| Common Name: | ABS SPECIAL MILKY CLEAR |
| Manufacturer: | OATEY |
| SDS Revision Date: | 12/1/2017 |
| SDS Format: | GHS-US |
| Item Number(s): | |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
OATEY(R*)
SAFETY DATA SHEET
| 1. IDENTIFICATION |  |
PRODUCT IDENTIFIER: OATEY ABS SPECIAL MILKY CLEAR
OTHER MEANS OF IDENTIFICATION:
SDS NUMBER: 1300E
RECOMMENDED USE: JOINING ABS PIPES
RECOMMENDED RESTRICTIONS: NONE KNOWN.
MANUFACTURER/IMPORTER/SUPPLIER/DISTRIBUTOR INFORMATION:
COMPANY NAME: OATEY CO.
ADDRESS:
4700 WEST 160TH ST.
CLEVELAND, OH 44135
TELEPHONE: 216-267-7100
E-MAIL: INFO@OATEY.COM
TRANSPORT EMERGENCY:
CHEMTREC: 1-800-424-9300 (OUTSIDE THE US 1-703-527-3887)
EMERGENCY FIRST AID: 1-877-740-5015
CONTACT PERSON: MSDS COORDINATOR
| 2. HAZARD(S) IDENTIFICATION | |
PHYSICAL HAZARDS:
FLAMMABLE LIQUIDS: CATEGORY 2
HEALTH HAZARDS:
SERIOUS EYE DAMAGE/EYE IRRITATION: CATEGORY 2A
SPECIFIC TARGET ORGAN TOXICITY, SINGLE EXPOSURE:
CATEGORY 3 RESPIRATORY TRACT IRRITATION
SPECIFIC TARGET ORGAN TOXICITY, SINGLE EXPOSURE:
CATEGORY 3 NARCOTIC EFFECTS
ASPIRATION HAZARD: CATEGORY 1
OSHA DEFINED HAZARDS: NOT CLASSIFIED.
LABEL ELEMENTS:
FLAME
HEALTH HAZARD
EXCLAMATION MARK
SIGNAL WORD: DANGER
HAZARD STATEMENT:
HIGHLY FLAMMABLE LIQUID AND VAPOR. MAY BE FATAL IF SWALLOWED AND ENTERS
AIRWAYS. CAUSES SERIOUS EYE IRRITATION. MAY CAUSE RESPIRATORY IRRITATION.
MAY CAUSE DROWSINESS OR DIZZINESS.
PRECAUTIONARY STATEMENT:
PREVENTION:
KEEP AWAY FROM HEAT/SPARKS/OPEN FLAMES/HOT SURFACES. - NO SMOKING. USE ONLY
OUTDOORS OR IN A WELL-VENTILATED AREA. KEEP CONTAINER TIGHTLY CLOSED.
GROUND/BOND CONTAINER AND RECEIVING EQUIPMENT. USE EXPLOSION-PROOF
ELECTRICAL/VENTILATING/LIGHTING EQUIPMENT. USE ONLY NON-SPARKING TOOLS.
TAKE PRECAUTIONARY MEASURES AGAINST STATIC DISCHARGE. AVOID BREATHING MIST
OR VAPOR. WASH THOROUGHLY AFTER HANDLING. WEAR PROTECTIVE GLOVES/EYE
PROTECTION/FACE PROTECTION.
RESPONSE: DO NOT INDUCE VOMITING.
IF EYE IRRITATION PERSISTS: GET MEDICAL ADVICE/ATTENTION.
IN CASE OF FIRE: USE APPROPRIATE MEDIA TO EXTINGUISH.
STORAGE:
STORE IN A WELL-VENTILATED PLACE. KEEP COOL. STORE LOCKED UP. KEEP
CONTAINER TIGHTLY CLOSED.
DISPOSAL:
DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH
LOCAL/REGIONAL/NATIONAL/INTERNATIONAL REGULATIONS.
HAZARD(S) NOT OTHERWISE CLASSIFIED (HNOC):
FREQUENT OR PROLONGED CONTACT MAY DEFAT AND DRY THE SKIN, LEADING TO
DISCOMFORT AND DERMATITIS.
