NOT PUBLISHED WASTE NUMBERS FOR THIS PRODUCT'S COMPONENTS.
DISPOSAL OF CONTAMINATED PACKAGING:
DISPOSE OF WASTE MATERIAL ACCORDING TO LOCAL, STATE, FEDERAL, AND
PROVINCIAL ENVIRONMENTAL REGULATIONS.
| SECTION 14 - TRANSPORT INFORMATION | |
US DOT INFORMATION: NOT REGULATED AS A HAZARDOUS MATERIAL.
TDG INFORMATION: NO CLASSIFICATION ASSIGNED.
MARINE POLLUTANT:
TITANIUM DIOXIDE (13463-67-7):
IBC CODE: CATEGORY Z (SLURRY)
| SECTION 15 - REGULATORY INFORMATION | |
U.S. FEDERAL REGULATIONS:
NONE OF THIS PRODUCTS COMPONENTS ARE LISTED UNDER SARA SECTIONS 302/304
(40 CFR 355 APPENDIX A), SARA SECTION 313 (40 CFR 372.65), CERCLA (40 CFR
302.4), TSCA 12(B), OR REQUIRE AN OSHA PROCESS SAFETY PLAN.
SARA 311/312:
ACUTE HEALTH: YES
CHRONIC HEALTH: YES
FIRE: NO
PRESSURE: NO
REACTIVE: NO
U.S. STATE REGULATIONS:
THE FOLLOWING COMPONENTS APPEAR ON ONE OR MORE OF THE FOLLOWING STATE
HAZARDOUS SUBSTANCES LISTS:
COMPONENT CAS CA MA MN NJ PA
ALUMINIUM HYDROUS SILICATE: 1332-58-7 NO YES YES YES YES
KAOLIN CLAY
STARCH 9005-25-8 NO YES YES NO YES
QUARTZ(INBOUND) 14808-60-7 NO YES YES YES YES
GROUND CALCIUM CARBONATE 1317-65-3 NO YES YES YES YES
TITANIUM DIOXIDE 13463-67-7 NO YES YES YES YES
CANADIAN CLASSIFICATION:
THIS PRODUCT HAS BEEN CLASSIFIED IN ACCORDANCE WITH THE CRITERIA OF THE
CONTROLLED PRODUCTS REGULATIONS (CPR) AND THE MSDS CONTAINS ALL OF THE
INFORMATION REQUIRED BY THE CPR.
CANADIAN WHMIS INGREDIENT DISCLOSURE LIST (IDL):
COMPONENTS OF THIS MATERIAL HAVE BEEN CHECKED AGAINST THE CANADIAN WHMIS
INGREDIENTS DISCLOSURE LIST. THE LIST IS COMPOSED OF CHEMICALS WHICH MUST
BE IDENTIFIED ON MSDSS IF THEY ARE INCLUDED IN PRODUCTS WHICH FALL UNDER
WHMIS CRITERIA SPECIFIED IN THE CONTROLLED PRODUCTS REGULATIONS AND PRESENT
ABOVE THE THRESHOLD LIMITS LISTED ON THE IDL.
QUARTZ(INBOUND) (14808-60-7): 1%
CANADA-WHMIS:
WHMIS CLASSIFICATION:
D2A
D2B.