SUPPLEMENTAL INFORMATION: NOT APPLICABLE.
| 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
MIXTURES:
CHEMICAL NAME CAS NUMBER %
METHYL ETHYL KETONE 78-93-3 30-60
ACRYLONITRILE-BUTADIENE-STYRENE COPOLYMERS 9003-56-9 15-40
ACETONE 67-64-1 10-30
*DESIGNATES THAT A SPECIFIC CHEMICAL IDENTITY AND/OR PERCENTAGE OF
COMPOSITION HAS BEEN WITHHELD AS A TRADE SECRET.
| 4. FIRST-AID MEASURES | |
INHALATION:
REMOVE VICTIM TO FRESH AIR AND KEEP AT REST IN A POSITION COMFORTABLE FOR
BREATHING. CALL A POISON CENTER OR DOCTOR/PHYSICIAN IF YOU FEEL UNWELL.
SKIN CONTACT:
TAKE OFF IMMEDIATELY ALL CONTAMINATED CLOTHING. WASH OFF WITH SOAP AND
WATER.
EYE CONTACT:
IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES.
REMOVE CONTACT LENSES, IF PRESENT AND EASY TO DO. CONTINUE RINSING.
IF EYE IRRITATION PERSISTS: GET MEDICAL ADVICE/ATTENTION.
INGESTION:
CALL A PHYSICIAN OR POISON CONTROL CENTER IMMEDIATELY. DO NOT INDUCE
VOMITING. IF VOMITING OCCURS, KEEP HEAD LOW SO THAT STOMACH CONTENT DOESN'T
GET INTO THE LUNGS. ASPIRATION MAY CAUSE PULMONARY EDEMA AND PNEUMONITIS.
MOST IMPORTANT SYMPTOMS/EFFECTS, ACUTE AND DELAYED:
SYMPTOMS MAY INCLUDE STINGING, TEARING, REDNESS, SWELLING, AND BLURRED
VISION. VAPORS HAVE A NARCOTIC EFFECT AND MAY CAUSE HEADACHE, FATIGUE,
DIZZINESS AND NAUSEA.
INDICATION OF IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED:
PROVIDE GENERAL SUPPORTIVE MEASURES AND TREAT SYMPTOMATICALLY. THERMAL
BURNS: FLUSH WITH WATER IMMEDIATELY. WHILE FLUSHING, REMOVE CLOTHES WHICH
DO NOT ADHERE TO AFFECTED AREA. CALL AN AMBULANCE. CONTINUE FLUSHING DURING
TRANSPORT TO HOSPITAL. KEEP VICTIM UNDER OBSERVATION. SYMPTOMS MAY BE
DELAYED.
GENERAL INFORMATION:
TAKE OFF ALL CONTAMINATED CLOTHING IMMEDIATELY. ENSURE THAT MEDICAL
PERSONNEL ARE AWARE OF THE MATERIAL(S) INVOLVED, AND TAKE PRECAUTIONS
TO PROTECT THEMSELVES. WASH CONTAMINATED CLOTHING BEFORE REUSE.
| 5. FIRE-FIGHTING MEASURES | |
SUITABLE EXTINGUISHING MEDIA:
ALCOHOL RESISTANT FOAM. WATER FOG. DRY CHEMICAL POWDER. CARBON DIOXIDE
(CO2).
UNSUITABLE EXTINGUISHING MEDIA:
WATER. DO NOT USE WATER JET AS AN EXTINGUISHER, AS THIS WILL SPREAD THE
FIRE.
SPECIFIC HAZARDS ARISING FROM THE CHEMICAL:
VAPORS MAY FORM EXPLOSIVE MIXTURES WITH AIR. VAPORS MAY TRAVEL CONSIDERABLE
DISTANCE TO A SOURCE OF IGNITION AND FLASH BACK. DURING FIRE, GASES
HAZARDOUS TO HEALTH MAY BE FORMED.
SPECIAL PROTECTIVE EQUIPMENT AND PRECAUTIONS FOR FIREFIGHTERS:
SELF-CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE CLOTHING MUST BE
WORN IN CASE OF FIRE.
FIRE FIGHTING EQUIPMENT/INSTRUCTIONS:
IN CASE OF FIRE AND/OR EXPLOSION DO NOT BREATHE FUMES. MOVE CONTAINERS FROM
FIRE AREA IF YOU CAN DO SO WITHOUT RISK.
SPECIFIC METHODS:
USE STANDARD FIREFIGHTING PROCEDURES AND CONSIDER THE HAZARDS OF OTHER
INVOLVED MATERIALS.
GENERAL FIRE HAZARDS: HIGHLY FLAMMABLE LIQUID AND VAPOR.
| 6. ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
KEEP UNNECESSARY PERSONNEL AWAY. KEEP PEOPLE AWAY FROM AND UPWIND OF
SPILL/LEAK. KEEP OUT OF LOW AREAS. ELIMINATE ALL IGNITION SOURCES (NO
SMOKING, FLARES, SPARKS, OR FLAMES IN IMMEDIATE AREA). WEAR APPROPRIATE
PROTECTIVE EQUIPMENT AND CLOTHING DURING CLEAN-UP. AVOID INHALATION OF
VAPORS OR MISTS. DO NOT TOUCH DAMAGED CONTAINERS OR SPILLED MATERIAL UNLESS
WEARING APPROPRIATE PROTECTIVE CLOTHING. VENTILATE CLOSED SPACES BEFORE
ENTERING THEM. LOCAL AUTHORITIES SHOULD BE ADVISED IF SIGNIFICANT SPILLAGES
CANNOT BE CONTAINED. FOR PERSONAL PROTECTION, SEE SECTION 8 OF THE SDS.
METHODS AND MATERIALS FOR CONTAINMENT AND CLEANING UP:
ELIMINATE ALL IGNITION SOURCES (NO SMOKING, FLARES, SPARKS, OR FLAMES IN
IMMEDIATE AREA). TAKE PRECAUTIONARY MEASURES AGAINST STATIC DISCHARGE. USE
ONLY NON-SPARKING TOOLS. KEEP COMBUSTIBLES (WOOD, PAPER, OIL, ETC.) AWAY
FROM SPILLED MATERIAL.
LARGE SPILLS:
STOP THE FLOW OF MATERIAL, IF THIS IS WITHOUT RISK. DIKE THE SPILLED
MATERIAL, WHERE THIS IS POSSIBLE. COVER WITH PLASTIC SHEET TO PREVENT
SPREADING. USE A NON-COMBUSTIBLE MATERIAL LIKE VERMICULITE, SAND OR EARTH
TO SOAK UP THE PRODUCT AND PLACE INTO A CONTAINER FOR LATER DISPOSAL.
PREVENT ENTRY INTO WATERWAYS, SEWER, BASEMENTS OR CONFINED AREAS. FOLLOWING
PRODUCT RECOVERY, FLUSH AREA WITH WATER.
SMALL SPILLS:
WIPE UP WITH ABSORBENT MATERIAL (E.G. CLOTH, FLEECE). CLEAN SURFACE
THOROUGHLY TO REMOVE RESIDUAL CONTAMINATION.
NEVER RETURN SPILLS TO ORIGINAL CONTAINERS FOR RE-USE. FOR WASTE DISPOSAL,
SEE SECTION 13 OF THE SDS.
ENVIRONMENTAL PRECAUTIONS:
AVOID DISCHARGE INTO DRAINS, WATER COURSES OR ONTO THE GROUND.
| 7. HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING:
VAPORS MAY FORM EXPLOSIVE MIXTURES WITH AIR. DO NOT HANDLE, STORE OR OPEN
NEAR AN OPEN FLAME, SOURCES OF HEAT OR SOURCES OF IGNITION. PROTECT
MATERIAL FROM DIRECT SUNLIGHT. DO NOT SMOKE. TAKE PRECAUTIONARY MEASURES
AGAINST STATIC DISCHARGES. ALL EQUIPMENT USED WHEN HANDLING THE PRODUCT
MUST BE GROUNDED. USE NON-SPARKING TOOLS AND EXPLOSION-PROOF EQUIPMENT.
AVOID BREATHING MIST OR VAPOR. AVOID CONTACT WITH EYES. AVOID PROLONGED
EXPOSURE. PROVIDE ADEQUATE VENTILATION. WEAR APPROPRIATE PERSONAL
PROTECTIVE EQUIPMENT. OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES. WASH HANDS
THOROUGHLY AFTER HANDLING.
CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES:
STORE LOCKED UP. KEEP AWAY FROM HEAT, SPARKS AND OPEN FLAME. PREVENT
ELECTROSTATIC CHARGE BUILD-UP BY USING COMMON BONDING AND GROUNDING
TECHNIQUES. STORE IN ORIGINAL TIGHTLY CLOSED CONTAINER. STORE IN A COOL,
DRY PLACE OUT OF DIRECT SUNLIGHT. STORE IN A WELL-VENTILATED PLACE. STORE
AWAY FROM INCOMPATIBLE MATERIALS (SEE SECTION 10 OF THE SDS). KEEP IN AN
AREA EQUIPPED WITH SPRINKLERS.
| 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
OCCUPATIONAL EXPOSURE LIMITS:
US. OSHA TABLE Z-1 LIMITS FOR AIR CONTAMINANTS (29 CFR 1910.1000):
COMPONENTS TYPE VALUE
ACETONE (CAS 67-64-1) PEL 2400 MG/M3
1000 PPM
METHYL ETHYL KETONE (CAS PEL 590 MG/M3
78-93-3) 200 PPM
US. ACGIH THRESHOLD LIMIT VALUES:
COMPONENTS TYPE VALUE
ACETONE (CAS 67-64-1) STEL 750 PPM
TWA 500 PPM
METHYL ETHYL KETONE (CAS STEL 300 PPM
78-93-3) TWA 200 PPM
US. NIOSH: POCKET GUIDE TO CHEMICAL HAZARDS
COMPONENTS TYPE VALUE
ACETONE (CAS 67-64-1) TWA 590 MG/M3
250 PPM
METHYL ETHYL KETONE (CAS STEL 885 MG/M3
78-93-3) 300 PPM
TWA 590 MG/M3
200 PPM
BIOLOGICAL LIMIT VALUES:
ACGIH BIOLOGICAL EXPOSURE INDICES:
COMPONENTS VALUE DETERMINANT SPECIMEN SAMPLING TIME
ACETONE (CAS 67-64-1) 50 MG/L ACETONE URINE *
METHYL ETHYL KETONE 2 MG/L MEK URINE *
(CAS 78-93-3)
* - FOR SAMPLING DETAILS, PLEASE SEE THE SOURCE DOCUMENT.
APPROPRIATE ENGINEERING CONTROLS:
EXPLOSION-PROOF GENERAL AND LOCAL EXHAUST VENTILATION. GOOD GENERAL
VENTILATION (TYPICALLY 10 AIR CHANGES PER HOUR) SHOULD BE USED. VENTILATION
RATES SHOULD BE MATCHED TO CONDITIONS. IF APPLICABLE, USE PROCESS
ENCLOSURES, LOCAL EXHAUST VENTILATION, OR OTHER ENGINEERING CONTROLS TO
MAINTAIN AIRBORNE LEVELS BELOW RECOMMENDED EXPOSURE LIMITS. IF EXPOSURE
LIMITS HAVE NOT BEEN ESTABLISHED, MAINTAIN AIRBORNE LEVELS TO AN ACCEPTABLE
LEVEL. PROVIDE EYEWASH STATION.
INDIVIDUAL PROTECTION MEASURES, SUCH AS PERSONAL PROTECTIVE EQUIPMENT:
EYE/FACE PROTECTION: WEAR SAFETY GLASSES WITH SIDE SHIELDS (OR GOGGLES).
SKIN PROTECTION:
HAND PROTECTION: WEAR PROTECTIVE GLOVES.
OTHER: WEAR APPROPRIATE CHEMICAL RESISTANT CLOTHING.
RESPIRATORY PROTECTION:
IF ENGINEERING CONTROLS DO NOT MAINTAIN AIRBORNE CONCENTRATIONS BELOW
RECOMMENDED EXPOSURE LIMITS (WHERE APPLICABLE) OR TO AN ACCEPTABLE LEVEL
(IN COUNTRIES WHERE EXPOSURE LIMITS HAVE NOT BEEN ESTABLISHED), AN APPROVED
RESPIRATOR MUST BE WORN.
THERMAL HAZARDS:
WEAR APPROPRIATE THERMAL PROTECTIVE CLOTHING, WHEN NECESSARY.
GENERAL HYGIENE CONSIDERATIONS: WHEN USING, DO NOT EAT, DRINK OR SMOKE.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE: TRANSLUCENT.
PHYSICAL STATE: LIQUID.
FORM: LIQUID.
COLOR: MILKY.
ODOR: SOLVENT.
ODOR THRESHOLD: NOT AVAILABLE.
PH: NOT AVAILABLE.
MELTING POINT/FREEZING POINT: NOT AVAILABLE.