CHEMICAL INVENTORY LISTINGS:
COMPONENT ANALYSIS - INVENTORY:
COMPONENT CAS US CA EU AU PH JP KR CN NZ
ALUMINIUM 1332-58-7 YES DSL EIN YES YES YES YES YES YES
HYDROUS
SILICATE:
KAOLIN CLAY
PERLITE 130885-09-5 NO NO NO NO NO NO YES YES NO
STARCH 9005-25-8 YES DSL EIN YES YES YES YES YES YES
QUARTZ(INBOUND) 14808-60-7 YES DSL EIN YES YES YES YES YES YES
GROUND CALCIUM 1317-65-3 YES NSL EIN YES YES YES YES YES YES
CARBONATE
TITANIUM 13463-67-7 YES DSL EIN YES YES YES YES YES YES
DIOXIDE
| SECTION 16 - OTHER INFORMATION | |
SUMMARY OF CHANGES:
NEW SDS: 06/12/2013
NFPA RATINGS:
HEALTH 2
FIRE 1
REACTIVITY 0
HAZARD SCALE:
0 = MINIMAL
1 = SLIGHT
2 = MODERATE
3 = SERIOUS
4 = SEVERE
KEY / LEGEND:
ACGIH: AMERICAN CONFERENCE OF GOVERNMENTAL INDUSTRIAL HYGIENISTS
AU: AUSTRALIA
BOD: BIOCHEMICAL OXYGEN DEMAND
C: CELSIUS
CA: CALIFORNIA
CAN: CANADA
CAS: CHEMICAL ABSTRACT SERVICE
CERCLA:
COMPREHENSIVE ENVIRONMENTAL RESPONSE, COMPENSATION AND LIABILITY ACT
CFR: CODE OF FEDERAL REGULATIONS
CN: CANADA
DFG: DEUTSCHE FORSCHUNGSGEMEINSCHAFT
DOT: DEPARTMENT OF TRANSPORTATION
DSL: CANADIAN DOMESTIC SUBSTANCE LIST
EPA: ENVIRONMENTAL PROTECTION AGENCY
EU: EUROPEAN UNION
IARC: INTERNATIONAL AGENCY FOR RESEARCH ON CANCER
IDL: INGREDIENT DISCLOSE LIST
IDLH: IMMEDIATELY DANGER TO LIFE AND HEALTH
JP: JAPAN
KR: KOREA
LC50: LETHAL CONCENTRATION
LD50: LETHAL DOSE
LEL: LOWER EXPLOSIVE LIMIT
LMPE-CT: MEXICO STEL EQUIVALENT
LMPE-PPT: MEXICO TWA EQUIVALENT
MSDS: MATERIAL SAFETY DATA SHEET
NIOSH: NATIONAL INSTITUTE OF OCCUPATIONAL SAFETY AND HEALTH
NJTSR: NEW JERSEY TRADE SECRET REGISTRY
NTP: NATIONAL TOXICOLOGY PROGRAM
NZ: NEW ZEALAND
OEL: OCCUPATIONAL EXPOSURE LIMIT
OSHA: OCCUPATIONAL SAFETY AND HEALTH ADMINISTRATION
PEL: PERMISSIBLE EXPOSURE LIMIT
PH: PHILIPPINES
RQ: REPORTABLE QUANTITY
SARA: SUPERFUND AMENDMENTS ACT
SDS: SAFETY DATA SHEET
STEL: SHORT-TERM EXPOSURE LIMIT
TDG: TRANSPORTATION OF DANGEROUS GOODS
TLV: THRESHOLD LIMIT VALUE
TSCA: TOXIC SUBSTANCE CONTROL ACT
TWA: TIME WEIGHTED AVERAGE
UEL: UPPER EXPLOSIVE LIMIT
UN: UNITED NATIONS
US: UNITED STATE
WHMIS: WORKPLACE HAZARDOUS MATERIALS INFORMATION SYSTEM
OTHER INFORMATION:
REASONABLE CARE HAS BEEN TAKEN IN THE PREPARATION OF THIS INFORMATION;
HOWEVER, THE MANUFACTURER MAKES NO WARRANTY WHATSOEVER INCLUDING THE
WARRANTY OF MERCHANTABILITY, EXPRESSED OR IMPLIED, WITH RESPECT TO THIS
INFORMATION. THE MANUFACTURER MAKES NO REPRESENTATIONS AND ASSUMES NO
LIABILITY FOR ANY DIRECT, INCIDENTAL, CONSEQUENTIAL, OR OTHER SUCH DAMAGES
RESULTING FROM ITS USE OR MISUSE.
DISCLAIMER:
SUPPLIER GIVES NO WARRANTY WHATSOEVER, INCLUDING THE WARRANTIES OF
MERCHANTABILITY OR OF FITNESS FOR A PARTICULAR PURPOSE. ANY PRODUCT
PURCHASED IS SOLD ON THE ASSUMPTION THE PURCHASER SHALL DETERMINE THE
QUALITY AND SUITABILITY OF THE PRODUCT. SUPPLIER EXPRESSLY DISCLAIMS ANY
AND ALL LIABILITY FOR INCIDENTAL, CONSEQUENTIAL OR ANY OTHER DAMAGES
ARISING OUT OF THE USE OR MISUSE OF THIS PRODUCT. NO INFORMATION PROVIDED
SHALL BE DEEMED TO BE A RECOMMENDATION TO USE ANY PRODUCT IN CONFLICT WITH
ANY EXISTING PATENT RIGHTS.
ISSUE DATE: 06/11/13
REVISION: 1.0000
PRINT DATE: 3/19/2015
PRODUCT IDENTIFIER: MINERAL FIBER ACOUSTICAL CEILING TILES - MSDS #4