INITIAL BOILING POINT AND BOILING RANGE: 151 DEG. F (66.11 DEG. C)
FLASH POINT: 14.0 - 23.0 DEG. F (-10.0 - -5.0 DEG. C)
EVAPORATION RATE: 5.5 - 8
FLAMMABILITY (SOLID, GAS): NOT AVAILABLE.
UPPER/LOWER FLAMMABILITY OR EXPLOSIVE LIMITS:
FLAMMABILITY LIMIT - LOWER (%): 1.8
FLAMMABILITY LIMIT - UPPER (%): 11.8
EXPLOSIVE LIMIT - LOWER (%): NOT AVAILABLE.
EXPLOSIVE LIMIT - UPPER (%): NOT AVAILABLE.
VAPOR PRESSURE: 145 MM Hg @ 20 C
VAPOR DENSITY: 2.5
RELATIVE DENSITY: 0.87 - 0.91
SOLUBILITY(IES):
SOLUBILITY (WATER): NOT AVAILABLE.
PARTITION COEFFICIENT (N-OCTANOL/WATER): NOT AVAILABLE.
AUTO-IGNITION TEMPERATURE: NOT AVAILABLE.
DECOMPOSITION TEMPERATURE: NOT AVAILABLE.
VISCOSITY: 500 - 1500 CP
OTHER INFORMATION:
DENSITY: 7.40 LB/GAL
VOC (WEIGHT %): <325 G/L SQACMD METHOD 304
| 10. STABILITY AND REACTIVITY | |
REACTIVITY:
THE PRODUCT IS STABLE AND NON-REACTIVE UNDER NORMAL CONDITIONS OF USE,
STORAGE AND TRANSPORT.
CHEMICAL STABILITY: MATERIAL IS STABLE UNDER NORMAL CONDITIONS.
POSSIBILITY OF HAZARDOUS REACTIONS:
NO DANGEROUS REACTION KNOWN UNDER CONDITIONS OF NORMAL USE.
CONDITIONS TO AVOID:
AVOID HEAT, SPARKS, OPEN FLAMES AND OTHER IGNITION SOURCES. AVOID
TEMPERATURES EXCEEDING THE FLASH POINT. CONTACT WITH INCOMPATIBLE
MATERIALS.
INCOMPATIBLE MATERIALS:
ACIDS. STRONG OXIDIZING AGENTS. AMMONIA. AMINES. ISOCYANATES. CAUSTICS.
HAZARDOUS DECOMPOSITION PRODUCTS:
NO HAZARDOUS DECOMPOSITION PRODUCTS ARE KNOWN.
| 11. TOXICOLOGICAL INFORMATION | |
INFORMATION ON LIKELY ROUTES OF EXPOSURE:
INHALATION:
MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS. VAPORS HAVE A NARCOTIC EFFECT
AND MAY CAUSE HEADACHE, FATIGUE, DIZZINESS AND NAUSEA. PROLONGED INHALATION
MAY BE HARMFUL. MAY CAUSE IRRITATION TO THE RESPIRATORY SYSTEM.
SKIN CONTACT: NO ADVERSE EFFECTS DUE TO SKIN CONTACT ARE EXPECTED.
EYE CONTACT: CAUSES SERIOUS EYE IRRITATION.
INGESTION: MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS.
SYMPTOMS RELATED TO THE PHYSICAL, CHEMICAL AND TOXICOLOGICAL
CHARACTERISTICS:
SYMPTOMS MAY INCLUDE STINGING, TEARING, REDNESS, SWELLING, AND BLURRED
VISION. SYMPTOMS OF OVEREXPOSURE MAY BE HEADACHE, DIZZINESS, TIREDNESS,
NAUSEA AND VOMITING.
INFORMATION ON TOXICOLOGICAL EFFECTS:
ACUTE TOXICITY:
MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS. NARCOTIC EFFECTS. MAY CAUSE
RESPIRATORY IRRITATION.
COMPONENTS SPECIES TEST RESULTS
ACETONE (CAS 67-64-1):
ACUTE:
DERMAL:
LD50 RABBIT 20 ML/KG
INHALATION:
LC50 RAT 50 MG/L, 8 HOURS
ORAL:
LD50 RAT 5800 MG/KG
* ESTIMATES FOR PRODUCT MAY BE BASED ON ADDITIONAL COMPONENT DATA NOT
SHOWN.
SKIN CORROSION/IRRITATION:
PROLONGED SKIN CONTACT MAY CAUSE TEMPORARY IRRITATION.
SERIOUS EYE DAMAGE/EYE IRRITATION: CAUSES SERIOUS EYE IRRITATION.
RESPIRATORY OR SKIN SENSITIZATION:
RESPIRATORY SENSITIZATION: NOT AVAILABLE.
SKIN SENSITIZATION:
THIS PRODUCT IS NOT EXPECTED TO CAUSE SKIN SENSITIZATION.
GERM CELL MUTAGENICITY:
NO DATA AVAILABLE TO INDICATE PRODUCT OR ANY COMPONENTS PRESENT AT GREATER
THAN 0.1% ARE MUTAGENIC OR GENOTOXIC.
CARCINOGENICITY:
THIS PRODUCT IS NOT CONSIDERED TO BE A CARCINOGEN BY IARC, ACGIH, NTP, OR
OSHA.
OSHA SPECIFICALLY REGULATED SUBSTANCES (29 CFR 1910.1001-1050): NOT LISTED.
REPRODUCTIVE TOXICITY:
THIS PRODUCT IS NOT EXPECTED TO CAUSE REPRODUCTIVE OR DEVELOPMENTAL
EFFECTS.
SPECIFIC TARGET ORGAN TOXICITY - SINGLE EXPOSURE:
RESPIRATORY TRACT IRRITATION. NARCOTIC EFFECTS.
SPECIFIC TARGET ORGAN TOXICITY - REPEATED EXPOSURE: NOT CLASSIFIED.
ASPIRATION HAZARD: MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS.
CHRONIC EFFECTS: PROLONGED INHALATION MAY BE HARMFUL.
| 12. ECOLOGICAL INFORMATION | |
ECOTOXICITY:
THE PRODUCT IS NOT CLASSIFIED AS ENVIRONMENTALLY HAZARDOUS. HOWEVER, THIS
DOES NOT EXCLUDE THE POSSIBILITY THAT LARGE OR FREQUENT SPILLS CAN HAVE A
HARMFUL OR DAMAGING EFFECT ON THE ENVIRONMENT.
COMPONENTS SPECIES TEST RESULTS
ACETONE (CAS 67-64-1):
AQUATIC:
FISH LC50 FATHEAD MINNOW (PIMEPHALES PROMELAS) >100 MG/L, 96 HOURS
* ESTIMATES FOR PRODUCT MAY BE BASED ON ADDITIONAL COMPONENT DATA NOT
SHOWN.
PERSISTENCE AND DEGRADABILITY:
NO DATA IS AVAILABLE ON THE DEGRADABILITY OF THIS PRODUCT.
BIOACCUMULATIVE POTENTIAL: NO DATA AVAILABLE.
PARTITION COEFFICIENT N-OCTANOL / WATER (LOG KOW):
ACETONE (CAS 67-64-1): -0.24
METHYL ETHYL KETONE (CAS 78-93-3): 0.29
MOBILITY IN SOIL: NO DATA AVAILABLE.
OTHER ADVERSE EFFECTS:
NO OTHER ADVERSE ENVIRONMENTAL EFFECTS (E.G. OZONE DEPLETION, PHOTOCHEMICAL
OZONE CREATION POTENTIAL, ENDOCRINE DISRUPTION, GLOBAL WARMING POTENTIAL)
ARE EXPECTED FROM THIS COMPONENT.
| 13. DISPOSAL CONSIDERATIONS | |
DISPOSAL INSTRUCTIONS:
COLLECT AND RECLAIM OR DISPOSE IN SEALED CONTAINERS AT LICENSED WASTE
DISPOSAL SITE. THIS MATERIAL AND ITS CONTAINER MUST BE DISPOSED OF AS
HAZARDOUS WASTE. DO NOT ALLOW THIS MATERIAL TO DRAIN INTO SEWERS/WATER
SUPPLIES. DO NOT CONTAMINATE PONDS, WATERWAYS OR DITCHES WITH CHEMICAL
OR USED CONTAINER. DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH
LOCAL/REGIONAL/NATIONAL/INTERNATIONAL REGULATIONS.
LOCAL DISPOSAL REGULATIONS:
DISPOSE IN ACCORDANCE WITH ALL APPLICABLE REGULATIONS.
HAZARDOUS WASTE CODE:
THE WASTE CODE SHOULD BE ASSIGNED IN DISCUSSION BETWEEN THE USER, THE
PRODUCER AND THE WASTE DISPOSAL COMPANY.
WASTE FROM RESIDUES / UNUSED PRODUCTS:
DISPOSE OF IN ACCORDANCE WITH LOCAL REGULATIONS. EMPTY CONTAINERS OR LINERS
MAY RETAIN SOME PRODUCT RESIDUES. THIS MATERIAL AND ITS CONTAINER MUST BE
DISPOSED OF IN A SAFE MANNER (SEE: DISPOSAL INSTRUCTIONS).
CONTAMINATED PACKAGING:
EMPTY CONTAINERS SHOULD BE TAKEN TO AN APPROVED WASTE HANDLING SITE FOR
RECYCLING OR DISPOSAL. SINCE EMPTIED CONTAINERS MAY RETAIN PRODUCT RESIDUE,
FOLLOW LABEL WARNINGS EVEN AFTER CONTAINER IS EMPTIED.
| 14. TRANSPORT INFORMATION | |
DOT:
UN NUMBER: UN1133
UN PROPER SHIPPING NAME: ADHESIVES
TRANSPORT HAZARD CLASS(ES):
CLASS: 3
SUBSIDIARY RISK:
LABEL(S): 3
PACKING GROUP: II
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
SPECIAL PROVISIONS: T11, TP1, TP8, TP27
PACKAGING EXCEPTIONS: 150
PACKAGING NON BULK: 201
PACKAGING BULK: 243
IATA:
UN NUMBER: UN1133
UN PROPER SHIPPING NAME: ADHESIVES
TRANSPORT HAZARD CLASS(ES):
CLASS: 3
SUBSIDIARY RISK:
PACKING GROUP: II
ENVIRONMENTAL HAZARDS: NO.
ERG CODE: 3L
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
IMDG:
UN NUMBER: UN1133
UN PROPER SHIPPING NAME: ADHESIVES
TRANSPORT HAZARD CLASS(ES):
CLASS: 3
SUBSIDIARY RISK:
PACKING GROUP: II
ENVIRONMENTAL HAZARDS:
MARINE POLLUTANT: NO.
EMS: F-E, S-D
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
TRANSPORT IN BULK ACCORDING TO ANNEX II OF MARPOL 73/78 AND THE IBC CODE:
NOT AVAILABLE.
| 15. REGULATORY INFORMATION | |
US FEDERAL REGULATIONS:
THIS PRODUCT IS A "HAZARDOUS CHEMICAL" AS DEFINED BY THE OSHA HAZARD
COMMUNICATION STANDARD, 29 CFR 1910.1200.
ALL COMPONENTS ARE ON THE U.S. EPA TSCA INVENTORY LIST.
TSCA SECTION 12(B) EXPORT NOTIFICATION (40 CFR 707, SUBPT. D):
NOT REGULATED.
OSHA SPECIFICALLY REGULATED SUBSTANCES (29 CFR 1910.1001-1050): NOT LISTED.
CERCLA HAZARDOUS SUBSTANCE LIST (40 CFR 302.4):
ACETONE (CAS 67-64-1): LISTED
METHYL ETHYL KETONE (CAS 78-93-3): LISTED
SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 (SARA):
HAZARD CATEGORIES:
IMMEDIATE HAZARD: YES
DELAYED HAZARD: NO
FIRE HAZARD: YES
REACTIVITY HAZARD: NO
PRESSURE HAZARD: NO
SARA 302 EXTREMELY HAZARDOUS SUBSTANCE: NOT LISTED.
SARA 311/312 HAZARDOUS CHEMICAL: NO
SARA 313 (TRI REPORTING): NOT REGULATED.
OTHER FEDERAL REGULATIONS:
CLEAN AIR ACT (CAA) SECTION 112 HAZARDOUS AIR POLLUTANTS (HAPS) LIST:
NOT REGULATED.
CLEAN AIR ACT (CAA) SECTION 112(R) ACCIDENTAL RELEASE PREVENTION (40 CFR
68.130): NOT REGULATED.
SAFE DRINKING WATER ACT (SDWA): NOT REGULATED.
DRUG ENFORCEMENT ADMINISTRATION (DEA). LIST 2, ESSENTIAL CHEMICALS (21 CFR
1310.02(B) AND 1310.04(F)(2) AND CHEMICAL CODE NUMBER:
ACETONE (CAS 67-64-1): 6532
METHYL ETHYL KETONE (CAS 78-93-3): 6714
DRUG ENFORCEMENT ADMINISTRATION (DEA). LIST 1 & 2 EXEMPT CHEMICAL MIXTURES
(21 CFR 1310.12(C)):
ACETONE (CAS 67-64-1): 35%WV
METHYL ETHYL KETONE (CAS 78-93-3): 35%WV
DEA EXEMPT CHEMICAL MIXTURES CODE NUMBER:
ACETONE (CAS 67-64-1): 6532
METHYL ETHYL KETONE (CAS 78-93-3): 6714
US STATE REGULATIONS:
CALIFORNIA SAFE DRINKING WATER AND TOXIC ENFORCEMENT ACT OF 1986
(PROPOSITION 65):
THIS MATERIAL IS NOT KNOWN TO CONTAIN ANY CHEMICALS CURRENTLY LISTED AS
CARCINOGENS OR REPRODUCTIVE TOXINS.
US. MASSACHUSETTS RTK - SUBSTANCE LIST:
ACETONE (CAS 67-64-1)
METHYL ETHYL KETONE (CAS 78-93-3)
US. NEW JERSEY WORKER AND COMMUNITY RIGHT-TO-KNOW ACT:
ACETONE (CAS 67-64-1)
METHYL ETHYL KETONE (CAS 78-93-3)
US. PENNSYLVANIA WORKER AND COMMUNITY RIGHT-TO-KNOW LAW:
ACETONE (CAS 67-64-1)
METHYL ETHYL KETONE (CAS 78-93-3)
US. RHODE ISLAND RTK:
ACETONE (CAS 67-64-1)
METHYL ETHYL KETONE (CAS 78-93-3)
US. CALIFORNIA PROPOSITION 65:
CALIFORNIA SAFE DRINKING WATER AND TOXIC ENFORCEMENT ACT OF 1986
(PROPOSITION 65):
THIS MATERIAL IS NOT KNOWN TO CONTAIN ANY CHEMICALS CURRENTLY LISTED AS
CARCINOGENS OR REPRODUCTIVE TOXINS.
INTERNATIONAL INVENTORIES:
COUNTRY(S) OR REGION INVENTORY NAME ON INVENTORY
(YES/NO)*
AUSTRALIA AUSTRALIAN INVENTORY OF CHEMICAL YES
SUBSTANCES (AICS)
CANADA DOMESTIC SUBSTANCES LIST (DSL) YES
CANADA NON-DOMESTIC SUBSTANCES LIST (NDSL) NO
CHINA INVENTORY OF EXISTING CHEMICAL YES
SUBSTANCES IN CHINA (IECSC)
EUROPE EUROPEAN INVENTORY OF EXISTING NO
COMMERCIAL CHEMICAL SUBSTANCES
(EINECS)
EUROPE EUROPEAN LIST OF NOTIFIED CHEMICAL NO
SUBSTANCES (ELINCS)
JAPAN INVENTORY OF EXISTING AND NEW YES
CHEMICAL SUBSTANCES (ENCS)
KOREA EXISTING CHEMICALS LIST (ECL) YES
NEW ZEALAND NEW ZEALAND INVENTORY YES
PHILIPPINES PHILIPPINE INVENTORY OF CHEMICALS YES
AND CHEMICAL SUBSTANCES (PICCS)
UNITED STATES & TOXIC SUBSTANCES CONTROL ACT (TSCA) YES
PUERTO RICO INVENTORY
*A "YES" INDICATES THIS PRODUCT COMPLIES WITH THE INVENTORY REQUIREMENTS
ADMINISTERED BY THE GOVERNING COUNTRY(S).
A "NO" INDICATES THAT ONE OR MORE COMPONENTS OF THE PRODUCT ARE NOT LISTED
OR EXEMPT FROM LISTING ON THE INVENTORY ADMINISTERED BY THE GOVERNING
COUNTRY(S).
| 16. OTHER INFORMATION, INCLUDING DATE OF PREPARATION | |
OR LAST REVISION
ISSUE DATE: 30-JULY-2014
REVISION DATE: 10-DECEMBER-2014
VERSION #: 02
HMIS(R*) RATINGS:
HEALTH 2
FLAMMABILITY 3
PHYSICAL HAZARD 0
DISCLAIMER:
THE INFORMATION IN THE SHEET WAS WRITTEN BASED ON THE BEST KNOWLEDGE AND
EXPERIENCE CURRENTLY AVAILABLE.
921055
REVISION DATE: 12-1-2017
SDS US